Volvo VNX recalls by model year

Reported: 2014-09-11 (September 11, 2014) · Model years: 2015

Volvo Trucks North America (Volvo) is recalling certain model year 2015 VNL and VNX trucks manufactured January 7, 2014, to June 5, 2014, and equipped with a D16 engine. Due to the engine control unit having an incorrect parameter setting in the software, the engine may stall.

Consequence: An engine stall while driving increases the risk of a crash.

Remedy: Volvo will notify owners, and dealers will update the engine control unit software, free of charge. The recall began in October 2014. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1404.

Reported: 2015-01-22 (January 22, 2015) · Model years: 2015, 2016

Volvo Trucks North America (Volvo) is recalling certain model year 2015 and 2016 VNX and VNL trucks manufactured from May 20, 2014, through March 6, 2015, equipped with certain Haldex Life Seal Type 30/30 Long Stroke Air Brake Actuators manufactured January 9, 2014, to October 28, 2014. The affected actuators may have an incomplete attachment of the internal rubber diaphragm to the actuation mechanism of the parking brake section of the Life Seal actuator.

Consequence: If the diaphragm is not completely attached, there may be internal leakage from the service section past the diaphragm, potentially trapping air pressure in the parking brake section. This air pressure in turn, if not vented, may prevent full release of the actuator unit, and may induce brake drag and may result in overheated wheelend service brakes, increasing the risk of a fire.

Remedy: Volvo will notify owners, and dealers will inspect the brake actuator and replace, as necessary, free of charge. The recall began March 20, 2015. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1501.

Reported: 2016-02-17 (February 17, 2016) · Model years: 2016, 2017

Volvo Trucks North America (Volvo) is recalling certain model year 2016-2017 VNL, VNX, and VNM trucks manufactured from May 11, 2015, through April 18, 2016. The trucks may have been manufactured without a roll pin on the steering shafts. If the roll pin is missing, the lower steering shaft may disconnect from the junction block. Also, the bolt connecting the upper steering shaft to the lower steering shaft may not have been properly tightened. Either condition can lead to separation of the steering shaft.

Consequence: Separation of the steering shaft will result in complete loss of steering which may lead to a vehicle crash.

Remedy: Volvo is strongly recommending that the affected vehicles not be driven until the interim remedy is applied. An interim notice was sent to Volvo owners on March 16, 2016, and an interim repair is available now. A second notice was mailed on May 13, 2016. The final remedy is now available. Both remedies are free of charge. Owners may contact Volvo customer service at 1-877-800-4945 opt #1. Volvo's recall numbers for this campaign are RVXX1602 and RVXX1603. This recall supersedes safety recall 15V-786.

Reported: 2016-12-22 (December 22, 2016) · Model years: 2017

Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.

Consequence: If the brake system becomes contaminated, braking performance could be affected, increasing the risk of a crash.

Remedy: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1608.

Reported: 2019-03-18 (March 18, 2019) · Model years: 2018, 2019, 2020

Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VNL and VNX vehicles configured as 740 and 760 sleeper models. The sleeper bunk window may detach and fall from the vehicle.

Consequence: If a window detaches from the vehicle, it may strike another vehicle or pedestrian, increasing the risk of a crash or injury.

Remedy: Volvo Trucks has notified owners, and dealers will replace the window hinge, free of charge. Owners were notified of the recall on April 8, 2019 and will be sent a second notice when the remedy parts are available. The recall began August 21, 2019. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX1902.