Chevrolet CITATION recalls by model year

Reported: 1979-03-22 (March 22, 1979) · Model years: 1980

VEHICLES DO NOT COMPLY TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "ANCHORAGE OF SEATS". THE LOCK BAR IN THE FRONT SEAT ADJUSTER ASSEMBLIES MAY NOT ENGAGE PROPERLY AND THE ABILITY OF THE SEAT ADJUSTER TO MAINTAIN THE SEAT IN A LATCHED POSITION DURING AN ACCIDENT MAY BE REDUCED.

Remedy: BOTH FRONT SEAT ADJUSTER ASSEMBLIES WILL BE REPLACED AT NO CHARGE TO OWNER.

Reported: 1979-04-05 (April 5, 1979) · Model years: 1980

THERE IS A POTENTIAL FOR INTERFERENCE BETWEEN THE CLUTCH CONTROL CABLE AND BRAKE PIPE IN THE MASTER CYLINDER. THIS CAN RESULT IN RUBBING CONTACT WHEN THE CLUTCH PEDAL IS OPERATED. ALSO, THE BRAKE PIPE CLEARANCE TO THE TRANSMISSION CASE MAY BE INADEQUATE. IF THIS CONDITION EXISTS, IT COULD EVENTUALLY RESULT IN A FAILURE IN THE BRAKE PIPE, CAUSING LOSS OF BRAKE FLUID AND PARTIAL LOSS OF BRAKING ACTION.

Remedy: THE CLUTCH CABLE ROUTING WILL BE REVISED TO PREVENT CONTACT WITH THE MASTER CYLINDER, WITHOUT CHARGE.

Reported: 1979-04-05 (April 5, 1979) · Model years: 1980

FUEL HOSES MAY BE INCORRECTLY POSITIONED AND CONTACT THE RIGHT FRONT DRIVE AXLE BOOT DURING VEHICLE OPERATION. AFTER A PERIOD OF TIME, THE ROTATING BOOT COULD WEAR A HOLE IN THE FUEL HOSE, RESULTING IN FULE LEAKAGE.

Remedy: IF PROPER CLEARANCE IS NOT PRESENT, THE METAL FUEL PIPE WILL BE REFORMED UPWARDS TO CORRECT THE PROBLEM, WITHOUT CHARGE TO OWNER.

Reported: 1979-04-05 (April 5, 1979) · Model years: 1980

THE LONGITUDINAL BODY BARS AT THE REAR CONTROL ARM LOCATION MAY NOT HAVE BEEN ADEQUATELY WELDED INTO THE STRUCTURE. SOME OF THESE BARS MAY HAVE BEEN PULLED DOWN FROM THE BODY DURING SHIPMENT WITH RESULTING DAMAGE TO THE BRAKE OR FUEL LINES. SEPARATION OF THE CONTROL ARM ATTACHMENT MAY ALSO RESULT.

Remedy: LONGITUDINAL BODY BARS WILL BE WELDED AND BOLTED IN THE PROPER POSITION WITHOUT CHARGE TO OWNER.

Reported: 1979-04-17 (April 17, 1979) · Model years: 1980

THE FRONT SUSPENSION COIL SPRING MAY HAVE A LARGER THAN DESIRED INSIDE DIAMETER OF THE LOWER COIL WHERE IT RESTS ON THE SPRING SEAT. THIS COULD ALLOW THE SPRING TO BE FORCED OVER THE LOWER SPRING SEAT DUE TO SUSPENSION FORCES.

Remedy: DEALER WILL INSPECT AND REPLACE INCORRECT FRONT SUSPENSION COIL SPRINGS WITHOUT CHARGE.

Reported: 1979-09-25 (September 25, 1979) · Model years: 1980

THE AUTOMATIC COOLER LINE HOSES ON SOME OF THE SUSPECT VEHICLES MAY CONTAIN MATERIAL VOIDS, WHICH COMBINED WITH A HIGH THERMAL EXPANSION AT ELEVATED TEMPERATURES, COULD RESULT IN HOSE FAILURE AND TRANSMISSION FLUID LEAKAGE.

Remedy: THE DEALER WILL REPLACE THE COOLER LINE HOSES USING HOSES WITH KEVLAR BRAIDED REINFORCEMENT.

Reported: 1979-10-17 (October 17, 1979) · Model years: 1980

THE STEERING GEAR MOUNTING PLATE ON THE INVOLVED VEHICLES MAY DEVELOP FATIGUE CRACKS AT HIGH MILEAGE WHICH WOULD ALLOW THE STEERING GEAR ATTACHMENT TO BECOME LOOSE. IF THIS CONDITION EXISTS, THE DRIVER MAY NOTICE CONSIDERABLE "FREE PLAY" IN THE STEERING WHEEL.

Remedy: THE DEALER WILL INSTALL AN IMPROVED TYPE OF STEERING GEAR MOUNTING BRACKET WITHOUT CHARGE TO OWNER.

Reported: 1981-08-10 (August 10, 1981) · Model years: 1980

UNDER CERTAIN CONDITIONS, THE REAR BRAKES COULD LOCK UP WITHOUT PRIOR WARNING DURING HIGH DECELERATION BRAKING. THE PROBLEM MAY BE CAUSED BY DEFECTIVE PROPORTIONER VALVES IN THE BRAKING SYSTEM.

Remedy: THE DEALER WILL INSPECT THE BRAKE SYSTEM PROPORTIONER VALVES AND IF NECESSARY INSTALL NEW VALVES.

Reported: 1983-02-24 (February 24, 1983) · Model years: 1980

UNDER CERTAIN CONDITIONS, VEHICLES MAY EXPERIENCE PREMATURE REAR WHEEL SKID DURING BRAKING. REAR WHEEL SKIDDING IS MOST LIKELY TO OCCUR ON A WET OR SLICK SURFACE.

Remedy: DEPENDING ON THE TRANSMISSION TYPE AND THE BRAKE COMPONENTS THAT HAVE BEEN INSTALLED, DEALERS WILL INSPECT AND REPLACE OR REPAIR, AS NECESSARY, CERTAIN FRONT BRAKE COMPONENTS, AND THE PARKING BRAKE CABLES. THE REAR BRAKE SHOES AND LININGS WILL BE REPLACED WITH PARTS THAT USE A MATERIAL WHICH GREATLY REDUCES THE LIKELIHOOD OF REAR WHEEL SKID. ACTIONS TAKEN TO THE FRONT BRAKES ARE TO ENSURE UNIFORMITY OF THE ENTIRE BRAKE SYSTEM. ACTIONS TAKEN TO THE PARKING BRAKE COMPONENTS WILL ENSURE THAT THE PERFORMANCE REQUIREMENTS, FOR KEEPING THE VEHICLE STATIONARY WHILE MANUAL TRANSMISSION EQUIPPED UNITS ARE IN NEUTRAL AND AUTOMATIC TRANSMISSION EQUIPPED UNITS ARE IN PARK, ARE MET.

Reported: 1980-10-08 (October 8, 1980) · Model years: 1981

THE INVOLVED VEHICLES MAY HAVE BEEN ASSEMBLED WITH THE POWER STEERING HOSE INCORRECTLY ROUTED. THE POWER STEERING HOSE MAY THEN CONTACT THE EXHAUST MANIFOLD, RESULTING IN DETERIORATION AND EVENTUAL FAILURE OF THE HOSE AND LEAKAGE OF POWER STEERING FLUID ONTO THE EXHAUST MANIFOLD.

Remedy: THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE HOSES AND INLET PIPE AND ADD A CLIP AT NO CHARGE TO OWNER.

Reported: 1981-03-24 (March 24, 1981) · Model years: 1981

THE ENGINE-TO-BODY GROUND CABLE ON CERTAIN VEHICLES MAY HAVE BEEN DAMAGED DURING MANUFACTURE. THE CABLE COULD EVENTUALLY BREAK DUE TO THE RELATIVE MOTION BETWEEN THE ENGINE AND BODY DURING VEHICLE OPERATION.

Remedy: A NEW GROUND CABLE WILL BE INSTALLED FREE OF CHARGE.

Reported: 1982-03-02 (March 2, 1982) · Model years: 1982

THE CLUTCH CABLE MAY RUB AGAINST THE MASTER CYLINDER BRAKE PIPE WHEN THE CLUTCH PEDAL IS OPERATED. CONTINUED OPERATION OF THE VEHICLE MAY RESULT IN WEAR THROUGH OF THE INSULATION ON THE CLUTCH CABLE. THE RESULTING METAL ON METAL CONTACT COULD LEAD TO FAILURE OF THE BRAKE PIPE, LOSS OF BRAKE FLUID, AND PARTIAL LOSS OF BRAKE ACTION.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, CORRECT SYSTEM BY PROVIDING A MINIMUM 1/2 INCH CLEARANCE BETWEEN CLUTCH CABLE AND BRAKE PIPE TO AVOID METAL ON METAL CONTACT.

Reported: 1982-03-08 (March 8, 1982) · Model years: 1982

UNDER CERTAAIN CONDITIONS, THE HOSE CLAMPS ON THE FUEL TANK FILLER PIPE AND FUEL TANK FILLER VENT PIPE COULD FRACTURE. THE FRACTURE OF THESE CLAMPS COULD CAUSE FUEL LEAKAGE AT ANY OF THE FOUR PIPE TO HOSE CONNECTIONS. LEAKAGE CAN OCCUR DURING REFUELING, OR WHILE DRIVING, IF THE FUEL TANK IS ABOVE 3/4 FULL.

Remedy: DEALER WILL INSPECT AND REPLACE THE HOSE CLAMPS ON THE FUEL TANK FILLER PIPE AND VENT PIPE AT NO COST TO OWNER.

Reported: 1983-01-01 (January 1, 1983) · Model years: 1982

REAR BRAKE HOSES MAY HAVE BEEN MANUFACTURED INCORRECTLY WHEN THE METAL END FITTINGS WERE INSTALLED. SOME REAR BRAKE HOSES MAY SEPARATE FROM THE METAL END FITTINGS WHEN SUBJECTED TO THE PULLING FORCE SPECIFIED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD 106, "BRAKE HOSES".

Remedy: THE DEALER WILL INSPECT AND REPLACE, IF NECESSARY, THE REAR BRAKE HOSES AT NO CHARGE TO OWNERS.

Reported: 1983-10-13 (October 13, 1983) · Model years: 1983

THE BRAKE PROPORTIONER VALVES MAY BREAK AND SEPARATE FROM THE MASTER CYLINDER. THIS WOULD ALLOW BRAKE FLUID TO LEAK AND WOULD RESULT IN A PARTIAL LOSS OF THE BRAKE SYSTEM.

Remedy: THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE ALL SUSPECT VALVES.

Reported: 1985-03-29 (March 29, 1985) · Model years: 1984

THE FUEL SYSTEM MAY LEAK AT THE THROTTLE BODY INJECTION FUEL FEED PIPE CONNECTION. CONSEQUENCE OF DEFECT: THIS LEAKAGE COULD RESULT IN AN UNDERHOOD FIRE WHICH COULD SPREAD TO THE PASSENGER COMPARTMENT AND CAUSE BURN INJURIES TO OCCUPANTS.

Remedy: REPLACE THE FUEL FEED PIPE.