| Service Brakes | 0UnavailableNo examples available for this selection. | 1100.0%ODI 10946448 · 4,000 miGREASE SEALS ON INNER HUB AND CAP ON OUTER HUB LEAKED GREASE INTO BRAKE SYSTEM AND CONTAMINATED THE BRAKES. COULD BE THE GREASE WAS TOO THIN, OVER PACKED OR GREASE SEALS DEFECTIVE. I HAVE CLEANED AND RESEALED MY BRAKES TWICE. LIPPERT WHO SUPPLIES THE AXLE AND BRAKE ASSEMBLIES TO GRAND DESIGN SENT ME NEW GREASE SEALS ONCE BUT DID NOT AGREE TO PAY FOR MY TIME AND OTHER SUPPLIES. I WAS ABLE TO CATCH IT QUICK ENOUGH THAT THE BRAKE SHOES HAD NOT BEEN CONTAMINATED YET. WHEN THIS PROBLEM OCCURS THERE IS NO BRAKING ACTION ON THE TRAILER DUE TO THE … Look up ODI 10946448 at NHTSA ↗ | 1062.5%ODI 10733047 · 2,500 miLIPPERT BRAKE SHOES AND MAGNETS CONTAMINATED WITH GREASE. GREASE SEAL BLEW OUT WITH EXCESSIVE GREASE AND/OR FAULTY SEALS. STOPPING ABILITY OF VEHICLE EXTREMELY IMPACTED AND DANGEROUS Look up ODI 10733047 at NHTSA ↗ | 1473.7%ODI 10726616 · 400 miTL* THE CONTACT OWNS A 2016 GRAND DESIGN REFLECTION 337. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKES HESITATED TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE AXLE GREASE SEAL FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 400. Look up ODI 10726616 at NHTSA ↗ | 1872.0%ODI 10920095 · 3,420 miGREASE LEAKING FROM AXLE SEALS WITH EXTENSIVE CONTAMINATION OF BRAKES ON 2 OUT OF 4 WHEELS. A 3RD WHEEL IS JUST STARTING TO SHOW SIGNS OF GREASE LEAKING PAST SEAL WITH ONLY THE START OF CONTAMINATION OF BRAKE PAD. LIPPERT AXLE AND BRAKE ASSEMBLIES. APPROXIMATELY 3,420 MILES SINCE MANUFACTURE OF TRAILER IN JUNE 2016. SAFETY CONCERN IS LOSS OF BRAKING ABILITY ON A TRAILER WITH A GVWR OF 11,995 LBS. CONTAMINATION NOTED ON OCTOBER 30, 2016 WHEN OWNER PERFORMED INSPECTION OF AXLE AND BRAKE ASSEMBLIES AFTER LEARNING OF NUMEROUS OTHER OWNERS WITH… Look up ODI 10920095 at NHTSA ↗ | 327.3%ODI 10994259 · 60 miGREASE LEAKING FROM AXLE SEAL ONTO BRAKE DRUMS ON ALL FOUR WHEELS CAUSING INEFFECTIVE BRAKES. LIPPERT AXLES Look up ODI 10994259 at NHTSA ↗ | 111.1%ODI 11327697 · 1,500 miTL* THE CONTACT OWNS A 2019 GRAND DESIGN REFLECTION TRAILER EQUIPPED WITH SELF ADJUSTING BRAKES. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH SMOKE WAS PRESENT COMING FROM THE FRONT DRIVER SIDE AXLE. UPON INSPECTION IT WAS DISCOVERED THAT THE BRAKES WERE VERY HOT AND SMOKING. THE TRAILER WAS TAKEN TO THE LOCAL DEALER BRETZ RV & MARINE (2999 OLD HARDIN RD BILLING, MT 59101) THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT YET NOTIFIED. THE FAILURE MILEAGE WAS 1,500. *BF CONSUMER STATED AXLE COMPANY PAID TO FIX… Look up ODI 11327697 at NHTSA ↗ | 00.0%No examples available for this selection. | 313.0%ODI 11419770The electric brakes on our brand new 2021 Grand Design Reflection 303RLS periodically go out. We get a warning through the brake controller that the trailer is disconnected or to "check trailer brake wiring." The warning will go away and the electric brakes will work again, only to have the problem return with the complete loss of trailer brakes. This problem occurred on our very first outing with the new 5th wheel trailer. We have contacted Grand Design customer service through telephone and email, but have received no response. We have s… Look up ODI 11419770 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 114.3%ODI 11649902Trailer is equipped with the Lippert ABS brake system. During final review of issues covered by warranty at the Dealer (General RV in Birch Run MI) the dealer recommended a wheel bearing re grease which I agreed to. During this procedure the left rear brakes were noted as totally worn out and the brake drum had a significant crack due to excessive heat from the dragging brake. This trailer has approx. 8000 mi of towing. As of now root cause has not been determined but if I had not opted for the wheel bearing grease service the problem would n… Look up ODI 11649902 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Unknown Or Other | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 212.5%ODI 10761146THE 5TH WHEEL WAS 2 1/2 MONTHS OLD. AFTER RETURNING FROM A 250 MILE TRIP WE ATTEMPTED TO OPEN THE BEDROOM SLIDE AND IT WOULDN'T OPEN. I PLUGGED IN THE ELECTRICAL PLUG AND OPENED THE SLIDE IN ORDER TO UNLOAD THE REMAINING CLOTHES, THEN I CLOSED THE SLIDE. THIS WAS AT APPROXIMATELY 8:00PM. AT 10:45PM MY GIRLFRIEND HEARD THREE LOUD EXPLOSIONS AND WE RAN OUTSIDE TO FIND THE 5TH WHEEL TOTALLY ENGULFED IN FLAMES. I BELIEVE NOW THE EXPLOSIONS WERE THE TIRES ON THE 5TH WHEEL. THE FRAMES (BOTH OF THEM) THAT RUN THE LENGTH OF THE 5TH WHEEL WERE BENT… Look up ODI 10761146 at NHTSA ↗ | 210.5%ODI 10895532 · 3,500 miWHILE ROLLING DOWN THE HIGHWAY ALL FOUR OF THE WHEEL HUB SEALS LEAKED GREASE ALLOWING GREASE TO ESCAPE AND CONTAMINATE THE BREAKS DUE TO OVER FILLING AND POOR VISCOSITY GREASE. THIS ACCRUED OVER A PERIOD OF TIME TOWING THE TRAILER, THE ATTACHED PICTURE IS OF ONE OF THE HUBS ALL WERE THE SAME. Look up ODI 10895532 at NHTSA ↗ | 28.0%ODI 10957990 · 1,200 miWE WERE ON A TRIP FROM CALIFORNIA TO TEXAS AND THE GREASE SEALS ON ALL 4 WHEELS FAILED AND CONTAMINATED THE BRAKES. I HAVE OWNED THE VEHICLE FOR 1 MONTH AND IT HAD LESS THAN 1,200 MILES ON IT. Look up ODI 10957990 at NHTSA ↗ | 00.0%No examples available for this selection. | 111.1%ODI 11322178 · 12 miOUR 2019 GRAND DESIGN REFLECTION 290BH HAS A TURNING POINT HITCH. THE TURNING POINT HITCH IS DESIGNED SO THAT YOU CAN TOW THE 5TH WHEEL BEHIND A SHORT BED TRUCK WITHOUT A SLIDER HITCH. WHILE TOWING OUR TRAILER AT ABOUT 50 MPH AND APPROACHING A CURVE THE UNIVERSAL WEDGE CAME LOOSE IN OUR HITCH WHICH MADE THE HITCH TURN AT BOTH POINTS. THIS CAUSED OUR TRAILER TO HIT OUR HIT OUR TRUCK. LUCKILY WE TOW THIS 1/2 TON RATED TRAILER WITH A 1 TON TRUCK AND WE WERE ABLE TO WITHSTAND THE IMPACT OF THE HIT. WE WERE NOT THROWN OFF THE ROAD AND WE WERE ABLE… Look up ODI 11322178 at NHTSA ↗ | 120.0%ODI 11427214Wanted to inform NHTSA that our 5th Wheel Camper interior wall separated from it's self which can cause slide issues in the camper. This in my opinion is a safety hazard as this is the structure of the camper and can separate at anytime which could cause slide issues while traveling on the road if there was too much weight for the frame. These camper's have two large slides on one side. The concern is too much weight causing structure issues which could break traveling down the road if it were to break loose. Look up ODI 11427214 at NHTSA ↗ | 834.8%ODI 11624115Cracks in the frame of RV above the spring-shackle hangers. Did have them repaired, but it should not have happined Look up ODI 11624115 at NHTSA ↗ | 1555.6%ODI 11588787From the uploaded documents - Job#s 5,6,7 are the most serious, with #6 being the most likely to cause injury to the occupants of the tow vehicle and the motoring public. The dates are when we had to take it in to the dealer. Purchased the RV [XXX] and took it to FL for full time residency. Conferred with dealer throughout the winter and arranged to bring it in [XXX], 2023. On our way from FL, the kitchen slide would not close all the way and we had to drive with it that way. Uploaded documents show the explanation from the service tech at deal… Look up ODI 11588787 at NHTSA ↗ | 125.0%ODI 11630383Possible frame flex on 5th wheel, had nose cap replaced in June and was told nothing else was wrong, then why did my nose cap crack. Just want it on record with all the issues with GD trailer failures.. Look up ODI 11630383 at NHTSA ↗ | 114.3%ODI 11587981The entire rear section/walls of the camper have lifted and separated from the main frame. A licensed RV specialist has inspected the unit, and determined the main frame has severe issues and the unit should not be used or moved. There were several warning signs brought to the attention of Grand Design but they dismissed it as being within 'tolerance'. I'm a licensed contractor of 39 years and proved to them there is a major issue, but even their own service response technician dismissed it as being in 'tolerance'. Now it has turned into a cata… Look up ODI 11587981 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Suspension | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 318.8%ODI 10747286 · 2,500 miVIN STICKER ON SIDE OF FIFTH WHEEL TRAILER STATES "6000 LB AXLES" BUT TRAILER HAD UNDERSIZED AXLES RATED AT 5200 LB AXLES! GRAND DESIGN RV OWNERS PLEASE CHECK YOU AXLES BEFORE SOMEONE GETS HURT! Look up ODI 10747286 at NHTSA ↗ | 210.5%ODI 10923825 · 200 miALL FOUR AXLE SEALS WERE LEAKING ON THE TRAILER. THE LEAKING GREASE WAS SPRAYED ON THE WHEELS AND ALSO TWO HAD COATED THE BRAKES. THIS APPEARED AFTER I HAD TOWED THE TRAILER FOR 200 MILES AFTER TAKING IT NEW OFF OF THE DEALER LOT. Look up ODI 10923825 at NHTSA ↗ | 520.0%ODI 10920095 · 3,420 miGREASE LEAKING FROM AXLE SEALS WITH EXTENSIVE CONTAMINATION OF BRAKES ON 2 OUT OF 4 WHEELS. A 3RD WHEEL IS JUST STARTING TO SHOW SIGNS OF GREASE LEAKING PAST SEAL WITH ONLY THE START OF CONTAMINATION OF BRAKE PAD. LIPPERT AXLE AND BRAKE ASSEMBLIES. APPROXIMATELY 3,420 MILES SINCE MANUFACTURE OF TRAILER IN JUNE 2016. SAFETY CONCERN IS LOSS OF BRAKING ABILITY ON A TRAILER WITH A GVWR OF 11,995 LBS. CONTAMINATION NOTED ON OCTOBER 30, 2016 WHEN OWNER PERFORMED INSPECTION OF AXLE AND BRAKE ASSEMBLIES AFTER LEARNING OF NUMEROUS OTHER OWNERS WITH… Look up ODI 10920095 at NHTSA ↗ | 545.5%ODI 11121239 · 11,500 miGRAND DESIGN REFLECTION OPTIONS ASSEMBLED AT MANUFACTURER OR DEALER ARE NOT INCLUDED ARE NOT INCLUDED IN 9556# UVW OR SUBTRACTED FROM CCC LABEL OF 1379# AS REQUIRED BY AMENDED FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NOS. 110 AND 120 TO ADDRESS THE PROBLEM OF MOTOR HOME AND RECREATION VEHICLE TRAILER OVERLOADING. THE FINAL RULE TOOK EFFECT ON JUNE 2, 2008. IF OPTIONS INSTALLED BY MANUFACTURER OR DEALER AT TIME OF SALE WHEN OPTIONS EXCEED 165# WHICH IS 1.5% OF 10,995 LBS GVWR THE CCC TAG NEEDS TO BE MODIFIED OR REPLACED. MANUFACTURER SH… Look up ODI 11121239 at NHTSA ↗ | 222.2%ODI 11217271 · 1,300 miPULLING IN FOR GAS AT GAS STATION HIT THE CURB MAYBE 2 MILES AN HOUR WITH LEFT FRONT TIRE BENT FRONT TIRE ON LEFT BENT HANGER ON LEFT AND BENT HANGER ON RIGHT CAUSING TIRE TO POP AND OVER 3000 DOLLARS OF DAMAGE TO SUSPENSION. HAD ABOUT 1300 MILES ON TRAILER WAS FIRST TRIP OUT Look up ODI 11217271 at NHTSA ↗ | 240.0%ODI 11474668The right rear spring hanger broke away from frame while driving through a construction area with little to no room to maneuver. Look up ODI 11474668 at NHTSA ↗ | 417.4%ODI 11451734While parked in an RV park I discovered that the right rear spring hanger on my fifth wheel RV had fractured and separated immediately adjacent to a weld line. I am unaware of any incident that can explain this damage, although I did hear a clunk while auto leveling the vehicle at our campsite. (Auto leveling is computer controlled and is a routine operation.) Inspection of the intact left rear spring hanger reveals what appears to be a small crack that may be the beginning of a similar problem on that side. An undetected failed spring hang… Look up ODI 11451734 at NHTSA ↗ | 27.4%ODI 11628876While returning from a recent camping trip my wife while following the trailer home noticed the house structure was swaying and bouncing too much. She had thought the rig would fall apart. We arrived home and notice that the slide was out 2-4 inches, the cabin door had opened, an interior wall had separated from exterior wall and a side wall had flexed 2 or more inches out by another slide. There was bends and creases in the exterior metal side skirting that needed to be secured for travel. on approximately 11/04 we turned in the rig for repa… Look up ODI 11628876 at NHTSA ↗ | 125.0%ODI 11558983 · 200 miThe contact owns a 2023 Grand Design Reflection RV. The contact stated that the RV was designed with an electric leveling system. The contact stated the two rear levelers failed to elevate beyond 4.5 inches from the ground. The contact stated that the levelers would strike the ground while driving over a speed bump or on a bumpy road surface. The contact stated that the issue was a safety concern because it could cause damage to the RV while driving. The dealer was notified of the failure and referred the contact to the manufacturer for assista… Look up ODI 11558983 at NHTSA ↗ | 228.6%ODI 11587162Took delivery of this new 2024 on [XXX], 2024. There has been a know problem with the rear stabilizing jacks being installed too long. Lippert is the manufacture of the jacks and their specifications require that the rear jacks be at least 7" from the ground in travel mode. Mine measure 3-5" from the ground when attached to the truck and level. This creates a a dangerous issue if a jack strikes the ground during travel and comes loose. It was conveyed to me that Grand Design made changes to this by installing a shorter rear jack system begi… Look up ODI 11587162 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Structure | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 19.1%ODI 11709891The contact owns a 2018 Grand Design Recreational Reflection RV. The contact stated that there were structural cracks and frame separation on the RV, causing the rear interior walls to separate from the floor of the RV. The cause of the failure was not yet determined. The contact was informed of a Customer Satisfaction Campaign related to the failure. The vehicle was not yet repaired. The manufacturer and local dealer were not yet notified of the failure. The failure mileage was unknown. Look up ODI 11709891 at NHTSA ↗ | 222.2%ODI 11548368 · 30,000 miThe contact owns a 2019 Grand Design Reflection RV. The contact stated that while driving approximately 30 MPH, the RV drove over a slight ditch in the road and a loud clunking noise was heard. After stopping to inspect the RV, the contact discovered that the front frame of the RV had failed and was bent due to metal fatigue. The RV was taken to the local welder who re-welded the front frame, and the RV was repaired. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mile… Look up ODI 11548368 at NHTSA ↗ | 120.0%ODI 11578070The contact owns a 2020 Grand Design Reflection RV. The contact stated that the rear leveling jacks of the trailer were significantly close to the ground while in the retracted position. The contact stated while driving 10-15 MPH downhill, he noticed that the rear leveling jacks were touching the ground. The contact stated that he was concerned because the failure could cause him to lose control of the trailer while driving, which could lead to a crash. The dealer and the manufacturer were not notified of the failure. The RV was not diagnosed o… Look up ODI 11578070 at NHTSA ↗ | 834.8%ODI 11625771In 2021, we began noticing wall movement in the interior of the RV, fasteners, paneling and interior walls getting loose and moving. After more trips we noticed scratches in the flooring and wood chips laying on the interior floor when we would push the main slide out. We also began noticing the large slide didn’t seem to be closing tight to the outside wall on one end. After more inspection we noticed large roller marks appearing on the underside of the main slide. We scheduled our unit into the dealership for review. The Dealership identifie… Look up ODI 11625771 at NHTSA ↗ | 933.3%ODI 11595245-Baggage compartment doors, when latched securely and locked with key, would open during travel down the highway at random. Luckily no cargo was lost (I take turns very slowly and noticed flapping baggage doors in my side view mirrors pretty quickly). This has happened on multiple occasions, and continued to happen after multiple dealership service visits that supposedly rectified the issue. This issue first appeared within 100 miles of purchasing this travel trailer brand new. -Yes, Adventure RV of Cheyenne, WY (now Blue Compass) verified the… Look up ODI 11595245 at NHTSA ↗ | 250.0%ODI 11558983 · 200 miThe contact owns a 2023 Grand Design Reflection RV. The contact stated that the RV was designed with an electric leveling system. The contact stated the two rear levelers failed to elevate beyond 4.5 inches from the ground. The contact stated that the levelers would strike the ground while driving over a speed bump or on a bumpy road surface. The contact stated that the issue was a safety concern because it could cause damage to the RV while driving. The dealer was notified of the failure and referred the contact to the manufacturer for assista… Look up ODI 11558983 at NHTSA ↗ | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Structure:Body | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 14.0%ODI 11362230 · 21,300 miI WAS DRIVING IN ARKANSAS IN OCTOBER 11TH 2019 WHEN I NOTICED THE RV DID NOT APPEAR TO BE TRACKING STRAIGHT BEHIND THE TRUCK. I PACKED UP AND LEFT THE CAMPGROUND ABOUT 2 HOURS EARLIER. THERE WERE NO ISSUES WITH THE AXLES AT THAT TIME. THERE WERE NO UNUSUAL ROAD HAZARDS OR SHOCKS TO THE FRAME DURING THAT PERIOD PRIOR TO WHEN I NOTICED THE ISSUE. I STOPPED AT A REST AREA IN HELENA ARKANSAS AND FOUND THE RIGHT REAR AXLE SPRING HANGER HAD BROKEN FROM THE FRAME. THE SPRING AND REAR AXLE WAS SHIFTED TO THE LEFT AND LODGED PRECARIOUSLY UP INSIDE … Look up ODI 11362230 at NHTSA ↗ | 19.1%ODI 11522266The contact owns a 2018 Grand Design Reflection. The contact stated that as he retracted the RV's main slide out, the actuator used to retract the slide out snapped. Due to the failure, the slide out remained loose and was no longer secured to the RV. A technician was called to inspect the RV but informed the contact that there was too much damage and that extensive repairs would be needed. The manufacturer was notified of the failure and informed the contact that the RV was no longer under warranty. The RV was not repaired. The failure mileage… Look up ODI 11522266 at NHTSA ↗ | 222.2%ODI 11322178 · 12 miOUR 2019 GRAND DESIGN REFLECTION 290BH HAS A TURNING POINT HITCH. THE TURNING POINT HITCH IS DESIGNED SO THAT YOU CAN TOW THE 5TH WHEEL BEHIND A SHORT BED TRUCK WITHOUT A SLIDER HITCH. WHILE TOWING OUR TRAILER AT ABOUT 50 MPH AND APPROACHING A CURVE THE UNIVERSAL WEDGE CAME LOOSE IN OUR HITCH WHICH MADE THE HITCH TURN AT BOTH POINTS. THIS CAUSED OUR TRAILER TO HIT OUR HIT OUR TRUCK. LUCKILY WE TOW THIS 1/2 TON RATED TRAILER WITH A 1 TON TRUCK AND WE WERE ABLE TO WITHSTAND THE IMPACT OF THE HIT. WE WERE NOT THROWN OFF THE ROAD AND WE WERE ABLE… Look up ODI 11322178 at NHTSA ↗ | 00.0%No examples available for this selection. | 521.7%ODI 11474864 · 1,600 miThe contact owns a 2021 Grand Design Reflection RV. The contact stated that the structural slide seized and was inoperable. The RV was taken to the dealer where it was diagnosed with a faulty camber. The mechanics and the manufacturer's technicians performed numerous repairs by welding the frame; however, the failure recurred. The RV was then taken to the manufacturer's factory where the technicians added structural steel to strengthen the frame and replaced the front and rear axles; however, after the repair, the front cap was leaking water an… Look up ODI 11474864 at NHTSA ↗ | 1037.0%ODI 11590780The large slide that has the fridge and dinette has a inadequate schwintek slide mechanism that fails and leaves the buyer to fix out of their own pocket. About all of the floor plan 28BH has this problem. Grand Design may attempt to fix it but it's a bandaid. I have had to pay out of pocket to get the VROOM system to replace the schwintek system along with everyone else that has it. The schwintek slide system is weak and problematic as it strips gears, looses timing and burns up motors. We have only used our camper for going on three years. Look up ODI 11590780 at NHTSA ↗ | 125.0%ODI 11630383Possible frame flex on 5th wheel, had nose cap replaced in June and was told nothing else was wrong, then why did my nose cap crack. Just want it on record with all the issues with GD trailer failures.. Look up ODI 11630383 at NHTSA ↗ | 114.3%ODI 11578999Each trailer must have rear impact guards (bumpers) or other devices that prevent another vehicle from riding underneath. https://csa.fmcsa.dot.gov › MyFiles 5.1.9 Rear-End Protection (393.86) - CSA Compliance, Safety My trailer does not have a rear bumper. Look up ODI 11578999 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Wheels | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 16.3%ODI 11110034 · 12,000 miGRAAND DESIGN USES LIONSHEAD ALUMINUM 5 SPOKE WHEELS ON REFLECTION MODELS. THE WHEELS CRACK. I KNOW OF 3 CASES BESIDES MINE WHERE THE WHEELS HAVE CRACKED, AT SOME POINT SOMEONE IS GOING TO LOSE A WHEEL AND KILL SOMEONE. SEE HERE. HTTPS://WWW.FACEBOOK.COM/GROUPS/147999938972932/PERMALINK/465702340536022/ Look up ODI 11110034 at NHTSA ↗ | 421.1%ODI 10907505 · 3,000 miMY 2016 357BHS HAS A STATED 7K GAWR. THE LCI AXLE IS 7K AND THE WESTLAKE TIRES ARE LISTED AT 3520 WHILE THE 6 LUG WHEELS ARE STAMPED WITH ONLY 3200 LBS WHICH GIVES ME 6400 GAWR AND NOT MEETING THE STATED 7K GAWR. Look up ODI 10907505 at NHTSA ↗ | 28.0%ODI 10958446 · 3,000 miWITH LESS THAN 3000 MILES, THE WHEEL GREASE SEALS HAVE LEAKED CONTAMINATING THE TRAILER BRAKES. RESULTED IN REDUCED BRAKING ABILITY. POTENTIAL SAFETY PROBLEM REDUCING TRAILER BRAKES EFFECTIVE STOPPING POWER. Look up ODI 10958446 at NHTSA ↗ | 00.0%No examples available for this selection. | 111.1%ODI 11217271 · 1,300 miPULLING IN FOR GAS AT GAS STATION HIT THE CURB MAYBE 2 MILES AN HOUR WITH LEFT FRONT TIRE BENT FRONT TIRE ON LEFT BENT HANGER ON LEFT AND BENT HANGER ON RIGHT CAUSING TIRE TO POP AND OVER 3000 DOLLARS OF DAMAGE TO SUSPENSION. HAD ABOUT 1300 MILES ON TRAILER WAS FIRST TRIP OUT Look up ODI 11217271 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 13.7%ODI 11679103After the trailer collapsed, I’m deeply concerned for my children’s safety and the safety of others. Despite raising these issues, the manufacture Grand Design has deflected responsibility and refused to act, even while under warranty. I kindly request immediate attention and a formal response. I previously brought it to Grand Design in Elkhart, Indiana while it was under warranty, but they declined both inspection and repair. I am really struggling with why RVs are not federally regulated. My trailer poses serious safety risks to my family a… Look up ODI 11679103 at NHTSA ↗ | 00.0%No examples available for this selection. | 114.3%ODI 11729187Fifth wheel was purchased with a tire monitoring system included. It has not worked since we purchased it 8-19-2024. We have taken it twice to the dealer, Blue Compass and it still doesn't work. I am told the problem is they put the wrong sensors in the tires. Lippert and Grand Design are fighting about who's fault it is all while it still doesn't work. Not having the tire sensor/monitoring system working has created a safety issues for us. We have no idea if the tires get hot, start to lose air, all of which could happen without the system wor… Look up ODI 11729187 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Electrical System | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 210.5%ODI 10865789TL* THE CONTACT OWNED A 2016 GRAND DESIGN REFLECTION RV. THE VEHICLE CAUGHT FIRE WHILE PARKED. A FIRE REPORT WAS NOT FILED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE CONTACT WAS INFORMED BY THE FIRE MARSHALL THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAILURE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN. Look up ODI 10865789 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 222.2%ODI 11330508 · 30 miI HAVE AN UNSAFE AND POTENTIALLY DANGEROUS WIRING PROBLEM ON MY RV. THE HEATER AND THE REFRIGERATOR ARE WIRED ON THE SAME CIRCUIT BREAKER (SPLICED TOGETHER). WHEN THE HEATER TURNS ON, THE FRIDGE POWER FLASHES ON AND OFF FOR A MOMENT UNTIL THE HEATER IS RUNNING NORMALLY. THIS KIND OF SURGE ON THE CIRCUIT IS UNSAFE AND CAN CAUSE DAMAGE TO OTHER ELECTRICAL COMPONENTS AND/OR FIRE. THE CONTROL BOARD FOR THE FRIDGE HAS ALREADY BEEN REPLACED AS PER BISH'S RV. I HAVE NOTIFIED GRAND DESIGN ABOUT THIS IN A SURVEY (04/2019). SHORTLY AFTER THAT, I RECE… Look up ODI 11330508 at NHTSA ↗ | 00.0%No examples available for this selection. | 28.7%ODI 11421248Improper routing of 110v wiring on RV Gas/Electric Refrigerator circuit wiring leads to wire contacting the refrigerator "chimney" (boiler flue) which over time burns through the wire insulation cover and results in "live wire" to metal contact and can lead to FIRE! Grand Design RV is aware of this issue! One customer had a fire as a result of this poor installation practice and posted the info on Facebook, stating Grand Design, a Fire Inspector for the Insurance Company and an agent for Norcold Refrigerator determined the cause of the fire a… Look up ODI 11421248 at NHTSA ↗ | 13.7%ODI 11593220After removing the factory installed refrigerator to install a warranty replacement unit, I discovered that the aluminum housing of the refrigerator was coming in contact with two 120v electrical outlets and the corresponding wiring. Excess movement of the refrigerator while towing caused chafing of the wiring and resulted in one of the punch down type electrical outlets breaking. The side of the refrigerator also suffered significant damage, clearly demonstrating the potential for a short circuit event. The broken outlet also has the potential… Look up ODI 11593220 at NHTSA ↗ | 00.0%No examples available for this selection. | 114.3%ODI 11578993The camper does not have a GFCI receptacle within the camper. It does have a GFCI breaker. Unfortunately, the GFCI breaker is not easily accessible because you have to remove a couch before you can access the breaker. That does not follow ANSI code. Look up ODI 11578993 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Equipment:Recreational Vehicle/Trailer | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 15.3%ODI 10986102 · 500 miLEAKING AXEL SEALS CAUSING GREASE TO COVER BRAKE SHOES, BRAKE MAGNETS AND DRUMS. Look up ODI 10986102 at NHTSA ↗ | 312.0%ODI 10956632 · 50 miWHEEL GREASE SEALS ARE LEAKING ON THE NEW TRAILER (2 OF 4 SEALS). THIS IS A NEW TRAILER AND I HAVE ONLY PUT ON ABOUT 50 MILES. THERE HAS BEEN NUMEROUS COMPLAINTS ON THIS ISSUE WITH GRAND DESIGN TRAILERS. Look up ODI 10956632 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 14.3%ODI 116563651. DETACHED REAR WALL The interior screws on the back wall tore a horizontal hole (approx 1/2 inch), and interior cabinetry joints are pulling apart. I looked outside to see if there were any signs that were indicative of rear wall separation. The Reflection 150 has an underbelly covering, so mostly the structure/frame is not readily viewable. However, investigating outside I found the black skirt wrinkled/buckled on the rear/drivers side. Upon googling, this is apparent indication of rear wall brackets broken/rear wall detached. 2. iFAME CRAC… Look up ODI 11656365 at NHTSA ↗ | 27.4%ODI 11595281-Stabilizer leveling powered scissor jacks front and rear collapsed during first trip ever; at a level campsite (Lippert LCI brand) on brand new travel trailer. -Rear stabilizer failed the worst, with the metal arms deforming so much that the jack could not be retracted fully via power or manual with backup tool and best arm strength (in shape [XXX] at the time). -Called dealership (Adventure RV Cheyenne, WY now Blue Compass RV Cheyenne, WY) and was told it would probably not be covered under warranty, but they would need to inspect it in per… Look up ODI 11595281 at NHTSA ↗ | 125.0%ODI 11574468The contact owns a 2023 Grand Design Reflection Fifth Wheel RV. The contact stated that the rear stabilizers remained significantly close to the ground while retracted. The contact was concerned that the issue could cause the RV to strike the ground while driving or reversing. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was unknown. Look up ODI 11574468 at NHTSA ↗ | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|