Damon TUSCANY recalls by model year

Reported: 2008-05-22 (May 22, 2008) · Model years: 2005, 2006, 2007

DAMON IS RECALLING 738 MY 2005-2007 ASTORIA, TUSCANY, MY 2005 ASTORIA WALDORF, AND MY 2006-2007 ASTORIA PACIFIC MOTOR HOMES BUILT ON FREIGHTLINER XC CHASSIS. THE CHASSIS CONTAINS STEERING FILTERS THAT CAN PLUG DUE TO FAILURE OF THE SCREEN ADHESION TO THE FILTER HOUSING CAUSING A RISE IN RETURN LINE PRESSURE POTENTIALLY LEADING TO A HOSE SEPARATION FROM THE FILTER OR STEERING GEAR FITTING RESULTING IN A SUDDEN LOSS OF STEERING FLUID AND POWER ASSIST.

Consequence: SUDDEN LOSS OF STEERING ASSIST WITHOUT WARNING INVOLVING A MOTOR HOME COULD BE A PROBLEM FOR CERTAIN DRIVERS INCREASING THE RISK OF A CRASH.

Remedy: FREIGHTLINER IS CONDUCTING THIS RECALL AND WILL REPLACE THE AFFECTED FILTERS WITH A LARGER FILTER (PLEASE SEE 07V570). OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712 OR DAMON AT 1-800-860-3812.

Reported: 2010-11-16 (November 16, 2010) · Model years: 2005, 2006, 2007, 2008, 2009

TMC IS RECALLING CERTAIN MODEL YEAR 2004-2011 DAMON AND FOUR WINDS RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK, MAY NOT SHUT-OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: TMC IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL NFORMATION. THE RECALL BEGAN ON JANUARY 12, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR THOR MOTOR COACH AT 1-877-855-2867.

Reported: 2007-01-30 (January 30, 2007) · Model years: 2006, 2007

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE MOTOR HOMES WERE BUILT WITHOUT THE RED REAR REFLEX REFLECTORS AND SOME MOTOR HOMES WERE BUILT WITHOUT THE SIDE REAR RED REFLEX REFLECTORS.

Consequence: DURING NIGHT DRIVING CONDITIONS OR WHILE THE MOTOR HOME IS PARKED, THE REAR AND SIDE MARKER LIGHTS WILL NOT PROVIDE ANY REFLEX REFLECTION TO MARK THE VEHICLE'S LOCATION IN THE DARK INCREASING THE RISK OF A CRASH.

Remedy: DAMON WILL PROVIDE THE OWNERS WITH A KIT CONTAINING THE MISSING REFLECTORS AND INSTRUCTIONS FOR APPLYING THEM TO THEIR VEHICLE. OWNERS MAY CHOOSE TO HAVE THEIR DEALERS DO THE REPAIR FREE OF CHARGE. THE RECALL BEGAN ON JULY 9, 2007. OWNERS MAY CONTACT DAMON AT 1-800-860-3812.

Reported: 2008-02-05 (February 5, 2008) · Model years: 2007, 2008

DAMON IS RECALLING 126 MY 2007-2008 TUSCANY, MY 2008 ASTORIA, AND ASTORIA PACIFIC MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS. THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER-TIGHTENED.

Consequence: INCORRECTLY TORQUED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.

Remedy: DAMON IS WORKING WITH FREIGHTLINER TO REPAIR THESE VEHICLES FREE OF CHARGE(PLEASE SEE 07V-306). THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712 OR DAMON AT 1-937-596-6849.

Reported: 2008-08-07 (August 7, 2008) · Model years: 2008

DAMON IS RECALLING 179 MY 2008 ASTORIA, TUSCANY,ESSENCE, AND MY 2008-2009 ASTORIA PACIFIC MOTOR HOME CHASSIS EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

Consequence: IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.

Remedy: DAMON IS WORKING WITH DAIMLER TRUCKS/SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712, SAF-HOLLAND AT 1-231-773-3271 OR DAMON AT 1-800-860-3812.

Reported: 2015-11-10 (November 10, 2015) · Model years: 2008, 2009, 2010, 2011

Thor Motor Coach (Thor) is recalling certain model year 2011-2016 Thor Challenger, Thor Citation, Thor Hurricane, Thor Tuscany, Thor Windsport, 2011-2012 Thor Astoria, Thor Avanti, Thor Chateau, 2011-2014 Thor Daybreak, 2011-2015 Thor Outlaw, Thor Siesta, 2014-2015 Thor Miramar, 2012 Thor Four Winds, 2008-2011 Damon Astoria, Damon Daybreak, Damon Outlaw, Damon Tuscany, 2008-2012, Damon Challenger, 2008-2010 Damon Essence, 2009-2011 Damon Avanti, Four Winds Chateau, Four Winds Citation, Four Winds Four Winds, Four Winds Hurricane, Four Winds Siesta, Four Winds Windsport, 2009-2010 Four Winds Dorado, Four Winds Dutchmen, Four Winds Magellan, Four Winds Mandalay and 2009 Four Winds Fun Mover, and Four Winds Presidio motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double and Triple Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable.

Consequence: Unstable entry and exit steps increase the risk of injury.

Remedy: Thor will notify owners, and dealers will install a retainer bracket to reinforce the operating mechanism and replace all of the affected bolts, free of charge. The recall began on January 6, 2016. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000111.

Reported: 2011-08-19 (August 19, 2011) · Model years: 2010, 2011

THOR MOTOR COACH (TMC) IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 DAMON TUSCANY, ASTORIA, AND ESSENCE RECREATIONAL VEHICLES AND MODEL YEAR 2011 AND 2012 TMC TUSCANY AND ASTORIA RECREATIONAL VEHICLES MANUFACTURED FROM MAY 7, 2009, THROUGH AUGUST 12, 2011. THE CIRCUIT BREAKER FOR THE WINDSHIELD WIPER MOTOR IS INSUFFICIENT FOR THE LOAD. THE BREAKER SHOULD HAVE A 15 AMP RATING, HOWEVER THE VEHICLE WAS BUILT WITH ONE RATED AT 10 AMPS.

Consequence: THE WINDSHIELD WIPER WILL STOP OPERATING IF THE BREAKER TRIPS DUE TO A CIRCUIT OVERLOAD. IF THIS OCCURS, THE DRIVER'S FIELD OF VISION MAY BE REDUCED, INCREASING THE RISK OF A CRASH.

Remedy: TMC WILL NOTIFY OWNERS, AND DEALERS WILL EXCHANGE THE BREAKER WITH A 15-AMP ONE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 6, 2011. OWNERS MAY CONTACT TMC WARRANTY/SERVICE DEPARTMENT AT 1-877-855-2867.