2015 Ford TAURUS POLICE INTERCEPTOR: complaints, problems and recalls

POWER STEERING FAILED. MECHANICAL SHOP ADVISED PROBLEM IS FAULTY STEERING MOTOR SENSOR FAULT. FORD RECALL #15S18. OUR VEHICLE MANUFACTURED 04/2012; VEHICLES COVERED BY RECALL HAVE ENDING MANUFACTURE DATE OF 02/2012.

Look up ODI 11084603 at NHTSA ↗

THE POWER STEERING MAKES NOISE AND IS SLIPPING AT CERTAIN POINTS WHILE THE VEHICLE IS MOVING. IT SEEMS TO BE CONSISTENT WITH CUSTOMER SATISFACTION PROGRAM 17B22, WHICH WAS RECENTLY ISSUED FOR THE POLICE UTILITY VEHICLES OF THIS SAME YEAR, BUT DID NOT INCLUDE THE SEDAN. THIS IS A DANGEROUS PROBLEM, AS POWER STEERING COULD FAIL AT HIGH SPEEDS.

Look up ODI 11021219 at NHTSA ↗

WHILE DRIVING HOME FROM WORK MERGING TO GET ON THE HIGHWAY AS I WAS TURNING THE STEERING WHEEL FROZE UP AND BECAME HARD TO TURN I ALMOST DROVE INTO THE WALL MY CAR ONLY HAS 26 THOUSAND MILES ON IT

Look up ODI 11166546 at NHTSA ↗

ON WEDNESDAY FEBRUARY 08, 2017, I WAS DRIVING ON MY WAY TO WORK. WHEN OUT OF NO WHERE, MY FORD TAURUS POLICE INTERCEPTOR 2013 DIE ON ME. WITH NO WARNINGS THE ENGINE JUST TURNED OFF. JUST AS I WAS APROCHING A LIGHT AT A BUSY INTERCEPTION. I TRIED TO TURN IT UP AGAIN AND IT TURNED ON AND DROVE IT FOR 1/2 A MILE. I DROVE IT INSIDE A PARKING LOT OF AN ADVANCE AUTO PARTS. THEY RUN A DYNASTIC BECAUSE, THE CHECK ENGINE CAME ON. AND THE ONLY CODE THEY FOUND WAS THIS: P0627 - FUEL PUMP CONTROL CIRCUIT OPEN. IT SHUT OFF AGAIN AS I PULL OFF IN THE PARKING…

Look up ODI 10954059 at NHTSA ↗

POWER TRANSFER SEALS LEAKING-(PTU)--COMMON PROBLEM FOR MANY YEARS ON 4WD FORD VEHICLES. SAFETY RELATED AS LEAKING TRANSMISSION AND GEAR OIL LEAK ONTO HOT EXHAUST MAKES SMOKE THAT ENTERS CABIN THRU HVAC SYSTEM. SHOULD BE A CAMPAIGN OR RECALL ACTION!!!!!

Look up ODI 11210760 at NHTSA ↗

STARTED VEHICLE AT HOME, DROVE APPROXIMATELY 45 MILES TO WORK AND PARKED. AFTER EXITING VEHICLE AND WALKING ABOUT 30 FEET, HEARD A LOUD BANG AND SAW THE REAR WINDOW SHATTER. IT WAS 19 F OUTSIDE TEMP. ON REPLACING THE REAR WINDOW, TECHNICIAN DISCOVERED REAR WINDOW DEFROSTER CONNECTOR ON PASSENGER SIDE WAS MELTED AND ON THE PIECE OF GLASS STILL CONNECTED TO THE WIRE, BURNT GLASS. FUSE/RELAY ON THE REAR DEFROSTER CIRCUIT WAS NOT BLOWN.

Look up ODI 10953897 at NHTSA ↗

COMPONENT IN FUEL PUMP ELECTRIC MODULE FAILED AND FUEL PUMP FAILED AND BOTH REPLACED. SALINAS VALLEY FORD DID NOT HONOR RECALL NUMBER 16V621000 OR 15V812000 COVERING THESE EQUIPMENT FAILURES. THEY ARE OR SHOULD BE COVERED BY THE RECALL NOTICES SENT IN 2105 AND 2015. DROVE CAR TO PLACE OF EMPLOYMENT AND IT FAILED TO START AT END OF THE DAY.

Look up ODI 11055581 at NHTSA ↗

OUR DEPARTMENT'S FLEET OF 2013 AND 2015 INTERCEPTORS HAVE EXPERIENCED TEPEATED HEADLIGHT FAILURES. NO RECALL FOUND FOR THIS PROBLEM. PROBLEMS BEGAN AS VEHICLES SURPASSED WARRANTY LIMITS. ONE SERVICED AT THE DEALER AND THE WIRE HARNESS HAD BURNED UP AND NEEDED REPLACED, AS WELL AS THE BCM NEEDED REPROGRAMMING. ONE HOUR INTO USE AFTER SERVICE THE SAME HEADLIGHT FAILED AGAIN. EACH 2013 MODEL HAS HAD HEADLIGHTS REPLACED AT LEAST TWICE AND THE 2015'S ARE INCREASING IN FAILURE RATE. THE SERVICE COST WAS OVER $500. THE ESTIMATED REPROGRAMMING COST WAS…

Look up ODI 11071856 at NHTSA ↗

TL* THE CONTACT DRIVES A 2013 FORD TAURUS POLICE INTERCEPTOR. THE CONTACT STATED THAT THE SEAT BELT STEEL CABLE SNAPPED IN HALF WHEN THE OFFICER TRIED TO SECURE HIMSELF IN THE VEHICLE BEFORE DRIVING. THE CABLE FLEW UP AFTER BEING SNAPPED IN FROM THE BASE OF THE ATTACHMENT TO THE VEHICLE'S FLOOR. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 153,670.

Look up ODI 11162633 at NHTSA ↗

ME AND MY SISTER BOTH OWN 2013 TAURUSES, MINE A INTERCEPTER, HERS A SELF, BY 100000 BOTH TOE LINKS WERE CRACKED AND JOINTS BROKE, REPLACED LINKS ON BOTH CARS. PLUS MY FUEL MODULE WAS UNDER RECALL AND NOT HERS, BUT HERS FAILED AND MINE DID NOT. SHE HAD TO PAY OUT OF POCKET FOR HER MODULE, AND MINE WAS FIXED UNDER RECALL.

Look up ODI 11221091 at NHTSA ↗