2003 Freightliner COLUMBIA: complaints, problems and recalls

THE VEHICLE LOST POWER, AND LOCKED IN THE GEAR IT WAS IN. *JB

Owner-reported narrative. Look up ODI 10011381 at NHTSA ↗

WE RECENTLY PURCHASED A GROUP OF 40 FREIGHTLINER TRACTORS IN OCTOBER 2002. TRACTORS WERE BUILT WITH AN H7 LOW BEAM HEADLAMP ASSEMBLY. WE HAVE SINCE HAD MULTIPLE FAILURES OF THIS STYLE HEADLAMP AND HAVE HAD SEVERAL OCCASIONS WHEN BOTH HEADLAMPS BURNED OUT AT THE SAME TIME WHILE DRIVER WAS OPERATIONG VEHICLE IN DARKNESS. ALL DATA ON THIS LAMP THAT I CAN FIND, SHOWS A SERVICE LIFE IN THE 200 HOUR RANGE. MOST STANDARD HEADLAMPS ARE RATED FOR 1000+ HOURS. MOST USA APPLICATIONS FOR THIS H7 BULB ARE FOR THE FOG LAMP POSITION, NOT LOW BEAM HEADLIG…

Owner-reported narrative. 42,136 miles reported. Look up ODI 10028725 at NHTSA ↗

CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITH NO WARNING VEHICLE WILL SHUT OFF, CAUSING CONSUMER TO PULL OVER. IT WILL BE HARD TO GET THE VEHICLE BACK STARTED.DEALER NOTIFIED.*AK

Owner-reported narrative. Look up ODI 10033748 at NHTSA ↗

FUMES COMING INTO CAB, 2003,FREIGHTLINER,COLUMBIA,RELATED EGR VALVE LEAKING ENTS FROM DASH. *AK

Owner-reported narrative. 30,000 miles reported. Look up ODI 10043867 at NHTSA ↗

WHILE DRIVING THE TRUCK, THE CONSUMER WOULD SMELL A ROTTEN EGG ODOR COMING FROM THE VENTILATION SYSTEM. THE OWNER HAS MADE CONTACT WITH THE DEALERSHIP ON FIVE SEPARATE OCCASIONS AND THE PROBLEM STILL OCCURS. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *PH

Owner-reported narrative. Look up ODI 10047752 at NHTSA ↗

DT: FUMES COMING INSIDE EQUIPMENT THROUGH AIR VENTS OF TRUCK. THE TRUCK WAS TAKEN TO THE DEALER 3-4 DIFFERENT TIMES AND THE PROBLEM WAS NEVER FIXED. THESE FUMES CAUSED HEADACHES, NAUSEA,BURNING EYES, AND HIGH BLOOD PRESSURE. NOW, DIAGNOSED WITH COPD. HAVE TALKED TO OTHER DRIVERS AND SAME PROBLEMS HAVE OCCURRED.*AK THE VEHICLE WAS PARKED BECAUSE THE CONSUMER FELT IT WAS UNSAFE TO DRIVE. *NM

Owner-reported narrative. Look up ODI 10120286 at NHTSA ↗

WHILE DRIVING CAN SMELL EXHAUST FUMES FUMES COMING INTO CAB THROUGH AIR VENTS,WIFE GETTING ILL AN BURNING EYES, HARD TO BREATH,HEADACHES,TIRED ALL THE TIME, ALSO OTHER DRIVER GETTING ILL, ONLY BEEN IN THIS FREIGHTLINER 2 MONTHS, WITH DETROIT. AFTER 10 TO 12 HRS OF SLEEPING, IT ONLY TAKES ABOUT 4 HRS BEHIND THE WHEEL START GETTING TIRED AGAIN, SOMETHINGS NOT RIGHT, THIS ISN'T SAFE, HOW COME DRIVERS AREN'T BEING TOLD ABOUT THIS. *NM

Owner-reported narrative. 633,461 miles reported. Look up ODI 10172048 at NHTSA ↗

THERE ARE NO HAND HOLDS ON THE DRIVER'S SIDE EXTERIOR OR INTERIOR TO AID IN ENTERING OR EXITING THE TRUCK. I WAS INJURED BECAUSE OF THIS FAILURE TO PROVIDE HANDHOLDS WHEN I SLIPPED OF THE TOP STEP WHILE ATTEMPTING TO EXIT THE VEHICLE. I HAVE UNDER GONE SURGERY ON MY LEFT KNEE FROM WHICH I HAVE NOT RECOVERED, AND WILL IN THE NEAR FUTURE UNDERGO SURGERY ON MY RIGHT ELBOW AS A RESULT OF THIS FAILURE TO PROVIDE A SAFE WAY TO ENTER OR EXIT THE TRUCK. THERE ARE NO FMCSA REGULATIONS IN REGARDS TO THIS. *TR

Owner-reported narrative. Look up ODI 10209257 at NHTSA ↗

Reported: 2003-12-04 (December 4, 2003)

ON CERTAIN TRUCKS EQUIPPED WITH AIR BRAKES, THE PLASTIC PUSH-TO-CONNECT AIR LINE FITTING CARTRIDGE COULD BE IMPROPERLY WELDED INTO THE NYLON JUNCTION BLOCK HOUSING ALLOWING AN AIR LINE TO BECOME DISCONNECTED.

Consequence: THIS COULD LEAD TO REDUCED BRAKE CONTROL, LOSS OF SERVICE BRAKE CONTROL, OR THE EMERGENCY BRAKES AUTOMATICALLY APPLYING, POSSIBLY RESULTING IN A CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL INSTALL A NEW CAB AIR MANIFOLD. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON JANUARY 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 800-547-0712.

Reported: 2004-05-04 (May 4, 2004)

ON CERTAIN TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, THE TAPERED JOINT THAT ATTACHES THE SHIFTER TO THE TRANSMISSION MAY BECOME LOOSE MAKING IT DIFFICULT TO PUT THE TRANSMISSION INTO GEAR.

Consequence: IF SHIFT LEVER DETACHMENT OCCURS, THA ABILITY RO ACCELERATE OT MAINTAIN SPEED WILL BE LOST, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL RE-SECURE THE SHIFT LEVER TO THE TRANSMISSION USING THREADLOCK AND RE-TORQUING THE FASTENING BOLT. OWNER NOTIFICATION BEGAN ON MAY 21, 2004. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2005-01-03 (January 3, 2005)

ON CERTAIN TRUCKS EQUIPPED WITH SEATS BUILT BY GRA-MAG, THE SEAT PIVOT BOLTS CAN LOOSEN AND POSSIBLY FRACTURE OR DISLODGE, CAUSING THE SEAT BACK TO FAIL TO PROVIDE FULL SUPPORT TO THE DRIVER'S BACK.

Consequence: A POSSIBLE VEHICLE CRASH COULD OCCUR SHOULD THE SEAT FALL BACKWARDS DURING USE.

Remedy: DEALERS WILL REPAIR THESE VEHICLES. THE RECALL BEGAN ON APRIL 20, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2007-07-16 (July 16, 2007)

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.

Consequence: THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.

Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2017-12-15 (December 15, 2017)

Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: DTNA will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on April 11, 2018. Owners may contact DTNA customer service at 1-800-547-0712, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.