1997 Freightliner FS-65: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
0 owner complaints analyzed
3 distinct recall campaigns
Not available median reported failure mileage
Scope: 1997 model year. Data updated: . 0 complaints include usable failure mileage. View data status.
Most common problems
No owner complaints are recorded for this selection. A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
No usable records for this chart.
| Category | Count |
|---|
No records.
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 0 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
No usable records for this chart.
| Category | Count |
|---|
No records.
Pattern summary
There is not enough complaint evidence to summarize patterns.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Recall history
3 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
00V232002 · Service Brakes, Air:Antilock
Reported: 2000-08-07 (August 7, 2000)
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
Consequence: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
Remedy: DEALERS WILL REPLACE THE ABS ECU.
NHTSA campaign record ↗02V248000 · Vehicle Speed Control
Reported: 2002-09-16 (September 16, 2002)
ON CERTAIN SCHOOL BUS CHASSIS WITH CUMMINS ISB ENGINES WITH MECHANICAL THROTTLE, THE THROTTLE CABLE CAN VIBRATE EXCESSIVELY AND BREAK NEAR THE END FITTING THAT ATTACHES TO THE ENGINE LINKAGE.
Consequence: THIS CAN RESULT IN A LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REMOVE AND REPLACE THE THROTTLE CABLE WITH A NEW DESIGN. OWNER NOTIFICATION BEGAN ON FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
NHTSA campaign record ↗04V343000 · Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings
Reported: 2004-07-12 (July 12, 2004)
ON CERTAIN SCHOOL BUSES CHASSIS EQUIPPED WITH CATERPILLAR ENGINES AND HYDRAULIC BRAKES. A BRAIDED GROUND STRAP FOR THE STARTER MAY RUB ON A STEEL CHASSIS BRAKE LINE POTENTIALLY CAUSING A FLUID LEAK.
Consequence: A BRAKE FLUID LEAK CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE THE STOPPING DISTANCE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE AND REPLACE IT, IF NECESSARY. THE BRAIDED GROUND STRAP WILL BE REPLACED WITH AN INSULATED CABLE. THE RECALL BEGAN ON AUGUST 10, 2004. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
0 unique complaints in this selection. Analysis snapshot: 2026-09-30.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 1996 | 1997 | 1998 | 1999 | 2000 | 2001 | 2002 | 2005 | 2006 |
|---|---|---|---|---|---|---|---|---|---|
| Fuel System, Diesel | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 150.0%ODI 10189571 · 84,000 miTL*THE CONTACT OWNS A 1999 FREIGHTLINER FS-65. THE CURRENT MILEAGE WAS 84000. WHEN HE ATTEMPTED TO START THE VEHICLE IT WOULD NOT START. ALSO, THE CONTACT STATED THAT PREVIOUSLY THE VEHICLE WOULD SHUT OFF WITHOUT WARNING AND HE WAS UNABLE TO TO RESTART. THE MECHANIC STATED THAT THE TRANSFER PUMP AND/OR THE INJECTION PUMP SHOULD BE REPLACED. THE REPAIR WAS MADE. HOWEVER, THE PROBLEM CONTINUED TO OCCUR. THE CONTACT OWNED A FLEET OF EIGHTEEN VEHICLES THAT HAD THE SAME PROBLEM. THE VIN WAS AVAILABLE FOR ONLY ONE OF THE VEHICLES. ON ALL OF … | 12100.0%ODI 10130448DT: THE CONTACT OWNED A 2000 AND 2001 FREIGHTLINERS. CONTACT WAS UNABLE TO GET THE RECALL REPAIR WORK ON FUEL SYSTEM DONE BECAUSE THE MANUFACTURER WILL NOT PAY THE DEALERSHIP ENOUGH TO DO THE REPAIR WORK. HAD 20 OF THESE VEHICLES, 2000-2001 YEAR MODELS. COULD DO DO THE REPAIRS THEMSELVES, BUT THEY COULD NOT DO FAST ENOUGH FOR THE VEHICLES TO BE DONE BEFORE SCHOOL STARTED. THE DEALER WILL NOT LET ANY OTHER PERSON HELP HIM TO GET THE REPAIR WORK DONE. THE COMPANY WASCOMMUNITY BUS SERVICES. *AK | 866.7%ODI 10130469DT:EDTHE CONTACT OWNS A 2000 FREIGHTLINER. CONTACT WAS UNABLE TO GET RECALL REPAIR WORK WORK ON FUEL SYSTEM DONE BECAUSE THE MANUFACTUREE WILL NOT PAY THE DEALERSHIP ENOUGH TO DO THE REPAIR WORK. HAD 20 OF THESE VEHICLES, 2000-2001 YEAR MODELS. COULD DO THE REPAIRS THEMSELVES, BUT THEY COULD NOT DO FAST ENOUGH FOR THE VEHICLES TO BE DONE BEFORE SCHOOL STARTED. THE DEALER WILL NOT LET ANY OF OTHER PERSON HELP HIM TO GET THE REPAIR WORK DONE. THE COMPANY WAS COMMUNITY BUS SERVICES.*AK | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Structure:Frame And Members | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 150.0%ODI 10137854 · 97,777 miBROKEN FRAME ON 1999 FREIGHTLINER SCHOOL BUS/THOMAS BODY OVER RIGHT REAR AIR RIDE AT TORSION BAR MOUNT. VEHICLE IS CURRENTLY UNDERGOING FRAME REPLACEMENT AT BODY SHOP. *NM | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 360.0%ODI 10476806 · 129,210 miTL* THE CONTACT OWNS A 2002 FREIGHT-LINER FS65 SCHOOL BUS. THE CONTACT STATED THAT AFTER HAVING ROUTING MAINTENANCE DONE ON THE VEHICLE, HE WAS NOTIFIED THAT THE CROSS MEMBER FRAME HAD DEVELOPED A CRACK. THE MANUFACTURER WAS NOTIFIED WHO STATED THAT THEY WOULD REIMBURSE FOR THE PARTS BUT NOT FOR THE LABOR. THE VEHICLE WAS NOT REPAIR. THE FAILURE MILEAGE WAS 129,210. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 325.0%ODI 10049737 · 56,581 miSTARTER GROUND STRAP RUBBED HOLE IN STEEL BRAKE LINE LOCATED NEAR THE STARTER. THIS CAUSED A LOSS OF BRAKE FLUID AND BRAKE PRESSURE. *AK | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Electrical System:Starter Assembly | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 216.7%ODI 10049737 · 56,581 miSTARTER GROUND STRAP RUBBED HOLE IN STEEL BRAKE LINE LOCATED NEAR THE STARTER. THIS CAUSED A LOSS OF BRAKE FLUID AND BRAKE PRESSURE. *AK | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Electrical System | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 1100.0%ODI 10449091 · 188,497 miNORTH CAROLINA PUBLIC SCHOOL BUS LOCATED IN MECKLENBURG COUNTY WAS IN ROUTE WITH SIX CHILDREN AND A DRIVER WHEN THE DRIVER SMELLED SMOKE AND SAW THE SMOKE COMING FROM THE AREA BELOW THE STEERING COLUMN. THE DRIVER STOPPED THE BUS IN A SAFE AREA AND IMMEDIATELY STARTED EVACUATION PROCEDURES AND SUCCESSFULLY UNLOADED THE CHILDREN TO A SAFE PLACE. WITHIN APPROXIMATELY 5 TO 7 MINUTES AFTER EVACUATION FIRE WAS SEEN IN THE PASSENGER COMPARTMENT AND PROCEEDED TO SPREAD THROUGH OUT THE INSTRUMENT PANEL AREA AND THEN TO THE REAR OF THE BUS BODY. THE BUS… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Engine And Engine Cooling:Engine:Diesel | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 1100.0%ODI 10449091 · 188,497 miNORTH CAROLINA PUBLIC SCHOOL BUS LOCATED IN MECKLENBURG COUNTY WAS IN ROUTE WITH SIX CHILDREN AND A DRIVER WHEN THE DRIVER SMELLED SMOKE AND SAW THE SMOKE COMING FROM THE AREA BELOW THE STEERING COLUMN. THE DRIVER STOPPED THE BUS IN A SAFE AREA AND IMMEDIATELY STARTED EVACUATION PROCEDURES AND SUCCESSFULLY UNLOADED THE CHILDREN TO A SAFE PLACE. WITHIN APPROXIMATELY 5 TO 7 MINUTES AFTER EVACUATION FIRE WAS SEEN IN THE PASSENGER COMPARTMENT AND PROCEEDED TO SPREAD THROUGH OUT THE INSTRUMENT PANEL AREA AND THEN TO THE REAR OF THE BUS BODY. THE BUS… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Fuel System, Other:Fuel Injection System | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10105924 · 55,028 miROSEAU SCHOOL DISTRICT OPERATES A FLEET OF 26 BUSES COVERING APPROX. 1000 SQUARE MILES IN AREA. IN 1999 ROSEAU SCHOOLS BEGAN PURCHASING BUSES WITH THE CUMMINS ISB ENGINES (AN ALL ELECTRONIC ENGINE REPLACING THE OLDER "B" ENGINES). THE DISTRICT NOW HAS 8 UNITS WITH THIS PARTICULAR ENGINE. THE DISTRICT HAS BEEN EXPERIENCING TOO MANY PROBLEMS WITH SENSORS, CHECK ENGINE LIGHTS COMING ON AND POWER DERATING WHEN OPERATING THESE ENGINES. A COMMON PROBLEM IS LIFT PUMP FAILURE CAUSING RETOACTIVE FAILURE TO THE INJECTION PUMP (CUMMINS NAME FOR THE IN… | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Seats | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 1100.0%ODI 10778337 · 140,000 miSYNTECH SEAT BACKS ARE MADE TOO THIN. 23 OUT OF 26 OF THE SEATS ON THIS SCHOOL BUS ARE BROKEN. THESE SEAT BACKS ARE SPOT WELDED TO A TUBULAR FRAME AND THE THIN SHEET METAL SEAT BACK CRACKS AND SEPARATES FROM THE FRAME. IN THE STATE OF MICHIGAN THE STATE SCHOOL BUS INSPECTOR WILL RED TAG THIS BUS BECAUSE OF THIS DEFECT. | 0UnavailableNo examples available for this selection. |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| No usable records for this analysis. | ||||
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-10 | 0 | None | No examples available for this selection. |
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2005: 0 complaints · 2006: 0 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2005 | 0 | 0 | 0 |
| 2006 | 0 | 0 | 0 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2005 | 1 | 0 | 0 |
| 2006 | 0 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component |
|---|
| No usable records for this analysis. |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.