2000 Mci 102DL3: complaints, problems and recalls

FIRST GROUP ALLEGES TO HAVE EXPERIENCED SEVERAL DRIVESHAFT FAILURES BEGINNING IN MARCH 2010 WHICH WERE NOT CONTAINED BY THE SAFETY LOOPS ON THE SUBJECT MCI BUSES. THEY BELIEVE THAT TWO OF THE EVENTS RESULTED IN MULTIPLE INJURIES AND FATALITIES DUE AN "UNLOCKED CONDITION" OF THE STEERABLE TAG AXLE AND A LOSS OF VEHICLE CONTROL. THE DESIGN IN QUESTION HAS BEEN IN PRODUCTION SINCE THE EARLY 1990S. A STEERABLE TAG AXLE IS USED TO INCREASE THE GVWR WHILE REDUCING THE TURNING RADIUS AND MINIMIZING THE TIRE SCRUB WHICH WOULD NORMALLY OCCUR WITH A…

Owner-reported narrative. Look up ODI 10447575 at NHTSA ↗

Reported: 2000-09-06 (September 6, 2000)

VEHICLE DESCRIPTION: MOTOR HOME CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.

Consequence: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.

Remedy: DEALERS WILL REPLACE THE ABS ECU.

Reported: 2001-12-19 (December 19, 2001)

MOTORHOMES EQUIPPED WITH DRAG LINK ASSEMBLIES CONTAINING 20-EDL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.

Consequence: IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.

Remedy: DEALERS WILL REPLACE THE DEFECTIVE DRAG LINKS. OWNER/DISTRIBUTOR NOTIFICATION BEGAN APRIL 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MCI AT 1-800-241-2941 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.

Reported: 2006-12-19 (December 19, 2006)

ON CERTAIN MOTOR COACHES, THE BOOST CONNECTOR HOUSING CAN FAIL OVER TIME, EXPOSING THE POSITIVE AND NEGATIVE TERMINALS.

Consequence: THIS COULD RESULT IN THE GROUNDING OF AN UNPROTECTED CIRCUIT AND COULD LEAD TO A THERMAL EVENT IF NOT CORRECTED.

Remedy: CUSTOMERS ARE BEING ADVISED TO REMOVE THE BOOST CONNECTOR AND DISCARD IT. CUSTOMERS WILL BE OFFERED A NEW DESIGN BOOST CONNECTOR AS AN ALTERNATIVE AT NO COST. THE RECALL BEGAN ON JANUARY 2, 2007. OWNERS MAY CONTACT MCI AT 1-800-241-2947.

Reported: 2013-10-17 (October 17, 2013)

Motor Coach Industries (MCI) is recalling certain model year 2000-2012 D, E, G and J series coaches manufactured January 2000 through June 2011 and equipped with Sure Power battery equalizers containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.

Consequence: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.

Remedy: MCI will notify owners, and Sure Power will replace the equalizers, free of charge. Owners may contact MCI at 1-847-285-2000. This campaign is MCI service bulletin 401.

Reported: 2025-12-10 (December 10, 2025)

Motor Coach Industries (MCI) is recalling certain 102DL3, 102D3, MC12PTV, E4500, D4000, 102D3ISTV, D4500, J4500, D4000ISTV, D4005, D4505, and J3500 transit buses. Please refer to MCI's recall report for specific model year information. The front door lower curb view glazing material is incorrect. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 205, "Glazing Materials."

Consequence: The incorrect window glazing material may reduce the driver's visibility, increasing the risk of a crash.

Remedy: MCI will replace the glass, free of charge. Owner notification letters were mailed February 4, 2026. Owners may contact MCI customer service at 1-800-241-2947. MCI's number for this recall is 22-005.