| Electrical System:Ignition:Module | 00.0%No examples available for this selection. | 4134.7%ODI 10036842 · 63,000 miFAILURE OF DIRECT IGNITION CASSETTE. VEHICLE (1999 SAAB 9-5 SE) STOPS RUNNING IN TRAFFIC AND CANNOT BE RESTARTED. BASED ON REPORTS IN SAABNET.COM, THIS IS A RELATIVELY COMMON FAILURE. *AK Look up ODI 10036842 at NHTSA ↗ | 4140.2%ODI 10052795 · 38,000 mi2000 SAAB 9-5 SEDAN SUDDENLY STALLED OUT AT 60 MPH AS 2 TRACKER TRAILERS NEARLY COLLIDED INTO MY VEHICLE. NO SHOULDERS ON THIS HIGHWAY LEAVING MY FAMILY IN A HORRIBLY DANGEROUS PLACE. VERMONT STATE POLICE RESPONDED TO PROVIDE PROTECTION. THE CASSETTE WHICH HOUSES THE IGNITION FAILED. BOTH THE DEALER AND OTHER OWNERS HAVE EXPRESSED THAT THIS OCCURS AL THE TIME WITH SAABS AND THERE IS NO WAY TO PREVENT THESE CARS FROM STALLING AT ANY TIME!*AK Look up ODI 10052795 at NHTSA ↗ | 2530.5%ODI 10025942 · 23,400 miTHE ENGINE ON OUR 2001 SAAB 9.5 WAGON COMPLETELY SHUT DOWN AS WE EXITED I-10 NORTH OF SAN ANTONIO TEXAS. THE VEHICLE WAS AT A SPEED OF 65 MPH AND THE ENGINE JUST QUIT. WE WERE ABLE TO STOP THE CAR AT THE EXITS INTERSECTION BECAUSE OF ITS LENGTH OF ABOUT 1/4 MILE. THERE WAS NO WARNING, JUST NO ENGINE AND NO RESTART. THE DIRECT IGNITION CASSETTE WAS REPLACED. *AK Look up ODI 10025942 at NHTSA ↗ | 1528.3%ODI 10011398 · 25,000 miTHE VEHICLE STALLED WITHOUT WARNING, THE DEALER DIAGNOSED THE DIRECT IGNITION CASSETTE FAILED. *JB SCC Look up ODI 10011398 at NHTSA ↗ | 510.6%ODI 10151234 · 100,424 miCHECK ENGINE LIGHT ON 2003 SAAB 9-5 AERO DIAGNOSED AS FAILING IGNITION CASSETTE WHICH IS THE SAME FAULTY PART FOR RECALL ON THE 2000-2002 CARS ONLY. A COMPLETE FAILURE WHILE DRIVING WOULD HAVE CAUSED THE ENGINE TO TOTALLY SHUTDOWN. THIS PART WAS REPLACED AT MY COST, BUT THE ORIGINAL PART NUMBER WAS INSTALLED VS. THE NEWER UPGRADED VERSION TO HOPEFULLY PREVENT FUTURE FAILURES. RE: CAMPAIGN ID# 05V399000. SHOULDN'T THE FAULTY "ORIGINAL" PART BE PULLED FROM DEALER STOCK AND WHY HAS THE 2003 MODEL YEAR AND OTHER YEARS BEEN EXCLUDED SINCE THE FAULTY… Look up ODI 10151234 at NHTSA ↗ | 210.5%ODI 10129885 · 2,500 miON NUMEROUS OCCASIONS, OUR 2004 SAAB 95 WOULD NOT START. LATER IT WOULD START. SAAB REFUSES TO ACKNOWLEDGE THERE IS A PROBLEM. NOTHING HAS BEEN DONE. THERE HAVE BEEN 5 INSTANCES BEGINNING IN MAY OF 2004. Look up ODI 10129885 at NHTSA ↗ | 19.1%ODI 10424440 · 95,000 miTHE IGNITION CASSETTE CRACKS CAUSING IGNITION PROBLEMS, STALLING, ACCELERATION PROBLEMS. IT MAKES IT UNPREDICTABLE. THIS IS THE SAME PROBLEM AS THE PREVIOUS RECALL PASTED BELOW. WHY DOES IT NOT COVER THESE OTHER MODEL YEARS? NHTSA CAMPAIGN NUMBER: 06V410000 WWW.NHTSA.DOT.GOV MANUFACTURER SAAB CARS USA, INC. RECALL DATE: OCT 23, 2006 POTENTIAL NUMBER OF UNITS AFFECTED: 5078 DESCRIPTION ELECTRICAL SYSTEM:IGNITION:MODULE SUMMARY CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEA… Look up ODI 10424440 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Electrical System | 00.0%No examples available for this selection. | 2319.5%ODI 10033346 · 78,000 mi2ND TIME THE SID DISPLAY HAS FAILED, AFTER RESEARCHING, THIS IS A KNOWN AND WIDE SPREAD PROBLEM WITH SAAB SID DISPLAYS FOR MANY YEARS. HAVE CONTACTED SAAB AND SO FAR WILL NOT REPLACE. CAR IS NOT UNDER WARRENTY, BUT CAN'T GET ANY INFORMATION FROM CAR ABOUT WARNINGS, ERRORS, TIME, DATE, RADIO STATION. *AK Look up ODI 10033346 at NHTSA ↗ | 109.8%ODI 10052795 · 38,000 mi2000 SAAB 9-5 SEDAN SUDDENLY STALLED OUT AT 60 MPH AS 2 TRACKER TRAILERS NEARLY COLLIDED INTO MY VEHICLE. NO SHOULDERS ON THIS HIGHWAY LEAVING MY FAMILY IN A HORRIBLY DANGEROUS PLACE. VERMONT STATE POLICE RESPONDED TO PROVIDE PROTECTION. THE CASSETTE WHICH HOUSES THE IGNITION FAILED. BOTH THE DEALER AND OTHER OWNERS HAVE EXPRESSED THAT THIS OCCURS AL THE TIME WITH SAABS AND THERE IS NO WAY TO PREVENT THESE CARS FROM STALLING AT ANY TIME!*AK Look up ODI 10052795 at NHTSA ↗ | 2024.4%ODI 10028525 · 21,000 miI WAS DRIVING ON THE HIGHWAY AND BEGAN EXITING WHEN THE SAAB COMPLETELY DIED. NO WARNING..ALL LIGHTS CAME ON AND THE CAR HAD NO POWER. I COASTED DOWN THE RAMP. WHAT WOULD HAVE HAPPENED HAD I BEEN IN THE LEFT LANE? SAAB QUICKLY DIAGNOSED THIS AS A SHORTED OUT DIRECT IGNITION CASSETTE. THEY REPAIRED IT RETURNED THE CAR. IT NEEDED TO GO BACK AS IT HAD NO POWER. THE CASSETTE'S FAILURE DESTROYED THE CATALYTIC CONVERTER AS WELL. I HAVE NOW HEARD OF THIS INCIDENT THREE TIMES ON 2001 SAAB 9-5'S. WHERE IS THE RECALL?*AK Look up ODI 10028525 at NHTSA ↗ | 1732.1%ODI 10011398 · 25,000 miTHE VEHICLE STALLED WITHOUT WARNING, THE DEALER DIAGNOSED THE DIRECT IGNITION CASSETTE FAILED. *JB SCC Look up ODI 10011398 at NHTSA ↗ | 2042.6%ODI 10097342 · 3,000 miTHE VEHICLE STALLED ON 4 SEPARATE OCCASIONS FROM VARIOUS SPEEDS OF 25 MPH OR MORE WHILE DRIVING. THE VEHICLE HAS BEEN TO THE DEALER ON 3 SEPARATE OCCASIONS. THE DEALER HAS CLEANED AND TIGHTENED THE BATTERY CABLES, THE FIRST TIME, THEY REPLACED THE CRANK SENSOR, T-7 AND THE IGNITION SWITCH, THE SECOND TIME AND THE THIRD TIME, THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *JB THE ECM WAS REPLACED BUT THE VEHICLE STALLED AGAIN, THE CUP HOLDER CRACK AND HAD BROKEN, THE BATTERY CABLES WERE LOOSE AND DIRTY, THE TRANSMISSION DID NOT SHIFT PROPERLY … Look up ODI 10097342 at NHTSA ↗ | 842.1%ODI 10155724 · 15,000 miMY WIFE WAS DRIVING OUR 2004 SAAB 9-5 WAGON AT OR AROUND 35 MPH WHEN THE CAR, SUDDENLY AND WITHOUT WARNING, LOST ITS ELECTRICAL POWER. SHE WAS UNABLE TO STEER, BRAKE OR CONTROL THE VEHICLE IN ANYWAY. ALL OF THE LIGHTS WERE ILLUMINATED ON THE DRIVER'S PANEL. LUCKILY, THERE WAS NO ON-COMING TRAFFIC OR ANY VEHICLE FOLLOWING BEHIND HER BECAUSE SHE WAS APPROACHING A CURVE IN THE ROAD AT THE TIME THE CAR FAILED. SHE COASTED STRAIGHT AHEAD, THROUGH THE CURVE, TO A STOP. SHE TURNED THE CAR OFF, THEN RESTARTED THE CAR. WE CALLED THE DEALERSHIP TH… Look up ODI 10155724 at NHTSA ↗ | 19.1%ODI 10458300 · 154,000 miRUNNING LIGHTS WILL NOT TURN OFF, EVEN AFTER THE CAR IS STOPPED AND THE KEY IS OUT OF THE IGNITION, CAUSING THE BATTERY TO RUN DOWN. *JS Look up ODI 10458300 at NHTSA ↗ | 28.7%ODI 10510972UNKNOWN- DIRECT IGNITION CASSETTE UNIT HAS BEEN REPLACED THREE TIMES. EACH TIME OF REPLACEMENT THE ACTUAL PART HAS MELTED, BURNED OUT CAUSING THE CAR TO AUTOMATICALLY SHUT DOWN. THE CAR ONLY HAS 72,000 MILES. THE PART IS MELTING AGAIN MAKING THIS THE FOURTH REPLACEMENT IN A 3 MONTH PERIOD. ENGINE - EXHAUST MANIFOLD/CATALYTIC CONVERTER NEEDS TO BE REPLACED AND ALL SAAB AUTHORIZED DEALERS IN NORTHERN CA. STATE THEY ARE UNABLE TO GET PART DUE TO BEING ON BACK ORDER AND NO IDEA WHEN THE PART WILL BE AVAILABLE. BUT I WAS ABLE TO FIND THE PART… Look up ODI 10510972 at NHTSA ↗ | 15.9%ODI 10391871 · 61,711 miDIRECT IGNITION CASSETTE FAILURE AT 62,000 MILES. Look up ODI 10391871 at NHTSA ↗ | 210.0%ODI 10573937 · 30,000 miTL* THE CONTACT OWNS A 2008 SAAB 9-5. THE CONTACT STATED THAT WHEN HE WOULD REMOVED THE KEY OUT OF THE IGNITION, THE VEHICLE WOULD NOT TURN OFF. THE DEALER WAS CONTACTED AND THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. IN ADDITION, THE AIR BAG WARNING LAMP ILLUMINATED SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSED THE FAILURE FOR THE AIR BAG WARNING LAMP . THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED FOR THE IGNITION SWITCH. THE … Look up ODI 10573937 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Air Bags | 00.0%No examples available for this selection. | 21.7%ODI 10520408 · 103,000 miTL* THE CONTACT OWNS A 1999 SAAB 9-5. THE CONTACT STATED THAT WHILE PARKED, THE PASSENGER'S SIDE IMPACT AIR BAG ERRONEOUSLY DEPLOYED. THE VEHICLE WAS NOT INVOLVED IN A CRASH OR ANY TYPE OF IMPACT. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR A DIAGNOSTIC TEST HOWEVER, DEALER DID NOT PROVIDE AN EXPLANATION ON WHAT CAUSED THE AIR BAG TO INADVERTENTLY DEPLOY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 103,000. Look up ODI 10520408 at NHTSA ↗ | 00.0%No examples available for this selection. | 11.2%ODI 10230554 · 100,000 miTHE AIRBAG WARNING LIGHT COMES ON WITHOUT NOTICE, AND HORN STOPS WORKING, TOOK TO DEALER WHO SAID IT WAS THE CLOCK SPRING AND THIS IS A TYPICAL PROBLEM. IT IS A SAFETY ISSUE AS THE AIRBAG IS NEEDED TO PREVENT INJURIES. I HAVE HEARD OF OTHER PEOPLE BEING INJURED BY THIS. *TR Look up ODI 10230554 at NHTSA ↗ | 23.8%ODI 10230130TL*THE CONTACT OWNS A 2002 SAAB 9-5. THE CONTACT STATED THAT HE HAS NOT EXPERIENCED ANY FAILURES AT THIS TIME WITH THE AIR BAGS; HOWEVER, HE FEELS THAT THEY WILL NOT DEPLOY DURING A CRASH. HE ALSO BELIEVES THAT THEY MAY DEPLOY WITHOUT WARNING AT ANY TIME. THE AIR BAGS ARE RUNNING THROUGH A CENTRAL RIBBON CABLE AND NOTHING ELSE CONNECTED TO THAT CABLE IS FUNCTIONING PROPERLY. THE CENTRAL WARNING LIGHT IS ILLUMINATED, WHICH COULD ALSO CAUSE THE AIR BAGS TO MALFUNCTION. THE VEHICLE WAS PURCHASED TWO WEEKS AGO AND THE CENTRAL WARNING LIGHT WAS… Look up ODI 10230130 at NHTSA ↗ | 12.1%ODI 10074314 · 10,000 miWHILE DRIVING 30 MPH, ANOTHER VEHICLE REAR END THE CONSUMER. THIS CAUSED THE DRIVER TO LOOSE CONTROL OF THE VEHICLE. AS A RESULT THE VEHICLE WAS HIT MY OTHER VEHICLE'S FROM DIFFERENT ANGLES. BOTH FRONTAL AIRBAGS FAILED TO DEPLOY. BOTH THE DRIVER AND PASSENGER SUSTAINED INJURIES AND WERE TRANSPORTED BY AMBULANCE. THE VEHICLE WAS TOTALED OUT BY THE INSURANCE COMPANY. *NM NEITHER THE SIDE IMPACT AIR BAGS NOR THE HEAD RESTRAINT AIR BAGS DEPLOYED. *NM Look up ODI 10074314 at NHTSA ↗ | 15.3%ODI 114777167/26/22 10:23pm on interstate 25 North of Denver mile 249 I was not able to stop and rear ended another vehicle. My air bags did not deploy there were no dash lights indicating any problem with the airbags prior to the accident. My vehicle was not drivable and was towed to H&R Towing in Johnstown, CO. The only inspection so far has been by an Amica Insurance adjuster. My set belt pretensioner held me fast but the crown of my head went forward into the visor area I was dazed. I went by ambulance to MCR hospital in Loveland diagnosed with a concu… Look up ODI 11477716 at NHTSA ↗ | 218.2%ODI 10403888 · 46,000 miTL*THE CONTACT OWNS A 2005 9-5 SAAB. THE CONTACT STATED THAT WHILE MAKING A TURN SHE CRASHED INTO A PARKED VEHICLE. THE AIR BAGS DID DEPLOY AFTER THE CRASH OCCURRED AND THE DRIVER RECEIVED INJURIES TO HER FACE AND MOUTH. A POLICE REPORT WAS FILED. SHE WAS NOT TRANSPORTED TO THE HOSPITAL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO ADVISED HER THAT THE WAY THE SHE CRASHED INTO THE VEHICLE, THE AIR BAGS WOULD NOT DEPLOY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 46,000. THE VIN WAS UNAVAILABLE. UPDATED 07/18/1… Look up ODI 10403888 at NHTSA ↗ | 1356.5%ODI 10888453TL* TAKATA RECALL. THE CONTACT OWNS A 2006 SAAB 9-5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PARTS FOR THE RECALL REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. Look up ODI 10888453 at NHTSA ↗ | 1270.6%ODI 10871641TL* TAKATA RECALL. THE CONTACT OWNS A 2007 SAAB 9-5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. Look up ODI 10871641 at NHTSA ↗ | 1890.0%ODI 10246609 · 100 miI HAVE A 2008 9-5 SAAB AND THE PASSENGER AIRBAG TURNS ITSELF ON AND OFF WHILE SOMEONE IS SITTING IN THE SEAT AND THE CAR IS MOVING. THE SENSOR IS SUPPOSED TO BE SET TO TURN AIRBAG ON FOR 90 LBS BUT MY WIFE AND KIDS WEIGH ABOUT 120 LBS AND THE ONLY WAY TO KEEP THE AIRBAG SENSOR ON IS TO PULL YOURSELF DOWN IN THE SEAT AND HOLD ON. I HAVE NOTIFIED SAAB ABOUT THIS ISSUE AND THEY CANNOT FIX NOR DO THEY SEEM WILLING TO TRY. MY WIFE SAT IN OTHER 2008 9-5?S AND HAD THE SAME PROBLEM AT THE DEALERSHIPS AND THEY WITNESSED THE PROBLEM SO IT IS NOT JUST … Look up ODI 10246609 at NHTSA ↗ | 2100.0%ODI 10946757TAKATA RECALL. THE RECALL STATUS IS STILL INDICATING RECALL INCOMPLETE. REMEDY NOT YET AVAILABLE. WENT TO DEALERSHIP SERVICE DEP'T WAS TOLD PART NOT AVAILABLE. RECEIVED NOTICE IN MAY 2016. VERY CONCERNED THAT THE FIX FOR THIS EXTREMELY DANGEROUS CONDITION IS NOT YET AVAILABLE. NEED TO HAVE PRESSURE PUT ON THE COMPANY TO GET THIS FIXED ASAP. Look up ODI 10946757 at NHTSA ↗ | 150.0%ODI 10862875S10 DIRECT REPLY- LETTER ADDRESSED TO PRESIDENT OBAMA REQUESTING ASSISTANCE WITH A TAKATA AIRBAG RECALL. *SMD 2010 SAAB 9-5. THE CONSUMER WAS INFORMED THE PARTS WERE NOT AVAILABLE. *JB UPDATED 06/08/16.*JB Look up ODI 10862875 at NHTSA ↗ | 111.1%ODI 10862214TL* TAKATA RECALL. THE CONTACT OWNS A 2011 SAAB 9-5. THE CONTACT RECEIVED A RECALL NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PARTS FOR THE RECALL WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. Look up ODI 10862214 at NHTSA ↗ |
|---|
| Electrical System:Ignition | 00.0%No examples available for this selection. | 2218.6%ODI 10036842 · 63,000 miFAILURE OF DIRECT IGNITION CASSETTE. VEHICLE (1999 SAAB 9-5 SE) STOPS RUNNING IN TRAFFIC AND CANNOT BE RESTARTED. BASED ON REPORTS IN SAABNET.COM, THIS IS A RELATIVELY COMMON FAILURE. *AK Look up ODI 10036842 at NHTSA ↗ | 109.8%ODI 10052795 · 38,000 mi2000 SAAB 9-5 SEDAN SUDDENLY STALLED OUT AT 60 MPH AS 2 TRACKER TRAILERS NEARLY COLLIDED INTO MY VEHICLE. NO SHOULDERS ON THIS HIGHWAY LEAVING MY FAMILY IN A HORRIBLY DANGEROUS PLACE. VERMONT STATE POLICE RESPONDED TO PROVIDE PROTECTION. THE CASSETTE WHICH HOUSES THE IGNITION FAILED. BOTH THE DEALER AND OTHER OWNERS HAVE EXPRESSED THAT THIS OCCURS AL THE TIME WITH SAABS AND THERE IS NO WAY TO PREVENT THESE CARS FROM STALLING AT ANY TIME!*AK Look up ODI 10052795 at NHTSA ↗ | 1417.1%ODI 10010313KEY WAS TOUCHED BY A BABY BOTTLE (VERY GENTLY). THE CAR SHUT OFF ON A BUSY EXPRESSWAY. LUCKILY NOBODY WAS KILLED. I WENT TO THE CAR SERVICE AND GENTLY TAPPED THE KEY AND REPRODUCED THE KEY TURNING. THE SERVICE PERSON SAID THAT WAS NORMAL! PLEASE HELP BEFORE SOME ONE IS KILLED.*JB Look up ODI 10010313 at NHTSA ↗ | 611.3%ODI 10011398 · 25,000 miTHE VEHICLE STALLED WITHOUT WARNING, THE DEALER DIAGNOSED THE DIRECT IGNITION CASSETTE FAILED. *JB SCC Look up ODI 10011398 at NHTSA ↗ | 24.3%ODI 10277935 · 39,000 miTL*THE CONTACT OWNS A 2003 SAAB 9-5. THE CONTACT EXPERIENCED IGNITION CASSETTE FAILURE, WHICH CONTROLS THE SPARKS PLUGS. THE DEALER REPLACED THE IGNITION AT THE COST OF $500; HOWEVER, THE CONTACT WANTS TO BE REIMBURSED. HE WAS INFORMED TO CALL THE SAAB MANUFACTURER AND REPORT THE ISSUE. THE FAILURE MILEAGE WAS 39,000. Look up ODI 10277935 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Engine And Engine Cooling | 00.0%No examples available for this selection. | 54.2%ODI 10121309 · 29,000 miDT: THE ENGINE JUST SHUT DOWN WITHOUT WARNING AND THE VEHICLE WAS UNABLE TO BE RESTARTED. THERE WAS ONLY A CLICKING NOISE. THE ENGINE WOULD NOT TURN OVER. THIS HAS HAPPENED TWICE IN THE MIDDLE OF TRAFFIC. THE FIRST INCIDENT, THE IGNITION CASSETTE WAS REPLACED, AND THIS SUBSEQUENTLY HAPPENED AGAIN. MORE REPAIR WORK WAS DONE AND THIS HAPPENED FOR A THIRD TIME. THE VEHICLE IS CURRENTLY IN SHOP. *AK THE THROTTLE BODY HAD TRIPPED AND WENT INTO LIMP MODE ON THE THIRD INCIDENT. THE DEALER COULD NOT DETECT THE ROOT CAUSE. *SC *JB Look up ODI 10121309 at NHTSA ↗ | 32.9%ODI 10198841 · 92,000 miTL*THE CONTACT OWNS A 2000 SAAB 9-5. THE CONTACT BELIEVES THAT THE IGNITION DISCHARGE MODULE WAS THE CAUSE OF HER VEHICLE CATCHING FIRE. THE CONTACT STATED THAT BEFORE THE FIRE OCCURRED, THE CHECK ENGINE LIGHT FLASHED. THE CONTACT'S HUSBAND WAS DRIVING WHEN HE NOTICED SMOKE RISING FROM UNDER THE HOOD. HE PULLED OVER AND EXITED THE VEHICLE AS IT CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND THE VEHICLE WAS TOWED. A POLICE REPORT WAS FILED. THE PURCHASE DATE AND SPEED WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 92,000… Look up ODI 10198841 at NHTSA ↗ | 33.7%ODI 10173772 · 71,000 miDT*: THE CONTACT STATED THE ENGINE DIED WHILE THE VEHICLE WAS TRAVELING 60 MPH, ALMOST CAUSING AN ACCIDENT. THE SERVICE DEALER DETERMINED THE VEHICLE NEEDED A NEW ENGINE. THE CONSUMER HAD THE ENGINE REPLACED. UPDATED 01/26/07. *JB Look up ODI 10173772 at NHTSA ↗ | 35.7%ODI 10086069 · 22,000 miMARCH 25,'04, JUNE 3,O4,JUNE 10, 'O4;JULY 21'O4;AUG 2,'04: TRAVELING ALONG HIGHWAY KEEPING UP WITH THE FLOW OF TRAFFIC (65 MPH) WHEN A SUDDEN AND COMPLETE LOSS OF POWER OCCURS NECESSITATING EMERGENCY AVOIDANCE PROCEDURES TO ADVERT SERIOUS MULTI-CAR CRASH. DEALERSHIP,SMITHTOWN SAAB (530 EAST JERICHO TPKE, SMITHTOWN,NY,117870) SAYS IT'S FIXED -5 TIMES. NOT. SAAB USA REFUSES TO DO ANYTHING DESPITE MY NUMEROUS CALLS. CAR IS A 2002 SAAB 9-5,WITH 27,000 MLES,UNDER WARRANTY.*AK Look up ODI 10086069 at NHTSA ↗ | 48.5%ODI 10097342 · 3,000 miTHE VEHICLE STALLED ON 4 SEPARATE OCCASIONS FROM VARIOUS SPEEDS OF 25 MPH OR MORE WHILE DRIVING. THE VEHICLE HAS BEEN TO THE DEALER ON 3 SEPARATE OCCASIONS. THE DEALER HAS CLEANED AND TIGHTENED THE BATTERY CABLES, THE FIRST TIME, THEY REPLACED THE CRANK SENSOR, T-7 AND THE IGNITION SWITCH, THE SECOND TIME AND THE THIRD TIME, THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *JB THE ECM WAS REPLACED BUT THE VEHICLE STALLED AGAIN, THE CUP HOLDER CRACK AND HAD BROKEN, THE BATTERY CABLES WERE LOOSE AND DIRTY, THE TRANSMISSION DID NOT SHIFT PROPERLY … Look up ODI 10097342 at NHTSA ↗ | 15.3%ODI 10237522 · 31,821 miI OWN A 2004 SAAB 9-5 WAGON, WHICH WAS PURCHASED IN NOV 2004. THERE WERE APPROXIMATELY 31,800 MILES ON THE CAR AT THE TIME OF THIS FAILURE, WHICH OCCURRED IN LATE JULY 2008. (IRONICALLY, LESS THAN 2 WEEKS AFTER HAVING TAKEN THE CAR FOR ROUTINE SERVICE/OIL CHANGE/TIRE ROTATION.) AFTER HAVING RUN 2 ERRANDS (I.E. TWO STOPS & STARTS), I WAS DRIVING TO WORK ON A RELATIVELY BUSY 4-LANE ROAD. JUST AFTER HAVING COME DOWN A HILL & ROUNDING A CORNER, WITH ESTIMATED SPEED 35MPH, THE CAR'S ENGINE CUT OUT, THE POWER STEERING WENT OUT, & THE BRAKES SEEME… Look up ODI 10237522 at NHTSA ↗ | 19.1%ODI 10424440 · 95,000 miTHE IGNITION CASSETTE CRACKS CAUSING IGNITION PROBLEMS, STALLING, ACCELERATION PROBLEMS. IT MAKES IT UNPREDICTABLE. THIS IS THE SAME PROBLEM AS THE PREVIOUS RECALL PASTED BELOW. WHY DOES IT NOT COVER THESE OTHER MODEL YEARS? NHTSA CAMPAIGN NUMBER: 06V410000 WWW.NHTSA.DOT.GOV MANUFACTURER SAAB CARS USA, INC. RECALL DATE: OCT 23, 2006 POTENTIAL NUMBER OF UNITS AFFECTED: 5078 DESCRIPTION ELECTRICAL SYSTEM:IGNITION:MODULE SUMMARY CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEA… Look up ODI 10424440 at NHTSA ↗ | 14.3%ODI 10233488 · 24,500 miSIGNIFICANTLY DELAYED ACCELERATION WHEN AMBIENT TEMPS EXCEED 90F. CAR FUNCTIONS NORMALLY UNTIL YOU ENCOUNTER SUMMER TEMPS AND HEAVY TRAFFIC. THEN, UPON PRESSING THE ACCELERATOR PEDAL CAR HESITATES SEVERELY UNTIL ENGINE SPEED REACHES APPROXIMATELY 2100 RPM. THEN ACCELERATION COMES ON STRONGER THAN EXPECTED. THIS IS PARTICULARLY DISTURBING WHEN MAKING LEFT TURNS OR ENTERING A BUSY STREET. CAR SOMETIMES MISFIRES WHEN THIS OCCURS. *TR Look up ODI 10233488 at NHTSA ↗ | 15.9%ODI 10201225 · 5,800 miTL*THE CONTACT OWNS A 2007 SAAB 9-5. WHILE DRIVING 50 MPH AND ATTEMPTING TO ACCELERATE, THE VEHICLE STALLED. THE FAILURE OCCURS INTERMITTENTLY. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OR DUPLICATE THE FAILURE ON TWO OCCASIONS. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE CURRENT AND FAILURE MILEAGES WERE 5,800. UPDATED 09/18/07 *TR Look up ODI 10201225 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Engine And Engine Cooling:Engine | 00.0%No examples available for this selection. | 43.4%ODI 10112080WHILE DRIVING ON AN INTERSTATE HIGHWAY, CHECK ENGINE DISPLAY CAME ON, BUT BEFORE I WAS ABLE TO GET OFF THE ROAD THE CAR COMPLETELY STALLED. CAR TOWED TO DEALERSHIP (VILLAGE SAAB,ACTON, MA), AND TOLD I NEEDED A NEW ENGINE. OIL ALWAYS CHANGED WITHIN SPECIFIED PARAMETERS, W/ 76K MI. SAAB NOTES DEFECT-BUT OFFERS NO HELP. *NM Look up ODI 10112080 at NHTSA ↗ | 32.9%ODI 10059495WHILE DRIVING 55 MPH, VEHICLE LOST ALL POWER. ECM WAS REPLACED BUT PROBLEM STILL EXISTS. (NAR) *LA *CB Look up ODI 10059495 at NHTSA ↗ | 78.5%ODI 10105773 · 41,000 miMULTIPLE TIMES THE CAR, WHEN WARM WILL JUST WITHOUT WARNING. ALL ELECTRICAL AND ENGINE SIMULTANEOUSLY QUITS LEAVING THE DRIVER TO DEAL WITH A SITUATION OF NO POWER BRAKES AND STEERING. MULTIPLE TRIPS TO DEALER HAS RESULTED IN NO DIAGNOSIS AND GENEARL APATHY ABOUT THE PROBLEM. THE CAR IS STIL UNDER WARRANLTY BUT IT OFFERS NO VALUE. CLEAR SAFETY ISSUE AS THE LAST EVENT WAS AT A ELEMENARY SCHOOL WHERE A CHILD WAS ALMOST HIT AS THE LACK OF BRAKING AND STEERING POWER. HOW CAN SUCH A SYMPTOM BETREATED WITHSUCH APATHY. WE WILL BE FORCED TO SEL T… Look up ODI 10105773 at NHTSA ↗ | 11.9%ODI 10048199PROBLEMS WITH DELAY IN REPORT OF WARRANTY CLAIM AND THE AVAILABILITY OF SERVICE.*MR THE VEHICLE STALLED IN TRAFFIC POSING A SAFETY HAZARD. UPON CONTACTING HIS LOCAL DEALER, THE CONSUMER WAS GIVEN AN APPOINTMENT FOR REPAIRS TWO WEEKS AFTER THE CALL. CONSUMER FELT THIS WAS UNACCEPTABLE, AND THIS SERIOUS SAFETY DEFECT SHOULDN'T WAIT AS LONG. CONSUMER IS HOLDING SAAB RESPONSIBLE FOR ANYTHING THAT MAY HAPPEN BETWEEN THE DATE OF THE PHONE CALL AND THE APPOINTMENT. *PH Look up ODI 10048199 at NHTSA ↗ | 24.3%ODI 10162804I WAS DRIVING ON THE HIGHWAY AT 70 MPH AND THE ENGINE SUDDENLY SHUT DOWN WITHOUT ANY WARNING. THE CAR COMPLETELY LOST POWER AND I HAD TO QUICKLY COAST TO THE SHOULDER. I WAS NOT ABLE TO RESTART THE CAR AND IT HAD TO BE TOWED TO SAAB DEALER. I WAS TOLD THERE WAS A FAULT IN DI CASSETTE. *NM Look up ODI 10162804 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 14.3%ODI 10233488 · 24,500 miSIGNIFICANTLY DELAYED ACCELERATION WHEN AMBIENT TEMPS EXCEED 90F. CAR FUNCTIONS NORMALLY UNTIL YOU ENCOUNTER SUMMER TEMPS AND HEAVY TRAFFIC. THEN, UPON PRESSING THE ACCELERATOR PEDAL CAR HESITATES SEVERELY UNTIL ENGINE SPEED REACHES APPROXIMATELY 2100 RPM. THEN ACCELERATION COMES ON STRONGER THAN EXPECTED. THIS IS PARTICULARLY DISTURBING WHEN MAKING LEFT TURNS OR ENTERING A BUSY STREET. CAR SOMETIMES MISFIRES WHEN THIS OCCURS. *TR Look up ODI 10233488 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 43.9%ODI 10170159CONSUMER SAAB AERO 9-5 CLIP HOLD THE GAS TANK BROKE, SPILLING GASOLINE ALL OVER THE CAR, THE ROAD AND EXHAUST LINES. *TS ***NAR*** A CLIP THAT WAS HOLDING THE GAS HOSE IN PLACE BROKE, WHICH REQUIRED THE REPLACEMENT OF THE ENTIRE FUEL PUMP. *JB Look up ODI 10170159 at NHTSA ↗ | 56.1%ODI 10171613 · 49,000 miDT*: THE CONTACT STATED WHILE DRIVING 60 MPH, A DRAMATIC DECREASE IN THE GAS GAUGE WAS NOTICED. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE GAS LINE TO THE FUEL PUMP WHICH CAUSED A RAPID LOSS OF FUEL. THERE WAS A NHTSA RECALL, # 04V557000, REGARDING THE HOSES, LINES/PIPING AND FITTINGS. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. Look up ODI 10171613 at NHTSA ↗ | 47.5%ODI 10139470DT: CONSUMER STATES ON OCTOBER 6, 2005 WHILE DRIVING ON A ROAD THE VEHICLE CAUGHT ON FIRE. THE FUEL LINE WAS RIPPED, AND ONE SMELLED GASOLINE ALL OVER THE PASSENGER SIDE OF THE VEHICLE. CONSUMER STATED WHEN PUTTING THE VEHICLE IN REVERSE IT WILL STALL INTERMITTENTLY. CONSUMER TOOK THE VEHICLE TO DEALER AND NO CODES SHOWED UP ON THE DIAGNOSTIC MACHINE. THE DEALER CHANGED CATALYTIC CONVERTER AND THE OXYGEN SENSOR TWICE. THE DEALER COULD NOT PIN POINT THE PROBLEM. THE ENGINE FAILURE LIGHT DID COME ON BEFORE THE VEHICLE CAUGHT ON FIRE. THE DEAL… Look up ODI 10139470 at NHTSA ↗ | 12.1%ODI 10195511TL*THE CONTACT OWNS A 2003 SAAB 9-5. ON JULY 6, 2007, THE CONTACT RECEIVED RECALL NOTICE # 07V087000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE IS CURRENTLY LOCATED IN SPAIN. THE MANUFACTURER STATED THAT THEY ARE NOT OBLIGATED TO REPAIR THE VEHICLE FOR FREE BECAUSE IT IS LOCATED OUTSIDE OF THE UNITED STATES. THE MANUFACTURER ALSO REFUSED TO PROVIDE THE CONTACT WITH A COPY OF THE RECALL NOTICE IN SPANISH. THE CURRENT MILEAGE WAS 48,063 AND THERE HAD BEEN NO FAILURE TO DATE. Look up ODI 10195511 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Exterior Lighting | 00.0%No examples available for this selection. | 21.7%ODI 10148678 · 108,000 mi1999 SAAB 9-5 HAS A FAULTY MASTER CYLINDER, AND VACUUM BOOSTER WHICH BOTH HAD TO BE REPLACED AT OWNERS EXPENSE. *TS IN THE PAST THE CONSUMER HAD TO REPLACE THE WATER PUMP. HEATER FAN MOTOR, THERMOSTAT. LEAKY SUNROOF, BATTERY, BATTERY CABLES AND NUMEROUS LIGHT BULBS. *JB Look up ODI 10148678 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 15.3%ODI 10245621 · 46,500 miPURCHASED THE CAR USED 5/23/08 WITH 42,700 MILES FROM SAAB DEALERSHIP. WITHIN A MONTH THE HEADLIGHTS WORKED RANDOMLY, CHECK ENGINE LIGHT WOULD COME ON RANDOMLY. CALLED THE DEALERSHIP AND WAS TOLD THAT IT WOULDN'T HURT ANYTHING AND SHOULD IT BECOME MORE FREQUENT, BRING THE CAR IN. 8/18 TOOK THE CAR IN TO DEALERSHIP WHEN THE LIGHT WAS COMING ON MORE FREQUENTLY. HEADLIGHT RELAY REPLACED, ENGINE LIGHT WAS DUE TO A DIRECT IGNITION CASSETTE FAILURE. SAAB DEALERSHIP ORDERED THE PART WHICH WAS ON NATIONAL BACK ORDER, PART CAME IN 10/9. VEHICLE WAS TAKE… Look up ODI 10245621 at NHTSA ↗ | 218.2%ODI 10419580 · 137,800 miBECAUSE OF IMPROPER DESIGN, REAR WIRE HARNESS FOR REVERSE LIGHTS ARE BEING SEVERED CAUSING THE REVERSING LIGHTS NOT TO WORK. THIS SAME DESIGN FLAW CAN BE ATTRIBUTED TO THE FAILURE OF BRAKE LIGHTS AND ELECTRONIC TRUNK RELEASE/LOCK. *TR Look up ODI 10419580 at NHTSA ↗ | 28.7%ODI 10743352 · 187,123 miTHE HEADLIGHTS OF THIS CAR IS SO WEAK THAT I COULD NOT SEE THE ROAD WHEN I WAS DRIVING IN THE DARK. I DID POLISH THE OUTSIDE OF THE LIGHTS BOX BUT IT DID NOT MAKE ANY DIFFERENCE. I REPLACED THE LIGHTS WITH SAAB BUT IT IS STILL VERY HARD TO SEE THE ROAD IN THE DARK. Look up ODI 10743352 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 555.6%ODI 10536965 · 22,000 miTL* THE CONTACT OWNS A 2011 SAAB 9-5. THE CONTACT STATED THAT THE CHECK REAR TAILLIGHT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT BOTH TAIL LIGHT BULB SOCKETS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 22,000. Look up ODI 10536965 at NHTSA ↗ |
|---|