2021 Mini COOPER S CLUBMAN: complaints, problems and recalls

ENGINE TIMING CHAIN BROKE WHILE DRIVING BECAUSE OF A FAULTY PLASTIC TENSIONER PIECE BRAKING. THIS ISSUE HAS SURFACED REPEATEDLY GLOBALLY, BUT NO RECALL ISSUED. THIS NEEDS TO BE RECALLED, IT IS CLEARLY A SAFETY ISSUE AND BECAUSE OF ONE SMALL LITTLE PLASTIC FAULTY PART COST ME CLOSE TO $5000. MINI/BMW NORTH AMERICA DOES NOT ACKNOWLEDGE THIS ISSUE NOR WANTS TO REIMBURSE ME FOR THE EXPENSES INCURRED TO KEEP DRIVING SAFELY. *TR

Look up ODI 10492944 at NHTSA ↗

CAR RATTLING AND SOUNDING LIKE A DIESEL FOR OVER A YEAR. DEALER SERVICE ADVISED TO CHECK OIL AND BE SURE OIL LEVEL WAS PROPER. NOVEMBER 2011, ALL OIL LEAKED OUT OF CAR ONTO GARAGE FLOOR. CAR TOWED TO DEALER SERVICE. THEY EXPLAINED OIL LEAKED BECAUSE A "PLUG" HAD COME LOOSE. DEALER REPLACED SEALING RING AND ADJUSTED THE CHAIN. I EXPRESSED CONCERN ABOUT THE ENGINE AND REQUESTED A DIAGNOSTIC BE DONE. SERVICE MANAGER REPLIED THE CAR WAS ALREADY PUT TOGETHER AND I WOULD NEED TO MAKE ANOTHER APPOINTMENT. CAR CONTINUED TO RATTLE LOUDLY. MAD…

Look up ODI 10461109 at NHTSA ↗

MY 2010 COOPER CLUBMAN S RECENTLY HAD ITS TIMING CHAIN SUDDENLY AND WITHOUT WARNING FAIL. THE VEHICLE HAS BEEN MAINTAINED ACCORDING TO MINI'S SUGGESTED MAINTENANCE SCHEDULE SINCE I FIRST PURCHASED IT. IN FACT, I WAS ON MY WAY TO A SCHEDULED SERVICING OF THE VEHICLE WHEN THE MOTOR FAILED. IT STARTED WITH A LOUD RATTLING NOISE FROM THE MOTOR, WHICH MADE THE CAR INTERMITTENTLY SOUND LIKE EITHER A DIESEL ENGINE OR A CHAINSAW SLICING THROUGH SOMETHING. THEN AS I SLOWED DOWN IN TRAFFIC, THE RPMS ON THE CAR BEGAN TO SPASTICALLY JUMP. I WAS FORTUNATE T…

Look up ODI 10598272 at NHTSA ↗

MY VEHICLE WAS PARKED IN MY GARAGE FOR APPROXIMATELY ONE HOUR, AFTER DRIVING IT FOR THREE MILES IN THE RAIN. THE ENGINE SPONTANEOUSLY CAUGHT ON FIRE. *TR

Look up ODI 10664381 at NHTSA ↗

THE CHECK ENGINE LIGHT CAME ON AT 55,005 MILES WHILE WE WERE DRIVING. WE TOOK IT TO BE SERVICED AND WERE TOLD THAT THE THERMOSTAT HOUSING /THERMOSTAT SENSOR NEEDED TO BE REPLACED BECAUSE IT WAS STUCK IN THE OPEN POSITION. THIS CAUSED THE CHECK ENGINE LIGHT TO BE ILLUMINATED. THEY MENTIONED THAT THERE WAS A RECALL FOR THIS PART DATED 8/5/2016 ON THE SAME MAKE, MODEL AND YEAR, BUT OUR VIN WAS NOT INCLUDED IN THE RECALL. HOW COULD THAT BE? THE CAR IS EXPERIENCING THE EXACT SAME ISSUE DESCRIBED IN THE RECALL. I WOULD LIKE TO HAVE SOMEONE CONTACT ME…

Look up ODI 11128556 at NHTSA ↗

I CAME HOME FROM WORK AND PARKED THE CAR IN HIS NORMAL PARKING SPACE ON THE BLACK TOP. I TURNED OFF THE CAR, PUT THE VEHICLE IN GEAR WITH THE PARKING BRAKE AND LOCKED THE DOOR. A MINUTE LATER, THE VEHICLE WAS ON FIRE. THE FIRE DEPT REPORT WAS UNABLE TO DETERMINE IF THERE WAS A KEY LEFT IN THE IGNITION.

Look up ODI 10458361 at NHTSA ↗

AFTER DRIVING TO WORK FOR 30 MINUTES, I PARKED MY CAR. I THOUGHT I SMELLED SOMETHING AS I WALKED AWAY, SO I STOPPED AN LOOKED, BUT I DID NOT SEE ANYTHING. FIVE MINUTES AFTER WALKING INTO MY BUILDING, SOMEONE TOLD ME MY CAR WAS ON FIRE. THE FIRST WITNESS TO SEE SOMETHING (A CO-WORKER) SAID HE SAW SOMETHING ON FIRE DROP FROM THE BOTTOM OF THE CAR. WHEN I RAN OUTSIDE, THE CAR WAS PUTTING OFF A SIGNIFICANT AMOUNT OF SMOKE. WE TRIED TO USE A FIRE EXTINGUISHER, TO NO END, AND WITHIN MINUTES WE WERE SEEING FLAMES. FIVE MINUTES LATER, THE FRONT OF THE …

Look up ODI 10430619 at NHTSA ↗

FIRST INCIDENT: ON A HOT DAY, VEHICLE WAS PARKED, DRIVERS SEAT OCCUPIED AND RECLINED. AIR BAG LIGHT ILLUMINATES UPON RESTART OF VEHICLE. FAULT WAS RESET BY DEALER WITH NO EXPLANATION. SECOND TIME SAME SITUATION; HOT DAY, PARKED, DRIVER SEAT OCCUPIED AND RECLINED, AIRBAG LIGHT ILLUMINATES UPON RESTART. DEALER REPLACED AIR BAG DUE TO ELECTRICAL CABLE FOR DRIVERS SEAT AIRBAG BEING NEARLY CUT IN TWO BY SHARP EDGE OF SEAT FRAME. *TR

Look up ODI 10564011 at NHTSA ↗

MY VEHICLE WAS PARKED IN MY GARAGE FOR APPROXIMATELY ONE HOUR, AFTER DRIVING IT FOR THREE MILES IN THE RAIN. THE ENGINE SPONTANEOUSLY CAUGHT ON FIRE. *TR

Look up ODI 10664381 at NHTSA ↗

AIR BAG LIGHT GOES OFF WITH CODE 93B1 PASSENGER HEAD AIRBAG NOT PRESENT. MINI KNOWS THIS IS AN ISSUE AS IT HAS ISSUED A TECHNICAL SERVICE BULLETIN FOR THIS ISSUE. THE TSB NUMBER IS SI-M-65-10-08. THIS IS A SERIOUS ISSUE AND SHOULD BE RECALLED. *TR

Look up ODI 10520269 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 MINI COOPER S CLUBMAN. THE CONTACT STATED THAT WHEN SOMEONE SITS IN THE PASSENGER SEAT THE YELLOW AIR BAG LIGHT DOES NOT SHUT OFF. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD SINCE THERE WAS NO ERROR CODE THERE WAS NOTHING THAT COULD BE DONE TO REPAIR THE FAILURE. THE CONTACT SAID THAT THE MANUAL STATED IF THE FAILURE OCCURRED THE AIR BAG MAY NOT DEPLOY. THE CONTACT WAS CONCERNED ABOUT THE SAFETY ISSUE. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 18,600. UPDATED 03/14/12*LJ

Look up ODI 10447911 at NHTSA ↗

FIRST INCIDENT: ON A HOT DAY, VEHICLE WAS PARKED, DRIVERS SEAT OCCUPIED AND RECLINED. AIR BAG LIGHT ILLUMINATES UPON RESTART OF VEHICLE. FAULT WAS RESET BY DEALER WITH NO EXPLANATION. SECOND TIME SAME SITUATION; HOT DAY, PARKED, DRIVER SEAT OCCUPIED AND RECLINED, AIRBAG LIGHT ILLUMINATES UPON RESTART. DEALER REPLACED AIR BAG DUE TO ELECTRICAL CABLE FOR DRIVERS SEAT AIRBAG BEING NEARLY CUT IN TWO BY SHARP EDGE OF SEAT FRAME. *TR

Look up ODI 10564011 at NHTSA ↗

I'VE HAD MY 2011 MINI CLUBMAN S FOR THREE YEARS NOW AND HAD SPENT THOUSANDS OF DOLLARS ALREADY. I'VE REPLACED THE WATER PUMP, DSC LIGHTS, AND OTHER THINGS. THE INDICATOR LIGHTS SEEM TO COME ON ALL THE TIME AND THE MECHANICS DON'T ALWAYS HAVE THE IDEA ON WHAT'S CAUSING THESE PROBLEMS.

Look up ODI 10895739 at NHTSA ↗

THE TRANSMISSION IN MY CAR IS GOING OUT AT ONLY 53 THOUSAND MILES... EVERY TIME I GOT TO TURN OFF MY CAR THE LIGHT POPS ON SAYING THEIR IS A ISSUE WITH MY TRANSMISSION..IT ALSO TAKES ME TURNING OFF MY CAR AND BACK ON FOR IT TO GET UN STUCK OUT OF PARK.. IM GETTING FED UP AND FEAR THAT SOMETHING WORSE WILL HAPPEN WITH MY CAR WHEN MY CHILD OR HUSBAND IS IN THE CAR WITH ME.. I'VE ONLY HAD THIS CAR A YEAR AND ALREADY PUT $1200 INTO A WATERPUMP AND THERMOSTAT WITH HOUSING ... AND THAT WAS HARDSHIP ON ME. *TR

Look up ODI 10478895 at NHTSA ↗

2009 MINI CLUBMAN S... TIMING CHAIN NEEDS REPLACED AT 51000. 1000 MILES OUT OF WARRANTY. MINI WILL NOT TAKE RESPONSIBILITY. THIS IS POOR ENGINEERING AND EVEN POORER LACK OF ACCOUNTABILITY FROM MINI FOR A KNOWN, DOCUMENTED, AND VERY FREQUENT PROBLEM. *TR

Look up ODI 10449005 at NHTSA ↗

MY FATHER PURCHASED A 2010 MINI COOPER CLUBMAN S IN LATE 2009. HE HAS MAINTAINED PROPER MAINTENANCE ON THE CAR SINCE DAY ONE. IN FEBRUARY 2014 HE GAVE THE CAR TO ME. THE CAR ONLY HAS 57,000 MILES ON IT AND WE NOTICED THAT THE TRANSMISSION WAS SLIPPING AND WE TOOK IT TO MINI OF LOUISVILLE. THEY HAD THE CAR FOR OVER 1 MONTH TO REPLACE THE VALVE BODY BECAUSE THE PART WAS ON NATIONAL BACKORDER. WE WERE ADVISED THAT IF WE CONTINUED TO DRIVE THE VEHICLE IT COULD CAUSE THE TRANSMISSION TO FAIL EVEN WHILE DRIVING. IF IT IS ON NATIONAL BACKORDER, AND FO…

Look up ODI 10574970 at NHTSA ↗

MY 2008 MINI CLUBMAN S WAS PARKED AT THE POST OFFICE, WHEN SOMEONE CAME IN TO TELL ME MY CAR WAS ON FIRE. I RAN OUTSIDE TO FIND SMOKE POURING FROM UNDER THE HOOD, AND CALLED THE FIRE DEPARTMENT. I RAN BACK INSIDE TO GET A FIRE EXTINGUISHER, AND CAME BACK OUT TO FIND FLAMES COMING OUT FROM UNDER THE HOOD, ALONG WITH THE SMOKE. I EMPTIED THE EXTINGUISHER, BUT THE FLAMES KEPT COMING. BY THE TIME THE FIRE DEPARTMENT ARRIVED, ONLY FIVE MINUTES LATER, THE FLAMES WERE 12 FEET HIGH, AND THE CAR WAS TOTALED. I HAVE FOUND REPORTS OF AT LEAST 30 OTHER S…

Look up ODI 10310677 at NHTSA ↗

I PARKED MY 2009 MINI CLUBMAN AFTER DRIVING ABOUT 10 MILES TO THE GROCERY STORE ROUND TRIP AND UNLOADED GROCERIES, WENT BACK OUT TO THE CAR AND IT WAS SMOKING WHITE SMOKE. FLAMES STARTED SHOOTING UP FROM THE ENGINE OVER THE WINDSHIELD AND IT PROGRESSED FROM THERE. THE SMOKE TURNED BLACK ALL WINDOWS WERE BLOWN OUT, FRONT TIRES MELTED AND BLOWN AND THE CAR WAS DECLARED AN OBVIOUS TOTAL LOSS. IT CAUGHT OUR HOME ON FIRE AND HAS CAUSED MORE THAN $50,000 WORTH OF DAMAGE. PLEASE CORRECT THIS PROBLEM. *TR

Look up ODI 10346542 at NHTSA ↗

NHTSA ID NUMBER: 10043724 THERE HAS BEEN A SERVICE BULLETIN BUT NOT A RECALL ON THE TURBO HEAT SHIELD. WITH THE LACK OF THE HEAT SHIELD THERE COULD BE ENGINE FAILURE BY A LACK OF OIL SUPPLY. I PAID OUT OF POCKET FOR THE ALL THE REPAIRS CAUSED BY THE LACK OF THE HEAT SHIELD TOTALING $636.37, BUT MINI WILL NOT ACCEPT ANY RESPONSIBILITY FOR THESE COSTS AS THIS IS A SERVICE BULLETIN NOT A RECALL (THOUGH MY DEALER HAD LEFT A MESSAGE STATING THAT IT WAS AN OPEN RECALL). THIS SHOULD BE AN OPEN RECALL AS THIS IS A SAFETY ISSUE THAT SHOULD BE ADDR…

Look up ODI 10551000 at NHTSA ↗

MY 2010 COOPER CLUBMAN S RECENTLY HAD ITS TIMING CHAIN SUDDENLY AND WITHOUT WARNING FAIL. THE VEHICLE HAS BEEN MAINTAINED ACCORDING TO MINI'S SUGGESTED MAINTENANCE SCHEDULE SINCE I FIRST PURCHASED IT. IN FACT, I WAS ON MY WAY TO A SCHEDULED SERVICING OF THE VEHICLE WHEN THE MOTOR FAILED. IT STARTED WITH A LOUD RATTLING NOISE FROM THE MOTOR, WHICH MADE THE CAR INTERMITTENTLY SOUND LIKE EITHER A DIESEL ENGINE OR A CHAINSAW SLICING THROUGH SOMETHING. THEN AS I SLOWED DOWN IN TRAFFIC, THE RPMS ON THE CAR BEGAN TO SPASTICALLY JUMP. I WAS FORTUNATE T…

Look up ODI 10598272 at NHTSA ↗

I WAS TRYING TO MAKE A RIGHT TURN GOING ON A 35MPH STREET AND MY CAR DID NOT TURN RIGHT WHEN I TRIED TO GO INTO A STREET AND IT WENT STRAIGHT INTO A TREE AND MY CAR WAS ALMOST OR MAY BE TOTALED BECAUSE OF THIS. I BELIEVE THE STEERING WHEEL WAS FAULTY. I COULD HAVE HIT A CONCRETE WALL BUT THE TREE I RAN INTO SAVED MY LIFE. I AM NOT SURE IF THERE HAS BEEN OTHER REPORTS FOR THIS LATELY BUT I WANT TO BE SAFE AND IF THE STEERING WHEEL DID NOT FUNCTION RIGHT THEN I BELIEVE THERE SHOULD BE A RECALL FOR THIS.

Look up ODI 11104507 at NHTSA ↗

DRIVING ON THE INTERSTATE APPROXIMATELY 70MPH, SUDDENLY VEHICLE BEGAN RUMBLING. IMMEDIATELY CHECK ENGINE LIGHT FLASHED AND THE CAR IMMEDIATELY STOPPED ACCELERATING. THE MOTOR KEPT RUNNING BUT WITH A CONTINUOUS RUMBLING AND ACCELERATOR WAS COMPLETELY INACTIVE. CAR WILL START BUT NO POWER OUTPUT, PRESSING ON THE GAS IS FUTILE.

Look up ODI 10724854 at NHTSA ↗

THE HIGH PRESSURE FUEL PUMP (HPFP) FAILED AT 88400 MILES AND I HAD TO PAY OVER $1300 TO HAVE IT REPLACED. MINI COOPER ISSUED AN EXTENDED WARRANTY ON SELECT 2007-2009 MODELS TO REPLACE THE HPFP AT NO CHARGE BECAUSE OF THIS HPFP PROBLEM IN SO MANY OF THEIR VEHICLES WITH THE R14 ENGINE. OUR VEHICLE WAS MANUFACTURED IN SEPTEMBER OF 2009. MINI COOPER IS SAYING THAT OUR VEHICLE IS NOT COVERED BY THEIR WARRANTY. I BELIEVE THIS FUEL PUMP WAS ONE OF THE FAULTY UNITS THAT PROMPTED THE REQUIREMENT AND APPLICATION OF THE WARRANTY EXTENSION AND THAT MINI S…

Look up ODI 10886280 at NHTSA ↗

When I bought the car, John, a sales representative, promised me that he would have the car inspected by a mechanic before finalizing the paperwork, addressing issues with the tire pressure monitor, tail light sensor, and license plate light. However, the mechanic couldn't fix these issues, and Mike, the owner, directed me to his “personal mechanic” in San Bruno. After multiple reschedules from Mike, the car began to display an engine malfunction error. I informed Mike, and he advised me to mention the issue to the mechanic when I brought the c…

Look up ODI 11638064 at NHTSA ↗

6/21/2018, MY 2010 MINI COOPER CLUBMAN S DEVELOPED SERIOUS DEFECTS. I DROVE MY CAR ON THE LEFTMOST LANE OF THREE-LANE BOSTON TURNPIKE. CLOSE TO A TRAFFIC LIGHT, I BRAKED TO DECELERATE VEHICLE BUT THE ENGINE SUDDENLY DIED WITHOUT WARNING, WHILE CAR WAS IN MOTION. BOTH BATTERY AND STARTER WORKED. I TRIED MULTIPLE TIMES TO RESTART THE ENGINE IN FAILURE. I BLOCKED TRAFFIC DURING RUSH-HOUR. SEVERAL CARS TOOK ACROSS ROAD CURB AND PASSED TO MY LEFT. IT MADE ME AND MY SON IN DANGEROUS SITUATIONS. UNTIL A TRUCK DRIVER CAME TO HELP ME TO PUSH MY CAR OFF …

Look up ODI 11256102 at NHTSA ↗

I'VE HAD MY 2011 MINI CLUBMAN S FOR THREE YEARS NOW AND HAD SPENT THOUSANDS OF DOLLARS ALREADY. I'VE REPLACED THE WATER PUMP, DSC LIGHTS, AND OTHER THINGS. THE INDICATOR LIGHTS SEEM TO COME ON ALL THE TIME AND THE MECHANICS DON'T ALWAYS HAVE THE IDEA ON WHAT'S CAUSING THESE PROBLEMS.

Look up ODI 10895739 at NHTSA ↗