2006 Jayco SENECA: complaints, problems and recalls

TL*- THE CONTACT OWNS A 2006 JAYCO SENECA 34SS. THE CONTACT STATED THAT THE TRAILER HITCH BOLTS WERE CRACKED. THE DEALER INSPECTED THE VEHICLE AND REPLACED THE BOLTS. THE ROAD CONDITIONS WERE CLEAR. THERE WAS ANOTHER OCCURRENCE WHEN THE CONTACT HEARD A LOUD SCRAPING NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT NOTICED THAT THE DRIVER'S SIDE BOLT WAS MISSING, AND ANOTHER ONE WAS BENT. THE MANUFACTURER PROVIDED A NEW TRAILER HITCH TO THE CONTACT AS PART OF RECALL #07V005000. APPROXIMATELY SEVEN MONTHS LATER THE CONTACT NOTICED ANOTHER B…

Owner-reported narrative. 35,000 miles reported. Look up ODI 10186768 at NHTSA ↗

TL*THE CONTACT OWNS A 2006 JAYCO SENECA HD 35GS MOTOR HOME. THE CONTACT STATED THAT THE MAIN FRAME WELDS HAVE BEEN SPLICED, WHICH CAUSED THE VEHICLE TO DOG-TRACK. THE SLIDES ARE NOT CLOSING CORRECTLY AND DIESEL EXHAUST FUMES ARE ENTERING THE VEHICLE. THE FAILURE HAS LEFT BLACK SMUT ON THE WALLS OF THE MOTOR HOME. GENERAL MOTORS STATED THAT THEY WILL NOT TOUCH ANY COMPONENT OF THESE DEFECTS. THE CONTACT STATED THAT THE VEHICLE IS NOT UNDER WARRANTY. THE ENGINE SIZE, # OF CYLINDERS, AND POWERTRAIN WERE UNKNOWN. THE CURRENT AND FAILURE MILE…

Owner-reported narrative. 4,800 miles reported. Look up ODI 10196216 at NHTSA ↗

ENGINE SHUT DOWN AFTER SHUTDOWN WARNING ALARM ENGAGED. NO RUNNING ISSUES UP TO THIS POINT. VEHICLE TOWED TO CHEVY MEDIUM DUTY TRUCK CENTER. NOTHING FOUND WRONG. *TR

Owner-reported narrative. 9,000 miles reported. Look up ODI 10212460 at NHTSA ↗

WHILE TRAVELING DOWNHILL, OVERDRIVE OFF, JAKE BRAKE ON, BRAKE APPLIED, WHEN TRANSMISSION DOWNSHIFTED, HEARD LOUD BANG AND SAW BLACK PIECES BOUNCE OFF THE ROAD AND UP PAST DRIVER'S WINDOW. STOPPED VEHICLE AND FOUND HOLES IN FAN SHROUD, COOLANT DRAINING ON ROAD, HOLE IN FIBERGLASS HOOD, AND BLACK PLASTIC OBJECT LODGE INTO WIRE BUNDLE ON RIGHT SIDE. VEHICLE TOWED TO REPAIR SHOP WHERE FAN WAS FOUND TO HAVE SHED PLASTIC OUTER RING AND TOP SECTIONS OF BLADES. PLASTIC PIECES WERE SCATTERED THROUGHOUT THE ENGINE COMPARTMENT AND EMBEDDED IN RADIATOR, MU…

Owner-reported narrative. 24,500 miles reported. Look up ODI 10354812 at NHTSA ↗

Reported: 2007-01-04 (January 4, 2007)

ON CERTAIN MOTOR HOMES, THE DISTANCE FROM THE REAR CAP TO THE HITCH RECEIVER ENCOURAGES THE USE OF LONGER BALL MOUNTS AND/OR EXTENSIONS. THE LONGER THE BALL MOUNT AND/OR EXTENSIONS USED, THE GREATER THE FORCES THAT ARE APPLIED TO THE FASTENERS THAT ATTACH THE HITCH TO THE MAIN CHASSIS RAILS. THESE INCREASED FORCES EXCEED THE ALLOWABLE FORCES PERMITTED IN THE FASTENERS. WHEN THIS HAPPENS, THE FASTENERS MAY STRETCH, LOOSEN, OR BREAK CAUSING AN UNSAFE TOWING CONDITION OR SEPARATION OF THE HITCH FROM THE MOTOR HOME.

Consequence: THIS COULD RESULT IN SEPARATION OF THE TOWED VEHICLE FROM THE MOTOR HOME WHICH COULD RESULT IN A CRASH, INJURY OR DEATH.

Remedy: DEALERS WILL REPLACE ALL MOUNTING HARDWARE WITH HARDWARE OF A HIGHER GRADE. THE RECALL BEGAN ON JANUARY 22, 2007. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2008-05-06 (May 6, 2008)

JAYCO IS RECALLING 1,265 MY 2005-2008 SENECA '35GS' AND MY 2007-2008 GREYHAWK '33DS' AND '32SS' MOTOR HOMES. THE CONDUIT CLAMP ON THE COPPER LIQUID PROPANE (LP) TUBE FEEDING THE SLIDE-0UT IS INCORRECTLY PLACED WHICH MAY ALLOW THE COPPER TUBE TO BEND AND POSSIBLY LEAK WITH THE MOVEMENT OF THE SLIDE-OUT.

Consequence: IF THE COPPER TUBE CRACKED, PRESSURIZED LP GAS MAY ESCAPE INTO THE COMPARTMENT. THIS CONDITION, IF NOT ADDRESSED, MAY RESULT IN A FIRE, INJURY OR DEATH.

Remedy: DEALERS WILL RELOCATE THE CONDUIT CLAMP AND ADD A RUBBER GROMMET TO ALLOW ADHESION. THE RECALL BEGAN ON MAY 26, 2008. OWNERS MAY CONTACT JAYCO AT 1-574-825-5861.

Reported: 2008-05-07 (May 7, 2008)

JAYCO IS RECALLING 1,673 MY 2005-2008 SENECA MOTOR HOMES. AN ELECTRICAL SHORT CAN OCCUR IF THE BATTERY CABLES WERE NOT TUCKED INTO THE COMPARTMENT IN A MANNER THAT DOES NOT ALLOW THE CABLES TO BE PINCHED BETWEEN THE BATTERY SLIDE TRAY AND THE COMPARTMENT DOOR.

Consequence: IF THIS CONDITION IS NOT ADDRESSED, IT MAY RESULT IN A FIRE, INJURY OR DEATH.

Remedy: DEALERS WILL RELOCATE THE BATTERY CABLES TO THE REAR BATTERY AND REPOSITION A CLAMP TO PREVENT PINCHING. THE RECALL BEGAN ON MAY 26, 2008. OWNERS MAY CONTACT JAYCO AT 1-574-825-5861.

Reported: 2017-11-21 (November 21, 2017)

Jayco, Inc. (Jayco) is recalling various 2002-2016 recreational vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V746-9524.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Jayco will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Jayco customer service at 1-800-283-8267, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.