U.S. public vehicle records

Volkswagen ROUTAN electrical problems

206 complaint narratives mention electrical terms.

Key facts

784 owner complaints analyzed

8 distinct recall campaigns

68,483 mi median reported failure mileage

Scope: 2008 to 2014 model years. Data updated: 2026-09-30 (September 30, 2026). 647 complaints include usable failure mileage. View data status.

Electrical and battery issues evidence

206 of 784 complaints match this topic (26.3%). The keyword filter can include complaints that mention a transmission without reporting its failure. View matching rules.

Owner report 10325835 · 2010-04-15 (April 15, 2010)

THE REAR TAILGATE OF MY 2009 VOLKSWAGEN ROUTAN OPENED UP AUTOMATICALLY WHILE THE CAR WAS IN GEAR AND IN MOTION WHICH, ACCORDING TO THE OWNER'S MANUAL, IT SHOULD NOT DO EVEN IF THE POWER TAILGATE BUTTON IS PRESSED. THIS HAPPENED WHILE THE CAR WAS BEING PULLED INTO THE GARAGE WHICH RESULTED IN THE REAR WINDSHIELD SHATTERING UPON CONTACT WITH THE GARAGE DOOR OPENING. THE CAR WAS BROUGHT TO THE LOCAL VOLKSWAGEN DEALERSHIP THE SAME DAY AND NOTHING WAS FOUND IN THE DIAGNOSTICS THAT POINTED TO A FAILURE OF ANY SORT. THERE WERE PREVIOUS ELECTRICAL I…

Owner-reported narrative. 6,800 miles reported. Look up ODI 10325835 at NHTSA ↗

Owner report 10331625 · 2010-05-21 (May 21, 2010)

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE ELECTRICAL SLIDING DOOR WOULD NOT FUNCTION CORRECTLY. THE SENSOR FAILED AND HER CHILDS FINGERS AND PART OF HIS BODY WERE JAMMED IN THE DOOR. THE DEALER ADVISED THERE WERE NO FAILURES IN THE VEHICLE AND WHEN CONTACTING THE MANUFACTURER, THEY CONFIRMED THERE WERE NO FAILURES WITHIN THE VEHICLE. THE FAILURE MILEAGE WAS 1,000 AND THE CURRENT MILEAGE WAS 11,000.

Owner-reported narrative. 1,000 miles reported. Look up ODI 10331625 at NHTSA ↗

Owner report 10436595 · 2011-11-21 (November 21, 2011)

OUR ROUTAN HAS "STARTED ITSELF" MULTIPLE TIMES. IN EACH INSTANCE, WITHOUT INTENTIONALLY STARTING THE IGNITION (KEYS WERE IN PURSE/HANDBAG UNTOUCHED BY HUMAN HANDS), WE HAVE FOUND THE VEHICLE ON AND IDLING. MOST RECENTLY, WE HAPPENED (FORTUITOUSLY) TO FIND THE VEHICLE RUNNING IN OUR ENCLOSED GARAGE. THE GARAGE IS ATTACHED TO OUR HOME AND WE FELT, GIVEN THE POTENTIAL FOR ACCIDENTAL DEATH IF NOT DISCOVERED IN A TIMELY FASHION, WE NEEDED TO ALERT AUTHORITIES OF THE (EITHER) DESIGN FLAW OR ELECTRICAL SYSTEM MALFUNCTION. WHILE ELECTRICAL SYSTEM MA…

Owner-reported narrative. Look up ODI 10436595 at NHTSA ↗

Owner report 10455108 · 2012-04-13 (April 13, 2012)

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE ATTEMPTING TO CLOSE THE REAR PASSENGER SIDE DOOR, THE CONTACT NOTICED THAT THE DOOR WOULD IMMEDIATELY REOPEN AFTER BEING CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DOOR CHAIN AND AN UNSPECIFIED ELECTRICAL COMPONENT WAS REPLACED. HOWEVER THE CONTACT CONTINUED TO EXPERIENCE THE FAILURE. THE FAILURE MILEAGE WAS 150 AND THE CURRENT MILEAGE WAS 30,000.

Owner-reported narrative. 150 miles reported. Look up ODI 10455108 at NHTSA ↗

Owner report 10522844 · 2013-07-02 (July 2, 2013)

I WAS DRIVING APPROX 65 MPH ON A HIGHWAY. WITHOUT A WARNING (NO CHECK ENGINE LIGHT, NO BATTERY LIGHT, ETC) MY ENGINE TURNED OFF WHILE STILL CRUISING AT 65 MPH. THE VEHICLE STILL HAD MOMENTUM, BUT NO POWER STEERING TO SAFELY PULL THE VEHICLE OVER. I HAD TO WAIT FOR THE ROAD TO TURN, SO I CAN POSITION THE VEHICLE TO STOP ON THE SHOULDER OF THE VEHICLE. I ALMOST CRASHED INTO OTHER VEHICLES, BECAUSE I HAD NO CONTROL OF THE CAR OTHER THAN BRAKING IN THE MIDDLE LANE OF A HIGHWAY. TOWED VEHICLE DEALER FOUND A BLOWN ENGINE FUSE. THEY REPLACED THE ENGIN…

Owner-reported narrative. 376,500 miles reported. Look up ODI 10522844 at NHTSA ↗

Explore the data

Vehicle analysis explorer

Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.

Data completeness

784 unique complaints in this selection. Analysis snapshot: 2026-09-30.

82.5%Usable mileage647 / 784 records

100.0%Valid incident date784 / 784 records

100.0%Valid filing date784 / 784 records

100.0%Ordered incident and filing dates784 / 784 records

Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.

Problems by model year

Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.

From model yearThrough model year

Component complaint heatmap
Component	2008	2009	2010	2011	2012	2013	2014
Electrical System	00.0% No examples available for this selection.	14750.0% ODI 10288990 · 1,719 mi DRIVING APPROXIMATELY 25MPH WHEN THE ONE MONTH OLD VEHICLE JUST SUDDENLY FELT LIKE SOMEONE SLAMMED ON THE BRAKES. THE VEHICLE CAME TO A HALT. THE MOTOR WAS STILL RUNNING. I GOT IN THE CAR AGAIN TO MOVE IT OUT OF THE WAY AND THE SAME THING OCCURRED. IMMEDIATELY HAD IT TOWED TO THE VOLKSWAGEN DEALERSHIP. THERE IT STAYED FOR 13 DAYS. THE FOLLOWING PROBLEMS WERE REPAIRED/REPLACE: FAULTY TRANSMISSION SENSOR, REPLACED SENSOR. ALSO, ABS STEERING ANGLE SENSOR ERRATIC PERFORMANCE. FAULTY STEERING ANGLE SENSOR. REPLACED SENSOR. *TR Look up ODI 10288990 at NHTSA ↗	14560.4% ODI 10367104 · 2,800 mi TL*THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE LOST POWER AND SHUT OFF WITHOUT WARNING. THE CONTACT WAS CONCERNED THAT A CRASH WOULD RESULT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE COMPUTER SYSTEM WAS RE-FLASHED AND THE ABS MODULE WAS REPLACED; THE FAILURE CONTINUED. THE CONTACT CALLED THE MANUFACTURER BUT HAD YET TO BE CONTACTED. THE FAILURE MILEAGE WAS 2,800. Look up ODI 10367104 at NHTSA ↗	11163.4% ODI 10491583 · 30,852 mi DRIVING DOWN I70 WEST BOUND GOING 70 MPH IN INDIANA AND ENGINE TURNED OFF LOST POWER EVERY LIGHT ON DASH CAME ON AND THE WAS A BLINKING RED LIGHT IN CENTER OF DASH. SOME HOW I MADE IT OVER TO THE EDGE OF THE ROAD AND PUT IT IN PARK. THE VAN WOULD NOT START. I NOTICED I WAS ON THE WHITE LINE AND WANTED TO MOVE THE VAN OVER MORE, BUT I COULD NOT GET THE VAN INTO NEUTRAL. I COULD FEEL THE EVERY CAR AND TRUCK DRIVE BY. I WAS SCARED FOR MY LIFE. I WAS TRAVELING WITH MY WIFE AND 3 CHILDREN UNDER FIVE ON THE COLDEST DAY OF THE YEAR. I KEPT THI… Look up ODI 10491583 at NHTSA ↗	3961.9% ODI 10510832 · 10,735 mi MY HUSBAND WAS AT A LIGHT AND PRESSED THE GAS TO GO, WHEN HE NOTICED THAT HE ENTIRE VEHICLE HAD TURNED OFF. STEERING, BRAKES, AND ALL ELECTRICAL. IT TOOK HIM A WHILE TO REALIZE WHAT WAS HAPPENING, BUT THEN HE TRIED TURNING THE VAN OFF AND BACK ON, AND IT STARTED RIGHT BACK UP. HE THOUGHT IT A FREAK OCCURRENCE. *TR Look up ODI 10510832 at NHTSA ↗	228.6% ODI 10886240 · 9,500 mi ENGINE WON'T START WHEN BRAKE PEDAL IS DEPRESSED WHILE VAN IS PARKED IN DRIVEWAY, GARAGE, AT GAS STATION, AT SORE PARKING LOT; ALARM HORN SOUNDS FOR NO REASON WHEN VAN IS PARKED; DOORS LOCK WHEN EXITING VEHICLE YET NO LOCK/FOB HAS BEEN PRESSED LOCKING BOTH ELDERLY PARENTS INSIDE VAN WHEN TEMPS. WERE -5 DEGREES OUTSIDE; ENGINE ONLY STARTS WHEN REMOTE START BUTTON ON KEY FOB IS USED, THEN THE ALARM HORN SOUNDS UNTIL VAN IS TURNED OFF AND RESTARTED. THE ISSUE IS CLEARLY THE T.I.P.M. MODULE WHICH HAS BEEN AN ISSUE ON SEVERAL CHRYSLER-BASED PRODUCTS… Look up ODI 10886240 at NHTSA ↗	150.0% ODI 10897876 · 48,000 mi VW ROUTANS ARE KNOWN BY THE MANUFACTURER TO HAVE THE TOTALLY INTEGRATED POWER MODULE OR "TIPM" FAIL CAUSING THE ELECTRICAL SYSTEM TO SHUTDOWN. THIS FAILURE IS RANDOM AND HAPPENS WITH NO WARNING. MY PERSONAL VEHICLE EXPERIENCED THIS FAILURE WHILE PULLING UP TO A STOP SIGN AND LOSING ALL POWER. THE ENGINE DID RESTART AFTER CYCLING THE IGNITION SWITCH AND DROVE FINE AFTERWARDS. THE ROUTAN IS A JOINT VENTURE VEHICLE WITH CHRYSLER WHO HAS HAD THE SAME "TIPM" ISSUES AND HAS ISSUED RECALLS TO CORRECT THE SAFETY CONCERN AS THIS EVENT COULD HAPPEN … Look up ODI 10897876 at NHTSA ↗
Engine	00.0% No examples available for this selection.	7826.5% ODI 10481360 · 57,000 mi 10/7/12: ENTERING ONTO ROAD, BEGAN ACCELERATION UP TO 20/25 MPH -THEN ALL POWER, CONTROLS DEAD. LOST POWER STEERING AND COASTED INTO PARKING LOT. SHUT CAR DOWN, FLOODED/PUMPED ACCELERATOR PEDAL. DIFFICULTY STARTING BUT WORKED, DROVE LIKE NORMAL, AGAIN. 10/14/12: TURNING FROM SIDESTREET, ON TO MAIN STREET -GOING 20 MPH. LOST ALL POWER AGAIN-MANUALLY TURNED COASTED CAR INTO LEFT MIDDLE TURNING LANE. RE-STARTED, OPERATED NORMAL. *TR Look up ODI 10481360 at NHTSA ↗	4518.8% ODI 10459663 · 29,000 mi THIS IS THE THIRD EXPERIENCE WE HAVE HAD OF OUR CAR SHUTTING OFF ALL OF THE SUDDEN. THE FIRST TIME IT HAPPENED I COULD HARDLY PULL THE CAR OFF THE ROAD BECAUSE WHEN IT SHUT OFF I WAS ON THE HIGHWAY AND WAS VERY DIFFICULT TO STEER OF THE ROAD. THE SECOND AND THIRD TIME THIS HAPPENED I WAS IN TOWN AND ALSO HAD A HARD TIME PULLING OVER. AFTER EACH INCIDENT I HAD TO TURN KEY TO OFF POSITION PUT CAR IN PARK AND RESTART IT. THEN IT SEEMED TO BE OK UNTIL THE NEXT TIME IT HAPPENED. THIS IS VERY SCARY AND COULD CAUSE AN ACCIDENT. I AM SCARED TO DRIVE TH… Look up ODI 10459663 at NHTSA ↗	4827.4% ODI 10491583 · 30,852 mi DRIVING DOWN I70 WEST BOUND GOING 70 MPH IN INDIANA AND ENGINE TURNED OFF LOST POWER EVERY LIGHT ON DASH CAME ON AND THE WAS A BLINKING RED LIGHT IN CENTER OF DASH. SOME HOW I MADE IT OVER TO THE EDGE OF THE ROAD AND PUT IT IN PARK. THE VAN WOULD NOT START. I NOTICED I WAS ON THE WHITE LINE AND WANTED TO MOVE THE VAN OVER MORE, BUT I COULD NOT GET THE VAN INTO NEUTRAL. I COULD FEEL THE EVERY CAR AND TRUCK DRIVE BY. I WAS SCARED FOR MY LIFE. I WAS TRAVELING WITH MY WIFE AND 3 CHILDREN UNDER FIVE ON THE COLDEST DAY OF THE YEAR. I KEPT THI… Look up ODI 10491583 at NHTSA ↗	2133.3% ODI 10898509 · 78,000 mi TL* THE CONTACT OWNS A 2012 VOLKSWAGEN ROUTAN. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE STEERING WHEEL SEIZED WITHOUT WARNING. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL AND TURN THE STARTER TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 78,000. Look up ODI 10898509 at NHTSA ↗	342.9% ODI 11000862 · 74,000 mi TL* THE CONTACT OWNS A 2013 VOLKSWAGEN ROUTAN. WHILE DRIVING UNKNOWN SPEEDS, THE VEHICLE SHOOK, JERKED, AND MISFIRED WHILE THE ACCELERATOR PEDAL WAS APPLIED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (HAWK VOLKSWAGEN LOCATED AT 2861 W JEFFERSON ST JOLIET, IL 60435 [phone removed]) WHERE IT WAS DIAGNOSED THAT THE CYLINDER HEAD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 74,000. Look up ODI 11000862 at NHTSA ↗	00.0% No examples available for this selection.
Service Brakes	00.0% No examples available for this selection.	3812.9% ODI 10461184 · 4,000 mi WE BOUGHT THIS VEHICLE IN APRIL OF 2009 BASED ON ALL OF THE "SAFETY FEATURES" AND AS IT TURNS OUT HAS BEEN ONE OF THE MOST UNSAFE VEHICLE I HAVE EVER OWNED. SINCE PURCHASE WE HAVE HAD THE ROTORS CUT 2X AND REPLACED ONCE DUE TO VIOLENT SHAKING IN FRONT END WHEN BRAKING AT ANY SPEED. THE FIRST TIME WE WERE TOLD THIS WAS DUE TO THE VEHICLES SITTING IN THE RAIN FOR A PERIOD OF TIME . WHAT ??? THAT MAY BE THE MOST AGGRAVATING OF ALL WHICH IS THAT VW WOULD RATHER ASSUME YOU ARE STUPID ENOUGH TO BELIEVE THAT. ANOTHER ISSUE HAS BEEN THAT THE HEAD UNIT … Look up ODI 10461184 at NHTSA ↗	239.6% ODI 10483410 · 11,418 mi TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED NUMEROUS FAILURES. THE REAR ROTORS BECAME WARPED NUMEROUS TIMES AND THE DEALER REPLACED THE ROTORS FOUR TIMES. THE TRANSMISSION WOULD CAUSE THE VEHICLE TO LUNGE ABRUPTLY WHEN THE GEAR WAS SHIFTED FROM REVERSE TO DRIVE. ADDITIONALLY, THE FOG LIGHT ASSEMBLY BECAME OVERHEATED AND BURNED SEVERAL TIMES. THE PLASTIC ON THE FRONT PASSENGER SIDE DOOR BECAME FRACTURED AND CAUSED THE CONTACT TO SUSTAIN LACERATIONS TO THE RIGHT HAND AND FINGERS. THE VEHICLE WAS … Look up ODI 10483410 at NHTSA ↗	158.6% ODI 10519965 · 8,000 mi WV 2011 ROUTAN. WHEN THE REAR TIRES/BRAKES GET WET EITHER BY RAIN OR WASHING, AND THE PARKING BRAKE IS APPLIED, THE BRAKES WILL NOT RELEASE WHEN YOU UNLOCK THE PARKING BRAKE PEDAL, DEALER KEPT THE VEHICLE OVERNIGHT AND SOAKED REAR BRAKES WITH GARDEN HOSE AND APPLIED PARKING BRAKES, NEXT MORNING IT WOULD NOT UNLOCK, DEALER REPLACED BRAKE PAD, TOOK VEHICLE AND WENT HOME SAME THING AFTER RAIN, THIS IS THE 8TH TIME I HAVE BEEN STRANDED IN PARKING LOTS DUE TO THIS, TOOK BACK TO DEALER WHO THEN REPLACED REAR BRAKES CALIPER, WENT HOME AND SAME THING … Look up ODI 10519965 at NHTSA ↗	711.1% ODI 10510832 · 10,735 mi MY HUSBAND WAS AT A LIGHT AND PRESSED THE GAS TO GO, WHEN HE NOTICED THAT HE ENTIRE VEHICLE HAD TURNED OFF. STEERING, BRAKES, AND ALL ELECTRICAL. IT TOOK HIM A WHILE TO REALIZE WHAT WAS HAPPENING, BUT THEN HE TRIED TURNING THE VAN OFF AND BACK ON, AND IT STARTED RIGHT BACK UP. HE THOUGHT IT A FREAK OCCURRENCE. *TR Look up ODI 10510832 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Steering	00.0% No examples available for this selection.	3411.6% ODI 10288990 · 1,719 mi DRIVING APPROXIMATELY 25MPH WHEN THE ONE MONTH OLD VEHICLE JUST SUDDENLY FELT LIKE SOMEONE SLAMMED ON THE BRAKES. THE VEHICLE CAME TO A HALT. THE MOTOR WAS STILL RUNNING. I GOT IN THE CAR AGAIN TO MOVE IT OUT OF THE WAY AND THE SAME THING OCCURRED. IMMEDIATELY HAD IT TOWED TO THE VOLKSWAGEN DEALERSHIP. THERE IT STAYED FOR 13 DAYS. THE FOLLOWING PROBLEMS WERE REPAIRED/REPLACE: FAULTY TRANSMISSION SENSOR, REPLACED SENSOR. ALSO, ABS STEERING ANGLE SENSOR ERRATIC PERFORMANCE. FAULTY STEERING ANGLE SENSOR. REPLACED SENSOR. *TR Look up ODI 10288990 at NHTSA ↗	239.6% ODI 10356966 · 659 mi TL* THE CONTACT OWNS 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE TRANSMISSION AND STEERING GOES OUT ON THE VEHICLE. THE VEHICLE WILL STOP WHILE DRIVING AT ANY SPEED AND THE STEERING WILL FAIL. IF THE VEHICLE IS TURNED OFF AND RE-STARTED THE TRANSMISSION WILL WORK, BUT THE VEHICLE WILL CONTINUE TO SHIFT VERY HARD AND THERE IS A LOUD BANGING SOUND AND IT FEELS LIKE SOMEONE HIT THE VEHICLE. THE VEHICLE GIVES NO WARNING BEFORE THE FAILURES OCCUR. THE DEALER HAS INSPECTED THE VEHICLE AND STATED THAT THEY CANNOT FIND ANY PROBLEMS WITH THE TR… Look up ODI 10356966 at NHTSA ↗	116.3% ODI 10421300 · 4,000 mi HAD THE VAN LESS THAN 3 MONTHS AND TOOK IT IN FOR SERVICE - BRAKES SQUEAKING AND STEERING PULLING TO RIGHT W/ONLY 4K MILES. FOUND OUT STEERING BOOT WAS "DISINTEGRATED" AND NEEDED TO BE REPLACED, ALONG WITH STEERING PUMP AND RELATED PARTS. DEALERSHIP HAD NO EXPLANATION AS TO WHY THE DAMAGE OCCURRED OR WHAT COULD HAVE CAUSED IT. MY VAN WAS IN THE SHOP FOR 28 DAYS WAITING FOR AVAILABLE PARTS AND COMPLETING REPAIRS. I HAVE ONLY HAD MY VAN BACK A WEEK AND IT'S PULLING TO THE RIGHT AGAIN. ALSO, A/C DOESN'T COOL CONSISTENTLY - FADES IN AND OUT. … Look up ODI 10421300 at NHTSA ↗	812.7% ODI 10510832 · 10,735 mi MY HUSBAND WAS AT A LIGHT AND PRESSED THE GAS TO GO, WHEN HE NOTICED THAT HE ENTIRE VEHICLE HAD TURNED OFF. STEERING, BRAKES, AND ALL ELECTRICAL. IT TOOK HIM A WHILE TO REALIZE WHAT WAS HAPPENING, BUT THEN HE TRIED TURNING THE VAN OFF AND BACK ON, AND IT STARTED RIGHT BACK UP. HE THOUGHT IT A FREAK OCCURRENCE. *TR Look up ODI 10510832 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Power Train	00.0% No examples available for this selection.	165.4% ODI 10522951 · 63,000 mi WHERE TO BEGIN WITH THIS CAR. ALL 4 VALVE STEMS NEEDED TO BE REPLACED. I WAS LOSING PRESSURE IN MY TIRES, AND MECHANIC SAID THEY WERE CORRODED. THEN MY TIPTRONICS DID NOT WORK, ALSO WHEN YOU SHIFTED IN TO GEAR, IT DIDN'T WANT TO MOVE. HAD THE WHOLE SHIFTING LEVER COMPONENT REPLACED. LOTS OF TROUBLE WITH THE DOORS NOT OPENING RIGHT, THEN WHEN CLOSING THE SENSOR DOESN'T ALWAYS WORK. ALMOST HAD MY KIDS GET CAUGHT IN THE DOOR. IF THE CAR IS EVEN ON THE SLIGHTEST SLOPE THE DOOR WON'T CLOSE. WHILE DRIVING DOWN THE ROAD AT 55MPH THE CAR JUST SHUT OF… Look up ODI 10522951 at NHTSA ↗	166.7% ODI 10332677 THIS COMPLAINT IS REGARDING MY NEW 2010 VOLKSWAGEN ROUTAN, THE CAR IS UNDER TWO MONTHS OLD. THE ACCIDENT OCCURRED AFTER I PULLED INTO MY DRIVEWAY AND I PUT THE CAR IN PARK AND LEFT THE KEYS IN THE ENGINE BECAUSE I WAS GOING TO RUN INTO OPEN THE GARAGE.... I WANTED TO GET A PUPPY OUT OF THE REAR OF THE CAR FIRST SO I WENT AND STOOD BEHIND THE CAR BUT IT WAS LOCKED (CLEARLY IN PARKED.) I THEN WENT TO THE DRIVERS SIDE TO HIT THE UNLOCK SWITCH ON THE DOOR AND THE CAR STARTED REVERSING AND I WAS JUST CAUGHT REALLY OFF GUARD SO I TRIED TO JUMP IN… Look up ODI 10332677 at NHTSA ↗	179.7% ODI 10435306 MY SISTER BOUGHT A VW ROUTAN SE 2011 SIX MONTHS AGO. RECENTLY, WE HAVE EXPERIENCED A "SAFETY PROBLEM" WITH THE VEHICLE ESPECIALLY WHEN WE ARE TRYING PARK IT ON A (STEEP DOWNHILL) BETWEEN TWO CARS IN SAN FRANCISCO. WHEN THE TRANSMISSION IS PUT IN REVERSE AND THE DRIVER IS BACKING UP TO PARK BETWEEN THE TWO CARS ON A STEEP DOWNHILL, THE VW ROUTAN MOVES FORWARD APPROXIMATELY ONE FOOT PRIOR TO BACKING UP AND WE FEEL ABNORMAL VIBRATIONS IN THE TRANSMISSION/ENGINE. PLUS, IF YOU DO NOT PRESS ANY GAS WHEN THE TRANSMISSION IS PUT IN REVERSE, THE CAR ACT… Look up ODI 10435306 at NHTSA ↗	711.1% ODI 10577107 · 700 mi WE HAVE NOTICED THAT THE NEW CAR HAS BEING PROBLEM SHIFTING GEARS AND HAVE BEEN TAKING IT TO THE SHOP SEVERAL TIMES JUST TO BE TOLD THAT THEY DO NOT SEE ANY PROBLEMS. MAY 2013 WE HAVE RECEIVED A RECALL MENTIONING HARSH 1-3 UP SHIFTS AND ERROR IN THE TORQUE MANAGEMENT SOFTWARE, WHICH WILL APPLY MORE PRESSURE TO THE CLUTCH. WE TOOK IT IN AND WERE TOLD THEY HAVE NOT RECEIVED THE RECALL LETTER YET. AT SOME POINT THEY AGREED TO UPDATE THE SOFTWARE, HOWEVER THAT MADE THE PROBLEM WORSE. THE CAR IS NOT MOVING AND WHEN WE GIVE MORE GAS IT WILL ACCELERA… Look up ODI 10577107 at NHTSA ↗	228.6% ODI 11426930 · 128,000 mi The contact owns a 2013 Volkswagen Routan. The contact stated while driving 50 mph, he started to hear an abnormal sound. The contact stated that the check engine warning light was illuminated. The contact was able to continue driving to his destination. The contact stated that he replaced the intake manifold and the check engine warning light disappeared. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed nor repaired. The contact also called a second local dealer Volkswagen of St. Augustine (… Look up ODI 11426930 at NHTSA ↗	00.0% No examples available for this selection.
Unknown Or Other	00.0% No examples available for this selection.	155.1% ODI 10267716 · 4,000 mi WE RECENTLY PURCHASED A 2009 VOLKSWAGEN ROUTAN SE WITH BOTH DRIVER AND PASSENGER AUTOMATIC SLIDING DOORS. OUR 4 YEAR OLD SON WENT TO OPEN THE REAR PASSENGER SIDE DOOR BY PULLING ON THE HANDLE, AND AT THE SAME TIME MY HUSBAND WENT TO OPEN THE DOOR BY PUSHING THE "DOOR OPEN" BUTTON ON THE KEY. AS A RESULT OF THIS, THE DOOR ENDED UP CLOSING COMPLETELY, AND LATCHING, ON MY SON'S HAND. IT ALSO WOULD ONLY OPEN ONCE MY HUSBAND FORCEFULLY PULLED THE DOOR OPEN. OF COURSE HIS HAND IMMEDIATELY SWELLED UP AND WE VISITED THE EMERGENCY DEPARTMENT, HAD XRAY'… Look up ODI 10267716 at NHTSA ↗	187.5% ODI 10677066 · 51,186 mi THIS WILL BE THE THIRD TIME THAT MY FIANCE AND I ARE EXPERIENCING THIS PROBLEM. I HAVE TAKEN MY VAN BACK TO THE DEALERSHIP THE FIRST WEEK OF JANUARY 2015, IT HASN'T BEEN 2 WEEKS AND THE PROBLEM HAS COME BACK. THE VAN IS GOING BACK TO THE DEALERSHIP TO GET FIXED. THIS MORNING THE WINDSHIELD WIPERS TURNED ON AND WON'T TURN OFF OR STOP WHEN WE TURN THE SWITCH TO TURN OFF, THE TURNING SIGNAL BLINKERS, AND THE HEATED SEATS WON'T TURN ON AT ALL. WE CALLED THE DEALERSHIP AND THEY SAID THE MANUFACTURE FIXED IT BUT THEY DON'T UNDERSTAND WHY IT'S HAPPENI… Look up ODI 10677066 at NHTSA ↗	179.7% ODI 10836522 · 65,000 mi MULTIPLE INSTANCES. VEHICLE SHUTS OFF WHILE DRIVING AND WILL RESTART AFTER SITTING FOR AN HOUR OR TWO. THE FIRST INSTANCE OCCURRED WHILE TRAVELING ON A BUSY INTERSTATE AT 65 MPH. I HAD A SEMI TO THE RIGHT AND ANOTHER SEMI BEHIND ME WHEN THE VEHICLE STALLED. VERY SCARY! I TOOK IT TO THE DEALERSHIP THAT I BOUGHT IT FROM AND THEY COULD NOT GET THE PROBLEM TO REPEAT. NO REPAIR WAS MADE. THIS PROBLEM RECURS EVERY 6-10 DAYS. I JUST PURCHASED THIS VEHICLE ABOUT A MONTH AGO WITH 65,000 MILES ON IT. Look up ODI 10836522 at NHTSA ↗	711.1% ODI 10969276 · 97,000 mi THE PROBLEM STARTED WITH THE CAR NOT STARTING ON VARIOUS OCCASIONS. I JUST THOUGHT IT WAS A FLUKE. THEN IT DIED ON ME MULTIPLE TIMES WHILE DRIVING VARIOUS SPEEDS UPWARD OF 70 MPH. EVERYTHING WOULD TURN OFF AND THEN I WOULD PULL OVER AND IT WOULD START RIGHT BACK UP. UPON THOSE THINGS HAPPENING I DECIDED TO TAKE IT IN. AS I WAS HEADING HOME ON THE HIGHWAY GOING ABOUT 75 MPH THE CAR ACCELERATED WITHOUT ME TOUCHING THE GAS AND THEN THE TRANSMISSION DROPPED AND IT DIED. VERY SCARY. I TOOK IT IN AND THEY CONCLUDED THAT IT WAS SOMETHING TO DO WITH TH… Look up ODI 10969276 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Fuel/Propulsion System	00.0% No examples available for this selection.	41.4% ODI 10481360 · 57,000 mi 10/7/12: ENTERING ONTO ROAD, BEGAN ACCELERATION UP TO 20/25 MPH -THEN ALL POWER, CONTROLS DEAD. LOST POWER STEERING AND COASTED INTO PARKING LOT. SHUT CAR DOWN, FLOODED/PUMPED ACCELERATOR PEDAL. DIFFICULTY STARTING BUT WORKED, DROVE LIKE NORMAL, AGAIN. 10/14/12: TURNING FROM SIDESTREET, ON TO MAIN STREET -GOING 20 MPH. LOST ALL POWER AGAIN-MANUALLY TURNED COASTED CAR INTO LEFT MIDDLE TURNING LANE. RE-STARTED, OPERATED NORMAL. *TR Look up ODI 10481360 at NHTSA ↗	41.7% ODI 10763450 · 90,000 mi IN APRIL 2015 THE CHECK ENGINE LIGHT CAME ON IN MY 2010 VW ROUTAN, MAYBE A WEEK OR SO LATER IT STARTED TO STALL WHILE I WAS DRIVING IT. I TOOK IT TO AN IMPORT DEALER LOCALLY TO HAVE IT LOOKED AT AND WAS TOLD THAT THE EGR VALVE WAS BAD. THEY REPLACED IT, WHICH COST ME $400, AND PUT A NEW GAS CAP ON IT. IN JULY THE ENGINE LIGHT CAME ON AGAIN, HAD THE CODES RUN AT A PARTS STORE AND IT WAS THE EGR VALVE AGAIN. TOOK IT BACK TO THE SHOP THAT DID THE FIRST REPAIR BECAUSE IT STILL HAD A PARTS AND LABOR WARRANTEE WITH THEM. THEY REPLACED IT AGAIN. NOW, … Look up ODI 10763450 at NHTSA ↗	3922.3% ODI 10626580 · 60,000 mi 7/2/14 - AFTER BEING IDLE FOR 1HR THE CAR WOULD NOT START. AFTER SEVERAL REPEAT ATTEMPTS IT DID. IT WOULD CRANK AS NORMAL, NO DASHBOARD WARNING LIGHTS EVER CAME ON. 8/8/14 - AFTER 3HRS OF HIGHWAY DRIVING WE STOPPED TO FILL UP WITH GAS. ECO FUEL NEVER USED THE SAME CRANK ISSUE OCCURRED AS 7/2. 8/9/14 - AFTER 8HRS IDLE TIME THE VAN WOULD NOT START UNTIL REPEATED TRIES. I BROUGHT TO DEALERSHIP, THEY COULD NOT GET THE PROBLEM TO REPEAT AND SUSPECTED THE TPIM MODULE. 8/10/14 - AFTER 8HRS IDLE TIME THE VAN WOULD NOT START. WHEN IT FINALLY DID I… Look up ODI 10626580 at NHTSA ↗	812.7% ODI 11041088 · 60,800 mi TAKATA RECALL. HAVING PROBLEMS STARTING VAN ON FIRST TRY. VAN WILL STALL A FEW TIMES BEFORE STARTING. SOMETIMES THE BATTERY IS DRAIN. BATTERY HAS BEEN TESTED=GOOD! THIS HAS BEEN HAPPENING FOR 3 MONTHS. I AFTER READING AND RESEARCHING I COME TO A CONCLUSION THAT IT IS THE TIPM FUEL RELAY! Look up ODI 11041088 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Electronic Stability Control (Esc)	00.0% No examples available for this selection.	124.1% ODI 10639576 · 54,694 mi WHILE DRIVING IN JACKSONVILLE FLORIDA ON HIGHWAY, WIPERS SUDDENLY CAME ON, ALL IDIOT LIGHTS BEGAN TO BLINK, HEADLIGHTS BEGAN FLASHING OFF AND ON, BEEPING SOUND LIKE WHEN DOOR IS OPEN, THE VAN SUDDENLY DIED AND I WAS UNABLE TO BRAKE, STEER OR CONTROL VEHICLE. THE VAN WAS TOWED TO VW DEALERSHIP THE PROBLEM WAS FOUND TO BE THE SLIDING DOOR HARNESS WHICH WAS INTERFERING WITH NORMAL OPERATION OF THE ELECTRICAL SYSTEM. REPLACED SLIDING DOOR HARNESS AND FAILED BATTERY. WHEN I QUESTIONED THE FAULTY PART POSSIBLY BEING A RECALL ISSUE I WAS TOLD IT W… Look up ODI 10639576 at NHTSA ↗	93.8% ODI 10818389 · 64,000 mi TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. WHILE DRIVING APPROXIMATELY 20 MPH, THE ESP WARNING INDICATOR ILLUMINATED AND THE ENGINE SEIZED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 64,000. Look up ODI 10818389 at NHTSA ↗	126.9% ODI 10819083 · 20,000 mi INTERMITTENT STARTS AN STOPS TURN KEY WON`T START SOMETIMES TROUBLE STARTED IN 2012 TOOK IT TO SHOP DIDN`T ACT UP FOR THEM SAID NOTHING WAS WRONG SO I SORT OF LIVED WITH IT IT ALWAYS STARTED AFTER A FEW TRIES BUT LATLEY IT START TURNING OFF WHILE IM DRIVING WENT TO DEALER TOLD ME THEY NEVER HEARD OF SUCH A THING HAPPENING I TCAME HOME AN GOOGLED IT THERE WERE 2 RECALLS FOR THAT REASON FOR 2009 AN2010 VANS I BELIEVE THEY OUT RIGHT LIED TO ME APPARENTLY THE FIRST QUICK FIX RECALL GOT PUT IN MY VAN PLEASE HELP ME I`VE HAD 2 CLOSE CALLS ON THE HI… Look up ODI 10819083 at NHTSA ↗	11.6% ODI 11154490 · 70,000 mi TIPM - THE TIPM IN THE ROUTAN HAS BEEN NOTED AS MALFUNCTIONING ON MANY ONLINE FORUMS. MY TIPM MALFUNCTIONED AND MY VEHICLE SUDDENLY STOP ON A HIGHWAY WHILE DRIVING. THIS IS VERY DANGEROUS. Look up ODI 11154490 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.

Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.

Failure mileage by component

Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.

Component failure mileage distribution
Component	Mileage range (25th–75th percentile)	Median	Usable records	Examples
Electrical System	52,000–102,000 mi	75,000 mi	357	ODI 10288990 · 1,719 mi DRIVING APPROXIMATELY 25MPH WHEN THE ONE MONTH OLD VEHICLE JUST SUDDENLY FELT LIKE SOMEONE SLAMMED ON THE BRAKES. THE VEHICLE CAME TO A HALT. THE MOTOR WAS STILL RUNNING. I GOT IN THE CAR AGAIN TO MOVE IT OUT OF THE WAY AND THE SAME THING OCCURRED. IMMEDIATELY HAD IT TOWED TO THE VOLKSWAGEN DEALERSHIP. THERE IT STAYED FOR 13 DAYS. THE FOLLOWING PROBLEMS WERE REPAIRED/REPLACE: FAULTY TRANSMISSION SENSOR, REPLACED SENSOR. ALSO, ABS STEERING ANGLE SENSOR ERRATIC PERFORMANCE. FAULTY STEERING ANGLE SENSOR. REPLACED SENSOR. *TR Look up ODI 10288990 at NHTSA ↗ ODI 10336236 · 16,600 mi MY WIFE AND TWO DAUGHTERS WERE DRIVING IN OUR 2009 ROUTAN TODAY. MY WIFE SMELLED SMOKE AND NOTICED SMOKE EMANATING FROM OUR RIGHT SIDE SLIDING DOOR. MY WIFE PULLED OFF QUICKLY INTO A GAS STATION WHERE THE ATTENDANT EXTINGUISHED THE FIRE. THE FIRE CAUSED THE WINDOW TO EXPLODE; THE INTERIOR OF THE VEHICLE WAS FILLED WITH SMOKE WITHIN MINUTES OF EXITING THE CAR. FIRE CREW CAME TO INSPECT THE VEHICLE. WE HAVE HAD ISSUES WITH THIS SLIDING DOOR NOT CLOSING PROPERLY (ELECTRONICALLY) AND HAVE ASKED THE DEALERSHIP TO FIX THIS ISSUE WITH OUR RIGHT… Look up ODI 10336236 at NHTSA ↗ ODI 10353934 · 22,000 mi 2009 VOLKSWAGEN ROUTAN. 1) NORMAL VEHICLE, 22000 MILES, PUT AWAY IN ATTACHED GARAGE AT NIGHT. BEDROOMS ABOVE GARAGE. 2) BEFORE GOING TO BED I CHECKED TO BE SURE GARAGE DOOR WAS CLOSED. I FOUND VEHICLE IN GARAGE RUNNING. 3) VEHICLE HAS REMOTE START KEY. KEY SHOULD ONLY ACTIVATE PUSHING FIRST DOOR LOCK BUTTON AND THEN REMOTE START BUTTON TWICE. CHECKING SYSTEM I FOUND ONLY PUSHING REMOTE START BUTTON WILL START THE VEHICLE UNLOCKED. THIS IS A POSSIBLE DEADLY INCIDENT AS CARBON MONOXIDE WOULD UNDOUBTEDLY HAVE KILLED MY WHOLE FAMILY AS WE SLEPT H… Look up ODI 10353934 at NHTSA ↗
Engine	52,250–99,500 mi	71,750 mi	166	ODI 10481360 · 57,000 mi 10/7/12: ENTERING ONTO ROAD, BEGAN ACCELERATION UP TO 20/25 MPH -THEN ALL POWER, CONTROLS DEAD. LOST POWER STEERING AND COASTED INTO PARKING LOT. SHUT CAR DOWN, FLOODED/PUMPED ACCELERATOR PEDAL. DIFFICULTY STARTING BUT WORKED, DROVE LIKE NORMAL, AGAIN. 10/14/12: TURNING FROM SIDESTREET, ON TO MAIN STREET -GOING 20 MPH. LOST ALL POWER AGAIN-MANUALLY TURNED COASTED CAR INTO LEFT MIDDLE TURNING LANE. RE-STARTED, OPERATED NORMAL. TR Look up ODI 10481360 at NHTSA ↗ ODI 10491660 · 45,000 mi NOTICE OIL LIGHT COMING ON BETWEEN OIL CHANGE....FILLED OIL TO PROPER LEVEL...I TOOK CAR IN FOR SERVICE TODAY (1/7/13) WAS TOLD BY DEALERSHIP THE GASKET WILL NEED REPLACE, THAT WAS THE REASON FOR OIL USAGE. I JUST HAD MY VEHICLE IN TO FIX THE SLIDING DOOR (TSB RECALL NOT HONORED) IN OCTOBER AND IN WAS INSPECTED WITH NO PROBLEMS. DOING RESEARCH ON INTERNET AND FINDING THE OIL, DOOR IS A COMMON PROBLEM IN VW ROUTAN ( ALSO TALKED TO ANOTHER OWNER WAS IN FOR SAME PROBLEM, STATED HAS BEEN GIVEN RUNAROUND SINCE DAY ONE ABOUT PROBLEMS WITH HIS ROUTA… Look up ODI 10491660 at NHTSA ↗ ODI 10501019 · 59,500 mi WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. TR Look up ODI 10501019 at NHTSA ↗
Service Brakes	27,595–92,272 mi	64,840 mi	72	ODI 10461184 · 4,000 mi WE BOUGHT THIS VEHICLE IN APRIL OF 2009 BASED ON ALL OF THE "SAFETY FEATURES" AND AS IT TURNS OUT HAS BEEN ONE OF THE MOST UNSAFE VEHICLE I HAVE EVER OWNED. SINCE PURCHASE WE HAVE HAD THE ROTORS CUT 2X AND REPLACED ONCE DUE TO VIOLENT SHAKING IN FRONT END WHEN BRAKING AT ANY SPEED. THE FIRST TIME WE WERE TOLD THIS WAS DUE TO THE VEHICLES SITTING IN THE RAIN FOR A PERIOD OF TIME . WHAT ??? THAT MAY BE THE MOST AGGRAVATING OF ALL WHICH IS THAT VW WOULD RATHER ASSUME YOU ARE STUPID ENOUGH TO BELIEVE THAT. ANOTHER ISSUE HAS BEEN THAT THE HEAD UNIT … Look up ODI 10461184 at NHTSA ↗ ODI 10465347 · 22,000 mi PROBLEM WITH THE CAR: START VIBRATING WHEN BRAKES ARE APPLIED, THEN START SHAKING. I HAVE TAKE THE CAR TO 2 DIFFERENT DEALERS (4 DIFFERENT TIMES) SINCE JUNE 2011. FIRST TIME DEALER REPLACE BRAKE PADS AND ROTORS. SECOND TIME DEALER SERVICE REP TOLD "THAT NOTHING IS WRONG WITH IT". THIRD THEY SAID "THAT'S NORMAL WEAR AND TEAR" SUBMITTED A COMPLAINT THROUGH CORPORATE. A LADY FROM CORPORATE CALLED ME BACK AND TOLD ME THE SAME THING THE DEALER TOLD ME. SHE ALSO STATED THAT WILL FORWARD THE COMPLIANT TO THE DEALER MANAGER. FOURTH TIME: I TOO… Look up ODI 10465347 at NHTSA ↗ ODI 10508723 · 76,200 mi OUR ROUTAN WAS ONLY GOING ABOUT 20 MPH AFTER PULLING OUT OF PARKING PLACES AND TURNING IN TO MAIN ROADS THE POWER STEERING, BRAKES, GAS ALL STOP WORKING THE CAR BECOMES IMPOSSIBLE TO TURN THE WHEEL THE BRAKES AND GAS BOTH DO NOT WORK AND YOU HAVE TO COAST TO A STOP ONCE STOPPED YOU HAVE PUT THE VAN IN PARK TURN KEY OFF AND RESTART THE ENGINE. THIS HAS NOW HAPPENED TWICE IN A 2 WEEK TIME FRAME EXTREMELY CONCERNED WITH TWO YOUNG CHILDREN IN THE BACK BOTH IN CAR SEATS. WHAT HAPPENS IF I AM ON A FREEWAY AND THIS HAPPENS AT 60-70MPH? *TR Look up ODI 10508723 at NHTSA ↗
Steering	37,427–114,000 mi	80,000 mi	67	ODI 10288990 · 1,719 mi DRIVING APPROXIMATELY 25MPH WHEN THE ONE MONTH OLD VEHICLE JUST SUDDENLY FELT LIKE SOMEONE SLAMMED ON THE BRAKES. THE VEHICLE CAME TO A HALT. THE MOTOR WAS STILL RUNNING. I GOT IN THE CAR AGAIN TO MOVE IT OUT OF THE WAY AND THE SAME THING OCCURRED. IMMEDIATELY HAD IT TOWED TO THE VOLKSWAGEN DEALERSHIP. THERE IT STAYED FOR 13 DAYS. THE FOLLOWING PROBLEMS WERE REPAIRED/REPLACE: FAULTY TRANSMISSION SENSOR, REPLACED SENSOR. ALSO, ABS STEERING ANGLE SENSOR ERRATIC PERFORMANCE. FAULTY STEERING ANGLE SENSOR. REPLACED SENSOR. TR Look up ODI 10288990 at NHTSA ↗ ODI 10291507 · 9,000 mi TL THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE MAKING A RIGHT TURN AT 10 MPH THE VEHICLE SWERVED TO THE RIGHT WITHOUT EFFORT. THE ANTI-SKID WARNING SENSOR ILLUMINATED ON THE INSTRUMENT PANEL. AFTER REPEATED BRAKE APPLICATION HE WAS ABLE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE STEERING ANGLE SENSOR. NO REPAIRS WERE MADE BECAUSE THE PART WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 9,000. UPDATED 12/7/09 *CN UPDATED 12/0… Look up ODI 10291507 at NHTSA ↗ ODI 10400797 · 46,000 mi ENGINE SHUTDOWN-RESULTING IN LOSS OF STEERING. DURING NORMAL DRIVING SPEED BETWEEN 15-25 MPH, ENGINE SHUTS DOWN (QUITS RUNNING) DURING TURNS (EITHER DIRECTION) . MALE DRIVER OF VEHICLE IS RETIRED LAW ENFORCEMENT , TRAINED IN EMERGENCY PROCEDURES, DURING FAILURE IT TAKES EXTREME EFFORT TO MAINTAIN PHYSICAL CONTROL OF VEHICLE TO BRING TO A STOP. VEHICLE WILL NOT RESTART WHEN SHIFTING TO NEUTRAL WHILE MOVING, IGNITION IS ON WHEN FAILURE OCCURS. VEHICLE CAN BE RESTARTED AFTER STOPPING AND PLACING IN PARK. CAN REOCCUR WITHOUT WARNING . VEHICLE… Look up ODI 10400797 at NHTSA ↗
Power Train	38,000–98,000 mi	68,000 mi	49	ODI 10522951 · 63,000 mi WHERE TO BEGIN WITH THIS CAR. ALL 4 VALVE STEMS NEEDED TO BE REPLACED. I WAS LOSING PRESSURE IN MY TIRES, AND MECHANIC SAID THEY WERE CORRODED. THEN MY TIPTRONICS DID NOT WORK, ALSO WHEN YOU SHIFTED IN TO GEAR, IT DIDN'T WANT TO MOVE. HAD THE WHOLE SHIFTING LEVER COMPONENT REPLACED. LOTS OF TROUBLE WITH THE DOORS NOT OPENING RIGHT, THEN WHEN CLOSING THE SENSOR DOESN'T ALWAYS WORK. ALMOST HAD MY KIDS GET CAUGHT IN THE DOOR. IF THE CAR IS EVEN ON THE SLIGHTEST SLOPE THE DOOR WON'T CLOSE. WHILE DRIVING DOWN THE ROAD AT 55MPH THE CAR JUST SHUT OF… Look up ODI 10522951 at NHTSA ↗ ODI 10664225 · 76,000 mi CATASTROPHIC FAILURE OF TRANSMISSION AT 76K. MAJOR TRANSMISSION WORK DONE APPROXIMATELY 26K. TRANSMISSION REPLACED 6 MONTHS LATER AND STILL HAS ISSUES (SLUGGISH, NON-SMOOTH SHIFT BETWEEN GEARS AT HIGHER CRUISING SPEEDS. VW ENGINEER GERARDO ZELEDON CALLS THIS THE "ROUTAN SHAKE" AND CLAIMS THIS IS NORMAL. APPROXIMATELY 95,000 MILES STEERING BEGAN SEIZING UP WHILE IN MOTION. THIS IS, ACCORDING TO RECALL NOTICE AND SERVICE MANAGER AT FLOW VW WINSTON SALEM NC, A BEHAVIOR RELATED TO A RECALL ON THE IGNITION SWITCH (NTSHA 14V-396). NO PARTS ARE AVAILA… Look up ODI 10664225 at NHTSA ↗ ODI 10684264 · 34,031 mi TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT AFTER STOPPING AT TRAFFIC LIGHT, THE VEHICLE STALLED AND THE INSTRUMENT PANEL WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR TH… Look up ODI 10684264 at NHTSA ↗
Unknown Or Other	52,000–100,000 mi	75,000 mi	41	ODI 10267716 · 4,000 mi WE RECENTLY PURCHASED A 2009 VOLKSWAGEN ROUTAN SE WITH BOTH DRIVER AND PASSENGER AUTOMATIC SLIDING DOORS. OUR 4 YEAR OLD SON WENT TO OPEN THE REAR PASSENGER SIDE DOOR BY PULLING ON THE HANDLE, AND AT THE SAME TIME MY HUSBAND WENT TO OPEN THE DOOR BY PUSHING THE "DOOR OPEN" BUTTON ON THE KEY. AS A RESULT OF THIS, THE DOOR ENDED UP CLOSING COMPLETELY, AND LATCHING, ON MY SON'S HAND. IT ALSO WOULD ONLY OPEN ONCE MY HUSBAND FORCEFULLY PULLED THE DOOR OPEN. OF COURSE HIS HAND IMMEDIATELY SWELLED UP AND WE VISITED THE EMERGENCY DEPARTMENT, HAD XRAY'… Look up ODI 10267716 at NHTSA ↗ ODI 10630230 · 62,000 mi PASSENGER SIDE POWER SLIDING DOOR WIRE HARNESS KEEPS COMING OUT OF PLACE AND GETTING CAUGHT IN DOOR. LOCAL DEALER CLAIMS THIS HAS ALREADY BEEN REPAIRED UNDER THE RECALL BUT IT IS STILL HAPPENING. Look up ODI 10630230 at NHTSA ↗ ODI 10724199 · 42,000 mi THE ELECTRONIC DRIVER SIDE PASSENGER DOOR WILL NOT LATCH OPEN. THE DOOR WILL POWER OPEN THEN SLIDE BACK SHUT HITTING WHOEVER OR WHATEVER IS IN THE WAY. THIS IS AN INTERMITTENT PROBLEM. THE VAN WAS CHECKED BY OUR LOCAL DEALER SEVERAL TIMES OVER SEVERAL YEARS. THIS IS STILL AN ISSUE. THIS HAS LED TO MYSELF AND CHILDREN BEING HIT BY THE DOOR LEAVING BRUISES. IT ALMOST SMASHED MY 2 YEAR OLD DAYCARE CHILD'S LEG IN THE DOOR BUT I INTERVENED STOPPING THE DOOR PRIOR TO IT HITTING HER. I HAVE LOOKED ON THE INTERNET AND FOUND SEVERAL OTHER COMPLAINTS ALS… Look up ODI 10724199 at NHTSA ↗
Fuel/Propulsion System	60,600–100,750 mi	75,900 mi	44	ODI 10481360 · 57,000 mi 10/7/12: ENTERING ONTO ROAD, BEGAN ACCELERATION UP TO 20/25 MPH -THEN ALL POWER, CONTROLS DEAD. LOST POWER STEERING AND COASTED INTO PARKING LOT. SHUT CAR DOWN, FLOODED/PUMPED ACCELERATOR PEDAL. DIFFICULTY STARTING BUT WORKED, DROVE LIKE NORMAL, AGAIN. 10/14/12: TURNING FROM SIDESTREET, ON TO MAIN STREET -GOING 20 MPH. LOST ALL POWER AGAIN-MANUALLY TURNED COASTED CAR INTO LEFT MIDDLE TURNING LANE. RE-STARTED, OPERATED NORMAL. TR Look up ODI 10481360 at NHTSA ↗ ODI 10501019 · 59,500 mi WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. TR Look up ODI 10501019 at NHTSA ↗ ODI 10730842 · 52,577 mi I DRIVING LAST MONTH 47 MPH AND MY DRIVING SLIDING DOOR OPEN AND MY 8 YEARS GIRLS WAS DEAR AND SHE SCARE WHEN THE DOOR OPEN WHEN I DRIVING ,, AND WHEN I STOP THE DOOR NOT WANT TO CLOSE AUTOMATIC..THAT SCARE ME AND MY WIFE... THE OTHER CONCERN IS MY TRANSMISION HARD SHIFFTING ,HARD SHIFFTING , I READY TAKE LIKE 5,6 TIME MY VAN TO CHECK MY TRANSMISSION AND MY SLIDING DOOR AND THE SAY IS NORMAL , AND MY SLIDING DOOR NOT FOUND ANYTIME , THEY SAY THE SLIDING DOOR RECALL WAS DONE READY,, THE OTHER BIG CONCERN IS THE GAS MILEAGE, ONLY 11 OR 12 GALLON … Look up ODI 10730842 at NHTSA ↗
Electronic Stability Control (Esc)	64,750–122,250 mi	86,200 mi	32	ODI 10639576 · 54,694 mi WHILE DRIVING IN JACKSONVILLE FLORIDA ON HIGHWAY, WIPERS SUDDENLY CAME ON, ALL IDIOT LIGHTS BEGAN TO BLINK, HEADLIGHTS BEGAN FLASHING OFF AND ON, BEEPING SOUND LIKE WHEN DOOR IS OPEN, THE VAN SUDDENLY DIED AND I WAS UNABLE TO BRAKE, STEER OR CONTROL VEHICLE. THE VAN WAS TOWED TO VW DEALERSHIP THE PROBLEM WAS FOUND TO BE THE SLIDING DOOR HARNESS WHICH WAS INTERFERING WITH NORMAL OPERATION OF THE ELECTRICAL SYSTEM. REPLACED SLIDING DOOR HARNESS AND FAILED BATTERY. WHEN I QUESTIONED THE FAULTY PART POSSIBLY BEING A RECALL ISSUE I WAS TOLD IT W… Look up ODI 10639576 at NHTSA ↗ ODI 10669104 · 60,567 mi WE HAVE HAD SEVERAL OCCASIONS WHERE THE VAN COMPLETELY SHUTS OFF EVEN WHILE RUNNING. REPORTED IT TO OUR LOCAL VW DEALER AND HAVE BEEN TOLD THAT IT MIGHT BE AN IGNITION PROBLEM WHICH IS PART OF A RECALL. WAS INFORMED THAT AT THIS TIME THEY CAN'T REPAIR IT BECAUSE THEY DON'T MAKE THAT PART. HAD IT COMPLETELY SHUT DOWN ON US WHILE IT WAS GETTING SERVICED AT THE DEALER FOR NEW BRAKES. WAS TOLD THAT ALL IT NEEDED WAS NEW BATTERY. PAID FOR IT AND GOT IT TO START ONLY TO SHUT DOWN AGAIN TWO DAYS LATER. TOOK IT BACK AGAIN AND WAS TOLD THAT IT IS NOT … Look up ODI 10669104 at NHTSA ↗ ODI 10678483 · 135,000 mi VEHICLE LOOSES ALL POWER WHILE DRIVING. THIS HAS HAPPEN 3 TIMES IN 5 DAYS. HAPPENS RANDOMLY. TRIED USING ANOTHER KEY WITH NOTHING ON KEY CHAIN AND STILL HAPPENS. I ALSO TRIED TO GIGGLE KEY WHILE VEHICLE IS PARKED AND RUNNING BUT COULD NOT DUPLICATE LOSE OF POWER. THIS IS VERY, VERY DANGEROUS BECAUSE YOU HAVE LIMITED STEERING AND BRAKING WHEN ENGINE STALLS. VW WEB-SITE SAYS RECALL IS PENDING. THIS IS DANGEROUS!!!!! *TR Look up ODI 10678483 at NHTSA ↗

Complaint and recall timeline

Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.

ComponentPeriod

Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.

Monthly counts, recall campaigns and complaint examples

Monthly complaint and recall timeline
Month	Complaints	Campaigns announced	Examples
2024-10	0	None	No examples available for this selection.
2024-11	1	None	ODI 11624687 I bought this van just a few weeks ago. One day I was driving and all a sudden it lost power while in motion. This has happened 4xs so far. It could've resulted in the inability to stop my vehicle as the brakes are stiff after the power & engine stop working. It could've resulted in either I hit someone or someone could've hit me. My cousins husband had a town and country that did this & it was on a recall for the ignition switch failure. He's a mechanic. He has also stated what is going on is the ignition switch failure going into acces… Look up ODI 11624687 at NHTSA ↗
2024-12	0	None	No examples available for this selection.
2025-01	2	None	ODI 11639386 On 01/24/25 around 9pm I was leaving a friend house headed home. I took the i76 route home because it's faster. As I'm getting off on my exit, coming up on the first stop sign I start pressing down on the break pedal and all of a sudden the car engine shuts off and comes to a sudden seizure like halt. I put on my hazards lights instantly, put the car in park and proceeded to to start the car again. After like 10 failed start attempts. I decided to give it a rest and that's when I realized that there key would not come out the ignition, I had to… Look up ODI 11639386 at NHTSA ↗ ODI 11635180 loss of steering while driving, fluid loss multiple times since late september 2024(all while driving and no lights or warnings came on), 2 snapped serpentine belts, key ignition sticking(would not turn), dashboard not lighting up, rpm no longer rests below 1.5 - 2, car struggles to accelerate(especially uphill), car turns over and struggles to start, even though has newer battery. 1/9/25 driving to an appointment, upon reaching destination, a pop sound. No smell, no warnings came up on dashboard. Upon leaving, saw fluid leak, headed straight t… Look up ODI 11635180 at NHTSA ↗
2025-02	1	None	ODI 11643273 The brakes randomly stop working. At random times you go to brake and have to push the pedal all the way to the floor to start stopping. 2nd issue. The car dies and looses all power at intermittent times while driving. The car has to be restarted while driving. Could be driving 70 on a hwy or 30 on a residential street. Either coast to the side of the road to restart... or quickly put the car in neutral and restart it while driving. Both of these have almost caused wrecks several times. Unknown own causes to both as they happen a… Look up ODI 11643273 at NHTSA ↗
2025-03	0	None	No examples available for this selection.
2025-04	1	None	ODI 11653263 · 100,000 mi The contact was helping her friend who owns a 2010 Volkswagen Routan. The contact stated while driving at approximately 35 MPH, the vehicle stalled. The contact stated that the check engine and stability control warning lights were illuminated. The contact stated that the failure was a recurring failure. The contact had taken the vehicle to a local dealer and was informed that the vehicle was built by another manufacturer. The contact was then referred to another dealer. The contact was advised by the 2nd dealer that the vehicle should be taken… Look up ODI 11653263 at NHTSA ↗
2025-05	0	None	No examples available for this selection.
2025-06	0	None	No examples available for this selection.
2025-07	0	None	No examples available for this selection.
2025-08	0	None	No examples available for this selection.
2025-09	0	None	No examples available for this selection.
2025-10	0	None	No examples available for this selection.
2025-11	0	None	No examples available for this selection.
2025-12	0	None	No examples available for this selection.
2026-01	1	None	ODI 11712238 The contact owns a 2010 Volkswagen Routan. The contact stated that while driving at an undisclosed speed, the instrument cluster failed to function as intended. In addition, the contact stated that the turn signal and the speed control failed to function as designed. The vehicle was taken to an independent mechanic. The failure was troubleshooted; however, the failure was not diagnosed. In addition, the vehicle was taken to the dealer, and the failure was not diagnosed. The contact stated that neither the independent mechanic nor the dealer was… Look up ODI 11712238 at NHTSA ↗
2026-02	0	None	No examples available for this selection.
2026-03	0	None	No examples available for this selection.
2026-04	0	None	No examples available for this selection.
2026-05	0	None	No examples available for this selection.
2026-06	0	None	No examples available for this selection.
2026-07	0	None	No examples available for this selection.
2026-08	1	None	ODI 11759820 The contact owns a 2009 Volkswagen Routan. The contact received notification for NHTSA Campaign Number: 15V194000 (Electrical System); however, the part to complete the recall repair was not available. The local dealer was contacted to schedule the recall repair, but the part remained unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Look up ODI 11759820 at NHTSA ↗
2026-09 (partial)	0	None	No examples available for this selection.

Emerging complaint spikes

Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.

This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.

No complete months meet the spike thresholds for this selection.

Equal-age model-year comparison

Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.

Observation windowFirst model yearSecond model year

2013: 1 complaints · 2014: 1 complaints

Equal observation windows
Model year	Through age 0	Through age 1	Through age 2
2013	0	0	1
2014	0	0	1

Date coverage across each selected cohort

Date basis for all complaints in selected model years
Year	Incident dates used	Filing date fallbacks	Excluded dates
2013	7	0	0
2014	2	0	0

Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.

Components reported together

Each cell counts unique complaints naming both components. Open a nonzero cell for examples.

Component co-occurrence matrix
Component	Electrical System	Engine	Service Brakes	Steering	Power Train	Unknown Or Other	Fuel/Propulsion System	Electronic Stability Control (Esc)
Electrical System	—	88 ODI 10491660 · 45,000 mi NOTICE OIL LIGHT COMING ON BETWEEN OIL CHANGE....FILLED OIL TO PROPER LEVEL...I TOOK CAR IN FOR SERVICE TODAY (1/7/13) WAS TOLD BY DEALERSHIP THE GASKET WILL NEED REPLACE, THAT WAS THE REASON FOR OIL USAGE. I JUST HAD MY VEHICLE IN TO FIX THE SLIDING DOOR (TSB RECALL NOT HONORED) IN OCTOBER AND IN WAS INSPECTED WITH NO PROBLEMS. DOING RESEARCH ON INTERNET AND FINDING THE OIL, DOOR IS A COMMON PROBLEM IN VW ROUTAN ( ALSO TALKED TO ANOTHER OWNER WAS IN FOR SAME PROBLEM, STATED HAS BEEN GIVEN RUNAROUND SINCE DAY ONE ABOUT PROBLEMS WITH HIS ROUTA… Look up ODI 10491660 at NHTSA ↗ ODI 10501019 · 59,500 mi WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. TR Look up ODI 10501019 at NHTSA ↗ ODI 10578476 · 64,000 mi WE HAVE A 2009 VW ROUTAN SEL THAT HAS STALLED MULTIPLE TIMES NOW (4-5) WHILE DRIVING. THERE IS NO WARNING AND CAR LOSES POWER. CAR STARTS UP IMMEDIATELY AFTER PUTTING IN PARK AND RESTARTING. THIS SEEMS TO BE COMMON PROBLEM AND THERE IS A RECALL FOR THE 2010 MODEL AS WELL AS THE CHRYSLER MINIVAN WHICH THIS CAR IS BASED FROM. TR Look up ODI 10578476 at NHTSA ↗	24 ODI 10508723 · 76,200 mi OUR ROUTAN WAS ONLY GOING ABOUT 20 MPH AFTER PULLING OUT OF PARKING PLACES AND TURNING IN TO MAIN ROADS THE POWER STEERING, BRAKES, GAS ALL STOP WORKING THE CAR BECOMES IMPOSSIBLE TO TURN THE WHEEL THE BRAKES AND GAS BOTH DO NOT WORK AND YOU HAVE TO COAST TO A STOP ONCE STOPPED YOU HAVE PUT THE VAN IN PARK TURN KEY OFF AND RESTART THE ENGINE. THIS HAS NOW HAPPENED TWICE IN A 2 WEEK TIME FRAME EXTREMELY CONCERNED WITH TWO YOUNG CHILDREN IN THE BACK BOTH IN CAR SEATS. WHAT HAPPENS IF I AM ON A FREEWAY AND THIS HAPPENS AT 60-70MPH? TR Look up ODI 10508723 at NHTSA ↗ ODI 10649852 · 12,000 mi OIL CONSUMPTION SINCE 24000 MILES. VW DEALER NEVER WANT TO ADDRESS THE PROBLEM. KEEP TELL ME THIS NORMAL. NOW I HAVE TO ADD QUARTER OIL EVERY MONTH. ON MORNING CAR WASN'T STARTING AND TOOK TO THE DEALER AND HAD THE IGNITION REPLACED AT 42000 MILES BUT NOW THE KEY GET STUCK ON IGNITION MULTIPLE TIMES. I HOPE THE RECALL WILL FIX THIS PROBLEM. I HAD TO REPLACE BRAKES AT 12000 MILES DUE THE VIBRATION WHILE BRAKES. I HAD MULTIPLES ELECTRICAL PROBLEMS AND SOME WAS REPAIR AFTER COUPLE TRIPS TO THE DEALER. THIS CAR IS A LEMON. WHEN WE WILL HAVE OUR MO… Look up ODI 10649852 at NHTSA ↗ ODI 10679807 · 87,500 mi WHILE DRIVING TYPICALLY AT SPEEDS LESS THAN 45 MPH THE VEHICLE ENGINE WILL SHUT DOWN AND ELECTRICAL POWER AT THE DASH IS LOST. VEHICLE WILL RESTART AFTER IT SHUTS DOWN. PROBLEM IS NOT CONSISTENT. DEALER CAN NOT VERIFY THE COMPLAINT, THEREFORE CAN NOT REPAIR. NHTSA RECALL 14V396 APPEARS TO BE THE CORRECTION FOR THE ISSUE. DEALER WILL NOT PERFORM THE RECALL UNTIL THEY DUPLICATE THE ISSUE. HAS BEEN AT THE DEALER FOR 6 DAYS WITH NO DUPLICATION OF THE COMPLAINT. TR Look up ODI 10679807 at NHTSA ↗	33 ODI 10288990 · 1,719 mi DRIVING APPROXIMATELY 25MPH WHEN THE ONE MONTH OLD VEHICLE JUST SUDDENLY FELT LIKE SOMEONE SLAMMED ON THE BRAKES. THE VEHICLE CAME TO A HALT. THE MOTOR WAS STILL RUNNING. I GOT IN THE CAR AGAIN TO MOVE IT OUT OF THE WAY AND THE SAME THING OCCURRED. IMMEDIATELY HAD IT TOWED TO THE VOLKSWAGEN DEALERSHIP. THERE IT STAYED FOR 13 DAYS. THE FOLLOWING PROBLEMS WERE REPAIRED/REPLACE: FAULTY TRANSMISSION SENSOR, REPLACED SENSOR. ALSO, ABS STEERING ANGLE SENSOR ERRATIC PERFORMANCE. FAULTY STEERING ANGLE SENSOR. REPLACED SENSOR. TR Look up ODI 10288990 at NHTSA ↗ ODI 10508723 · 76,200 mi OUR ROUTAN WAS ONLY GOING ABOUT 20 MPH AFTER PULLING OUT OF PARKING PLACES AND TURNING IN TO MAIN ROADS THE POWER STEERING, BRAKES, GAS ALL STOP WORKING THE CAR BECOMES IMPOSSIBLE TO TURN THE WHEEL THE BRAKES AND GAS BOTH DO NOT WORK AND YOU HAVE TO COAST TO A STOP ONCE STOPPED YOU HAVE PUT THE VAN IN PARK TURN KEY OFF AND RESTART THE ENGINE. THIS HAS NOW HAPPENED TWICE IN A 2 WEEK TIME FRAME EXTREMELY CONCERNED WITH TWO YOUNG CHILDREN IN THE BACK BOTH IN CAR SEATS. WHAT HAPPENS IF I AM ON A FREEWAY AND THIS HAPPENS AT 60-70MPH? TR Look up ODI 10508723 at NHTSA ↗ ODI 10519722 · 200 mi COMPLETELY LOST CONTROL OF THE VEHICLE (NO POWER, NO POWER STEERING) WHILE DRIVING 45MPH ON A 7 LANE MAJOR STREET. THANKFULLY IT WAS IN THE EARLY MORNING HOURS AND I WAS ABLE TO GLIDE ACROSS THE INTERSECTION TO A SIDE STREET WHERE I TURNED THE VEHICLE OFF AND ON AND IT RESUMED POWER. THIS HAS HAPPENED AT LEAST 4 MORE TIMES SINCE THEN, USUALLY WHILE IDLING AT A RED LIGHT. *TR Look up ODI 10519722 at NHTSA ↗	21 ODI 10522951 · 63,000 mi WHERE TO BEGIN WITH THIS CAR. ALL 4 VALVE STEMS NEEDED TO BE REPLACED. I WAS LOSING PRESSURE IN MY TIRES, AND MECHANIC SAID THEY WERE CORRODED. THEN MY TIPTRONICS DID NOT WORK, ALSO WHEN YOU SHIFTED IN TO GEAR, IT DIDN'T WANT TO MOVE. HAD THE WHOLE SHIFTING LEVER COMPONENT REPLACED. LOTS OF TROUBLE WITH THE DOORS NOT OPENING RIGHT, THEN WHEN CLOSING THE SENSOR DOESN'T ALWAYS WORK. ALMOST HAD MY KIDS GET CAUGHT IN THE DOOR. IF THE CAR IS EVEN ON THE SLIGHTEST SLOPE THE DOOR WON'T CLOSE. WHILE DRIVING DOWN THE ROAD AT 55MPH THE CAR JUST SHUT OF… Look up ODI 10522951 at NHTSA ↗ ODI 10684264 · 34,031 mi TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT AFTER STOPPING AT TRAFFIC LIGHT, THE VEHICLE STALLED AND THE INSTRUMENT PANEL WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR TH… Look up ODI 10684264 at NHTSA ↗ ODI 10701917 · 70,000 mi TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE IN PARK, THE VEHICLE FAILED TO START. WHILE DRIVING AT 40 MPH, THERE WAS A BEEPING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE RANGE SELECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF THE … Look up ODI 10701917 at NHTSA ↗	27 ODI 10724199 · 42,000 mi THE ELECTRONIC DRIVER SIDE PASSENGER DOOR WILL NOT LATCH OPEN. THE DOOR WILL POWER OPEN THEN SLIDE BACK SHUT HITTING WHOEVER OR WHATEVER IS IN THE WAY. THIS IS AN INTERMITTENT PROBLEM. THE VAN WAS CHECKED BY OUR LOCAL DEALER SEVERAL TIMES OVER SEVERAL YEARS. THIS IS STILL AN ISSUE. THIS HAS LED TO MYSELF AND CHILDREN BEING HIT BY THE DOOR LEAVING BRUISES. IT ALMOST SMASHED MY 2 YEAR OLD DAYCARE CHILD'S LEG IN THE DOOR BUT I INTERVENED STOPPING THE DOOR PRIOR TO IT HITTING HER. I HAVE LOOKED ON THE INTERNET AND FOUND SEVERAL OTHER COMPLAINTS ALS… Look up ODI 10724199 at NHTSA ↗ ODI 10764970 · 110,000 mi VEHICLE STALLED SEVERAL TIMES APPROXIMATELY FEBRUARY 17, 2015.THEN FINALLY WOULDN'T START AT ALL. EMERGENCY ROAD SIDE ASSISTANCE CAME GOT CAR STARTED. THEN WHILE DRIVING DASHBOARD STARTED BLINKING POWER WAS LOST CAR CUT OFF. HAD TO CONTACT ROAD SIDE ASSISTANCE AGAIN TO HAVE CART TOWED TO REPAIR FACILITY. COULD NOT FIND OUT PROBLEM SUGGESTED TO BE TOWED TO DEALER. DEALER COULDN'T FIND THE PROBLEM INITIALLY THEN FOUND IT MADE REPAIRS WHICH I FOUND OUT LATER IT WAS PARTLY DUE TO THE RECALL (28H1.) THEN APPROXIMATELY THE MIDDLE OF JULY 2015 CAR BE… Look up ODI 10764970 at NHTSA ↗ ODI 10821636 · 89,000 mi I BOUGHT A CERTIFIED PRE-OWNED 2009 ROUTAN. AFTER ABOUT A YEAR, THE CAR RANDOMLY WILL NOT START, IT JUST CLICKS BUT WILL NOT START. REPLACED BATTERY. STILL - CAR WILL NOT START. THIS HAS BEEN GOING ON FOR 3 YEARS. HAD STARTER & ALTERNATOR CHECKED - BOTH GOOD. HAD THE IGNITION RECALL DONE AND PROBLEM RESOLVED ITSELF FOR ABOUT 3 MONTHS - NOW IT STARTED DOING THIS AGAIN - RANDOMLY WILL NOT START. HUBBY MOVED A WIRE UNDER THE HOOD AND MAGICALLY THE CAR STARTED. GOT HOME AND VAN WILL NOT START! AFTER SPENDING $5,200 ON A NEW TRANSMISSION - I HAT… Look up ODI 10821636 at NHTSA ↗	41 ODI 10501019 · 59,500 mi WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. *TR Look up ODI 10501019 at NHTSA ↗ ODI 10730842 · 52,577 mi I DRIVING LAST MONTH 47 MPH AND MY DRIVING SLIDING DOOR OPEN AND MY 8 YEARS GIRLS WAS DEAR AND SHE SCARE WHEN THE DOOR OPEN WHEN I DRIVING ,, AND WHEN I STOP THE DOOR NOT WANT TO CLOSE AUTOMATIC..THAT SCARE ME AND MY WIFE... THE OTHER CONCERN IS MY TRANSMISION HARD SHIFFTING ,HARD SHIFFTING , I READY TAKE LIKE 5,6 TIME MY VAN TO CHECK MY TRANSMISSION AND MY SLIDING DOOR AND THE SAY IS NORMAL , AND MY SLIDING DOOR NOT FOUND ANYTIME , THEY SAY THE SLIDING DOOR RECALL WAS DONE READY,, THE OTHER BIG CONCERN IS THE GAS MILEAGE, ONLY 11 OR 12 GALLON … Look up ODI 10730842 at NHTSA ↗ ODI 11000831 · 110,000 mi ENGINE WILL NOT START. HAPPENS ON OCCASION BUT HAPPENED ENOUGH THAT I HAD TWO STARTERS INSTALLED AS WELL AS A BATTERY. WHAT ELSE COULD IT BE? CAN TURN THE KEY AND NOTHING HAPPENS. I CAN POSSIBLY SIT THERE AND TURN THE IGNITION 10+ TIMES AND STILL NOTHING. THOUGHT IT COULD BE A BAD SPOT IN THE NEW STARTER?? CLEANED BATTERY POSTS OFTEN AND NOW HAVE TREATED THE CONNECTIONS. WOULD LIKE NOT TO RECEIVE ANOTHER CALL FROM LOVELY WIFE THAT THE VAN WOULD NOT START. HAS TO BE SOMETHING WITH A CIRCUIT STAYING OPEN OR SOMETHING. SAFETY ISSUE DUE… Look up ODI 11000831 at NHTSA ↗	24 ODI 10639576 · 54,694 mi WHILE DRIVING IN JACKSONVILLE FLORIDA ON HIGHWAY, WIPERS SUDDENLY CAME ON, ALL IDIOT LIGHTS BEGAN TO BLINK, HEADLIGHTS BEGAN FLASHING OFF AND ON, BEEPING SOUND LIKE WHEN DOOR IS OPEN, THE VAN SUDDENLY DIED AND I WAS UNABLE TO BRAKE, STEER OR CONTROL VEHICLE. THE VAN WAS TOWED TO VW DEALERSHIP THE PROBLEM WAS FOUND TO BE THE SLIDING DOOR HARNESS WHICH WAS INTERFERING WITH NORMAL OPERATION OF THE ELECTRICAL SYSTEM. REPLACED SLIDING DOOR HARNESS AND FAILED BATTERY. WHEN I QUESTIONED THE FAULTY PART POSSIBLY BEING A RECALL ISSUE I WAS TOLD IT W… Look up ODI 10639576 at NHTSA ↗ ODI 10669104 · 60,567 mi WE HAVE HAD SEVERAL OCCASIONS WHERE THE VAN COMPLETELY SHUTS OFF EVEN WHILE RUNNING. REPORTED IT TO OUR LOCAL VW DEALER AND HAVE BEEN TOLD THAT IT MIGHT BE AN IGNITION PROBLEM WHICH IS PART OF A RECALL. WAS INFORMED THAT AT THIS TIME THEY CAN'T REPAIR IT BECAUSE THEY DON'T MAKE THAT PART. HAD IT COMPLETELY SHUT DOWN ON US WHILE IT WAS GETTING SERVICED AT THE DEALER FOR NEW BRAKES. WAS TOLD THAT ALL IT NEEDED WAS NEW BATTERY. PAID FOR IT AND GOT IT TO START ONLY TO SHUT DOWN AGAIN TWO DAYS LATER. TOOK IT BACK AGAIN AND WAS TOLD THAT IT IS NOT … Look up ODI 10669104 at NHTSA ↗ ODI 10702805 · 73,000 mi IN JULY 2012 I BOUGHT A CERTIFIED PRE-OWNED 2009 VOLKSWAGEN ROUTAN MINIVAN. I HAVE REPORTED THE FOLLOWING MAJOR SAFETY PROBLEMS ON SEVERAL OCCASIONS TO NO RESOLVE: LOSS OF POWER' THE CAR WILL COMPLETELY LOSE POWER AND THE STEERING WHEEL LOCKS WHILE DRIVING. FOR EX ON 12/22 FROM 5:32P ' 10:48P, THE CAR LOST POWER AND STEERING WHEEL LOCKED 11 TIMES. SLIDING DOORS AUTOMATICALLY OPEN ' THE DOORS WILL NOT CLOSE SECURELY, WON'T OPEN, OR WILL APPEAR CLOSED AND SPONTANEOUSLY REOPEN. THERE HAVE BEEN SEVERAL TIMES WE WILL GO OUT FOR THE EVENING OR COME O… Look up ODI 10702805 at NHTSA ↗
Engine	88 ODI 10491660 · 45,000 mi NOTICE OIL LIGHT COMING ON BETWEEN OIL CHANGE....FILLED OIL TO PROPER LEVEL...I TOOK CAR IN FOR SERVICE TODAY (1/7/13) WAS TOLD BY DEALERSHIP THE GASKET WILL NEED REPLACE, THAT WAS THE REASON FOR OIL USAGE. I JUST HAD MY VEHICLE IN TO FIX THE SLIDING DOOR (TSB RECALL NOT HONORED) IN OCTOBER AND IN WAS INSPECTED WITH NO PROBLEMS. DOING RESEARCH ON INTERNET AND FINDING THE OIL, DOOR IS A COMMON PROBLEM IN VW ROUTAN ( ALSO TALKED TO ANOTHER OWNER WAS IN FOR SAME PROBLEM, STATED HAS BEEN GIVEN RUNAROUND SINCE DAY ONE ABOUT PROBLEMS WITH HIS ROUTA… Look up ODI 10491660 at NHTSA ↗ ODI 10501019 · 59,500 mi WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. TR Look up ODI 10501019 at NHTSA ↗ ODI 10578476 · 64,000 mi WE HAVE A 2009 VW ROUTAN SEL THAT HAS STALLED MULTIPLE TIMES NOW (4-5) WHILE DRIVING. THERE IS NO WARNING AND CAR LOSES POWER. CAR STARTS UP IMMEDIATELY AFTER PUTTING IN PARK AND RESTARTING. THIS SEEMS TO BE COMMON PROBLEM AND THERE IS A RECALL FOR THE 2010 MODEL AS WELL AS THE CHRYSLER MINIVAN WHICH THIS CAR IS BASED FROM. TR Look up ODI 10578476 at NHTSA ↗	—	27 ODI 10537923 · 47,000 mi TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS RESTARTED. THE VEHICLE RESUMED NORMAL FUNCTION. THE CONTACT ALSO MENTIONED THAT THE BRAKES HAD TO BE REPLACED OFTEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 47,000. Look up ODI 10537923 at NHTSA ↗ ODI 10607348 AT LEAST TWICE PER MONTH WHEN I DRIVE MY VAN, THE STEERING WILL SUDDENLY GO OUT, THEN THE BRAKES WILL STOP WORKING, THEN IT WILL JUST SHUT OFF. SO FAR IT HAS ONLY HAPPENED WHEN I WAS DRIVING AT PRETTY LOW RATES OF SPEED. I'VE CALLED THE VW DEALERSHIP SEVERAL TIMES AND EACH TIME THEY SAY THAT THEY HAVEN'T HEARD OF ANYTHING LIKE THIS BEFORE AND WANT TO CHARGE ME A FORTUNE JUST TO LOOK AT IT. WITH THE NEWEST RECALL, I CANNOT UNDERSTAND WHY MY VEHICLE IS NOT INCLUDED AND THE DEALERSHIP STILL CLAIMS THAT THEY HAVE NO CLUE WHAT I'M TAKING ABOUT WH… Look up ODI 10607348 at NHTSA ↗ ODI 10621954 · 91,000 mi THE ENGINE TURNED TO OFF WHILE I WAS DRIVING AND DEPOWERED POWER STEERING AND BRAKES. AT THAT POINT I RESTARTED THE CAR AND WAS ABLE TO DRIVE. TOOK THE CAR IMMEDIATELY TO VW DEALER, KEPT THE CAR FOR 24 HOURS, AND THEY COULD NOT REPLICATE THE INCIDENT SO NOTHING WAS DONE BY THEM. THIS HAPPENED AGAIN AT 93000 MILES ON AUGUST 8, 2014. *TR Look up ODI 10621954 at NHTSA ↗	27 ODI 10607348 AT LEAST TWICE PER MONTH WHEN I DRIVE MY VAN, THE STEERING WILL SUDDENLY GO OUT, THEN THE BRAKES WILL STOP WORKING, THEN IT WILL JUST SHUT OFF. SO FAR IT HAS ONLY HAPPENED WHEN I WAS DRIVING AT PRETTY LOW RATES OF SPEED. I'VE CALLED THE VW DEALERSHIP SEVERAL TIMES AND EACH TIME THEY SAY THAT THEY HAVEN'T HEARD OF ANYTHING LIKE THIS BEFORE AND WANT TO CHARGE ME A FORTUNE JUST TO LOOK AT IT. WITH THE NEWEST RECALL, I CANNOT UNDERSTAND WHY MY VEHICLE IS NOT INCLUDED AND THE DEALERSHIP STILL CLAIMS THAT THEY HAVE NO CLUE WHAT I'M TAKING ABOUT WH… Look up ODI 10607348 at NHTSA ↗ ODI 10620722 · 55,000 mi OUR 2009 VW ROUTAN COMPLETELY SHUTS DOWN WHILE DRIVING 3 TIMES NOW. NOT ONLY DOES IT SHUT DOWN, BUT THE STEERING AND BRAKES LOCK AS WELL. ON THE LAST OCCURRENCE, MY WIFE (WITH OUR CHILDREN IN THE CAR) CAME VERY CLOSE TO HITTING A PARKED CAR IN THE STREET. WE HAVE TAKEN IT TO 2 VW DEALERS SO FAR IN CHARLOTTE, NC AND THEY STATE: "WE CANNOT DUPLICATE THE ISSUE." UNFORTUNATELY, THAT IS NOT THE RIGHT ANSWER WHEN YOU HAVE SOMETHING AS DANGEROUS AS THIS HAPPENING TO OUR FAMILY CAR. WE HAVE CALLED VW CORPORATE TO HELP 2ND DEALERSHIP WITH A RESOLUTI… Look up ODI 10620722 at NHTSA ↗ ODI 10621954 · 91,000 mi THE ENGINE TURNED TO OFF WHILE I WAS DRIVING AND DEPOWERED POWER STEERING AND BRAKES. AT THAT POINT I RESTARTED THE CAR AND WAS ABLE TO DRIVE. TOOK THE CAR IMMEDIATELY TO VW DEALER, KEPT THE CAR FOR 24 HOURS, AND THEY COULD NOT REPLICATE THE INCIDENT SO NOTHING WAS DONE BY THEM. THIS HAPPENED AGAIN AT 93000 MILES ON AUGUST 8, 2014. *TR Look up ODI 10621954 at NHTSA ↗	14 ODI 10712217 · 75,400 mi I WENT TO PASS A VEHICLE AT 65MPH AND THE ACCELERATOR PEDAL DID NOT RELEASE, THE VAN HIT 80-MPH BEFORE I POPPED IT IN NEUTRAL AND THEN BACK INTO DRIVE TO CORRECT THE ISSUE. HITTING THE BRAKES HAD NO EFFECT ON THE UNINTENDED ACCELERATION. THIS VEHICLE IS MECHANICALLY IDENTICAL TO CHRYSLER TOWN & COUNTRY AND DADGE GRAND CARAVAN, SEE OTHER IDENTICAL COMPLAINTS HERE: HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/14835/DODGE/VOYAGER/DODGE-GRAND-CARAVAN-SUDDEN-ACCELERATION? TR Look up ODI 10712217 at NHTSA ↗ ODI 10717419 · 51,496 mi THE FIRST INCIDENT WITH A "CLUNKING" NOISE OF THE TRANSMISSION BEGAN ON 7/10/2014 AT 51,496 MILES. WHEN SHIFTING FROM REVERSE TO DRIVE CAR MAKES A "CLUNKING" NOISE AND JERKS THE CAR FORWARD. IT WAS NOTED BY DEALERSHIP AFTER A TEST DRIVE NO FAULTS FOUND. ON 3/19/15 AT 58,611 MILES CAR RETURNED TO DEALERSHIP. SAME CLUNKING AND GRINDING NOISES. FAULTS: P0868, P1790 & P0944. PRESSURE READINGS TO LOW IN TCM CONTROL WIRES. TRANSMISSION TO BE REPLACED PER DEALERSHIP. FINDINGS: UNDER DRIVE CLUTCHES WORN OUT, SUNGEARS AND ASSEMBLY DAMAGED WITH METAL MET… Look up ODI 10717419 at NHTSA ↗ ODI 11151140 · 115,226 mi TL THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING BETWEEN 30 TO 65 MPH, THE VEHICLE RANDOMLY JERKED FORWARD AND BACKWARD AS IF IT WERE SKIPPING A GEAR. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED AFTERWARDS SEVERAL TIMES. THE CONTACT SPOKE WITH TWO UNKNOWN DEALERS AND THEN CONTACTED AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE UNDERDRIVE SOLENOID CIRCUIT OF THE TRANSMISSION WAS MALFUNCTIONING. AFTER CONDUCTING SOME RESEARCH, THE CONTACT FOUND THAT THE MANUFACTURER PLACED A CHRYSLER ENGINE AND TRANSMISSION INTO HER … Look up ODI 11151140 at NHTSA ↗	11 ODI 10995198 · 134,692 mi WHILE DRIVING AT 65 MPH ON I35, THE CAR'S TRANSMISSION ACTED LIKE IT SLIPPED INTO 2ND GEAR AND THE TACK WENT TO 5000RPM. I TRIED TO JUST SLOW DOWN AND GET OFF THE ROAD, TURNED THE CAR OFF AND BACK ON WHEN I GOT TO A PARKING LOT. I THEN STARTED DRIVING AGAIN AND IT APPEARED TO BE ALRIGHT. WITHIN A FEW DAYS IT DID IT A COUPLE TIMES MORE, THIS TIME TURNING ON THE CHECK ENGINE LIGHT. TOOK IT TO THE DEALER AND THEY COULDN'T DUPLICATE PROBLEM IN THE WEEK THEY HAD IT. PICKED IT UP FROM THE DEALERSHIP AND WAS ABOUT 10 TO 15 MILES AWAY AND IT DID I… Look up ODI 10995198 at NHTSA ↗ ODI 11052059 · 70,000 mi WHILE DRIVING ON STREET OR HIGHWAY OR STOPPED. USUALLY AROUND 20-40MPH CAR STALLS. BRAKES LOCK UP/STEERING WHEEL LOCKS UP/NO CONTROL OF CAR AT ALL. ALL LIGHTS INDICATE CAR IS ON, ONE BELL GOES OFF PRIOR AND ANTI-SKID LIGHT COMES ON. BY THEN PANIC CANNOT CONTROL CAR! PUT CAR IN PARK AFTER STOPPED AND IT STARTS RIGHT UP. Look up ODI 11052059 at NHTSA ↗ ODI 11290284 CAR ELECTRICAL SYSTEM GOES CRAZY, SPEEDOMETER NEEDLE GOES CRAZY. RADIO TURNS OFF AND ON, THEN THE VEHICLE TURNS OFF COMPLETELY. IT TURNS ON AFTER. SOMETIMES ALL THIS HAPPENS BEFORE TURNING OFF, SOMETIMES IT TURNS OFF SUDDENLY WITH NO WARNING. HAVE SPENT A LOT OF MONEY TRYING TO FIX ISSUE WITH NO LUCK. DRIVING IT MAKES ME VERY NERVOUS BUT I CAN'T CHANGE CARS RIGHT NOW. IT HAS HAPPENED BOTH ON SMALL STREETS AND HIGHWAY IN MOTION. Look up ODI 11290284 at NHTSA ↗	17 ODI 10481360 · 57,000 mi 10/7/12: ENTERING ONTO ROAD, BEGAN ACCELERATION UP TO 20/25 MPH -THEN ALL POWER, CONTROLS DEAD. LOST POWER STEERING AND COASTED INTO PARKING LOT. SHUT CAR DOWN, FLOODED/PUMPED ACCELERATOR PEDAL. DIFFICULTY STARTING BUT WORKED, DROVE LIKE NORMAL, AGAIN. 10/14/12: TURNING FROM SIDESTREET, ON TO MAIN STREET -GOING 20 MPH. LOST ALL POWER AGAIN-MANUALLY TURNED COASTED CAR INTO LEFT MIDDLE TURNING LANE. RE-STARTED, OPERATED NORMAL. TR Look up ODI 10481360 at NHTSA ↗ ODI 10501019 · 59,500 mi WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. TR Look up ODI 10501019 at NHTSA ↗ ODI 11000831 · 110,000 mi ENGINE WILL NOT START. HAPPENS ON OCCASION BUT HAPPENED ENOUGH THAT I HAD TWO STARTERS INSTALLED AS WELL AS A BATTERY. WHAT ELSE COULD IT BE? CAN TURN THE KEY AND NOTHING HAPPENS. I CAN POSSIBLY SIT THERE AND TURN THE IGNITION 10+ TIMES AND STILL NOTHING. THOUGHT IT COULD BE A BAD SPOT IN THE NEW STARTER?? CLEANED BATTERY POSTS OFTEN AND NOW HAVE TREATED THE CONNECTIONS. WOULD LIKE NOT TO RECEIVE ANOTHER CALL FROM LOVELY WIFE THAT THE VAN WOULD NOT START. HAS TO BE SOMETHING WITH A CIRCUIT STAYING OPEN OR SOMETHING. SAFETY ISSUE DUE… Look up ODI 11000831 at NHTSA ↗	8 ODI 10639576 · 54,694 mi WHILE DRIVING IN JACKSONVILLE FLORIDA ON HIGHWAY, WIPERS SUDDENLY CAME ON, ALL IDIOT LIGHTS BEGAN TO BLINK, HEADLIGHTS BEGAN FLASHING OFF AND ON, BEEPING SOUND LIKE WHEN DOOR IS OPEN, THE VAN SUDDENLY DIED AND I WAS UNABLE TO BRAKE, STEER OR CONTROL VEHICLE. THE VAN WAS TOWED TO VW DEALERSHIP THE PROBLEM WAS FOUND TO BE THE SLIDING DOOR HARNESS WHICH WAS INTERFERING WITH NORMAL OPERATION OF THE ELECTRICAL SYSTEM. REPLACED SLIDING DOOR HARNESS AND FAILED BATTERY. WHEN I QUESTIONED THE FAULTY PART POSSIBLY BEING A RECALL ISSUE I WAS TOLD IT W… Look up ODI 10639576 at NHTSA ↗ ODI 10669104 · 60,567 mi WE HAVE HAD SEVERAL OCCASIONS WHERE THE VAN COMPLETELY SHUTS OFF EVEN WHILE RUNNING. REPORTED IT TO OUR LOCAL VW DEALER AND HAVE BEEN TOLD THAT IT MIGHT BE AN IGNITION PROBLEM WHICH IS PART OF A RECALL. WAS INFORMED THAT AT THIS TIME THEY CAN'T REPAIR IT BECAUSE THEY DON'T MAKE THAT PART. HAD IT COMPLETELY SHUT DOWN ON US WHILE IT WAS GETTING SERVICED AT THE DEALER FOR NEW BRAKES. WAS TOLD THAT ALL IT NEEDED WAS NEW BATTERY. PAID FOR IT AND GOT IT TO START ONLY TO SHUT DOWN AGAIN TWO DAYS LATER. TOOK IT BACK AGAIN AND WAS TOLD THAT IT IS NOT … Look up ODI 10669104 at NHTSA ↗ ODI 10995677 · 130,000 mi AS WE ARE DRIVING THE POWER STEERING COMPLETELY CUTS OFF AND WILL NOT LET YOU DRIVE - THE ENGINE SHUTS OFF AND YOUR FORCED INTO TURNING THE VEHICLE COMPLETELY OFF THEM BACK ON AGAIN. THIS HAPPENED WHILE ON THE INTERSTATE IN TRAFFIC WHICH NEARLY CAUSED A COLLISION. Look up ODI 10995677 at NHTSA ↗
Service Brakes	24 ODI 10508723 · 76,200 mi OUR ROUTAN WAS ONLY GOING ABOUT 20 MPH AFTER PULLING OUT OF PARKING PLACES AND TURNING IN TO MAIN ROADS THE POWER STEERING, BRAKES, GAS ALL STOP WORKING THE CAR BECOMES IMPOSSIBLE TO TURN THE WHEEL THE BRAKES AND GAS BOTH DO NOT WORK AND YOU HAVE TO COAST TO A STOP ONCE STOPPED YOU HAVE PUT THE VAN IN PARK TURN KEY OFF AND RESTART THE ENGINE. THIS HAS NOW HAPPENED TWICE IN A 2 WEEK TIME FRAME EXTREMELY CONCERNED WITH TWO YOUNG CHILDREN IN THE BACK BOTH IN CAR SEATS. WHAT HAPPENS IF I AM ON A FREEWAY AND THIS HAPPENS AT 60-70MPH? TR Look up ODI 10508723 at NHTSA ↗ ODI 10649852 · 12,000 mi OIL CONSUMPTION SINCE 24000 MILES. VW DEALER NEVER WANT TO ADDRESS THE PROBLEM. KEEP TELL ME THIS NORMAL. NOW I HAVE TO ADD QUARTER OIL EVERY MONTH. ON MORNING CAR WASN'T STARTING AND TOOK TO THE DEALER AND HAD THE IGNITION REPLACED AT 42000 MILES BUT NOW THE KEY GET STUCK ON IGNITION MULTIPLE TIMES. I HOPE THE RECALL WILL FIX THIS PROBLEM. I HAD TO REPLACE BRAKES AT 12000 MILES DUE THE VIBRATION WHILE BRAKES. I HAD MULTIPLES ELECTRICAL PROBLEMS AND SOME WAS REPAIR AFTER COUPLE TRIPS TO THE DEALER. THIS CAR IS A LEMON. WHEN WE WILL HAVE OUR MO… Look up ODI 10649852 at NHTSA ↗ ODI 10679807 · 87,500 mi WHILE DRIVING TYPICALLY AT SPEEDS LESS THAN 45 MPH THE VEHICLE ENGINE WILL SHUT DOWN AND ELECTRICAL POWER AT THE DASH IS LOST. VEHICLE WILL RESTART AFTER IT SHUTS DOWN. PROBLEM IS NOT CONSISTENT. DEALER CAN NOT VERIFY THE COMPLAINT, THEREFORE CAN NOT REPAIR. NHTSA RECALL 14V396 APPEARS TO BE THE CORRECTION FOR THE ISSUE. DEALER WILL NOT PERFORM THE RECALL UNTIL THEY DUPLICATE THE ISSUE. HAS BEEN AT THE DEALER FOR 6 DAYS WITH NO DUPLICATION OF THE COMPLAINT. TR Look up ODI 10679807 at NHTSA ↗	27 ODI 10537923 · 47,000 mi TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS RESTARTED. THE VEHICLE RESUMED NORMAL FUNCTION. THE CONTACT ALSO MENTIONED THAT THE BRAKES HAD TO BE REPLACED OFTEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 47,000. Look up ODI 10537923 at NHTSA ↗ ODI 10607348 AT LEAST TWICE PER MONTH WHEN I DRIVE MY VAN, THE STEERING WILL SUDDENLY GO OUT, THEN THE BRAKES WILL STOP WORKING, THEN IT WILL JUST SHUT OFF. SO FAR IT HAS ONLY HAPPENED WHEN I WAS DRIVING AT PRETTY LOW RATES OF SPEED. I'VE CALLED THE VW DEALERSHIP SEVERAL TIMES AND EACH TIME THEY SAY THAT THEY HAVEN'T HEARD OF ANYTHING LIKE THIS BEFORE AND WANT TO CHARGE ME A FORTUNE JUST TO LOOK AT IT. WITH THE NEWEST RECALL, I CANNOT UNDERSTAND WHY MY VEHICLE IS NOT INCLUDED AND THE DEALERSHIP STILL CLAIMS THAT THEY HAVE NO CLUE WHAT I'M TAKING ABOUT WH… Look up ODI 10607348 at NHTSA ↗ ODI 10621954 · 91,000 mi THE ENGINE TURNED TO OFF WHILE I WAS DRIVING AND DEPOWERED POWER STEERING AND BRAKES. AT THAT POINT I RESTARTED THE CAR AND WAS ABLE TO DRIVE. TOOK THE CAR IMMEDIATELY TO VW DEALER, KEPT THE CAR FOR 24 HOURS, AND THEY COULD NOT REPLICATE THE INCIDENT SO NOTHING WAS DONE BY THEM. THIS HAPPENED AGAIN AT 93000 MILES ON AUGUST 8, 2014. *TR Look up ODI 10621954 at NHTSA ↗	—	32 ODI 10508723 · 76,200 mi OUR ROUTAN WAS ONLY GOING ABOUT 20 MPH AFTER PULLING OUT OF PARKING PLACES AND TURNING IN TO MAIN ROADS THE POWER STEERING, BRAKES, GAS ALL STOP WORKING THE CAR BECOMES IMPOSSIBLE TO TURN THE WHEEL THE BRAKES AND GAS BOTH DO NOT WORK AND YOU HAVE TO COAST TO A STOP ONCE STOPPED YOU HAVE PUT THE VAN IN PARK TURN KEY OFF AND RESTART THE ENGINE. THIS HAS NOW HAPPENED TWICE IN A 2 WEEK TIME FRAME EXTREMELY CONCERNED WITH TWO YOUNG CHILDREN IN THE BACK BOTH IN CAR SEATS. WHAT HAPPENS IF I AM ON A FREEWAY AND THIS HAPPENS AT 60-70MPH? TR Look up ODI 10508723 at NHTSA ↗ ODI 10607348 AT LEAST TWICE PER MONTH WHEN I DRIVE MY VAN, THE STEERING WILL SUDDENLY GO OUT, THEN THE BRAKES WILL STOP WORKING, THEN IT WILL JUST SHUT OFF. SO FAR IT HAS ONLY HAPPENED WHEN I WAS DRIVING AT PRETTY LOW RATES OF SPEED. I'VE CALLED THE VW DEALERSHIP SEVERAL TIMES AND EACH TIME THEY SAY THAT THEY HAVEN'T HEARD OF ANYTHING LIKE THIS BEFORE AND WANT TO CHARGE ME A FORTUNE JUST TO LOOK AT IT. WITH THE NEWEST RECALL, I CANNOT UNDERSTAND WHY MY VEHICLE IS NOT INCLUDED AND THE DEALERSHIP STILL CLAIMS THAT THEY HAVE NO CLUE WHAT I'M TAKING ABOUT WH… Look up ODI 10607348 at NHTSA ↗ ODI 10621954 · 91,000 mi THE ENGINE TURNED TO OFF WHILE I WAS DRIVING AND DEPOWERED POWER STEERING AND BRAKES. AT THAT POINT I RESTARTED THE CAR AND WAS ABLE TO DRIVE. TOOK THE CAR IMMEDIATELY TO VW DEALER, KEPT THE CAR FOR 24 HOURS, AND THEY COULD NOT REPLICATE THE INCIDENT SO NOTHING WAS DONE BY THEM. THIS HAPPENED AGAIN AT 93000 MILES ON AUGUST 8, 2014. TR Look up ODI 10621954 at NHTSA ↗	4 ODI 11074207 · 120,000 mi WE WERE DRIVING THE VEHICLE WHEN ALL OF THE SUDDEN IT STALLED! THERE IS NO CHECK LIGHT ON AND WHEN IT DOES THIS WE LOST ALL POWER BREAKING AND STEERING. THIS ALMOST HAPPENED TO US AROUND AN ELEVATED CORNER LUCKILY WE HAD JUST PAST THE CURVE WHEN WE LOST ALL POWER. IN READING THIS IS A COMMON PROBLEM ON THE TOWN AND COUNTRY ROUTAN GRAND CARAVAN AND ALL ASSOCIATED MODELS. SOMETHING SHOULD BE DONE DUE TO THE DANGER AND POTENTIAL RISK TO HUMAN LIFE! WE BOUGHT THIS VAN TO KEEP OUR CHILDREN SAFE NOT HAVE TO WORRY OF IT WILL LOOSE POWER STEERING AT 30… Look up ODI 11074207 at NHTSA ↗ ODI 10483410 · 11,418 mi TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED NUMEROUS FAILURES. THE REAR ROTORS BECAME WARPED NUMEROUS TIMES AND THE DEALER REPLACED THE ROTORS FOUR TIMES. THE TRANSMISSION WOULD CAUSE THE VEHICLE TO LUNGE ABRUPTLY WHEN THE GEAR WAS SHIFTED FROM REVERSE TO DRIVE. ADDITIONALLY, THE FOG LIGHT ASSEMBLY BECAME OVERHEATED AND BURNED SEVERAL TIMES. THE PLASTIC ON THE FRONT PASSENGER SIDE DOOR BECAME FRACTURED AND CAUSED THE CONTACT TO SUSTAIN LACERATIONS TO THE RIGHT HAND AND FINGERS. THE VEHICLE WAS … Look up ODI 10483410 at NHTSA ↗ ODI 10554579 · 23,456 mi BOUGHT THE VAN IN FEBRUARY 2012 SINCE THEN IT HAS BEEN IN THE SHOP 11 TIMES FOR TRANSMISSION,ROTORS,AND MY PASSENGER SLIDING DOORS THEY OPEN AUTOMATICALLY. NOW ITS LEAKING ANTIFREEZE AND WE BOUGHT EXTENDED WARRANTY AND THIS PART THE PLASTIC Y PART THAT CONTEXTS TWO HOSES THEY SAY ISN'T COVERED AND WANTS US TO PAY 450$ TO DO IT..THE VAN HAS 38,035 MILES WE BOUGHT IT WITH 18,563 MILES HOW CAN THIS VEHICLE HAVE THIS MANY PROBLEMS? MY POWER DOORS I BELIEVE IF THEY OPEN WHEN YOUR PUMPING GAS ISN'T RIGHT. *TR Look up ODI 10554579 at NHTSA ↗	1 ODI 11001470 · 68,483 mi DRIVER AIR BAG HAS FAILED TWICE RESULTING IN HIGH DOLLAR REPAIRS. BRAKES GO BAD EXTREMELY FAST. ALREADY REPLACED 2 FULL SETS OF BRAKES AND ROTORS IN 2 YEARS; LESS THAN 10,000 MILES ON EACH SET. VEHICLE VIOLENTLY JERKS WHEN IN REVERSE ON A HILL. ABNORMAL AMOUNT OF POPPING IN STEERING. DEALER UNABLE TO PINPOINT PROBLEM WITH JERKING OR POPPING. Look up ODI 11001470 at NHTSA ↗	0	1 ODI 11039881 · 66,000 mi ESP ABS LIGHT ILLUMINATES WHILE CAR IS IN MOTION AND THE CAR WILL NOT SHIFT OUT OF GEAR WHEN STOPPED AS IF THE BREAK IS NOT DETECTED. HAVE TO SHUT CAR OFF IN THE MIDDLE OF TRAFFIC OR DROP OF LINES AND TURN BACK ON SEVERAL TIMES TO CLEAR ERROR AND GET SHIFTER TO SHIFT TO DRIVE GEAR. USED SNAP ON READER TO CHECK CODES AND DOES NOT RECOGNIZE CAR AS VW, INSTEAD IT PULLS UP CHRYSLER TOWN AND COUNTRY. TRIED TO REPLACE A BREAK LIGHT MODULE, THE PART WAS ACTUALLY FOR A DODGE NEON. (I AM ONLY OWNER, BOUGHT VAN BRAND NEW). SYMPTOM CAME BACK AFTER TWO DA… Look up ODI 11039881 at NHTSA ↗
Steering	33 ODI 10288990 · 1,719 mi DRIVING APPROXIMATELY 25MPH WHEN THE ONE MONTH OLD VEHICLE JUST SUDDENLY FELT LIKE SOMEONE SLAMMED ON THE BRAKES. THE VEHICLE CAME TO A HALT. THE MOTOR WAS STILL RUNNING. I GOT IN THE CAR AGAIN TO MOVE IT OUT OF THE WAY AND THE SAME THING OCCURRED. IMMEDIATELY HAD IT TOWED TO THE VOLKSWAGEN DEALERSHIP. THERE IT STAYED FOR 13 DAYS. THE FOLLOWING PROBLEMS WERE REPAIRED/REPLACE: FAULTY TRANSMISSION SENSOR, REPLACED SENSOR. ALSO, ABS STEERING ANGLE SENSOR ERRATIC PERFORMANCE. FAULTY STEERING ANGLE SENSOR. REPLACED SENSOR. TR Look up ODI 10288990 at NHTSA ↗ ODI 10508723 · 76,200 mi OUR ROUTAN WAS ONLY GOING ABOUT 20 MPH AFTER PULLING OUT OF PARKING PLACES AND TURNING IN TO MAIN ROADS THE POWER STEERING, BRAKES, GAS ALL STOP WORKING THE CAR BECOMES IMPOSSIBLE TO TURN THE WHEEL THE BRAKES AND GAS BOTH DO NOT WORK AND YOU HAVE TO COAST TO A STOP ONCE STOPPED YOU HAVE PUT THE VAN IN PARK TURN KEY OFF AND RESTART THE ENGINE. THIS HAS NOW HAPPENED TWICE IN A 2 WEEK TIME FRAME EXTREMELY CONCERNED WITH TWO YOUNG CHILDREN IN THE BACK BOTH IN CAR SEATS. WHAT HAPPENS IF I AM ON A FREEWAY AND THIS HAPPENS AT 60-70MPH? TR Look up ODI 10508723 at NHTSA ↗ ODI 10519722 · 200 mi COMPLETELY LOST CONTROL OF THE VEHICLE (NO POWER, NO POWER STEERING) WHILE DRIVING 45MPH ON A 7 LANE MAJOR STREET. THANKFULLY IT WAS IN THE EARLY MORNING HOURS AND I WAS ABLE TO GLIDE ACROSS THE INTERSECTION TO A SIDE STREET WHERE I TURNED THE VEHICLE OFF AND ON AND IT RESUMED POWER. THIS HAS HAPPENED AT LEAST 4 MORE TIMES SINCE THEN, USUALLY WHILE IDLING AT A RED LIGHT. *TR Look up ODI 10519722 at NHTSA ↗	27 ODI 10607348 AT LEAST TWICE PER MONTH WHEN I DRIVE MY VAN, THE STEERING WILL SUDDENLY GO OUT, THEN THE BRAKES WILL STOP WORKING, THEN IT WILL JUST SHUT OFF. SO FAR IT HAS ONLY HAPPENED WHEN I WAS DRIVING AT PRETTY LOW RATES OF SPEED. I'VE CALLED THE VW DEALERSHIP SEVERAL TIMES AND EACH TIME THEY SAY THAT THEY HAVEN'T HEARD OF ANYTHING LIKE THIS BEFORE AND WANT TO CHARGE ME A FORTUNE JUST TO LOOK AT IT. WITH THE NEWEST RECALL, I CANNOT UNDERSTAND WHY MY VEHICLE IS NOT INCLUDED AND THE DEALERSHIP STILL CLAIMS THAT THEY HAVE NO CLUE WHAT I'M TAKING ABOUT WH… Look up ODI 10607348 at NHTSA ↗ ODI 10620722 · 55,000 mi OUR 2009 VW ROUTAN COMPLETELY SHUTS DOWN WHILE DRIVING 3 TIMES NOW. NOT ONLY DOES IT SHUT DOWN, BUT THE STEERING AND BRAKES LOCK AS WELL. ON THE LAST OCCURRENCE, MY WIFE (WITH OUR CHILDREN IN THE CAR) CAME VERY CLOSE TO HITTING A PARKED CAR IN THE STREET. WE HAVE TAKEN IT TO 2 VW DEALERS SO FAR IN CHARLOTTE, NC AND THEY STATE: "WE CANNOT DUPLICATE THE ISSUE." UNFORTUNATELY, THAT IS NOT THE RIGHT ANSWER WHEN YOU HAVE SOMETHING AS DANGEROUS AS THIS HAPPENING TO OUR FAMILY CAR. WE HAVE CALLED VW CORPORATE TO HELP 2ND DEALERSHIP WITH A RESOLUTI… Look up ODI 10620722 at NHTSA ↗ ODI 10621954 · 91,000 mi THE ENGINE TURNED TO OFF WHILE I WAS DRIVING AND DEPOWERED POWER STEERING AND BRAKES. AT THAT POINT I RESTARTED THE CAR AND WAS ABLE TO DRIVE. TOOK THE CAR IMMEDIATELY TO VW DEALER, KEPT THE CAR FOR 24 HOURS, AND THEY COULD NOT REPLICATE THE INCIDENT SO NOTHING WAS DONE BY THEM. THIS HAPPENED AGAIN AT 93000 MILES ON AUGUST 8, 2014. *TR Look up ODI 10621954 at NHTSA ↗	32 ODI 10508723 · 76,200 mi OUR ROUTAN WAS ONLY GOING ABOUT 20 MPH AFTER PULLING OUT OF PARKING PLACES AND TURNING IN TO MAIN ROADS THE POWER STEERING, BRAKES, GAS ALL STOP WORKING THE CAR BECOMES IMPOSSIBLE TO TURN THE WHEEL THE BRAKES AND GAS BOTH DO NOT WORK AND YOU HAVE TO COAST TO A STOP ONCE STOPPED YOU HAVE PUT THE VAN IN PARK TURN KEY OFF AND RESTART THE ENGINE. THIS HAS NOW HAPPENED TWICE IN A 2 WEEK TIME FRAME EXTREMELY CONCERNED WITH TWO YOUNG CHILDREN IN THE BACK BOTH IN CAR SEATS. WHAT HAPPENS IF I AM ON A FREEWAY AND THIS HAPPENS AT 60-70MPH? TR Look up ODI 10508723 at NHTSA ↗ ODI 10607348 AT LEAST TWICE PER MONTH WHEN I DRIVE MY VAN, THE STEERING WILL SUDDENLY GO OUT, THEN THE BRAKES WILL STOP WORKING, THEN IT WILL JUST SHUT OFF. SO FAR IT HAS ONLY HAPPENED WHEN I WAS DRIVING AT PRETTY LOW RATES OF SPEED. I'VE CALLED THE VW DEALERSHIP SEVERAL TIMES AND EACH TIME THEY SAY THAT THEY HAVEN'T HEARD OF ANYTHING LIKE THIS BEFORE AND WANT TO CHARGE ME A FORTUNE JUST TO LOOK AT IT. WITH THE NEWEST RECALL, I CANNOT UNDERSTAND WHY MY VEHICLE IS NOT INCLUDED AND THE DEALERSHIP STILL CLAIMS THAT THEY HAVE NO CLUE WHAT I'M TAKING ABOUT WH… Look up ODI 10607348 at NHTSA ↗ ODI 10621954 · 91,000 mi THE ENGINE TURNED TO OFF WHILE I WAS DRIVING AND DEPOWERED POWER STEERING AND BRAKES. AT THAT POINT I RESTARTED THE CAR AND WAS ABLE TO DRIVE. TOOK THE CAR IMMEDIATELY TO VW DEALER, KEPT THE CAR FOR 24 HOURS, AND THEY COULD NOT REPLICATE THE INCIDENT SO NOTHING WAS DONE BY THEM. THIS HAPPENED AGAIN AT 93000 MILES ON AUGUST 8, 2014. TR Look up ODI 10621954 at NHTSA ↗	—	4 ODI 10522951 · 63,000 mi WHERE TO BEGIN WITH THIS CAR. ALL 4 VALVE STEMS NEEDED TO BE REPLACED. I WAS LOSING PRESSURE IN MY TIRES, AND MECHANIC SAID THEY WERE CORRODED. THEN MY TIPTRONICS DID NOT WORK, ALSO WHEN YOU SHIFTED IN TO GEAR, IT DIDN'T WANT TO MOVE. HAD THE WHOLE SHIFTING LEVER COMPONENT REPLACED. LOTS OF TROUBLE WITH THE DOORS NOT OPENING RIGHT, THEN WHEN CLOSING THE SENSOR DOESN'T ALWAYS WORK. ALMOST HAD MY KIDS GET CAUGHT IN THE DOOR. IF THE CAR IS EVEN ON THE SLIGHTEST SLOPE THE DOOR WON'T CLOSE. WHILE DRIVING DOWN THE ROAD AT 55MPH THE CAR JUST SHUT OF… Look up ODI 10522951 at NHTSA ↗ ODI 10664225 · 76,000 mi CATASTROPHIC FAILURE OF TRANSMISSION AT 76K. MAJOR TRANSMISSION WORK DONE APPROXIMATELY 26K. TRANSMISSION REPLACED 6 MONTHS LATER AND STILL HAS ISSUES (SLUGGISH, NON-SMOOTH SHIFT BETWEEN GEARS AT HIGHER CRUISING SPEEDS. VW ENGINEER GERARDO ZELEDON CALLS THIS THE "ROUTAN SHAKE" AND CLAIMS THIS IS NORMAL. APPROXIMATELY 95,000 MILES STEERING BEGAN SEIZING UP WHILE IN MOTION. THIS IS, ACCORDING TO RECALL NOTICE AND SERVICE MANAGER AT FLOW VW WINSTON SALEM NC, A BEHAVIOR RELATED TO A RECALL ON THE IGNITION SWITCH (NTSHA 14V-396). NO PARTS ARE AVAILA… Look up ODI 10664225 at NHTSA ↗ ODI 11074207 · 120,000 mi WE WERE DRIVING THE VEHICLE WHEN ALL OF THE SUDDEN IT STALLED! THERE IS NO CHECK LIGHT ON AND WHEN IT DOES THIS WE LOST ALL POWER BREAKING AND STEERING. THIS ALMOST HAPPENED TO US AROUND AN ELEVATED CORNER LUCKILY WE HAD JUST PAST THE CURVE WHEN WE LOST ALL POWER. IN READING THIS IS A COMMON PROBLEM ON THE TOWN AND COUNTRY ROUTAN GRAND CARAVAN AND ALL ASSOCIATED MODELS. SOMETHING SHOULD BE DONE DUE TO THE DANGER AND POTENTIAL RISK TO HUMAN LIFE! WE BOUGHT THIS VAN TO KEEP OUR CHILDREN SAFE NOT HAVE TO WORRY OF IT WILL LOOSE POWER STEERING AT 30… Look up ODI 11074207 at NHTSA ↗	1 ODI 11427268 referenced to recall nhsta Id no:11v-151 same issue happens on newer models, the car key ignition switch does not secure the key and that causes the car shut-down in tje middle of highway or road intermittently! ıt does not give any dashboard warning and no codes! all the lights are being gone and even ac shuts off! when ı push the key the lights come back on and the car can be turned on again. similiar problems are poster on youtube: https://youtu.be/ZESy-MnVPZs Look up ODI 11427268 at NHTSA ↗	2 ODI 10763450 · 90,000 mi IN APRIL 2015 THE CHECK ENGINE LIGHT CAME ON IN MY 2010 VW ROUTAN, MAYBE A WEEK OR SO LATER IT STARTED TO STALL WHILE I WAS DRIVING IT. I TOOK IT TO AN IMPORT DEALER LOCALLY TO HAVE IT LOOKED AT AND WAS TOLD THAT THE EGR VALVE WAS BAD. THEY REPLACED IT, WHICH COST ME $400, AND PUT A NEW GAS CAP ON IT. IN JULY THE ENGINE LIGHT CAME ON AGAIN, HAD THE CODES RUN AT A PARTS STORE AND IT WAS THE EGR VALVE AGAIN. TOOK IT BACK TO THE SHOP THAT DID THE FIRST REPAIR BECAUSE IT STILL HAD A PARTS AND LABOR WARRANTEE WITH THEM. THEY REPLACED IT AGAIN. NOW, … Look up ODI 10763450 at NHTSA ↗ ODI 10968462 · 100,000 mi I HAVE A VOLKSWAGEN ROUTAN 2011 BUILT BY CHRYSLER IN A CANADA FACTORY. THIS VEHICLE IS SHUTTING OFF WHEN DRIVE ON THE FREEWAY. THE GEARS AND SREERING LOCKS UP WHILE DRIVING. THE VEHICLE ALSO HAS ELECTRICAL ISSUES THE LIGHTS TURN ON AND OFF EVEN WHEN THE CAR IS OFF. AFTER PURCHASING A NEW BATTERY AND ALTERNATOR THE CAR IN THE MORNING WILL NOT START. THE BATTERY IS DEAD AND DRAINED. WITH NOTHING ON IT INTERMITTENTLY HAS A DEAD BATTERY AND SHUTS OF AFTER STARTING THE CAR. WHEN I CALL THE VOLKSWAGEN DEALER IN STOCKTON CA TO EXPLAIN THE SERVICE GU… Look up ODI 10968462 at NHTSA ↗	6 ODI 10690482 · 41,600 mi THE CLOCKSPRING IN THE STEERING WHEEL WENT OUT. AT 28 MILES THE TRACTION CONTROL TURNS ON AND THE CAR STARTS BRAKING EVEN IF THE CAR IS NOT SKIDDING. VERY DANGEROUS. OUR MECHANIC TOLD US THE CLOCKSPRING IS A COMMON PROBLEM WITH BOTH THE VOLKSWAGEN ROUTON AND THE CHRYSLER TOWN AND COUNTRY. I FOUND ONE REPORT ON THE INTERNET THAT SAID VOLKSWAGEN STARTED SERVICING THE CLOCKSPRING AS OF 2010 ROUTON MODELS BUT DID NOTHING FOR THE 2009 ROUTON. *JS Look up ODI 10690482 at NHTSA ↗ ODI 10995677 · 130,000 mi AS WE ARE DRIVING THE POWER STEERING COMPLETELY CUTS OFF AND WILL NOT LET YOU DRIVE - THE ENGINE SHUTS OFF AND YOUR FORCED INTO TURNING THE VEHICLE COMPLETELY OFF THEM BACK ON AGAIN. THIS HAPPENED WHILE ON THE INTERSTATE IN TRAFFIC WHICH NEARLY CAUSED A COLLISION. Look up ODI 10995677 at NHTSA ↗ ODI 11076779 · 130,000 mi 2010 VOLKSWAGON ROUTAN HAS STOPPED IN MID TRAFFIC GOING 30-40 MPH ON A BUSY ROAD. LIGHTS AND AUDIO HAVE FLICKERED, THEN TURN OFF. CAR SPONTANEOUSLY STARTS AND STOPS ANY GIVEN TIME IN MOTION AND STANDING STILL, AND CANNOT BE JUMPED TO REVIVE. HAVE BEEN IN THE CAR WITH MY CHILDREN AND HAVE HAD IT STOP IN THE MIDDLE OF THE ROAD. WE HAVE HAD IT LESS THAN A YEAR, COMPLETELY UNSAFE. TOLD THE EXACT RECALL DOESN'T APPLY TO MY VIN#. Look up ODI 11076779 at NHTSA ↗
Power Train	21 ODI 10522951 · 63,000 mi WHERE TO BEGIN WITH THIS CAR. ALL 4 VALVE STEMS NEEDED TO BE REPLACED. I WAS LOSING PRESSURE IN MY TIRES, AND MECHANIC SAID THEY WERE CORRODED. THEN MY TIPTRONICS DID NOT WORK, ALSO WHEN YOU SHIFTED IN TO GEAR, IT DIDN'T WANT TO MOVE. HAD THE WHOLE SHIFTING LEVER COMPONENT REPLACED. LOTS OF TROUBLE WITH THE DOORS NOT OPENING RIGHT, THEN WHEN CLOSING THE SENSOR DOESN'T ALWAYS WORK. ALMOST HAD MY KIDS GET CAUGHT IN THE DOOR. IF THE CAR IS EVEN ON THE SLIGHTEST SLOPE THE DOOR WON'T CLOSE. WHILE DRIVING DOWN THE ROAD AT 55MPH THE CAR JUST SHUT OF… Look up ODI 10522951 at NHTSA ↗ ODI 10684264 · 34,031 mi TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT AFTER STOPPING AT TRAFFIC LIGHT, THE VEHICLE STALLED AND THE INSTRUMENT PANEL WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR TH… Look up ODI 10684264 at NHTSA ↗ ODI 10701917 · 70,000 mi TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE IN PARK, THE VEHICLE FAILED TO START. WHILE DRIVING AT 40 MPH, THERE WAS A BEEPING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE RANGE SELECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF THE … Look up ODI 10701917 at NHTSA ↗	14 ODI 10712217 · 75,400 mi I WENT TO PASS A VEHICLE AT 65MPH AND THE ACCELERATOR PEDAL DID NOT RELEASE, THE VAN HIT 80-MPH BEFORE I POPPED IT IN NEUTRAL AND THEN BACK INTO DRIVE TO CORRECT THE ISSUE. HITTING THE BRAKES HAD NO EFFECT ON THE UNINTENDED ACCELERATION. THIS VEHICLE IS MECHANICALLY IDENTICAL TO CHRYSLER TOWN & COUNTRY AND DADGE GRAND CARAVAN, SEE OTHER IDENTICAL COMPLAINTS HERE: HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/14835/DODGE/VOYAGER/DODGE-GRAND-CARAVAN-SUDDEN-ACCELERATION? TR Look up ODI 10712217 at NHTSA ↗ ODI 10717419 · 51,496 mi THE FIRST INCIDENT WITH A "CLUNKING" NOISE OF THE TRANSMISSION BEGAN ON 7/10/2014 AT 51,496 MILES. WHEN SHIFTING FROM REVERSE TO DRIVE CAR MAKES A "CLUNKING" NOISE AND JERKS THE CAR FORWARD. IT WAS NOTED BY DEALERSHIP AFTER A TEST DRIVE NO FAULTS FOUND. ON 3/19/15 AT 58,611 MILES CAR RETURNED TO DEALERSHIP. SAME CLUNKING AND GRINDING NOISES. FAULTS: P0868, P1790 & P0944. PRESSURE READINGS TO LOW IN TCM CONTROL WIRES. TRANSMISSION TO BE REPLACED PER DEALERSHIP. FINDINGS: UNDER DRIVE CLUTCHES WORN OUT, SUNGEARS AND ASSEMBLY DAMAGED WITH METAL MET… Look up ODI 10717419 at NHTSA ↗ ODI 11151140 · 115,226 mi TL THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING BETWEEN 30 TO 65 MPH, THE VEHICLE RANDOMLY JERKED FORWARD AND BACKWARD AS IF IT WERE SKIPPING A GEAR. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED AFTERWARDS SEVERAL TIMES. THE CONTACT SPOKE WITH TWO UNKNOWN DEALERS AND THEN CONTACTED AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE UNDERDRIVE SOLENOID CIRCUIT OF THE TRANSMISSION WAS MALFUNCTIONING. AFTER CONDUCTING SOME RESEARCH, THE CONTACT FOUND THAT THE MANUFACTURER PLACED A CHRYSLER ENGINE AND TRANSMISSION INTO HER … Look up ODI 11151140 at NHTSA ↗	4 ODI 11074207 · 120,000 mi WE WERE DRIVING THE VEHICLE WHEN ALL OF THE SUDDEN IT STALLED! THERE IS NO CHECK LIGHT ON AND WHEN IT DOES THIS WE LOST ALL POWER BREAKING AND STEERING. THIS ALMOST HAPPENED TO US AROUND AN ELEVATED CORNER LUCKILY WE HAD JUST PAST THE CURVE WHEN WE LOST ALL POWER. IN READING THIS IS A COMMON PROBLEM ON THE TOWN AND COUNTRY ROUTAN GRAND CARAVAN AND ALL ASSOCIATED MODELS. SOMETHING SHOULD BE DONE DUE TO THE DANGER AND POTENTIAL RISK TO HUMAN LIFE! WE BOUGHT THIS VAN TO KEEP OUR CHILDREN SAFE NOT HAVE TO WORRY OF IT WILL LOOSE POWER STEERING AT 30… Look up ODI 11074207 at NHTSA ↗ ODI 10483410 · 11,418 mi TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED NUMEROUS FAILURES. THE REAR ROTORS BECAME WARPED NUMEROUS TIMES AND THE DEALER REPLACED THE ROTORS FOUR TIMES. THE TRANSMISSION WOULD CAUSE THE VEHICLE TO LUNGE ABRUPTLY WHEN THE GEAR WAS SHIFTED FROM REVERSE TO DRIVE. ADDITIONALLY, THE FOG LIGHT ASSEMBLY BECAME OVERHEATED AND BURNED SEVERAL TIMES. THE PLASTIC ON THE FRONT PASSENGER SIDE DOOR BECAME FRACTURED AND CAUSED THE CONTACT TO SUSTAIN LACERATIONS TO THE RIGHT HAND AND FINGERS. THE VEHICLE WAS … Look up ODI 10483410 at NHTSA ↗ ODI 10554579 · 23,456 mi BOUGHT THE VAN IN FEBRUARY 2012 SINCE THEN IT HAS BEEN IN THE SHOP 11 TIMES FOR TRANSMISSION,ROTORS,AND MY PASSENGER SLIDING DOORS THEY OPEN AUTOMATICALLY. NOW ITS LEAKING ANTIFREEZE AND WE BOUGHT EXTENDED WARRANTY AND THIS PART THE PLASTIC Y PART THAT CONTEXTS TWO HOSES THEY SAY ISN'T COVERED AND WANTS US TO PAY 450$ TO DO IT..THE VAN HAS 38,035 MILES WE BOUGHT IT WITH 18,563 MILES HOW CAN THIS VEHICLE HAVE THIS MANY PROBLEMS? MY POWER DOORS I BELIEVE IF THEY OPEN WHEN YOUR PUMPING GAS ISN'T RIGHT. *TR Look up ODI 10554579 at NHTSA ↗	4 ODI 10522951 · 63,000 mi WHERE TO BEGIN WITH THIS CAR. ALL 4 VALVE STEMS NEEDED TO BE REPLACED. I WAS LOSING PRESSURE IN MY TIRES, AND MECHANIC SAID THEY WERE CORRODED. THEN MY TIPTRONICS DID NOT WORK, ALSO WHEN YOU SHIFTED IN TO GEAR, IT DIDN'T WANT TO MOVE. HAD THE WHOLE SHIFTING LEVER COMPONENT REPLACED. LOTS OF TROUBLE WITH THE DOORS NOT OPENING RIGHT, THEN WHEN CLOSING THE SENSOR DOESN'T ALWAYS WORK. ALMOST HAD MY KIDS GET CAUGHT IN THE DOOR. IF THE CAR IS EVEN ON THE SLIGHTEST SLOPE THE DOOR WON'T CLOSE. WHILE DRIVING DOWN THE ROAD AT 55MPH THE CAR JUST SHUT OF… Look up ODI 10522951 at NHTSA ↗ ODI 10664225 · 76,000 mi CATASTROPHIC FAILURE OF TRANSMISSION AT 76K. MAJOR TRANSMISSION WORK DONE APPROXIMATELY 26K. TRANSMISSION REPLACED 6 MONTHS LATER AND STILL HAS ISSUES (SLUGGISH, NON-SMOOTH SHIFT BETWEEN GEARS AT HIGHER CRUISING SPEEDS. VW ENGINEER GERARDO ZELEDON CALLS THIS THE "ROUTAN SHAKE" AND CLAIMS THIS IS NORMAL. APPROXIMATELY 95,000 MILES STEERING BEGAN SEIZING UP WHILE IN MOTION. THIS IS, ACCORDING TO RECALL NOTICE AND SERVICE MANAGER AT FLOW VW WINSTON SALEM NC, A BEHAVIOR RELATED TO A RECALL ON THE IGNITION SWITCH (NTSHA 14V-396). NO PARTS ARE AVAILA… Look up ODI 10664225 at NHTSA ↗ ODI 11074207 · 120,000 mi WE WERE DRIVING THE VEHICLE WHEN ALL OF THE SUDDEN IT STALLED! THERE IS NO CHECK LIGHT ON AND WHEN IT DOES THIS WE LOST ALL POWER BREAKING AND STEERING. THIS ALMOST HAPPENED TO US AROUND AN ELEVATED CORNER LUCKILY WE HAD JUST PAST THE CURVE WHEN WE LOST ALL POWER. IN READING THIS IS A COMMON PROBLEM ON THE TOWN AND COUNTRY ROUTAN GRAND CARAVAN AND ALL ASSOCIATED MODELS. SOMETHING SHOULD BE DONE DUE TO THE DANGER AND POTENTIAL RISK TO HUMAN LIFE! WE BOUGHT THIS VAN TO KEEP OUR CHILDREN SAFE NOT HAVE TO WORRY OF IT WILL LOOSE POWER STEERING AT 30… Look up ODI 11074207 at NHTSA ↗	—	2 ODI 10992287 · 61,800 mi THE MINIVAN SUDDENLY GAVE AWAY ON THE TRANSMISSION. AT SPEEDS OF AROUND 70MPH, THE TRANSMISSION WAS IN "D" (AUTO TRANSMISSION VS MANUAL) BUT THERE WAS NO ENGAGEMENT FROM THE ENGINE. GIVING MORE GAS THE ENGINE WAS JUST REVVING UP AS IF IT WAS IN NEUTRAL. MOVED IT TO NEUTRAL AND BACK TO DRIVE AND STILL THE ENGINE REVVED UP WITHOUT ENGAGEMENT. HAD TO MOVE OVER TO THE RIGHT LANE AND STARTED SLOWING DOWN TO STOP. AFTER ABOUT 2-3 MINUTES, TRIED AGAIN AND THEN THE CAR SUDDENLY REVVED UP TO 5000RPM OR SO AS IF IT WAS IN THE 2ND OR 3RD GEAR. IT THEN RE-… Look up ODI 10992287 at NHTSA ↗ ODI 11451803 On Thursday January 6, 2022, I took my car Volkswagen Routan 2012 to the service center because the check engine light went on and the engine revving. The service center took a week for diagnostic it, then they informed me on January 13, after charging me $180 that it needs a new transmission because it stuck in limp mode (see attached report). I asked the customer service to contact Volkswagen representative because this problem seems to be a manufacture problem, especially the car run less than 85000 miles and all maintenance service done on … Look up ODI 11451803 at NHTSA ↗	4 ODI 10730842 · 52,577 mi I DRIVING LAST MONTH 47 MPH AND MY DRIVING SLIDING DOOR OPEN AND MY 8 YEARS GIRLS WAS DEAR AND SHE SCARE WHEN THE DOOR OPEN WHEN I DRIVING ,, AND WHEN I STOP THE DOOR NOT WANT TO CLOSE AUTOMATIC..THAT SCARE ME AND MY WIFE... THE OTHER CONCERN IS MY TRANSMISION HARD SHIFFTING ,HARD SHIFFTING , I READY TAKE LIKE 5,6 TIME MY VAN TO CHECK MY TRANSMISSION AND MY SLIDING DOOR AND THE SAY IS NORMAL , AND MY SLIDING DOOR NOT FOUND ANYTIME , THEY SAY THE SLIDING DOOR RECALL WAS DONE READY,, THE OTHER BIG CONCERN IS THE GAS MILEAGE, ONLY 11 OR 12 GALLON … Look up ODI 10730842 at NHTSA ↗ ODI 10908851 · 85,000 mi RECENTLY THE VAN HAS GIVEN ME TROUBLE UPON STARTUP. THE PROBLEM IS INTERMITTENT. SOMETIMES, IT WOULD START FINE. OTHER TIMES, IT WOULD TAKE MULTIPLE ATTEMPTS TO START THE VEHICLE. OTHER TIMES, THE VEHICLE WOULD START, THEN IMMEDIATELY TURN ITSELF OFF. SOMETIMES, IT WOULD BE LIKE THERE WASN'T ENOUGH CHARGE TO TURN THE STARTER, AND OTHER TIMES, WHEN IT WOULD START THEN DIE, IT FELT LIKE IT WAS RUNNING OUT OF GAS. AFTER MUCH RESEARCH, I DISCOVERED THAT THE TOTALLY INTEGRATED POWER MODULE IS THE CULPRIT OF THESE ISSUES. SPECIFICALLY, IT IS… Look up ODI 10908851 at NHTSA ↗ ODI 11033454 · 85,000 mi OUR TRANSMISSION ISSUE STARTED AS WE'RE GOING DOWN I-75 AT ABOUT 65-70. WHAT SOUNDED LIKE SOMETHING FALLING FROM UNDER THE HOOD AND MAKING A KLANKING SOUND AT IF IT WAS FALLING FROM THE ENGINE. AFTER A FEW MONTHS THE TRANSMISSION STARTED MAKING A HIGH PITCHED NOISE. OUR LOCAL AUTO REPAIR STORE WOULDN'T TOUCH IT SO WE HAD TO TAKE IT TO THE VW DEALER. TURNS OUT NOT ONLY DID WE NEED A NEW TRANSMISSION BUT WE ALSO NEEDED A NEW TIPM. TOTAL COST INCLUDING LABOR WAS OVER $7000.00. WE HAD ROUGHLY 85,000 MILES ON IT SO IT WAS NO LONGER COVERED UNDER WAR… Look up ODI 11033454 at NHTSA ↗	2 ODI 10897474 · 65,000 mi SOMETIMES THE VEHICLE WILL NOT START FOR NO APPARENT REASON.VW SERVICE DEPT. CANNOT DETECT AN ISSUE. ENGINE LIGHT COMES ON INTERMITTENTLY WHILE DRIVING-VW CANNOT DETECT ANYTHING WRONG.* ALARMS GO OFF BUT NO SIGNAL SHOWING ON THE DASHBOARD.POWER WINDOWS AND SEATS WORK INTERMITTENTLY- FOUND VEHICLE'S SLIDING DOOR WIDE OPEN I PARKING LOT, TWICE. * HAVE ALSO FOUND WINDOWS OPEN. OUR LIFT GATE (TRUNK) OPENED WHILE DRIVING ON THE HIGHWAY.* VEHICLE FAILED TO SHIFT,WHILE DRIVING, REVVED AND WOULD NOT RESET UNTIL PULLING OVER AND TURNING OFF THE VEHI… Look up ODI 10897474 at NHTSA ↗ ODI 11022870 VOLKSWAGEN ROUTAN 2010 WILL TURN OFF WHILE IN MOTION, ON HIGHWAY, STREET, OR WHEN STATIONARY. CAR IS AN AUTOMATIC AND WILL NOT ADJUST TO THE PROPER GEAR WHEN DRIVING. WHEN IN DRIVE THE CAR WILL ACT AS IF IT IS IN NEUTRAL AND ROLL BACKWARDS AND WILL NOT KICK INTO FIRST GEAR. THE ELECTRONIC SYSTEM NEVER WORKS PROPERLY AND IS CONSTANTLY NEEDING NEW BATTERIES VERY FEW MONTHS. THIS CAR IS UNSTABLE, UNSAFE, AND UNRELIABLE! THE VOLKSWAGEN ROUTAN 2010 NEEDS TO BE RECALLED IMMEDIATELY! Look up ODI 11022870 at NHTSA ↗
Unknown Or Other	27 ODI 10724199 · 42,000 mi THE ELECTRONIC DRIVER SIDE PASSENGER DOOR WILL NOT LATCH OPEN. THE DOOR WILL POWER OPEN THEN SLIDE BACK SHUT HITTING WHOEVER OR WHATEVER IS IN THE WAY. THIS IS AN INTERMITTENT PROBLEM. THE VAN WAS CHECKED BY OUR LOCAL DEALER SEVERAL TIMES OVER SEVERAL YEARS. THIS IS STILL AN ISSUE. THIS HAS LED TO MYSELF AND CHILDREN BEING HIT BY THE DOOR LEAVING BRUISES. IT ALMOST SMASHED MY 2 YEAR OLD DAYCARE CHILD'S LEG IN THE DOOR BUT I INTERVENED STOPPING THE DOOR PRIOR TO IT HITTING HER. I HAVE LOOKED ON THE INTERNET AND FOUND SEVERAL OTHER COMPLAINTS ALS… Look up ODI 10724199 at NHTSA ↗ ODI 10764970 · 110,000 mi VEHICLE STALLED SEVERAL TIMES APPROXIMATELY FEBRUARY 17, 2015.THEN FINALLY WOULDN'T START AT ALL. EMERGENCY ROAD SIDE ASSISTANCE CAME GOT CAR STARTED. THEN WHILE DRIVING DASHBOARD STARTED BLINKING POWER WAS LOST CAR CUT OFF. HAD TO CONTACT ROAD SIDE ASSISTANCE AGAIN TO HAVE CART TOWED TO REPAIR FACILITY. COULD NOT FIND OUT PROBLEM SUGGESTED TO BE TOWED TO DEALER. DEALER COULDN'T FIND THE PROBLEM INITIALLY THEN FOUND IT MADE REPAIRS WHICH I FOUND OUT LATER IT WAS PARTLY DUE TO THE RECALL (28H1.) THEN APPROXIMATELY THE MIDDLE OF JULY 2015 CAR BE… Look up ODI 10764970 at NHTSA ↗ ODI 10821636 · 89,000 mi I BOUGHT A CERTIFIED PRE-OWNED 2009 ROUTAN. AFTER ABOUT A YEAR, THE CAR RANDOMLY WILL NOT START, IT JUST CLICKS BUT WILL NOT START. REPLACED BATTERY. STILL - CAR WILL NOT START. THIS HAS BEEN GOING ON FOR 3 YEARS. HAD STARTER & ALTERNATOR CHECKED - BOTH GOOD. HAD THE IGNITION RECALL DONE AND PROBLEM RESOLVED ITSELF FOR ABOUT 3 MONTHS - NOW IT STARTED DOING THIS AGAIN - RANDOMLY WILL NOT START. HUBBY MOVED A WIRE UNDER THE HOOD AND MAGICALLY THE CAR STARTED. GOT HOME AND VAN WILL NOT START! AFTER SPENDING $5,200 ON A NEW TRANSMISSION - I HAT… Look up ODI 10821636 at NHTSA ↗	11 ODI 10995198 · 134,692 mi WHILE DRIVING AT 65 MPH ON I35, THE CAR'S TRANSMISSION ACTED LIKE IT SLIPPED INTO 2ND GEAR AND THE TACK WENT TO 5000RPM. I TRIED TO JUST SLOW DOWN AND GET OFF THE ROAD, TURNED THE CAR OFF AND BACK ON WHEN I GOT TO A PARKING LOT. I THEN STARTED DRIVING AGAIN AND IT APPEARED TO BE ALRIGHT. WITHIN A FEW DAYS IT DID IT A COUPLE TIMES MORE, THIS TIME TURNING ON THE CHECK ENGINE LIGHT. TOOK IT TO THE DEALER AND THEY COULDN'T DUPLICATE PROBLEM IN THE WEEK THEY HAD IT. PICKED IT UP FROM THE DEALERSHIP AND WAS ABOUT 10 TO 15 MILES AWAY AND IT DID I… Look up ODI 10995198 at NHTSA ↗ ODI 11052059 · 70,000 mi WHILE DRIVING ON STREET OR HIGHWAY OR STOPPED. USUALLY AROUND 20-40MPH CAR STALLS. BRAKES LOCK UP/STEERING WHEEL LOCKS UP/NO CONTROL OF CAR AT ALL. ALL LIGHTS INDICATE CAR IS ON, ONE BELL GOES OFF PRIOR AND ANTI-SKID LIGHT COMES ON. BY THEN PANIC CANNOT CONTROL CAR! PUT CAR IN PARK AFTER STOPPED AND IT STARTS RIGHT UP. Look up ODI 11052059 at NHTSA ↗ ODI 11290284 CAR ELECTRICAL SYSTEM GOES CRAZY, SPEEDOMETER NEEDLE GOES CRAZY. RADIO TURNS OFF AND ON, THEN THE VEHICLE TURNS OFF COMPLETELY. IT TURNS ON AFTER. SOMETIMES ALL THIS HAPPENS BEFORE TURNING OFF, SOMETIMES IT TURNS OFF SUDDENLY WITH NO WARNING. HAVE SPENT A LOT OF MONEY TRYING TO FIX ISSUE WITH NO LUCK. DRIVING IT MAKES ME VERY NERVOUS BUT I CAN'T CHANGE CARS RIGHT NOW. IT HAS HAPPENED BOTH ON SMALL STREETS AND HIGHWAY IN MOTION. Look up ODI 11290284 at NHTSA ↗	1 ODI 11001470 · 68,483 mi DRIVER AIR BAG HAS FAILED TWICE RESULTING IN HIGH DOLLAR REPAIRS. BRAKES GO BAD EXTREMELY FAST. ALREADY REPLACED 2 FULL SETS OF BRAKES AND ROTORS IN 2 YEARS; LESS THAN 10,000 MILES ON EACH SET. VEHICLE VIOLENTLY JERKS WHEN IN REVERSE ON A HILL. ABNORMAL AMOUNT OF POPPING IN STEERING. DEALER UNABLE TO PINPOINT PROBLEM WITH JERKING OR POPPING. Look up ODI 11001470 at NHTSA ↗	1 ODI 11427268 referenced to recall nhsta Id no:11v-151 same issue happens on newer models, the car key ignition switch does not secure the key and that causes the car shut-down in tje middle of highway or road intermittently! ıt does not give any dashboard warning and no codes! all the lights are being gone and even ac shuts off! when ı push the key the lights come back on and the car can be turned on again. similiar problems are poster on youtube: https://youtu.be/ZESy-MnVPZs Look up ODI 11427268 at NHTSA ↗	2 ODI 10992287 · 61,800 mi THE MINIVAN SUDDENLY GAVE AWAY ON THE TRANSMISSION. AT SPEEDS OF AROUND 70MPH, THE TRANSMISSION WAS IN "D" (AUTO TRANSMISSION VS MANUAL) BUT THERE WAS NO ENGAGEMENT FROM THE ENGINE. GIVING MORE GAS THE ENGINE WAS JUST REVVING UP AS IF IT WAS IN NEUTRAL. MOVED IT TO NEUTRAL AND BACK TO DRIVE AND STILL THE ENGINE REVVED UP WITHOUT ENGAGEMENT. HAD TO MOVE OVER TO THE RIGHT LANE AND STARTED SLOWING DOWN TO STOP. AFTER ABOUT 2-3 MINUTES, TRIED AGAIN AND THEN THE CAR SUDDENLY REVVED UP TO 5000RPM OR SO AS IF IT WAS IN THE 2ND OR 3RD GEAR. IT THEN RE-… Look up ODI 10992287 at NHTSA ↗ ODI 11451803 On Thursday January 6, 2022, I took my car Volkswagen Routan 2012 to the service center because the check engine light went on and the engine revving. The service center took a week for diagnostic it, then they informed me on January 13, after charging me $180 that it needs a new transmission because it stuck in limp mode (see attached report). I asked the customer service to contact Volkswagen representative because this problem seems to be a manufacture problem, especially the car run less than 85000 miles and all maintenance service done on … Look up ODI 11451803 at NHTSA ↗	—	3 ODI 10981131 · 163,100 mi WHILE OPERATING THE VEHICLE THE CAR STALLED AN SIMPLY STOPPED IN THE MIDDLE OF DRIVING. COMPLETELY RIDICULOUS, VERY DANGEROUS! YOUR WEBSITE STATES THAT VEHICLES SAME YEAR, MAKE AND MODEL AND MANFU DATE THEVSAME HAVE RECALLS FOR EXACT SAME ISSUE. THIS IS URGENT. THIS COULD CAUSE THE DEATH OF ME OR MY FAMILY. IT MUST BE FIXED BY VW, ESPECIALLY WHEN RECALLS ARE THERE FOR SOME. Look up ODI 10981131 at NHTSA ↗ ODI 10898013 · 74,000 mi PROBLEM STARTED ABOUT 4 WEEKS AGO WITH CAR NOT STARTING. WOULD TURN OVER BUT NEVER CRANK UP/START. LOCAL VW DEALER SAID ISSUE WAS FUEL PUMP AND REPLACED. SYMPTOMS CONTINUED WITH LONGER THAN NORMAL CRANKING BEFORE STARTING. SOMETIMES VEHICLE ACTS LIKE THE BATTERY IS DEAD AND WILL "CLICK" UNTIL AFTER MULTIPLE ATTEMPTS IT WILL FINALLY TURN OVER AND START. CERTAIN TIMES AFTER HAVING VEHICLE IN REVERSE AND PLACING INTO DRIVE IT JUST DIES, HAVE TO PLACE IN PARK AND RESTART. WHILE SLOWING FOR A TRAFFIC LIGHT, VEHICLE HAS HESITATED AS IF TO DIE, … Look up ODI 10898013 at NHTSA ↗ ODI 10990604 · 115,000 mi THE VAN WAS MY MOTHERS WHICH SHE PASSED AWAY ABOUT YEAR AGO. I INHERITED THE VAN I DRIVE IT FOR COUPLE MONTHS WHEN I NOTICED THAT SOMETIMES WHEN I WOULD TRY TO START IT THAT IT WOULDN'T START. IT WOULD ONLY MAKE A CLICKING NOISE. I WOULD TURN KEY OFF & TRY IT AGAIN IT WOULD START. THEN IN MONTH OR SO I NOTICED THAT WHEN I WOULD BE DRIVING 55-70 MPH THAT IT WOULD LIKE STALL. IT WOULDN'T SHIFT DOWN OR ACCELERATE. I WOULD HAVE TO PULL OVER & RESTART IT. IT BEGAN DOING THAT QUITE OFTEN UNTIL ONE NIGHT I WAS DRIVING DOWN THE ROAD & WENT TO TURN I… Look up ODI 10990604 at NHTSA ↗	4 ODI 11268099 · 129,000 mi I JUST PURCHASED THE 2009 VOLKSWAGEN ROUTAN. I HAVE HAD IT 3 WEEKS IT RANDOMLY DIED WHEN TEST DRIVING THE VAN AND ALL THE ALARMS AND LIGHTS CAME ON. WE JUST THOUGHT I DIDN'T HAVE THE FOB IN RIGHT. THEN IT STARTED TO RANDOMLY NOT START, EVEN THE REMOTE START WILL NOT WORK. THE LIGHTS, RADIO, ALARM, WINDOWS AND DOOR LOCKS WORK LIKE THEY NORMALLY SHOULD. USUALLY IF I WAIT LIKE 20 MINUTES AND KEEP TRYING THE KEY (TAKING IT OUT OF THE IGNITION AND REINSERTING IT) UNTIL IT STARTS. THE CHECK ENGINE LIGHT CAME ON FOR 7 DAYS. THURSDAY 10/10/2019 NOTHING… Look up ODI 11268099 at NHTSA ↗ ODI 11253574 · 155,800 mi WHILE DRIVING (CAR IN MOTION)THE CAR TO PICK UP MY CHILDREN FROM SCHOOL, IT SOUNDED LIKE IT WAS DRAINING. THE ALERT LIGHT BEEPED SO I LOOKED AT DASH THE LIGHTS/INFO ON CAR STARTED BLINKING THEN THE CAR STOPPED COMPLETELY IN MIDDLE OF THE ROAD. NO POWER WOULD WORK I COULDN'T ROLL DOWN THE WINDOWS OR TURN ON HAZARD LIGHTS, I HAD TO PUT CAR IN PARK. THE KEY WAS STUCK IN THE IGNITION AND WOULD NOT START FROM A JUMP. THE CAR HAD NO WARNING SIGNS AND WAS RECENTLY INSPECTED AND CHECKED ON COMPUTER AND THEY WERE UNABLE TO GET ANY CODES OR SEE ANY EN… Look up ODI 11253574 at NHTSA ↗ ODI 10936830 · 45,126 mi INTEGRATED BODY CONTROL/ECU:TIPM MODULE MALFUNCTION. Look up ODI 10936830 at NHTSA ↗
Fuel/Propulsion System	41 ODI 10501019 · 59,500 mi WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. *TR Look up ODI 10501019 at NHTSA ↗ ODI 10730842 · 52,577 mi I DRIVING LAST MONTH 47 MPH AND MY DRIVING SLIDING DOOR OPEN AND MY 8 YEARS GIRLS WAS DEAR AND SHE SCARE WHEN THE DOOR OPEN WHEN I DRIVING ,, AND WHEN I STOP THE DOOR NOT WANT TO CLOSE AUTOMATIC..THAT SCARE ME AND MY WIFE... THE OTHER CONCERN IS MY TRANSMISION HARD SHIFFTING ,HARD SHIFFTING , I READY TAKE LIKE 5,6 TIME MY VAN TO CHECK MY TRANSMISSION AND MY SLIDING DOOR AND THE SAY IS NORMAL , AND MY SLIDING DOOR NOT FOUND ANYTIME , THEY SAY THE SLIDING DOOR RECALL WAS DONE READY,, THE OTHER BIG CONCERN IS THE GAS MILEAGE, ONLY 11 OR 12 GALLON … Look up ODI 10730842 at NHTSA ↗ ODI 11000831 · 110,000 mi ENGINE WILL NOT START. HAPPENS ON OCCASION BUT HAPPENED ENOUGH THAT I HAD TWO STARTERS INSTALLED AS WELL AS A BATTERY. WHAT ELSE COULD IT BE? CAN TURN THE KEY AND NOTHING HAPPENS. I CAN POSSIBLY SIT THERE AND TURN THE IGNITION 10+ TIMES AND STILL NOTHING. THOUGHT IT COULD BE A BAD SPOT IN THE NEW STARTER?? CLEANED BATTERY POSTS OFTEN AND NOW HAVE TREATED THE CONNECTIONS. WOULD LIKE NOT TO RECEIVE ANOTHER CALL FROM LOVELY WIFE THAT THE VAN WOULD NOT START. HAS TO BE SOMETHING WITH A CIRCUIT STAYING OPEN OR SOMETHING. SAFETY ISSUE DUE… Look up ODI 11000831 at NHTSA ↗	17 ODI 10481360 · 57,000 mi 10/7/12: ENTERING ONTO ROAD, BEGAN ACCELERATION UP TO 20/25 MPH -THEN ALL POWER, CONTROLS DEAD. LOST POWER STEERING AND COASTED INTO PARKING LOT. SHUT CAR DOWN, FLOODED/PUMPED ACCELERATOR PEDAL. DIFFICULTY STARTING BUT WORKED, DROVE LIKE NORMAL, AGAIN. 10/14/12: TURNING FROM SIDESTREET, ON TO MAIN STREET -GOING 20 MPH. LOST ALL POWER AGAIN-MANUALLY TURNED COASTED CAR INTO LEFT MIDDLE TURNING LANE. RE-STARTED, OPERATED NORMAL. TR Look up ODI 10481360 at NHTSA ↗ ODI 10501019 · 59,500 mi WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. TR Look up ODI 10501019 at NHTSA ↗ ODI 11000831 · 110,000 mi ENGINE WILL NOT START. HAPPENS ON OCCASION BUT HAPPENED ENOUGH THAT I HAD TWO STARTERS INSTALLED AS WELL AS A BATTERY. WHAT ELSE COULD IT BE? CAN TURN THE KEY AND NOTHING HAPPENS. I CAN POSSIBLY SIT THERE AND TURN THE IGNITION 10+ TIMES AND STILL NOTHING. THOUGHT IT COULD BE A BAD SPOT IN THE NEW STARTER?? CLEANED BATTERY POSTS OFTEN AND NOW HAVE TREATED THE CONNECTIONS. WOULD LIKE NOT TO RECEIVE ANOTHER CALL FROM LOVELY WIFE THAT THE VAN WOULD NOT START. HAS TO BE SOMETHING WITH A CIRCUIT STAYING OPEN OR SOMETHING. SAFETY ISSUE DUE… Look up ODI 11000831 at NHTSA ↗	0	2 ODI 10763450 · 90,000 mi IN APRIL 2015 THE CHECK ENGINE LIGHT CAME ON IN MY 2010 VW ROUTAN, MAYBE A WEEK OR SO LATER IT STARTED TO STALL WHILE I WAS DRIVING IT. I TOOK IT TO AN IMPORT DEALER LOCALLY TO HAVE IT LOOKED AT AND WAS TOLD THAT THE EGR VALVE WAS BAD. THEY REPLACED IT, WHICH COST ME $400, AND PUT A NEW GAS CAP ON IT. IN JULY THE ENGINE LIGHT CAME ON AGAIN, HAD THE CODES RUN AT A PARTS STORE AND IT WAS THE EGR VALVE AGAIN. TOOK IT BACK TO THE SHOP THAT DID THE FIRST REPAIR BECAUSE IT STILL HAD A PARTS AND LABOR WARRANTEE WITH THEM. THEY REPLACED IT AGAIN. NOW, … Look up ODI 10763450 at NHTSA ↗ ODI 10968462 · 100,000 mi I HAVE A VOLKSWAGEN ROUTAN 2011 BUILT BY CHRYSLER IN A CANADA FACTORY. THIS VEHICLE IS SHUTTING OFF WHEN DRIVE ON THE FREEWAY. THE GEARS AND SREERING LOCKS UP WHILE DRIVING. THE VEHICLE ALSO HAS ELECTRICAL ISSUES THE LIGHTS TURN ON AND OFF EVEN WHEN THE CAR IS OFF. AFTER PURCHASING A NEW BATTERY AND ALTERNATOR THE CAR IN THE MORNING WILL NOT START. THE BATTERY IS DEAD AND DRAINED. WITH NOTHING ON IT INTERMITTENTLY HAS A DEAD BATTERY AND SHUTS OF AFTER STARTING THE CAR. WHEN I CALL THE VOLKSWAGEN DEALER IN STOCKTON CA TO EXPLAIN THE SERVICE GU… Look up ODI 10968462 at NHTSA ↗	4 ODI 10730842 · 52,577 mi I DRIVING LAST MONTH 47 MPH AND MY DRIVING SLIDING DOOR OPEN AND MY 8 YEARS GIRLS WAS DEAR AND SHE SCARE WHEN THE DOOR OPEN WHEN I DRIVING ,, AND WHEN I STOP THE DOOR NOT WANT TO CLOSE AUTOMATIC..THAT SCARE ME AND MY WIFE... THE OTHER CONCERN IS MY TRANSMISION HARD SHIFFTING ,HARD SHIFFTING , I READY TAKE LIKE 5,6 TIME MY VAN TO CHECK MY TRANSMISSION AND MY SLIDING DOOR AND THE SAY IS NORMAL , AND MY SLIDING DOOR NOT FOUND ANYTIME , THEY SAY THE SLIDING DOOR RECALL WAS DONE READY,, THE OTHER BIG CONCERN IS THE GAS MILEAGE, ONLY 11 OR 12 GALLON … Look up ODI 10730842 at NHTSA ↗ ODI 10908851 · 85,000 mi RECENTLY THE VAN HAS GIVEN ME TROUBLE UPON STARTUP. THE PROBLEM IS INTERMITTENT. SOMETIMES, IT WOULD START FINE. OTHER TIMES, IT WOULD TAKE MULTIPLE ATTEMPTS TO START THE VEHICLE. OTHER TIMES, THE VEHICLE WOULD START, THEN IMMEDIATELY TURN ITSELF OFF. SOMETIMES, IT WOULD BE LIKE THERE WASN'T ENOUGH CHARGE TO TURN THE STARTER, AND OTHER TIMES, WHEN IT WOULD START THEN DIE, IT FELT LIKE IT WAS RUNNING OUT OF GAS. AFTER MUCH RESEARCH, I DISCOVERED THAT THE TOTALLY INTEGRATED POWER MODULE IS THE CULPRIT OF THESE ISSUES. SPECIFICALLY, IT IS… Look up ODI 10908851 at NHTSA ↗ ODI 11033454 · 85,000 mi OUR TRANSMISSION ISSUE STARTED AS WE'RE GOING DOWN I-75 AT ABOUT 65-70. WHAT SOUNDED LIKE SOMETHING FALLING FROM UNDER THE HOOD AND MAKING A KLANKING SOUND AT IF IT WAS FALLING FROM THE ENGINE. AFTER A FEW MONTHS THE TRANSMISSION STARTED MAKING A HIGH PITCHED NOISE. OUR LOCAL AUTO REPAIR STORE WOULDN'T TOUCH IT SO WE HAD TO TAKE IT TO THE VW DEALER. TURNS OUT NOT ONLY DID WE NEED A NEW TRANSMISSION BUT WE ALSO NEEDED A NEW TIPM. TOTAL COST INCLUDING LABOR WAS OVER $7000.00. WE HAD ROUGHLY 85,000 MILES ON IT SO IT WAS NO LONGER COVERED UNDER WAR… Look up ODI 11033454 at NHTSA ↗	3 ODI 10981131 · 163,100 mi WHILE OPERATING THE VEHICLE THE CAR STALLED AN SIMPLY STOPPED IN THE MIDDLE OF DRIVING. COMPLETELY RIDICULOUS, VERY DANGEROUS! YOUR WEBSITE STATES THAT VEHICLES SAME YEAR, MAKE AND MODEL AND MANFU DATE THEVSAME HAVE RECALLS FOR EXACT SAME ISSUE. THIS IS URGENT. THIS COULD CAUSE THE DEATH OF ME OR MY FAMILY. IT MUST BE FIXED BY VW, ESPECIALLY WHEN RECALLS ARE THERE FOR SOME. Look up ODI 10981131 at NHTSA ↗ ODI 10898013 · 74,000 mi PROBLEM STARTED ABOUT 4 WEEKS AGO WITH CAR NOT STARTING. WOULD TURN OVER BUT NEVER CRANK UP/START. LOCAL VW DEALER SAID ISSUE WAS FUEL PUMP AND REPLACED. SYMPTOMS CONTINUED WITH LONGER THAN NORMAL CRANKING BEFORE STARTING. SOMETIMES VEHICLE ACTS LIKE THE BATTERY IS DEAD AND WILL "CLICK" UNTIL AFTER MULTIPLE ATTEMPTS IT WILL FINALLY TURN OVER AND START. CERTAIN TIMES AFTER HAVING VEHICLE IN REVERSE AND PLACING INTO DRIVE IT JUST DIES, HAVE TO PLACE IN PARK AND RESTART. WHILE SLOWING FOR A TRAFFIC LIGHT, VEHICLE HAS HESITATED AS IF TO DIE, … Look up ODI 10898013 at NHTSA ↗ ODI 10990604 · 115,000 mi THE VAN WAS MY MOTHERS WHICH SHE PASSED AWAY ABOUT YEAR AGO. I INHERITED THE VAN I DRIVE IT FOR COUPLE MONTHS WHEN I NOTICED THAT SOMETIMES WHEN I WOULD TRY TO START IT THAT IT WOULDN'T START. IT WOULD ONLY MAKE A CLICKING NOISE. I WOULD TURN KEY OFF & TRY IT AGAIN IT WOULD START. THEN IN MONTH OR SO I NOTICED THAT WHEN I WOULD BE DRIVING 55-70 MPH THAT IT WOULD LIKE STALL. IT WOULDN'T SHIFT DOWN OR ACCELERATE. I WOULD HAVE TO PULL OVER & RESTART IT. IT BEGAN DOING THAT QUITE OFTEN UNTIL ONE NIGHT I WAS DRIVING DOWN THE ROAD & WENT TO TURN I… Look up ODI 10990604 at NHTSA ↗	—	5 ODI 10968462 · 100,000 mi I HAVE A VOLKSWAGEN ROUTAN 2011 BUILT BY CHRYSLER IN A CANADA FACTORY. THIS VEHICLE IS SHUTTING OFF WHEN DRIVE ON THE FREEWAY. THE GEARS AND SREERING LOCKS UP WHILE DRIVING. THE VEHICLE ALSO HAS ELECTRICAL ISSUES THE LIGHTS TURN ON AND OFF EVEN WHEN THE CAR IS OFF. AFTER PURCHASING A NEW BATTERY AND ALTERNATOR THE CAR IN THE MORNING WILL NOT START. THE BATTERY IS DEAD AND DRAINED. WITH NOTHING ON IT INTERMITTENTLY HAS A DEAD BATTERY AND SHUTS OF AFTER STARTING THE CAR. WHEN I CALL THE VOLKSWAGEN DEALER IN STOCKTON CA TO EXPLAIN THE SERVICE GU… Look up ODI 10968462 at NHTSA ↗ ODI 11052235 · 89,000 mi TIPM MODULE. MY 2011 VW ROUTAN WAS BUILT BY CHRYSLER WITH THE SAME PARTS AS ANY OTHER CHRYSLER CAR AT THAT TIME. CHRYSLER ISSUED A RECALL FOR ALL VEHICLES MADE WITH THIS PARTICULAR PART AS IT IS A LIFE THREATENING ISSUE. MOST IMPORTANTLY THE CAR WILL STOP IN THE MIDDLE OF DRIVING! IMAGINE GOING DOWN THE FREEWAY DOING 70MPH WITH YOUR KIDS IN THE CAR AND THE CAR SHUTS OFF. FORTUNATELY WE WERE ONLY DRIVING IN A PARKING LOT. BECAUSE THE CAR IS BRANDED AS A VW, CHRYSYLER REFUSES TO REPLACE THE RECALLED PART WHICH I WAS QUOTED AT $1300 FROM THE DEALE… Look up ODI 11052235 at NHTSA ↗ ODI 11056826 · 62,300 mi REPLACED FUEL PUMP AFTER ISSUES WITH ENGINE REFUSING TO TURN OVER. NEXT DAY AFTER REPAIR THE VEHICLE REFUSED TO START; TOWED TO GARAGE FOR DIAGNOSIS. ONE MECHANIC WAS ABLE TO START IT AND ANOTHER NOT. COMPUTER DIAGNOSIS CAN'T FIND THE ISSUE. I HAVE EXPLORED THE INTERNET REGARDING THIS ISSUE AND FIND MANY COMPLAINTS WITH THE NEED TO REPLACEMTHE TIPM. THIS VAN HAS AN ENGINE BUILT BY CHRYSLER WHICH RECALLED ITS 2011 VANS TO REPLACE THIS DEVICE. PLEASE FORCE VW TO DO THE SAME! THANKFULLY THE VAN WAS IN PARK WHEN IT REFUSED TO START. Look up ODI 11056826 at NHTSA ↗
Electronic Stability Control (Esc)	24 ODI 10639576 · 54,694 mi WHILE DRIVING IN JACKSONVILLE FLORIDA ON HIGHWAY, WIPERS SUDDENLY CAME ON, ALL IDIOT LIGHTS BEGAN TO BLINK, HEADLIGHTS BEGAN FLASHING OFF AND ON, BEEPING SOUND LIKE WHEN DOOR IS OPEN, THE VAN SUDDENLY DIED AND I WAS UNABLE TO BRAKE, STEER OR CONTROL VEHICLE. THE VAN WAS TOWED TO VW DEALERSHIP THE PROBLEM WAS FOUND TO BE THE SLIDING DOOR HARNESS WHICH WAS INTERFERING WITH NORMAL OPERATION OF THE ELECTRICAL SYSTEM. REPLACED SLIDING DOOR HARNESS AND FAILED BATTERY. WHEN I QUESTIONED THE FAULTY PART POSSIBLY BEING A RECALL ISSUE I WAS TOLD IT W… Look up ODI 10639576 at NHTSA ↗ ODI 10669104 · 60,567 mi WE HAVE HAD SEVERAL OCCASIONS WHERE THE VAN COMPLETELY SHUTS OFF EVEN WHILE RUNNING. REPORTED IT TO OUR LOCAL VW DEALER AND HAVE BEEN TOLD THAT IT MIGHT BE AN IGNITION PROBLEM WHICH IS PART OF A RECALL. WAS INFORMED THAT AT THIS TIME THEY CAN'T REPAIR IT BECAUSE THEY DON'T MAKE THAT PART. HAD IT COMPLETELY SHUT DOWN ON US WHILE IT WAS GETTING SERVICED AT THE DEALER FOR NEW BRAKES. WAS TOLD THAT ALL IT NEEDED WAS NEW BATTERY. PAID FOR IT AND GOT IT TO START ONLY TO SHUT DOWN AGAIN TWO DAYS LATER. TOOK IT BACK AGAIN AND WAS TOLD THAT IT IS NOT … Look up ODI 10669104 at NHTSA ↗ ODI 10702805 · 73,000 mi IN JULY 2012 I BOUGHT A CERTIFIED PRE-OWNED 2009 VOLKSWAGEN ROUTAN MINIVAN. I HAVE REPORTED THE FOLLOWING MAJOR SAFETY PROBLEMS ON SEVERAL OCCASIONS TO NO RESOLVE: LOSS OF POWER' THE CAR WILL COMPLETELY LOSE POWER AND THE STEERING WHEEL LOCKS WHILE DRIVING. FOR EX ON 12/22 FROM 5:32P ' 10:48P, THE CAR LOST POWER AND STEERING WHEEL LOCKED 11 TIMES. SLIDING DOORS AUTOMATICALLY OPEN ' THE DOORS WILL NOT CLOSE SECURELY, WON'T OPEN, OR WILL APPEAR CLOSED AND SPONTANEOUSLY REOPEN. THERE HAVE BEEN SEVERAL TIMES WE WILL GO OUT FOR THE EVENING OR COME O… Look up ODI 10702805 at NHTSA ↗	8 ODI 10639576 · 54,694 mi WHILE DRIVING IN JACKSONVILLE FLORIDA ON HIGHWAY, WIPERS SUDDENLY CAME ON, ALL IDIOT LIGHTS BEGAN TO BLINK, HEADLIGHTS BEGAN FLASHING OFF AND ON, BEEPING SOUND LIKE WHEN DOOR IS OPEN, THE VAN SUDDENLY DIED AND I WAS UNABLE TO BRAKE, STEER OR CONTROL VEHICLE. THE VAN WAS TOWED TO VW DEALERSHIP THE PROBLEM WAS FOUND TO BE THE SLIDING DOOR HARNESS WHICH WAS INTERFERING WITH NORMAL OPERATION OF THE ELECTRICAL SYSTEM. REPLACED SLIDING DOOR HARNESS AND FAILED BATTERY. WHEN I QUESTIONED THE FAULTY PART POSSIBLY BEING A RECALL ISSUE I WAS TOLD IT W… Look up ODI 10639576 at NHTSA ↗ ODI 10669104 · 60,567 mi WE HAVE HAD SEVERAL OCCASIONS WHERE THE VAN COMPLETELY SHUTS OFF EVEN WHILE RUNNING. REPORTED IT TO OUR LOCAL VW DEALER AND HAVE BEEN TOLD THAT IT MIGHT BE AN IGNITION PROBLEM WHICH IS PART OF A RECALL. WAS INFORMED THAT AT THIS TIME THEY CAN'T REPAIR IT BECAUSE THEY DON'T MAKE THAT PART. HAD IT COMPLETELY SHUT DOWN ON US WHILE IT WAS GETTING SERVICED AT THE DEALER FOR NEW BRAKES. WAS TOLD THAT ALL IT NEEDED WAS NEW BATTERY. PAID FOR IT AND GOT IT TO START ONLY TO SHUT DOWN AGAIN TWO DAYS LATER. TOOK IT BACK AGAIN AND WAS TOLD THAT IT IS NOT … Look up ODI 10669104 at NHTSA ↗ ODI 10995677 · 130,000 mi AS WE ARE DRIVING THE POWER STEERING COMPLETELY CUTS OFF AND WILL NOT LET YOU DRIVE - THE ENGINE SHUTS OFF AND YOUR FORCED INTO TURNING THE VEHICLE COMPLETELY OFF THEM BACK ON AGAIN. THIS HAPPENED WHILE ON THE INTERSTATE IN TRAFFIC WHICH NEARLY CAUSED A COLLISION. Look up ODI 10995677 at NHTSA ↗	1 ODI 11039881 · 66,000 mi ESP ABS LIGHT ILLUMINATES WHILE CAR IS IN MOTION AND THE CAR WILL NOT SHIFT OUT OF GEAR WHEN STOPPED AS IF THE BREAK IS NOT DETECTED. HAVE TO SHUT CAR OFF IN THE MIDDLE OF TRAFFIC OR DROP OF LINES AND TURN BACK ON SEVERAL TIMES TO CLEAR ERROR AND GET SHIFTER TO SHIFT TO DRIVE GEAR. USED SNAP ON READER TO CHECK CODES AND DOES NOT RECOGNIZE CAR AS VW, INSTEAD IT PULLS UP CHRYSLER TOWN AND COUNTRY. TRIED TO REPLACE A BREAK LIGHT MODULE, THE PART WAS ACTUALLY FOR A DODGE NEON. (I AM ONLY OWNER, BOUGHT VAN BRAND NEW). SYMPTOM CAME BACK AFTER TWO DA… Look up ODI 11039881 at NHTSA ↗	6 ODI 10690482 · 41,600 mi THE CLOCKSPRING IN THE STEERING WHEEL WENT OUT. AT 28 MILES THE TRACTION CONTROL TURNS ON AND THE CAR STARTS BRAKING EVEN IF THE CAR IS NOT SKIDDING. VERY DANGEROUS. OUR MECHANIC TOLD US THE CLOCKSPRING IS A COMMON PROBLEM WITH BOTH THE VOLKSWAGEN ROUTON AND THE CHRYSLER TOWN AND COUNTRY. I FOUND ONE REPORT ON THE INTERNET THAT SAID VOLKSWAGEN STARTED SERVICING THE CLOCKSPRING AS OF 2010 ROUTON MODELS BUT DID NOTHING FOR THE 2009 ROUTON. *JS Look up ODI 10690482 at NHTSA ↗ ODI 10995677 · 130,000 mi AS WE ARE DRIVING THE POWER STEERING COMPLETELY CUTS OFF AND WILL NOT LET YOU DRIVE - THE ENGINE SHUTS OFF AND YOUR FORCED INTO TURNING THE VEHICLE COMPLETELY OFF THEM BACK ON AGAIN. THIS HAPPENED WHILE ON THE INTERSTATE IN TRAFFIC WHICH NEARLY CAUSED A COLLISION. Look up ODI 10995677 at NHTSA ↗ ODI 11076779 · 130,000 mi 2010 VOLKSWAGON ROUTAN HAS STOPPED IN MID TRAFFIC GOING 30-40 MPH ON A BUSY ROAD. LIGHTS AND AUDIO HAVE FLICKERED, THEN TURN OFF. CAR SPONTANEOUSLY STARTS AND STOPS ANY GIVEN TIME IN MOTION AND STANDING STILL, AND CANNOT BE JUMPED TO REVIVE. HAVE BEEN IN THE CAR WITH MY CHILDREN AND HAVE HAD IT STOP IN THE MIDDLE OF THE ROAD. WE HAVE HAD IT LESS THAN A YEAR, COMPLETELY UNSAFE. TOLD THE EXACT RECALL DOESN'T APPLY TO MY VIN#. Look up ODI 11076779 at NHTSA ↗	2 ODI 10897474 · 65,000 mi SOMETIMES THE VEHICLE WILL NOT START FOR NO APPARENT REASON.VW SERVICE DEPT. CANNOT DETECT AN ISSUE. ENGINE LIGHT COMES ON INTERMITTENTLY WHILE DRIVING-VW CANNOT DETECT ANYTHING WRONG.* ALARMS GO OFF BUT NO SIGNAL SHOWING ON THE DASHBOARD.POWER WINDOWS AND SEATS WORK INTERMITTENTLY- FOUND VEHICLE'S SLIDING DOOR WIDE OPEN I PARKING LOT, TWICE. * HAVE ALSO FOUND WINDOWS OPEN. OUR LIFT GATE (TRUNK) OPENED WHILE DRIVING ON THE HIGHWAY.* VEHICLE FAILED TO SHIFT,WHILE DRIVING, REVVED AND WOULD NOT RESET UNTIL PULLING OVER AND TURNING OFF THE VEHI… Look up ODI 10897474 at NHTSA ↗ ODI 11022870 VOLKSWAGEN ROUTAN 2010 WILL TURN OFF WHILE IN MOTION, ON HIGHWAY, STREET, OR WHEN STATIONARY. CAR IS AN AUTOMATIC AND WILL NOT ADJUST TO THE PROPER GEAR WHEN DRIVING. WHEN IN DRIVE THE CAR WILL ACT AS IF IT IS IN NEUTRAL AND ROLL BACKWARDS AND WILL NOT KICK INTO FIRST GEAR. THE ELECTRONIC SYSTEM NEVER WORKS PROPERLY AND IS CONSTANTLY NEEDING NEW BATTERIES VERY FEW MONTHS. THIS CAR IS UNSTABLE, UNSAFE, AND UNRELIABLE! THE VOLKSWAGEN ROUTAN 2010 NEEDS TO BE RECALLED IMMEDIATELY! Look up ODI 11022870 at NHTSA ↗	4 ODI 11268099 · 129,000 mi I JUST PURCHASED THE 2009 VOLKSWAGEN ROUTAN. I HAVE HAD IT 3 WEEKS IT RANDOMLY DIED WHEN TEST DRIVING THE VAN AND ALL THE ALARMS AND LIGHTS CAME ON. WE JUST THOUGHT I DIDN'T HAVE THE FOB IN RIGHT. THEN IT STARTED TO RANDOMLY NOT START, EVEN THE REMOTE START WILL NOT WORK. THE LIGHTS, RADIO, ALARM, WINDOWS AND DOOR LOCKS WORK LIKE THEY NORMALLY SHOULD. USUALLY IF I WAIT LIKE 20 MINUTES AND KEEP TRYING THE KEY (TAKING IT OUT OF THE IGNITION AND REINSERTING IT) UNTIL IT STARTS. THE CHECK ENGINE LIGHT CAME ON FOR 7 DAYS. THURSDAY 10/10/2019 NOTHING… Look up ODI 11268099 at NHTSA ↗ ODI 11253574 · 155,800 mi WHILE DRIVING (CAR IN MOTION)THE CAR TO PICK UP MY CHILDREN FROM SCHOOL, IT SOUNDED LIKE IT WAS DRAINING. THE ALERT LIGHT BEEPED SO I LOOKED AT DASH THE LIGHTS/INFO ON CAR STARTED BLINKING THEN THE CAR STOPPED COMPLETELY IN MIDDLE OF THE ROAD. NO POWER WOULD WORK I COULDN'T ROLL DOWN THE WINDOWS OR TURN ON HAZARD LIGHTS, I HAD TO PUT CAR IN PARK. THE KEY WAS STUCK IN THE IGNITION AND WOULD NOT START FROM A JUMP. THE CAR HAD NO WARNING SIGNS AND WAS RECENTLY INSPECTED AND CHECKED ON COMPUTER AND THEY WERE UNABLE TO GET ANY CODES OR SEE ANY EN… Look up ODI 11253574 at NHTSA ↗ ODI 10936830 · 45,126 mi INTEGRATED BODY CONTROL/ECU:TIPM MODULE MALFUNCTION. Look up ODI 10936830 at NHTSA ↗	5 ODI 10968462 · 100,000 mi I HAVE A VOLKSWAGEN ROUTAN 2011 BUILT BY CHRYSLER IN A CANADA FACTORY. THIS VEHICLE IS SHUTTING OFF WHEN DRIVE ON THE FREEWAY. THE GEARS AND SREERING LOCKS UP WHILE DRIVING. THE VEHICLE ALSO HAS ELECTRICAL ISSUES THE LIGHTS TURN ON AND OFF EVEN WHEN THE CAR IS OFF. AFTER PURCHASING A NEW BATTERY AND ALTERNATOR THE CAR IN THE MORNING WILL NOT START. THE BATTERY IS DEAD AND DRAINED. WITH NOTHING ON IT INTERMITTENTLY HAS A DEAD BATTERY AND SHUTS OF AFTER STARTING THE CAR. WHEN I CALL THE VOLKSWAGEN DEALER IN STOCKTON CA TO EXPLAIN THE SERVICE GU… Look up ODI 10968462 at NHTSA ↗ ODI 11052235 · 89,000 mi TIPM MODULE. MY 2011 VW ROUTAN WAS BUILT BY CHRYSLER WITH THE SAME PARTS AS ANY OTHER CHRYSLER CAR AT THAT TIME. CHRYSLER ISSUED A RECALL FOR ALL VEHICLES MADE WITH THIS PARTICULAR PART AS IT IS A LIFE THREATENING ISSUE. MOST IMPORTANTLY THE CAR WILL STOP IN THE MIDDLE OF DRIVING! IMAGINE GOING DOWN THE FREEWAY DOING 70MPH WITH YOUR KIDS IN THE CAR AND THE CAR SHUTS OFF. FORTUNATELY WE WERE ONLY DRIVING IN A PARKING LOT. BECAUSE THE CAR IS BRANDED AS A VW, CHRYSYLER REFUSES TO REPLACE THE RECALLED PART WHICH I WAS QUOTED AT $1300 FROM THE DEALE… Look up ODI 11052235 at NHTSA ↗ ODI 11056826 · 62,300 mi REPLACED FUEL PUMP AFTER ISSUES WITH ENGINE REFUSING TO TURN OVER. NEXT DAY AFTER REPAIR THE VEHICLE REFUSED TO START; TOWED TO GARAGE FOR DIAGNOSIS. ONE MECHANIC WAS ABLE TO START IT AND ANOTHER NOT. COMPUTER DIAGNOSIS CAN'T FIND THE ISSUE. I HAVE EXPLORED THE INTERNET REGARDING THIS ISSUE AND FIND MANY COMPLAINTS WITH THE NEED TO REPLACEMTHE TIPM. THIS VAN HAS AN ENGINE BUILT BY CHRYSLER WHICH RECALLED ITS 2011 VANS TO REPLACE THIS DEVICE. PLEASE FORCE VW TO DO THE SAME! THANKFULLY THE VAN WAS IN PARK WHEN IT REFUSED TO START. Look up ODI 11056826 at NHTSA ↗	—

Co-reporting does not establish that one component caused another concern.

Recurring narrative patterns

Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.

Search patterns

7 patterns with matching reports.

Stalling or loss of power

195 mentions · 24.9% of complaints

Median mileage: 71,000 mi (180 usable records).

ODI 10671784 · 58,000 mi

TL* THE CONTACT OWNS A 2008 VOLKSWAGEN ROUTAN. WHILE DRIVING 20 MPH, THE VEHICLE STALLED AND THE ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 58,000.

Look up ODI 10671784 at NHTSA ↗

ODI 10428182 · 51,000 mi

ENGINE SHUT OFF WHILE DRIVING, STEERING COLUMN LOCKED AND POWER BRAKING LOST. LIGHTING AND RADIO WERE STILL ON. WAS BARELY ABLE TO VEHICLE TO A STOP BY PUSHING EXTREMELY HARD ON THE BRAKE, BRAKES WERE VERY UNRESPONSIVE. ONCE STOPPED, WAS ABLE TO TURN IGNITION OFF AND RESTART VEHICLE. *TR

Look up ODI 10428182 at NHTSA ↗

ODI 10465366 · 38,000 mi

VAN WAS TRAVELING 65MPH ON INTERSTATE WHEN THE CAR SWITCHED FROM ON TO ACCESSORY MODE. VW SERVICE INDICATED THAT THE INCIDENT WAS CAUSED BY A FAULTY WIN (WIRELESS IGNITION NODE MODULE). WHEN THE CAR SWITCHED TO ACCESSORY MODE, I LOST POWER TO THE ENGINE AND I HAD NO ANTI-LOCK BRAKES OR POWER STEERING. I WAS ABLE TO COAST THE VAN TO THE SIDE OF THE ROAD WITHOUT AN ACCIDENT. THIS EXACT ISSUE HAS BEEN REPORTED IN SEVERAL 2009 ROUTANS AND WAS ALREADY SUBJECT TO A RECALL FOR THE 2010 ROUTAN'S. IT ALSO IMPACTS THE GRAND CARAVANS AND TOWN & COUN…

Look up ODI 10465366 at NHTSA ↗

Matching rule

\b(stall\w*|loss of power|lost power|engine shut\w* off)\b

Warning lights and dashboard alerts

87 mentions · 11.1% of complaints

Median mileage: 84,500 mi (78 usable records).

ODI 10671784 · 58,000 mi

Look up ODI 10671784 at NHTSA ↗

ODI 10461184 · 4,000 mi

WE BOUGHT THIS VEHICLE IN APRIL OF 2009 BASED ON ALL OF THE "SAFETY FEATURES" AND AS IT TURNS OUT HAS BEEN ONE OF THE MOST UNSAFE VEHICLE I HAVE EVER OWNED. SINCE PURCHASE WE HAVE HAD THE ROTORS CUT 2X AND REPLACED ONCE DUE TO VIOLENT SHAKING IN FRONT END WHEN BRAKING AT ANY SPEED. THE FIRST TIME WE WERE TOLD THIS WAS DUE TO THE VEHICLES SITTING IN THE RAIN FOR A PERIOD OF TIME . WHAT ??? THAT MAY BE THE MOST AGGRAVATING OF ALL WHICH IS THAT VW WOULD RATHER ASSUME YOU ARE STUPID ENOUGH TO BELIEVE THAT. ANOTHER ISSUE HAS BEEN THAT THE HEAD UNIT …

Look up ODI 10461184 at NHTSA ↗

ODI 10508770 · 34,000 mi

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED TO 85 MPH. THE CONTACT DEPRESSED THE BRAKES CONTINUALLY UNTIL THE VEHICLE CAME TO A STOP. THE BRAKE WARNING LIGHT WAS ALSO ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 34,000. *TR

Look up ODI 10508770 at NHTSA ↗

Matching rule

\b(warning light\w*|check engine|dashboard warning\w*|malfunction indicator)\b

Steering assistance concerns

76 mentions · 9.7% of complaints

Median mileage: 85,000 mi (71 usable records).

ODI 10409276 · 52,000 mi

MY WIFE (AND 8 MONTH OLD SON) WERE DRIVING WHEN THE VAN SUDDENLY SHUT OFF. MY WIFE WAS DRIVING APPROXIMATELY 55 MPH. SHE WAS ABLE TO GET THE VAN OFF THE ROAD BEFORE THE STEERING WHEEL LOCKED UP. SHE WAS ABLE TO RESTART THE VAN. SHE WAS ABLE TO AVOID A REAR-END COLLISION WITH A TRACTOR-TRAILER THAT WAS BEHIND HER. *TR

Look up ODI 10409276 at NHTSA ↗

ODI 10465366 · 38,000 mi

Look up ODI 10465366 at NHTSA ↗

ODI 10481360 · 57,000 mi

10/7/12: ENTERING ONTO ROAD, BEGAN ACCELERATION UP TO 20/25 MPH -THEN ALL POWER, CONTROLS DEAD. LOST POWER STEERING AND COASTED INTO PARKING LOT. SHUT CAR DOWN, FLOODED/PUMPED ACCELERATOR PEDAL. DIFFICULTY STARTING BUT WORKED, DROVE LIKE NORMAL, AGAIN. 10/14/12: TURNING FROM SIDESTREET, ON TO MAIN STREET -GOING 20 MPH. LOST ALL POWER AGAIN-MANUALLY TURNED COASTED CAR INTO LEFT MIDDLE TURNING LANE. RE-STARTED, OPERATED NORMAL. *TR

Look up ODI 10481360 at NHTSA ↗

Matching rule

\b(power steer\w*|steering assist\w*|steering lock\w*|steering wheel lock\w*)\b

Battery drain and no-start mentions

42 mentions · 5.4% of complaints

Median mileage: 79,000 mi (31 usable records).

ODI 10681477 · 105,023 mi

HAVE OWNED THIS VEHICLE FOR 5 MONTHS. VEHICLE WOULD NOT START...HAD BEEN DRIVEN APROX 30 MILES/COOLED JUST WOULD CLICK, WOULD RESTART AFTER TIME GIVEN, TAKEN TO DEALER NO PROBLEMS FOUND, IT HAS DONE THIS 4 MORE TIME SINCE, IS PART OF THE RECALL 14V-396. HAVE TAKEN IT BACK TO THE DEALER PURCHASED FROM AND VW DEALERSHIP AND PROBLEM CANNOT BE DUPLICATED THEREFORE IT CANNOT BE REPAIRED. IT HAS BEEN IN THE SHOP FOR TWO WEEKS AND NO SOLUTION FOUND....SUSPECT IT IS THE IGNITION SWITCH IN THE RECALL BUT IS NOT THROWING OUT ANY CODE. VW STATES THAT THEY…

Look up ODI 10681477 at NHTSA ↗

ODI 10692950

TL*THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM). THE CONTACT STATED THAT THE PART NEEDED TO REMEDY THE VEHICLE WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 4/21/15*CN THE CONSUMER STATED THE VEHICLE WOULD NOT START. UPDATED 04/20/15*JB

Look up ODI 10692950 at NHTSA ↗

ODI 10924877 · 120,000 mi

THE CAR WON'T START INTERMITTENTLY. WHEN YOU TURN THE KEY IT JUST CLICKS. THE STARTER IS NOT ENGAGED OR THE FLYWHEEL DOESN'T TURN. TOOK IT TO THE DEALER SAID IT WAS FAULTY TIPM MODULE NEEDED TO BE REPLACED NOT COVERED BY WARRANTY. GOOGLE TIPM ROUTAN/ CHRYSLER / DODGE / JEEP AND YOU WILL SEE THIS IS A HUGE PROBLEM. NOT SURE WHY THE GOVERNMENT WON'T FORCE CHRYSLER / VOLKSWAGEN (CHRYSLER MANUFACTURED THE ROUTAN FOR VOLKSWAGEN) TO RECALL THEM AFFECTED VEHICLES. THIS NOT COVERED BY WARRANTY AND ITS A $1200 TO REPLACE. COMPLETELY RIDICULOUS IF THIS I…

Look up ODI 10924877 at NHTSA ↗

Matching rule

Hard or delayed shifting

23 mentions · 2.9% of complaints

Median mileage: 65,000 mi (21 usable records).

ODI 10620715 · 40,000 mi

I WAS ACCELERATING FROM A RED LIGHT WHEN THE HOSE FROM THE COOLING SYSTEM EXPLODED. MY VAN LURCHED FORWARD AND DIED. I HAD PURCHASED AN EXTENDED WARRANTY BUT WAS TOLD THEY WOULD NOT COVER IT. I HAD TO PAY OVER $600 TO GET THE HOSE FIXED. THIS IS JUST THE BEGINNING OF MANY PROBLEMS. *TR

Look up ODI 10620715 at NHTSA ↗

ODI 10717419 · 51,496 mi

THE FIRST INCIDENT WITH A "CLUNKING" NOISE OF THE TRANSMISSION BEGAN ON 7/10/2014 AT 51,496 MILES. WHEN SHIFTING FROM REVERSE TO DRIVE CAR MAKES A "CLUNKING" NOISE AND JERKS THE CAR FORWARD. IT WAS NOTED BY DEALERSHIP AFTER A TEST DRIVE NO FAULTS FOUND. ON 3/19/15 AT 58,611 MILES CAR RETURNED TO DEALERSHIP. SAME CLUNKING AND GRINDING NOISES. FAULTS: P0868, P1790 & P0944. PRESSURE READINGS TO LOW IN TCM CONTROL WIRES. TRANSMISSION TO BE REPLACED PER DEALERSHIP. FINDINGS: UNDER DRIVE CLUTCHES WORN OUT, SUNGEARS AND ASSEMBLY DAMAGED WITH METAL MET…

Look up ODI 10717419 at NHTSA ↗

ODI 10734696 · 74,000 mi

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING APPROXIMATELY 15 MPH, THE STEERING WHEEL JERKED AND THE VEHICLE SHUT OFF. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.

Look up ODI 10734696 at NHTSA ↗

Matching rule

Brake response concerns

12 mentions · 1.5% of complaints

Median mileage: 55,000 mi (11 usable records).

ODI 10390455 · 40,715 mi

PREMATURE REAR BRAKE FAILURE. WITH 40K MILES THE REAR CALIPER LOCKED CAUSING BURNING OF THE PADS, AND REQUIRING COMPLETE REPLACEMENT OF ALL REAR BRAKE COMPONENTS. *TR

Look up ODI 10390455 at NHTSA ↗

ODI 10407066 · 200 mi

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT WAS DRIVING VARIOUS SPEED AND WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL, THERE WAS A DELAYED RESPONSE WITH AN EXCESSIVE VIBRATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FIVE SEPARATE OCCASIONS WHO STATED THE BRAKES WERE NOT COMPATIBLE FOR THE VEHICLE WEIGHT CAPACITY. THE FRONT AND REAR ROTORS WERE REPLACED FIVE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 200.

Look up ODI 10407066 at NHTSA ↗

ODI 10700702 · 91,770 mi

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING APPROXIMATELY 40 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE BRAKES FAILED TO RESPOND WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIE…

Look up ODI 10700702 at NHTSA ↗

Matching rule

Oil consumption or dilution

3 mentions · 0.4% of complaints

Median mileage: 16,080 mi (3 usable records).

ODI 10631181 · 87,000 mi

WHILE ENTERING FREEWAY LOUD NOISE THEN ALL INDICATOR LIGHTS CAME ON. VEHICLE QUIT RUNNING IN TRAFFIC. COASTED OFF ROADWAY. INSPECTED ENGINE AND SPACER BETWEEN ENGINE BLOCK AND OIL PAN WAS CRACKED. ENGINE SEIZED AND INTERNAL PARTS CRACKED BLOCK. ENGINE HAD NEW PISTON RINGS AND VALVE SEALS INSTALLED AT 68000 MILES BY DEALER FOR OIL CONSUMPTION ISSUES. OIL CONSUMPTION ISSUE WAS NEVER RESOLVED. *TR

Look up ODI 10631181 at NHTSA ↗

ODI 10649852 · 12,000 mi

OIL CONSUMPTION SINCE 24000 MILES. VW DEALER NEVER WANT TO ADDRESS THE PROBLEM. KEEP TELL ME THIS NORMAL. NOW I HAVE TO ADD QUARTER OIL EVERY MONTH. ON MORNING CAR WASN'T STARTING AND TOOK TO THE DEALER AND HAD THE IGNITION REPLACED AT 42000 MILES BUT NOW THE KEY GET STUCK ON IGNITION MULTIPLE TIMES. I HOPE THE RECALL WILL FIX THIS PROBLEM. I HAD TO REPLACE BRAKES AT 12000 MILES DUE THE VIBRATION WHILE BRAKES. I HAD MULTIPLES ELECTRICAL PROBLEMS AND SOME WAS REPAIR AFTER COUPLE TRIPS TO THE DEALER. THIS CAR IS A LEMON. WHEN WE WILL HAVE OUR MO…

Look up ODI 10649852 at NHTSA ↗

ODI 10703606 · 16,080 mi

OIL CONSUMPTION SINCE 12000 MILES. VW DEALER NEVER WANT TO ADDRESS THE PROBLEM. KEEP TELL ME THIS NORMAL. NOW I HAVE TO ADD QUARTER OIL EVERY1400 MIL. I HOPE THE RECALL WILL FIX THIS PROBLEM. I HAD TO REPLACE BRAKES AT 12000 MILES DUE THE WHILE BRAKES. I'VE DONE OIL CONSUMPTION TEST 3 TIMES ALREADY. *TR

Look up ODI 10703606 at NHTSA ↗

Matching rule

\b(oil consumption|burn\w* oil|consum\w* oil|oil dilution|gas(?:oline)? in (?:the )?oil)\b