2001 International Harvester 4700: complaints, problems and recalls

NO PARTS AVAILABLE. RECALL #02V135002 BRAKE RELAY VALVE. PLEASE PROVIDE THE NAME, NUMBER, AND ADDRESS OF THE DEALER. TS

Owner-reported narrative. Look up ODI 10001370 at NHTSA ↗

THE RIGHT REAR HYDRAULIC BRAKE CALIPER FAILED TO RELEASE PROPERLY, WHICH RESULTED IN A VEHICLE FIRE. *MR ON THE SECOND OCCASION, THE FRONT CALIPER FAILED TO RELEASE PROPERLY WHICH ALMOST CAUSED THE CONSUMER TO LOSE CONTROL OF THE TRUCK WHILE TRAVELING 55 MPH. *TS *JB *SCC *JB

Owner-reported narrative. 10,300 miles reported. Look up ODI 10024693 at NHTSA ↗

RIGHT REAR HYDRAULIC BRAKE CALIPER FAILED. *MR THE RIGHT REAR BRAKE CALIPER FAILED TO RELEASE PROPERLY AND RESULTED IN A FIRE. THE CONSUMER WAS TRANSPORTING A BULLDOZER AT THE TIME. ALL REAR BRAKES AND CALIPERS WERE REPLACED. WHILE TRANSPORTING A BACKHOE, THE RIGHT FRONT CALIPER FAILED TO RELEASE PROPERLY AND RESULTED IN A NEAR LOSS OF CONTROL. THE THERE WAS AN OCCASION WHERE THE AXLE HAD BROKEN ON THE VEHICLE WHILE IN MOTION. (UNEXPECTEDLY) THE VEHICLE ALSO ACCELERATED ON IT'S OWN ON SEVERAL OCCASIONS AND WAS REPAIRED TWICE TO CORREC…

Owner-reported narrative. 10,300 miles reported. Look up ODI 10026434 at NHTSA ↗

I OWN A 2001 INTERNATIONAL FLAT BED TOW TRUCK,ALSO REFERRED TO AS A ROLL BACK OR CAR CARRIER.I HAVE HAD ONE INCIDENT WITH THE THE"L"ARM BRACKET THAT RETAINS THE "L"ARM FOR THE WHEEL LIFT COMING OFF MY TRUCK AND ANOTHER INCIDENT WHERE THE COMPLETE HYDRAULIC CONTROL PANEL ASSEMBLY THAT GOES FROM ONE SIDE OF THE TRUCK TO THE OPPOSITE SIDE, FALLING DOWN.THE EQUIPMENT WAS INSTALLED BY CHEVRON CARRIERS AND WRECKERS,LOCATED AT 7320 W.MARKET ST,MERCER,PA,16137.THEIR PHONE NUMBER IS [phone removed] OR [phone removed].I CONTACTED CHEVRON AND NOTIFIED THE…

Owner-reported narrative. 150,511 miles reported. Look up ODI 10080577 at NHTSA ↗

WHILE DRIVING, THE ABS WARNING LIGHT ILLUMINATED UNTIL THE VEHICLE WAS TURNED OFF. PLEASE PROVIDE MORE INFORMATION. *JB

Owner-reported narrative. 70,000 miles reported. Look up ODI 10096748 at NHTSA ↗

THE BRAKES HAVE BEEN DEFECTIVE SINCE CONSUMER PURCHASED THE VEHICLE. CONSUMER'S VEHICLE WAS INCLUDED IN A RECALL FOR THE SAME BRAKE PROBLEM, BUT PROBLEM RECURRED. ABS LIGHT WAS STILL ON AFTER BEING SERVICED 8 TIMES.*AK

Owner-reported narrative. 6,000 miles reported. Look up ODI 10101335 at NHTSA ↗

THE GAUGES AND SPEEDOMETER QUIT WORKING ON THE DASH OF THE 2001 INTERNATIONAL MODEL 4700. SO FAR THERE HAVE BEEN NO CONSEQUENCES BUT I HAVE BEEN HEARING THAT IT IS A HAZARDOUS OCCURENCE BECAUSE OF THE POSSIBILITY OF A FIRE IN THE DASHBOARD. TALKING TO OTHER OWNERS OF INTERNATIONAL TRUCKS THEY HAVE ALL EXPERIENCED THE SAME THING, ONE WITH A FIRE OCCURING.*AK

Owner-reported narrative. Look up ODI 10133228 at NHTSA ↗

Reported: 2001-03-26 (March 26, 2001)

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH BOSTROM DRIVER SEAT MODELS (910, 910SC, OR 914) AND INTERNATIONAL'S PARKING BRAKE CODE 04036. IF SOMEONE OUTSIDE THE CAB ADJUSTS/SLIDES THE DRIVER'S SEAT TO ITS MOST FORWARD POSITION, WITH THE PARKING BRAKE SET, THE SEAT WILL CONTACT AND RELEASE THE PARKING BRAKE LEVER.

Consequence: IF THE PARKING BRAKE IS ACCIDENTALLY RELEASED, THE VEHICLE COULD MOVE UNEXPECTEDLY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A STOP-BRACKET ON THE SEAT TRACK TO LIMIT THE TRAVEL OF THE SEAT SO THAT THE SEAT CAN NOT RELEASE THE PARKING BRAKE LEVER. OWNER NOTIFICATION BEGAN APRIL 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2002-05-20 (May 20, 2002)

ON CERTAIN MEDIUM AND HEAVY DUTY TRUCKS, A BRASS FITTING CONNECTS THE DOUBLE CHECK VALVE TO THE BRAKE RELAY VALVE. WITH CERTAIN INPUTS TO THE VEHICLE, THE WEIGHT OF THE CHECK VALVE ON THE FITTING CAN CAUSE THE ASSEMBLY TO RESONATE. THE SUBJECT VIBRATION CAN CAUSE EXCESSIVE STRAIN LEVELS IN THE FITTING, WHICH COULD EVENTUALLY FATIGUE AND FAIL.

Consequence: IF THE FITTING BREAKS, THE REAR SERVICE BRAKES WILL CEASE TO OPERATE WITHOUT WARNING, RESULTING IN AN EXTENDED STOPPING DISTANCE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A KIT TO REMOUNT THE DOUBLE CHECK VALVE WITH A FLEXIBLE HOSE ON THE MAJORITY OF VEHICLES. ON A SMALL NUMBER OF UNITS WITH CLEARANCE ISSUES OR TRACTION CONTROL, A KIT WITH A NEW RELAY VALVE THAT HAS A BUILT-IN DOUBLE CHECK VALVE WILL BE INSTALLED. OWNER NOTIFICATION BEGAN SEPTEMBER 11, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2003-04-03 (April 3, 2003)

ON CERTAIN HEAVY DUTY TRUCKS, A BRASS FITTING CONNECTS THE DOUBLE CHECK VALVE TO THE BRAKE RELAY VALVE. WITH CERTAIN INPUTS TO THE VEHICLE, THE WEIGHT OF THE CHECK VALVE ON THE FITTING CAN CAUSE THE ASSEMBLY TO RESONATE. THE SUBJECT VIBRATION CAN CAUSE EXCESSIVE STRAIN LEVELS IN THE FITTING, WHICH COULD EVENTUALLY FATIGUE AND FAIL.

Consequence: IF THE FITTING BREAKS, THE REAR SERVICE BRAKES WILL CEASE TO OPERATE WITHOUT WARNING, RESULTING IN AN EXTENDED STOPPING DISTANCE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A KIT TO REMOUNT THE DOUBLE CHECK VALVE WITH A FLEXIBLE HOSE ON THE MAJORITY OF VEHICLES. ON A SMALL NUMBER OF UNITS WITH CLEARANCE ISSUES OR TRACTION CONTROL, A KIT WITH A NEW RELAY VALVE THAT HAS A BUILT-IN DOUBLE CHECK VALVE WILL BE INSTALLED. OWNER NOTIFICATION BEGAN ON APRIL 18, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Reported: 2004-06-03 (June 3, 2004)

ON CERTAIN SCHOOL BUSES AND TRUCK MODEL VEHICLES MANUFACTURED BETWEEN FEBRUARY 28, 1999, THROUGH APRIL 5, 2004, THE ANTI-LOCK BRAKE SYSTEM ELECTRONIC CONTROL UNIT (ECU) MAY MISINTERPRET A CORRUPT WHEEL SPEED SIGNAL.

Consequence: THE CORRUPT WHEEL SPEED SIGNALS MAY IMPROPERLY ACTIVATE THE ABS, INSTEAD OF DEACTIVATING THE ABS. THIS MAY RESULT IN THE DRIVER EXPERIENCING A HARD PEDAL FEEL AND A DECREASE IN DECELERATION AT THE END OF THE STOP, RESULTING IN EXTENDED STOPPING DISTANCES WHICH COULD CAUSE A VEHICLE CRASH, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: INTERNATIONAL WILL NOTIFY ITS CUSTOMERS AND INSPECT AND REPAIR THE AFFECTED VEHICLES FREE OF CHARGE. THE RECALL BEGAN AUGUST 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL CUSTOMER SERVICE AT 1-800-327-4236.