U.S. public vehicle records

Volvo XC90 transmission problems

289 complaint narratives mention transmission terms.

Key facts

1,524 owner complaints analyzed

35 distinct recall campaigns

75,000 mi median reported failure mileage

Scope: 2003 to 2025 model years. Data updated: 2026-09-30 (September 30, 2026). 997 complaints include usable failure mileage. View data status.

Transmission and shifting evidence

289 of 1,524 complaints match this topic (19.0%). The keyword filter can include complaints that mention a transmission without reporting its failure. View matching rules.

Owner report 10041548 · 2003-10-09 (October 9, 2003)

WE BOUGHT A 2003 VOLVO XC 90 IN JANUARY 2003, THE VEHICLE IS LESS THAN A YEAR OLD AND HAS ABOUT 12,600 MILES. IN THE LAST SIX WEEKS, WE HAVE HAD FOUR SYSTEM PROBLEMS, BRAKES, CRUISE CONTROL, AC/ DEFROSTER AND MOST RECENTLY AUTOMATIC TRANSMISSION. I BELIEVE THAT THE TRANSMISSION IS THE MOST SERIOUS PROBLEM SINCE IT FAILED TO OPERATE WHILE MY WIFE WAS DRIVING ON THE HIGHWAY.THE DEALER REPAIRED THE VEHICLE STATING THAT A CORRUPT SOFTWARE WAS THE CAUSE. VOLVO USA STATED THAT THE "NEW " SOFTWARE WAS A MODIFICATION/UPGRADE WHICH IS BEING PUT IN THE 2…

Owner-reported narrative. 12,600 miles reported. Look up ODI 10041548 at NHTSA ↗

Owner report 10045003 · 2003-10-20 (October 20, 2003)

PROBLEMS WITH VEHICLE'S TRANSMISSION, SEAT BELTS DO NOT LATCH, DRIVER'S SEAT RECLINES BY ITSELF. *MR THE RADIO WENT OUT AND THE ENGINE MADE A GRINDING NOISE *SCC *JB

Owner-reported narrative. 12,000 miles reported. Look up ODI 10045003 at NHTSA ↗

Owner report 10049611 · 2003-12-11 (December 11, 2003)

FOR BOTH OUR 2001 VOLVO S60 2.4T AND OUR 2003 VOLVO XC90 2.5T AWD THERE HAVE BEEN UNSUCCESSFUL ATTEMPTS TO REPAIR A TRANSMISSION DEFECT (ESSENTIALLY SAME TRANSMISSION IN BOTH VEHICLES PER VOLVO TECH SUPPORT). BETWEEN 2ND AND 3RD THERE IS INTERMITTENT/UNPREDICTABLE FAILURE TO ENGAGE 3RD IN TIMELY FASHION WITH RESULTANT LOSS OF ACCELERATION AS VEHICLE IS FUNCTIONALLY IN NEUTRAL WITH ENGINE RACING FOR ~0.5-2.5 SECONDS. THIS CAN BE EXTREMELY DANGEROUS ESPECIALLY WHEN PULLING ON TO A HIGHWAY. WE HAVE EXPERIENCED 2 NEAR COLLISIONS (ALMOST BEING …

Owner-reported narrative. 9,000 miles reported. Look up ODI 10049611 at NHTSA ↗

Owner report 10079652 · 2004-06-22 (June 22, 2004)

WHEN SHIFTING VEHICLE FROM PARK TO DRIVE VEHICLE ACCELERATED OR DECELERATED FOLLOWED BY A NOISE. DEALERSHIP COULD NOT DUPLICATE THE PROBLEM.*AK

Owner-reported narrative. Look up ODI 10079652 at NHTSA ↗

Owner report 10191378 · 2007-05-21 (May 21, 2007)

TL*THE CONTACT OWNS A 2003 VOLVO XC 90. THE CURRENT MILEAGE WAS 75000 AND THE FAILURE MILEAGE WAS 47000. THE VEHICLE IS HAVING TRANSMISSION PROBLEMS. WHILE DRIVING 45 MPH AND TRYING TO ACCELERATE, THE ACCELERATIONS DIES, MAKING THE VEHICLE UNABLE TO MOVE AS NEEDED. THIS INCIDENT OCCURED TWICE LAST YEAR, AND LAST WEEK. THE DEALER STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT DOES NOT HAVE THE VIN; HOWEVER SHE WILL ADD IT TO THE COMPLAINT WHEN SHE RECEIVES THE HARD COPY.

Owner-reported narrative. 47,000 miles reported. Look up ODI 10191378 at NHTSA ↗

Explore the data

Vehicle analysis explorer

Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.

Data completeness

1,524 unique complaints in this selection. Analysis snapshot: 2026-09-30.

65.4%Usable mileage997 / 1,524 records

100.0%Valid incident date1,524 / 1,524 records

100.0%Valid filing date1,524 / 1,524 records

100.0%Ordered incident and filing dates1,524 / 1,524 records

Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.

Problems by model year

Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.

From model yearThrough model year

Component complaint heatmap
Component	2011	2012	2013	2014	2015	2016	2017	2018	2019	2020	2021	2022	2023	2024	2025
Electrical System	526.3% ODI 10668277 · 63,035 mi THE BATTERY IN THE VEHICLE FAILS DUE TO A DRAIN IN THE POWER SYSTEMS BECAUSE OF A FAILURE IN SOFTWARE SYSTEMS ,THIS FAULT IS KNOWN TO VOLVO AND THEY REFUSE TO REPAIR .IF THE CAR IS NOT DRIVEN EVERY DAY THE ELECTRONIC SYSTEMS SEARCH FOR BLUE TOOTH PHONE SIGNALS AND SATELLITE RADIO SIGNALS CAUSING A DRAIN ON THE ELECTRICAL SYSTEMS ENOUGH TO KILL THE BATTERY ON A DAILY BASIS. VOLVO SAYS THEY HAVE A REPAIR FOR THIS AND SAY THAT I MUST PAY. THIS IS A KNOWN DEFECT TO VOLVO THEY SHOULD REPAIR THIS. *TR Look up ODI 10668277 at NHTSA ↗	133.3% ODI 10862587 · 44,013 mi TL* THE CONTACT OWNS A 2012 VOLVO XC90. THE CONTACT STATED THAT THE REAR BACK UP CAMERA AND GPS SYSTEM WORKED INTERMITTENTLY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER APPROXIMATELY SIX TIMES WHERE THE TECHNICIAN DIAGNOSED THAT THE VEHICLE NEEDED A SOFTWARE UPDATE AND THE MULTIMEDIA MODULE AND CAMERA NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER INFORMED THE CONTACT THAT DUE TO THE SOFTWARE COMPANY GOING OUT OF BUSIN… Look up ODI 10862587 at NHTSA ↗	218.2% ODI 10861229 · 31,000 mi THE ANTI SKID SERVICE IS NOT FUNCTIONING. THE WARNING LIGHT KEEPS COMING ON AND OFF PERIODICIALLY. WHEN THIS HAPPENS, I SOMETIMES LOSE THE DASH LIGHTS, BLINKERS AND THE FUEL DOOR UNLOCKS. THE ISSUE IS NOT HAPPENING CONSISTENTLY. SOMETIMES IT WON'T HAPPEN FOR MONTHS AND THEN IT WILL HAPPEN AGAIN MULTIPLE TIMES. I HAVE TAKEN IT TO VOLVO TWICE AND THEY ARE UNABLE TO DETERMINE WHY THIS ISSUE IS HAPPENING. Look up ODI 10861229 at NHTSA ↗	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	5527.9% ODI 10808864 · 4,000 mi CAR WAS HAVING ISSUES WITH SPEEDOMETER SCREEN AND CENTER CONSOLE SCREENS. SCREEN WOULD BLANK OUT WHEN NAVIGATION SYSTEM WAS IN USE AND VEHICLE WAS MOVING. THIS WOULD HAPPEN TWICE AND SYSTEM WOULD NORMALIZE. SEVERAL WEEKS AGO THIS HAPPENED AND MY HUSBAND AND I SMELLED A WEIRD ODOR AND THEN SMOKE BEGAN BELLOWING OUT CENTER CONSOLE. UNIT WAS TURNED OFF AND DEALER CONTACTED. VEHICLE WAS BROUGHT IN BUT AFTER THREE WEEKS STILL HAS ISSUES. WENT TO PICK UP CAR ON 12/5 ONLY TO FIND VEHICLE WAS HAVING ISSUE WITH RETAINING A FULLY CHARGED BATTERY. WE WE… Look up ODI 10808864 at NHTSA ↗	1822.8% ODI 10970765 · 1,500 mi TL* THE CONTACT OWNS A 2017 VOLVO XC90. WHILE DRIVING VARIOUS SPEEDS WITH THE PILOT ASSIST AND LANE ASSIST SYSTEMS ACTIVATED, THE VEHICLE WOULD ERRONEOUSLY CHANGE LANES AND/OR CHANGE DIRECTIONS. ON OCCASION, THE FEATURES WOULD ERRONEOUSLY SHUT OFF FOR NO REASON. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE CAUSE OF THE FAILURES COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 1,500. UPDATED 06/02/17LJ AS Look up ODI 10970765 at NHTSA ↗	1530.0% ODI 11056836 · 3,400 mi BRAKES CONTINOUSLY SQUEAK. THE DEALER HAS INSPECTED THE BREAK SYSTEM TWICE AND MADE ONE ATTEMPTED REPAIR. ONE WEEK LATER THE BRAKES ARE BACKING TO SQUEAKING. I HAVE OWNED THE VEHICLE LESS THAN 90 DAYS, I'VE HAD ISSUES WITH THE BRAKES FOR MORE THAN HALF THAT TIME. THE CENTER DISPLAY COMPUTER SCREENS FREEZES CONSTANTLY, BUT RECENTLY FREEZES AND WILL NOT RESTART UNTIL AFTER THE CAR IS STOPPED AND RESTARTED. Look up ODI 11056836 at NHTSA ↗	1126.2% ODI 11189914 · 500 mi I PURCHASED MY NEW 2019 VOLVO XC90 ON DECEMBER 15, 2018. ON THE MORNING OF DECEMBER 29, 2018 I WAS WITH MY TWO CHILDREN WHEN THERE WAS A MALFUNCTION WITH THE VEHICLE KEY RECOGNITION SYSTEM WHICH ALLOWS FOR THE VEHICLE TO START. MY VEHICLE GAVE ME THE ERROR 'VEHICLE KEY NOT FOUND. SEE OWNER'S MANUAL'. THIS LEFT MYSELF, MY 4 YEAR OLD AND MY 4 MONTH OLD STRANDED. THE LOCAL FORT MYERS DEALER SAID THEY REPLACED THE FOB ANTENNA. MY VEHICLE THEN HAD THE SAME PROBLEM FEBRUARY 14, 2019 LEAVING MYSELF AND MY TWO CHILDREN STRANDED BECAUSE THE VEHICLE WOUL… Look up ODI 11189914 at NHTSA ↗	928.1% ODI 11584613 The airbag system detected a fault and caused an automated vehicle warning message, which, with further dealer diagnosis, caused the driver seat belt to have a ground fault issue, preventing the normal, safe, and fully operating vehicle airbags. The cause and what must be replaced to rectify the problem are unknown. Volvo has poor customer support and satisfaction regarding avoidable repairs, along with various documented airbag failure incidents confirming a severe issue with its system components that require government oversight and correc… Look up ODI 11584613 at NHTSA ↗	1129.7% ODI 11388231 · 700 mi WITH THE BOWERS & WILKINS SOUND SYSTEM TWICE WITHIN 1400 MILES, THERE WAS A LOUD "POP" SOUND FROM THE SPEAKERS FOLLOWED BY NO SOUND FROM ANY PORTION OF THE VEHICLE. THE POP SOUNDED LIKE A WINDOW OR THE SUNROOF SHATTERED. ALL SOUND WAS LOST: SENSUS FEEDBACK, TURN SIGNALS, PARKING SENSORS, PHONE, ETC. THE ONLY THING THAT WORKED WAS THE BASS. AFTER THE CAR WAS PARKED AND OFF, AND RE-STARTED, EVERYTHING WORKED AS NORMAL. ODDLY, THERE WAS THE FEELING OF STATIC ELECTRICITY JUST PRIOR TO EACH POP. THESE POPS WERE CAUGHT ON DASH CAM FOR PROOF. THERE … Look up ODI 11388231 at NHTSA ↗	1344.8% ODI 11481092 Propulsion Service Required message one week after we picked up our new car. Three weeks later----check engine light. Soon after another Propulsion Service Required. Each time, our dealership reset the computer. Three months into ownership, on I-84, traveling 75 mph in the far left lane: turtle mode light, loss of power, no propulsion, able to just get off the freeway on the left. Two hour wait for assistance on side of freeway in 98 degree heat. Dealership kept car for 40 days: replaced BDU, AC compressor, IGM. Similar accounts of turtl… Look up ODI 11481092 at NHTSA ↗	717.9% ODI 11536197 On May 18, 2023, the vehicle was not driveable and it was not able to be taken out of the park mode. The vehicle had no power so the engine would not start regardless of what the tow truck driver tried. The car had to be pulled onto the tow truck so the tires did not move. On June 10, 2023, Due to a backlog. The Volvo dealership was finally able to look at the vehicle. They stated "error codes in the computer indicate an internal defect in the high-voltage battery. Even after consultation with Volvo technical support, we cannot avoid removin… Look up ODI 11536197 at NHTSA ↗	1747.2% ODI 11557619 All of the electronics are malfunctioning, no navigation, possible airbag and seatbelt malfunction, warning lights on. I am concerned that all of the electronic safety systems are not working properly. Internal SOS button not working. Herb Chambers Volvo in Norwood, Ma. Service manager has confirmed that this is a problem with the 2024 XC90. The car is brand new and Herb Chambers Volvo does not have any available appointments for several weeks to address concerns. I also contacted Volvo USA and they were unable to assist. I have also requested … Look up ODI 11557619 at NHTSA ↗	724.1% ODI 11637435 Remote start, infotainment system which controls everything, dashboard, lights, and cigarette lighter all intermittently turn off and on. Everyday, something else seems to stop working. My vehicle is 2.5 weeks old. This is apparently is a know latent defect that Volvo has chosen to keep from customers, based on feedback from VOLVO service, who are actually denying appointments stating that there is nothing they can do. Look up ODI 11637435 at NHTSA ↗
Engine	526.3% ODI 10515377 EVERY TIME I DO NOT TURN MY CAR ON FOR 2 OR MORE CONSECUTIVE DAYS MY CAR BATTERY DIES. THIS HAS HAPPENED TO ME 7 TIMES IN THE COURSE OF MY 2 YEAR LEASE. EACH TIME IT IS TOWED AND SENT TO VOLVO FOR SERVICE THEY REPORT THAT THEY HAVE SOLVED THE PROBLEM. ONE TIME THEY CLAIMED IT WAS MY BLUE TOOTH DRAINING THE BATTERY. THE NEXT TIME IT WAS SIRIUS RADIO DRAINING THE BATTERY. THE LOST GOES ON AND ON. CLEARLY THERE IS A PROBLEM WITH NO SOLUTION AS MY VAR BATTERY DIES EVERY TIME IT IS LEFT UNATTENDED. WITHOUT FAIL! *TR Look up ODI 10515377 at NHTSA ↗	00.0% No examples available for this selection.	218.2% ODI 10502462 · 12,000 mi I WAS DRIVING THE VEHICLE DOWN THE HIGHWAY WHEN IT STARTED TO STALL AND THEN THE ENGINE JUST CUT OFF. THIS HAPPENED IN THE MIDDLE OF THE ROAD WITH TRAFFIC IN BOTH DIRECTIONS LEAVING ME AND MY WIFE VULNERABLE IN THE MIDDLE OF TRAFFIC. I MADE SEVERAL ATTEMPTS TO RESTART THE ENGINE AND IT WOULD NOT START, IT STARTED TO SMOKE AFTER A FEW ATTEMPTS. ROADSIDE ASSISTANCE HAD TO BE CALLED AND THE VEHICLE WAS TOWED TO THE VOLVO SERVICE DEPARTMENT WHICH TOLD ME THAT THE ENGINE FAILURE WAS DUE TO A FAULTY STARTER. THIS IS A FAIRLY NEW VEHICLE WITH NO DAMAG… Look up ODI 10502462 at NHTSA ↗	125.0% ODI 11160701 · 5,200 mi PURCHASED 2014 XC 90, 5,200 MILES ON IT MARCH 2018. STEERING WHEEL VIBRATION ISSUE REPORTED BY ME 5/2018 .IT DOESN'T MATTER IF IT IS IN NEUTRAL,DRIVE,REVERSE WITH THE BRAKE DEPRESSED. WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT,IT VIBRATES. NOW FEELING MORE VIBRATIONS FROM ENGINE/STEERING WHEEL WHEN ACCELERATING. VOLVO USA/SWEDEN TECHS HAVE BEEN INVOLVED. IT IS NOW DEC. 2018. MOTOR/TRANSMISSION MOUNTS,STEERING WHEEL OSCILLATOR,POWER STEERING PUMP/PULLEY REPLACED,ENGINE TORQUE MOUNTS ADJUSTED.BEING TOLD THIS IS "CHARACTERISTIC" OF THIS ENGINE.… Look up ODI 11160701 at NHTSA ↗	0Unavailable No examples available for this selection.	8643.7% ODI 10807990 · 400 mi TL* THE CONTACT OWNS A 2016 VOLVO XC90. WHILE DRIVING AT APPROXIMATELY 70 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE STALLED. THE VEHICLE WAS NOT ABLE TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 400. Look up ODI 10807990 at NHTSA ↗	2430.4% ODI 10939201 · 800 mi TL* THE CONTACT OWNS A 2017 VOLVO XC90. THE CONTACT STATED THAT THE VEHICLE CAME EQUIPPED WITH A REMOTE START APPLICATION FOR THE CELLULAR TELEPHONE. THE TELEPHONE WOULD INDICATE THAT THE REMOTE START FAILED, YET THE VEHICLE'S ENGINE WOULD BE RUNNING WHEN THE GARAGE DOOR WAS OPENED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE APPLICATION DID NOT PERFORM A NUMBER OF TASKS PROVIDED BY THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE OCCURRED TWICE. THE APPROXIMATE F… Look up ODI 10939201 at NHTSA ↗	510.0% ODI 11152941 · 11,500 mi I PURCHASED MY 2018 VOLVO XC90 T6 AWD (HEREINAFTER, THE '2018 XC90' OR 'THE VEHICLE') IN OCTOBER 2017, THROUGH LEASE AGREEMENT. SHORTLY THEREAFTER, I NOTICED THAT THE FUEL EFFICIENCY OF THE VEHICLE WAS WELL BELOW THE EPA RATING AND WARRANTED RANGE, BASED ON REPRESENTATIONS BY THE DEALER AT, AND PRIOR TO, THE TIME OF SALE. I TOOK THE VEHICLE TO THE DEALER'S SERVICE DEPARTMENT, SO THE ISSUE COULD BE INVESTIGATED FURTHER. THE DEALER REPORTED THERE WAS A SOFTWARE UPDATE THAT ADDRESSED THE PROBLEM, AND THAT IT WOULD NO LONGER BE AN ISSUE. SUBSEQUENT… Look up ODI 11152941 at NHTSA ↗	1023.8% ODI 11189914 · 500 mi I PURCHASED MY NEW 2019 VOLVO XC90 ON DECEMBER 15, 2018. ON THE MORNING OF DECEMBER 29, 2018 I WAS WITH MY TWO CHILDREN WHEN THERE WAS A MALFUNCTION WITH THE VEHICLE KEY RECOGNITION SYSTEM WHICH ALLOWS FOR THE VEHICLE TO START. MY VEHICLE GAVE ME THE ERROR 'VEHICLE KEY NOT FOUND. SEE OWNER'S MANUAL'. THIS LEFT MYSELF, MY 4 YEAR OLD AND MY 4 MONTH OLD STRANDED. THE LOCAL FORT MYERS DEALER SAID THEY REPLACED THE FOB ANTENNA. MY VEHICLE THEN HAD THE SAME PROBLEM FEBRUARY 14, 2019 LEAVING MYSELF AND MY TWO CHILDREN STRANDED BECAUSE THE VEHICLE WOUL… Look up ODI 11189914 at NHTSA ↗	721.9% ODI 11432078 I was driving the speed limit on the highway in my Volvo 2020 XC90 which was less than one year old. The vehicle lost acceleration power and then an engine performance light came on, then a check engine light. I pulled over immediately and my car engine caught fire under the hood. The entire front of vehicle was engulfed in flames within minutes. There were approximately 11k miles on the car and it had never been maintenanced or worked on in any way that would have caused an engine fire. It was clearly a fuel line fire and Volvo did not properl… Look up ODI 11432078 at NHTSA ↗	821.6% ODI 11511411 Vehicle is lurching on slow acceleration in Hybrid Mode. For example, lurching occurs when pulling away from a stop sign, pulling out into traffic, pulling into a parking spot. Issue started beginning of January 2023. In February Fields Volvo Service diagnosed issue as a software problem (Code IEM-P287100) and that Volvo hasn't written the software yet. Fields Volvo Service said software update should be available in Quarter 2. Advised that I do not drive my car in Hybrid Mode. I own a hybrid vehicle that I have been told not to drive in Hybrid… Look up ODI 11511411 at NHTSA ↗	620.7% ODI 11481092 Propulsion Service Required message one week after we picked up our new car. Three weeks later----check engine light. Soon after another Propulsion Service Required. Each time, our dealership reset the computer. Three months into ownership, on I-84, traveling 75 mph in the far left lane: turtle mode light, loss of power, no propulsion, able to just get off the freeway on the left. Two hour wait for assistance on side of freeway in 98 degree heat. Dealership kept car for 40 days: replaced BDU, AC compressor, IGM. Similar accounts of turtl… Look up ODI 11481092 at NHTSA ↗	12.6% ODI 11592156 Check engine light comes on every few weeks. Dealer inspects, resets, and says software issues. Now engine performance lights and "turtle mode" has come on twice throttling my speed while driving. Again no known cause and just resetting. Currently in a loaner vehicle while they research. Look up ODI 11592156 at NHTSA ↗	411.1% ODI 11582432 We drove this vehicle to a family event in chicago. We pulled the vehicle out of the parking garage and pulled into a downtown street in front of a hotel to load the vehicle up. Once the family was loaded the vehicle up the car would not start it had 700 miles when it failed. we were stuck on a busy street trying to start the car. I called roadside assitance and someone came out with a jump pack, but the battery was not dead. I was in the pouring rain trying to figure out what was wrong. They did hook a computer up to find several faults… Look up ODI 11582432 at NHTSA ↗	13.4% ODI 11650504 · 2,300 mi The contact owns a 2025 Volvo XC90. The contact stated that while driving through a residential area at 35 MPH, the vehicle independently slowed down with the message "Engine Has Now Stopped" displayed on the instrument panel. The contact pulled over and turned off the vehicle. The contact stated that the vehicle initially failed to restart after the first attempt; however, the vehicle restarted after the second attempt and resumed normal operation after the failure. The manufacturer was notified of the failure and referred the contact to the d… Look up ODI 11650504 at NHTSA ↗
Power Train:Automatic Transmission	15.3% ODI 10425590 · 2,400 mi I FIRST EXPERIENCED THE DELAY IN RE-ACCELERATION ONE MORNING ON MY WAY TO WORK. AFTER COMING TO A COMPLETE STOP @ A STOP SIGN, I STEPPED ON THE GAS TO TAKE A TURN AND THE CAR HESITATED AT A VERY SLOW PACE TO TAKE OFF. I CHALKED IT UP AS THE CAR BEING COLD EARLY IN THE MORNING. IT CONTINUED TO HAPPEN PERIODICALLY UNTIL ONE DAY IT HAPPENED AS I WAS STOPPED AT A BUSY INTERSECTION WAITING TO TURN LEFT. WHEN THE INTERSECTION WAS CLEARED OF ONCOMING TRAFFIC FROM A REASONABLE DISTANCE I PRESSED THE GAS TO GO AND THE CAR LITERALLY DRAGGED IN SLOW MO… Look up ODI 10425590 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	12.4% ODI 11428347 · 50,000 mi The contact owns a 2019 VOLVO XC90. The contact stated that while her foot was on the brake pedal and while talking with a friend outside her vehicle, she had decided to place the vehicle into park. After approximately 8-10 minutes, the vehicle independently accelerated forward without warning and crashed into her friend's garage door. The air bags deployed immediately upon impact. An automatic safety feature on the vehicle detected the crash and automatically notified the police; a police report was filed. The contact sustained bruising to her… Look up ODI 11428347 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Unknown Or Other	15.3% ODI 11311027 THE BUILT-IN CHILD SAFETY SEAT IN THE MIDDLE CRACKED AFTER THE FIRST TIME I OPENED IT SO I CAN'T PUT IT BACK DOWN AND DON'T KNOW IF IT AFFECTS THE CHILD AIRBAG. I ASKED VOLVO ABOUT IT AND THEY TOLD ME IT WOULD BE $500 JUST TO SIMPLY LOOK AT IT BEFORE DECIDING WHETHER TO FIX IT OR IF COVERED BY THE WARRANTY. THIS ISN'T SAFE AND I NOW HAVE A CHILD SEAT I CAN'T USE AND A SEAT I CAN'T PUT DOWN. THIS ISN'T THE FIRST OF COMPLAINTS I HAVE SEEN ABOUT THIS AND AM WORRIED ABOUT THE SAFETY OF MY CHILDREN AKA SONS. MY VIN IS: [XXX] AND IT'S A 2011 VOLVO XC… Look up ODI 11311027 at NHTSA ↗	133.3% ODI 11316201 · 51,500 mi ON MORNING OF 2/15/2020, I WAS DRIVING MY XC90 (2012, BASE, AUTO TRANSMISSION) ON A CITY STREET WHEN I REALIZED THE STEERING WHEEL WAS NO LONGER IN CONTROL. IT CAUSED THE VEHICLE TO SWING LEFT AND RIGHT BETWEEN THE 2 LANES. I PRESSED HARD ON THE BRAKE TO SLOW DOWN -- THANK GOD THAT CARS BEHIND ME WERE ABLE TO AVOID ME. AFTER 10 SECONDS OR SO OF MANEUVERING, I MANAGED TO PULL OVER BY THE STREET. AN ORANGE TRIANGLE LIGHT CAME ON THE DASHBOARD, WITH A WARNING MESSAGE: "AUTO-SKID TEMPORARY OFF". I CALLED THE ROADSIDE ASSISTANCE TO TOW IT TO MY G… Look up ODI 11316201 at NHTSA ↗	19.1% ODI 10819490 · 28,000 mi THE ANTI SKID SERVICE IS NOT FUNCTIONING. THE WARNING LIGHT KEEPS COMING ON AND OFF PERIODICIALLY. Look up ODI 10819490 at NHTSA ↗	125.0% ODI 11160701 · 5,200 mi PURCHASED 2014 XC 90, 5,200 MILES ON IT MARCH 2018. STEERING WHEEL VIBRATION ISSUE REPORTED BY ME 5/2018 .IT DOESN'T MATTER IF IT IS IN NEUTRAL,DRIVE,REVERSE WITH THE BRAKE DEPRESSED. WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT,IT VIBRATES. NOW FEELING MORE VIBRATIONS FROM ENGINE/STEERING WHEEL WHEN ACCELERATING. VOLVO USA/SWEDEN TECHS HAVE BEEN INVOLVED. IT IS NOW DEC. 2018. MOTOR/TRANSMISSION MOUNTS,STEERING WHEEL OSCILLATOR,POWER STEERING PUMP/PULLEY REPLACED,ENGINE TORQUE MOUNTS ADJUSTED.BEING TOLD THIS IS "CHARACTERISTIC" OF THIS ENGINE.… Look up ODI 11160701 at NHTSA ↗	0Unavailable No examples available for this selection.	3618.3% ODI 10808864 · 4,000 mi CAR WAS HAVING ISSUES WITH SPEEDOMETER SCREEN AND CENTER CONSOLE SCREENS. SCREEN WOULD BLANK OUT WHEN NAVIGATION SYSTEM WAS IN USE AND VEHICLE WAS MOVING. THIS WOULD HAPPEN TWICE AND SYSTEM WOULD NORMALIZE. SEVERAL WEEKS AGO THIS HAPPENED AND MY HUSBAND AND I SMELLED A WEIRD ODOR AND THEN SMOKE BEGAN BELLOWING OUT CENTER CONSOLE. UNIT WAS TURNED OFF AND DEALER CONTACTED. VEHICLE WAS BROUGHT IN BUT AFTER THREE WEEKS STILL HAS ISSUES. WENT TO PICK UP CAR ON 12/5 ONLY TO FIND VEHICLE WAS HAVING ISSUE WITH RETAINING A FULLY CHARGED BATTERY. WE WE… Look up ODI 10808864 at NHTSA ↗	2329.1% ODI 11006164 · 9,000 mi I WAS USING THE PARALLEL PARK ASSIST AND THE CAR SLAMMED INTO THE CURB DAMAGING THE RIMS. THE DEALER INSISTS THAT THERE IS NO MALFUNCTION. THE CURB WAS OF THE PERFECT HEIGHT AND IT WAS A VERY SCARY SITUATION Look up ODI 11006164 at NHTSA ↗	918.0% ODI 11208577 · 19,400 mi SPONTANEOUS SUNROOF BREAKAGE Look up ODI 11208577 at NHTSA ↗	921.4% ODI 11566341 Air conditioning failed to function as soon as vehicle lease was up. Less than 45k miles on a 3 year old car. Stopped working, hot air blowing in the middle of summer no less. This does not appear to be a part that is on the maintenance interval list. This does not appear to be an isolated incident when researching this fault now over a year later.The climate control system failing on a new car on a part that cannot be reasonably serviced seems problematic to say the least. I asked the dealer to consider a good will repair on more than one occa… Look up ODI 11566341 at NHTSA ↗	618.8% ODI 11432078 I was driving the speed limit on the highway in my Volvo 2020 XC90 which was less than one year old. The vehicle lost acceleration power and then an engine performance light came on, then a check engine light. I pulled over immediately and my car engine caught fire under the hood. The entire front of vehicle was engulfed in flames within minutes. There were approximately 11k miles on the car and it had never been maintenanced or worked on in any way that would have caused an engine fire. It was clearly a fuel line fire and Volvo did not properl… Look up ODI 11432078 at NHTSA ↗	513.5% ODI 11532602 The infotainment system has locked up and has shut completely off while driving. When it shuts down (screen goes black) or glitches, the car actually loses power. Luckily it powered right back on but it was scary and could happen again and be much worse. The screen/ infotainment system has had this issue for awhile. We’ve even told Volvo of Tulsa about it when it was in for service but they said they couldn’t do anything about it because they couldn’t reproduce the issue. We have also had the brakes and rotors replaced twice at the dealershi… Look up ODI 11532602 at NHTSA ↗	517.2% ODI 11473422 Volvo's Blind Spot Information System (BLIS) lends itself to unsafe conditions. This is true for the many drivers who are used to driving cars that are smilarly equipped. For nearly 15 years I have been driving cars that were similarly equipped and when activating the turn signal in the direction where the system indicated another vehicle in the "blind spot" an audible warning sounded until the trun signal was extinguished or the danger passed. Volvo fails to provide the audible signal and thus, if there is a failed LED in the mirror, there … Look up ODI 11473422 at NHTSA ↗	717.9% ODI 11511753 1)Rear 2nd row seat Creaking noises. I visited the dealer 3 times, showed evidence with video clips what I recorded, but they couldn't find the cause. I thought that replacing the entire seat was the best way, but the work was finished by applying lubricant only, and this phenomenon continues even after that. The noise disappears when the seat is folded and unfolded as a trial, but it reappears after a few days, and there is no noise when the passenger sits in the seats. These cases are mentioned in swedespeed.com, a user's Internet forum, b… Look up ODI 11511753 at NHTSA ↗	822.2% ODI 11610344 Air conditioning is not working within one month of purchase. In 110 degree heat in Arizona , this is a safety issue. This has also occured on another new volvo xc90 in Austin , Texas. At least two failures on brand new volvo xc90. Look up ODI 11610344 at NHTSA ↗	517.2% ODI 11616288 Brand new vehicle emitting moderate amount of smoke from exhaust when stopping, idle, or when pulling out from stopped position (I.e. traffic light, stop sign). Notice exhaust smoke more when coming to stop on slight decline or accelerating from stopped position to incline roadway. Smoke is malodorous (burning metal/wire smell). No warning lights on vehicle dash. Inspected by Volvo dealership service team and unable to find source of smoking. Smoke odor causes headache in vehicle occupants if windows down when smoke present. Thankfully, no… Look up ODI 11616288 at NHTSA ↗
Fuel/Propulsion System	00.0% No examples available for this selection.	00.0% No examples available for this selection.	19.1% ODI 10938673 · 110,000 mi THE XC90 I JUST BOUGHT FROM A DEALER AS IS TWO DAYS AGO HAS SOME LEAKING OF FUEL. I SUSPECT SOMETHING IS WRONG WITH THE FUEL PUMP. THE PREVIOUS OWNER DID NOT BRING THE CAR TO VOLVO DEALER TO REPLACE THE FUEL PUMP UNDER THE EXTENDED WARRANTY. NOW I HAVE TO PAY THOUSAND DOLLARS TO REPAIR IT. Look up ODI 10938673 at NHTSA ↗	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	126.1% ODI 10885322 · 10,000 mi WHILE DRIVING BETWEEN CINCINNATI, OH AND NASHVILLE, TN, WE STOPPED IN CAROLLTON, KY TO REFUEL AT A LOCAL GAS STATION. UPON ATTEMPTING TO OPEN THE FUEL DOOR, THE DOOR WOULD NOT UNLOCK. THERE IS NO BUTTON OR SWITCH TO USE TO OPEN THE FUEL DOOR ON THIS VEHICLE. DESPITE SEVERAL ATTEMPTS TO TURN THE LOCK AND UNLOCK THE CAR, THE FUEL DOOR WOULD NOT OPEN. WE CONTACTED VOLVO ONCALL, WHO ADMITTED THIS WAS A KNOWN ISSUE BUT THEY DID NOT HAVE SOLUTION. THE ONLY OFFER FOR ASSISTANCE WAS TO USE THE KEY REMOTE TO LOCK AND UNLOCK THE CAR 3 TIMES IN AN AT… Look up ODI 10885322 at NHTSA ↗	56.3% ODI 11673211 ERAD (Electronic Rear Axle Drive) clutch failure. Upon depressing accelerator pedal, when in drive modes that rely more on ERAD (Hybrid/Pure modes), the clutch occasionally does not engage correctly, resulting in no power for a full 1-2 seconds, then power kicking in, in full. Not being consistent means not having a good way to anticipate when the problem will arise in order to compensate for it. The hazard came when attempting to cross traffic (to take a left into a commercial driveway), the delay happened, then before the ability to fully … Look up ODI 11673211 at NHTSA ↗	612.0% ODI 11152941 · 11,500 mi I PURCHASED MY 2018 VOLVO XC90 T6 AWD (HEREINAFTER, THE '2018 XC90' OR 'THE VEHICLE') IN OCTOBER 2017, THROUGH LEASE AGREEMENT. SHORTLY THEREAFTER, I NOTICED THAT THE FUEL EFFICIENCY OF THE VEHICLE WAS WELL BELOW THE EPA RATING AND WARRANTED RANGE, BASED ON REPRESENTATIONS BY THE DEALER AT, AND PRIOR TO, THE TIME OF SALE. I TOOK THE VEHICLE TO THE DEALER'S SERVICE DEPARTMENT, SO THE ISSUE COULD BE INVESTIGATED FURTHER. THE DEALER REPORTED THERE WAS A SOFTWARE UPDATE THAT ADDRESSED THE PROBLEM, AND THAT IT WOULD NO LONGER BE AN ISSUE. SUBSEQUENT… Look up ODI 11152941 at NHTSA ↗	12.4% ODI 11767107 Coming from a cold start in hybrid or pure mode the ERAD disengages causing the vehicle to slow down, hesitate and buck until the gas engine can engage to recover acceleration. Look up ODI 11767107 at NHTSA ↗	39.4% ODI 11432078 I was driving the speed limit on the highway in my Volvo 2020 XC90 which was less than one year old. The vehicle lost acceleration power and then an engine performance light came on, then a check engine light. I pulled over immediately and my car engine caught fire under the hood. The entire front of vehicle was engulfed in flames within minutes. There were approximately 11k miles on the car and it had never been maintenanced or worked on in any way that would have caused an engine fire. It was clearly a fuel line fire and Volvo did not properl… Look up ODI 11432078 at NHTSA ↗	513.5% ODI 11446230 With 2700 miles my XC90 has the Emission Control System light is on. The engine noise is considerably louder than normal (being a hybrid the SUV is pretty quiet) and it is not using the electric option. Look up ODI 11446230 at NHTSA ↗	931.0% ODI 11480246 On August 17th 2022 I received the reduced performance and acceleration reduced sign with an icon of a turtle. Besides getting this light on my dash my evening ended in fear and distress as I received a call from my family that the new car purchased was acting up and all that they were afraid for their life. This occurred to my spouse in the middle of driving home on the freeway (as she had our two kids in the backseat). She had to drive in a very low and dangerous speed on the highway and take the first exit possible as the car started acting … Look up ODI 11480246 at NHTSA ↗	512.8% ODI 11536197 On May 18, 2023, the vehicle was not driveable and it was not able to be taken out of the park mode. The vehicle had no power so the engine would not start regardless of what the tow truck driver tried. The car had to be pulled onto the tow truck so the tires did not move. On June 10, 2023, Due to a backlog. The Volvo dealership was finally able to look at the vehicle. They stated "error codes in the computer indicate an internal defect in the high-voltage battery. Even after consultation with Volvo technical support, we cannot avoid removin… Look up ODI 11536197 at NHTSA ↗	12.8% ODI 11691492 Safety Complaint – Volvo XC90 Electrical and Airbag Malfunction Issues I am reporting ongoing safety concerns with my Volvo XC90 related to electrical malfunctions and unexpected engine shutdowns while driving. The vehicle has suddenly turned off multiple times, including: •Once before merging onto a highway, •Once while entering a roundabout, and •Once while driving in traffic. Each incident occurred without warning and created a hazardous situation with the potential for a collision. Additionally, the vehicle displayed an airbag malfuncti… Look up ODI 11691492 at NHTSA ↗	00.0% No examples available for this selection.
Power Train	210.5% ODI 10428725 · 1,500 mi SHORTLY AFTER WE PURCHASED OUR 2011 VOLVO XC90 BRAND NEW WE HAVE EXPERIENCED A LAGS IN ACCELERATION. WHEN ACCELERATING THE CAR WOULD ROLL VERY SLOWLY UNLESS THE ACCELERATOR PEDAL WAS COMPLETELY FLOORED. WE WAITED UNTIL OUR ROUTINE OIL CHANGE WAS DUE TO HAVE IT CHECKED OUT, AND WE WERE TOLD BY THE DEALER THAT THEY COULD NOT RECREATE THE CIRCUMSTANCE. THEY TOLD US THEY WOULD UPDATE THE CAR'S COMPUTER WHICH SEEMED TO WORK BRIEFLY, BUT SHORTLY AFTER THE LAGGING BEGAN AGAIN. IT EVENTUALLY BECAME MORE AND MORE COMMON AND NOW IT IS HAPPENING MANY TIME… Look up ODI 10428725 at NHTSA ↗	133.3% ODI 10913682 · 75,000 mi THERE APPEARS TO BE AN INTERMITENT DEFECT WITH THE TRANSMISSION WHEN THE VEHICLE GETS WET. WHEN WET THE VEHICLE LOCK UP AND NOT EASILY GO INTO FORWARD OR REVERSE. THIS OCCASIONALLY OCCURS AFTER GOING THROUGH A CAR WASH OR WHEN THE VEHICLE IS DRIVEN IN WET WEATHER AND THEN, PARKED. AFTER A FEW HOURS, WHEN IT IS ATTEMPTED TO PUT THE VEHICLE IN GEAR, THE TRANSMISSION IS LOCKED UP AND THE VEHICLE WON'T MOVE. ONLY BY ROCKING THE VEHICLE DOES THE TRANSMISSION LOOSEN UP AND THE VEHICLE GOES INTO REVERSE. THE PARKING BRAKE IS NOT ENGAGED. THIS ISSUE IS… Look up ODI 10913682 at NHTSA ↗	00.0% No examples available for this selection.	125.0% ODI 11160701 · 5,200 mi PURCHASED 2014 XC 90, 5,200 MILES ON IT MARCH 2018. STEERING WHEEL VIBRATION ISSUE REPORTED BY ME 5/2018 .IT DOESN'T MATTER IF IT IS IN NEUTRAL,DRIVE,REVERSE WITH THE BRAKE DEPRESSED. WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT,IT VIBRATES. NOW FEELING MORE VIBRATIONS FROM ENGINE/STEERING WHEEL WHEN ACCELERATING. VOLVO USA/SWEDEN TECHS HAVE BEEN INVOLVED. IT IS NOW DEC. 2018. MOTOR/TRANSMISSION MOUNTS,STEERING WHEEL OSCILLATOR,POWER STEERING PUMP/PULLEY REPLACED,ENGINE TORQUE MOUNTS ADJUSTED.BEING TOLD THIS IS "CHARACTERISTIC" OF THIS ENGINE.… Look up ODI 11160701 at NHTSA ↗	0Unavailable No examples available for this selection.	105.1% ODI 10876773 · 5,000 mi AROUND 10.30 AM ON SUNDAY, 26TH JUNE 2016, I WAS DRIVING ON I-95 (NEAR STAMFORD CT) WITH MY FAMILY WHEN THE CAR SUDDENLY LOST POWER, SLOWED DOWN DRAMATICALLY IN THE MIDDLE OF I-95 AND STARTED TO CRAWL AT 10 MILES/HOUR. WE WERE IN DANGER OF BEING HIT BY A NUMBER OF VEHICLES WHILE I NEGOTIATED TO EXIT THE HIGHWAY ON EXIT 9 AND PULLED OVER INTO A SIDE STREET. THE INSTRUMENTATION PANEL OF THE CAR HAD BLANKED OUT. THE CAR COULD ONLY CRAWL AT ABOUT 10 MILES/HOUR. IT WOULD NOT SHIFT TO HIGHER GEAR EVEN IN MANUAL MODE. I CALLED THE VOLVO ON CALL AND TH… Look up ODI 10876773 at NHTSA ↗	56.3% ODI 11140502 · 7,766 mi ON 2018-09-17, THE VEHICLE, A 2017 VOLVO XC90 T8 HYBRID, REPORTED AN ERROR STATING "REDUCED PERFORMANCE" WITHIN THE INSTRUMENT GAUGE. THE VEHICLE CONTINUED TO DRIVE, WITHOUT THE HYBRID SYSTEM, ONLY WORKING ON THE GAS ENGINE. THE VEHICLE WAS DRIVEN APPROXIMATELY 3 MILES AFTER THE ERROR MESSAGE APPEARED. THE NEXT DAY, 2018-09-18, THE VEHICLE WAS STARTED, WITH THE SAME ERROR. AFTER DRIVING LESS THAN A QUARTER OF A MILE, THE VEHICLE ABRUPTLY HALTED IN THE MIDDLE OF AN INTERSECTION, AND THEN LIMITED THE VEHICLE SPEED TO 17 MILES PER HOUR. THE VEH… Look up ODI 11140502 at NHTSA ↗	510.0% ODI 11161200 · 2,800 mi SOMETIMES WHEN THE START STOP SYSTEM IS ACTIVATED AT A STOP AND YOU START BACK OFF THE VEHICLE ACCELERATES FORWARD WITHOUT DEPRESSING THE ACCELERATOR. ON 3 OCCASIONS IT CAUSED ME TO ALMOST RUN INTO THINGS. I REPORTED IT TO VOLVO AND THEY SAID THE SYSTEM IS FINE. Look up ODI 11161200 at NHTSA ↗	24.8% ODI 11704235 Upon driving a symbol with a turtle and engine cation sign flashed upon the dash displaying and reading reduced power train mode as this is being shown on dash the passenger next to me smelt smoke as we next seen smoke coming from the air conditioning system we immediately pulled over to the safest spot out of the ongoing traffic as smoke continued to worsen now under the hood when flames engulfed the engine and spread to rest of car. Look up ODI 11704235 at NHTSA ↗	39.4% ODI 11511040 The vehicle shudders randomly when taking off from a stopped position around 18mph. The vehicle shudders randomly when slowing down to make a right turn. The vehicle shudders when driving at higher speeds. It's not a violent shudder, but those riding in the vehicle feel it as well. The safety concern is two fold in that there is a fear of losing control at an inopportune time. Secondly, the constant shuddering over time is going to result in damaging other part of the vehicle, particularly the engine, that will present a safety hazard wh… Look up ODI 11511040 at NHTSA ↗	38.1% ODI 11440067 Check engine light illuminated at 11,000 miles. Diagnostics showed a software update was needed but the software update did not fix the problem. Volvo corporate said the IEM module needed to be replaced. The IEM module controls the rear axle / propulsion and this is a serious safety issue because sudden loss of propulsion while driving at high speeds increases risk of having an accident. After replacing the IEM module, the mechanic cleared the DTC codes, test drove the car, and re-ran the DTC - and the code indicating a software update was stil… Look up ODI 11440067 at NHTSA ↗	13.4% ODI 11578997 I was going 60 mph when the check engine light came on , the car started to jerk and reduce speed. I pulled onto the shoulder until the car stopped. I than proceeded to drive slowly and the turtle appeared on the dash. I drove about another mile until I reached my home doing 30 miles per hour or less. Look up ODI 11578997 at NHTSA ↗	37.7% ODI 11515127 · 1,000 mi The contact owns a 2023 Volvo XC90. The contact stated that before exiting the vehicle, he pressed the park button and the vehicle inadvertently started to reverse. The vehicle was taken to a dealer where the vehicle was diagnosed but no cause for the failure was found. The contact stated that the gear shifter and parking brake failed to engage as needed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 1,000. Look up ODI 11515127 at NHTSA ↗	513.9% ODI 11564688 Park fails to engage when pressing the P button adjacent to the shifter. It will, however, engage 100% of the time when applying additional pressure. The button doesn’t actually travel any further when applying the additional pressure, but park will engage. It’s even possible to push the button down fully, hold it for several seconds, and then apply additional pressure to cause it to engage. The tactile response of the button occurs too soon before activation. Look up ODI 11564688 at NHTSA ↗	00.0% No examples available for this selection.
Service Brakes	210.5% ODI 10472427 · 5 mi FROM THE BEGINNING THIS VEHICLE HAS DELAYED ACCELERATION, VERY DANGEROUS TO DRIVE WHEN PULLING OUT IN FRONT OF ON-COMING TRAFFIC, OR MAKING LEFT HAND TURN WITH ON-COMING TRAFFIC. BRAKES MAKE LOUD CRACKING POPPING SOUND WHEN BRAKING AND TURNING THE WHEEL, DO NOT FEEL SAFE WITH IT MAKING SUCH AWFUL SOUNDS. *TR Look up ODI 10472427 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	125.0% ODI 11592028 Brake Vacuum Booster: P/Q BRAKE BOOSTER. P/Q BRAKE FLUID $3271.36 Other]: P/Q ENGINE VACUUM PUMP SEAL KIT Front Suspension vibration and while vibration Look up ODI 11592028 at NHTSA ↗	0Unavailable No examples available for this selection.	147.1% ODI 10778004 · 1,200 mi TL* THE CONTACT OWNS A 2016 VOLVO XC90. WHILE DRIVING APPROXIMATELY 50 MPH, THE BRAKES INDEPENDENTLY ENGAGED WITHOUT WARNING AND SLOWED THE VEHICLE DOWN TO APPROXIMATELY 5 MPH. THE CITY SAFETY WARNING INDICATOR ILLUMINATED AFTER THE BRAKES INDEPENDENTLY ENGAGED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,200. ...UPDATED 12/03/15 BF UPDATED 4/9/18 JB Look up ODI 10778004 at NHTSA ↗	78.9% ODI 11010933 · 500 mi ON 7 DIFFERENT OCCASIONS, THE VEHICLE AUTOMATICALLY AND AGGRESSIVELY BRAKED ON ITS OWN. THE COLLISION AVOIDANCE SYSTEM SENSED THAT I WAS ABOUT TO GET INTO AN ACCIDENT EVEN THOUGH THERE WAS ABSOLUTELY NOTHING IN FRONT OF ME. THE COLLISION AVOIDANCE SYSTEM IS DEFECTIVE ON THIS MODEL. IT WAS A MIRACLE THAT I DIDN'T GET REAR ENDED AS THE 7 INSTANCES ALL HAPPENED ON HIGHWAYS. MANY OTHER PEOPLE HAVE HAD THE SAME PROBLEM. VOLVO HAS AGREED TO REPURCHASE MY VEHICLE. THIS IS A MAJOR SAFETY PROBLEM THAT NEEDS TO BE FIXED BEFORE SOMEONE GETS KILLED. Look up ODI 11010933 at NHTSA ↗	1122.0% ODI 11056836 · 3,400 mi BRAKES CONTINOUSLY SQUEAK. THE DEALER HAS INSPECTED THE BREAK SYSTEM TWICE AND MADE ONE ATTEMPTED REPAIR. ONE WEEK LATER THE BRAKES ARE BACKING TO SQUEAKING. I HAVE OWNED THE VEHICLE LESS THAN 90 DAYS, I'VE HAD ISSUES WITH THE BRAKES FOR MORE THAN HALF THAT TIME. THE CENTER DISPLAY COMPUTER SCREENS FREEZES CONSTANTLY, BUT RECENTLY FREEZES AND WILL NOT RESTART UNTIL AFTER THE CAR IS STOPPED AND RESTARTED. Look up ODI 11056836 at NHTSA ↗	49.5% ODI 11439155 The front rotors on my truck had to be changed twice already. The truck has 25k miles on it. The dealer warrantied them both times but they keep putting in the same kind of rotors. After a few month of driving with the new rotors the steering starts to shake when brakes are applied. The front brake pads also wear out pretty quickly. With only 25k miles they told me I needed new ones. I have invoices if needed to prove the rotors have been changed twice Look up ODI 11439155 at NHTSA ↗	412.5% ODI 11322553 · 4,500 mi ON FEBRUARY 5, 2020 I WAS INVOLVED IN A MINOR FENDER BENDER WHICH RESULTED WHEN I DROVE OFF ALIGHT AND THE CAR IN FRONT OF ME DID NOT TAKE OFF AND I HIT IT IN THE REAR AT A VERY LOW RATE OF SPEED. THE AUTO BRAKE DID NOT ENGAGE. I WAS NO MORE THAN ONE AND A HALF CAR LENGTHS BEHIND AND THE CAR WAS MOVING AT ONE TO TWO MILES PER HOUR. WHEN I HIT THE REAR OF THE CAR IN FRONT OF ME THE AIR BAGS DEPLOYED WHICH CAUSED ME TO HAVE A SLIGHT CONCUSSION AND CERTAINLY SCARED ME. THERE WAS LITTLE IF NO PHYSICAL DAMAGE TO THE VEHICLE. I CONTACTED VOLVO C… Look up ODI 11322553 at NHTSA ↗	718.9% ODI 11389044 · 2,000 mi ELECTRIC PARKING BRAKE ENGAGING VIOLENTLY AT HIGHWAY SPEEDS AT LEAST. 3 TIMES. RESULTING IN ABRUPT STOP IN MOVEING TRAFFIC! DEALER IN NO HURRY TO REPAIR SUGGESTING BRING BACK WHEN THEY ARE ABLE! AM NOTIFYING VOLVO, DEALER , THEY WILL ASSUME ALL LIABILITY FOR INJURY OR DEATH FOR THIS DEFECT AND LACK OF CONCERN IN REPAIRING ( TOLD A SOFTWARE PROBLEM , BUT ALSO TOLD CAUSED DAMAGE TO OTHER COMPONENTS DUE TO VIOLENT AND ABRUPT STOPS! VERY UNCOMFORTABLE ESPECIALLY SINCE REPAIR MGR IS SO ARROGANT! Look up ODI 11389044 at NHTSA ↗	13.4% ODI 11556577 During cold weather, and when backing up, the vehicle makes a loud knocking noise as if an accident has occurred. This is an intermittent problem. The vehicle is equipped with Auto-hold brakes. The dealership stated that this might be the issue where the auto-hold is engaging without warring. The dealership tested the brakes and stated that it was operating per manufacturing specs. This issue happened several times so far since 2022. It is a scary moment when feeling as if I had hit some one or some thing. Look up ODI 11556577 at NHTSA ↗	410.3% ODI 11615593 WHEN PUTTING THE VEHICLE INTO REVERSE, THE BRAKE PEDAL AUTOMATICALLY HAD TENSION, THEREFORE, I WAS UNABLE TO PRESS DOWN ON THE BREAK AS NORMAL. WITH LITTLE FORGIVENESS, I ATTEMPTED TO REVERSE AND ROLL BACK IN A SMALL PARKING LOT OF A LOCAL SCHOOL. AS I WAS ATTEMPTING TO ROLL BACK, THE CAR MADE A LOUD NOISE WHEN I WOULD TRY TO ENGAGE THE BREAK. Look up ODI 11615593 at NHTSA ↗	38.3% ODI 11553522 While parking my vehicle in the garage, I pressed the P (park) button on my center console and proceeded to exit my vehicle. As I was exiting, the car began to roll backwards. I was knocked to the ground by the open driver’s door, unable to reenter the vehicle. The vehicle began rolling causing me injury to my legs, elbow and feet because I was essentially trapped under the side of the vehicle as it was moving. The vehicle continued to roll. Hitting items on my garage, including my second vehicle parked in the driveway, before coming to a stop … Look up ODI 11553522 at NHTSA ↗	413.8% ODI 11643056 Complete brake failure. Vehicle would no slow at all. Brake failure warning on dash. Now multitude of warnings. Look up ODI 11643056 at NHTSA ↗
Exterior Lighting	15.3% ODI 11452346 Electrical, Brake lights suddenly stopped working on both sides at once. I checked the fuse only to be told a relay may be the issue. The location of said relay is vague and not serviceable by owner. Risk of rear end collision. Of following traffic Look up ODI 11452346 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.	0Unavailable No examples available for this selection.	21.0% ODI 10894039 · 4,000 mi I UPDATED THE MAPS IN THE CAR'S NAVIGATION SYSTEM ON 8/3/2016. AT THAT TIME, VOLVO'S SERVER IN SWEDEN WERE DOWN. THEY HAD BEEN DOWN FOR DAYS. NEXT MORNING, WHEN I STARTED DRIVING TO WORK, I NOTICED THAT THE SENSUS SYSTEM STARTED REBOOTING EVERY COUPLE OF MINUTES. AS I DROVE ON THE HIGHWAY, I NOTICED THAT WHEN THE SENSUS SYSTEM REBOOTED, IF MY LEFT TURN SIGNAL WAS ON, IT WOULD GO OFF FOR A COUPLE OF SECONDS AND THEN COME BACK ON. IF THE SENSUS SYSTEM WAS REBOOTING AND I TRIED TO TURN ON THE LEFT TURN SIGNAL, IT WOULD NOT COME ON. THIS IS A SAFET… Look up ODI 10894039 at NHTSA ↗	11.3% ODI 11725903 The vehicle experienced a major electrical system malfunction involving multiple critical components. The issue began with the Volvo On Call system light remaining illuminated continuously, which suggested a possible communication or battery-related fault. Shortly after, additional systems failed, including the turn signal system, windshield wipers, and high beam headlights. These components are currently non-functional and can be made available for inspection upon request. The failure significantly impacted vehicle safety. The loss of turn si… Look up ODI 11725903 at NHTSA ↗	12.0% ODI 11183474 · 20,000 mi ERROR MESSAGE SHOWED ON THE INSTRUMENT PANEL, ' HEADLAMP SYSTEM MALFUNCTION, SERVICE REQUIRED', HOWEVER THE LIGHT WORKS BUT BACKUP CAMERA STOP WORKING. IT ALSO SHOWS ANOTHER ERROR MESSAGE 'CITY SAFETY SYSTEM UNAVAILABLE'. ASK THE DEALER AND THEY SAID IT IS AN SOFTWARE ISSUE. FIXED AFTER THE SOFTWARE UPGRADE. Look up ODI 11183474 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	12.7% ODI 11742208 I am submitting this complaint regarding serious safety concerns with my Volvo vehicle that may affect the safety of my family, especially young children. 1. Second-Row Center Seat Integrated Booster Seat Belt Failure The integrated booster seat belt in the second-row center seat is not functioning properly. The seat belt mechanism appears defective and does not secure the child as intended. This presents a significant safety risk. In the event of sudden braking or an emergency stop, a child could be thrown forward due to the seat belt’s fai… Look up ODI 11742208 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	12.8% ODI 11635810 Instrument cluster failure and turn signal malfunction while highway driving. No interior sounds, including no lane change warning or near collision warning signals, and no audible confirmation of signal; no exterior blinker activated despite use by driver. Instrument cluster went blank. Safety at risk and accident occurred: approaching car from rear passenger side hit front right side of our car because there was no exterior signal and no audio or visual alerts in our vehicle about lane change or blind spot. Signal and instrument cluster failu… Look up ODI 11635810 at NHTSA ↗	00.0% No examples available for this selection.

Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.

Failure mileage by component

Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.

Component failure mileage distribution
Component	Mileage range (25th–75th percentile)	Median	Usable records	Examples
Electrical System	42,100–111,440 mi	80,000 mi	293	ODI 10045003 · 12,000 mi PROBLEMS WITH VEHICLE'S TRANSMISSION, SEAT BELTS DO NOT LATCH, DRIVER'S SEAT RECLINES BY ITSELF. MR THE RADIO WENT OUT AND THE ENGINE MADE A GRINDING NOISE SCC JB Look up ODI 10045003 at NHTSA ↗ ODI 10097221 · 15,000 mi MULTIPLE FAILURES; DOOR LOCK,TIRES WERE WORN TO THE CORD. BF THE LUG NUTS WERE REPLACED BECAUSE THEY WERE RUSTED WHEN THE VEHICLE WAS DELIVERED, THE DOORS DID NOT FIT PROPERLY, THE RADIO FAILED, THE KEY WOULD NOT TURN IN THE IGNITION, THE LEFT REAR DOOR COULD NOT BE OPENED DUE TO THE PROBLEM WITH THE SEAT MOLDING AND THE TIRE DISPLAYED UNUSUAL WEAR AND WERE WORN SMOOTH TO THE CORD. THE LUG NUTS THAT WERE INSTALLED RUSTED AGAIN. (TIRES/PERRILLI SCORPIAN) SC JB Look up ODI 10097221 at NHTSA ↗ ODI 10329409 · 71,000 mi 2003 VOLVO XC90 BEGAN DISPLAYING "SRS SERVICE URGENT" MESSAGE, TOOK VEHICLE TO DEALER WHO KNEW RIGHT AWAY WHAT PROBLEM WAS, THEY CLEANED THE CONTACTS OF THE INSTRUMENT CLUSTER (MAYBE THE CENTRAL ELECTRONIC MODULE)(CEM) AND ERROR WAS REMOVED. 3 WEEKS LATER SAME ERROR RETURNS. SOUNDS LIKE A DEFECT TO ME, ACCORDING TO VOLVO FORUMS ON WEB MANY VOLVOS HAVING SAME ISSUE. SOUNDS DEFECTIVE TO ME. *TR Look up ODI 10329409 at NHTSA ↗
Engine	19,000–115,000 mi	86,000 mi	116	ODI 10760442 · 114,687 mi WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YEAR LATER THE VEHICLE WAS PLACED IN THE SHOP FOR THE TURBO'S HAD GONE OUT ON THE VEHICLE ON APRIL 11, 2015 UNTIL CURRENT DATE. THEY ARE NOW SAYING THE VEHICLE HAS A BLOWN HEAD GASKET AND IT IS… Look up ODI 10760442 at NHTSA ↗ ODI 10810354 · 230,000 mi DRIVING THE XC90 AND SUDDENLY THERE IS A HUGE THUMP AND CLICKING FROM THE DASHBOARD. ALL THE DIALS AROUND THE SPEDOMETER STOP WORKING.. IF WE KEEP DRIVING THERE ARE MORE THUMPS AND WE QUICKLY LOSE ENGINE POWER - IT IS EXTREMELY SCARY WHEN IT HAPPENS.. ALL THE LIGHTS COME ON (INSIDE THE CAR), DASHBOARD GOES DEAD ETC ETC. IT IS EXTREMELY DANGEROUS .. IT HAPPENED TO USE A NUMBER OF TIMES WITH 3 CHILDREN IN THE CAR. IT HAS OCCURRED WHEN WE WERE DRIVING ON THE HIGHWAY, 2-3 TIMES, IT HAS OCCURRED ON SHORT TRIPS - IT HAPPENS AT SEEMINGLY RANDOM TI… Look up ODI 10810354 at NHTSA ↗ ODI 10462528 · 101,000 mi TL* THE CONTACT OWNS A 2004 VOLVO XC90 T6. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD LOSE POWER AND STALL. THE LIGHTS ON THE INSTRUMENTAL PANEL ILLUMINATED AFTER THE FAILURE OCCURRED. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE CONTACT WAS ABLE TO COAST THE VEHICLE ONTO THE SHOULDER. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND THE CURRENT MILEAGE WAS 101,000. Look up ODI 10462528 at NHTSA ↗
Power Train:Automatic Transmission	58,000–92,000 mi	71,000 mi	177	ODI 10041548 · 12,600 mi WE BOUGHT A 2003 VOLVO XC 90 IN JANUARY 2003, THE VEHICLE IS LESS THAN A YEAR OLD AND HAS ABOUT 12,600 MILES. IN THE LAST SIX WEEKS, WE HAVE HAD FOUR SYSTEM PROBLEMS, BRAKES, CRUISE CONTROL, AC/ DEFROSTER AND MOST RECENTLY AUTOMATIC TRANSMISSION. I BELIEVE THAT THE TRANSMISSION IS THE MOST SERIOUS PROBLEM SINCE IT FAILED TO OPERATE WHILE MY WIFE WAS DRIVING ON THE HIGHWAY.THE DEALER REPAIRED THE VEHICLE STATING THAT A CORRUPT SOFTWARE WAS THE CAUSE. VOLVO USA STATED THAT THE "NEW " SOFTWARE WAS A MODIFICATION/UPGRADE WHICH IS BEING PUT IN THE 2… Look up ODI 10041548 at NHTSA ↗ ODI 10045003 · 12,000 mi PROBLEMS WITH VEHICLE'S TRANSMISSION, SEAT BELTS DO NOT LATCH, DRIVER'S SEAT RECLINES BY ITSELF. MR THE RADIO WENT OUT AND THE ENGINE MADE A GRINDING NOISE SCC *JB Look up ODI 10045003 at NHTSA ↗ ODI 10049611 · 9,000 mi FOR BOTH OUR 2001 VOLVO S60 2.4T AND OUR 2003 VOLVO XC90 2.5T AWD THERE HAVE BEEN UNSUCCESSFUL ATTEMPTS TO REPAIR A TRANSMISSION DEFECT (ESSENTIALLY SAME TRANSMISSION IN BOTH VEHICLES PER VOLVO TECH SUPPORT). BETWEEN 2ND AND 3RD THERE IS INTERMITTENT/UNPREDICTABLE FAILURE TO ENGAGE 3RD IN TIMELY FASHION WITH RESULTANT LOSS OF ACCELERATION AS VEHICLE IS FUNCTIONALLY IN NEUTRAL WITH ENGINE RACING FOR ~0.5-2.5 SECONDS. THIS CAN BE EXTREMELY DANGEROUS ESPECIALLY WHEN PULLING ON TO A HIGHWAY. WE HAVE EXPERIENCED 2 NEAR COLLISIONS (ALMOST BEING … Look up ODI 10049611 at NHTSA ↗
Unknown Or Other	18,000–114,687 mi	54,414 mi	49	ODI 10412040 · 150,000 mi 2003 VOLVO XC90 ENGINE CUT OFF SUDDENLY WHILE DRIVING ~70MPH ON THE HIGHWAY. WAS LUCKY I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD WITHOUT BEING HIT OR STALLED IN THE MIDDLE OF THE ROADWAY. DEALER UNABLE TO DIAGNOSE THE PROBLEM. I BELIEVE THIS COULD HAVE POTENTIALLY CAUSED A FATAL ACCIDENT CONSIDERING THE SPEEDS AT WHICH OTHER CARS WERE TRAVELLING AND THE POTENTIAL TO BE STRANDED IN THE ROAD. CAR HAS BEEN SERVICED REGULARLY. *TT Look up ODI 10412040 at NHTSA ↗ ODI 10760442 · 114,687 mi WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YEAR LATER THE VEHICLE WAS PLACED IN THE SHOP FOR THE TURBO'S HAD GONE OUT ON THE VEHICLE ON APRIL 11, 2015 UNTIL CURRENT DATE. THEY ARE NOW SAYING THE VEHICLE HAS A BLOWN HEAD GASKET AND IT IS… Look up ODI 10760442 at NHTSA ↗ ODI 10269896 · 112,709 mi 1. SINCE DAY 1, THE TRANSMISSION ON MY 2004 VOLVO-XC90 HAS ALWAYS GIVEN ME TROUBLE, IT DOESN'T ENGAGE TROUGH GEAR AS QUICKLY AS IT SHOULD. ON MAY 25TH 2009, THE TRANSMISSION COMPLETELY WENT OUT LEAVING ME IN THE MIDDLE OF THE INTERSECTION WITH CARS BEHIND ME TRAVELING 35 MILES AND ALMOST CAUSED AN ACCIDENT. 2. THE TRANSMISSION HAS NEVER OPERATED PROPERLY SINCE I PURCHASED THE CAR IN APRIL OF 2009. THE SHOP AND EVERY OTHER ONE I CALLED KNEW EXACTLY WHAT THE PROBLEM WAS. THEY SAID THAT THE TRANSMISSION IN THIS MODEL AND YEAR WAS A FAULTY … Look up ODI 10269896 at NHTSA ↗
Fuel/Propulsion System	99,500–147,500 mi	126,000 mi	55	ODI 10694911 · 141,000 mi TL* THE CONTACT OWNS A 2003 VOLVO XC90. THE CONTACT STATED THAT FUEL FUMES EMITTED IN AND AROUND THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THERE WAS A LEAK IN THE FUEL PUMP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THE VIN WAS NOT ASSOCIATED WITH NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 141,000. Look up ODI 10694911 at NHTSA ↗ ODI 10715762 · 111,000 mi TL* THE CONTACT OWNS A 2003 VOLVO XC90. WHILE DRIVING AT APPROXIMATELY 55 MPH, FUEL FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS ALL OVER THE EXHAUST PIPE AND THE BOTTOM OF THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS CRACK AND LEAKING FUEL. THE VEHICLE WAS NOT REPAIRED. THE VIN NUMBER WAS NOT INCLUDED IN NHTSA CAMPAIGN: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 111… Look up ODI 10715762 at NHTSA ↗ ODI 10493730 · 200,000 mi TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING, A FUEL ODOR WAS EMITTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT FUEL WAS LEAKING FROM THE FUEL TANK. THE CONTACT WAS TOLD THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP). THE FAILURE AND CURRENT MILEAGES WERE 200,000. Look up ODI 10493730 at NHTSA ↗
Power Train	62,750–125,000 mi	96,942 mi	84	ODI 10234959 · 54,000 mi VOLVO XC90 TAKEN INTO DEALERSHIP FOR AXLE REPLACEMENT ON 07/09/08 CONTACTED THAT THE TRANSMISSION WILL BE REPLACED THEN WHEN QUESTION GIVEN VAGUE STATEMENT NO WILL BE A TRANSMISSION FLUSH. CAR RETURNED ON 07/16/08 ADVISED GIVEN NEW TRANSMISSION. DRIVING CAR ON 07/19/08 COME TO A STOP TO CROSS 4 LANE PARKWAY WHEN HIT GAS PEDAL CAR DOES NOT RESPOND RECEIVE MESSAGE REDUCE ENGINE PERFORMANCE. AFTER MUCH RESEARCH THIS IS A KNOWN PROBLEM WITH THE VOLVO TRANSMISSION IN THIS MODEL MANUFACTURER REFUSES TO ACKNOWLEDGE. TR Look up ODI 10234959 at NHTSA ↗ ODI 10352913 · 85,000 mi LEAVING A PARKING LOT AND HEARD LOUD SOUND CAR WOULDN'T MOVE. VOLVO SAYS THE FOLLOWING IS BROKEN: LOWER CONTROL ARM, CV AXLE, ROTOR AND DAMAGED RIM. WE HAD BEEN PARKED AND WERE ATTEMPTING TO LEAVING PARKING LOT(.BARELY MOVING) COULD HAVE BEEN KILLED IF THIS HAPPENED AT HIGHER SPEED. WE HAVE CONSTANTLY SPENT MONEY ON THIS VEHICLE AND I FEEL IT IS UNSAFE AND THAT WHEN THE RECALLS WERE MADE THERE COULD HAVE ALREADY BEEN A FRACTURE. THIS CAR IS ONLY DRIVEN TO WORK AND HOME ON A REGULAR BASIS. NO ROUGH ROADS. WE HAVE NOT CAUSED ANY DAMAGE. THIS WEB… Look up ODI 10352913 at NHTSA ↗ ODI 10470810 · 500 mi TL THE CONTACT OWNS A 2003 VOLVO XC90. THE CONTACT STATED THAT THE VEHICLE WOULD JERK ABNORMALLY AND WITHOUT WARNING. IN ADDITION, THE SHIFT GEAR LEVER WAS DEFECTIVE AND BOTH THE POWER STEERING FLUID AND TRANSMISSION FLUIDS WERE LEAKING. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THE VEHICLE AGE HAD EXCEEDED THE TIME FRAME IN WHICH THEY WERE WILLING TO OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY AND OFFERED NO ADDITIONAL ASSISTANC… Look up ODI 10470810 at NHTSA ↗
Service Brakes	2,585–99,895 mi	23,000 mi	39	ODI 10478919 · 104,789 mi MY WIFE AND I WERE DRIVING TO A FRIEND'S HOW'S WHEN SUDDENLY THE RADIO STARTED ACTING UP ,IT WOULD GO ON AND OFF . AFTER WE NOTICED THAT I SLOWED DOWN A BIT THEN ALL OF A SUDDEN MY HOLE DASH BOARD WENT OUT . I TRIED PULLING OVER BUT THE TRANSMISSION WOULD NOT RESPOND ,THEN THE DASHBOARD CAME BACK ON BUT I HAD ALL THESE WARNINGS LIKE BRAKE FAILURE ,SRS AIRBAG SERVICE URGENT , ENGINE SYSTEM SERVICE URGENT . AFTER ALL THE HAPPENS THE TRUCK DIED ,LUCKILY I WAS ABLE TO GET OFF THE ROAD BEFORE OTHER CARS HIT US .AFTER A COUPLE A MINUTES I TRIED TURN… Look up ODI 10478919 at NHTSA ↗ ODI 10500856 · 110,156 mi TODAY, WE LEARNED OUR VOLVO XC90'S YAW RATE SENSOR HAS FAILED. THE ROOT CAUSE WAS WATER LEAKING INTO THE PASSENGER SIDE OF THE CAR DUE TO BLOCKED MOONROOF (I.E. SUNROOF) DRAINS, WHICH SHORTED THE YAW RATE SENSOR. THIS IMPAIRED THE ELECTRONIC STABILITY CONTROL AND BRAKES OF OUR VOLVO, PUTTING US AT RISK OF ACCIDENT. RESEARCH SHOWS THIS IS A FREQUENT AND RECURRING PROBLEM KNOWN SINCE AT LEAST 2004. IT HAS CAUSED THOUSANDS OF DOLLARS IN DAMAGE TO NUMEROUS XC90S. VOLVO IS AWARE OF THIS ISSUE UP TO AND INCLUDING THE PRESIDENT OF VOLVO USA. EV… Look up ODI 10500856 at NHTSA ↗ ODI 10503681 · 167,000 mi DRIVING APPROXIMATELY 55-60 MPH WHEN HAVING TO MAKE A QUICK BRAKING STOP THE BRAKE PEDAL WAS HARD AND THE BRAKES EVENTUALLY STOPPED THE VEHICLE BUT, SEEMED TO BE WITHOUT ASSISTANCE FROM ABS. ALSO, AFTER THE VEH IS IN CRUISE CONTROL AND STEPPING ON THE BRAKE TO TAKE OUT OF CRUISE THE PEDAL IS HARD. *TR Look up ODI 10503681 at NHTSA ↗
Exterior Lighting	65,500–120,000 mi	99,900 mi	59	ODI 10293742 · 79,300 mi OPERATING VEHICLE SINCE OCT '08, SINCE THAT TIME THERE HAS BEEN A NOISE EMANATING FROM FRONT PASS-SIDE WHEEL AREA. PURCHASING DEALER(HALL CHEVY, CHESAPEAKE, VA) PERFORMED WHEEL-ALIGNMENT TO "FIX" THE NOISE WHICH DID NOT REMEDY. VOLVO DEALER IN ARVADA, CO DIAGNOSED IT AS FAILED, OR FAILING WHEEL HUB, TO BE REPLACED AT COST OF $500. THIS VEHICLE ALSO HAD TRANS FAILURE AT APPX 76K MILES, AND THROTTLE CONTROL MODULE FAILURE IN OCT '09. I BELIEVE THERE ARE MANY CONCERNS ABOUT OPERATING AND HAVING CONFIDENCE IN ITS ABILITY TO OPERATE "SAFELY AND… Look up ODI 10293742 at NHTSA ↗ ODI 10205276 · 9,750 mi UNSAFE FRONT SUSPENSION REPAIRED 4 TIMES BY VOLVO INVOLVING DISTRICT FACTORY TECHNICAL SUPERVISOR AND TECHNICIANS ON 3 OF FOUR OCCASIONS AND THE VEHICLE STILL HAS SERIOUS SAFETY AND HANDLING CONCERNS - NO ONE IN THE FAMILY WILL DRIVE THE CAR. IT HAS ALSO HAD SERIOUS PERFORMANCE RELATED SAFETY ISSUES REGARDING VEHICLE ELECTRONICS VIRTUALLY SHUTTING THE VEHICLE DOWN IN THE MIDDLE OF AN INTERSTATE. ANTI SKID PROBLEMS ON MULTIPLE OCCASIONS. DRIVERS SEAT BELT ANCHOR WAS IMPROPERLY ATTACHED AND WOULD NOT HAVE HELD IN AN ACCIDENT. THE STEERING WHEEL … Look up ODI 10205276 at NHTSA ↗ ODI 10241888 · 60,000 mi WHILE DRIVING MY 2004 VOLVO XC-90 AT NIGHT I EXPERIENCED A MOMENTARY LOSS OF CONTROL, FOLLOWED BY THE HEADLIGHTS PAUSING AND THEN GOING FROM HIGH BEAMS TO LOW. THE INSTRUMENT CLUSTER LOST SOME OF IT'S DISPLAYS AND THE DOOR LOCKS BECAME INOPERATIVE. THE DATA DISPLAY WARNED ME OF AN "URGENT SRS FAILURE". I WAS AT LOW SPEED A BLOCK FROM HOME SO I CREPT HOME AND THE NEXT DAY SENT THE CAR TO TRIAD VOLVO BY ROLL-BACK WRECKER. PROBLEM WAS FAILURE OF CENTRAL ELECTRONIC MODULE. I CALLED VOLVO CORPORATE AND THEY SEEMED DISINTERESTED. *TR Look up ODI 10241888 at NHTSA ↗

Complaint and recall timeline

Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.

ComponentPeriod

Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.

Monthly counts, recall campaigns and complaint examples

Monthly complaint and recall timeline
Month	Complaints	Campaigns announced	Examples
2024-10	3	None	ODI 11622921 Door handle for drivers side door breaks off into hand. Exiting vehicle made extremely complicated: if window is compromised in any way or lock system is compromised in any way, exit of vehicle is impossible. Look up ODI 11622921 at NHTSA ↗ ODI 11621462 · 49,800 mi The contact owns a 2019 Volvo XC90. The contact stated while reversing out of a parking space, the contact depressed the brake pedal; however, the vehicle failed to stop. The contact pumped the brake pedal and then depressed the brake pedal to the floor for the vehicle to come to a stop. There were no warning lights illuminated. The vehicle was towed to be diagnosed and it was determined that the brake master cylinder and the brake booster had failed internally, causing a vacuum leak. The contact was informed that the brake master cylinder and … Look up ODI 11621462 at NHTSA ↗ ODI 11621625 The chrome trim started peeling on the center console, near cup holders. This revealed a razor sharp edge on which I cut my finger. All of the exterior door handles have chrome trim and are peeling. Last week my [XXX] daughter cut her finger as a result of a sharp peeled chrome edge. Many reports of this on volvo forums. Some dealers will repair for free, others want to charge for this defective, safety hazard. My service provider said they could not fix for free and wanted $3800 for the repair. This is a known issue and a safety hazard that… Look up ODI 11621625 at NHTSA ↗
2024-11	3	None	ODI 11626848 Unsure of what the issue is with the vehicle but smells like gas in my garage and I found a recall I was never notified about I moved from Washington to Las Vegas and never received any info regarding the fuel pump recall as well as a noise that’s been going on for a year now when I drive at 60 miles an hour I’ve had it looked at and no one seems to know what that issue is Look up ODI 11626848 at NHTSA ↗ ODI 11626185 The instrument cluster display on my 2020 Volvo XC90 went completely out while driving my vehicle. This was a single point of failure and SAFETY ISSUE as it affected my speedometer, gas gauge, etc. I was driving without any functioning indicators on the highway when it went out. There was no advanced warning. The issue was fixed by my dealership and part replaced, invoice is attached. We have made multiple attempts to resolve this issue with Volvo Corporate, who has been non-responsive to the overall safety concern. Based on research Ford … Look up ODI 11626185 at NHTSA ↗ ODI 11625105 The automatic reverse braking feature is far too sensitive and causes headache-inducing, jarring, sudden extreme braking without any warning. It’s so aggressive that I believed I actually struck something each time. There’s no way to release the locked brakes unless you put it in park and then in drive. Extreme safety concern! This occurs when backing into or out of the garage using the mirrors, backing up to a 6 inch parking curb, or any bushes/brush that is near the bumper. It is wildly inaccurate and is not useful for people who actually use… Look up ODI 11625105 at NHTSA ↗
2024-12	9	None	ODI 11628794 The rear doors get stuck closed. No unlocking or releasing child lock solves this issue. Had the passenger rear door unavailable for over 6 months and then it opened again only for the other side to quit working now. Volvo does not cover this issue despite clear danger to riders in accident or emergency in need to exit vehicle. Look up ODI 11628794 at NHTSA ↗ ODI 11629994 I have a 2016 XC90 T6 Inscription. The issue started after refill the engine oil and led to malfunction in engine system. The engine list the power and slowed down the car while driving. I brought the car to the dealer 2 times already and had been fine for 3 months. However, the engine oil light showed up to refill after 3 months. I am aware that other Volvo owners are facing the same issue and it is due to defect of piston and piston ring. Look up ODI 11629994 at NHTSA ↗ ODI 11632722 · 80,000 mi The contact owns a 2016 Volvo XC90. The contact stated that water was entering the vehicle through the sunroof. There was an abnormal odor of mold inside the vehicle. The carpet was not wet. There was an abnormal swishing sound detected inside the vehicle. After it rained, the contact noticed that the passenger side front floorboard had an accumulation of water a quarter inch deep. The contact noticed the water was leaking on the airbag from the exterior A-pillar. The contact moved the headliner, and the rubber boot was intact. The call/SOS war… Look up ODI 11632722 at NHTSA ↗
2025-01	9	None	ODI 11639662 · 1 mi The contact owned a 2016 Volvo XC90. The contact stated that while her daughter was driving at an unknown speed, white smoke began to emit from the vehicle as fellow motorists alerted her daughter that a fire had started underneath the vehicle. The contact's daughter immediately pulled over as all occupants exited the vehicle. The contact called the authorities as the vehicle was quickly incinerated by the fire. The contact stated that her youngest grandson suffered emotional distress as a result of the fire. No physical injuries were reported … Look up ODI 11639662 at NHTSA ↗ ODI 11635297 · 65,000 mi The contact owns a 2019 Volvo XC90. The contact stated that after stopping and parking the vehicle, the vehicle failed to turn off. The contact's fiancée arrived on the scene and was able to turn off the vehicle; however, the vehicle later failed to restart, and the gear shifter seized. The message "Gear Lever Lock" was displayed. The vehicle was towed to an independent mechanic, who diagnosed that the panoramic sunroof seal strip had a gap, allowing debris and water into the vehicle, clogging the drain, and rendering the vehicle inoperable. Th… Look up ODI 11635297 at NHTSA ↗ ODI 11637504 Spontaneously the left back side door has failed to close on several occasions. It happened first while parked in the driveway and I had to use my body to get it shut. I went to have it checked out at the Volvo dealer and when I described it they told me several people had been in for service with the same issue. They told me one lady had it on 2 doors and another realized her door was open when it flung open mid-drive. They told me the car was just cold and that I needed to make sure the handle was flush with the door when trying to close it. … Look up ODI 11637504 at NHTSA ↗
2025-02	4	None	ODI 11640401 Loaded children into second row of vehicle, confirmed all doors closed. Began driving, passenger rear door swung open. Child DID NOT engage door handle. Pulled over to attempt to close door. Door latch would not engage, could not close or lock door. Still unable to close and lock door. Look up ODI 11640401 at NHTSA ↗ ODI 11640263 Remote start - when the vehicle is running by remote start using the Volvo app, it is not possible to directly fully start to the normal operating mode. If foot is placed on brake and the start/stop knob is turned, the display briefly shows the normal operating display and then reverts back to the limited display showing miles to empty and door status. If attempted again, the same occurs (1-2 seconds of normal display followed by limited display). The car cannot be driven until and unless the start/stop knob is turned without your foot on the b… Look up ODI 11640263 at NHTSA ↗ ODI 11643056 Complete brake failure. Vehicle would no slow at all. Brake failure warning on dash. Now multitude of warnings. Look up ODI 11643056 at NHTSA ↗
2025-03	10	25V179000	ODI 11647245 Instrument panel shuts down while driving on street. I believe it is the central electronic module that fails. It has happened numerous times and it is unsafe to drive without a speedometer, tachometer, odometer fuel gauge, and temperature gauge. It has now stopped altogether. Gauges just sit there and bounce Look up ODI 11647245 at NHTSA ↗ ODI 11646424 I was getting off the highway and made a left turn. As I was accelerating the motor gentle cut off.. (You wouldnt even notice if you wasnt driving) Full Traffic was behind me, so luckily I was able to get out of the way and pull to shoulder. It was the day before Christmas and car hasn't ran since. Upon investigation I found the CEM was effected. When the car died I was in left hand lane and I had to make my way to right, the shoulder. Yes the problem was diagnosed by myself. However I did investigation and researched using all data at li… Look up ODI 11646424 at NHTSA ↗ ODI 11648529 Vehicle is slightly off-balance no matter if I do an alignment ball joints seem to always get affected. I’m not sure if the hydraulics are working correctly. Yesterday I just started leaking antifreeze fluid. Look up ODI 11648529 at NHTSA ↗
2025-04	7	None	ODI 11654041 · 168,000 mi The contact owns a 2016 Volvo XC90. The contact stated that water had been leaking into the vehicle on rainy days. The contact stated that the water intrusion was causing several warning lights to illuminate and unknown vehicle safety equipment failures. The contact stated that the front and rear carpets and the spare tire were saturated with water. The contact had taken the vehicle to a local dealer, where it was determined that water was leaking into the vehicle, but the dealer was unable to determine the point of intrusion. The vehicle was n… Look up ODI 11654041 at NHTSA ↗ ODI 11654773 The first incidence occurred around [XXX]. I was traveling [XXX] on [XXX] in North Carolina about an hour north of Charlotte. I pulled into a rest area and, upon pressing the brake pedal, heard a bit of a hissing noise and suddenly the brake pedal was extremely hard and the car was very difficult to bring to a stop. I did an online search for what might be wrong and discovered it was likely a brake booster failure. I drove the car onto Charlotte, carefully and with extreme difficulty, and took it to the Swedish Connection, a local Volvo special… Look up ODI 11654773 at NHTSA ↗ ODI 11655417 The vehicle engine will fail while driving. The electronics reflect the vehicle is still running. Restarting is not immediate and is difficult. This is a known problem that Volvo recalled for 2019/2020 XC90s. Volvo will not diagnose and repair under goodwill despite my repeated attempts. Look up ODI 11655417 at NHTSA ↗
2025-05	10	25V282000	ODI 11663205 The back door, or liftgate, closes automatically (without me pressing the close button). This is inconsistent, as it doesn't happen all the time. Each time the car has been off, and maybe it's on some kind of timer. It's happened 3 times, at random, where each time it caught me off guard. One time it hit me on the back of the head. The next time my kids were sitting in the back and I had to yell for them to tuck their legs inside. The third time, was just last week, and I had to run out from under it. There is no beeping or warning, and I'm afr… Look up ODI 11663205 at NHTSA ↗ ODI 11658368 I am reporting multiple critical component failures on my 2017 Volvo XC90, which I believe represent potential design or manufacturing defects related to vehicle safety and reliability. At approximately 93,000 miles, my Volvo XC90 experienced a battery failure, thermostat failure, which did not resolve the vehicle's engine issues. Subsequently, the dealership diagnosed a failed Engine Control Module (ECM), requiring complete replacement at a cost of over $5,000. The ECM is a critical motherboard component responsible for engine control and veh… Look up ODI 11658368 at NHTSA ↗ ODI 11658873 The contact owns a 2017 Volvo XC90. The contact stated that while driving approximately 25 MPH, the low coolant level warning light was illuminated. The contact refilled the coolant reservoir; however, approximately one week later, the warning light was again illuminated. The vehicle was taken to the dealer who diagnosed that the small coolant hose was leaking. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was unknown. Look up ODI 11658873 at NHTSA ↗
2025-06	6	None	ODI 11668145 The contact owns a 2022 Volvo XC90. The contact received notification of NHTSA Campaign Number: 25V179000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. Look up ODI 11668145 at NHTSA ↗ ODI 11664155 Rear view camera sometimes does not display on the infotainment screen even though the car is in Reverse. The display message is “Camera is temporarily unavailable”. I have yet to receive a recall notice. This issues makes backing up very dangerous! Look up ODI 11664155 at NHTSA ↗ ODI 11664156 The Emergency Flashers on occasion and randomly malfunctions with the red triangle button flashing but the green arrows intermittently blink on the dash screen and the ticking sound also intermittently working. I have a video clip of the issue but can’t upload on this webpage. Look up ODI 11664156 at NHTSA ↗
2025-07	14	None	ODI 11677323 Piston ring failure, excessive oil consumption. There was an extended warranty regarding the issue, but it has since been closed. I know there have been multiple lawsuits regarding this issue. Look up ODI 11677323 at NHTSA ↗ ODI 11670512 I am reporting a safety defect related to the Vehicle Connectivity Module (VCM) in my 2017 Volvo XC90. The VCM is critical for emergency communications, including automatic crash notification and location sharing with emergency responders. This function is vital for occupant safety in the event of an accident. My VCM was serviced at an authorized Volvo dealer in Natick, MA in December 2024 due to intermittent connectivity issues. Despite this recent service, the VCM completely failed in mid-April 2025. When the module fails, the vehicle loses … Look up ODI 11670512 at NHTSA ↗ ODI 11673211 ERAD (Electronic Rear Axle Drive) clutch failure. Upon depressing accelerator pedal, when in drive modes that rely more on ERAD (Hybrid/Pure modes), the clutch occasionally does not engage correctly, resulting in no power for a full 1-2 seconds, then power kicking in, in full. Not being consistent means not having a good way to anticipate when the problem will arise in order to compensate for it. The hazard came when attempting to cross traffic (to take a left into a commercial driveway), the delay happened, then before the ability to fully … Look up ODI 11673211 at NHTSA ↗
2025-08	10	None	ODI 11680108 I am filing a safety complaint regarding a failed rear door latch actuator in my 2016 Volvo XC90. This is a known issue among Volvo owners, yet there appears to be no recall or corrective action. The defect causes the door latch actuator to seize, rendering the affected rear door completely inoperable from both the inside and outside. This means passengers seated in the rear are unable to open the door to exit the vehicle. This is an extremely dangerous and potentially life-threatening hazard. In the event of an emergency, such as a fire, coll… Look up ODI 11680108 at NHTSA ↗ ODI 11680248 This car is consuming oil and has the potential to catastrophically fail, or catch fire. Look up ODI 11680248 at NHTSA ↗ ODI 11682539 Backup camera not activating when in reverse sporadically. My recorded video of this happening: [XXX] Issue has been brought to the Volvo dealership service department. Remedy from the Volvo service has been to update software but it has not corrected the issue. Multiple of owners have encountered the same issue which is widely documented online. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Look up ODI 11682539 at NHTSA ↗
2025-09	12	None	ODI 11684873 The rear two car doors will not open. It started months ago with the left side and now is both doors. This is dangerous if anyone in the rear of the vehicle should need to exit in a timely manner. The dealership knows this is an issue, but says they are not obligated to fix it for free because there isn’t a recall yet. Look up ODI 11684873 at NHTSA ↗ ODI 11685940 Known supercharger leak on 2016 Volvo XC90 at 60,000 miles. Numerous reports of the same failure. Dealer and Volvo declined goodwill repair. Potential safety/fire issue if oil leakage worsens Look up ODI 11685940 at NHTSA ↗ ODI 11687093 The A/C evaporator core in my 2017 Volvo XC90 failed prematurely, cracking and leaking refrigerant. This is a well-known problem among XC90 owners from model years 2016–2020. Repair costs are USD$5k+ because the entire dashboard must be removed to replace the evaporator. This is not normal wear and tear. Volvo has issued multiple Technical Journals (e.g. TJ 35912.1.0 -- attached -- and later revisions) instructing dealers to install an additional resistor in the evaporator temperature sensor harness when replacing the evaporator. This proves V… Look up ODI 11687093 at NHTSA ↗
2025-10	6	None	ODI 11694587 On September 30, 2025, a 2016 Volvo XC90 T6 experienced sudden engine failure while driving westbound on I-75 (Alligator Alley) at highway speed. The vehicle abruptly went into reduced power mode (“turtle mode”) without warning. This forced the driver to stop on the roadside, creating a serious safety hazard in fast-moving traffic. Component/system that failed: Engine / Power Train. An independent repair facility performed diagnostics on October 6, 2025, including a compression test. Results confirmed that one cylinder had lost compression due… Look up ODI 11694587 at NHTSA ↗ ODI 11691437 My car completely locked up on the road and came to a screeching stop. This car is known for having the ERAD completely fail and it could have caused it to have a serious accident. It has also caused my car to plummet in value losing over 30k in just 3 years. Now my repairs cost nearly what it’s worth and aren’t guaranteed to actually fix it. It’s terrible. I’m so upside down n my loan due to this issue that they dealerships refuse to help on. The dealership acknowledges it is a design flaw but yet they won’t help. I have an email stating … Look up ODI 11691437 at NHTSA ↗ ODI 11696466 There is a flaw in Volvo sunroof drains. There are class action lawsuits because of this. 6 months after purchasing my car, there was a leak into my car due to a clogged sunroof drains causing damage to electronics and potentially to computers within the car. I fixed it at a quote of over $2k. Volvo refused to cover it under my warranty. Now, 6 months after the fix, the SAME issue is happening. Look up ODI 11696466 at NHTSA ↗
2025-11	11	None	ODI 11698131 Vehicle is a 2017 model year of the Volvo XC90 and has the same safety issue in the Quality Bulletin for Recall R29936: Coolant Bleeder Hose (Engine Side), which is for the same make and model but for the 2016 model year. The vehicle has a plastic coolant bleeder hose that can crack and create a coolant leak that drips above the catalytic converter. The coolant accumulates in the catalytic converter heat shield insulation and poses a fire risk in the engine compartment area. The leak can also be small enough to cause coolant to evaporate and o… Look up ODI 11698131 at NHTSA ↗ ODI 11699448 On November 5, 2025, while driving my 2017 Volvo XC90, I experienced a sudden and dangerous loss of braking assist. When I pressed the brake pedal, I heard a loud hissing noise coming from under the dashboard, and the car would not stop. The brake would not work and the vehicle would not slow or stop unless I stood up and used my full body weight to press it. A licensed mechanic inspected the vehicle and confirmed this is consistent with loss of vacuum pressure from the brake booster/failure of the vacuum brake booster, the component that pr… Look up ODI 11699448 at NHTSA ↗ ODI 11700036 As I was driving, the coolant low warning came on. Luckily I was able to pull over safely at a nearby gas station. I found that the coolant expansion tank was empty. The coolant was leaking from the plastic connector on the bleeder hose and was pooling on the top of the engine. There is a recall on 2016 vehicles for this (Volvo campaign R29936) and looks like many are having same issue on 2017 models also. My problem was exactly as described, the part broke, coolant squirts out all over hot engine parts, system coolant level rapidly depletes. … Look up ODI 11700036 at NHTSA ↗
2025-12	11	25V908000	ODI 11705066 · 150,000 mi The contact owned a 2017 Volvo XC90. The contact stated that after driving 35 miles at 70 MPH on I-95 South in South Carolina, the contact started smelling an abnormally gasoline odor inside the vehicle entering through the AC vents. There was no warning light illuminated. The contact and her husband continued driving, believing that the odor was coming from the outside because the air recirculation switch was set to recirculate the air inside the vehicle. The contact stated that after driving an additional 5 miles, the gasoline odor grew stron… Look up ODI 11705066 at NHTSA ↗ ODI 11704235 Upon driving a symbol with a turtle and engine cation sign flashed upon the dash displaying and reading reduced power train mode as this is being shown on dash the passenger next to me smelt smoke as we next seen smoke coming from the air conditioning system we immediately pulled over to the safest spot out of the ongoing traffic as smoke continued to worsen now under the hood when flames engulfed the engine and spread to rest of car. Look up ODI 11704235 at NHTSA ↗ ODI 11703455 The camera system when backing up becomes unavailable intermittently. Sometimes it works and sometimes it doesn’t. System has been updated and restarted but it fails to fix the issue. When it happens it states camera unavailable and service required. Shutting off the vehicle and restarting multiple times sometimes corrects it. Automotive dealer said there is no issue with it. We have pictures of when it happens and the vehicle is available for inspection. Look up ODI 11703455 at NHTSA ↗
2026-01	14	None	ODI 11712975 the engine is the part that failed due to excessive oil consumption. it became a safety risk once it started selecting its own driving speed after dropping driving speed to 31mph on [XXX in Raleigh. the problem was confirmed by the dealer, Volvo of Cary it has not been inspected by the manufacturer, police, insurance representatives or others *upon a service visit our technician, Ray Rancell of Volvo of Cary advised that the engine was leaking oil and engine failure would occur if we didn't take care of it so we did to a total of $2879.74 … Look up ODI 11712975 at NHTSA ↗ ODI 11713040 My vehicle was signaling me to add oil every 600 - 1000 miles around 85,000 miles. The dealership charged me for a chemical treatment to stop the oil burning around 90,000 miles. At about 95,000 miles, my engine failed while driving on the interstate. There was no warning light or degradation of power. Suddenly, the engine lost power, went into limp mode and I could not maintain highway speed. The display flashes "Engine Performance Reduced." My SUV is now parked in my yard. I have paid two Volvo dealerships and a Volvo repair shop to insp… Look up ODI 11713040 at NHTSA ↗ ODI 11712394 The rear door latch/lock actuators on my 2017 Volvo XC90 fail to latch in cold temperatures, making the vehicle undrivable and unsafe. The doors may appear closed but are not secure, creating a serious risk to the driver, passengers, and others on the road; I rely on this vehicle daily to transport my children. The issue has worsened over multiple winters, and on one occasion the doors remained frozen for about four hours, preventing safe travel to work and school. A local independent garage has confirmed this is a known issue affecting XC90 mo… Look up ODI 11712394 at NHTSA ↗
2026-02	13	None	ODI 11715108 While driving the vehicle under normal conditions, a sudden electrical fire occurred, requiring immediate evacuation. The vehicle was pulled over safely and the driver exited before the fire escalated. The fire department responded and the vehicle was declared a total loss due to fire damage. The failure is believed to have originated from an electrical short involving the climate control/defroster system. The affected wiring and components were destroyed by the fire and are not available for inspection. The day prior to the fire, the fuse cont… Look up ODI 11715108 at NHTSA ↗ ODI 11715435 All seatbelts in vehicle sticks and/or catches have to use seriously more pressure on release button,or seatbelt/latch it’s self or both. My wife and children have had me have to come get it because it wouldn’t release. Engine motor mount bolt had to be replaced, I noticed when alternator went out, vehicle wouldn’t respond from throttle acted like it was missing then threw dash lights then no lights all of a sudden it happened within 1-2mins vehicle wouldn’t respond while running stopped in middle of road. Didn’t give any warning was even going… Look up ODI 11715435 at NHTSA ↗ ODI 11716016 The catillatic converter exploded as we started the vehicle .was a very loud explosion..no fire but lots of smoke. Look up ODI 11716016 at NHTSA ↗
2026-03	17	None	ODI 11726307 Had to replace emission coil plugs.My mechanics said it has wiring issues Look up ODI 11726307 at NHTSA ↗ ODI 11725903 The vehicle experienced a major electrical system malfunction involving multiple critical components. The issue began with the Volvo On Call system light remaining illuminated continuously, which suggested a possible communication or battery-related fault. Shortly after, additional systems failed, including the turn signal system, windshield wipers, and high beam headlights. These components are currently non-functional and can be made available for inspection upon request. The failure significantly impacted vehicle safety. The loss of turn si… Look up ODI 11725903 at NHTSA ↗ ODI 11725921 The failure involves the instrument cluster (driver information display) on my 2017 Volvo XC90. This component is responsible for displaying speed, warning indicators, and all critical driving information. The failed component remains installed and is available for inspection. The issue began while driving on public roads. The display intermittently showed distorted, “barcode-like” patterns that would appear suddenly, disappear, and then return. The condition progressively worsened over time. The failure is now consistent and reproducible. … Look up ODI 11725921 at NHTSA ↗
2026-04	19	None	ODI 11731647 Hey I purchased a Volvo xc90 2016 seven months ago and I currently still have this car. Also others with the same model, are having problems with oil consumption who is the problem that I’m sadly dealing with, My car burns so much oil and I’m only 19 I got this hoping for a reliable car but in stead in burns oil just has much as I burn fuel every 500 miles, if that probably less miles. it tells me to had a liter of oil because it says I’m out of oil. I just need some one to help me it hasn’t had anything done to it it’s all original with only 1… Look up ODI 11731647 at NHTSA ↗ ODI 11732429 About a month ago I received an Engine Coolant Low warning from the vehicle so the fluid was topped off. This past Friday, April 17th as I was driving home around midnight, I received an Engine Temperature is High, please pull over notice so I stopped the vehicle and had it towed home. Saturday evening, as the car was sitting in my driveway, the vehicle caught fire. The entire engine bay ignited and basically melted. Look up ODI 11732429 at NHTSA ↗ ODI 11732842 Since moving here to Nevada in 2023, I’ve had several oil changes. After about 1200 I have to add mother oil to the car. I’ve gone back three times to 5 min oil change to get free refills since they offer free top offs after your initial oil change. I than took a deep dive on the internet and discovered that the Volvo XC90, 2016 had issues with oil consumption, but never informed me of this issue. I’ve been to the dealership several times and not once did the inform me either. I mentioned to Bailey Anderson at Findlay Volvo in Las Vegas that t… Look up ODI 11732842 at NHTSA ↗
2026-05	9	None	ODI 11737317 The eRAD (Electric Rear Axle Drive) on my 2016 Volvo XC90 T8 PHEV failed completely. The warning light appeared approximately 11/3/2025, within one week of purchasing the vehicle at 88,000 miles. The failure was confirmed by a Volvo dealership. The eRAD is the component that powers the rear electric motor and provides AWD and hybrid function , its failure results in complete loss of rear wheel drive and hybrid system operation. Safety risk includes unexpected loss of AWD traction control in adverse weather conditions. This is a known systemic d… Look up ODI 11737317 at NHTSA ↗ ODI 11736779 The suspension module failed due to water accumulation on floorboards. Suspect other electronics may be at risk. Water ingress cause by a combination of what dealer said was a worn out sunroof gasket and two of four drains that became plugged. Further examination from dealer found the plugged drains were crimped from when the vehicle was manufactured. The dealer blamed the excessive water ingress was further allowed by a failed sunroof seal. The vehicle has always been serviced by the dealer and problem areas like that were either not inspected… Look up ODI 11736779 at NHTSA ↗ ODI 11738272 The exterior paint on my 2019 Volvo XC90 has experienced significant premature peeling and delamination on the front bumper and surrounding body panels. This is not the result of collision, misuse, or environmental damage the vehicle has been properly maintained and garaged. The paint failure appears to be a factory defect related to improper adhesion, primer application, or a substandard clear coat process during manufacture. The affected components are available for inspection upon request. Safety concern: Peeling and delaminating paint can o… Look up ODI 11738272 at NHTSA ↗
2026-06	10	None	ODI 11746768 My 2016 Volvo XC90 suddenly lost power while I was driving, requiring me to pull over and have the vehicle towed. This is a documented safety issue associated with a known piston ring defect in 2013-2016 Volvo vehicles equipped with 2.0L and 2.5L engines, which was the subject of a federal class action lawsuit ([XXX] et al. v. Volvo Car USA, LLC, Case No. XXX, filed XXX. No there we NO warning lamps, messages or other symptoms of the problem prior to the failure. I purchased this vehicle as a second owner from Carvana [XXX] , one month after th… Look up ODI 11746768 at NHTSA ↗ ODI 11742110 · 85,000 mi The contact's daughter owns a 2017 Volvo XC90. The contact stated that while her son-in-law was driving at an undisclosed speed, the brake pedal was firmly depressed, but the vehicle failed to stop immediately. No warning light was illuminated. The vehicle was towed to the dealer, who determined that the vacuum hose had detached and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 85,000. Look up ODI 11742110 at NHTSA ↗ ODI 11744366 At approximately 6:30 PM, after normal driving and parking at a local park, our family was unloading children from the vehicle. One child was standing next to the vehicle while we removed a younger child from the rear seat. The child suddenly screamed and stated that he had burned himself. We later determined that he had accidentally come into contact with the exterior exhaust outlet. As we continued walking, we noticed the injury was more severe than initially believed. We took photographs of the burn and later sought medical evaluation. The … Look up ODI 11744366 at NHTSA ↗
2026-07	13	None	ODI 11749074 The AC evaporator has a leak. I am reporting as this is a well known issue on the Volvo's, especially the 2016 XC90 which has a large amount of issues that cause issues of safety and undue amount of financial burden on owners who operate the vehicle in normal conditions. I have been told by the dealer after they repaired a another issue of the engine (8 times this vehcile has been in for repair on engine issues that are due to a block issue) the ac evaporator is well known by Volvo to be poorly designed and manufatcurered where they last under… Look up ODI 11749074 at NHTSA ↗ ODI 11751100 Piston rings inside the engine failed due to a known oil consumption issue with this model vehicle. The engine failed while the car was driving 85 mph and consequently slowed down to 15mph on the highway, leaving the owner of the car stranded alone on the highway. Volvo has a known fix for this issue and there was a class action lawsuit for it, but since it was settled, there was no recall. This is, in fact, a dangerous issue that is preventable. Additionally, the sunroof drains also leak. Water frequently leaks down the A-pillar directly ont… Look up ODI 11751100 at NHTSA ↗ ODI 11749713 Spark plugs, fuel injectors, cylinders and cylinder walls, pistons, oxygen sensor. Our safety was put at risk because the vehicles "reduced performance" was triggered and it affected the acceleration of the vehicle. The Volvo dealership was able to reproduce the issue because of the engine misfires.The only alert we received was the day prior our engine needed a liter of oil. We topped off the oil and that alert went away. The day we had the reduced performance we were alerted of that at the time on the highway. It's a little turtle icon. We we… Look up ODI 11749713 at NHTSA ↗
2026-08	11	None	ODI 11757537 I discovered an engine coolant leak from a crack near the end of the Plastic Coolant Bypass Pipe (part #31368673/32382362) after noticing coolant puddling on my garage floor. There are numerous comments with pictures on-line about how common this part fails on this model Volvo. What's also interesting is that the "pipe" fails in exactly the same location (on top and near the end). Seems to me if this is a known defect and the part is not performing with reasonable reliability, Volvo should provide an allowance to car owners when the part fa… Look up ODI 11757537 at NHTSA ↗ ODI 11756005 · 94,000 mi The contact owns a 2017 Volvo XC90. The contact stated that while driving at an undisclosed speed, the window power switch was enabled; however, the window switch failed to function as intended. The contact stated that the rear-view camera, the door switch, and the air conditioner failed to function as intended. In addition, the contact became aware of water on the front passenger’s side floorboard. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unkn… Look up ODI 11756005 at NHTSA ↗ ODI 11757883 At first I was having issues with stop and start, replaced the battery then was told I wasted coffee in my center Console and it cause electrical issues and was told the repairs would be 3,400 in which collision issuance paid for. After the repairs my driver side seat belt would latch then the passenger side wouldn’t latch either so I currently don’t have working A/C or working seatbelts which is known problem for these vehicles. Look up ODI 11757883 at NHTSA ↗
2026-09 (partial)	15	None	ODI 11761290 2017 Volvo XC90 T8 plug-in hybrid, approximately 81,000 miles, experienced intermittent hesitation/loss of propulsion when accelerating. When acceleration is requested, the vehicle can hesitate before power is delivered, creating a serious safety concern when entering, merging into, or crossing traffic because expected acceleration is not immediately available. Diagnostic testing identified faults in the IEM/ERAD system, including P286D00, Clutch A Engagement Time Performance/Too Slow, and P0A1B62, Drive Motor A Control Module, Algorithm Based… Look up ODI 11761290 at NHTSA ↗ ODI 11765624 I was driving my 2017 Volvo XC90 T6 Inscription when a ‘coolant low’ warning appeared. I immediately pulled over and the car began to smoke. I was unaware what to do so I called my husband and he told me to pop my hood. With 1.5 minutes of pulling over I open my door to find the lack to pop the hood and someone started yelling at me to get out. I looked up and the smoke had changed from white to brown- I exited the vehicle and called 911- Within approximately 5 minutes, the vehicle became fully engulfed in flames and was a total loss. The vehic… Look up ODI 11765624 at NHTSA ↗ ODI 11766225 2017 Volvo XC90 manufacturing defect where panoramic sunroof drainage network fails under normal rain, pooling water directly in the floorboard channels over safety module networks and wire harnesses.Water infiltration caused a catastrophic short-circuit of the floorboard-mounted amplifier while driving. This forced the audio system to emit an un-modulated, maximum-volume electronic blast through the cabin, causing severe driver distraction and documented temporary acute acoustic trauma/ear injuries to myself and my young child.Progressive el… Look up ODI 11766225 at NHTSA ↗

Emerging complaint spikes

Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.

This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.

No complete months meet the spike thresholds for this selection.

Equal-age model-year comparison

Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.

Observation windowFirst model yearSecond model year

2022: 22 complaints · 2023: 35 complaints

Equal observation windows
Model year	Through age 0	Through age 1	Through age 2
2022	8	18	22
2023	9	16	35

Date coverage across each selected cohort

Date basis for all complaints in selected model years
Year	Incident dates used	Filing date fallbacks	Excluded dates
2022	29	0	0
2023	37	0	2

Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.

Components reported together

Each cell counts unique complaints naming both components. Open a nonzero cell for examples.

Component co-occurrence matrix
Component	Electrical System	Engine	Power Train:Automatic Transmission	Unknown Or Other	Fuel/Propulsion System	Power Train	Service Brakes	Exterior Lighting
Electrical System	—	69 ODI 10810354 · 230,000 mi DRIVING THE XC90 AND SUDDENLY THERE IS A HUGE THUMP AND CLICKING FROM THE DASHBOARD. ALL THE DIALS AROUND THE SPEDOMETER STOP WORKING.. IF WE KEEP DRIVING THERE ARE MORE THUMPS AND WE QUICKLY LOSE ENGINE POWER - IT IS EXTREMELY SCARY WHEN IT HAPPENS.. ALL THE LIGHTS COME ON (INSIDE THE CAR), DASHBOARD GOES DEAD ETC ETC. IT IS EXTREMELY DANGEROUS .. IT HAPPENED TO USE A NUMBER OF TIMES WITH 3 CHILDREN IN THE CAR. IT HAS OCCURRED WHEN WE WERE DRIVING ON THE HIGHWAY, 2-3 TIMES, IT HAS OCCURRED ON SHORT TRIPS - IT HAPPENS AT SEEMINGLY RANDOM TI… Look up ODI 10810354 at NHTSA ↗ ODI 10463571 · 109 mi DRIVING ON STREET AND ENGINE JUST DIED, NO REASON CAN THINK OF, NO ENGINE LIGHT OR MESSAGE IN TEXT. HAPPENED AGAIN 2-3 WEEKS (YESTERDAY) WHILE SLOWING DOWN FOR STREET ACCIDENT, LOST ALL POWER, HAD TO STOP CAR WITHOUT POWER STEERING OR BRAKES, PUT IN PARK AND STARTED AGAIN. NO PROBLEM AFTERWARDS AND DROVE HOME. TOOK TO VOLVO DEALER TODAY WHERE I REGULARLY GO AND OF COURSE NO REASON FOUND FOR TWO TIME FAILURE. LUCKILY NOT DRIVING ON FREEWAY OR MAY HAVE BEEN REAR-ENDED DUE TO ENGINE FAILURE. QUITE SCARED NOW TO DRIVE - WHEN IS IT GONNA HAPP… Look up ODI 10463571 at NHTSA ↗ ODI 10471266 · 111,000 mi ALL INTERIOR LIGHTS, GUAGES, WINDSHIELD WIPERS RANDOMLY SHUT DOWN AT FREEWAY SPEEDS AND AT IDLE. ENGINE POWER IS ALSO AFFECTED AS UNABLE TO ACCELERATE PROPERLY. DEALER REPLACED DRIVER INFORMATION MODULE HOWEVER PROBLEM CONTINUES. DEALER UNABLE TO SOURCE THE PROBLEM AS THE VEHICLE NEEDS TO BE IN THE PROCESS OF FAILING FOR THEM TO SOURCE THE PROBLEM. THIS HAS NOT BEEN POSSIBLE AS THE ISSUE IS RANDOM AND TYPICAL GOES AWAY AFTER THE CAR SITS FOR SEVERAL HOURS. THE SERVICE AIRBAG AND BRAKE FAILURE CODE REMAINS IN THE DRIVER INFORMATION MODULE. THIS … Look up ODI 10471266 at NHTSA ↗	6 ODI 10045003 · 12,000 mi PROBLEMS WITH VEHICLE'S TRANSMISSION, SEAT BELTS DO NOT LATCH, DRIVER'S SEAT RECLINES BY ITSELF. MR THE RADIO WENT OUT AND THE ENGINE MADE A GRINDING NOISE SCC *JB Look up ODI 10045003 at NHTSA ↗ ODI 10282656 · 65,000 mi 2004 VOLVO XC90 2.5L TRANSMISSION. COMPLETE FAILURE AT 65,000 MILES REQUIRING REPLACEMENT OF ENTIRE TRANSMISSION. FOUR DAYS AFTER REPAIR, VEHICLE HAS LOUD ENGINE THUMP AND CHECK ENGINE LIGHT COMES BACK ON. REPEATS THUMP WITH ENTIRE ELECTRICAL SYSTEM GOING OUT REQUIRING A 3.5 HOUR TOW HOME FROM 1/2 TO OUR VACATION DESTINATION. DEALER REPLACED ALTERNATOR. HAD FOR 2 DAYS AND CHECK ENGINE LIGHT COMES BACK ON AND THE THUMP/ELECTRICAL ISSUES START AGAIN. BARELY GOT TO DEALER WHO HAS HAD FOR A WEEK. THEY REPLACED ALTERNATOR AS PUT IN THE WRONG O… Look up ODI 10282656 at NHTSA ↗ ODI 10345228 · 75,000 mi AFTER DRIVING 125 MILES WITHOUT INCIDENT, WE LEFT OUR 2004 VOLVO XC 90 T6 AWD PARKED FOR 4 HOURS BEFORE DRIVING AGAIN. AFTER LESS THAN A HALF MILE AT LOW SPEED, THERE WAS A "THUMP" FROM THE FRONT OF THE CAR, THE WIPERS CYCLED, THE GAUGES ALL WENT BLANK, SOME OF THE WINDOWS STOPPED WORKING, THE A/C WENT OUT (BLOWER STAYED ON). THE CAR STAYED ON, BUT SEEMED "STUCK" IN SECOND GEAR AND THE BRAKES BECAME "SPONGY," BUT OPERABLE. TURN SIGNALS WERE INOPERABLE AND THE POWER STEERING WENT OUT. THE INDICATOR LIGHT ON THE GEAR SHIFT WENT OUT AND THE CE… Look up ODI 10345228 at NHTSA ↗	34 ODI 10345228 · 75,000 mi AFTER DRIVING 125 MILES WITHOUT INCIDENT, WE LEFT OUR 2004 VOLVO XC 90 T6 AWD PARKED FOR 4 HOURS BEFORE DRIVING AGAIN. AFTER LESS THAN A HALF MILE AT LOW SPEED, THERE WAS A "THUMP" FROM THE FRONT OF THE CAR, THE WIPERS CYCLED, THE GAUGES ALL WENT BLANK, SOME OF THE WINDOWS STOPPED WORKING, THE A/C WENT OUT (BLOWER STAYED ON). THE CAR STAYED ON, BUT SEEMED "STUCK" IN SECOND GEAR AND THE BRAKES BECAME "SPONGY," BUT OPERABLE. TURN SIGNALS WERE INOPERABLE AND THE POWER STEERING WENT OUT. THE INDICATOR LIGHT ON THE GEAR SHIFT WENT OUT AND THE CE… Look up ODI 10345228 at NHTSA ↗ ODI 10438941 · 135 mi WHILE DRIVING ON THE HIGHWAY AT NIGHT, ALL ELECTRICAL INDICATORS ON DASHBOARD INCLUDING THE TURN SIGNALS STOP WORKING THEN THE VEHICLE STARTED SLOWING DOWN. AFTER STOPPING I WAS UNABLE TO OPEN GAS TANK AND TAILGATE WHERE THE BATTERY IS LOCATED. I TOOK THE VEHICLE TO THE VOLVO DEALER AND THEY WERE UNABLE TO DUPLICATE THE INCIDENT. NOW THIS HAS HAPPEN 7 MORE TIMES. I AM A SINGLE PARENT WITH MINOR CHILDREN IN MY VEHICLE. PLEASE ASSIST. SOMEONE INFORM ME THE PROBLEM MIGHT BE WITH THE CENTRAL ELECTRICAL MODULE. I PURCHASE THIS VEHICLE USED AND IT IS… Look up ODI 10438941 at NHTSA ↗ ODI 10594009 · 95,000 mi WHILE DRIVING DOWN THE ROAD AROUND 50 MPH THE XC90 SKIPPED AND TEMPORARILY TURNED OFF ALL ELECTIONS. THOUGHT IT WAS A GLITCH SO CONTINUED DOWN THE ROAD MORE CAREFULLY. THEN IT HAPPENED AGAIN AND THE ELECTRONICS NEVER CAME BACK ON. I COULDN'T MAKE IT UP A SMALL HILL ON THE ROAD TO GET SAFELY HOME. MY TRANSMISSION WOULDN'T PULL. THE SPEED GAUGE AND RPMS WERE COMPLETELY UNWORKING. WINDOWS WOULD NOT ROLL DOWN AIR HAD WENT OUT. POWER STEERING TEMPORARILY WENT OUT. MADE IT HOME FINALLY AND NOTHING SEEMS WRONG NOW BUT THERE IS OBVIOUSLY A PROBLEM THAT… Look up ODI 10594009 at NHTSA ↗	23 ODI 10534670 MY XC90 VOLVO IS VERY DISAPPOINTING THE DASH BOARD ON THE CAR COMPLETELY FAILS NO NOTHING NO GAS, SPEEDOMETER EVERY THINGS GOES OUT. IN THE NIGHT TIME ITS VERY SCARY ITS COMPLETELY DARK I DON'T KNOW HOW FAST I'M GOING HOW MUCH GAS I HAVE ITS SCARY. NOW THE FUEL PUMP IS GONE AND THE NAVIGATION SYSTEM BURNED OUT I CUT THE CAR ON HEARD A POP THEN I SMELLED SOMETHING BURNING THE NAVIGATION SYSTEM HASN'T WORKED SINCE. TR Look up ODI 10534670 at NHTSA ↗ ODI 10713394 · 143,000 mi MY 2004 VOLVO XC90 WITH A 2.5T ENGINE, 7 PASS, INTERMITTENTLY AND INADVERTENTLY STALLS WHILE DRIVING IT. IT IS SCARY BECAUSE ALL ELECTRICAL GOES OFF, INSTRUMENT PANEL, RADIO, LIGHTS, ETC, SEVERAL WARNING MESSAGES APPEARS, SUCH ABS, AIR BAGS FAILURE, BRAKE FAILURE, ENGINE FAILURE, ETC. IT WON'T RESPOND TO ACCELERATION AND BRAKES ARE VERY HARD TO PUSH, THE ENGINE DOES NOT STOP. I HAVE TO STOP, TURN IT OFF, WAIT FEW MINUTES, THEN START IT, EVERYTHING COMES TO NORMAL AGAIN BUT WITH THE CHECK ENGINE AND THE AIR BAGS MESSAGE, THEN AFTER SOME MINUTES … Look up ODI 10713394 at NHTSA ↗ ODI 10716499 TL THE CONTACT OWNS A 2004 VOLVO XC90. WHILE IN PARK, THE CONTACT HEARD A NOISE. ALL THE WARNING LIGHTS ON THE INSTRUMENT PANEL FAILED TO ILLUMINATE AND THE VEHICLE STALLED. IN ADDITION, THE CONTACT STATED THAT THE ODOMETER DISPLAYED AN INCORRECT READING AND THERE WAS A FUEL ODOR IN THE VEHICLE. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TOWED B… Look up ODI 10716499 at NHTSA ↗	31 ODI 10478870 · 170,000 mi AT 65 MPH WIPERS WENT ON BY THEMSELVES THEN FOLLOWED BY SPLIT SECOND POWER FAILURE,MEANING DASHBOARD LIGHT OUT,HAZARD LIGHTS COULD NOT BE TURNED ON,WINDOWS WOULD NOT OPEN,A/C OUT,IN THE MESSAGE SCREEN AT THAT MOMENT ANTILOCK BRAKE FAILURE WAS DISPLAYED BEFORE EVERYTHING WENT OUT,DRIVING ANOTHER 20 MILES TILL NEXT EXIT AT THE DUSK,AFTER PULLING OVER AND RESTART ( TO RESET) SRS FAILURE IN THE MESSAGE SCREEN. CAR CHECKED BY VOLVO DEALER AND STATEMENT FROM THEM:FAULT IN CEM IS SHUTTING DOWN NETWORK AND CAUSING DIM TO BLACK OUT. REPLACEMENT WILL RUN… Look up ODI 10478870 at NHTSA ↗ ODI 10513661 · 974,300 mi AFTER SEVERAL HOURS OF DRIVING IN THE GEORGIA / NORTH CAROLINA MOUNTAINS WITH THE WIFE AND 2 KIDS IN THE BACK, THE AIR-CONDITIONER AND RADIO ON WITH THE 2004 XC90, THE CAR STARTED EXPERIENCING WEIRD BEHAVIOR. SHORTLY AFTER CROSSING THE GEORGIA BORDER INTO THE MOUNTAINS OF NORTH CAROLINA THERE WAS A LOUD NOISE UNDER THE HOOD OF THE CAR AND THE VEHICLE JERKED VIOLENTLY. THE CAR IMMEDIATELY LOST ALL ELECTRICAL POWER (NO DASHBOARD, HAZARD LIGHTS, BLINKERS, WINDOWS AND DOOR LOCKS, SUNROOF, ETC.). THE DRIVE TRAIN ALSO SEEMED STUCK IN A HIGH GEAR A… Look up ODI 10513661 at NHTSA ↗ ODI 10538331 · 106,530 mi WHILE DRIVING 70 MPH ON I-5 WE HEARD A LOUD THUMP IN THE ENGINE COMPARTMENT AND WE SUDDENLY WENT TO ABOUT 25 MPH ALL OF OUR ELECTRONIC SYSTEMS SHUT DOWN, THERE WAS AN EXTREMELY LOUD GRINDING SOUND FOR APPROX. 2-3 SECONDS. NOW I THINK MY TRANSMISSION IS DAMAGED AND THE ELECTRONICS SYSTEM SHUTS DOWN PRETTY FREQUENTLY. I AM TOTALLY DISAPPOINTED TO READ THAT THIS HAS HAPPENED TO NUMEROUS OTHER FAMILIES. THANK GOD NO ONE HAS DIED FROM THIS.....THIS IS VERY IRRESPONSIBLE AND NEGLIGENT FROM A REPUTABLE AUTO COMPANY. IS IT GOING TO TAKE SOMEONE OR FAMI… Look up ODI 10538331 at NHTSA ↗	20 ODI 10478919 · 104,789 mi MY WIFE AND I WERE DRIVING TO A FRIEND'S HOW'S WHEN SUDDENLY THE RADIO STARTED ACTING UP ,IT WOULD GO ON AND OFF . AFTER WE NOTICED THAT I SLOWED DOWN A BIT THEN ALL OF A SUDDEN MY HOLE DASH BOARD WENT OUT . I TRIED PULLING OVER BUT THE TRANSMISSION WOULD NOT RESPOND ,THEN THE DASHBOARD CAME BACK ON BUT I HAD ALL THESE WARNINGS LIKE BRAKE FAILURE ,SRS AIRBAG SERVICE URGENT , ENGINE SYSTEM SERVICE URGENT . AFTER ALL THE HAPPENS THE TRUCK DIED ,LUCKILY I WAS ABLE TO GET OFF THE ROAD BEFORE OTHER CARS HIT US .AFTER A COUPLE A MINUTES I TRIED TURN… Look up ODI 10478919 at NHTSA ↗ ODI 10500856 · 110,156 mi TODAY, WE LEARNED OUR VOLVO XC90'S YAW RATE SENSOR HAS FAILED. THE ROOT CAUSE WAS WATER LEAKING INTO THE PASSENGER SIDE OF THE CAR DUE TO BLOCKED MOONROOF (I.E. SUNROOF) DRAINS, WHICH SHORTED THE YAW RATE SENSOR. THIS IMPAIRED THE ELECTRONIC STABILITY CONTROL AND BRAKES OF OUR VOLVO, PUTTING US AT RISK OF ACCIDENT. RESEARCH SHOWS THIS IS A FREQUENT AND RECURRING PROBLEM KNOWN SINCE AT LEAST 2004. IT HAS CAUSED THOUSANDS OF DOLLARS IN DAMAGE TO NUMEROUS XC90S. VOLVO IS AWARE OF THIS ISSUE UP TO AND INCLUDING THE PRESIDENT OF VOLVO USA. EV… Look up ODI 10500856 at NHTSA ↗ ODI 10522327 · 78,244 mi WAS DRIVING IN NEIGHBORHOOD AT ABOUT 20 MPH, WHEN RADIO SHUT OFF AND THEN ALL ELECTRICAL SHUT OFF, CAR DID NOT RESPOND TO EITHER GAS OR BRAKES, THEN THERE WAS A THUMP FROM THE FRONT OF THE CAR, WHICH BROUGHT THE DASH LIGHTS BACK ON. I THEN WAS ABLE TO PULL OVER AND TURN OFF CAR. RESTARTED THE CAR AND THERE WERE A SLEW OF ERROR MESSAGES ON THE DASH, INCLUDING A BRAKE WARNING. ATTEMPTED TO CONTINUE TO DRIVE CAR, ISSUE HAPPENED AGAIN AND AGAIN ON MY DRIVE HOME. VERY UNSAFE TO BE DRIVING AND NOT SURE IF YOUR BRAKES OR STEERING ARE GOING TO CUT OUT.… Look up ODI 10522327 at NHTSA ↗	43 ODI 10241888 · 60,000 mi WHILE DRIVING MY 2004 VOLVO XC-90 AT NIGHT I EXPERIENCED A MOMENTARY LOSS OF CONTROL, FOLLOWED BY THE HEADLIGHTS PAUSING AND THEN GOING FROM HIGH BEAMS TO LOW. THE INSTRUMENT CLUSTER LOST SOME OF IT'S DISPLAYS AND THE DOOR LOCKS BECAME INOPERATIVE. THE DATA DISPLAY WARNED ME OF AN "URGENT SRS FAILURE". I WAS AT LOW SPEED A BLOCK FROM HOME SO I CREPT HOME AND THE NEXT DAY SENT THE CAR TO TRIAD VOLVO BY ROLL-BACK WRECKER. PROBLEM WAS FAILURE OF CENTRAL ELECTRONIC MODULE. I CALLED VOLVO CORPORATE AND THEY SEEMED DISINTERESTED. TR Look up ODI 10241888 at NHTSA ↗ ODI 10345921 · 104,365 mi ON OUR 2004 VOLVO XC90 THE HEADLIGHTS SUDDENLY WENT DARK, NO LOW OR HIGH BEAMS AT ALL. I AM NOW BEING TOLD IT IS A MODULE AND THE REPAIR COST IS IN EXCESS OF $1200. THE CAR HAS HID HEADLIGHTS. THIS OUTAGE CREATED A VERY SERIOUS SAFETY ISSUE IN THAT WE WERE DRIVING UP HIGHWAY 395 AT NIGHT WHEN THE COMPLETE FAILURE OF THE HEADLIGHTS OCCURRED. IN RESEARCHING THE ISSUE ON THE INTERNET IT APPEARS IT IS A RELATIVELY COMMON FAILURE. TR Look up ODI 10345921 at NHTSA ↗ ODI 10354896 · 169,200 mi MY HEADLIGHTS, DRIVING LIGHTS, PARK LIGHTS, AND TURN SIGNALS ARE NOT WORKING. THIS BEGAN WHEN I STARTED TO GO SOMEWHERE LAST NIGHT. ALL OF THESE THINGS WERE WORKING THE DAY BEFORE. THE TAIL LIGHTS, TURN SIGNALS, AND BRAKE LIGHTS ARE WORKING IN THE REAR. MY VEHICLE IS GARAGED WHEN IT IS NOT IN USE. MY RADIO, CD PLAYER, OR SATELLITE RADIO WOULD NOT OPERATE 2 DAYS AGO AND STARTED WORKING THE NEXT TIME I STARTED MY CAR. ABOUT 2 WEEKS AGO THE CAR WOULDN'T START. IT ACTED LIKE THE SECURITY SYSTEM HAD BEEN ACTIVATED AS IT WOULD CRANK, BUT NOT START. … Look up ODI 10354896 at NHTSA ↗
Engine	69 ODI 10810354 · 230,000 mi DRIVING THE XC90 AND SUDDENLY THERE IS A HUGE THUMP AND CLICKING FROM THE DASHBOARD. ALL THE DIALS AROUND THE SPEDOMETER STOP WORKING.. IF WE KEEP DRIVING THERE ARE MORE THUMPS AND WE QUICKLY LOSE ENGINE POWER - IT IS EXTREMELY SCARY WHEN IT HAPPENS.. ALL THE LIGHTS COME ON (INSIDE THE CAR), DASHBOARD GOES DEAD ETC ETC. IT IS EXTREMELY DANGEROUS .. IT HAPPENED TO USE A NUMBER OF TIMES WITH 3 CHILDREN IN THE CAR. IT HAS OCCURRED WHEN WE WERE DRIVING ON THE HIGHWAY, 2-3 TIMES, IT HAS OCCURRED ON SHORT TRIPS - IT HAPPENS AT SEEMINGLY RANDOM TI… Look up ODI 10810354 at NHTSA ↗ ODI 10463571 · 109 mi DRIVING ON STREET AND ENGINE JUST DIED, NO REASON CAN THINK OF, NO ENGINE LIGHT OR MESSAGE IN TEXT. HAPPENED AGAIN 2-3 WEEKS (YESTERDAY) WHILE SLOWING DOWN FOR STREET ACCIDENT, LOST ALL POWER, HAD TO STOP CAR WITHOUT POWER STEERING OR BRAKES, PUT IN PARK AND STARTED AGAIN. NO PROBLEM AFTERWARDS AND DROVE HOME. TOOK TO VOLVO DEALER TODAY WHERE I REGULARLY GO AND OF COURSE NO REASON FOUND FOR TWO TIME FAILURE. LUCKILY NOT DRIVING ON FREEWAY OR MAY HAVE BEEN REAR-ENDED DUE TO ENGINE FAILURE. QUITE SCARED NOW TO DRIVE - WHEN IS IT GONNA HAPP… Look up ODI 10463571 at NHTSA ↗ ODI 10471266 · 111,000 mi ALL INTERIOR LIGHTS, GUAGES, WINDSHIELD WIPERS RANDOMLY SHUT DOWN AT FREEWAY SPEEDS AND AT IDLE. ENGINE POWER IS ALSO AFFECTED AS UNABLE TO ACCELERATE PROPERLY. DEALER REPLACED DRIVER INFORMATION MODULE HOWEVER PROBLEM CONTINUES. DEALER UNABLE TO SOURCE THE PROBLEM AS THE VEHICLE NEEDS TO BE IN THE PROCESS OF FAILING FOR THEM TO SOURCE THE PROBLEM. THIS HAS NOT BEEN POSSIBLE AS THE ISSUE IS RANDOM AND TYPICAL GOES AWAY AFTER THE CAR SITS FOR SEVERAL HOURS. THE SERVICE AIRBAG AND BRAKE FAILURE CODE REMAINS IN THE DRIVER INFORMATION MODULE. THIS … Look up ODI 10471266 at NHTSA ↗	—	0	26 ODI 10760442 · 114,687 mi WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YEAR LATER THE VEHICLE WAS PLACED IN THE SHOP FOR THE TURBO'S HAD GONE OUT ON THE VEHICLE ON APRIL 11, 2015 UNTIL CURRENT DATE. THEY ARE NOW SAYING THE VEHICLE HAS A BLOWN HEAD GASKET AND IT IS… Look up ODI 10760442 at NHTSA ↗ ODI 11279190 TRANSMISION IS STRUGGLING ON 3RD OR 4TH SHIFT, I READ ON INTERNET MANY COLVOS THIS TRIM FAILING AND BEEN REBUILTED AND STILL FAILING Look up ODI 11279190 at NHTSA ↗ ODI 11421934 is been stolen form my home and trying to fine it Look up ODI 11421934 at NHTSA ↗	34 ODI 10713394 · 143,000 mi MY 2004 VOLVO XC90 WITH A 2.5T ENGINE, 7 PASS, INTERMITTENTLY AND INADVERTENTLY STALLS WHILE DRIVING IT. IT IS SCARY BECAUSE ALL ELECTRICAL GOES OFF, INSTRUMENT PANEL, RADIO, LIGHTS, ETC, SEVERAL WARNING MESSAGES APPEARS, SUCH ABS, AIR BAGS FAILURE, BRAKE FAILURE, ENGINE FAILURE, ETC. IT WON'T RESPOND TO ACCELERATION AND BRAKES ARE VERY HARD TO PUSH, THE ENGINE DOES NOT STOP. I HAVE TO STOP, TURN IT OFF, WAIT FEW MINUTES, THEN START IT, EVERYTHING COMES TO NORMAL AGAIN BUT WITH THE CHECK ENGINE AND THE AIR BAGS MESSAGE, THEN AFTER SOME MINUTES … Look up ODI 10713394 at NHTSA ↗ ODI 11626848 Unsure of what the issue is with the vehicle but smells like gas in my garage and I found a recall I was never notified about I moved from Washington to Las Vegas and never received any info regarding the fuel pump recall as well as a noise that’s been going on for a year now when I drive at 60 miles an hour I’ve had it looked at and no one seems to know what that issue is Look up ODI 11626848 at NHTSA ↗ ODI 10563531 THIS CAR HAS BEEN A CONSTANT PROBLEM - I AM THE ORIGINAL OWNER AND THE COST TO REPAIR IS EXTREMELY HIGH.. I AM A RECENT WIDOW AND A SINGLE MOTHER OF 3 CHILDREN ON A FIXED INCOME... I AM SO TIRED OF THIS CAR BEING SO UNRELIABLE AND THE REPAIR COSTS ARE BANKRUPTING ME. I HAVE NO WHERE TO TURN THIS CAR HAS BEEN A LEMON FROM DAY ONE AND THE MANUFACTURER AND DEALER COULD CARE LESS. *TR Look up ODI 10563531 at NHTSA ↗	21 ODI 10760442 · 114,687 mi WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YEAR LATER THE VEHICLE WAS PLACED IN THE SHOP FOR THE TURBO'S HAD GONE OUT ON THE VEHICLE ON APRIL 11, 2015 UNTIL CURRENT DATE. THEY ARE NOW SAYING THE VEHICLE HAS A BLOWN HEAD GASKET AND IT IS… Look up ODI 10760442 at NHTSA ↗ ODI 10782080 · 135,000 mi TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING 65 MPH, THE ENGINE RPMS DECREASED AS IF THE BRAKE PEDAL WERE DEPRESSED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 135,000....UPDATED 01/27/16 BF JS Look up ODI 10782080 at NHTSA ↗ ODI 10489205 · 115,000 mi VOLVO KNOWS THE V8 ENGINE ON THE 2005 XC90 IS FAULTY. SPECIFICALLY, THE COUNTERBALANCE SHAFT BEARING FAILING DUE TO WATER INTRUSION. FORTUNATELY MINE FAILED WHILE AT IDLE. UNFORTUNATELY THE ENTIRE ENGINE IS NOW SEIZED UP AND MY OTHERWISE CLEAN CAR IS A LARGE AND USELESS PAPERWEIGHT. IF THIS WERE TO HAPPEN WHILE THE CAR IS MOVING AT SPEED, IT COULD CAUSE A HORRIBLE ACCIDENT. UNLESS VOLVO ACTIVELY FINDS THE REMAINING ENGINES IN SERVICE AND FIXES THIS PROBLEM, IT REMAINS A RISK REGARDLESS OF THE MILEAGE. APPROPRIATELY, THEY SHOULD ALSO REIMB… Look up ODI 10489205 at NHTSA ↗	7 ODI 10478919 · 104,789 mi MY WIFE AND I WERE DRIVING TO A FRIEND'S HOW'S WHEN SUDDENLY THE RADIO STARTED ACTING UP ,IT WOULD GO ON AND OFF . AFTER WE NOTICED THAT I SLOWED DOWN A BIT THEN ALL OF A SUDDEN MY HOLE DASH BOARD WENT OUT . I TRIED PULLING OVER BUT THE TRANSMISSION WOULD NOT RESPOND ,THEN THE DASHBOARD CAME BACK ON BUT I HAD ALL THESE WARNINGS LIKE BRAKE FAILURE ,SRS AIRBAG SERVICE URGENT , ENGINE SYSTEM SERVICE URGENT . AFTER ALL THE HAPPENS THE TRUCK DIED ,LUCKILY I WAS ABLE TO GET OFF THE ROAD BEFORE OTHER CARS HIT US .AFTER A COUPLE A MINUTES I TRIED TURN… Look up ODI 10478919 at NHTSA ↗ ODI 10522327 · 78,244 mi WAS DRIVING IN NEIGHBORHOOD AT ABOUT 20 MPH, WHEN RADIO SHUT OFF AND THEN ALL ELECTRICAL SHUT OFF, CAR DID NOT RESPOND TO EITHER GAS OR BRAKES, THEN THERE WAS A THUMP FROM THE FRONT OF THE CAR, WHICH BROUGHT THE DASH LIGHTS BACK ON. I THEN WAS ABLE TO PULL OVER AND TURN OFF CAR. RESTARTED THE CAR AND THERE WERE A SLEW OF ERROR MESSAGES ON THE DASH, INCLUDING A BRAKE WARNING. ATTEMPTED TO CONTINUE TO DRIVE CAR, ISSUE HAPPENED AGAIN AND AGAIN ON MY DRIVE HOME. VERY UNSAFE TO BE DRIVING AND NOT SURE IF YOUR BRAKES OR STEERING ARE GOING TO CUT OUT.… Look up ODI 10522327 at NHTSA ↗ ODI 10938344 · 166,000 mi WHEN TRAVELING AT HIGH RATES OF SPEED (ON THE HIGHWAY) THE CAR COMPLETELY SHUTS OFF. THE DASHBOARD AND ALL ELECTRICAL SHUTS OFF, THE HAZARDS DO NOT SEEM TO WORK OR THE TURN INDICATORS, ABS DOES NOT WORK SO IT IS A VERY SLOW HEAVY STOP. THIS HAPPENED TO ME IN THIS CAR ONE OTHER TIME IN 2010, AND THERE WAS AN IMMEDIATE COMPUTER MODULE UPGRADE ISSUED. Look up ODI 10938344 at NHTSA ↗	9 ODI 10490370 · 144,010 mi LAST NIGHT MY 2004 VOLVO XC90 LEFT ME ON THE SIDE OF THE ROAD INTERSTATE 88 NEAR ROCK FALLS, IL WEATHER 7:00 PM 28 HUMIDITY: 73% WIND: NNE DEW POINT: 22 PRESSURE: 30.16 IN BONE DRY WHILE DRIVING 65MPH FELT A "THUMP" IN THE FRONT END, FOLLOWED BY A SPLIT SECOND WHERE ALL DASHBOARD LIGHTS, WENT BLACK. WHILE TRYING TO PUSH THE GAS PEDAL THE CAR WOULD NOT ACCELERATE. THEN NORMAL FUNCTION RESUMED. A MINUTE OR TWO LATER, SAME THING AND ALL LIGHTS INTERNALLY COMPLETELY WENT OUT, I PULLED OVER IMMEDIATELY AND TURNED THE CAR OFF. HAZARD LIGHTS C… Look up ODI 10490370 at NHTSA ↗ ODI 10512481 · 79,000 mi I WAS DRIVING ON THE HIGHWAY AT 60 MILES AN HOUR AND THE CAR COMPLETELY SHUT OFF. NO LIGHTS, NO ENGINE, NO POWER STEERING, NO DASH LIGHTS. THE CAR WENT COMPLETELY DEAD. I PULLED OVER AND LET THE CAR REST AND THEN IT STARTED UP AGAIN. I NOTICED THE SECOND TIME IT HAPPENED WHEN I TOOK MY FOOT OFF THE ACCELERATOR. I TOOK IT TO ARBORMOTION IN ANN ARBOR MI AND THEY TOLD ME A CODE CAME UP AND SOME PART HAD TO BE CLEANED. WHEN I TOOK MY FOOT OFF THE ACCELERATOR THERE WAS NOT ENOUGH AIR GOING THROUGH THE PART TO ALLOW GAS TO FLOW. THEY FIXED THE PART A… Look up ODI 10512481 at NHTSA ↗ ODI 10584217 · 95,000 mi ON TWO SEPARATE OCCASIONS, OUR VEHICLE WOULD NOT RESTART AFTER STOPPING FOR GAS. THIS OCCURRED AFTER IT WAS SERVICED AND BATTERY REPLACED A WEEK PRIOR. AAA WAS UNABLE TO JUMP START IT AS WELL, AND VEHICLE HAD TO BE TOWED BACK TO DEALERSHIP FOR REPAIRS. ACCORDING TO THE TWO SEPARATE DEALERSHIPS, THE CENTRAL ELECTRONICS MODULE IS THE CULPRIT, AND NEEDED REPLACING. ACROSS MULTIPLE ONLINE FORUMS, VOLVO OWNERS HAVE COMPLAINED ABOUT SIMILAR PROBLEMS WITH THE CEM, OFTEN PLACING DRIVERS AND OCCUPANTS IN DANGER AS THEY EXPERIENCED COMPLETE ELECTRICAL … Look up ODI 10584217 at NHTSA ↗
Power Train:Automatic Transmission	6 ODI 10045003 · 12,000 mi PROBLEMS WITH VEHICLE'S TRANSMISSION, SEAT BELTS DO NOT LATCH, DRIVER'S SEAT RECLINES BY ITSELF. MR THE RADIO WENT OUT AND THE ENGINE MADE A GRINDING NOISE SCC *JB Look up ODI 10045003 at NHTSA ↗ ODI 10282656 · 65,000 mi 2004 VOLVO XC90 2.5L TRANSMISSION. COMPLETE FAILURE AT 65,000 MILES REQUIRING REPLACEMENT OF ENTIRE TRANSMISSION. FOUR DAYS AFTER REPAIR, VEHICLE HAS LOUD ENGINE THUMP AND CHECK ENGINE LIGHT COMES BACK ON. REPEATS THUMP WITH ENTIRE ELECTRICAL SYSTEM GOING OUT REQUIRING A 3.5 HOUR TOW HOME FROM 1/2 TO OUR VACATION DESTINATION. DEALER REPLACED ALTERNATOR. HAD FOR 2 DAYS AND CHECK ENGINE LIGHT COMES BACK ON AND THE THUMP/ELECTRICAL ISSUES START AGAIN. BARELY GOT TO DEALER WHO HAS HAD FOR A WEEK. THEY REPLACED ALTERNATOR AS PUT IN THE WRONG O… Look up ODI 10282656 at NHTSA ↗ ODI 10345228 · 75,000 mi AFTER DRIVING 125 MILES WITHOUT INCIDENT, WE LEFT OUR 2004 VOLVO XC 90 T6 AWD PARKED FOR 4 HOURS BEFORE DRIVING AGAIN. AFTER LESS THAN A HALF MILE AT LOW SPEED, THERE WAS A "THUMP" FROM THE FRONT OF THE CAR, THE WIPERS CYCLED, THE GAUGES ALL WENT BLANK, SOME OF THE WINDOWS STOPPED WORKING, THE A/C WENT OUT (BLOWER STAYED ON). THE CAR STAYED ON, BUT SEEMED "STUCK" IN SECOND GEAR AND THE BRAKES BECAME "SPONGY," BUT OPERABLE. TURN SIGNALS WERE INOPERABLE AND THE POWER STEERING WENT OUT. THE INDICATOR LIGHT ON THE GEAR SHIFT WENT OUT AND THE CE… Look up ODI 10345228 at NHTSA ↗	0	—	3 ODI 10269896 · 112,709 mi 1. SINCE DAY 1, THE TRANSMISSION ON MY 2004 VOLVO-XC90 HAS ALWAYS GIVEN ME TROUBLE, IT DOESN'T ENGAGE TROUGH GEAR AS QUICKLY AS IT SHOULD. ON MAY 25TH 2009, THE TRANSMISSION COMPLETELY WENT OUT LEAVING ME IN THE MIDDLE OF THE INTERSECTION WITH CARS BEHIND ME TRAVELING 35 MILES AND ALMOST CAUSED AN ACCIDENT. 2. THE TRANSMISSION HAS NEVER OPERATED PROPERLY SINCE I PURCHASED THE CAR IN APRIL OF 2009. THE SHOP AND EVERY OTHER ONE I CALLED KNEW EXACTLY WHAT THE PROBLEM WAS. THEY SAID THAT THE TRANSMISSION IN THIS MODEL AND YEAR WAS A FAULTY … Look up ODI 10269896 at NHTSA ↗ ODI 10345228 · 75,000 mi AFTER DRIVING 125 MILES WITHOUT INCIDENT, WE LEFT OUR 2004 VOLVO XC 90 T6 AWD PARKED FOR 4 HOURS BEFORE DRIVING AGAIN. AFTER LESS THAN A HALF MILE AT LOW SPEED, THERE WAS A "THUMP" FROM THE FRONT OF THE CAR, THE WIPERS CYCLED, THE GAUGES ALL WENT BLANK, SOME OF THE WINDOWS STOPPED WORKING, THE A/C WENT OUT (BLOWER STAYED ON). THE CAR STAYED ON, BUT SEEMED "STUCK" IN SECOND GEAR AND THE BRAKES BECAME "SPONGY," BUT OPERABLE. TURN SIGNALS WERE INOPERABLE AND THE POWER STEERING WENT OUT. THE INDICATOR LIGHT ON THE GEAR SHIFT WENT OUT AND THE CE… Look up ODI 10345228 at NHTSA ↗ ODI 10257656 · 54,414 mi WHILE DRIVING MY 2005 VOLVO XC90 (54,414 MILES) ON A BUSY CALIFORNIA FREEWAY (THE 405), THE ENGINE STOPPED SUDDENLY WITH NO WARNING OR WARNING LIGHT. FORTUNATELY, I WAS ABLE TO MAKE IT OVER TO THE SIDE OF THE ROAD TO CALL FOR A TOW WITHOUT INJURY (ALTHOUGH I WAS ALMOST REAR ENDED SINCE THE FAILURE WAS SO SUDDEN AND WITHOUT WARNING) AND HAD IT TOWED TO A VOLVO DEALER IN TORRANCE, CA. IT IS A TRANSMISSION PROBLEM. SINCE THEN, WE HAVE FOUND HUNDREDS OF OTHER CONSUMERS WHO HAVE HAD THE SAME PROBLEM WITH THEIR XC90 VOLVOS TOO. VOLVO HAS NOT RECA… Look up ODI 10257656 at NHTSA ↗	0	2 ODI 10258423 · 53,000 mi I HAVE THE ILL FATED XC90 T6...LIKE CLOCKWORK AT 53000 MILES THE DREADED TRANSMISSION SERVICE URGENT LIGHT COMES ON....NOW I AM SUPPOSED TO FORK OVER 7000 BUCKS FOR A COMPLETELY DEFECTIVE TRANSMISSION! TR Look up ODI 10258423 at NHTSA ↗ ODI 10534206 · 40,000 mi TL THE CONTACT OWNS A 2007 VOLVO XC90. THE CONTACT STATED WHILE DRIVING 45 MPH HE ATTEMPTED TO ACCELERATE; HOWEVER, THE VEHICLE FAILED TO MOVE FORWARD. THE CONTACT HEARD A LOUD BANGING NOISE AND THE VEHICLE BEGAN MOVING FORWARD. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER SEVERAL TIMES OVER THE COURSE OF FIVE YEARS BUT NO CAUSE FOR FAILURE WAS FOUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 93,000. UPDATED 09/10/13*LJ Look up ODI 10534206 at NHTSA ↗	0	1 ODI 10293742 · 79,300 mi OPERATING VEHICLE SINCE OCT '08, SINCE THAT TIME THERE HAS BEEN A NOISE EMANATING FROM FRONT PASS-SIDE WHEEL AREA. PURCHASING DEALER(HALL CHEVY, CHESAPEAKE, VA) PERFORMED WHEEL-ALIGNMENT TO "FIX" THE NOISE WHICH DID NOT REMEDY. VOLVO DEALER IN ARVADA, CO DIAGNOSED IT AS FAILED, OR FAILING WHEEL HUB, TO BE REPLACED AT COST OF $500. THIS VEHICLE ALSO HAD TRANS FAILURE AT APPX 76K MILES, AND THROTTLE CONTROL MODULE FAILURE IN OCT '09. I BELIEVE THERE ARE MANY CONCERNS ABOUT OPERATING AND HAVING CONFIDENCE IN ITS ABILITY TO OPERATE "SAFELY AND… Look up ODI 10293742 at NHTSA ↗
Unknown Or Other	34 ODI 10345228 · 75,000 mi AFTER DRIVING 125 MILES WITHOUT INCIDENT, WE LEFT OUR 2004 VOLVO XC 90 T6 AWD PARKED FOR 4 HOURS BEFORE DRIVING AGAIN. AFTER LESS THAN A HALF MILE AT LOW SPEED, THERE WAS A "THUMP" FROM THE FRONT OF THE CAR, THE WIPERS CYCLED, THE GAUGES ALL WENT BLANK, SOME OF THE WINDOWS STOPPED WORKING, THE A/C WENT OUT (BLOWER STAYED ON). THE CAR STAYED ON, BUT SEEMED "STUCK" IN SECOND GEAR AND THE BRAKES BECAME "SPONGY," BUT OPERABLE. TURN SIGNALS WERE INOPERABLE AND THE POWER STEERING WENT OUT. THE INDICATOR LIGHT ON THE GEAR SHIFT WENT OUT AND THE CE… Look up ODI 10345228 at NHTSA ↗ ODI 10438941 · 135 mi WHILE DRIVING ON THE HIGHWAY AT NIGHT, ALL ELECTRICAL INDICATORS ON DASHBOARD INCLUDING THE TURN SIGNALS STOP WORKING THEN THE VEHICLE STARTED SLOWING DOWN. AFTER STOPPING I WAS UNABLE TO OPEN GAS TANK AND TAILGATE WHERE THE BATTERY IS LOCATED. I TOOK THE VEHICLE TO THE VOLVO DEALER AND THEY WERE UNABLE TO DUPLICATE THE INCIDENT. NOW THIS HAS HAPPEN 7 MORE TIMES. I AM A SINGLE PARENT WITH MINOR CHILDREN IN MY VEHICLE. PLEASE ASSIST. SOMEONE INFORM ME THE PROBLEM MIGHT BE WITH THE CENTRAL ELECTRICAL MODULE. I PURCHASE THIS VEHICLE USED AND IT IS… Look up ODI 10438941 at NHTSA ↗ ODI 10594009 · 95,000 mi WHILE DRIVING DOWN THE ROAD AROUND 50 MPH THE XC90 SKIPPED AND TEMPORARILY TURNED OFF ALL ELECTIONS. THOUGHT IT WAS A GLITCH SO CONTINUED DOWN THE ROAD MORE CAREFULLY. THEN IT HAPPENED AGAIN AND THE ELECTRONICS NEVER CAME BACK ON. I COULDN'T MAKE IT UP A SMALL HILL ON THE ROAD TO GET SAFELY HOME. MY TRANSMISSION WOULDN'T PULL. THE SPEED GAUGE AND RPMS WERE COMPLETELY UNWORKING. WINDOWS WOULD NOT ROLL DOWN AIR HAD WENT OUT. POWER STEERING TEMPORARILY WENT OUT. MADE IT HOME FINALLY AND NOTHING SEEMS WRONG NOW BUT THERE IS OBVIOUSLY A PROBLEM THAT… Look up ODI 10594009 at NHTSA ↗	26 ODI 10760442 · 114,687 mi WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YEAR LATER THE VEHICLE WAS PLACED IN THE SHOP FOR THE TURBO'S HAD GONE OUT ON THE VEHICLE ON APRIL 11, 2015 UNTIL CURRENT DATE. THEY ARE NOW SAYING THE VEHICLE HAS A BLOWN HEAD GASKET AND IT IS… Look up ODI 10760442 at NHTSA ↗ ODI 11279190 TRANSMISION IS STRUGGLING ON 3RD OR 4TH SHIFT, I READ ON INTERNET MANY COLVOS THIS TRIM FAILING AND BEEN REBUILTED AND STILL FAILING Look up ODI 11279190 at NHTSA ↗ ODI 11421934 is been stolen form my home and trying to fine it Look up ODI 11421934 at NHTSA ↗	3 ODI 10269896 · 112,709 mi 1. SINCE DAY 1, THE TRANSMISSION ON MY 2004 VOLVO-XC90 HAS ALWAYS GIVEN ME TROUBLE, IT DOESN'T ENGAGE TROUGH GEAR AS QUICKLY AS IT SHOULD. ON MAY 25TH 2009, THE TRANSMISSION COMPLETELY WENT OUT LEAVING ME IN THE MIDDLE OF THE INTERSECTION WITH CARS BEHIND ME TRAVELING 35 MILES AND ALMOST CAUSED AN ACCIDENT. 2. THE TRANSMISSION HAS NEVER OPERATED PROPERLY SINCE I PURCHASED THE CAR IN APRIL OF 2009. THE SHOP AND EVERY OTHER ONE I CALLED KNEW EXACTLY WHAT THE PROBLEM WAS. THEY SAID THAT THE TRANSMISSION IN THIS MODEL AND YEAR WAS A FAULTY … Look up ODI 10269896 at NHTSA ↗ ODI 10345228 · 75,000 mi AFTER DRIVING 125 MILES WITHOUT INCIDENT, WE LEFT OUR 2004 VOLVO XC 90 T6 AWD PARKED FOR 4 HOURS BEFORE DRIVING AGAIN. AFTER LESS THAN A HALF MILE AT LOW SPEED, THERE WAS A "THUMP" FROM THE FRONT OF THE CAR, THE WIPERS CYCLED, THE GAUGES ALL WENT BLANK, SOME OF THE WINDOWS STOPPED WORKING, THE A/C WENT OUT (BLOWER STAYED ON). THE CAR STAYED ON, BUT SEEMED "STUCK" IN SECOND GEAR AND THE BRAKES BECAME "SPONGY," BUT OPERABLE. TURN SIGNALS WERE INOPERABLE AND THE POWER STEERING WENT OUT. THE INDICATOR LIGHT ON THE GEAR SHIFT WENT OUT AND THE CE… Look up ODI 10345228 at NHTSA ↗ ODI 10257656 · 54,414 mi WHILE DRIVING MY 2005 VOLVO XC90 (54,414 MILES) ON A BUSY CALIFORNIA FREEWAY (THE 405), THE ENGINE STOPPED SUDDENLY WITH NO WARNING OR WARNING LIGHT. FORTUNATELY, I WAS ABLE TO MAKE IT OVER TO THE SIDE OF THE ROAD TO CALL FOR A TOW WITHOUT INJURY (ALTHOUGH I WAS ALMOST REAR ENDED SINCE THE FAILURE WAS SO SUDDEN AND WITHOUT WARNING) AND HAD IT TOWED TO A VOLVO DEALER IN TORRANCE, CA. IT IS A TRANSMISSION PROBLEM. SINCE THEN, WE HAVE FOUND HUNDREDS OF OTHER CONSUMERS WHO HAVE HAD THE SAME PROBLEM WITH THEIR XC90 VOLVOS TOO. VOLVO HAS NOT RECA… Look up ODI 10257656 at NHTSA ↗	—	6 ODI 11532420 I’ve had to change my fuel injection pump and catalytic convert twice on one year. Look up ODI 11532420 at NHTSA ↗ ODI 11746768 My 2016 Volvo XC90 suddenly lost power while I was driving, requiring me to pull over and have the vehicle towed. This is a documented safety issue associated with a known piston ring defect in 2013-2016 Volvo vehicles equipped with 2.0L and 2.5L engines, which was the subject of a federal class action lawsuit ([XXX] et al. v. Volvo Car USA, LLC, Case No. XXX, filed XXX. No there we NO warning lamps, messages or other symptoms of the problem prior to the failure. I purchased this vehicle as a second owner from Carvana [XXX] , one month after th… Look up ODI 11746768 at NHTSA ↗ ODI 11673211 ERAD (Electronic Rear Axle Drive) clutch failure. Upon depressing accelerator pedal, when in drive modes that rely more on ERAD (Hybrid/Pure modes), the clutch occasionally does not engage correctly, resulting in no power for a full 1-2 seconds, then power kicking in, in full. Not being consistent means not having a good way to anticipate when the problem will arise in order to compensate for it. The hazard came when attempting to cross traffic (to take a left into a commercial driveway), the delay happened, then before the ability to fully … Look up ODI 11673211 at NHTSA ↗	3 ODI 10760442 · 114,687 mi WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YEAR LATER THE VEHICLE WAS PLACED IN THE SHOP FOR THE TURBO'S HAD GONE OUT ON THE VEHICLE ON APRIL 11, 2015 UNTIL CURRENT DATE. THEY ARE NOW SAYING THE VEHICLE HAS A BLOWN HEAD GASKET AND IT IS… Look up ODI 10760442 at NHTSA ↗ ODI 10489205 · 115,000 mi VOLVO KNOWS THE V8 ENGINE ON THE 2005 XC90 IS FAULTY. SPECIFICALLY, THE COUNTERBALANCE SHAFT BEARING FAILING DUE TO WATER INTRUSION. FORTUNATELY MINE FAILED WHILE AT IDLE. UNFORTUNATELY THE ENTIRE ENGINE IS NOW SEIZED UP AND MY OTHERWISE CLEAN CAR IS A LARGE AND USELESS PAPERWEIGHT. IF THIS WERE TO HAPPEN WHILE THE CAR IS MOVING AT SPEED, IT COULD CAUSE A HORRIBLE ACCIDENT. UNLESS VOLVO ACTIVELY FINDS THE REMAINING ENGINES IN SERVICE AND FIXES THIS PROBLEM, IT REMAINS A RISK REGARDLESS OF THE MILEAGE. APPROPRIATELY, THEY SHOULD ALSO REIMB… Look up ODI 10489205 at NHTSA ↗ ODI 11160701 · 5,200 mi PURCHASED 2014 XC 90, 5,200 MILES ON IT MARCH 2018. STEERING WHEEL VIBRATION ISSUE REPORTED BY ME 5/2018 .IT DOESN'T MATTER IF IT IS IN NEUTRAL,DRIVE,REVERSE WITH THE BRAKE DEPRESSED. WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT,IT VIBRATES. NOW FEELING MORE VIBRATIONS FROM ENGINE/STEERING WHEEL WHEN ACCELERATING. VOLVO USA/SWEDEN TECHS HAVE BEEN INVOLVED. IT IS NOW DEC. 2018. MOTOR/TRANSMISSION MOUNTS,STEERING WHEEL OSCILLATOR,POWER STEERING PUMP/PULLEY REPLACED,ENGINE TORQUE MOUNTS ADJUSTED.BEING TOLD THIS IS "CHARACTERISTIC" OF THIS ENGINE.… Look up ODI 11160701 at NHTSA ↗	7 ODI 11435895 I have installed a SprintDrive installed in my Volvo. Since the installation, I have had several safety and security issues occur that stop once the device is removed. The following issues have occurred: 1) Whilst driving on the Muskogee Turnpike, the cruising control system would disengage. This occurred at least three times during the drive. On the third time, the cruising control system disengaged and the braking system engaged causing the vehicle to go from 85 mph to 45 mph. 2) I was driving on C-470. The transmission system would not … Look up ODI 11435895 at NHTSA ↗ ODI 10861446 WHILE DRIVING ON A CITY STREET I PUT THE CAR IN ECO MODE. THE CAR WAS MOVING AT THE TIME. I NOTICED THAT THE CAR SEEMED TO BE DRIVING LOUDLY. AS I TURNED LEFT, I SAW THE CAR WAS IN MANUAL MODE AND WAS IN FIRST GEAR. SO I TOOK MY FOOT OFF OF THE BRAKE TO SLOW DOWN THE CAR AND TRY TO PUT IT INTO DRIVE. AS I TRIED TO MOVE THE GEAR SHIFTER, THE CAR CAME TO A COMPLETE, SUDDEN STOP. IT FELT LIKE ALL FOUR WHEELS WERE SUDDENLY AND IMMEDIATELY LOCKED. I COULD NOT MOVE THEM, EVEN AS I HIT THE GAS. I DID NOT SEE ANY INDICATION ON THE DASHBOARD THAT TH… Look up ODI 10861446 at NHTSA ↗ ODI 11196537 · 17,000 mi THE COLLISION AVOIDANCE SYSTEM WAS ENGAGED, I WAS DRIVING DURING A RAIN STORM AT NIGHT AT 45 MPH, AND THE COLLISION AVOIDANCE ALARM WENT OFF WITHOUT ANYTHING IN FRONT OF MY CAR, THEN THE BRAKES SLAMMED ON BY THEMSELVES AND THE CAR BEHIND ME HAD TO SWERVE ONTO THE SHOULDER TO AVOID HITTING ME IN THE REAR Look up ODI 11196537 at NHTSA ↗	1 ODI 10716633 · 60,000 mi HELLO VOLVO, FOR THE RECORD, WE LOVE OUR VOLVO SUV (2004, XC90). OVER THE YEARS THE SERVICE FROM MICHELLE BALSIDE AT VOLVO ON PLAINFIELD ROAD IN CINCINNATI HAS BEEN TRULY EXCELLENT, HER CONTACT INFORMATION IS ATTACHED. HOWEVER, WE HAVE HAS AN ISSUE SINCE 2011 THAT HAS NOT BEEN RESOLVED, WHICH IS SO UNCHARACTERISTIC OF VOLVO. I AM HOPING YOU CAN HELP ME CHANGE THE OUTCOME. FOR YEARS MY HUSBANDS RIGHT HEADLIGHT HAS BEEN TURNING ON AND OFF INTERMITTENTLY. THIS IS VERY DANGEROUS WHEN HE DRIVES TO AND FROM WORK AT NIGHT ON AN OLD 4 LANE HI… Look up ODI 10716633 at NHTSA ↗
Fuel/Propulsion System	23 ODI 10534670 MY XC90 VOLVO IS VERY DISAPPOINTING THE DASH BOARD ON THE CAR COMPLETELY FAILS NO NOTHING NO GAS, SPEEDOMETER EVERY THINGS GOES OUT. IN THE NIGHT TIME ITS VERY SCARY ITS COMPLETELY DARK I DON'T KNOW HOW FAST I'M GOING HOW MUCH GAS I HAVE ITS SCARY. NOW THE FUEL PUMP IS GONE AND THE NAVIGATION SYSTEM BURNED OUT I CUT THE CAR ON HEARD A POP THEN I SMELLED SOMETHING BURNING THE NAVIGATION SYSTEM HASN'T WORKED SINCE. TR Look up ODI 10534670 at NHTSA ↗ ODI 10713394 · 143,000 mi MY 2004 VOLVO XC90 WITH A 2.5T ENGINE, 7 PASS, INTERMITTENTLY AND INADVERTENTLY STALLS WHILE DRIVING IT. IT IS SCARY BECAUSE ALL ELECTRICAL GOES OFF, INSTRUMENT PANEL, RADIO, LIGHTS, ETC, SEVERAL WARNING MESSAGES APPEARS, SUCH ABS, AIR BAGS FAILURE, BRAKE FAILURE, ENGINE FAILURE, ETC. IT WON'T RESPOND TO ACCELERATION AND BRAKES ARE VERY HARD TO PUSH, THE ENGINE DOES NOT STOP. I HAVE TO STOP, TURN IT OFF, WAIT FEW MINUTES, THEN START IT, EVERYTHING COMES TO NORMAL AGAIN BUT WITH THE CHECK ENGINE AND THE AIR BAGS MESSAGE, THEN AFTER SOME MINUTES … Look up ODI 10713394 at NHTSA ↗ ODI 10716499 TL THE CONTACT OWNS A 2004 VOLVO XC90. WHILE IN PARK, THE CONTACT HEARD A NOISE. ALL THE WARNING LIGHTS ON THE INSTRUMENT PANEL FAILED TO ILLUMINATE AND THE VEHICLE STALLED. IN ADDITION, THE CONTACT STATED THAT THE ODOMETER DISPLAYED AN INCORRECT READING AND THERE WAS A FUEL ODOR IN THE VEHICLE. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TOWED B… Look up ODI 10716499 at NHTSA ↗	34 ODI 10713394 · 143,000 mi MY 2004 VOLVO XC90 WITH A 2.5T ENGINE, 7 PASS, INTERMITTENTLY AND INADVERTENTLY STALLS WHILE DRIVING IT. IT IS SCARY BECAUSE ALL ELECTRICAL GOES OFF, INSTRUMENT PANEL, RADIO, LIGHTS, ETC, SEVERAL WARNING MESSAGES APPEARS, SUCH ABS, AIR BAGS FAILURE, BRAKE FAILURE, ENGINE FAILURE, ETC. IT WON'T RESPOND TO ACCELERATION AND BRAKES ARE VERY HARD TO PUSH, THE ENGINE DOES NOT STOP. I HAVE TO STOP, TURN IT OFF, WAIT FEW MINUTES, THEN START IT, EVERYTHING COMES TO NORMAL AGAIN BUT WITH THE CHECK ENGINE AND THE AIR BAGS MESSAGE, THEN AFTER SOME MINUTES … Look up ODI 10713394 at NHTSA ↗ ODI 11626848 Unsure of what the issue is with the vehicle but smells like gas in my garage and I found a recall I was never notified about I moved from Washington to Las Vegas and never received any info regarding the fuel pump recall as well as a noise that’s been going on for a year now when I drive at 60 miles an hour I’ve had it looked at and no one seems to know what that issue is Look up ODI 11626848 at NHTSA ↗ ODI 10563531 THIS CAR HAS BEEN A CONSTANT PROBLEM - I AM THE ORIGINAL OWNER AND THE COST TO REPAIR IS EXTREMELY HIGH.. I AM A RECENT WIDOW AND A SINGLE MOTHER OF 3 CHILDREN ON A FIXED INCOME... I AM SO TIRED OF THIS CAR BEING SO UNRELIABLE AND THE REPAIR COSTS ARE BANKRUPTING ME. I HAVE NO WHERE TO TURN THIS CAR HAS BEEN A LEMON FROM DAY ONE AND THE MANUFACTURER AND DEALER COULD CARE LESS. *TR Look up ODI 10563531 at NHTSA ↗	0	6 ODI 11532420 I’ve had to change my fuel injection pump and catalytic convert twice on one year. Look up ODI 11532420 at NHTSA ↗ ODI 11746768 My 2016 Volvo XC90 suddenly lost power while I was driving, requiring me to pull over and have the vehicle towed. This is a documented safety issue associated with a known piston ring defect in 2013-2016 Volvo vehicles equipped with 2.0L and 2.5L engines, which was the subject of a federal class action lawsuit ([XXX] et al. v. Volvo Car USA, LLC, Case No. XXX, filed XXX. No there we NO warning lamps, messages or other symptoms of the problem prior to the failure. I purchased this vehicle as a second owner from Carvana [XXX] , one month after th… Look up ODI 11746768 at NHTSA ↗ ODI 11673211 ERAD (Electronic Rear Axle Drive) clutch failure. Upon depressing accelerator pedal, when in drive modes that rely more on ERAD (Hybrid/Pure modes), the clutch occasionally does not engage correctly, resulting in no power for a full 1-2 seconds, then power kicking in, in full. Not being consistent means not having a good way to anticipate when the problem will arise in order to compensate for it. The hazard came when attempting to cross traffic (to take a left into a commercial driveway), the delay happened, then before the ability to fully … Look up ODI 11673211 at NHTSA ↗	—	8 ODI 11193422 · 113,223 mi BOUGHT THE VEHICLE WITH 112,000 MILES ON IT, IT HAS A GAS LEAK TRICKLING DOWN THE SIDE OF THE GAS TANK, PROBABLY A BAD SENDING UNIT, FUMES ARE BAD SOME DAYS BUT WORSE ON WARMER DAYS. THE TRANSMISSION FAILED ONE DAY WITH NO WARNING OR LIGHT, IT JUST LOST MOMENTUM AND FAILED TO ENGAGE IN DRIVE. I THINK THIS IS DUE TO THE POOR ENGINEERING DESIGN VOLVO USED. THIS MODEL IS THE T6 WITH THE GM 4T65E TRANSMISSION WHICH IS WIDELY KNOWN TO FAIL EVEN AT LOW MILES. I THINK A FULL SAFETY RECALL SHOULD E SANCTIONED FOR ALL MODEL YEARS WITH THESE HORRIBLE PRO… Look up ODI 11193422 at NHTSA ↗ ODI 11592531 The vehicle exhibits excessive oil consumption due to defective oil control rings, as highlighted by Quality Bulletin P10186. Additionally, the sunroof leaks, as noted in Technical Journal 31272 and TJ 35503.3.0, and there are further issues with the windshield wiper/turn signal system, the parking brake system, and the steering wheel module. Yes, the vehicle is available for inspection upon request. The excessive oil consumption and related engine issues can lead to engine damage and potential failure while driving, posing a serious safety ris… Look up ODI 11592531 at NHTSA ↗ ODI 11694587 On September 30, 2025, a 2016 Volvo XC90 T6 experienced sudden engine failure while driving westbound on I-75 (Alligator Alley) at highway speed. The vehicle abruptly went into reduced power mode (“turtle mode”) without warning. This forced the driver to stop on the roadside, creating a serious safety hazard in fast-moving traffic. Component/system that failed: Engine / Power Train. An independent repair facility performed diagnostics on October 6, 2025, including a compression test. Results confirmed that one cylinder had lost compression due… Look up ODI 11694587 at NHTSA ↗	1 ODI 11701873 On thanksgiving day i drove to train station in the morning, and had no issue. After work i got in the car started to drive, i was going 25-35 miles per hour in the maplewood township, and i wanted to slow down just in case i dont see any kid or person at dark. I almost had no brake! I was so scared and i pushed th brake pedal so hard, i was very dangerous for the society at this moment. I just wish i was not on the highway going higher speed, or there were no people around! I really cannot trust this car anymore, i could have hit something!!!… Look up ODI 11701873 at NHTSA ↗	1 ODI 11457064 Well I was at a red light waiting for the light to train green when I stepped on the Excelerator pedal I heard something snapped and the car would not move anymore I try to switch gears and the car would not move at all it would just accelerate the engine will sound like Like if I had the car on Neutral. In any gear I try to shift there was no warning in the vehicle no light turned on the only light that it was turned on was the one with the check engine because of the Cadillac converter but other than that no other lights were coming out or fl… Look up ODI 11457064 at NHTSA ↗
Power Train	31 ODI 10478870 · 170,000 mi AT 65 MPH WIPERS WENT ON BY THEMSELVES THEN FOLLOWED BY SPLIT SECOND POWER FAILURE,MEANING DASHBOARD LIGHT OUT,HAZARD LIGHTS COULD NOT BE TURNED ON,WINDOWS WOULD NOT OPEN,A/C OUT,IN THE MESSAGE SCREEN AT THAT MOMENT ANTILOCK BRAKE FAILURE WAS DISPLAYED BEFORE EVERYTHING WENT OUT,DRIVING ANOTHER 20 MILES TILL NEXT EXIT AT THE DUSK,AFTER PULLING OVER AND RESTART ( TO RESET) SRS FAILURE IN THE MESSAGE SCREEN. CAR CHECKED BY VOLVO DEALER AND STATEMENT FROM THEM:FAULT IN CEM IS SHUTTING DOWN NETWORK AND CAUSING DIM TO BLACK OUT. REPLACEMENT WILL RUN… Look up ODI 10478870 at NHTSA ↗ ODI 10513661 · 974,300 mi AFTER SEVERAL HOURS OF DRIVING IN THE GEORGIA / NORTH CAROLINA MOUNTAINS WITH THE WIFE AND 2 KIDS IN THE BACK, THE AIR-CONDITIONER AND RADIO ON WITH THE 2004 XC90, THE CAR STARTED EXPERIENCING WEIRD BEHAVIOR. SHORTLY AFTER CROSSING THE GEORGIA BORDER INTO THE MOUNTAINS OF NORTH CAROLINA THERE WAS A LOUD NOISE UNDER THE HOOD OF THE CAR AND THE VEHICLE JERKED VIOLENTLY. THE CAR IMMEDIATELY LOST ALL ELECTRICAL POWER (NO DASHBOARD, HAZARD LIGHTS, BLINKERS, WINDOWS AND DOOR LOCKS, SUNROOF, ETC.). THE DRIVE TRAIN ALSO SEEMED STUCK IN A HIGH GEAR A… Look up ODI 10513661 at NHTSA ↗ ODI 10538331 · 106,530 mi WHILE DRIVING 70 MPH ON I-5 WE HEARD A LOUD THUMP IN THE ENGINE COMPARTMENT AND WE SUDDENLY WENT TO ABOUT 25 MPH ALL OF OUR ELECTRONIC SYSTEMS SHUT DOWN, THERE WAS AN EXTREMELY LOUD GRINDING SOUND FOR APPROX. 2-3 SECONDS. NOW I THINK MY TRANSMISSION IS DAMAGED AND THE ELECTRONICS SYSTEM SHUTS DOWN PRETTY FREQUENTLY. I AM TOTALLY DISAPPOINTED TO READ THAT THIS HAS HAPPENED TO NUMEROUS OTHER FAMILIES. THANK GOD NO ONE HAS DIED FROM THIS.....THIS IS VERY IRRESPONSIBLE AND NEGLIGENT FROM A REPUTABLE AUTO COMPANY. IS IT GOING TO TAKE SOMEONE OR FAMI… Look up ODI 10538331 at NHTSA ↗	21 ODI 10760442 · 114,687 mi WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YEAR LATER THE VEHICLE WAS PLACED IN THE SHOP FOR THE TURBO'S HAD GONE OUT ON THE VEHICLE ON APRIL 11, 2015 UNTIL CURRENT DATE. THEY ARE NOW SAYING THE VEHICLE HAS A BLOWN HEAD GASKET AND IT IS… Look up ODI 10760442 at NHTSA ↗ ODI 10782080 · 135,000 mi TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING 65 MPH, THE ENGINE RPMS DECREASED AS IF THE BRAKE PEDAL WERE DEPRESSED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 135,000....UPDATED 01/27/16 BF JS Look up ODI 10782080 at NHTSA ↗ ODI 10489205 · 115,000 mi VOLVO KNOWS THE V8 ENGINE ON THE 2005 XC90 IS FAULTY. SPECIFICALLY, THE COUNTERBALANCE SHAFT BEARING FAILING DUE TO WATER INTRUSION. FORTUNATELY MINE FAILED WHILE AT IDLE. UNFORTUNATELY THE ENTIRE ENGINE IS NOW SEIZED UP AND MY OTHERWISE CLEAN CAR IS A LARGE AND USELESS PAPERWEIGHT. IF THIS WERE TO HAPPEN WHILE THE CAR IS MOVING AT SPEED, IT COULD CAUSE A HORRIBLE ACCIDENT. UNLESS VOLVO ACTIVELY FINDS THE REMAINING ENGINES IN SERVICE AND FIXES THIS PROBLEM, IT REMAINS A RISK REGARDLESS OF THE MILEAGE. APPROPRIATELY, THEY SHOULD ALSO REIMB… Look up ODI 10489205 at NHTSA ↗	2 ODI 10258423 · 53,000 mi I HAVE THE ILL FATED XC90 T6...LIKE CLOCKWORK AT 53000 MILES THE DREADED TRANSMISSION SERVICE URGENT LIGHT COMES ON....NOW I AM SUPPOSED TO FORK OVER 7000 BUCKS FOR A COMPLETELY DEFECTIVE TRANSMISSION! TR Look up ODI 10258423 at NHTSA ↗ ODI 10534206 · 40,000 mi TL THE CONTACT OWNS A 2007 VOLVO XC90. THE CONTACT STATED WHILE DRIVING 45 MPH HE ATTEMPTED TO ACCELERATE; HOWEVER, THE VEHICLE FAILED TO MOVE FORWARD. THE CONTACT HEARD A LOUD BANGING NOISE AND THE VEHICLE BEGAN MOVING FORWARD. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER SEVERAL TIMES OVER THE COURSE OF FIVE YEARS BUT NO CAUSE FOR FAILURE WAS FOUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 93,000. UPDATED 09/10/13*LJ Look up ODI 10534206 at NHTSA ↗	3 ODI 10760442 · 114,687 mi WHEN THIS VEHICLE WAS PURCHASED IT STARTED WITHIN 4 DAYS TO HAVE PROBLEMS WITH THE TRANSMISSION, AFTER THE TRANSMISSION THE TRANSFER CASE BEGAN TO HAVE PROBLEMS, SO THE VEHICLE WAS PLACED IN THE SHOP BEFORE THE THIRTY DAYS TAGS COULD EXPIRE AND BOTH PARTS WERE REBUILT BY AN OUTSIDE COMPANY WHICH WAS ADDED TO THE ORIGINAL PRICE TAG OF THE VEHICLE. THEN A YEAR LATER THE VEHICLE WAS PLACED IN THE SHOP FOR THE TURBO'S HAD GONE OUT ON THE VEHICLE ON APRIL 11, 2015 UNTIL CURRENT DATE. THEY ARE NOW SAYING THE VEHICLE HAS A BLOWN HEAD GASKET AND IT IS… Look up ODI 10760442 at NHTSA ↗ ODI 10489205 · 115,000 mi VOLVO KNOWS THE V8 ENGINE ON THE 2005 XC90 IS FAULTY. SPECIFICALLY, THE COUNTERBALANCE SHAFT BEARING FAILING DUE TO WATER INTRUSION. FORTUNATELY MINE FAILED WHILE AT IDLE. UNFORTUNATELY THE ENTIRE ENGINE IS NOW SEIZED UP AND MY OTHERWISE CLEAN CAR IS A LARGE AND USELESS PAPERWEIGHT. IF THIS WERE TO HAPPEN WHILE THE CAR IS MOVING AT SPEED, IT COULD CAUSE A HORRIBLE ACCIDENT. UNLESS VOLVO ACTIVELY FINDS THE REMAINING ENGINES IN SERVICE AND FIXES THIS PROBLEM, IT REMAINS A RISK REGARDLESS OF THE MILEAGE. APPROPRIATELY, THEY SHOULD ALSO REIMB… Look up ODI 10489205 at NHTSA ↗ ODI 11160701 · 5,200 mi PURCHASED 2014 XC 90, 5,200 MILES ON IT MARCH 2018. STEERING WHEEL VIBRATION ISSUE REPORTED BY ME 5/2018 .IT DOESN'T MATTER IF IT IS IN NEUTRAL,DRIVE,REVERSE WITH THE BRAKE DEPRESSED. WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT,IT VIBRATES. NOW FEELING MORE VIBRATIONS FROM ENGINE/STEERING WHEEL WHEN ACCELERATING. VOLVO USA/SWEDEN TECHS HAVE BEEN INVOLVED. IT IS NOW DEC. 2018. MOTOR/TRANSMISSION MOUNTS,STEERING WHEEL OSCILLATOR,POWER STEERING PUMP/PULLEY REPLACED,ENGINE TORQUE MOUNTS ADJUSTED.BEING TOLD THIS IS "CHARACTERISTIC" OF THIS ENGINE.… Look up ODI 11160701 at NHTSA ↗	8 ODI 11193422 · 113,223 mi BOUGHT THE VEHICLE WITH 112,000 MILES ON IT, IT HAS A GAS LEAK TRICKLING DOWN THE SIDE OF THE GAS TANK, PROBABLY A BAD SENDING UNIT, FUMES ARE BAD SOME DAYS BUT WORSE ON WARMER DAYS. THE TRANSMISSION FAILED ONE DAY WITH NO WARNING OR LIGHT, IT JUST LOST MOMENTUM AND FAILED TO ENGAGE IN DRIVE. I THINK THIS IS DUE TO THE POOR ENGINEERING DESIGN VOLVO USED. THIS MODEL IS THE T6 WITH THE GM 4T65E TRANSMISSION WHICH IS WIDELY KNOWN TO FAIL EVEN AT LOW MILES. I THINK A FULL SAFETY RECALL SHOULD E SANCTIONED FOR ALL MODEL YEARS WITH THESE HORRIBLE PRO… Look up ODI 11193422 at NHTSA ↗ ODI 11592531 The vehicle exhibits excessive oil consumption due to defective oil control rings, as highlighted by Quality Bulletin P10186. Additionally, the sunroof leaks, as noted in Technical Journal 31272 and TJ 35503.3.0, and there are further issues with the windshield wiper/turn signal system, the parking brake system, and the steering wheel module. Yes, the vehicle is available for inspection upon request. The excessive oil consumption and related engine issues can lead to engine damage and potential failure while driving, posing a serious safety ris… Look up ODI 11592531 at NHTSA ↗ ODI 11694587 On September 30, 2025, a 2016 Volvo XC90 T6 experienced sudden engine failure while driving westbound on I-75 (Alligator Alley) at highway speed. The vehicle abruptly went into reduced power mode (“turtle mode”) without warning. This forced the driver to stop on the roadside, creating a serious safety hazard in fast-moving traffic. Component/system that failed: Engine / Power Train. An independent repair facility performed diagnostics on October 6, 2025, including a compression test. Results confirmed that one cylinder had lost compression due… Look up ODI 11694587 at NHTSA ↗	—	5 ODI 10599097 · 90,000 mi WHILE ON THE INTERSTATE AT 60MPH, EXPERIENCED TEMPORARILY LOSS OF POWER, THE IP DISPLAYS AND AN ABNORMAL 'JERKING' IN THE TRANSMISSION/DRIVETRAIN. THE SRS AIRBAG AND BRAKE FAILURE ERROR MESSAGES APPEARED IN THE IP ERROR DISPLAY. THE WIPERS MOMENTARILY CAME ON. LIGHTS DIMMED. POWER FAILURE WAS ONLY FOR A SPLIT-SECOND (AT 60MPH) BEFORE RETURNING TO NORMAL. AFTER NORMAL POWER WAS RESTORED, ERROR MESSAGES CONTINUED TO BE SHOWN IN THE IP ERROR DISPLAY. THE BRAKE FAILURE MESSAGE INSTRUCTED ME TO PULL OVER AND BRING THE VEHICLE TO A SAFE STOP. UPO… Look up ODI 10599097 at NHTSA ↗ ODI 10872107 · 125,000 mi CAR MOVED TO RIGHT WHEN APPLYING BRAKES. CAR CLUNKS WHEN MAKING TURNS. CAR VERY NOISY WHEN GOING OVER BUMPS/ POTHOLES. Look up ODI 10872107 at NHTSA ↗ ODI 10472427 · 5 mi FROM THE BEGINNING THIS VEHICLE HAS DELAYED ACCELERATION, VERY DANGEROUS TO DRIVE WHEN PULLING OUT IN FRONT OF ON-COMING TRAFFIC, OR MAKING LEFT HAND TURN WITH ON-COMING TRAFFIC. BRAKES MAKE LOUD CRACKING POPPING SOUND WHEN BRAKING AND TURNING THE WHEEL, DO NOT FEEL SAFE WITH IT MAKING SUCH AWFUL SOUNDS. *TR Look up ODI 10472427 at NHTSA ↗	3 ODI 10873136 · 130,000 mi 2004 VOLVO XC90 SUDDEN ENGINE STALL WITH LOSE OF HEADLIGHTS: I WAS TRAVELING ON THE INTERSTATE AT NIGHT WITH THE CRUISE SET AT 75 MPH WHEN SUDDENLY IT WAS LIKE SOMEONE TURNED THE IGNITION KEY TO OFF FOR ABOUT 3 SECONDS, AND THEN TURNED THE KEY BACK ON WITHOUT RESTARTING THE ENGINE. WITH ALL THE WARNING LAMPS ILLUMINATED, AND THE ENGINE AT A STALL I PULLED INTO THE EMERGENCY LANE, AND STOPPED. I THEN SHIFTED TO PARK AND ATTEMPTED TO START THE VEHICLE, WHERE IT TOOK SEVERAL ATTEMPTS TO START. THE HEADLIGHTS DID NOT STOP WORKING WHILE PULLING OVE… Look up ODI 10873136 at NHTSA ↗ ODI 11105167 · 168,000 mi SIMILAR TO MANY OTHERS, WHILE DRIVING OUR 2004 VOLVO XC90, WE HEAR A CLICK, THEN THE CLIMATE, RADIO AND WINDSHIELD WIPERS (IF ON) SHUT OFF AND THEIR DISPLAY LIGHTS BLACK OUT, THEN ANOTHER CLICK IN A FRACTION OF A SECOND AND THEY COME BACK ON. THIS WAS HAPPENING RANDOMLY, AND NOTHING ELSE WAS AFFECTED, UNTIL THIS WEEKEND, WHILE ON A TRIP. WE WERE DRIVING ON HIGHWAYS, OUTSIDE TEMP IN THE 80'S, NO RAIN, AVERAGE SPEED ABOUT 70MPH. IT HAPPENED A FEW TIMES OVER ABOUT 45 MINUTES, THEN BEGAN HAPPENING EVERY 5 MILES OR SO. WHEN I TURNED UP THE AC FAN, … Look up ODI 11105167 at NHTSA ↗ ODI 10543169 · 146,342 mi WHILE DRIVING BACK FROM WORK THE PASSENGER LOW BEAM WENT OUT. I BOUGHT A NEW BULB AND THE LIGHT STILL DID NOT WORK L THEN CHECKED. THE WIRING GOING INTO THE HEADLIGHT AND THERE WAS NO POWER FOR THE LOW BEAM HOW DOES THIS HAPPEN IT WAS BAD ENOUGH I HAD TO REPLACE THE WHOLE TRANSMISSION JUST 3MONTHS AGO AND NOW THIS I ALSO READ NONLINEAR THEY HAD PROBLEMS WITH THE TRANNYS. *TR Look up ODI 10543169 at NHTSA ↗
Service Brakes	20 ODI 10478919 · 104,789 mi MY WIFE AND I WERE DRIVING TO A FRIEND'S HOW'S WHEN SUDDENLY THE RADIO STARTED ACTING UP ,IT WOULD GO ON AND OFF . AFTER WE NOTICED THAT I SLOWED DOWN A BIT THEN ALL OF A SUDDEN MY HOLE DASH BOARD WENT OUT . I TRIED PULLING OVER BUT THE TRANSMISSION WOULD NOT RESPOND ,THEN THE DASHBOARD CAME BACK ON BUT I HAD ALL THESE WARNINGS LIKE BRAKE FAILURE ,SRS AIRBAG SERVICE URGENT , ENGINE SYSTEM SERVICE URGENT . AFTER ALL THE HAPPENS THE TRUCK DIED ,LUCKILY I WAS ABLE TO GET OFF THE ROAD BEFORE OTHER CARS HIT US .AFTER A COUPLE A MINUTES I TRIED TURN… Look up ODI 10478919 at NHTSA ↗ ODI 10500856 · 110,156 mi TODAY, WE LEARNED OUR VOLVO XC90'S YAW RATE SENSOR HAS FAILED. THE ROOT CAUSE WAS WATER LEAKING INTO THE PASSENGER SIDE OF THE CAR DUE TO BLOCKED MOONROOF (I.E. SUNROOF) DRAINS, WHICH SHORTED THE YAW RATE SENSOR. THIS IMPAIRED THE ELECTRONIC STABILITY CONTROL AND BRAKES OF OUR VOLVO, PUTTING US AT RISK OF ACCIDENT. RESEARCH SHOWS THIS IS A FREQUENT AND RECURRING PROBLEM KNOWN SINCE AT LEAST 2004. IT HAS CAUSED THOUSANDS OF DOLLARS IN DAMAGE TO NUMEROUS XC90S. VOLVO IS AWARE OF THIS ISSUE UP TO AND INCLUDING THE PRESIDENT OF VOLVO USA. EV… Look up ODI 10500856 at NHTSA ↗ ODI 10522327 · 78,244 mi WAS DRIVING IN NEIGHBORHOOD AT ABOUT 20 MPH, WHEN RADIO SHUT OFF AND THEN ALL ELECTRICAL SHUT OFF, CAR DID NOT RESPOND TO EITHER GAS OR BRAKES, THEN THERE WAS A THUMP FROM THE FRONT OF THE CAR, WHICH BROUGHT THE DASH LIGHTS BACK ON. I THEN WAS ABLE TO PULL OVER AND TURN OFF CAR. RESTARTED THE CAR AND THERE WERE A SLEW OF ERROR MESSAGES ON THE DASH, INCLUDING A BRAKE WARNING. ATTEMPTED TO CONTINUE TO DRIVE CAR, ISSUE HAPPENED AGAIN AND AGAIN ON MY DRIVE HOME. VERY UNSAFE TO BE DRIVING AND NOT SURE IF YOUR BRAKES OR STEERING ARE GOING TO CUT OUT.… Look up ODI 10522327 at NHTSA ↗	7 ODI 10478919 · 104,789 mi MY WIFE AND I WERE DRIVING TO A FRIEND'S HOW'S WHEN SUDDENLY THE RADIO STARTED ACTING UP ,IT WOULD GO ON AND OFF . AFTER WE NOTICED THAT I SLOWED DOWN A BIT THEN ALL OF A SUDDEN MY HOLE DASH BOARD WENT OUT . I TRIED PULLING OVER BUT THE TRANSMISSION WOULD NOT RESPOND ,THEN THE DASHBOARD CAME BACK ON BUT I HAD ALL THESE WARNINGS LIKE BRAKE FAILURE ,SRS AIRBAG SERVICE URGENT , ENGINE SYSTEM SERVICE URGENT . AFTER ALL THE HAPPENS THE TRUCK DIED ,LUCKILY I WAS ABLE TO GET OFF THE ROAD BEFORE OTHER CARS HIT US .AFTER A COUPLE A MINUTES I TRIED TURN… Look up ODI 10478919 at NHTSA ↗ ODI 10522327 · 78,244 mi WAS DRIVING IN NEIGHBORHOOD AT ABOUT 20 MPH, WHEN RADIO SHUT OFF AND THEN ALL ELECTRICAL SHUT OFF, CAR DID NOT RESPOND TO EITHER GAS OR BRAKES, THEN THERE WAS A THUMP FROM THE FRONT OF THE CAR, WHICH BROUGHT THE DASH LIGHTS BACK ON. I THEN WAS ABLE TO PULL OVER AND TURN OFF CAR. RESTARTED THE CAR AND THERE WERE A SLEW OF ERROR MESSAGES ON THE DASH, INCLUDING A BRAKE WARNING. ATTEMPTED TO CONTINUE TO DRIVE CAR, ISSUE HAPPENED AGAIN AND AGAIN ON MY DRIVE HOME. VERY UNSAFE TO BE DRIVING AND NOT SURE IF YOUR BRAKES OR STEERING ARE GOING TO CUT OUT.… Look up ODI 10522327 at NHTSA ↗ ODI 10938344 · 166,000 mi WHEN TRAVELING AT HIGH RATES OF SPEED (ON THE HIGHWAY) THE CAR COMPLETELY SHUTS OFF. THE DASHBOARD AND ALL ELECTRICAL SHUTS OFF, THE HAZARDS DO NOT SEEM TO WORK OR THE TURN INDICATORS, ABS DOES NOT WORK SO IT IS A VERY SLOW HEAVY STOP. THIS HAPPENED TO ME IN THIS CAR ONE OTHER TIME IN 2010, AND THERE WAS AN IMMEDIATE COMPUTER MODULE UPGRADE ISSUED. Look up ODI 10938344 at NHTSA ↗	0	7 ODI 11435895 I have installed a SprintDrive installed in my Volvo. Since the installation, I have had several safety and security issues occur that stop once the device is removed. The following issues have occurred: 1) Whilst driving on the Muskogee Turnpike, the cruising control system would disengage. This occurred at least three times during the drive. On the third time, the cruising control system disengaged and the braking system engaged causing the vehicle to go from 85 mph to 45 mph. 2) I was driving on C-470. The transmission system would not … Look up ODI 11435895 at NHTSA ↗ ODI 10861446 WHILE DRIVING ON A CITY STREET I PUT THE CAR IN ECO MODE. THE CAR WAS MOVING AT THE TIME. I NOTICED THAT THE CAR SEEMED TO BE DRIVING LOUDLY. AS I TURNED LEFT, I SAW THE CAR WAS IN MANUAL MODE AND WAS IN FIRST GEAR. SO I TOOK MY FOOT OFF OF THE BRAKE TO SLOW DOWN THE CAR AND TRY TO PUT IT INTO DRIVE. AS I TRIED TO MOVE THE GEAR SHIFTER, THE CAR CAME TO A COMPLETE, SUDDEN STOP. IT FELT LIKE ALL FOUR WHEELS WERE SUDDENLY AND IMMEDIATELY LOCKED. I COULD NOT MOVE THEM, EVEN AS I HIT THE GAS. I DID NOT SEE ANY INDICATION ON THE DASHBOARD THAT TH… Look up ODI 10861446 at NHTSA ↗ ODI 11196537 · 17,000 mi THE COLLISION AVOIDANCE SYSTEM WAS ENGAGED, I WAS DRIVING DURING A RAIN STORM AT NIGHT AT 45 MPH, AND THE COLLISION AVOIDANCE ALARM WENT OFF WITHOUT ANYTHING IN FRONT OF MY CAR, THEN THE BRAKES SLAMMED ON BY THEMSELVES AND THE CAR BEHIND ME HAD TO SWERVE ONTO THE SHOULDER TO AVOID HITTING ME IN THE REAR Look up ODI 11196537 at NHTSA ↗	1 ODI 11701873 On thanksgiving day i drove to train station in the morning, and had no issue. After work i got in the car started to drive, i was going 25-35 miles per hour in the maplewood township, and i wanted to slow down just in case i dont see any kid or person at dark. I almost had no brake! I was so scared and i pushed th brake pedal so hard, i was very dangerous for the society at this moment. I just wish i was not on the highway going higher speed, or there were no people around! I really cannot trust this car anymore, i could have hit something!!!… Look up ODI 11701873 at NHTSA ↗	5 ODI 10599097 · 90,000 mi WHILE ON THE INTERSTATE AT 60MPH, EXPERIENCED TEMPORARILY LOSS OF POWER, THE IP DISPLAYS AND AN ABNORMAL 'JERKING' IN THE TRANSMISSION/DRIVETRAIN. THE SRS AIRBAG AND BRAKE FAILURE ERROR MESSAGES APPEARED IN THE IP ERROR DISPLAY. THE WIPERS MOMENTARILY CAME ON. LIGHTS DIMMED. POWER FAILURE WAS ONLY FOR A SPLIT-SECOND (AT 60MPH) BEFORE RETURNING TO NORMAL. AFTER NORMAL POWER WAS RESTORED, ERROR MESSAGES CONTINUED TO BE SHOWN IN THE IP ERROR DISPLAY. THE BRAKE FAILURE MESSAGE INSTRUCTED ME TO PULL OVER AND BRING THE VEHICLE TO A SAFE STOP. UPO… Look up ODI 10599097 at NHTSA ↗ ODI 10872107 · 125,000 mi CAR MOVED TO RIGHT WHEN APPLYING BRAKES. CAR CLUNKS WHEN MAKING TURNS. CAR VERY NOISY WHEN GOING OVER BUMPS/ POTHOLES. Look up ODI 10872107 at NHTSA ↗ ODI 10472427 · 5 mi FROM THE BEGINNING THIS VEHICLE HAS DELAYED ACCELERATION, VERY DANGEROUS TO DRIVE WHEN PULLING OUT IN FRONT OF ON-COMING TRAFFIC, OR MAKING LEFT HAND TURN WITH ON-COMING TRAFFIC. BRAKES MAKE LOUD CRACKING POPPING SOUND WHEN BRAKING AND TURNING THE WHEEL, DO NOT FEEL SAFE WITH IT MAKING SUCH AWFUL SOUNDS. *TR Look up ODI 10472427 at NHTSA ↗	—	1 ODI 11452346 Electrical, Brake lights suddenly stopped working on both sides at once. I checked the fuse only to be told a relay may be the issue. The location of said relay is vague and not serviceable by owner. Risk of rear end collision. Of following traffic Look up ODI 11452346 at NHTSA ↗
Exterior Lighting	43 ODI 10241888 · 60,000 mi WHILE DRIVING MY 2004 VOLVO XC-90 AT NIGHT I EXPERIENCED A MOMENTARY LOSS OF CONTROL, FOLLOWED BY THE HEADLIGHTS PAUSING AND THEN GOING FROM HIGH BEAMS TO LOW. THE INSTRUMENT CLUSTER LOST SOME OF IT'S DISPLAYS AND THE DOOR LOCKS BECAME INOPERATIVE. THE DATA DISPLAY WARNED ME OF AN "URGENT SRS FAILURE". I WAS AT LOW SPEED A BLOCK FROM HOME SO I CREPT HOME AND THE NEXT DAY SENT THE CAR TO TRIAD VOLVO BY ROLL-BACK WRECKER. PROBLEM WAS FAILURE OF CENTRAL ELECTRONIC MODULE. I CALLED VOLVO CORPORATE AND THEY SEEMED DISINTERESTED. TR Look up ODI 10241888 at NHTSA ↗ ODI 10345921 · 104,365 mi ON OUR 2004 VOLVO XC90 THE HEADLIGHTS SUDDENLY WENT DARK, NO LOW OR HIGH BEAMS AT ALL. I AM NOW BEING TOLD IT IS A MODULE AND THE REPAIR COST IS IN EXCESS OF $1200. THE CAR HAS HID HEADLIGHTS. THIS OUTAGE CREATED A VERY SERIOUS SAFETY ISSUE IN THAT WE WERE DRIVING UP HIGHWAY 395 AT NIGHT WHEN THE COMPLETE FAILURE OF THE HEADLIGHTS OCCURRED. IN RESEARCHING THE ISSUE ON THE INTERNET IT APPEARS IT IS A RELATIVELY COMMON FAILURE. TR Look up ODI 10345921 at NHTSA ↗ ODI 10354896 · 169,200 mi MY HEADLIGHTS, DRIVING LIGHTS, PARK LIGHTS, AND TURN SIGNALS ARE NOT WORKING. THIS BEGAN WHEN I STARTED TO GO SOMEWHERE LAST NIGHT. ALL OF THESE THINGS WERE WORKING THE DAY BEFORE. THE TAIL LIGHTS, TURN SIGNALS, AND BRAKE LIGHTS ARE WORKING IN THE REAR. MY VEHICLE IS GARAGED WHEN IT IS NOT IN USE. MY RADIO, CD PLAYER, OR SATELLITE RADIO WOULD NOT OPERATE 2 DAYS AGO AND STARTED WORKING THE NEXT TIME I STARTED MY CAR. ABOUT 2 WEEKS AGO THE CAR WOULDN'T START. IT ACTED LIKE THE SECURITY SYSTEM HAD BEEN ACTIVATED AS IT WOULD CRANK, BUT NOT START. … Look up ODI 10354896 at NHTSA ↗	9 ODI 10490370 · 144,010 mi LAST NIGHT MY 2004 VOLVO XC90 LEFT ME ON THE SIDE OF THE ROAD INTERSTATE 88 NEAR ROCK FALLS, IL WEATHER 7:00 PM 28 HUMIDITY: 73% WIND: NNE DEW POINT: 22 PRESSURE: 30.16 IN BONE DRY WHILE DRIVING 65MPH FELT A "THUMP" IN THE FRONT END, FOLLOWED BY A SPLIT SECOND WHERE ALL DASHBOARD LIGHTS, WENT BLACK. WHILE TRYING TO PUSH THE GAS PEDAL THE CAR WOULD NOT ACCELERATE. THEN NORMAL FUNCTION RESUMED. A MINUTE OR TWO LATER, SAME THING AND ALL LIGHTS INTERNALLY COMPLETELY WENT OUT, I PULLED OVER IMMEDIATELY AND TURNED THE CAR OFF. HAZARD LIGHTS C… Look up ODI 10490370 at NHTSA ↗ ODI 10512481 · 79,000 mi I WAS DRIVING ON THE HIGHWAY AT 60 MILES AN HOUR AND THE CAR COMPLETELY SHUT OFF. NO LIGHTS, NO ENGINE, NO POWER STEERING, NO DASH LIGHTS. THE CAR WENT COMPLETELY DEAD. I PULLED OVER AND LET THE CAR REST AND THEN IT STARTED UP AGAIN. I NOTICED THE SECOND TIME IT HAPPENED WHEN I TOOK MY FOOT OFF THE ACCELERATOR. I TOOK IT TO ARBORMOTION IN ANN ARBOR MI AND THEY TOLD ME A CODE CAME UP AND SOME PART HAD TO BE CLEANED. WHEN I TOOK MY FOOT OFF THE ACCELERATOR THERE WAS NOT ENOUGH AIR GOING THROUGH THE PART TO ALLOW GAS TO FLOW. THEY FIXED THE PART A… Look up ODI 10512481 at NHTSA ↗ ODI 10584217 · 95,000 mi ON TWO SEPARATE OCCASIONS, OUR VEHICLE WOULD NOT RESTART AFTER STOPPING FOR GAS. THIS OCCURRED AFTER IT WAS SERVICED AND BATTERY REPLACED A WEEK PRIOR. AAA WAS UNABLE TO JUMP START IT AS WELL, AND VEHICLE HAD TO BE TOWED BACK TO DEALERSHIP FOR REPAIRS. ACCORDING TO THE TWO SEPARATE DEALERSHIPS, THE CENTRAL ELECTRONICS MODULE IS THE CULPRIT, AND NEEDED REPLACING. ACROSS MULTIPLE ONLINE FORUMS, VOLVO OWNERS HAVE COMPLAINED ABOUT SIMILAR PROBLEMS WITH THE CEM, OFTEN PLACING DRIVERS AND OCCUPANTS IN DANGER AS THEY EXPERIENCED COMPLETE ELECTRICAL … Look up ODI 10584217 at NHTSA ↗	1 ODI 10293742 · 79,300 mi OPERATING VEHICLE SINCE OCT '08, SINCE THAT TIME THERE HAS BEEN A NOISE EMANATING FROM FRONT PASS-SIDE WHEEL AREA. PURCHASING DEALER(HALL CHEVY, CHESAPEAKE, VA) PERFORMED WHEEL-ALIGNMENT TO "FIX" THE NOISE WHICH DID NOT REMEDY. VOLVO DEALER IN ARVADA, CO DIAGNOSED IT AS FAILED, OR FAILING WHEEL HUB, TO BE REPLACED AT COST OF $500. THIS VEHICLE ALSO HAD TRANS FAILURE AT APPX 76K MILES, AND THROTTLE CONTROL MODULE FAILURE IN OCT '09. I BELIEVE THERE ARE MANY CONCERNS ABOUT OPERATING AND HAVING CONFIDENCE IN ITS ABILITY TO OPERATE "SAFELY AND… Look up ODI 10293742 at NHTSA ↗	1 ODI 10716633 · 60,000 mi HELLO VOLVO, FOR THE RECORD, WE LOVE OUR VOLVO SUV (2004, XC90). OVER THE YEARS THE SERVICE FROM MICHELLE BALSIDE AT VOLVO ON PLAINFIELD ROAD IN CINCINNATI HAS BEEN TRULY EXCELLENT, HER CONTACT INFORMATION IS ATTACHED. HOWEVER, WE HAVE HAS AN ISSUE SINCE 2011 THAT HAS NOT BEEN RESOLVED, WHICH IS SO UNCHARACTERISTIC OF VOLVO. I AM HOPING YOU CAN HELP ME CHANGE THE OUTCOME. FOR YEARS MY HUSBANDS RIGHT HEADLIGHT HAS BEEN TURNING ON AND OFF INTERMITTENTLY. THIS IS VERY DANGEROUS WHEN HE DRIVES TO AND FROM WORK AT NIGHT ON AN OLD 4 LANE HI… Look up ODI 10716633 at NHTSA ↗	1 ODI 11457064 Well I was at a red light waiting for the light to train green when I stepped on the Excelerator pedal I heard something snapped and the car would not move anymore I try to switch gears and the car would not move at all it would just accelerate the engine will sound like Like if I had the car on Neutral. In any gear I try to shift there was no warning in the vehicle no light turned on the only light that it was turned on was the one with the check engine because of the Cadillac converter but other than that no other lights were coming out or fl… Look up ODI 11457064 at NHTSA ↗	3 ODI 10873136 · 130,000 mi 2004 VOLVO XC90 SUDDEN ENGINE STALL WITH LOSE OF HEADLIGHTS: I WAS TRAVELING ON THE INTERSTATE AT NIGHT WITH THE CRUISE SET AT 75 MPH WHEN SUDDENLY IT WAS LIKE SOMEONE TURNED THE IGNITION KEY TO OFF FOR ABOUT 3 SECONDS, AND THEN TURNED THE KEY BACK ON WITHOUT RESTARTING THE ENGINE. WITH ALL THE WARNING LAMPS ILLUMINATED, AND THE ENGINE AT A STALL I PULLED INTO THE EMERGENCY LANE, AND STOPPED. I THEN SHIFTED TO PARK AND ATTEMPTED TO START THE VEHICLE, WHERE IT TOOK SEVERAL ATTEMPTS TO START. THE HEADLIGHTS DID NOT STOP WORKING WHILE PULLING OVE… Look up ODI 10873136 at NHTSA ↗ ODI 11105167 · 168,000 mi SIMILAR TO MANY OTHERS, WHILE DRIVING OUR 2004 VOLVO XC90, WE HEAR A CLICK, THEN THE CLIMATE, RADIO AND WINDSHIELD WIPERS (IF ON) SHUT OFF AND THEIR DISPLAY LIGHTS BLACK OUT, THEN ANOTHER CLICK IN A FRACTION OF A SECOND AND THEY COME BACK ON. THIS WAS HAPPENING RANDOMLY, AND NOTHING ELSE WAS AFFECTED, UNTIL THIS WEEKEND, WHILE ON A TRIP. WE WERE DRIVING ON HIGHWAYS, OUTSIDE TEMP IN THE 80'S, NO RAIN, AVERAGE SPEED ABOUT 70MPH. IT HAPPENED A FEW TIMES OVER ABOUT 45 MINUTES, THEN BEGAN HAPPENING EVERY 5 MILES OR SO. WHEN I TURNED UP THE AC FAN, … Look up ODI 11105167 at NHTSA ↗ ODI 10543169 · 146,342 mi WHILE DRIVING BACK FROM WORK THE PASSENGER LOW BEAM WENT OUT. I BOUGHT A NEW BULB AND THE LIGHT STILL DID NOT WORK L THEN CHECKED. THE WIRING GOING INTO THE HEADLIGHT AND THERE WAS NO POWER FOR THE LOW BEAM HOW DOES THIS HAPPEN IT WAS BAD ENOUGH I HAD TO REPLACE THE WHOLE TRANSMISSION JUST 3MONTHS AGO AND NOW THIS I ALSO READ NONLINEAR THEY HAD PROBLEMS WITH THE TRANNYS. *TR Look up ODI 10543169 at NHTSA ↗	1 ODI 11452346 Electrical, Brake lights suddenly stopped working on both sides at once. I checked the fuse only to be told a relay may be the issue. The location of said relay is vague and not serviceable by owner. Risk of rear end collision. Of following traffic Look up ODI 11452346 at NHTSA ↗	—

Co-reporting does not establish that one component caused another concern.

Recurring narrative patterns

Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.

Search patterns

8 patterns with matching reports.

Warning lights and dashboard alerts

178 mentions · 11.7% of complaints

Median mileage: 89,000 mi (119 usable records).

ODI 10067880

I OWN A VOLVO XC90 T6 AWD. THIS CAR HAS HAD PROBLEMS WITH THE TWIN TURBO-CHARGERS, THE WARNING LIGHTS, A TIRE BLOWOUT, VIBRATIONS IN THE STEERING WHEEL, ALIGNMENT ISSUES, SHORT CIRCUIT IN THE DRIVER'S SIDE CONTROL PANEL, POOR FIT AND FINISH OF THE DRIVER SIDE DOOR PANEL AND A HOST OF OTHER FIT AND FINISH PROBLEMS. THE MOMENTUM VOLVO DEALERSHIP IN HOUSTON, TEXAS AND VOLVO NORTH AMERICA SERVICE REPRESENTATIVE DENIED ANY PROBLEMS BEING A SERIOUS OR RECURRING PROBLEM. THIS ALL TOOK PLACE IN A SPAN OF LESS THAN 10 MONTHS FOR A BRAND NEW VEHICLE.T…

Look up ODI 10067880 at NHTSA ↗

ODI 10068267 · 22,300 mi

RIGHT REAR WHEEL BEARING FAILED. SYMPTOMS WERE THAT THE VEHICLE WOULD NOT ACCELERATE OVER 35 MPH. DASHBOARD WARNING LIGHT INDICATED THAT VEHICLE WAS AT RISK OF TIPPING. CAR WAS STRANDED ON HIGHWAY WHILE RETURNING FROM VACATION SOME 400 MILES FROM HOME. WAS ABLE TO LIMP OFF AND INVOKE VOLVO ROADSIDE ASSISTANCE PROGRAM. VEHICLE WAS TOWED TO DEALER WITHIN 30 MINUTES. DEALER WAS UNABLE TO DIAGNOSE PROBLEM FOR 2 DAYS BECAUSE NO FAULT INFORMATION WAS PROVIDED BY ON-BOARD DIAGNOSTIC COMPUTER. INITIAL SUSPICION WAS A FUEL PRESSURE PROBLEM. DEAL…

Look up ODI 10068267 at NHTSA ↗

ODI 10165560 · 30,200 mi

WE HAD TRAVELED ABOUT 200 MILES IN THE MORNING WITH NO PROBLEMS WITH THE CAR. WE STARTED OUT AFTER LUNCH, WENT ABOUT 200 YARDS, AND SMELLED A FAINT BURNING SMELL WE THOUGHT WAS OUTSIDE THE CAR. AFTER ABOUT ANOTHER 200 YARDS, WE WERE AT A TOLL BOOTH ENTERING THE THROUGH WAY, AND THE BRAKES DID NOT RESPOND PROPERLY; THERE WAS NO WARNING LIGHT. WE PULLED OVER IMMEDIATELY, AND THERE WAS SMOKE UNDER THE DASHBOARD. WE GOT OUT. WITHIN FIVE MINUTES THE CAR WAS TOTALLY ENGULFED IN FLAMES, DESPITE ATTEMPTS TO PUT IT OUT WITH FIRE EXTINGUISHERS. CA…

Look up ODI 10165560 at NHTSA ↗

Matching rule

\b(warning light\w*|check engine|dashboard warning\w*|malfunction indicator)\b

Stalling or loss of power

125 mentions · 8.2% of complaints

Median mileage: 97,500 mi (106 usable records).

ODI 10213488 · 45,000 mi

TL*THE CONTACT OWNS A 2003 VOLVO XC90. WHILE DRIVING 55MPH, THE VEHICLE SUDDENLY LOST POWER WHILE MERGING BETWEEN TWO LARGE VEHICLES. THE ACCELERATOR PEDAL WOULD NOT RESPOND WHEN HE TRIED TO ENGAGE IT. THE DEALER STATED THAT THE REAR DIFFERENTIAL, THE THROTTLE AND THE DISC BRAKES FAILED. THE PURCHASE DATE WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 45,000.

Look up ODI 10213488 at NHTSA ↗

ODI 10243918 · 50,000 mi

2003 VOLVO XC90 - TRANSMISSION FAILURE @ ~ 30,000. RESULTING IN LOSS OF POWER AND ACCELERATION. TRANSMISSION WAS REPLACED UNDER WARRANTY. AT ~80,000 WAS INFORMED THAT TRANSMISSION WAS AGAIN FAILING (DURING ROUTINE SERVICE) AND AGAIN NEEDED TO BE REPLACED. *TR

Look up ODI 10243918 at NHTSA ↗

ODI 10314570 · 62,000 mi

TL*THE CONTACT OWNS A 2003 VOLVO XC90. WHILE DRIVING AT SPEEDS OF 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. HE ATTEMPTED TO RESTART THE VEHICLE SUCCESSFULLY BUT BEFORE HE COULD MOVE THE VEHICLE, IT STALLED AGAIN. THE "MAINTENANCE REQUIRED" WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AT THAT TIME. THE CONTACT WAS AWAITING A TOW TO THE DEALER FOR FURTHER INSPECTION. NO REPAIRS WERE MADE TO DATE AND THE MANUFACTURER HAD NOT BEEN CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE UNDER 62,000.

Look up ODI 10314570 at NHTSA ↗

Matching rule

\b(stall\w*|loss of power|lost power|engine shut\w* off)\b

Brake response concerns

64 mentions · 4.2% of complaints

Median mileage: 78,500 mi (49 usable records).

ODI 10213488 · 45,000 mi

Look up ODI 10213488 at NHTSA ↗

ODI 10233490 · 49,271 mi

TL*THE CONTACT OWNS A 2003 VOLVO XC90. ON JUNE 10, 2008, WHILE DRIVING AT AN UNKNOWN SPEED AND APPROACHING A STOP SIGN, THE CONTACT HEARD A LOUD NOISE. SHORTLY AFTERWARDS, THE BRAKES FAILED TO RESPOND; HOWEVER, SHE WAS ABLE TO BRING THE VEHICLE UNDER CONTROL WITH THE EMERGENCY BRAKE. THE CONTACT SLOWLY DROVE THE VEHICLE TO THE DEALER AND THEY DIAGNOSED THE FAILURE AS THE BRAKE BOOSTER POWER CYLINDER. THE MANUFACTURER WAS NOTIFIED; HOWEVER, THEY DECLINED TO ASSIST WITH THE $1,036.44 REPAIR COST. THE FAILURE AND CURRENT MILEAGES WERE 49,271.…

Look up ODI 10233490 at NHTSA ↗

ODI 10128609 · 6,800 mi

1) 7,500 MILE CHECKUP (UNDER 7,000 MILES ON CAR) 2) CHECK ENGINE LIGHT KEEPS ACTIVATING. THIS STARTED ON TUESDAY. I ONLY USE PREMIUM GASOLINE IN CAR. 3) RECEIVED ''ANTI-SKID SERVICE REQUIRED'' MESSAGE WITH YELLOW INDICATOR LIGHT REMAINING ON. THIS HAPPENED ON TUESDAY AND LATER DISAPPEARED AFTER DRIVING THE CAR AGAIN. 4) THERE IS A PROBLEM WITH THE GEARSHIFT INDICATOR. WHEN I CHANGE GEARS FROM PARK TO ANYTHING ELSE, THE DISPLAY PANEL IS EITHER BLANK OR IT SHOWS AN INCORRECT GEAR '' IT WILL SHOW NEUTRAL WHEN I AM IN DRIVE OR REVERSE. ALSO IN A…

Look up ODI 10128609 at NHTSA ↗

Matching rule

Hard or delayed shifting

59 mentions · 3.9% of complaints

Median mileage: 86,500 mi (48 usable records).

ODI 10289340 · 116,000 mi

I PURCHASED MY 2003 VOLVO XC90 IN APRIL OF 2005 WITH 36K MILES. FOR THE LAST 3 YEARS, I HAVE COMPLAINED ON VARIOUS ISSUES WITH THE CAR'S PERFORMANCE RELATED TO THE VEHICLE'S TRANSMISSION. PULLING AND JERKING OF THE CAR WHEN I PROCEED TO ACCELERATE, SLOW ACCELERATION FROM STOP, NOT BEING ABLE TO PUT THE CAR IN REVERSE, CAR ONLY WANTING TO DRIVE IN THIRD GEAR, AND A HIGH PITCH NOISE. FROM OCT 05 TO MARCH 2008 I MADE 8 VISITS TO THE DEALER REGARDING THESE ISSUES FOR WHICH I WAS BLOWN OFF AND TOLD THAT UNLESS THE LIGHT APPEARED THEY COULD NOT RE…

Look up ODI 10289340 at NHTSA ↗

ODI 10372067 · 58,000 mi

TL* THE CONTACT OWNS A 2003 VOLVO XC90. THE CONTACT WAS DRIVING APPROXIMATELY 55-65 MPH WHEN THE TRANSMISSION BEGAN TO JERK WITH EXCESSIVE HESITATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TRANSMISSION WAS REPLACED FOR THE THIRD TIME. THE MANUFACTURER WAS NOTIFIED OF THE TRANSMISSION FAILURES BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. UPDATED 07/20/11 *BF UPDATED 10/26/11

Look up ODI 10372067 at NHTSA ↗

ODI 10470810 · 500 mi

TL* THE CONTACT OWNS A 2003 VOLVO XC90. THE CONTACT STATED THAT THE VEHICLE WOULD JERK ABNORMALLY AND WITHOUT WARNING. IN ADDITION, THE SHIFT GEAR LEVER WAS DEFECTIVE AND BOTH THE POWER STEERING FLUID AND TRANSMISSION FLUIDS WERE LEAKING. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THE VEHICLE AGE HAD EXCEEDED THE TIME FRAME IN WHICH THEY WERE WILLING TO OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY AND OFFERED NO ADDITIONAL ASSISTANC…

Look up ODI 10470810 at NHTSA ↗

Matching rule

Steering assistance concerns

38 mentions · 2.5% of complaints

Median mileage: 84,500 mi (34 usable records).

ODI 10075750 · 31,000 mi

WHILE BACKING PUT OF A PARKING LOT POWER STEERING FAILED, VEHICLE SMOKED THEN CAUGHT ON FIRE. DRIVER SUFFERED FROM SMOKE INHALATION. *AK PRIOR TO THE VEHICLE CATCHING ON FIRE THE CONSUMER WAS INVOLVED IN AN ACCIDENT THE YEAR BEFORE (JULY 12, 2003). THE CONSUMER WAS PRESSING ON THE HORN WHEN THE CRASH OCCURRED. THE CONSUMERS HAND WAS ON THE WHEN THE AIR BAG DEPLOYED. THE DRIVER SUSTAINED SEVERAL BROKEN ONES IN HER RIGHT HAND WHICH REQUIRED 2 SURGERIES, EXTENSIVE PHYSICAL THERAPY AND MANY OTHER MEDICAL PROCEDURES. *NM *LA

Look up ODI 10075750 at NHTSA ↗

ODI 10217704 · 56,627 mi

TL*THE CONTACT'S CUSTOMER OWNS A 2003 VOLVO XC90. THE CONTACT STATED THAT THE VEHICLE WAS INITIALLY BROUGHT INTO HIS SHOP DUE TO A LEAK IN THE POWER STEERING PUMP. THE CONTACT REPLACED THE POWER STEERING PUMP PURCHASED FROM A DEALER. THE CUSTOMER RETRIEVED THE VEHICLE AND, APPROXIMATELY 3 WEEKS LATER, IT SHUT OFF WITHOUT WARNING WHILE DRIVING. THE DEALER HAS BEEN NOTIFIED. THE SPEED WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 56,627.

Look up ODI 10217704 at NHTSA ↗

ODI 10467784 · 118,813 mi

WHILE DRIVING HOME FROM SCHOOL THE WINDSHIELD WIPERS AUTOMATICALLY CAME ON AND ABOUT THE SAME TIME THE BATTERY LIGHT AND ELECTRICAL WARNING SIDE CAME ON. IT ALSO AFFECTED THE POWER STEERING AND AIR CONDITION. HAD TO PULL OVER ON A BUSY STREET WHICH WAS NOT EASY. HAD THE BATTERY TESTED AND IT WAS GOOD, REPLACED IT 15 MONTHS AGO. CAR IS STILL SITTING IN THE GARAGE! *TR

Look up ODI 10467784 at NHTSA ↗

Matching rule

\b(power steer\w*|steering assist\w*|steering lock\w*|steering wheel lock\w*)\b

Fuel smell or leak mentions

36 mentions · 2.4% of complaints

Median mileage: 115,000 mi (26 usable records).

ODI 10303931 · 150,000 mi

CRACKED FUEL PUMP. STRONG GAS SMELL. THERE WAS A RECALL FOR SEVERAL VOLVOS. MY PARTICULAR VOLVO WAS NOT ON THE RECALL LIST. I'M EXPERIENCING THE SAME PROBLEMS AS THE OTHER 136,000 RECALLED VOLVOS FOR CRACKED FUEL PUMPS. I SURE THERE ARE SEVERAL OUT THERE. PLEASE EXTEND THE RECALLED VEHICLES. *TR

Look up ODI 10303931 at NHTSA ↗

ODI 10203720 · 56,252 mi

WHILE THE CAR WAS PARKED IN THE GARAGE THERE WAS AN OVERWHELMING SMELL OF GASOLINE. I TOOK THE CAR TO MY MECHANIC. THEY OBSERVED A FUEL LEAK COMING FROM FUEL PUMP HOUSING. A NEW FUEL PUMP WAS INSTALLED. *TR

Look up ODI 10203720 at NHTSA ↗

ODI 10242480 · 49,985 mi

IN MARCH OF 2008 I NOTICED A STRONG ODOR OF GASOLINE IN THE GARAGE WERE THE VEHICLE WAS STORED. THIS ODOR HAD ALSO PERMEATED THROUGH OUT THE INTERIOR OF THE VEHICLE. CHECKED VEHICLE FOR FUEL LEAKS AND COULD NOT DETERMINE SOURCE DUE TO QUICK EVAPORATION OF FUEL. ON MARCH 17, 08 LOCAL DEALER FOUND LEAK AT TOP OF FUEL TANK UNDER 2ND ROW SEATS. REPLACED FUEL PUMP AND "FAULTY" LEVEL SENSOR. ON MARCH 27, 08 I RETURNED VEHICLE TO DEALER WITH SAME PROBLEM. THEY TRIED TO PACIFY ME BY SAYING IT WAS RESIDUAL ODOR AND WOULD GO AWAY WITH TIME. AFTER…

Look up ODI 10242480 at NHTSA ↗

Matching rule

\b(fuel leak\w*|gas leak\w*|gas(?:oline)? smell|smell\w* (?:of )?(?:fuel|gas))\b

Oil consumption or dilution

32 mentions · 2.1% of complaints

Median mileage: 77,000 mi (4 usable records).

ODI 11449685

My car has begun to burn excessive oil. I am having to use 1 quart of oil every 1,000 miles. This is in addition to getting a routine oil change. Took vehicle to Volvo dealership for an oil consumption test, cost around $550, and had to drive 1245 miles and then bring car back. Brought car back and dealership confirmed car is using/burning excessive oil. Issue is with the o rings and gaskets needing to be replaced. Employee at dealership said this is known issue with the 2016 model burning excessive oil. Many threads online relating/repo…

Look up ODI 11449685 at NHTSA ↗

ODI 11456338

Engine oil Level decreases rapidly, this can cause the engine to burn up and possibly catch file or lock the engine. Dealer has started oil consumption test.

Look up ODI 11456338 at NHTSA ↗

ODI 11464980

The issue began in April 2021, the engine burns oil and empties out every 1,500 or less. Contacted Volvo corp & dealership several times. Have gotten two things repaired by Volvo indicating those were the root issue of the oil consumption, not the case, continues to burn oil. Was told by the dealer that I have to continue to drive the vehicle until the low oil comes on for them to re-check the engine. Not sure if they want me to crack the engine while I drive for them to realize this is a serious issue.

Look up ODI 11464980 at NHTSA ↗

Matching rule

\b(oil consumption|burn\w* oil|consum\w* oil|oil dilution|gas(?:oline)? in (?:the )?oil)\b

Battery drain and no-start mentions

18 mentions · 1.2% of complaints

Median mileage: 77,010 mi (15 usable records).

ODI 10129509 · 10,400 mi

WE LEASED OUR VOLVO XC90-T ALMOST EXACTLY 1 YEAR AGO TO DATE FROM SOUTH COUNTY VOLVO. LESS THAN 3 MONTHS LATER, THE CAR WOULDN'T START. THEY SAID THAT MY WIFE MUST HAVE LEFT A LIGHT ON; THE BATTERY WAS RECHARGED AND WE TOOK THE CAR BACK. 2 MONTHS LATER, THE CAR AGAIN WOULD NOT START; AGAIN IT WAS TOWED-BACK TO THE DEALERSHIP. THIS TIME, THEY SAID THE BATTERY WAS BAD. THE THIRD TIME THEY SAID THERE WAS BAD SWITCH WHICH CONTROLS THE LIGHTS AND THAT WAS CHANGED. ON THE FOURTH OCCASION, WHICH INCIDENTALLY OCCURRED EXCATLY ONE YEAR LATER ON JULY 7TH…

Look up ODI 10129509 at NHTSA ↗

ODI 10141594 · 24,600 mi

I PARKED MY VEHICLE IN MY DRIVEWAY ON THE EVENING OF FRIDAY, AUGUST 12, 2005. I LEFT ON VACATION THE FOLLOWING MORNING LEAVING MY VEHICLE IN THE DRIVEWAY. I RETURNED FROM VACATION LATE ON THE EVENING OF AUGUST 21, 2005. THE FOLLOWING MORNING WHEN I WENT OUT TO LEAVE FOR WORK, THE VEHICLE WOULD NOT START. I CALLED AAA IN ORDER TO HAVE THE CAR JUMPED. IT WOULD NOT JUMP. I THEN CALLED THE VOLVO DEALERSHIP AND THEY TOLD ME TO CALL THE VOLVO HOT LINE FOR A TOW. THE VEHICLE WAS TOWED TO THE GENGRAS VOLVO DEALERSHIP IN EAST HARTFORD, CT ON THE M…

Look up ODI 10141594 at NHTSA ↗

ODI 10170449 · 33,000 mi

2004 XC90 HAS HAD THREE COMPUTER/ELECTRICAL PROBLEMS, PERHAPS RELATED. URGENT MESSAGE APPEARS ON PANEL, "SRS NEEDS ATTENTION - URGENT". CAR TAKEN TO DEALER WITH MESSAGE ACTIVE, DEALER UNABLE TO DIAGNOSE PROBLEM, RESETS SYSTEM. 3 MONTHS LATER, SRS MESSAGE REAPPEARS, CAR WON'T START, NO LIGHTS OR OTHER ACCESSORIES LEFT ON. BATTERY DIAGNOSED AS DEAD, REPLACED, SRS MESSAGE CLEARS WITH NEW BATTERY. 3 MONTHS LATER, SRS MESSAGE REAPPEARS, TWO CONTROL MODULES REPLACED. *JB

Look up ODI 10170449 at NHTSA ↗

Matching rule