2017 Jayco GREYHAWK: complaints, problems and recalls

OUR CAB AREA THE DOGHOUSE AND THE FLOOR BETWEEN THE PASSENGER AND DRIVER IS REACHING 130 TO 140 DEGREES IN TEMPERATURE. I BURNED MY CALF ON LEFT LEG DUE TO EXTREME HEAT. THE LONGER WE DRIVE THE HOTTER THE CAB BECOMES. I HAVE MULTIPLE SCLEROSIS AND MY LEG AND ARMS ARE NUMB. I PURCHASED MOTOR HOME TO TRAVEL TO MAYO CLINIC. PLEASE HELP. THIS IS A SAFETY AND HEALTH ISSUE. I BECOME LETHARGIC IN HEAT.

Look up ODI 11120587 at NHTSA ↗

While driving down the road at about 45mph, the driver side upper cabin window located adjacent to the eating table exploded and blew into the cabin. The window shattered and glass blew throughout the cabin area. Whatever caused this, the blast was strong enough to pull the Velcro straps holding the seat cushions blown off and the glass ripped the cushion's vinyl. If someone had been sitting at the table, they would have been extremely cut and hurt and possibly blinded. I had no warning to this situation. At first, I thought someone had sh…

Look up ODI 11755354 at NHTSA ↗

After a recent purchase of a new 2026 Jayco Greyhawk 29MV RV, I discovered my 2 cats trying to enter a previously unknown and unfinished opening adjacent to a designated sleeping/play area of my RV in the cab overhead. One of the cats was panicked as he was stuck in the opening. The opening is very difficult to see unless you climb well forward into the sleeping area for closer examination which I did not do before my purchase. The area contains a very long area of sharp, unfinished and in some places splintered fiberglass edging that actual…

Look up ODI 11731455 at NHTSA ↗

WHILE DRIVING TO A CASINO PARKING LOT I HEARD SOMETHING SCRAPING UNDER THE VEHICLE. I PULLED OVER AND LOOKED UNDER THE COACH WHERE I DISCOVERED THAT THE HYDRAULIC SYSTEM HAD DROPPED ON THE GROUND (SEE PHOTO). AN ACCIDENT COULD HAVE OCCURRED IF THIS HAD HAPPENED AT HIGHWAY SPEEDS.*DT*JB

Look up ODI 11302898 at NHTSA ↗

TL* THE CONTACT OWNS A 2019 JAYCO GREYHAWK RV. THE CONTACT STATED THE REAR EXIT WINDOW LATCH WAS LOOSE. THE CONTACT REACHED OUT WHITE HORSE RV CENTER LOCATED AT 980 N BLACK HORSE PIKE, WILLIAMSTOWN, NJ 08094, [phone removed], AND NOTIFIED THE DEALER OF THE FAILURE. THE RV WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,017. *LN*JB

Look up ODI 11338180 at NHTSA ↗

While driving down the road at about 45mph, the driver side upper cabin window located adjacent to the eating table exploded and blew into the cabin. The window shattered and glass blew throughout the cabin area. Whatever caused this, the blast was strong enough to pull the Velcro straps holding the seat cushions blown off and the glass ripped the cushion's vinyl. If someone had been sitting at the table, they would have been extremely cut and hurt and possibly blinded. I had no warning to this situation. At first, I thought someone had sh…

Look up ODI 11755354 at NHTSA ↗

2015 RV, PURCHASED NEW IN 2014. TO THIS DAY - LESS THAN 5000.00 MILES. BROKE DOWN X3 WITHIN THE PAST YEAR (TWICE BROKEN DOWN ON THE HIGHWAY-WITH SERVICES NEEDED TO TOW TO A DEALERSHIP WHO COULD HANDLE ASSESSMENT & REPAIR OF A 31 FOOT RV). FIRST TWO TIMES-CODES RETRIEVED FROM THE COMPUTER WERE P025A AND P025B (FUEL PUMP DRIVER MODULE). CURRENTLY AT A DEALERSHIP FOR ASSESSMENT/REPAIR - SEEMS TO BE THE SAME PROBLEMS AS THE LAST TWO TIMES (VEHICLE "BUCKING" AND THEN SHUT DOWN). POWER STEARING AND POWER BREAKS BECOME MANUAL-HARDER TO NAVIGATE TO…

Look up ODI 11122805 at NHTSA ↗

THE DOG HOUSE AND FLOOR BETWEEN DRIVER AND PASSENGER IS REACHING 130 TO 140 DEGREESI BURNED MY LEFT CALF, I MULTIPLE SCLEROSIS AND MY LEG IS NUMB. I CAN'T TOLERATE GREAT I BECOME LETHARGIC. PLEASE HELP HEALTH AND SAFETY CONCERN. THE LONGER YOU DRIVE THE HOTTER THE FRONT CAB BECOMES. DOGHOUSE AND FLOOR. WE ARE AFRAID TO DRIVE OUR RV.

Look up ODI 11120612 at NHTSA ↗

Automatic transfer relay over heated creating a fire hazard. It's location under the bed prevents seeing the fire until it is burning. The switch is available for viewing. The rv carries 50 gallons of gasoline and 50 lbs propane a fire could cause collateral damage. This specific problem has not been inspected by a dealer or others. There was no danger warning. This is not an isolated incident on rv group websites there are many reports of this happening. No one to my knowledge has determined the cause of the malfunction that causes the fire ri…

Look up ODI 11493641 at NHTSA ↗

After a recent purchase of a new 2026 Jayco Greyhawk 29MV RV, I discovered my 2 cats trying to enter a previously unknown and unfinished opening adjacent to a designated sleeping/play area of my RV in the cab overhead. One of the cats was panicked as he was stuck in the opening. The opening is very difficult to see unless you climb well forward into the sleeping area for closer examination which I did not do before my purchase. The area contains a very long area of sharp, unfinished and in some places splintered fiberglass edging that actual…

Look up ODI 11731455 at NHTSA ↗

GOT RECALL FINAL REMEDY NOTICE FROM JAYCO ON SER#8H1ME0161. HOWEVER, CAMPING WORLD HAS SAID THE PARTS TO FIX THIS HAZARD ARE ON "BACK ORDER" FOR AT LEAST 12 OR MORE WEEKS SO THEY CAN'T SCHEDULE REPAIR APPOINTMENTS. WE WILL NEED TO OPERATE THIS VEHICLE SOON AND THIS DELAY CAUSES RISK THAT WE CANNOT AVOID! THUS JAYCO'S "FINAL REMEDY" IS FALSE REMEDY, THEY HAVE NOT ACTUALLY FIXED THIS POSSIBLE HAZARD.

Look up ODI 11388942 at NHTSA ↗

SERVICE ADVANCEMENT WARNING CAME ON THE MAIN GAUGE DISPLAY SCREEN WHILE I WAS DRIVING 62 MPH WITH CRUISE CONTROL SET. VEHICLE IS A 2021 JAYCO GREYHAWK 31F CLASS C MOTORHOME ON FORD E450 CHASSIS WITH 7.3L GAS V-8 AND 6-SPEED AUTOMATIC TRANSMISSION. CRUISE CONTROL STOPPED WORKING AND WOULD NOT COME BACK ON. HILL START ASSIST DISABLED MESSAGE CAME ON AFTER I HIT "OK" FOR THE SERVICE ADVANCEMENT WARNING. VEHICLE BECAME VERY DIFFICULT TO CONTROL WITH MODERATE CROSSWIND. IT WOULD SWAY SIDE TO SIDE AND MOVED ALL OVER IN THE LANE AS I STEERED AND COUNT…

Look up ODI 11395092 at NHTSA ↗

I OWN A 2013 JAYCO GREYHAWK MOTORHOME ON THE FORD E-450 CHASSIS EQUIPPED WITH MICHELIN LTX M/S TIRES, LT225-75R-16. THE ORIGINAL EQUIPMENT TIRES HAD 26,000 MILES ON THEM BEFORE PROBLEMS DEVELOPED. ON MY TRIP TO FLORIDA LAST MONTH, I HAD TO REPLACE 3 OF 6 TIRES DUE TO THE TREAD DELAMINATING COMPLETELY FROM THE TIRE AS IF THEY WERE RETREADS. THIS HAPPENED ON THE INTERSTATE TRAVELING AT 65 MPH. THE TIRES NVER LOST AIR PRESSURE, JUST THE COMPLETE TREAD. I ENDED UP REPLACING ALL 6 TIRES ON THE TRIP TO FOR OUR OWN SAFETY AND TO PREVENT FURTHER DAMAG…

Look up ODI 10936085 at NHTSA ↗

In January 2021, while traveling at approximately 65 miles per hour on a Chicago area tollroad, my motor home suddenly began violently bouncing up and down in the rear. I immediately began to slow and move to the shoulder, at which time I observed the outside left dual wheel separate from the vehicle and roll into the dividing median wall. I managed to get to the shoulder on the remaining wheel, which was also damaged beyond repair. After towing and repair, the total cost was approximately $3200. The technician was unable to determine why t…

Look up ODI 11431362 at NHTSA ↗