2004 Keystone SPRINTER: complaints, problems and recalls

DT: CONSUMER HAS A 2004 KEYSTONE SPRINTER 30 FOOT TRAVEL TRAILER WITH ABOUT 2500 MILES. AT ABOUT 2000 MILES TRAILER GOT A FLAT ON THE PASSENGERS REAR, WHICH WAS FROM A HOLE ON THE INTERIOR SIDEWALL. THIS HAPPENED ON APRIL 1, 2005. THEN ON JULY 12, 2005 TRAILER LOST 2 MORE TIRES WITHIN 40 MILES OF EACH OTHER ON I95 IN NORTH CAROLINA, ABOUT MILE MARKER 104 AND THEN AT 146. THE FIRST FLAT WAS A COMPLETE TREAD SEPARATION ON THE DRIVERS SIDE FRONT TIRE, WHEN THE TREAD SEPARATED IT TORE THE FINDER OFF OF TRAILER AND DONE DAMAGE TO SIDE OF TRAILER. 4…

Owner-reported narrative. 2,000 miles reported. Look up ODI 10128935 at NHTSA ↗

DT: THE CONTACT OWNS A 2004 KEYSTONE SPRINTER. THE CONTACT COMPLAINED ABOUT A TIRE PROBLEM . THERE WAS A BLOW OUT ON THE REAR PASSENGER SIDE TIRE. ALSO, REAR DRIVER'S SIDE TIRE WAS ABOUT TO BLOW OUT BECAUSE THE SIDEWALL BECAME DETACHED FROM THE REST OF THE TIRE. HE TOOK THE VEHICLE TO DEALER AND HAD ALL NEW TIRES PUT ON THE VEHICLE. HAD THE TIRE BRAND CHANGED AT HIS OWN EXPENSE. HE WENT ONLINE AND FOUND A LOT OF PEOPLE WITH THIS TRAILER THAT HAD SIMILAR TIRE PROBLEMS. *AK

Owner-reported narrative. Look up ODI 10132146 at NHTSA ↗

TWO OF OUR FOUR MISSION LOAD MAX TIRES ON OUR 2004 KEYSTONE SPRINTER 5TH WHEEL FAILED WHILE TRAVELING AT 55 MPH ON I-26 EAST ON 8/11/2005. THE RIGHT FRONT TIRE COMPLETELY SHREDDED AND THE LEFT REAR TREAD SEPARATED FROM THE SIDEWALL. LEGRAND FENDER INC OF ST GEORGE SC, STATED THE OTHER 2 TIRES WERE SHOWING SIGNS OF ABNORMAL WEAR AND TEAR. THE TIRE DEBRIS DAMAGED THE RIGHT FENDER SKIRT ON THE TRAILER. THE TIRES HAVE APPROXIMATELY 3,500 MILES ON THEM THE TRAILER WAS PURCHASED JUNE 21, 2004 FROM SUNCOAST RV IN MONROE, NC. KEYSTONE IS NOT WILLING …

Owner-reported narrative. 3,500 miles reported. Look up ODI 10133154 at NHTSA ↗

THIS WAS A CLOSE CALL INCIDENT. I HAVE ONLY OWNED THIS 2004 KEYSTONE SPRINTER ST307BHW04 TRAVEL TRAILER FOR 2 MONTHS. WHEN I GOT IT THE TIRES WERE FINE THIS PAST WEEKEND AFTER LESS THEN 500 MILES I JUST MADE IT TO OUR CAMPSITE AND FOUND CORDS HANGING OUT ON THE INSIDE EDGE OF THE REAR LEFT TIRE. WHILE I WAS CHANGING I NOTICED THAT THERE WAS DAMAGE FROM ANOTHER BLOWOUT. THE RIG IS NOT OVERLOADED AND THE TIRE PRESSURE WERE PERFECT. I FOUND A TREAD ON RV.NET TALKING ABOUT THIS EXACT PROBLEM IT IS DUE TO AL-KO KOBER MADE DURING 2003 AND 2004 THAT W…

Owner-reported narrative. Look up ODI 10199333 at NHTSA ↗

THE WEAKEST LINK I OWN A 2004 KEYSTONE SPRINTER. THIS RV UNIT HAS 30,000 TOWED MILES. THIS RV HAS THE DOUBLE EYE SUSPENSION SYSTEM. DURING MY TRAVELS IN 2007 A SET OF SHACKLE PLATES BROKE. THIS PART FAILURE HAS RESULTED IN A $1500.00 LOSS INCLUDING A BENT AXLE, SUSPENSION PARTS AND DAMAGED TIRES. YES, I AM OUT OF WARRANTY. KEYSTONE SPRINTER PROVIDED AN $800.00 COMPENSATION. THIS SUSPENSION FAILURE COULD CAUSE FATAL BODILY DAMAGE. WHEN A SHACKLE PLATE BREAKS THE AXLE CAN BECOME DETACHED FROM THE RV HOME FRAME. THE KEYSTONE SP…

Owner-reported narrative. Look up ODI 10220218 at NHTSA ↗

MY 2004 KEYSTONE SPRINTER 293 FIFTH WHEEL CAUGHT FIRE WHILE PARKED IN MY DRIVEWAY. THE CHARLOTTE, NC FIRE INVESTIGATOR SUSPECTS IT STARTED AT THE REFRIGERATOR. MY REFRIGERATOR IS PART OF THE DOMETIC RECALL. MY INSURANCE COMPANY IS IN THE PROCESS OF INVESTIGATING IF THE REFRIGERATOR DESIGN WAS THE CAUSE. THESE REFRIGERATOR ARE DANGEROUS AND DOMETIC NEEDS TO TAKE RESPONSIBILITY FOR THE LOSSES THAT OCCUR. KEYSTONE NEEDS TO BE HELD RESPONSIBLE AS WELL BECAUSE THEY ARE NOT ENSURING THEIR SUPPLIERS ARE PROVIDING SAFE COMPONENTS. *TR

Owner-reported narrative. Look up ODI 10290207 at NHTSA ↗

DOMESTIC COMPANY REGARDING REFRIGERATOR RECALL. 2004 SPRINTER TRAVEL TRAILER WAS PURCHASED NEW. *DT THE CONSUMER STATED HE NEVER RECEIVED A RECALL NOTICE IN THE MAIL. THE CONSUMER WAS ONLY BEEN ABLE TO FIND ONE DEALER WHO MADE SERVICE CALLS TO HOMES, BUT THEY CHARGED $240.00. THE CONSUMER STATED HE SHOULD NOT HAVE TO PAY THAT AMOUNT MONEY SINCE HE DID NOT CAUSE THE PROBLEM. DOMETIC STATED THEY WOULD ONLY COVER $60.00 OR THE CONSUMER WOULD HAVE TO FIND A CHEAPER DEALER.

Owner-reported narrative. Look up ODI 10313149 at NHTSA ↗

TL* THE CONTACT OWNS A 2004 KEYSTONE SPRINTER FIFTH WHEEL. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH A LADDER THAT WAS MOUNTED ON THE REAR BY THE MANUFACTURER. THE SCREWS THAT WERE USED TO MOUNT THE LATER ENDED UP PENETRATING AN ELECTRICAL WIRE. THE CONTACT NOTICED THE PROBLEM WHEN HE TOUCHED THE LADDER AND FELT A SLIGHT SHOCK. AFTER FURTHER REVIEW, THE CONTACT FOUND OUT THAT THE LADDER HAD NOT BEEN GROUNDED PER ELECTRICAL CODE. THE VEHICLE WAS TAKEN TO THE MANUFACTURER AND WAS REPAIRED. THE CONTACT SUGGESTED THAT THE MANUFACTURER S…

Owner-reported narrative. 5,000 miles reported. Look up ODI 10458961 at NHTSA ↗

Reported: 2007-03-22 (March 22, 2007)

CERTAIN FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN CERTAIN TUBING IN THE REFRIGERATOR WHICH COULD ALLOW PRESSURIZED FLAMMABLE COOLANT SOLUTION TO BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: THIS COULD RESULT IN A FIRE.

Remedy: KEYSTONE RV WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURNER HOUSING AND THERMAL FUSES FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR KEYSTONE RV AT 574-535-2100.

Reported: 2008-07-17 (July 17, 2008)

KEYSTONE IS RECALLING 161,250 MY 2004-2007 FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Remedy: KEYSTONE IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR KEYSTONE AT 1-866-425-4369.

Reported: 2017-11-22 (November 22, 2017)

Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.