Airstream INTERNATIONAL CCD recalls by model year
Explore the records behind recurring owner reports.
Key facts
12 owner complaints analyzed
2 distinct recall campaigns
14,000 mi median reported failure mileage
Scope: 2003 to 2005 model years. Data updated: . 4 complaints include usable failure mileage. View data status.
Recalls by model year
All campaigns in the snapshot affecting each model year, including recalls announced years later.
Recall campaigns
Shared campaigns appear once in each affected model year.
| Category | Count |
|---|---|
| 2003 | 1 |
| 2004 | 2 |
| 2005 | 1 |
2003: 1; 2004: 2; 2005: 1
Year-by-year records
Recall history
2 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
03V464000 · Equipment:Recreational Vehicle/Trailer
Reported: 2003-11-12 (November 12, 2003) · Model years: 2003, 2004
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR AIRSTREAM AT 937-596-6111.
NHTSA campaign record ↗04V506000 · Suspension:Front:Wheel Bearing
Reported: 2004-10-25 (October 25, 2004) · Model years: 2004, 2005
ON CERTAIN MOTORHOMES, THE OUTER WHEEL BEARING IN THE HUB OF THE AXLE MAY FAIL, LEADING TO UNEXPECTED SEPARATION OF THE WHEEL FROM THE AXLE. THIS FAILURE MAY BE DUE TO AN INADEQUATE AMOUNT OF GREASE IN THE HUB ASSEMBLY OR THE GREASE IN THE HUB MAY BREAK DOWN UNDER NORMAL OPERATING CONDITIONS INTO A LIQUID THAT INADEQUATELY LUBRICATES THE OUTER BEARING. INADEQUATE LUBRICATION OF THE OUTER BEARING CAN BEGIN A CHAIN OF EVENTS THAT COULD LEAD TO WHEEL SEPARATION.
Consequence: SEPARATION OF ONE OR MORE WHEELS FROM THE TRAILER COULD CAUSE THE TRAILER TO HANDLE ERRATICALLY OR GO OUT OF CONTROL. A LOST WHEEL COULD ALSO STRIKE AN ONCOMING OR FOLLOWING VEHICLE CAUSING A CRASH, RESULTING IN SERIOUS INJURY OF DEATH TO THOSE INVOLVED.
Remedy: DEALERS WILL REPAIR THE UNIT AND REMOVE THE WHEELS, INSPECT THE HUBS, INNER AND OUTER BEARINGS, RACES AND GREASE SEALS. IF NECESSARY, REPLACE PARTS AND REPACK THE WHEEL BEARING WITH HIGH TEMPERATURE GREASE AND REINSTALL THE HUB AND WHEELS. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT AIRSTREAM AT 1-877-596-6505.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
12 unique complaints in this selection. Analysis snapshot: 2026-10-01.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 2003 | 2004 | 2005 |
|---|---|---|---|
| Structure:Frame And Members | 583.3%ODI 10361211'03 AIRSTREAM 22FT. INT. CCD FRAME FAILURE. MY RECENTLY PURCHASED AS TRAILER HAS MAJOR DEFECTS IN THE FRAME DESIGN. THE OUTRIGGERS HAVE SAGGED AND CRACKED THE FRAME. THE FRAME IS BUCKLED BEHIND THE REAR AXEL AND DROPPED THE ENTIRE REAREND. THE OUTRIGGERS BEHIND THE REAR AXEL HAVE CRACKED AT THE WELD. THERE ARE 83+ COMPLAINTS ON THE AIRSTREAM OWNERS COMMUNITY FORUM. AS HAS ADMITTED THERE IS A PROBLEM AND SENT, REPAIR KITS TO NUMEROUS OWNERS, INCLUDING ME. I KNOW OF AT LEAST ONE OWNER THAT HAD HIS FRAME REPLACED BY AS AND NOW IT'S DOING THE SAME … | 133.3%ODI 10413356 · 20,000 miTL* THE CONTACT OWNS A 2004 AIRSTREAM INTERNATIONAL CCD TRAILER. THE CONTACT STATED THAT THE OUT RIGGERS WERE PUTTING PRESSURE ON THE FRAME AND CAUSING IT TO CRACK. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE THE FAILURE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS AWAITING A RESPONSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 20,000. THE VIN WAS UNAVAILABLE. | 133.3%ODI 11513027The contact owns a 2005 Airstream International CCD. The contact stated that while driving at an undisclosed speed, the floor and outriggers were sagging due to cracks in the subframe. The trailer was towed to the dealer, where it was inspected by a welder. The welder removed the skirts and determined that the main frame support beam had a linear defect in the rectangular tubing and complete separation in parts of the subframe. The trailer was not repaired. The manufacturer was made aware of the failure and had the trailer was towed to the deal… |
| Air Bags:Knee Bolster | 00.0%No examples available for this selection. | 133.3% | 00.0%No examples available for this selection. |
| Equipment:Mechanical:Integrated Jack/Leveler/Stabilizer | 00.0%No examples available for this selection. | 133.3% | 00.0%No examples available for this selection. |
| Service Brakes, Hydraulic | 00.0%No examples available for this selection. | 133.3%ODI 10087503WHILE PULLING A TRAILER AND DRIVING AT 55 MPH UP A HILL CONSUMER WAS INFORMED THAT HE HAD A FLAT TIRE ON THE TRAILER. CONSUMER EXAMINED THE FLAT TIRE, AND SAW NO DAMAGE, BUT DID NOTICE THAT THE HUB OF THE WHEEL WAS BURNT. CONSUMER FELT THE BURNT SPOT AND IT WAS HOT TO TOUCH. DEALER EXAMINED THE VEHICLE,E AND FOUND THAT THE BRAKES HAD BURNED UP. *AK *NM | 00.0%No examples available for this selection. |
| Structure:Body | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10809210 · 5,000 miFRAME FAILURE , SIGNS OF OUTRIGGERS SHOW CRACKS IN WHEEL WELL. |
| Tires:Sidewall | 116.7%ODI 10166641SIDE WALL TIRE BLOW OUT ON A GOODYEAR TRAILER TIRE ST 225/75/15 MARATHON. PROPER INFLATION AND NOT OVER LOADED TIRE HAD MAYBE 6000 MILES ON IT AND WAS ONE YEAR OLD. *JB | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Trailer Hitches | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10170699DT*: THE CONTACT STATED THE HITCH TRAILER CAUGHT ON FIRE AND THE ELECTRIC MOTOR BURNED UP. THERE WERE NO WARNING SIGNAL PRIOR TO THE FIRE. THE TRAILER HAS NOT BEEN TO A SERVICE DEALER.*AK |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| Structure:Frame And Members | Too few reports for a range | 18,000 mi | 3 (sparse) | ODI 10412162 · 18,000 mi2003 AIRSTREAM 22' TRAVEL TRAILER HAD LEAKING, FLOOR DETERIORATING, AND TOOK TO A REPAIR SHOP. UPON CHECKING, ALL OUTRIGGERS HAVE FAILED AND CRACKED, FRAME IS TWISTING AT REAR DUE TO OUTRIGGER FAILURE. DID NOT REALIZED THIS UNTIL FLOOR WAS REMOVED FOR REPAIR. *TR ODI 10413356 · 20,000 miTL* THE CONTACT OWNS A 2004 AIRSTREAM INTERNATIONAL CCD TRAILER. THE CONTACT STATED THAT THE OUT RIGGERS WERE PUTTING PRESSURE ON THE FRAME AND CAUSING IT TO CRACK. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE THE FAILURE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS AWAITING A RESPONSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 20,000. THE VIN WAS UNAVAILABLE. |
| Structure:Body | Too few reports for a range | 5,000 mi | 1 (sparse) | ODI 10809210 · 5,000 miFRAME FAILURE , SIGNS OF OUTRIGGERS SHOW CRACKS IN WHEEL WELL. |
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 | 0 | None | No examples available for this selection. |
| 2026-10 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2004: 2 complaints · 2005: 1 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2004 | 1 | 1 | 2 |
| 2005 | 0 | 1 | 1 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2004 | 3 | 0 | 0 |
| 2005 | 3 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component | Structure:Frame And Members | Air Bags:Knee Bolster | Equipment:Mechanical:Integrated Jack/Leveler/Stabilizer | Service Brakes, Hydraulic | Structure:Body | Tires:Sidewall | Trailer Hitches |
|---|---|---|---|---|---|---|---|
| Structure:Frame And Members | — | 0 | 0 | 0 | 0 | 0 | 0 |
| Air Bags:Knee Bolster | 0 | — | 1 | 0 | 0 | 0 | 0 |
| Equipment:Mechanical:Integrated Jack/Leveler/Stabilizer | 0 | 1 | — | 0 | 0 | 0 | 0 |
| Service Brakes, Hydraulic | 0 | 0 | 0 | — | 0 | 0 | 0 |
| Structure:Body | 0 | 0 | 0 | 0 | — | 0 | 0 |
| Tires:Sidewall | 0 | 0 | 0 | 0 | 0 | — | 0 |
| Trailer Hitches | 0 | 0 | 0 | 0 | 0 | 0 | — |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.