Coachmen TRAILER recalls by model year
Explore the records behind recurring owner reports.
Key facts
3 owner complaints analyzed
2 distinct recall campaigns
10,000 mi median reported failure mileage
Scope: 1998 to 1999 model years. Data updated: . 1 complaints include usable failure mileage. View data status.
Recalls by model year
All campaigns in the snapshot affecting each model year, including recalls announced years later.
Recall campaigns
Shared campaigns appear once in each affected model year.
| Category | Count |
|---|---|
| 1998 | 2 |
| 1999 | 0 |
1998: 2; 1999: 0
Year-by-year records
Recall history
2 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
97V190005 · Suspension:Rear
Reported: 1997-11-28 (November 28, 1997) · Model years: 1998
VEHICLE DESCRIPTION: TRAVEL AND FOLDING TRAILERS EQUIPPED WITH DEXTER AXLES. THE WHEEL BEARINGS USED IN SOME OF THESE AXLES HAVE A METALLURGICAL DEFECT CAUSING EARLY FAILURE.
Consequence: A WHEEL BEARING FAILURE COULD RESULT IN THE LOSS OF THE WHEEL END FROM THE AXLE INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEXTER AXLE IS CONDUCTING THE NOTIFICATION AND REMEDY FOR THIS RECALL. DEALERS WILL INSPECT THE AXLES AND REPLACE THE WHEEL BEARINGS IF NECESSARY.
NHTSA campaign record ↗98V010001 · Fuel System, Other:Storage
Reported: 1998-01-13 (January 13, 1998) · Model years: 1998
VEHICLE DESCRIPTION: TRAVEL TRAILERS EQUIPPED WITH 20 LB. LPG CYLINDERS SUPPLIED BY MANCHESTER TANK. THESE CYLINDERS ARE EQUIPPED WITH AN OVERFILL PROTECTION. THE OVERFILL PROTECTION DEVICE MAY NOT FUNCTION PROPERLY.
Consequence: IF A CYLINDER IS OVERFILLED, AND SOME OF THE GAS LEAKS OUT, THE VAPORS COULD IGNITE IF THERE WAS A SOURCE OF IGNITION PRESENT.
Remedy: MANCHESTER TANK IS PERFORMING THE OWNER NOTIFICATION AND REMEDY CAMPAIGN FOR THIS RECALL. MANCHESTER WILL REPLACE THESE LPG CYLINDERS.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
3 unique complaints in this selection. Analysis snapshot: 2026-09-30.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 1998 | 1999 |
|---|---|---|
| Power Train:Axle Assembly | 150.0%ODI 10345926 · 10,000 miTL* THE CONTACT OWNS A 1998 COACHMEN CATALINA LYTE 259RK TRAILER. THE CONTACT WAS STOPPED WHEN HE NOTICED SMOKE FROM THE REAR DRIVER SIDE TIRE. HE THEN FOUND THAT THE TIRE WAS PROTRUDING FROM THE WHEEL ASSEMBLY AND NOT ALIGNED. THE DEALER SENT A MECHANIC TO REPLACE THE REAR WHEEL BEARINGS. THE CONTACT WAS THEN ABLE TO DRIVE THE VEHICLE TO THE DEALER WHERE HE WAS ADVISED THAT THE AXLE AND THE BEARINGS WERE NOT SUITED FOR THE TRAILER. THERE WERE NO FURTHER REPAIRS. FOUR YEARS LATER WHILE TRAVELING AT 50 MPH, THE FAILURE RECURRED ON THE FRONT DRI… | 00.0%No examples available for this selection. |
| Suspension:Rear | 150.0%ODI 10345926 · 10,000 miTL* THE CONTACT OWNS A 1998 COACHMEN CATALINA LYTE 259RK TRAILER. THE CONTACT WAS STOPPED WHEN HE NOTICED SMOKE FROM THE REAR DRIVER SIDE TIRE. HE THEN FOUND THAT THE TIRE WAS PROTRUDING FROM THE WHEEL ASSEMBLY AND NOT ALIGNED. THE DEALER SENT A MECHANIC TO REPLACE THE REAR WHEEL BEARINGS. THE CONTACT WAS THEN ABLE TO DRIVE THE VEHICLE TO THE DEALER WHERE HE WAS ADVISED THAT THE AXLE AND THE BEARINGS WERE NOT SUITED FOR THE TRAILER. THERE WERE NO FURTHER REPAIRS. FOUR YEARS LATER WHILE TRAVELING AT 50 MPH, THE FAILURE RECURRED ON THE FRONT DRI… | 00.0%No examples available for this selection. |
| Tires | 00.0%No examples available for this selection. | 1100.0%ODI 752374THE 1ST TIRE FAILED (EXPLODED) IN AUGUST 7, 2000, THE 2ND TIRE 7/20/01 & THE 3RD WAS ON 7/21/01. THESE TIRES WERE ON OUR BOAT TRAILER WHEN WE BOUGHT IT IN MARCH, 2000. THE PREVIOUS OWNERS PURCHASED THE BOAT/TRAILER PACKAGE NEW IN THE SUMMER OF 1999 AND THESE WERE THE ORIGINAL TIRES. ALL 3 OF THEM HAD LESS THAN 2,000 MILES ON THEM AT THE TIME THEY FAILED. IN ALL 3 INSTANCES THE SIDE OF THE TIRE "EXPLODED" AND YOU COULD SEE THE BELT (VERY FRAYED) STICKING OUT OF THE LARGE HOLE. FORTUNATELY THIS IS A DOUBLE AXEL TRAILER AND WAS CONTROLABLE AT … |
| Tires:Tread/Belt | 150.0%ODI 10080764ON A TRIP TO THE SOUTHWEST, MY 1998 COACHMEN 30' TRAVEL TRAILER HAD 3 OUT OF 4 TIRES BLOW OUT. THEY HAD PLENTY OF TREAD, AND WERE INFLATED TO 50 PSI. SIZE IS STR 245-75R15. I BELIEVE THEY WERE ALL CARLISLE. THE FAILURES OCCURED OVER A 1-WEEK PERIOD.*AK | 00.0%No examples available for this selection. |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| Power Train:Axle Assembly | Too few reports for a range | 10,000 mi | 1 (sparse) | ODI 10345926 · 10,000 miTL* THE CONTACT OWNS A 1998 COACHMEN CATALINA LYTE 259RK TRAILER. THE CONTACT WAS STOPPED WHEN HE NOTICED SMOKE FROM THE REAR DRIVER SIDE TIRE. HE THEN FOUND THAT THE TIRE WAS PROTRUDING FROM THE WHEEL ASSEMBLY AND NOT ALIGNED. THE DEALER SENT A MECHANIC TO REPLACE THE REAR WHEEL BEARINGS. THE CONTACT WAS THEN ABLE TO DRIVE THE VEHICLE TO THE DEALER WHERE HE WAS ADVISED THAT THE AXLE AND THE BEARINGS WERE NOT SUITED FOR THE TRAILER. THERE WERE NO FURTHER REPAIRS. FOUR YEARS LATER WHILE TRAVELING AT 50 MPH, THE FAILURE RECURRED ON THE FRONT DRI… |
| Suspension:Rear | Too few reports for a range | 10,000 mi | 1 (sparse) | ODI 10345926 · 10,000 miTL* THE CONTACT OWNS A 1998 COACHMEN CATALINA LYTE 259RK TRAILER. THE CONTACT WAS STOPPED WHEN HE NOTICED SMOKE FROM THE REAR DRIVER SIDE TIRE. HE THEN FOUND THAT THE TIRE WAS PROTRUDING FROM THE WHEEL ASSEMBLY AND NOT ALIGNED. THE DEALER SENT A MECHANIC TO REPLACE THE REAR WHEEL BEARINGS. THE CONTACT WAS THEN ABLE TO DRIVE THE VEHICLE TO THE DEALER WHERE HE WAS ADVISED THAT THE AXLE AND THE BEARINGS WERE NOT SUITED FOR THE TRAILER. THERE WERE NO FURTHER REPAIRS. FOUR YEARS LATER WHILE TRAVELING AT 50 MPH, THE FAILURE RECURRED ON THE FRONT DRI… |
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-10 | 0 | None | No examples available for this selection. |
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
1998: 0 complaints · 1999: 1 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 1998 | 0 | 0 | 0 |
| 1999 | 0 | 0 | 1 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 1998 | 2 | 0 | 0 |
| 1999 | 1 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component | Power Train:Axle Assembly | Suspension:Rear | Tires | Tires:Tread/Belt |
|---|---|---|---|---|
| Power Train:Axle Assembly | — | 1ODI 10345926 · 10,000 miTL* THE CONTACT OWNS A 1998 COACHMEN CATALINA LYTE 259RK TRAILER. THE CONTACT WAS STOPPED WHEN HE NOTICED SMOKE FROM THE REAR DRIVER SIDE TIRE. HE THEN FOUND THAT THE TIRE WAS PROTRUDING FROM THE WHEEL ASSEMBLY AND NOT ALIGNED. THE DEALER SENT A MECHANIC TO REPLACE THE REAR WHEEL BEARINGS. THE CONTACT WAS THEN ABLE TO DRIVE THE VEHICLE TO THE DEALER WHERE HE WAS ADVISED THAT THE AXLE AND THE BEARINGS WERE NOT SUITED FOR THE TRAILER. THERE WERE NO FURTHER REPAIRS. FOUR YEARS LATER WHILE TRAVELING AT 50 MPH, THE FAILURE RECURRED ON THE FRONT DRI… | 0 | 0 |
| Suspension:Rear | 1ODI 10345926 · 10,000 miTL* THE CONTACT OWNS A 1998 COACHMEN CATALINA LYTE 259RK TRAILER. THE CONTACT WAS STOPPED WHEN HE NOTICED SMOKE FROM THE REAR DRIVER SIDE TIRE. HE THEN FOUND THAT THE TIRE WAS PROTRUDING FROM THE WHEEL ASSEMBLY AND NOT ALIGNED. THE DEALER SENT A MECHANIC TO REPLACE THE REAR WHEEL BEARINGS. THE CONTACT WAS THEN ABLE TO DRIVE THE VEHICLE TO THE DEALER WHERE HE WAS ADVISED THAT THE AXLE AND THE BEARINGS WERE NOT SUITED FOR THE TRAILER. THERE WERE NO FURTHER REPAIRS. FOUR YEARS LATER WHILE TRAVELING AT 50 MPH, THE FAILURE RECURRED ON THE FRONT DRI… | — | 0 | 0 |
| Tires | 0 | 0 | — | 0 |
| Tires:Tread/Belt | 0 | 0 | 0 | — |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.