2021 Harley-Davidson FLHX: complaints, problems and recalls

TL* THE CONTACT OWNS A 2012 HARLEY-DAVIDSON STREET GLIDE (FLHX). WHILE PARKING THE MOTORCYCLE, THE BRAKES FAILED. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER (STEEL CITY HARLEY-DAVIDSON, 1375 WASHINGTON RD, WASHINGTON, PA 15301) FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND WOULD NOT ASSIST. THE FAILURE MILEAGE WAS 21,000. *TT CARFAX NOT ABLE TO DISPLAY VIN RECORD UPDATED 9/26/18*JB

Look up ODI 11074540 at NHTSA ↗

TL* THE CONTACT OWNS A 2013 HARLEY-DAVIDSON FLHX STREET GLIDE. WHILE MERGING TO THE RIGHT LANE AT 45 MPH, THE REAR BRAKES FAILED TO RESPOND. THE CONTACT MENTIONED THAT THE REAR BRAKE HANDLE BECAME DIFFICULT TO DEPRESS AND CAUSED THE MOTORCYCLE TO SKID. THE CONTACT FELL OFF THE MOTORCYCLE, RESULTING IN A FRACTURED LEFT ARM AND LACERATION TO THE RIGHT ARM THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MOTORCYCLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILU…

Look up ODI 10889362 at NHTSA ↗

I NOTICED AT NIGHT WHILE I WAS STOPPED AT AN INTERSECTION, WHILE HOLDING THE FRONT BRAKE LEVER, BRAKE LIGHTS WERE NOT ACTUATED. BRAKE LIGHTS WOULD COME ON IF I SQUEEZED THE BRAKES HARDER, BUT THE AMOUNT OF PRESSURE REQUIRED TO HOLD BIKE STILL WHILE STOPPED ON BOTH THE FRONT AND REAR BRAKES WOULD NOT ACTUATE BRAKE LIGHTS. THIS POSES A SAFETY HAZARD PARTICULARLY AT NIGHT WHEN I AM STOPPED AND OTHER DRIVERS HAVE NO INDICATION OF ME BEING STOPPED.

Look up ODI 10744583 at NHTSA ↗

THE HYDRAULIC RESERVOIR COVERS ON BOTH THE CLUTCH LEVER AND FRONT BRAKE LEVER LEAK BRAKE FLUID AND ARE IN CONSTANT NEED OF MONITORING IN THE CASE OF LOW LEVELS OF BRAKE FUILD OR FLUID CONTAMINATION POSSIBLE RESULTING IN CLUTCH OR BRAKE FAILURE.

Look up ODI 10884929 at NHTSA ↗

TL* THE CONTACT OWNED A 2016 HARLEY-DAVIDSON FLHX. WHILE RIDING AT AN UNKNOWN SPEED, THERE WAS EITHER A TIRE BLOWOUT OR A BRAKE FAILURE THAT CAUSED THE CONTACT TO CRASH INTO A ROCK WALL. AS A RESULT, THE CONTACT WENT AIRBORNE AND LANDED ON THE PAVEMENT. THE CONTACT SUSTAINED LACERATIONS AND INJURIES TO THE LUNGS, HEAD, ELBOWS, FINGERS, AND NECK THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MOTORCYCLE WAS TOWED TO YELLOWSTONE HARLEY-DAVIDSON (540 ALASKA FRONTAGE RD, BELGRADE, MT 59714, [phone removed]) WHERE IT WAS DEEMED DESTR…

Look up ODI 11104039 at NHTSA ↗

Brakes are not working properly. There is a pulse when applying the brakes. The brakes do not squarely apply pressure. There is a shutter when applying brakes.

Look up ODI 11667686 at NHTSA ↗

Yes, a triangle on the bottom right side I was not aware of it. The dealership never told me that it needs to be serviced or looked at if that symbol popped up. I tried to get help but no one that Harley Davidson helped me on two separate occasions. The symbol appear approximately one month after purchase maybe two but I purchased a bike in November. The crash happened in January. It happened a few weeks before the crash. Complete brake failure the bike wobbles and threw me off of 30 ft

Look up ODI 11726246 at NHTSA ↗

BATTERY AND CHECK ENGINE LIGHT ON AND VOLTMETER DROPPING. *TR

Look up ODI 10459826 at NHTSA ↗

THE ELECTRICAL SWITCHES ON THE LEFT SIDE STOPPED WORKING. IT HAS LEFT ME WITHOUT INPORTANT SAFETY FEATURES LIKE HIGH BEAMS, LEFT BLINKER, AND HORN. CRUISE CONTROL AND VOLUME CONTROL ARE ALSO UNUSABLE. WHEN I TOOK IT INTO THE HARLEY DEALERSHIP IN FAIRFAX, VA THEY TOLD ME THEY COULDN'T DO ANYTHING AT THE SHOP B/C IT WASN'T CURRENTLY "THROWING A CODE". IT HAS SINCE STOPPED WORKING AGAIN. THE GUY AT THE SHOP SAID IT'S FAIRLY COMMON FOR THE SWITCH HOUSING TO GO OUT. THE KICKER, THEY SAID IT WOULD BE $100 JUST TO READ THE CODE (NOT COVERED UN…

Look up ODI 10904258 at NHTSA ↗

I BOUGHTA 2017 HARLEY DAVIDSON WITH A TWO YEAR MANUFACTURER WARRANTY AND I ALSO PURCHASED ADDITIONAL FIVE YEARS.ON EASTER SUNDAY THE BIKE CAUGHT ON FIRE WHEN I WENT TO GO RESTART THE BIKE.THE FIRE DEPARTMENT PUT THE FIRE OUT AND DETERMINED THAT IT WAS A ELECTRICALMALFUNCTION.HARLEY DAVIDSON DON'T WANT TO COVER THE BIKE.THE BIKE WAS PARK IN THE GARAGE.

Look up ODI 11093489 at NHTSA ↗

CLUTCH SAFETY SWITCH INTERMITTENTLY NOT WORKING. CAN NOT BE STARTED IN GEAR WITH CLUTCH LEVER PULLED IN. CAUSES ENGINE TO IDLE ROUGH AND STALL IN TRAFFIC WHEN IDLING AT INTERSECTIONS. *TR

Look up ODI 11326749 at NHTSA ↗

I have my motorcycle setup to connect to my phone using Bluetooth. I used this to connect via Apple Car Play. I occasionally have an issue where my IPhone 13 Pro Plus screen goes black with a spinning wheel. The iPhone eventually restarts. This happens occasionally. I have heard other people in a Harley Facebook group complain about the same issue with their 2024 Street Glide and Road Glide.

Look up ODI 11590249 at NHTSA ↗

WHILE TRAVELING AT SPEED LIMIT I ATTEMPTED TO EXIT HIGHWAY 101 SOUTHBOUND IN NOVATO CALIFORNIA. UPON BRAKING AND DOWNSHIFTING I REALIZED THE ENTIRE FOOT SHIFTER WAS MISSING. THE VEHICLE WAS IN SIXTH FEAR AND I HAD TO INITIATE EMERGENCY BRAKING TO AVOID LOSING CONTROL OF THE BIKE ON THE EXIT RAMP. THE BIKE WAS THEN STUCK IN SIXTH GEAR AND COULD NOT BE DRIVEN FURTHER. UPON OBTAINING REPLACEMENT PARTS AND INSTALLING THE SAME THE LOCAL DEALER HAD ADVISED ME THAT THIS WAS A COMMON PROBLEM WITH SOME OF THE NEWER HARLEY MODELS AND THAT HAVE HEARD MANY…

Look up ODI 10735887 at NHTSA ↗

I WAS DRIVING DOWN THE HIGHWAY AND MY SHIFTER LEVER FELL OFF THE BIKE ,SO WHEN I GOT HOME I DISCOVERED THAT THE SHIFTER ROD WAS STRIPPED SO NOT ONLY DID I HAVE TO REPLACE THE ROD BUT BOTH FRONT AND REAR SHIFTER LEVERS AS WELL.THIS BIKE ONLY HAS 6000,00 MILES ON IT . WHEN I WENT TO MY LOCAL HD DEALERSHIP FOR THE PARTS HE TOLD ME THAT THIS WAS HAPPENING WITH THE 2014-2016 MODELS AND THAT THESE PARTS WERE FLYING OFF HIS SHELF , WELL THAT SOUNDS TO ME LIKE THIS IS AN ISSUE AND SHOULD BE RECALLED ESPECIALLY SINCE THIS CAUSES A VERY DANGEROUS SITUATI…

Look up ODI 10884055 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 HARLEY-DAVIDSON FLHX. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY CAUSING THE CONTACT TO CRASH INTO AN OPEN LOT. THE CONTACT SUSTAINED A SKULL, ANKLE, LEFT LEG, AND RIGHT FOOT INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. PRIOR TO THE FAILURE, THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBERS: 15V216000 (POWER TRAIN) AND 15V427000 (EQUIPMENT). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILU…

Look up ODI 10786656 at NHTSA ↗

GAIL'S HARLEY DAVIDSON IN GRANDVIEW, MO. SOLD ME A NEW MOTORCYCLE THAT HAS A VERY SERIOUS EXISTING SAFETY RECALL .......... HD # 0169 NHTSA #16V-471. THIS IS A VIOLATION OF FEDERAL LAW. PER HARLEY- DAVIDSON'S OWN WEBSITE, OF WHICH I HAVE COPIES, THE RECALL CAME OUT ON 7/8/2016 AND I PURCHASED MY MOTORCYCLE AND TOOK POSSESSION ON 7/17/2016......... I HAD SEVERAL NEAR ACCIDENTS BEFORE I STOPPED RIDING THE BIKE ANY MORE; FOR INSTANCE I WAS ALMOST PULLED INTO AN INTERSECTION WHEN THE CLUTCH FAILED... IT DID THIS SEVERAL TIMES BEFORE I GOT IT…

Look up ODI 10906163 at NHTSA ↗

WHILE DRIVING LONG DISTANCES AT HIGHWAY SPEEDS, TRANSMISSION LUBRICANT IS TRANSFERRING TO THE PRIMARY CHAINCASE, CAUSING THE PRIMARY CHAINCASE TO OVERFILL. IF NOT DETECTED IMMEDIATELY BY VERIFYING FLUID LEVEL, THIS CAN CAUSE TRANSMISSION AND/OR CLUTCH DAMAGE.

Look up ODI 11014685 at NHTSA ↗

TRANSMISSION IS LOSING OIL INTO PRIMARY. IT OVER FILLS THE PRIMARY WHILE DRAINING THE TRANSMISSION OF NEEDED LUBRICATION. AN OVERFILLED PRIMARY CAN CAUSE HARD SHIFTS, AND COULD POTENTIALLY DAMAGE THE CLUTCH.

Look up ODI 11142210 at NHTSA ↗

The contact owns a 2024 Harley Davidson FLHX Street Glide Motorcycle. The contact stated while riding at approximately 65 MPH, the motorcycle became unstable, and the handlebars and front wheel started to vibrate violently. The motorcycle was taken to a local dealer where the tire pressure and torque converter was inspected; however, no cause for the failure was found. The motorcycle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 200.

Look up ODI 11598330 at NHTSA ↗

MOTORCYCLE SURGES UNEXPECTEDLY AND THEN ALSO LOSES THROTTLE CONTROL. THE FIRST INCIDENT I WAS PULLING OUT OF A PARKING LOT INTO TRAFFIC AND AS SOON AS I GOT INTO THE TRAFFIC LANE MOTORCYCLE LOST ALL THROTTLE RESPONSE BUT MOTOR WAS STILL RUNNING. TRAFFIC WAS A 4 LANE STREET WITH SPEED POSTED AT 35 MPH. THERE WAS NO SHOULDER AND ONLY A CURB. I HAD NOWHERE TO PULL OVER. I ALMOST GOT HIT BY SEVERAL PASSING VEHICLES. I HAD A CHECK ENGINE LIGHT COME ON AT THE TIME I LOST THROTTLE RESPONSE. I SHUT OFF IGNITION AND CYCLED POWER A FEW TIMES AND THE LIGH…

Look up ODI 10761697 at NHTSA ↗

TL* THE CONTACT OWNS A 2013 HARLEY-DAVIDSON FLHX MOTORCYCLE. WHEN THE MOTORCYCLE CLUTCH WAS ENGAGED TO START THE ENGINE, THE MOTORCYCLE FAILED TO ACCELERATE. THE CONTACT HAD TO ENGAGE THE START SWITCHES SEVERAL TIMES TO ENGAGE ACCELERATION. THE CONTACT ALSO STATED THAT THE ENGINE WARNING LIGHT ILLUMINATED WHILE DRIVING AND THE MOTORCYCLE DECELERATED. THE MOTORCYCLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. A DIAGNOSTIC WAS PERFORMED THAT WAS UNABLE TO LOCATE A FAILURE CODE; HOWEVER, THE DEALER REPLACED THE ELECTRONIC CONTROL MODULE…

Look up ODI 10762054 at NHTSA ↗

TL* THE CONTACT OWNS A 2017 HARLEY-DAVIDSON FLHX. UPON CHECKING THE OIL, IT WAS DISCOVERED THAT THERE WAS NO OIL ON THE DIP STICK. UPON FURTHER INSPECTION, IT WAS FOUND THAT THE OIL HAD TRANSFERRED TO THE PRIMARY. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD POTENTIALLY RESULT IN THE ENGINE STALLING. THE MOTORCYCLE WAS TAKEN TO BROTHERS HARLEY-DAVIDSON INC (LOCATED AT 557 W MAIN ST, BRANFORD, CT) WHERE THE FAILURE WAS CONFIRMED AND A TSB WAS PERFORMED REGARDING THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE MOTORCYCLE OPERAT…

Look up ODI 11128397 at NHTSA ↗

TRANSMISSION IS LOSING OIL INTO PRIMARY. IT OVER FILLS THE PRIMARY WHILE DRAINING THE TRANSMISSION OF NEEDED LUBRICATION. AN OVERFILLED PRIMARY CAN CAUSE HARD SHIFTS, AND COULD POTENTIALLY DAMAGE THE CLUTCH.

Look up ODI 11142210 at NHTSA ↗

BROKEN BOLT ON REMOVAL. TOO MUCH LOCTITE/WRONG LOCTITE. TAPPET CUFF (ANTI-ROTATIONAL) BOLT. CAUSES CATASTROPHIC ENGINE FAILURE.

Look up ODI 11416637 at NHTSA ↗

The speedometer is off between 3 and 7 MPH, depending on the speed traveling. I took it in for service, and they stated they needed to consult with corporate. They never got back to me, and after a month, I reached out again, and they sent a text message stating the below: "David this is Jacob at Daytona HD. After speaking with Harley again on your speedo concern they consider it to be within acceptable range of being off. The ref # for the call is [XXX], if you would like to reach out to Harley regarding this the customer service phone # is […

Look up ODI 11592806 at NHTSA ↗

The contact owns a 2026 Harley-Davidson FLHX. The contact stated that while riding the motorcycle at approximately 20 MPH, the engine throttle suddenly revved. The contact pulled the throttle and pressed the brake to stop the motorcycle, but the motorcycle accelerated forward and crashed into the rear of the vehicle ahead. The contact was thrown from the motorcycle and landed on the curb. The Police and Emergency Services were called to the scene, and the contact was transported to the hospital nearby. The contact sustained lacerations to the h…

Look up ODI 11758176 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 HARLEY-DAVIDSON STREET GLIDE FLHX MOTORCYCLE. WHILE DRIVING APPROXIMATELY 50 MPH AND APPLYING THE BRAKES, A VIBRATION OCCURRED UNDER THE CHASSIS. THE VEHICLE WAS TAKEN TO HARLEY-DAVIDSON OF NASSAU COUNTY (LOCATED ON SUNRISE HIGH, BELLMORE, NY 11710) WHERE IT WAS DIAGNOSED THAT THE AFTERMARKET PRODUCTION OF THE CUSTOM RIMS AND ROUTER THAT WERE ATTACHED TO THE WHEEL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 28,000.

Look up ODI 11012874 at NHTSA ↗

TL* THE CONTACT OWNED A 2016 HARLEY-DAVIDSON FLHX. WHILE RIDING AT AN UNKNOWN SPEED, THERE WAS EITHER A TIRE BLOWOUT OR A BRAKE FAILURE THAT CAUSED THE CONTACT TO CRASH INTO A ROCK WALL. AS A RESULT, THE CONTACT WENT AIRBORNE AND LANDED ON THE PAVEMENT. THE CONTACT SUSTAINED LACERATIONS AND INJURIES TO THE LUNGS, HEAD, ELBOWS, FINGERS, AND NECK THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MOTORCYCLE WAS TOWED TO YELLOWSTONE HARLEY-DAVIDSON (540 ALASKA FRONTAGE RD, BELGRADE, MT 59714, [phone removed]) WHERE IT WAS DEEMED DESTR…

Look up ODI 11104039 at NHTSA ↗

TL* THE CONTACT OWNS A 2018 HARLEY-DAVIDSON STREET GLIDE SPECIAL (FLHX). WHILE DRIVING 65 MPH, THE MOTORCYCLE WOBBLED WHEN MAKING TURNS. THE FAILURE OCCURRED ON THE FRONT END OF THE MOTORCYCLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

Look up ODI 11245807 at NHTSA ↗

Operating around New York City there’s a lot of potholes. Attempting to avoid potholes, I have hit a few and every time I may have hit one my bike feels as the tires are going to bust. The bike hits very hard.

Look up ODI 11650895 at NHTSA ↗

COMPENSATING GEAR FAIL

Look up ODI 11019057 at NHTSA ↗

THE 1/4 TURN HARDWARE ON THE SADDLEBAGS COMES LOOSE CAUSING THE BAG TO DETACH FROM THE BIKE CAUSING MAJOR SAFETY CONCERN TO THOSE TRAVELING AROUND THIS BIKE. I HAVE SEEN THIS ON MOST BIKES THIS YEAR, ETC.

Look up ODI 11205994 at NHTSA ↗

THE HYDRAULIC RESERVOIR COVERS ON BOTH THE CLUTCH LEVER AND FRONT BRAKE LEVER LEAK BRAKE FLUID AND ARE IN CONSTANT NEED OF MONITORING IN THE CASE OF LOW LEVELS OF BRAKE FUILD OR FLUID CONTAMINATION POSSIBLE RESULTING IN CLUTCH OR BRAKE FAILURE.

Look up ODI 10884929 at NHTSA ↗

I HAVE A 2018 STREET GLIDE AND HAD THE CLUTCH ACTUATOR RECALL WORK PERFORMED AT THE DEALER THIS PAST WINTER. IT FAILED SUNDAY AND I WAS BROKE DOWN. HARLEY DEALER CLAIMED THEY REPLACED IT TODAY ALL WAS WELL COME GET THE BIKE.. AS I WAS LEAVING THE DEALER WITH MY SO CALLED FIXED MOTORCYCLE I GOT OF THE HIGHWAY ON AN OFF RAMP THE CLUTCH LEVER HAD NO RESISTANCE AND DID NOT RESPOND AS I WAS TRYING TO GEAR DOWN FOR MY ANTICIPATED DEPARTURE FROM THE HWY! THIS COULD HAVE KILLED ME !! DANGEROUS, TRAFFIC WAS HEAVY THREE CARS AT THE INTERSECTION IN FRONT …

Look up ODI 11222829 at NHTSA ↗

As I was operating in Virginia speed limits was 70 and above my 2024 Harley Street Glide began to wobble at high speeds.

Look up ODI 11650893 at NHTSA ↗

This motorcycle is unstable at highway speeds. I believe the aerodynamics of the fairing and the front fender are to blame. It is not an issue when I ride the bike with a passenger, thus more total weight resolves the issue. I am 160 lbs. and when I ride solo and get around semis, or have a headwind, the front end begins to shake side to side at around 70mph, depending on the wind, oscillation begins and I need to pull over before the bike goes into a speed wobble (tank slapper). I've had the bike back to the dealership multiple times and they …

Look up ODI 11688911 at NHTSA ↗