2017 Triumph THRUXTON: complaints, problems and recalls

THE FRONT BRAKES HAVE A VERY SPONGY FEEL AND REQUIRE MULTIPLE PULLS OR 'PRIMER PULLS' FOR THE FRONT BRAKES TO ENGAGE CORRECTLY. IN EMERGENCY BRAKE SITUATIONS, I DO NOT GET FULL BRAKING POWER OUT OF THE FRONT BRAKES WHEN THE LEVER IS PULLED IN QUICKLY. THE LEVER GOES ALL THE WAY BACK TO THE HANDLEBAR GRIP. DEALERS AND SHOPS HAVE TRIED BLEEDING MY BRAKES NUMEROUS TIMES TO FIX THE ISSUE BUT THE LEVER RESPONSE DOES NOT IMPROVE. THEY ALL SUGGEST THAT I CHANGE THE WHOLE SYSTEM. I THOUGHT THE ISSUE WAS ONLY MY BIKE UNTIL A COMMUNITY OF RIDERS WITH MY …

Look up ODI 11331149 at NHTSA ↗

The front braking system on my 2017 Triumph Thruxton R has excessive brake lever travel that has gotten progressively worse. This has resulting in 'double pumping' the front brake lever to achieve adequate braking power, which in an emergency situation may not be possible. The brakes have been maintained at the appropriate intervals, new brake pads have not solved the issue. The brakes have been thoroughly bled out per the manufacturer's procedure.

Look up ODI 11438226 at NHTSA ↗

THE FRONT BRAKE LEVER MUST BE PUMPED FOR FULL EFFECTIVENESS PRIOR TO STOPPING. THIS IS AN ONGOING ISSUE, AND OCCURS EVERY TIME THE BRAKES ARE APPLIED.

Look up ODI 11372697 at NHTSA ↗

TL* THE CONTACT OWNS A 2019 TRIUMPH THRUXTON MOTORCYCLE. THE CONTACT STATED THAT WHILE DEPRESSING THE BRAKE LEVER, THE BRAKING SYSTEM FAILED TO RESPOND. THE CONTACT STATED THAT IN APPROXIMATELY 15 TO 20 SECONDS, THE BRAKES ACTIVATED BUT FELT SQUISHY. THE CONTACT INDICATED THAT AFTER PRESSING THE BRAKE LEVER A SECOND TIME THE BRAKING SYSTEM OPERATE NORMALLY. THE MOTORCYCLE WAS TAKEN TO TRIUMPH SAN DIEGO LOCATED AT 5171 MORENA PL. SAN DIEGO, CA 92110 HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. AFTER RETRIEVING THE MOTORCYCLE, THE F…

Look up ODI 11366688 at NHTSA ↗

The wire harness has torn under ignition. The traction control stops working, needles bounce, and at times will not start. The wire pulls when the handlebars are turned to the right. I brought it to Moto primo to have it fixed. There was a recall for this issue and they want to charge me over $700 for an issue that they are obviously aware of. I had the bike in AZ over last winter and brought it in on a different recall. Moto primo said that the dealer looked at the issue in Phoenix but did not replace the part. They told me that I h…

Look up ODI 11495521 at NHTSA ↗

Engine won’t start. Gearshift indicator shows a dash line, no fuel level shown, and engine modes are flashing on the dashboard. Once this occurs, the engine will not start. Turning the handlebars or tugging slightly on the wire harness may occasionally cause a connection to occur, and the fuel pump will run again with the dash returning to normal. No noticeable chafing is visible on the wiring harness, but there appears to be an intermittent connection in the harness.

Look up ODI 11493302 at NHTSA ↗

NEW MOTORCYCLE AND FIRST NIGHT OUT WITH IT. INSTRUMENT PANEL AT NIGHT IS NOT LEGIBLE. THE LIGHTING ON THE INSTRUMENT CLUSTER (SPEEDOMETER AND TACHOMETER) IS TOO DIM TO BE ABLE TO READ THE NUMBERS MAKING IT IMPOSIBLE TO DETERMINE SPEED AND RPMS.

Look up ODI 10929830 at NHTSA ↗

THE MOTORCYCLE STALL WHEN DOWNSHIFTING FROM 2ND TO 1ST GEAR, ALSO FROM 3RD TO 2ND GEAR. WILL STALL WHEN SITTING AT A STOPLIGHT AND YOU GIVE A LITTLE THROTTLE YOU HEAR AND CLANK SOUND AND IT STALLS. WILL STALL WHEN GOING AROUND CURVES AND AT INTERSECTIONS. HAVE TAKEN IT INTO DEALER MULTIPLE TIMES AND THEY CAN NOT FIND THE ISSUE. THERE ARE MANY PEOPLE THAT HAVE THE SAME PROBLEM ON FACEBOOK. I HAVE A VIDEO OF IT STALLING IN THE MIDDLE OF AN INTERSECTION WITH ONCOMING TRAFFIC. COULD HAVE BEEN KILLED. I CAN EMAIL YOU THE VIDEO, YOUR WEBSI…

Look up ODI 11002600 at NHTSA ↗

Engine won’t start. Gearshift indicator shows a dash line, no fuel level shown, and engine modes are flashing on the dashboard. Once this occurs, the engine will not start. Turning the handlebars or tugging slightly on the wire harness may occasionally cause a connection to occur, and the fuel pump will run again with the dash returning to normal. No noticeable chafing is visible on the wiring harness, but there appears to be an intermittent connection in the harness.

Look up ODI 11493302 at NHTSA ↗

THE MOTORCYCLE STALL WHEN DOWNSHIFTING FROM 2ND TO 1ST GEAR, ALSO FROM 3RD TO 2ND GEAR. WILL STALL WHEN SITTING AT A STOPLIGHT AND YOU GIVE A LITTLE THROTTLE YOU HEAR AND CLANK SOUND AND IT STALLS. WILL STALL WHEN GOING AROUND CURVES AND AT INTERSECTIONS. HAVE TAKEN IT INTO DEALER MULTIPLE TIMES AND THEY CAN NOT FIND THE ISSUE. THERE ARE MANY PEOPLE THAT HAVE THE SAME PROBLEM ON FACEBOOK. I HAVE A VIDEO OF IT STALLING IN THE MIDDLE OF AN INTERSECTION WITH ONCOMING TRAFFIC. COULD HAVE BEEN KILLED. I CAN EMAIL YOU THE VIDEO, YOUR WEBSI…

Look up ODI 11002600 at NHTSA ↗

PURCHASED A NEW 2013 TRIUMPH THRUXTON MOTORCYCLE. THE BIKE DOES NOT GO INTO FIRST GEAR AT TIMES. THE BIKE WILL NOT SHIFT UP OR DOWN AT TIMES. THE BIKE AT TIMES SHOW YOU ARE IN NEUTRAL BUT WHEN THE CLUTCH IS RELEASED YOU ARE STILL IN GEAR. *TR

Look up ODI 10553326 at NHTSA ↗

I HAVE HAD 3 SIDE STAND SPRINGS FAIL DURING THIS CALENDAR YEAR 2020, IN LESS THAN 3,000 TOTAL MILES. 2 OF THE FAILED SPRINGS HAVE BEEN UPGRADED PARTS FROM A TRIUMPH INTERNAL SAFETY BULLETIN REPLACEMENT. THIS LAST SPRING FAILED 900 MILES AFTER IT WAS INSTALLED ONLY A MONTH AND A HALF AGO. ALL INSTALLATIONS WERE DONE BY THE AUTHORIZED TRIUMPH DEALERSHIP. ALL 3 OF THE SPRING FAILURES OCCURRED AT FREEWAY SPEEDS, TOP GEAR, IN TRAFFIC - WHEN IT FAILS, IT ACTIVATES A KILL SWITCH THAT CUTS POWER TO THE MOTOR, LEAVING ME IN HIGHWAY TRAFFIC AT SPEED WITH…

Look up ODI 11376897 at NHTSA ↗