Winnebago REVEL problems and owner complaints

THERE IS AN EXISTING RECALL ON THIS VEHICLE (NHTSA CAMPAIGN 20V-474) FROM AUGUST 12 2020. I TOOK DELIVERY OF MY VEHICLE AFTER THIS DATE AND WAS TOLD MY VIN WAS NOT AFFECTED. IN TWO CALLS TO WINNEBAGO CUSTOMER SERVICE THEY ALSO CLAIM MY VEHICLE IS UNAFFECTED AND WAS REPAIRED PRIOR TO SALE. HOWEVER, MY ALTERNATOR BELT IS CLEARLY MISALIGNED AND IS RESULTING IN SIGNIFICANT SQUEALING WHEN THE ENGINE IS RUNNING. I HAVE COMPARED MY VEHICLE WITH THE POSTED PHOTOS AND INFORMATION REGARDING THE FIX PROVIDED BY THE MANUFACTURER AND POSTED ON THE NHTS…

Look up ODI 11387741 at NHTSA ↗

This is a Sprinter van finished by Winnebago into the 2022 Revel 44E SN 15219109. We have 1,500 miles on van and took delivery three weeks ago. Friday 9/17/21 While driving the van at highway speed in Massachusetts on I495, we detected an acrid burning smell and the van quickly filled with smoke. We were able to pull over, shut down the vehicle and open the doors. We found in the rear compartment where the lithium battery system is located a damaged/melted connection. It appears the bolt/nut connecting the wire from the alternator charging syst…

Look up ODI 11433566 at NHTSA ↗

Winnebego Revel BMB44E 15B443122871; The Lithionics battery installation allows movement which has caused fraying of insulation on a wire and resulting in a spark and activation of the 250A circuit breaker. This is part of the Winnebego aftermarket build of the Mercedes Sprinter based camper van.

Look up ODI 11548759 at NHTSA ↗

Our brand new 2024 Winnebago Revel was smoking/caught fire from the lithium house battery while driving from Washington state to Alaska. The incident occurred right before US customs on the highway to Alaska. House power failed while driving so we pulled over to diagnose the issue, when attempting to restore power to the vehicle, the positive terminal of the battery began smoking/caught fire. I immediately cut off the breaker and the alternator disconnect. Since the lithium battery is so large this could have spread and burned the entire vehicl…

Look up ODI 11608762 at NHTSA ↗

The contact owns a 2020 Winnebago Revel RV built on a 2020 Mercedes-Benz Sprinter 2500 chassis. The contact stated that while driving approximately 20 MPH, the retractable awning erroneously extended and detached from the RV. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not notified. The contact was concerned that the failure could have occurred while driving on a freeway. The failure mileage was 6,000. The contact stated that they are …

Look up ODI 11490327 at NHTSA ↗

The contact owns a 2021 Winnebago Revel built on a 2020 Mercedes- Benz Sprinter Chassis. The contact stated that while driving approximately 45 MPH, a load noise was heard coming from the vehicle and suddenly the passenger’s side awning inadvertently deployed and extended out from the vehicle. The cause of the failure was not yet determined. The manufacturer was notified of the failure but no assistance was offered. The local dealer was not contacted. The failure mileage was 24,000.

Look up ODI 11487708 at NHTSA ↗

The contact owns a 2023 Winnebago Revel built on a 2022 Mercedes-Benz Sprinter chassis. The contact stated that the awning alarm was chiming every 30 seconds. The contact disconnected the awning fuse to stop the alarm from chiming. The vehicle was taken to the dealer, where an unknown repair was performed; however, the failure recurred. The contact later received notification of NHTSA Campaign Number: 22V863000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the dealer had exceeded a reasonab…

Look up ODI 11524644 at NHTSA ↗

The contact owns a 2021 Winnebago Revel built on a 2020 Mercedes- Benz Sprinter Chassis. The contact stated that while driving approximately 45 MPH, a load noise was heard coming from the vehicle and suddenly the passenger’s side awning inadvertently deployed and extended out from the vehicle. The cause of the failure was not yet determined. The manufacturer was notified of the failure but no assistance was offered. The local dealer was not contacted. The failure mileage was 24,000.

Look up ODI 11487708 at NHTSA ↗

Our brand new 2024 Winnebago Revel was smoking/caught fire from the lithium house battery while driving from Washington state to Alaska. The incident occurred right before US customs on the highway to Alaska. House power failed while driving so we pulled over to diagnose the issue, when attempting to restore power to the vehicle, the positive terminal of the battery began smoking/caught fire. I immediately cut off the breaker and the alternator disconnect. Since the lithium battery is so large this could have spread and burned the entire vehicl…

Look up ODI 11608762 at NHTSA ↗

Secondary alternator failed. A known problem with the Sprinters.

Look up ODI 11661203 at NHTSA ↗

My engine’s cooling fan blade and clutch assembly became unscrewed from its belt-driven shaft. Once unscrewed, the assembly was suspended at its hub by 2 cables to the engine, one mechanical and one electrical. The suspended and swinging assembly then damaged the fan’s threaded shaft mount and the vehicle’s radiator. In other reported cases*, damage has also occurred to the radiator shroud, drive belts or other critical engine parts. Thankfully, in my case the failure occurred near my home on a quiet neighborhood street at low speed. Once I lo…

Look up ODI 11532882 at NHTSA ↗

The contact owned a 2023 Mercedes-Benz Sprinter 2500. The contact stated that while driving at 25 MPH, the vehicle hesitated upon depression of the accelerator pedal. The contact then heard a hose burst, followed by white steam emitting from the engine. The contact then heard a second burst, and upon inspection of the vehicle, the contact discovered a fire in the engine compartment. The contact called 911, and the fire was extinguished by a local fire department. No injuries were reported, and a police report was not filed. The vehicle was towe…

Look up ODI 11726284 at NHTSA ↗

My Van is a Winnebago Revel and I received a Winnebago recall # 24V-318. Called Meyers RV of SYR, last week and was told to bring in vehicle. Today I called Meyers to confirm that I'd bring in on 12/18/24. Rachel and service manager at Meyers now tells me it is a Mercedes Sprinter repair. MB denies it, and after going back and forth 3 times I call Winnebago National Service. National service rep Lonnie states it is Winnebago recall and to look up technical bulletin. Meyers still refuses and I go back to Winnebago national. National states di…

Look up ODI 11631062 at NHTSA ↗

The contact owns a 2022 Winnebago Revel. The contact stated that while driving at approximately MPH 40 the Winnebago crashed into the rear of a second vehicle which caused two additional vehicles ahead to be rear-ended and a third vehicle to crash into the rear of the Winnebago. During the crash, the Winnebago sustained severe front-end damage but the air bags did not deploy. No injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The local dealer and manufac…

Look up ODI 11576532 at NHTSA ↗

Our 2020 Sprinter (Winnebago Revel) currently has 13,212 miles on it. During our ownership we have experienced about(?) 12 failures of the Advanced Driver Assistance System, during our last trip of ≈1400 miles we experience this failure twice, both occurring while driving on a state highway while being passed in the opposite direction by on-coming traffic. This trip triggered a memory of at least one previous failure that also occurred while being passed in the opposite direction by on-coming traffic. When this failure happens the cruise contro…

Look up ODI 11542979 at NHTSA ↗

Our 2020 Sprinter (Winnebago Revel) currently has 13,212 miles on it. During our ownership we have experienced about(?) 12 failures of the Advanced Driver Assistance System, during our last trip of ≈1400 miles we experience this failure twice, both occurring while driving on a state highway while being passed in the opposite direction by on-coming traffic. This trip triggered a memory of at least one previous failure that also occurred while being passed in the opposite direction by on-coming traffic. When this failure happens the cruise contro…

Look up ODI 11542979 at NHTSA ↗

THERE IS AN EXISTING RECALL ON THIS VEHICLE (NHTSA CAMPAIGN 20V-474) FROM AUGUST 12 2020. I TOOK DELIVERY OF MY VEHICLE AFTER THIS DATE AND WAS TOLD MY VIN WAS NOT AFFECTED. IN TWO CALLS TO WINNEBAGO CUSTOMER SERVICE THEY ALSO CLAIM MY VEHICLE IS UNAFFECTED AND WAS REPAIRED PRIOR TO SALE. HOWEVER, MY ALTERNATOR BELT IS CLEARLY MISALIGNED AND IS RESULTING IN SIGNIFICANT SQUEALING WHEN THE ENGINE IS RUNNING. I HAVE COMPARED MY VEHICLE WITH THE POSTED PHOTOS AND INFORMATION REGARDING THE FIX PROVIDED BY THE MANUFACTURER AND POSTED ON THE NHTS…

Look up ODI 11387741 at NHTSA ↗

The secondary alternator on our 2023 Winnebago Revel failed and caught fire. Fortunately, it happened when the vehicle was stopped so the fire was quickly put out and the damage limited to the alternator itself and the belt that ran the alternator. Had the failure happened in motion, a broken belt could have completely disabled the van, possibly endangering other traffic. Had we not noticed and extinguished the fire immediately, it could have consumed the entire vehicle and spread to the surroundings. This issue of faulty secondary alternators …

Look up ODI 11690023 at NHTSA ↗