2005 Mci D4500: complaints, problems and recalls

Reported: 2006-04-27 (April 27, 2006)

ON CERTAIN MOTOR COACHES EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES, THE TURBOCHARGER COMPRESSORS CAN FAIL.

Consequence: A FIRE CAN RESULT SHOULD THE TURBOCHARGER FAIL.

Remedy: DETROIT DIESEL IS CONDUCTING THIS RECALL (PLEASE SEE 06E019000) AND WILL REMEDY THESE MOTOR COACHES. THE ENGINES WILL BE REPAIRED FREE OF CHARGE. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR MOTOR COACH AT 866-624-2622.

Reported: 2006-07-06 (July 6, 2006)

ON CERTAIN MOTOR COACHES EQUIPPED WITH A SLIDE SWITCH TO CONTROL THE DEFROSTER BLOWER SPEED, THERE IS A SPEED CONTROLLER FOR EACH OF THE TWO DEFROSTER FAN MOTORS. THE SPEED CONTROLLER MAY FAIL CAUSING THE FAN MOTOR TO OPERATE CONTINUOUSLY IN THE "HIGH" SPEED MODE, AND THE CARRIER SLIDE SWITCH MAY FAIL TO REDUCE OR OTHERWISE CONTROL THE FAN MOTOR SPEED.

Consequence: THE SPEED CONTROLLER MAY OVERHEAT AND RESULT IN A THERMAL EVEN, SUCH AS SMOKING OR POSSIBLE FIRE.

Remedy: DEALERS WILL REPLACE THE DEFROSTER SPEED CONTROLLER FREE OF CHARGE. THE RECALL BEGAN ON JULY 20, 2006. OWNERS MAY CONTACT MOTOR COACH AT 1-800-241-2947.

Reported: 2006-12-15 (December 15, 2006)

ON CERTAIN D SERIES MOTOR COACHES, THERE COULD BE A POSSIBLE INTERFERENCE BETWEEN THE DRIVE SHAFT MOUNTING HARDWARE AND THE TAG AXLE STRUCTURE.

Consequence: THE BEARING CAP BOLTS COULD SHEAR, FREEING THE BEARINGS, AND POSSIBLY RELEASING THE DRIVE SHAFT, INCREASING THE RISK OF A CRASH.

Remedy: SHIMS WILL BE INSTALLED ABOVE THE TAG AXLE AIR SPRING MOUNTING BRACKETS TO LIMIT THE SUSPENSION TRAVEL. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2007. OWNERS MAY CONTACT MCI AT 1-800-241-2947.

Reported: 2006-12-19 (December 19, 2006)

ON CERTAIN MOTOR COACHES, THE BOOST CONNECTOR HOUSING CAN FAIL OVER TIME, EXPOSING THE POSITIVE AND NEGATIVE TERMINALS.

Consequence: THIS COULD RESULT IN THE GROUNDING OF AN UNPROTECTED CIRCUIT AND COULD LEAD TO A THERMAL EVENT IF NOT CORRECTED.

Remedy: CUSTOMERS ARE BEING ADVISED TO REMOVE THE BOOST CONNECTOR AND DISCARD IT. CUSTOMERS WILL BE OFFERED A NEW DESIGN BOOST CONNECTOR AS AN ALTERNATIVE AT NO COST. THE RECALL BEGAN ON JANUARY 2, 2007. OWNERS MAY CONTACT MCI AT 1-800-241-2947.

Reported: 2009-02-03 (February 3, 2009)

MCI IS RECALLING 103 MY 2005-2008 D4500 AND D4505 COACHES EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES AND A ZF TRANSMISSION. CUSTOMERS MAY EXPERIENCE A POSSIBLE INTERFERENCE BETWEEN THE DRIVE SHAFT U-JOINT BEARING CAP BOLTS AND THE TAG AXLE CENTER BEAM ASSEMBLY.

Consequence: INTERFERENCE BETWEEN THE BEARING CAP BOLTS AND THE AXLE CENTER BEAM ASSEMBLY COULD CAUSE THE BEARING CAP BOLTS TO SHEAR, FREEING THE BEARINGS AND POSSIBLY RELEASING THE DRIVE SHAFT, INCREASING THE RISK OF VEHICLE DAMAGE OR A CRASH.

Remedy: DEALERS WILL INSTALL A TAG AXLE SUSPENSION SPACER KIT AND AN SPL250 DRIVESHAFT RETROFIT KIT TO LIMIT THE SUSPENSION TRAVEL AND REDUCE THE SWING DIAMETER OF THE DRIVESHAFT THEREBY INCREASING THE CLEARANCE AND ELIMINATING ANY POSSIBLE INTERFERENCE. THE RECALL BEGAN ON FEBRUARY 25, 2009. OWNERS MAY CONTACT MCI AT 1800-241-2947.

Reported: 2009-11-03 (November 3, 2009)

MCI IS RECALLING CERTAIN MODEL YEAR 2002-2009 D SERIES COACHES, EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

Consequence: A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.

Remedy: MCI WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR MCI CUSTOMER SERVICE AT 1-800-241-2947.

Reported: 2009-11-18 (November 18, 2009)

MCI IS RECALLING CERTAIN MODEL YEAR 2005-2008 D4000, MODEL YEAR 2005-2009 D4500 AND D4505 TRANSIT BUSES, EQUIPPED WITH CATERPILLAR C13 ENGINE AND 50DN ALTERNATOR. THE ALTERNATOR CABLE MAY BECOME LOOSE WITHIN THE CABLE CLAMP, WHICH COULD RESULT IN CHAFING OF THE ALTERNATOR CABLE AND POSSIBLE ARCING OF THE CABLE WIRES.

Consequence: THIS COULD RESULT IN A FIRE.

Remedy: MCI WILL NOTIFY OWNERS AND REPLACE THE ALTERNATOR CABLE CLAMP AND RELATED HARDWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 30, 2009. OWNERS MAY CONTACT MCI CUSTOMER SERVICE AT 1-800-241-2947.

Reported: 2010-03-09 (March 9, 2010)

MCI IS RECALLING CERTAIN MODEL YEAR 2000-2009 D4000, MODEL YEAR 2001-2010 D4500 AND MODEL YEAR 2005-2007 D4505 COACHES EQUIPPED WITH RICON WHEELCHAIR LIFT (WCL) AND A CASSETTE-TYPE WCL COMPARTMENT DOOR. THE WHEELCHAIR LIFT MAY BECOME DISENGAGED FROM A LOCKED POSITION AND SLIDE UNRESTRAINED ON ITS ROLLERS IN THE STORAGE STRUCTURE, POTENTIALLY BREAKING THROUGH THE CASSETTE DOOR AND EXTENDING BEYOND THE OUTSIDE OF THE DOOR WHEN THE COACH IS IN MOTION, PARTICULARLY WHEN THE COACH IS MAKING A LEFT TURN.

Consequence: IF THE COACH IS IN MOTION, POTENTIAL INJURY TO PERSONS AND/OR DAMAGE TO OTHER VEHICLES OR PROPERTY COULD OCCUR.

Remedy: MCI WILL PROVIDE PARTS AND LABOR TO INSTALL FREE OF CHARGE TO CUSTOMERS, A RICON DESIGNED RETROFIT KIT THAT INCLUDES A SPRING LOADED LOCK MECHANISM. THE SAFETY RECALL BEGAN ON MARCH 31, 2010. OWNERS MAY CONTACT MCI CUSTOMER SERVICE LINE AT 1-800-241-2947.

Reported: 2013-10-17 (October 17, 2013)

Motor Coach Industries (MCI) is recalling certain model year 2000-2012 D, E, G and J series coaches manufactured January 2000 through June 2011 and equipped with Sure Power battery equalizers containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.

Consequence: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.

Remedy: MCI will notify owners, and Sure Power will replace the equalizers, free of charge. Owners may contact MCI at 1-847-285-2000. This campaign is MCI service bulletin 401.

Reported: 2025-12-10 (December 10, 2025)

Motor Coach Industries (MCI) is recalling certain 102DL3, 102D3, MC12PTV, E4500, D4000, 102D3ISTV, D4500, J4500, D4000ISTV, D4005, D4505, and J3500 transit buses. Please refer to MCI's recall report for specific model year information. The front door lower curb view glazing material is incorrect. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 205, "Glazing Materials."

Consequence: The incorrect window glazing material may reduce the driver's visibility, increasing the risk of a crash.

Remedy: MCI will replace the glass, free of charge. Owner notification letters were mailed February 4, 2026. Owners may contact MCI customer service at 1-800-241-2947. MCI's number for this recall is 22-005.