| Engine | — | 0 | 6ODI 11099353 · 68,000 miPURCHASED 2013 SANTA FE SPORT IN JAN 2018, WITH 60K MILES. 7K MILES ADDED, TO DATE. MAY 2018, DROVE THROUGH A CAR WASH, WATER ENTERED THE CAB THROUGH A SEAL ABOVE THE DASHBOARD. HYUNDAI SERVICE INVESTIGATED, REPLACED MOON ROOF SEAL, AND THEN REPORTED THAT THE MOON ROOF SEAL WAS NOT THE CAUSE, FURTHER INVESTIGATION NEEDED, AT A COST, TO US, OF $400. WE RESPECTFULLY DECLINED. WATER ENTERING THE VEHICLE, DURING A HEAVY RAIN, COULD PROVE TO BE VERY DANGEROUS. 6/02/18, MERGED ONTO HIGHWAY, SPEED OF 75 MPH, 9:45 AM, CLEAR SKIES, FAIRLY MODERAT… Look up ODI 11099353 at NHTSA ↗ ODI 11101480 · 69,000 miSUV STALLED OUT ON EXPRESSWAY AT 50MPH. THE ENGINE MADE A LOUD TAPPING NOISE THEN ENGLINE AND OIL LIGHT APPEARED ON DASHBOARD. I COASTED DOWN THE EXIT RAMP NEARLY BEING HIT BY MERGING TRAFFIC. THE BRAKES BECAME HARD AND COSTED TO STOP SIGN. I WAS ABLE TO GET TO NEXT BLOCK TO MY HOME BY PLACING CAR IN PARK AND RESTARTING . THE ENGINE AT THIS POINT SOUNDS LIKE A WOODPECKER TAPPING ON WOOD. MY VEHICLE HAS BEEN TOWED TO DEALERSHIP AND AWAITING WARRANTY REPAIR.AUTHORIZATION. THIS EVENT MIRROR THE RECALL ISSUED BY HYUNDAI AND NHTSA#17V-226. I TOOK TH… Look up ODI 11101480 at NHTSA ↗ ODI 11138959 · 81,000 miON OCTOBER 7TH 2018 WHILE DRIVING AT HIGHWAY SPEED ON A FOUR LANE HIGHWAY MY HYUNDAI SANTA FE SPORT TURBO BEGAN TO MAKE NOISES IN THE ENGINE (NO WARNING LIGHTS CAME ON) THEN SUDDENLY THERE WAS A POPPING SOUND COMING FROM THE ENGINE COMPARTMENT, THE CHECK ENGINE LIGHT CAME ON AND THE CAR COMPLETELY SHUT OFF. I COASTED TO THE SHOULDER AND FOUND SMOKE COMING OUT FROM UNDER THE HOOD. WHEN I OPENED THE HOOD I FOUND THE WHOLE ENGINE COMPARTMENT FULLY ENGULFED IN FLAMES. THE CAR COMPLETELY BURNED OUT WHILE AWAITING THE FIRE DEPARTMENT. Look up ODI 11138959 at NHTSA ↗ | 9ODI 11132734 · 115,000 miTO WHOM IT MAY CONCERN, TWO WEEKS AGO MY 2013 HYUNDAI SANTAFE SPORT TURBO (WHICH I PURCHASED NEW IN 2013) EXPERIENCED AN ENGINE STALL AS I WAS DRIVING ON THE FREEWAY. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD AND THEN EXPERIENCED AN ENGINE FIRE THAT HAS CAUSED EXTENSIVE DAMAGE. THE FIRE WAS EXTINGUISHED AS QUICKLY AS POSSIBLE, BUT NOT BEFORE EXTENSIVE DAMAGE HAD BEEN CAUSED. I HAD MY CAR TOWED TO MY LOCAL AUTO SHOP AND THEY HAVE QUOTED THE DAMAGE IN EXCESS OF $2,000 AND INDICATED THAT THEY BELIEVED THE FIRE WAS DUE TO A SHORT IN THE E… Look up ODI 11132734 at NHTSA ↗ ODI 11132927 · 94,000 miON JULY 26, 2018 VEHICLE LOST ALL POWER AND ENGINE BEGAN SMOKING AND EMITTING FLAMES. CAR WAS IN MOTION AT APPROXIMATELY 70 MPS IN THE MIDDLE OF A TUNNEL ON COLORADO INTERSTATE 70 WITH NO PULL OFF SPACE. CARS BEHIND REPORTED FLAMES FROM UNDER THE VEHICLE. WE WERE ABLE TO EXIT WITHOUT BEING HARMED BUT INHALED HORRIBLE SMELLING FUMES. FIRE DEPARTMENT PERSONNEL DISCONNECT THE BATTERY TO KEEP THE ENGINE FROM CONTINUING TO FLAME AND SMOKE. TOWED OFF INTERSTATE TO SAFE AREA WHERE THEY CONTINUED TO MONITOR VEHICLE FOR CONTINUING SMOKING AND FLAMI… Look up ODI 11132927 at NHTSA ↗ ODI 11144445 · 96,000 miI WAS DRIVING NORTHBOUND ON A FREEWAY TO PICK UP MY 3 YEAR OLD DAUGHTER. MY CAR ENGINE COMPLETELY DIED/STALLED WHILE DRIVING 65MPH. AS SOON AS I TRIED TO GET INTO THE EMERGENCY LANE, I NOTICED SMOKE COMING FROM THE ENGINE. I GRABBED MY PURSE WHICH WAS ON THE PASSENGER SEAT NEXT TO ME, AND I EXITED THE VEHICLE IMMEDIATELY . AS SOON AS I EXITED THE VEHICLE, THE ENTIRE ENGINE AND FRONT OF MY CAR WAS IN FLAMES. THE FIREMAN ARRIVED ON THE SCENE WITHIN 5-10 MINUTES, BUT BY THE TIME THEY HAD GOTTEN THE FIRE OUT, MY ENTIRE CAR WAS TOTALED. I HAD A RECA… Look up ODI 11144445 at NHTSA ↗ | 6ODI 11000469 · 30,000 miON DEC 18TH DRIVING ON A COUNTY ROAD OUTSIDE OF GUNNISON, CO MY 2013 HYUNDAI SANTA FE SPORT WAS IN MOTION AND A CLICKING NOISE BEGAN IN ENGINE. AFTER ~1 HR AND AFTER CHECKING FLUID LEVELS A LOUD POP IN THE ENGINE CAUSED IT TO CEASE FUNCTIONING WHILE IN MOTION (~45-55 MPH) LEAVING MY STRANDED IN DANGEROUSLY COLD TEMPERATURES THAT NIGHT. I WAS FORCED TO HAVE THE VEHICLE TOWED TO DEALERSHIP WHERE, WITH NO LOANER CARS AND A 6 WEEK WAIT ON A NEW ENGINE, WAS FORCED TO PURCHASE ANOTHER VEHICLE FROM HYUNDAI WITH NO EXPLANATION OF WHAT HAPPENED TO THE E… Look up ODI 11000469 at NHTSA ↗ ODI 11006571 · 50,000 miTHERE ARE TWO SEPARATE INCIDENTS WHERE I EXPERIENCED COMPLETE ENGINE FAILURE IN MY SANTE FE SPORT 2.0T. INVOICE NUMBER ' 359131 FIRST OCCURRED AT 47,031 MILES. ON FEBRUARY 16, 2017 I WAS DRIVING MY VEHICLE WITH MY SON ON THE FREEWAY WHEN THE CHECK ENGINE LIGHT APPEARED AND MY VEHICLE BEGAN JERKING AND MAKING A LOUD CLICKING TAPPING SOUND SLOWING ME DOWN ALMOST IMMEDIATELY. I LOST POWER IN MY STEERING, VEHICLE WAS HARD TO MANEUVER. HYUNDAI ATTEMPTED TO REPAIR THE PROBLEM RETURNED MY VEHICLE AND CHARGED ME PARTIALLY FOR REPAIR. MADE CONTACT W… Look up ODI 11006571 at NHTSA ↗ ODI 11074284 · 78,068 miVEHICLE HAS SLIGHTLY OVER 78,000 MILES. ENGINE SEIZED WHILE MERGING ONTO THE HIGHWAY. I AM NOT BEING TOLD THAT THE ENGINE NEEDS TO BE REPLACED. THE DEALERSHIP SOLD US THE WRONG WARRANTY, GAVE US AN OUTDATED CAR FAX REPORT, AND IS SAYING THAT NOTHING CAN BE DONE. Look up ODI 11074284 at NHTSA ↗ | 1ODI 11647609 · 67,000 miThe contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that the vehicle was taken to a local dealer on several occasions for abnormal oil consumption and a burning odor on the exterior of the vehicle. There were no warning lights illuminated. The vehicle was taken back to the same local dealer where the PCV valve, valve cover gasket, sealant, drive belts, ribbed-V belt, RTV silicone gasket maker, turbo, and gasket engine oil plug were replaced; however, the failure persisted. The manufacturer was made aware of the failure. The failu… Look up ODI 11647609 at NHTSA ↗ | 7ODI 11006571 · 50,000 miTHERE ARE TWO SEPARATE INCIDENTS WHERE I EXPERIENCED COMPLETE ENGINE FAILURE IN MY SANTE FE SPORT 2.0T. INVOICE NUMBER ' 359131 FIRST OCCURRED AT 47,031 MILES. ON FEBRUARY 16, 2017 I WAS DRIVING MY VEHICLE WITH MY SON ON THE FREEWAY WHEN THE CHECK ENGINE LIGHT APPEARED AND MY VEHICLE BEGAN JERKING AND MAKING A LOUD CLICKING TAPPING SOUND SLOWING ME DOWN ALMOST IMMEDIATELY. I LOST POWER IN MY STEERING, VEHICLE WAS HARD TO MANEUVER. HYUNDAI ATTEMPTED TO REPAIR THE PROBLEM RETURNED MY VEHICLE AND CHARGED ME PARTIALLY FOR REPAIR. MADE CONTACT W… Look up ODI 11006571 at NHTSA ↗ ODI 11190549 · 97,000 miHUSBAND WAS DRIVING MY SANTA FE SPORT 2013 ON THE HIGHWAY WHEN THE CAR JUST DIED, 97,000 MILES ON THE CAR, NO WARNING AT ALL. NO ENGINE LIGHTS OR ANYTHING. TOOK TO A MECHANIC, SAID THE ENGINE SEIZED AND WILL NEED TO BE REPLACED. ALSO SAID THERE WAS NO OIL IN THE VEHICLE, EVEN THOUGH IT WAS NOT DUE FOR AN OIL CHANGE YET. HE SAID THEY COULDN'T FIND A REASON FOR THERE TO BE NO OIL, PROPER MAINTENANCE HAS BEEN COMPLETED ON THIS VEHICLE. HAD IT TOWED TO THE DEALERSHIP, WAITING TO SEE IF IT IS UNDER WARRANTY, BUT I AM SURE THEY WILL TRY TO FIND A REA… Look up ODI 11190549 at NHTSA ↗ ODI 11206589 · 72,400 miWHILE DRIVING DOWN THE HIGHWAY, THE VEHICLE STARTED TO LOOSE POWER, STARTED HAVING A VIBRATION AND COULD SEE SMOKE IN THE REAR VIEW MIRROR. I PULLED OVER AND THE ENGINE HAD CAUGHT FIRE. WITHIN MINUTES, THE WHOLE VEHICLE BURST INTO FLAMES. Look up ODI 11206589 at NHTSA ↗ | 3ODI 11101480 · 69,000 miSUV STALLED OUT ON EXPRESSWAY AT 50MPH. THE ENGINE MADE A LOUD TAPPING NOISE THEN ENGLINE AND OIL LIGHT APPEARED ON DASHBOARD. I COASTED DOWN THE EXIT RAMP NEARLY BEING HIT BY MERGING TRAFFIC. THE BRAKES BECAME HARD AND COSTED TO STOP SIGN. I WAS ABLE TO GET TO NEXT BLOCK TO MY HOME BY PLACING CAR IN PARK AND RESTARTING . THE ENGINE AT THIS POINT SOUNDS LIKE A WOODPECKER TAPPING ON WOOD. MY VEHICLE HAS BEEN TOWED TO DEALERSHIP AND AWAITING WARRANTY REPAIR.AUTHORIZATION. THIS EVENT MIRROR THE RECALL ISSUED BY HYUNDAI AND NHTSA#17V-226. I TOOK TH… Look up ODI 11101480 at NHTSA ↗ ODI 11708416I requested Engine oil consumption tests on November 12, 2020 and March 27,2021 at Vandergriff Huyndai, Arlington, Tx. Nothing was resolved,. I have been adding oil myself and getting oil changes regularly since. At 146,000 miles it's been worse. After just 2,000 miles after an oil change it was below low, my mechanic topped it off 3 weeks ago and I've had to add oil since. Took my car to Jerry's Huyndai, Weatherford, Texas on December 29,2025. Due to oil consumption, smoke, smell, and I'm wondering if the vibrating is from the engine or if… Look up ODI 11708416 at NHTSA ↗ ODI 11728684After having the ABS recall fixed a while back all of the lights came back on about a week ago. There has been a loss of oil meaning i have been adding oil in between oil changes at least once a week, there has been smoke coming from under the hood and if you run the heat or air you have to have circulate cabin air button pushed or it pulls the smell inside the car and it is overwhelming. The smoking has been going on for about at least a month now. Look up ODI 11728684 at NHTSA ↗ |
|---|
| Service Brakes, Hydraulic | 0 | — | 0 | 1ODI 11600804 · 108,000 miThe contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that the front passenger’s side door failed to register as closed when locked. The back over prevention camera failed to display the rear-view image while in the vehicle was in reverse. The contact stated that during the failure with the back over prevention camera the radio also became inoperable. The contact stated that the TPMS warning light erroneously illuminated with the tires properly inflated. The vehicle was taken to an independent mechanic but was not diagnosed. The co… Look up ODI 11600804 at NHTSA ↗ | 0 | 0 | 0 | 1ODI 11416563THE CONTACT OWNS A 2013 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V303000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. OURISMAN HYUNDAI OF BOWIE (2404 CRAIN HWY SUITE A, BOWIE, MD 20716, (301)390-0880) AND THE MANUFACTURER WERE MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. Look up ODI 11416563 at NHTSA ↗ |
|---|
| Unknown Or Other | 6ODI 11099353 · 68,000 miPURCHASED 2013 SANTA FE SPORT IN JAN 2018, WITH 60K MILES. 7K MILES ADDED, TO DATE. MAY 2018, DROVE THROUGH A CAR WASH, WATER ENTERED THE CAB THROUGH A SEAL ABOVE THE DASHBOARD. HYUNDAI SERVICE INVESTIGATED, REPLACED MOON ROOF SEAL, AND THEN REPORTED THAT THE MOON ROOF SEAL WAS NOT THE CAUSE, FURTHER INVESTIGATION NEEDED, AT A COST, TO US, OF $400. WE RESPECTFULLY DECLINED. WATER ENTERING THE VEHICLE, DURING A HEAVY RAIN, COULD PROVE TO BE VERY DANGEROUS. 6/02/18, MERGED ONTO HIGHWAY, SPEED OF 75 MPH, 9:45 AM, CLEAR SKIES, FAIRLY MODERAT… Look up ODI 11099353 at NHTSA ↗ ODI 11101480 · 69,000 miSUV STALLED OUT ON EXPRESSWAY AT 50MPH. THE ENGINE MADE A LOUD TAPPING NOISE THEN ENGLINE AND OIL LIGHT APPEARED ON DASHBOARD. I COASTED DOWN THE EXIT RAMP NEARLY BEING HIT BY MERGING TRAFFIC. THE BRAKES BECAME HARD AND COSTED TO STOP SIGN. I WAS ABLE TO GET TO NEXT BLOCK TO MY HOME BY PLACING CAR IN PARK AND RESTARTING . THE ENGINE AT THIS POINT SOUNDS LIKE A WOODPECKER TAPPING ON WOOD. MY VEHICLE HAS BEEN TOWED TO DEALERSHIP AND AWAITING WARRANTY REPAIR.AUTHORIZATION. THIS EVENT MIRROR THE RECALL ISSUED BY HYUNDAI AND NHTSA#17V-226. I TOOK TH… Look up ODI 11101480 at NHTSA ↗ ODI 11138959 · 81,000 miON OCTOBER 7TH 2018 WHILE DRIVING AT HIGHWAY SPEED ON A FOUR LANE HIGHWAY MY HYUNDAI SANTA FE SPORT TURBO BEGAN TO MAKE NOISES IN THE ENGINE (NO WARNING LIGHTS CAME ON) THEN SUDDENLY THERE WAS A POPPING SOUND COMING FROM THE ENGINE COMPARTMENT, THE CHECK ENGINE LIGHT CAME ON AND THE CAR COMPLETELY SHUT OFF. I COASTED TO THE SHOULDER AND FOUND SMOKE COMING OUT FROM UNDER THE HOOD. WHEN I OPENED THE HOOD I FOUND THE WHOLE ENGINE COMPARTMENT FULLY ENGULFED IN FLAMES. THE CAR COMPLETELY BURNED OUT WHILE AWAITING THE FIRE DEPARTMENT. Look up ODI 11138959 at NHTSA ↗ | 0 | — | 1ODI 11757483In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17… Look up ODI 11757483 at NHTSA ↗ | 1ODI 11083117 · 97,000 miTHERE IS A RUMBLING NOISE AFTER COMPLETING A TURN, GENERALLY LEFT HAND TURNS. ALSO, DURING THE TURN, THE ENGINE OIL LIGHT COMES ON AND GOES OFF Look up ODI 11083117 at NHTSA ↗ | 0 | 0 | 3ODI 11101480 · 69,000 miSUV STALLED OUT ON EXPRESSWAY AT 50MPH. THE ENGINE MADE A LOUD TAPPING NOISE THEN ENGLINE AND OIL LIGHT APPEARED ON DASHBOARD. I COASTED DOWN THE EXIT RAMP NEARLY BEING HIT BY MERGING TRAFFIC. THE BRAKES BECAME HARD AND COSTED TO STOP SIGN. I WAS ABLE TO GET TO NEXT BLOCK TO MY HOME BY PLACING CAR IN PARK AND RESTARTING . THE ENGINE AT THIS POINT SOUNDS LIKE A WOODPECKER TAPPING ON WOOD. MY VEHICLE HAS BEEN TOWED TO DEALERSHIP AND AWAITING WARRANTY REPAIR.AUTHORIZATION. THIS EVENT MIRROR THE RECALL ISSUED BY HYUNDAI AND NHTSA#17V-226. I TOOK TH… Look up ODI 11101480 at NHTSA ↗ ODI 11160955 · 74,500 miNOTHING HAS HAPPENED YET BUT ABS,ESC,DBC AND PARKING BRAKE LIGHT ALL ON. I HAVE LOOKED THIS UP AND IT SEEMS THIS IS HAPPENING TO MANY OF THESE VEHICLES. I'M JUST WONDERING WHY A RECALL HAS NOT BEEN APPROVED, FOR ALL THESE SYSTEMS ARE SERIOUS SAFETY ISSUES. I'M BRINGING MINE TO THE DEALERSHIP MONDAY BUT WAS TOLD I WOULD MORE THAN LIKELY BE RESPONSIBLE FOR PAYMENT OF THIS PROBLEM. Look up ODI 11160955 at NHTSA ↗ ODI 11757483In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17… Look up ODI 11757483 at NHTSA ↗ |
|---|
| Electrical System | 9ODI 11132734 · 115,000 miTO WHOM IT MAY CONCERN, TWO WEEKS AGO MY 2013 HYUNDAI SANTAFE SPORT TURBO (WHICH I PURCHASED NEW IN 2013) EXPERIENCED AN ENGINE STALL AS I WAS DRIVING ON THE FREEWAY. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD AND THEN EXPERIENCED AN ENGINE FIRE THAT HAS CAUSED EXTENSIVE DAMAGE. THE FIRE WAS EXTINGUISHED AS QUICKLY AS POSSIBLE, BUT NOT BEFORE EXTENSIVE DAMAGE HAD BEEN CAUSED. I HAD MY CAR TOWED TO MY LOCAL AUTO SHOP AND THEY HAVE QUOTED THE DAMAGE IN EXCESS OF $2,000 AND INDICATED THAT THEY BELIEVED THE FIRE WAS DUE TO A SHORT IN THE E… Look up ODI 11132734 at NHTSA ↗ ODI 11132927 · 94,000 miON JULY 26, 2018 VEHICLE LOST ALL POWER AND ENGINE BEGAN SMOKING AND EMITTING FLAMES. CAR WAS IN MOTION AT APPROXIMATELY 70 MPS IN THE MIDDLE OF A TUNNEL ON COLORADO INTERSTATE 70 WITH NO PULL OFF SPACE. CARS BEHIND REPORTED FLAMES FROM UNDER THE VEHICLE. WE WERE ABLE TO EXIT WITHOUT BEING HARMED BUT INHALED HORRIBLE SMELLING FUMES. FIRE DEPARTMENT PERSONNEL DISCONNECT THE BATTERY TO KEEP THE ENGINE FROM CONTINUING TO FLAME AND SMOKE. TOWED OFF INTERSTATE TO SAFE AREA WHERE THEY CONTINUED TO MONITOR VEHICLE FOR CONTINUING SMOKING AND FLAMI… Look up ODI 11132927 at NHTSA ↗ ODI 11144445 · 96,000 miI WAS DRIVING NORTHBOUND ON A FREEWAY TO PICK UP MY 3 YEAR OLD DAUGHTER. MY CAR ENGINE COMPLETELY DIED/STALLED WHILE DRIVING 65MPH. AS SOON AS I TRIED TO GET INTO THE EMERGENCY LANE, I NOTICED SMOKE COMING FROM THE ENGINE. I GRABBED MY PURSE WHICH WAS ON THE PASSENGER SEAT NEXT TO ME, AND I EXITED THE VEHICLE IMMEDIATELY . AS SOON AS I EXITED THE VEHICLE, THE ENTIRE ENGINE AND FRONT OF MY CAR WAS IN FLAMES. THE FIREMAN ARRIVED ON THE SCENE WITHIN 5-10 MINUTES, BUT BY THE TIME THEY HAD GOTTEN THE FIRE OUT, MY ENTIRE CAR WAS TOTALED. I HAD A RECA… Look up ODI 11144445 at NHTSA ↗ | 1ODI 11600804 · 108,000 miThe contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that the front passenger’s side door failed to register as closed when locked. The back over prevention camera failed to display the rear-view image while in the vehicle was in reverse. The contact stated that during the failure with the back over prevention camera the radio also became inoperable. The contact stated that the TPMS warning light erroneously illuminated with the tires properly inflated. The vehicle was taken to an independent mechanic but was not diagnosed. The co… Look up ODI 11600804 at NHTSA ↗ | 1ODI 11757483In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17… Look up ODI 11757483 at NHTSA ↗ | — | 0 | 0 | 2ODI 11206589 · 72,400 miWHILE DRIVING DOWN THE HIGHWAY, THE VEHICLE STARTED TO LOOSE POWER, STARTED HAVING A VIBRATION AND COULD SEE SMOKE IN THE REAR VIEW MIRROR. I PULLED OVER AND THE ENGINE HAD CAUGHT FIRE. WITHIN MINUTES, THE WHOLE VEHICLE BURST INTO FLAMES. Look up ODI 11206589 at NHTSA ↗ ODI 11726301I was driving on March 20, 2026 at about 12:00 PM when I suddenly noticed smoke, a strong gasoline smell, an oil smell, and a burning odor coming from the vehicle. I pulled over immediately because I believed the vehicle was unsafe and at risk of fire. The vehicle had to be towed. An independent repair shop later found a fuel leak at the high-pressure fuel line / fuel pump area, a loose ground wire on the right-hand side of the engine, a valve cover gasket leak, and engine timing chain noise. I was informed that gasoline had sprayed throughout… Look up ODI 11726301 at NHTSA ↗ | 3ODI 11150757 · 61,000 miABS SENSORS GOING BAD ON THESE MODELS. HAPPEND TODAY WHEN I WAS JUST SITTING WITH SUV RUNNING. GOT A C1209 BAD RIGHT REAR SENSOR, READ UP ON IT AND MORE PEOPLE HAVE HAD MULTIPLE FAILURES WITH THIS. SOME STATED THEY GOT RECALLS DEPENDING ON WHERE THEY LIVE AND OTHERS DIDN'T. Look up ODI 11150757 at NHTSA ↗ ODI 11180344 · 89,000 miRESET BRAKE LIGHT ASSEMBLY SHORTS OUT EVERY YEAR. THIS HAS BEEN AN ON GOING ISSUE SINCE I HAVE OWNED THE CAR AND THE DEALER ALWAYS SEEMS TO BE RELUCTANT TO REPAIR IT. THIS NEEDS A RECALL URGENTLET! Look up ODI 11180344 at NHTSA ↗ ODI 11757483In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17… Look up ODI 11757483 at NHTSA ↗ |
|---|
| Power Train | 6ODI 11000469 · 30,000 miON DEC 18TH DRIVING ON A COUNTY ROAD OUTSIDE OF GUNNISON, CO MY 2013 HYUNDAI SANTA FE SPORT WAS IN MOTION AND A CLICKING NOISE BEGAN IN ENGINE. AFTER ~1 HR AND AFTER CHECKING FLUID LEVELS A LOUD POP IN THE ENGINE CAUSED IT TO CEASE FUNCTIONING WHILE IN MOTION (~45-55 MPH) LEAVING MY STRANDED IN DANGEROUSLY COLD TEMPERATURES THAT NIGHT. I WAS FORCED TO HAVE THE VEHICLE TOWED TO DEALERSHIP WHERE, WITH NO LOANER CARS AND A 6 WEEK WAIT ON A NEW ENGINE, WAS FORCED TO PURCHASE ANOTHER VEHICLE FROM HYUNDAI WITH NO EXPLANATION OF WHAT HAPPENED TO THE E… Look up ODI 11000469 at NHTSA ↗ ODI 11006571 · 50,000 miTHERE ARE TWO SEPARATE INCIDENTS WHERE I EXPERIENCED COMPLETE ENGINE FAILURE IN MY SANTE FE SPORT 2.0T. INVOICE NUMBER ' 359131 FIRST OCCURRED AT 47,031 MILES. ON FEBRUARY 16, 2017 I WAS DRIVING MY VEHICLE WITH MY SON ON THE FREEWAY WHEN THE CHECK ENGINE LIGHT APPEARED AND MY VEHICLE BEGAN JERKING AND MAKING A LOUD CLICKING TAPPING SOUND SLOWING ME DOWN ALMOST IMMEDIATELY. I LOST POWER IN MY STEERING, VEHICLE WAS HARD TO MANEUVER. HYUNDAI ATTEMPTED TO REPAIR THE PROBLEM RETURNED MY VEHICLE AND CHARGED ME PARTIALLY FOR REPAIR. MADE CONTACT W… Look up ODI 11006571 at NHTSA ↗ ODI 11074284 · 78,068 miVEHICLE HAS SLIGHTLY OVER 78,000 MILES. ENGINE SEIZED WHILE MERGING ONTO THE HIGHWAY. I AM NOT BEING TOLD THAT THE ENGINE NEEDS TO BE REPLACED. THE DEALERSHIP SOLD US THE WRONG WARRANTY, GAVE US AN OUTDATED CAR FAX REPORT, AND IS SAYING THAT NOTHING CAN BE DONE. Look up ODI 11074284 at NHTSA ↗ | 0 | 1ODI 11083117 · 97,000 miTHERE IS A RUMBLING NOISE AFTER COMPLETING A TURN, GENERALLY LEFT HAND TURNS. ALSO, DURING THE TURN, THE ENGINE OIL LIGHT COMES ON AND GOES OFF Look up ODI 11083117 at NHTSA ↗ | 0 | — | 0 | 2ODI 11006571 · 50,000 miTHERE ARE TWO SEPARATE INCIDENTS WHERE I EXPERIENCED COMPLETE ENGINE FAILURE IN MY SANTE FE SPORT 2.0T. INVOICE NUMBER ' 359131 FIRST OCCURRED AT 47,031 MILES. ON FEBRUARY 16, 2017 I WAS DRIVING MY VEHICLE WITH MY SON ON THE FREEWAY WHEN THE CHECK ENGINE LIGHT APPEARED AND MY VEHICLE BEGAN JERKING AND MAKING A LOUD CLICKING TAPPING SOUND SLOWING ME DOWN ALMOST IMMEDIATELY. I LOST POWER IN MY STEERING, VEHICLE WAS HARD TO MANEUVER. HYUNDAI ATTEMPTED TO REPAIR THE PROBLEM RETURNED MY VEHICLE AND CHARGED ME PARTIALLY FOR REPAIR. MADE CONTACT W… Look up ODI 11006571 at NHTSA ↗ ODI 116818292013 HYUNDAI SANTA FE SPORT TURBO. PAST/PRESENT SAFETY-SENSITIVE DEFECTS, NOTED OVER THE PAST SEVERAL YEARS: 1. One Confirmed Open Recall [CAMPAIGN #/NHTSA RECALL #, Recall 251 / 23V651000] (To Be Scheduled ASAP). 2. RPM/Propulsion Limp-mode Conditions: Vehicle periodically loses RPM READINGS on Dash and goes into the Propulsion sputtering/restricted-speed limp-mode hesitation condition. This condition may occasionally normalize by stopping, turning off engine and restarting. This intermittent RPM/Propulsion condition sometimes occurs, sign… Look up ODI 11681829 at NHTSA ↗ | 0 |
|---|
| Engine And Engine Cooling | 1ODI 11647609 · 67,000 miThe contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that the vehicle was taken to a local dealer on several occasions for abnormal oil consumption and a burning odor on the exterior of the vehicle. There were no warning lights illuminated. The vehicle was taken back to the same local dealer where the PCV valve, valve cover gasket, sealant, drive belts, ribbed-V belt, RTV silicone gasket maker, turbo, and gasket engine oil plug were replaced; however, the failure persisted. The manufacturer was made aware of the failure. The failu… Look up ODI 11647609 at NHTSA ↗ | 0 | 0 | 0 | 0 | — | 0 | 0 |
|---|
| Fuel/Propulsion System | 7ODI 11006571 · 50,000 miTHERE ARE TWO SEPARATE INCIDENTS WHERE I EXPERIENCED COMPLETE ENGINE FAILURE IN MY SANTE FE SPORT 2.0T. INVOICE NUMBER ' 359131 FIRST OCCURRED AT 47,031 MILES. ON FEBRUARY 16, 2017 I WAS DRIVING MY VEHICLE WITH MY SON ON THE FREEWAY WHEN THE CHECK ENGINE LIGHT APPEARED AND MY VEHICLE BEGAN JERKING AND MAKING A LOUD CLICKING TAPPING SOUND SLOWING ME DOWN ALMOST IMMEDIATELY. I LOST POWER IN MY STEERING, VEHICLE WAS HARD TO MANEUVER. HYUNDAI ATTEMPTED TO REPAIR THE PROBLEM RETURNED MY VEHICLE AND CHARGED ME PARTIALLY FOR REPAIR. MADE CONTACT W… Look up ODI 11006571 at NHTSA ↗ ODI 11190549 · 97,000 miHUSBAND WAS DRIVING MY SANTA FE SPORT 2013 ON THE HIGHWAY WHEN THE CAR JUST DIED, 97,000 MILES ON THE CAR, NO WARNING AT ALL. NO ENGINE LIGHTS OR ANYTHING. TOOK TO A MECHANIC, SAID THE ENGINE SEIZED AND WILL NEED TO BE REPLACED. ALSO SAID THERE WAS NO OIL IN THE VEHICLE, EVEN THOUGH IT WAS NOT DUE FOR AN OIL CHANGE YET. HE SAID THEY COULDN'T FIND A REASON FOR THERE TO BE NO OIL, PROPER MAINTENANCE HAS BEEN COMPLETED ON THIS VEHICLE. HAD IT TOWED TO THE DEALERSHIP, WAITING TO SEE IF IT IS UNDER WARRANTY, BUT I AM SURE THEY WILL TRY TO FIND A REA… Look up ODI 11190549 at NHTSA ↗ ODI 11206589 · 72,400 miWHILE DRIVING DOWN THE HIGHWAY, THE VEHICLE STARTED TO LOOSE POWER, STARTED HAVING A VIBRATION AND COULD SEE SMOKE IN THE REAR VIEW MIRROR. I PULLED OVER AND THE ENGINE HAD CAUGHT FIRE. WITHIN MINUTES, THE WHOLE VEHICLE BURST INTO FLAMES. Look up ODI 11206589 at NHTSA ↗ | 0 | 0 | 2ODI 11206589 · 72,400 miWHILE DRIVING DOWN THE HIGHWAY, THE VEHICLE STARTED TO LOOSE POWER, STARTED HAVING A VIBRATION AND COULD SEE SMOKE IN THE REAR VIEW MIRROR. I PULLED OVER AND THE ENGINE HAD CAUGHT FIRE. WITHIN MINUTES, THE WHOLE VEHICLE BURST INTO FLAMES. Look up ODI 11206589 at NHTSA ↗ ODI 11726301I was driving on March 20, 2026 at about 12:00 PM when I suddenly noticed smoke, a strong gasoline smell, an oil smell, and a burning odor coming from the vehicle. I pulled over immediately because I believed the vehicle was unsafe and at risk of fire. The vehicle had to be towed. An independent repair shop later found a fuel leak at the high-pressure fuel line / fuel pump area, a loose ground wire on the right-hand side of the engine, a valve cover gasket leak, and engine timing chain noise. I was informed that gasoline had sprayed throughout… Look up ODI 11726301 at NHTSA ↗ | 2ODI 11006571 · 50,000 miTHERE ARE TWO SEPARATE INCIDENTS WHERE I EXPERIENCED COMPLETE ENGINE FAILURE IN MY SANTE FE SPORT 2.0T. INVOICE NUMBER ' 359131 FIRST OCCURRED AT 47,031 MILES. ON FEBRUARY 16, 2017 I WAS DRIVING MY VEHICLE WITH MY SON ON THE FREEWAY WHEN THE CHECK ENGINE LIGHT APPEARED AND MY VEHICLE BEGAN JERKING AND MAKING A LOUD CLICKING TAPPING SOUND SLOWING ME DOWN ALMOST IMMEDIATELY. I LOST POWER IN MY STEERING, VEHICLE WAS HARD TO MANEUVER. HYUNDAI ATTEMPTED TO REPAIR THE PROBLEM RETURNED MY VEHICLE AND CHARGED ME PARTIALLY FOR REPAIR. MADE CONTACT W… Look up ODI 11006571 at NHTSA ↗ ODI 116818292013 HYUNDAI SANTA FE SPORT TURBO. PAST/PRESENT SAFETY-SENSITIVE DEFECTS, NOTED OVER THE PAST SEVERAL YEARS: 1. One Confirmed Open Recall [CAMPAIGN #/NHTSA RECALL #, Recall 251 / 23V651000] (To Be Scheduled ASAP). 2. RPM/Propulsion Limp-mode Conditions: Vehicle periodically loses RPM READINGS on Dash and goes into the Propulsion sputtering/restricted-speed limp-mode hesitation condition. This condition may occasionally normalize by stopping, turning off engine and restarting. This intermittent RPM/Propulsion condition sometimes occurs, sign… Look up ODI 11681829 at NHTSA ↗ | 0 | — | 0 |
|---|
| Service Brakes | 3ODI 11101480 · 69,000 miSUV STALLED OUT ON EXPRESSWAY AT 50MPH. THE ENGINE MADE A LOUD TAPPING NOISE THEN ENGLINE AND OIL LIGHT APPEARED ON DASHBOARD. I COASTED DOWN THE EXIT RAMP NEARLY BEING HIT BY MERGING TRAFFIC. THE BRAKES BECAME HARD AND COSTED TO STOP SIGN. I WAS ABLE TO GET TO NEXT BLOCK TO MY HOME BY PLACING CAR IN PARK AND RESTARTING . THE ENGINE AT THIS POINT SOUNDS LIKE A WOODPECKER TAPPING ON WOOD. MY VEHICLE HAS BEEN TOWED TO DEALERSHIP AND AWAITING WARRANTY REPAIR.AUTHORIZATION. THIS EVENT MIRROR THE RECALL ISSUED BY HYUNDAI AND NHTSA#17V-226. I TOOK TH… Look up ODI 11101480 at NHTSA ↗ ODI 11708416I requested Engine oil consumption tests on November 12, 2020 and March 27,2021 at Vandergriff Huyndai, Arlington, Tx. Nothing was resolved,. I have been adding oil myself and getting oil changes regularly since. At 146,000 miles it's been worse. After just 2,000 miles after an oil change it was below low, my mechanic topped it off 3 weeks ago and I've had to add oil since. Took my car to Jerry's Huyndai, Weatherford, Texas on December 29,2025. Due to oil consumption, smoke, smell, and I'm wondering if the vibrating is from the engine or if… Look up ODI 11708416 at NHTSA ↗ ODI 11728684After having the ABS recall fixed a while back all of the lights came back on about a week ago. There has been a loss of oil meaning i have been adding oil in between oil changes at least once a week, there has been smoke coming from under the hood and if you run the heat or air you have to have circulate cabin air button pushed or it pulls the smell inside the car and it is overwhelming. The smoking has been going on for about at least a month now. Look up ODI 11728684 at NHTSA ↗ | 1ODI 11416563THE CONTACT OWNS A 2013 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V303000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. OURISMAN HYUNDAI OF BOWIE (2404 CRAIN HWY SUITE A, BOWIE, MD 20716, (301)390-0880) AND THE MANUFACTURER WERE MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. Look up ODI 11416563 at NHTSA ↗ | 3ODI 11101480 · 69,000 miSUV STALLED OUT ON EXPRESSWAY AT 50MPH. THE ENGINE MADE A LOUD TAPPING NOISE THEN ENGLINE AND OIL LIGHT APPEARED ON DASHBOARD. I COASTED DOWN THE EXIT RAMP NEARLY BEING HIT BY MERGING TRAFFIC. THE BRAKES BECAME HARD AND COSTED TO STOP SIGN. I WAS ABLE TO GET TO NEXT BLOCK TO MY HOME BY PLACING CAR IN PARK AND RESTARTING . THE ENGINE AT THIS POINT SOUNDS LIKE A WOODPECKER TAPPING ON WOOD. MY VEHICLE HAS BEEN TOWED TO DEALERSHIP AND AWAITING WARRANTY REPAIR.AUTHORIZATION. THIS EVENT MIRROR THE RECALL ISSUED BY HYUNDAI AND NHTSA#17V-226. I TOOK TH… Look up ODI 11101480 at NHTSA ↗ ODI 11160955 · 74,500 miNOTHING HAS HAPPENED YET BUT ABS,ESC,DBC AND PARKING BRAKE LIGHT ALL ON. I HAVE LOOKED THIS UP AND IT SEEMS THIS IS HAPPENING TO MANY OF THESE VEHICLES. I'M JUST WONDERING WHY A RECALL HAS NOT BEEN APPROVED, FOR ALL THESE SYSTEMS ARE SERIOUS SAFETY ISSUES. I'M BRINGING MINE TO THE DEALERSHIP MONDAY BUT WAS TOLD I WOULD MORE THAN LIKELY BE RESPONSIBLE FOR PAYMENT OF THIS PROBLEM. Look up ODI 11160955 at NHTSA ↗ ODI 11757483In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17… Look up ODI 11757483 at NHTSA ↗ | 3ODI 11150757 · 61,000 miABS SENSORS GOING BAD ON THESE MODELS. HAPPEND TODAY WHEN I WAS JUST SITTING WITH SUV RUNNING. GOT A C1209 BAD RIGHT REAR SENSOR, READ UP ON IT AND MORE PEOPLE HAVE HAD MULTIPLE FAILURES WITH THIS. SOME STATED THEY GOT RECALLS DEPENDING ON WHERE THEY LIVE AND OTHERS DIDN'T. Look up ODI 11150757 at NHTSA ↗ ODI 11180344 · 89,000 miRESET BRAKE LIGHT ASSEMBLY SHORTS OUT EVERY YEAR. THIS HAS BEEN AN ON GOING ISSUE SINCE I HAVE OWNED THE CAR AND THE DEALER ALWAYS SEEMS TO BE RELUCTANT TO REPAIR IT. THIS NEEDS A RECALL URGENTLET! Look up ODI 11180344 at NHTSA ↗ ODI 11757483In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17… Look up ODI 11757483 at NHTSA ↗ | 0 | 0 | 0 | — |
|---|