Damon DAYBREAK brakes problems

DT*: THE CONTACT STATED WHILE DRIVING 25MPH ON LEVEL ROADS THE BRAKES WERE APPLIED SEVERAL TIMES BEFORE THE VEHICLE STOPPED. THE PARKING BRAKE LIGHT ILLUMINATED AFTER THE FAILURE. THE BRAKES RESUMED NORMAL OPERATION ONCE THE VEHICLE WAS PARKED FOR AN HOUR. THE BRAKES FAILED PREVIOUSLY IN OCTOBER 2005. THE MANUFACTURER AND DEALER WERE NOT ALERTED FOLLOWING EITHER INCIDENT. UPDATED 05/23/06. *JB

Look up ODI 10157075 at NHTSA ↗

TL* THE CONTACT OWNS A 2002 DAMON DAYBREAK RV. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED AND THERE WAS A DELAYED RESPONSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT ROTORS AND CALIPERS NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 09V110000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOTIFIED AND STATED THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 30,052.

Look up ODI 10587176 at NHTSA ↗

TL*THE CONTACT OWNS A 2003 DAMON DAYBREAK RV. WHILE DRIVING 60 MPH, THE BRAKES FAILED WHEN THE PEDAL WAS DEPRESSED. THE CONTACT HAD TO DOWNSHIFT THE RV AND USE THE BRAKES IN THE VEHICLE THAT WAS BEING TOWED. HE HAS NOT DRIVEN THE VEHICLE SINCE THAT TIME. THE DEALER EXPLAINED THAT THE BRAKE LINE WAS TOO CLOSE TO THE FRAME. AS A RESULT, WATER ACCUMULATED AND RUSTED OUT THE BRAKE LINE, WHICH CAUSED A HOLE IN THE LINE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 21,000 AND CURRENT MILEAGE WAS 23,000.

Look up ODI 10274589 at NHTSA ↗

TL*THE CONTACT OWNS A 2008 DAMON DAYBREAK RV. ON JULY 15, 2008, THE FRONT DRIVER'S SIDE WHEEL WELL FENDER DETACHED FROM THE VEHICLE. IN ADDITION, THE WATER HEATER SENDS FLAMES THROUGH THE VENTS BEFORE IT IGNITES, THERE ARE ELECTRICAL OUTAGES, THE CHASSIS IS RUSTING OUT, THE BRAKES ARE FAILING, AND THE STABILIZING HYDRAULIC WELDS FOR THE SEAT WERE RUSTING OUT AND WEAKENING. THERE WAS NO FIRE DAMAGE, POLICE REPORT, OR INJURIES. THE VEHICLE HAS BEEN TO THE DEALER ON FIVE OCCASIONS FOR REPAIRS. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 4,8…

Look up ODI 10267428 at NHTSA ↗

TL* THE CONTACT OWNS A DAMON DAYBREAK WORKHORSE CHASSIS P30. WHILE ATTEMPTING TO START THE VEHICLE, THE CONTACT NOTICED SMOKE COMING FROM THE DASHBOARD BUT STOPPED INDEPENDENTLY WITHIN SECONDS. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 21,000.

Look up ODI 10355312 at NHTSA ↗

VEHICLE SHUT DOWN WHILE EXITING THE HIGHWAY.*MR WHILE LEAVING THE EXPRESSWAY AT 5 MPH THE MOTORHOME'S NEUTRAL SWITCH FAILED AND CAUSED THE VEHICLE'S BRAKES TO ACTIVATE SUDDENLY. THE SUDDEN BRAKING WAS FOLLOWED BY THE ENGINE SHUTTING DOWN. THE CONSUMER CONTACTED THE MANUFACTURER AND THEY INDICATED THAT THEY WERE AWARE OF THE PROBLEM WITH THE NEUTRAL SWITCH . THE CONSUMER IS CONCERNED BECAUSE THE MOTORHOME IS NOT EQUIPPED WITH AND EMERGENCY BRAKE AND IF THE PART FAILED AGAIN WHILE DRIVING AT A FASTER SPEED THE OUTCOME MAY BE DIFFERENT. *NM

Look up ODI 10089137 at NHTSA ↗

THE LCD WHICH DISPLAYS CRITICAL ENGINE INFORMATION HAS BAD PIXELS, WHICH MAKES IT DIFFICULT, IF NOT IMPOSSIBLE TO ASSESS OPERATING CONDITIONS. I UNDERSTAND THAT THIS IS A VERY COMMON FAULT WITH THE ACTIA DISPLAY USED IN THE WORKHORSE CHASSIS. *TR

Look up ODI 10694232 at NHTSA ↗

STATIONARY: EQUIPPED WITH AN IOTA ITS-50R, TRANSFER SWITCH IS EXPERIENCING FAILURE AND HEATS. BYPASSING THE DELAY CAUSES THE SWITCH TO WORK WHEN IT OTHERWISE WON'T. THERE IS A RECALL ON THE IOTA ITS 50R ISSUES BY THOR AND THE 2007 DAMON DAYBREAK IS NOT A CURRENTLY INCLUDED PRODUCT LINE - BUT SHOULD BE.

Look up ODI 11210786 at NHTSA ↗

TL*THE CONTACT OWNS A 2008 DAMON DAYBREAK RV. ON JULY 15, 2008, THE FRONT DRIVER'S SIDE WHEEL WELL FENDER DETACHED FROM THE VEHICLE. IN ADDITION, THE WATER HEATER SENDS FLAMES THROUGH THE VENTS BEFORE IT IGNITES, THERE ARE ELECTRICAL OUTAGES, THE CHASSIS IS RUSTING OUT, THE BRAKES ARE FAILING, AND THE STABILIZING HYDRAULIC WELDS FOR THE SEAT WERE RUSTING OUT AND WEAKENING. THERE WAS NO FIRE DAMAGE, POLICE REPORT, OR INJURIES. THE VEHICLE HAS BEEN TO THE DEALER ON FIVE OCCASIONS FOR REPAIRS. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 4,8…

Look up ODI 10267428 at NHTSA ↗

AFTER GOING THROUGH STOP AND GO TRAFFIC IN HARRISBURG PA THE BRAKES GAVE OUT COMPLETELY WITH THE BRAKE PEDAL GOING TO THE FLOOR IN SLOW TRAFFIC. THERE WAS A TINY BIT OF BRAKING AND THE VEHICLE COASTED ON THE SHOULDER TO A STOP. LOTS OF SMOKE FROM THE BRAKES FRONT AND REAR. REPAIR WAS OVER $2200 TO CHANGE THE LEFT REAR BRAKE CALIBER THAT HAD HUNG UP. FRONT RIGHT BAKE OVER HEATED AS WELL MELTING THE SPEED SENSOR AND CABLE. WORKHORSE/INTERNATIONAL CLAIMS THAT THIS P32 CHASSIC IS NOT PART OF THE BRAKE RECALL EVEN THOUGH IT HAS DEFECTIVE BRAKE CALIB…

Look up ODI 10882804 at NHTSA ↗

WHILE TRAVELING AT 35 MPH WITH OUR 2002 DAMON DAYBREAK RV WITH THE P32 CHASSIC WE SMELLED A BURNING BRAKE ODOR REAL BAD INSIDE. AT THAT TIME THE BRAKE PEDAL PRESSURE WAS GOOD. WE HAD JUST LEFT OUR HOME HEADING OUT ON OUR TRIP WHEN THIS OCCURRED. WE MADE THE DECISION TO TURN AROUND AND HEAD BACK TO OUR LOCAL REPAIR SHOP FOR INSPECTION. WE PULLED IN TO OUR REPAIR SHOP WE HAD NO BRAKE PEDAL. AFTER STOPPING IN THE PARKING LOT OF THE REPAIR SHOP I FOUND THE FRONT BRAKES ON FIRE. YES ON FIRE. LUCKILY WE HAD A FIRE EXTINGUISHER INSIDE AND WAS A…

Look up ODI 10459856 at NHTSA ↗

AUTO PARKING BRAKES APPLIES WHILE DRIVING DOWN ROAD. THIS HAS HAPPENED TO US THREE TIMES. *TR

Look up ODI 10680085 at NHTSA ↗

CONSUMER WAS PUTTING WHEEL COVER ON TIRES. WHEN HE PULLED HIS FINGERS BACK FROM THE TIRES WIRES WERE STICKING FROM VEHICLE. STEEL SPRING WAS STICKING FROM TIRES. MANUFACTURER WAS AWARE OF PROBLEM.*AK CONSUMER RECIVED A PRINT OUT THAT SHOWS THE FRONT TIRE HAD 1 DEGREE TILT IN AND THE RIGHT FRONT TIRE HAD 2 DEGREES OUT, BOTH FRONT TIRES WERE 4 DEGREES OUT OF PARALLEL, DUE TO THE BAD ALIGNMENT THE WHEEL BEARINGS, BALL JOINTS, IDLER ARMS, AND BELL CRANK HAD TO BE REPLACED

Look up ODI 894465 at NHTSA ↗

PROBLEMS WITH VEHICLE'S STEERING AND SUSPENSION.*MR (NAR) DEALER WAS NOTIFIED AND TO DATE HAS YET FIXED THE PROBLEM. *CB

Look up ODI 10048477 at NHTSA ↗

TL*THE CONTACT OWNS A 2005 DAMON DAYBREAK. WHILE DRIVING 55 MPH DOWNHILL OR ON ROUGH LEVEL PAVEMENT, THE VEHICLE MOVES FROM RIGHT TO LEFT WITH SEVERE SHAKING. THE CONTACT BELIEVES HE WILL LOSE CONTROL OF THE STEERING WHEEL AND THAT THE FAILURE IS WITH THE STEERING OR THE BRAKES. THE DEALER STATED THAT THE FRONT PASSENGER TIRE WAS CUPPING; HOWEVER, THE ROTORS AND BRAKES WERE FINE. THE CONTACT STATED THAT ALL OF THE TIRES WERE ROTATED AND ALIGNED, BUT THE FAILURE CONTINUED. THE FORD DEALER STATED THAT THE SHOCK ABSORBERS NEEDED TO BE REPLACE…

Look up ODI 10225277 at NHTSA ↗

TL*THE CONTACT OWNS A 2004 DAMON DAYBREAK. THE VEHICLE HAS A DOMETIC REFRIGERATOR, MODEL RM2852, SERIAL NUMBER 34403300. THE CONTACT RECEIVED A SAFETY RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V130000 (EQUIPMENT:RECREATIONAL VEHICLE) AND TOOK THE DOMETIC IN FOR REPAIR. WHEN SHE RETURNED HOME THAT SAME DAY, THE DOMETIC WOULD NOT TURN ON AT ALL. THE REPAIR SHOP THAT MADE THE REPAIR STATED THAT THEY WERE NOT RESPONSIBLE BECAUSE THEY ONLY INSERTED TWO SCREWS. THE CONTACT ATTEMPTED TO REACH DOMETIC, BUT WAS NOT ABLE TO GET PAST THE ANSWERING…

Look up ODI 10234634 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 DAMON DAYBREAK SPORT 3211 RV. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 15V745000 (EQUIPMENT). THE VEHICLE WAS TAKEN TO THE DEALER (CAMPING WORLD OF SYRACUSE, 7030 INTERSTATE ISLAND RD, SYRACUSE, NY 13209, [phone removed]) WHERE ADDITIONAL DEFECTS WERE DISCOVERED; THEREFORE, THE REPLACEMENT RECALL PART WAS NOT ENOUGH TO COMPLETE THE REPAIR. THE DEALER PROMISED TO CALL THE CONTACT BACK AFTER CHECKING WITH THEIR WARRANTY DEPARTMENT; HOWEVER, THE CONTACT HAD NOT RECEIVED A RETURN CALL. THE MANUFACT…

Look up ODI 11130361 at NHTSA ↗

PROBLEMS WITH VEHICLE'S STEERING AND SUSPENSION.*MR (NAR) DEALER WAS NOTIFIED AND TO DATE HAS YET FIXED THE PROBLEM. *CB

Look up ODI 10048477 at NHTSA ↗

TL*THE CONTACT OWNS A 2005 DAMON DAYBREAK. WHILE DRIVING 55 MPH DOWNHILL OR ON ROUGH LEVEL PAVEMENT, THE VEHICLE MOVES FROM RIGHT TO LEFT WITH SEVERE SHAKING. THE CONTACT BELIEVES HE WILL LOSE CONTROL OF THE STEERING WHEEL AND THAT THE FAILURE IS WITH THE STEERING OR THE BRAKES. THE DEALER STATED THAT THE FRONT PASSENGER TIRE WAS CUPPING; HOWEVER, THE ROTORS AND BRAKES WERE FINE. THE CONTACT STATED THAT ALL OF THE TIRES WERE ROTATED AND ALIGNED, BUT THE FAILURE CONTINUED. THE FORD DEALER STATED THAT THE SHOCK ABSORBERS NEEDED TO BE REPLACE…

Look up ODI 10225277 at NHTSA ↗

CONSUMER STATES THE VEHICLE CHASSIS STRUCTURE, WAS NOT WELL DESIGNED BY THE MANUFACTURER CAUSING PROBLEMS HILE DRIVING THE VEHICLE. DEALER HAS BEEN NOTIFIED. NLM

Look up ODI 8018636 at NHTSA ↗

TL*THE CONTACT OWNS A 2008 DAMON DAYBREAK RV. ON JULY 15, 2008, THE FRONT DRIVER'S SIDE WHEEL WELL FENDER DETACHED FROM THE VEHICLE. IN ADDITION, THE WATER HEATER SENDS FLAMES THROUGH THE VENTS BEFORE IT IGNITES, THERE ARE ELECTRICAL OUTAGES, THE CHASSIS IS RUSTING OUT, THE BRAKES ARE FAILING, AND THE STABILIZING HYDRAULIC WELDS FOR THE SEAT WERE RUSTING OUT AND WEAKENING. THERE WAS NO FIRE DAMAGE, POLICE REPORT, OR INJURIES. THE VEHICLE HAS BEEN TO THE DEALER ON FIVE OCCASIONS FOR REPAIRS. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 4,8…

Look up ODI 10267428 at NHTSA ↗

THE REEFER OF THE R/V POSSIBLY WHEN THE ELECTRIC CAME ON, WHICH GOES FROM GAS TO ELECTRIC, MAY HAVE HAD GAS RESIDUE ON IT CAUSING THE ELECTRIC ELEMENT TO COME IN CONTACT WITH GAS RESIDUE AND CAUGHT FIRE. NLM

Look up ODI 549162 at NHTSA ↗

CPSC: 2004 DAMON DAYBREAK MOTOR HOME. THE MAIN DOOR LATCH MECHANISM IS MANUFACTURED BY TRI MARK. THE LOCKING PLUNGER IS MADE OF AN INFERIOR DIE CAST ZINK ALLOY. TWO YEARS AGO THE PLUNGER BROKE, LOCKING MY WIFE INSIDE THE MOTOR HOME.THEY WILL NOT GET OUT. THERE IS A NEW VERSION AVAILABLE WITH A STEEL PLUNGER. I ORDERED ONE AND HAD TO PAY FOR IT. *BF UPDATED 06/13/2017*JS

Look up ODI 10994708 at NHTSA ↗