2012 International 4400: complaints, problems and recalls

TL* THE CONTACT OWNS A 2004 INTERNATIONAL 4400 DT466. THE CONTACT STATED THAT VEHICLE BURST INTO FLAMES FROM UNDER THE DASHBOARD WHILE PARKED IN THE GARAGE AND SHUT OFF. AS A RESULT, THE BUILDING ALSO BURNED DOWN. THE FIRE DEPARTMENT WAS CONTACTED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 120,000.

Look up ODI 10436224 at NHTSA ↗

TL* THE CONTACT OWNS A 2005 INTERNATIONAL 4400 TRUCK. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY AND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE POSITIVE SIDE CABLE WIRE NEEDED TO BE REPLACED. THE DEALER ALSO ADVISED THAT THE FAILURE WOULD LIKELY RECUR BECAUSE OF CORROSIVE FUMES THAT WERE EMITTED FROM THE BATTERY. THE FAILURE AND THE CURRENT MILEAGES WERE 110,118. UPDATED 10/11/12

Look up ODI 10459260 at NHTSA ↗

DT*: THE CONTACT STATED AFTER SHUTTING THE VEHICLE DOWN, THE BOTTOM LINER O-RING PROPELLED THROUGH THE NUMBER 4 CYLINDER. THE RADIATOR FLUID DRAINED INTO THE OIL WHICH RESULTED IN THE ENGINE SEIZURE. THE VEHICLE WAS TOWED TO THE DEALER AND THE ENGINE WAS OVER HAULED. THE MANUFACTURER WAS ALERTED. UPDATED05/16/06. *JB

Look up ODI 10152335 at NHTSA ↗

TL* THE CONTACT OWNS A 2005 INTERNATIONAL 4400 TRUCK. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY AND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE POSITIVE SIDE CABLE WIRE NEEDED TO BE REPLACED. THE DEALER ALSO ADVISED THAT THE FAILURE WOULD LIKELY RECUR BECAUSE OF CORROSIVE FUMES THAT WERE EMITTED FROM THE BATTERY. THE FAILURE AND THE CURRENT MILEAGES WERE 110,118. UPDATED 10/11/12

Look up ODI 10459260 at NHTSA ↗

THE CONSUMER STATED THAT HE HAS BEEN HAVING PROBLEMS WITH HIS BRAKES. HE STATED THAT WHEN IT IS RAINING THE BRAKES FAILED. HE ALSO STATED THAT ONCE HE WENT STRAIGHT THROUGH A STOP SIGN. THE CONSUMER STATED THAT THIS TRUCK WITH THESE FAULTY BRAKES HAS CAUSED HIM TO HAVE A ACCIDENT. HE SAYS HE TOOK THE TRUCK TO THE DEALER AND WAS TOLD ALL THEY COULD FIND IS WHEN IT RAINS THE RELAY VALVE GETS WET, SO THEY THINK IT IS A SHORT SOMEWHERE. *JB

Look up ODI 10097158 at NHTSA ↗

JANUARY 29 2009 DRIVER COMPLAINS OF NO BRAKES WHEN BRAKES ARE WET. VEHICLE IS 2007 INTERNATIONAL 4400 N LOW PRO SNOW PLOW WITH AIR BRAKES DELIVER DATE 08MAY 06. INTERNATIONAL NOTIFIED, SO FAR NO CURES. *TR

Look up ODI 10256860 at NHTSA ↗

WET WEATHER, BRAKES FAILED AND THERE WAS AN ACCIDENT. NOTHING WAS DONE BY MANUFACTURER CORKY MILLER SAID IF THERES AN ACCIDENT THAN WE'LL DO AN INVESTAGATION ON THE BRAKES. *AK

Look up ODI 10093276 at NHTSA ↗

WE'VE HAD TWO ENGINE FAILURES WITH THIS TRUCK. THE FIRST OCCURRED AT 121,000 MILES WHEN AN O-RING ON A CYLINDER SLEEVE FAILED LETTING COOLANT FILL THE CRANKCASE AND REQUIRING A COMPLETE ENGINE OVERHAUL THAT COST US OVER $6,000 DOLLARS. THE TRUCK WAS MORE THAN 3 YEARS OLD SO WE HAD TO PAY FOR THE REPAIRS. AFTER PUTTING ONLY 40,000 MILES ON THE REBUILT ENGINE IT HAS THROWN A ROD OUT THE SIDE OF THE BLOCK COMPLETELY RUINING THE ENGINE. IT WILL HAVE TO BE REPLACED AT AN ESTIMATED COST OF $16,000. WE HAVE CONTACTED NAVISTAR BECAUSE THE SERVICE TECHN…

Look up ODI 10300120 at NHTSA ↗

MASSIVE FUEL LEAK UNDER TRUCK CAB. THIS WAS CAUSED BY FUEL RETURN LINE COMING OFF BACK OF ENGINE. PLASTIC CLIP THAT IS NOT SECURELY FASTENED IS FACTORY DESIGN. VERY UNSAFE IN MY OPINION. *TR

Look up ODI 10676321 at NHTSA ↗

ON 19 JUNE 2012,, WE RECEIVED INFORMATION FROM OUR AMBULANCE MANAFACTURE SALES REPRESENATIVE ON A SAFETY CONCERN OF ANOTHER AMBULANCE SERVICE IN THE AREA THAT REPORTED A FAILURE OF THE BUSHINGS FOR THE TORQUE ARMS ON THEIR 2011 INTERNATIONAL NAVASTAR 4300, WHICH HAS LESS THAN 60,000 MILES. UPON RECEIVING THIS INFORMATION I IMMEDIATELY TOOK BOTH OF OUR 2011 INTERNATIONAL NAVISTAR 4400 AND HAD THEM INSPECTED AT THE INTERNATIONAL DEALERSHIP AND ONE OF OUR TWO 2011 INTERNATIONAL NAVISTAR 4400 WAS NOTED THAT THE LEFT REAR TORQUE ARM BUSHING HAD MOVE…

Look up ODI 10463011 at NHTSA ↗