2018 Fleetwood STORM problems and owner complaints

The contact owns a 2011 Fleetwood Storm. The contact received notification of NHTSA Campaign Number: 12V535000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The dealer informed the contact that parts were no longer manufactured. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distributi…

Look up ODI 11608047 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 FLEETWOOD STORM. WHEN DRIVING THE VEHICLE ON A SUNNY DAY, THE CONTACT NOTICED THAT HE COULD NOT SEE THE INSTRUMENT PANEL CLEARLY ENOUGH TO TELL WHAT SPEED HE WAS DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE CONTACT WAS INFORMED THAT THE DESIGN OF THE INSTRUMENT PANEL COULD NOT BE CHANGED. THE CURRENT AND FAILURE MILEAGES WERE 5,700. UPDATED 05/24/12 *BF THE CONSUMER STATED HE COULD NOT SEE ANY OF THE GAUGES ON THE INSTRUMENT PANEL. THE CONSUMER STATED HE NEARLY RAN OUT OF GAS ON ONE OCCASION. UPDATED 05/…

Look up ODI 10457820 at NHTSA ↗

The wall and floor has repeatedly separated from the chassis to the point light shows between the wall and floor and the dash moves up and down uncontrollably. Fleetwood did attempt to repair the problem under warranty but the fix was inadequate and the problem continues to surface. As of now the visible wall separation extends from the passenger-side front end to behind the door and may go much further back and I am concerned that the body may slide off of the chassis when in transit.

Look up ODI 11565450 at NHTSA ↗

WE HAD A STRONG ODOR OF OVER HEATING BRAKES THOUGH OUT THE VEHICLE I PULLED OVER AND THE RIGHT REAR WHEEL WERE EXTREMELY HOT AND SMELT OF OVERHEATED BRAKE SHOES I LET THEM COOL FOR AN HOUR AND TAPPED THE CALIBER WITH A HAMMER , THIS HAPPENED 2 MORE TIMES ON THE TRIP HOME, 8-8-08 TOOK VEHICLE OUT OF STORAGE TO GET IT INSPECTED A 15 MILE ROUND TRIP AND THE PROBLEM OCCURRED AGAIN ONLY THIS TIME IT WAS THE LEFT SIDE,I CURRENTLY HAVE AN APPOINTMENT TO HAVE THE BRAKES CHECKED BY A WORKHORSE DEALER WORK HORSE FRAME WAS MANUFACTURED 10-7-03 BOSCH CALIB…

Look up ODI 10239129 at NHTSA ↗

DASH CAME LOOSE AND IS SETTING ON TOP OF THE STEERING COLUMN. HEAT AND FUMES COMING FROM ENGINE COMPARTMENT INTO CAB. IT PULLED HEAT AND AIR DUCTS LOOSE UNDER THE DASH. INSIDE WALL WHERE THE REFRIGERATOR IS MOUNTED PULLED APART FROM EXTERIOR WALL AND CEILING. THIS UNIT HAS 6092 MILES ON IT. FLEETWOOD HAS REFUSED TO HELP US.

Look up ODI 11032790 at NHTSA ↗

THE GENERATOR CUT OFF WHILE YOU DRIVE, PER OMNI GENERATOR COMPANY, IS TO CLOSE TO THE ENGINE, AND THE GENERATOR SENSE OVER HEATING, AND CUT OFF. OTHER MODEL, HAS BEEN CORRECTED THE PROBLEMS, MY PHONE NUMBER IS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

Look up ODI 11355281 at NHTSA ↗

The wall and floor has repeatedly separated from the chassis to the point light shows between the wall and floor and the dash moves up and down uncontrollably. Fleetwood did attempt to repair the problem under warranty but the fix was inadequate and the problem continues to surface. As of now the visible wall separation extends from the passenger-side front end to behind the door and may go much further back and I am concerned that the body may slide off of the chassis when in transit.

Look up ODI 11565450 at NHTSA ↗

THERE APPEARS TO BE A MANUFACTURING DEFECT IN MATERIAL OR WORKMANSHIP THAT HAS CAUSED THE FOLLOWING STRUCTURAL/SYSTEM FAILURES FROM NORMAL OPERATION: 1) PASSENGER SIDE COCKPIT FLOORING HAS SEPARATED FROM THE COACH FRAME STARTING FROM THE FRONT OF THE COACH AND CONTINUING ALONG THE ENTIRE LENGTH OF THE COCKPIT AND POSSIBLY BEYOND TO UNDER THE DINETTE SEATING AREA. THE SEPARATION IS VISIBLE FROM UNDERNEATH THE MOTOR HOME AS WELL AS FROM THE COCKPIT PASSENGER SEATING AREA WHERE THE ROAD IS VISIBLE WHILE DRIVING. 2) THE DASHBOARD HAS DETA…

Look up ODI 10559623 at NHTSA ↗

THERE APPEARS TO BE A MANUFACTURING DEFECT IN MATERIAL OR WORKMANSHIP THAT HAS CAUSED THE FOLLOWING STRUCTURAL/SYSTEM FAILURES FROM NORMAL OPERATION: 1) PASSENGER SIDE COCKPIT FLOORING HAS SEPARATED FROM THE COACH FRAME STARTING FROM THE FRONT OF THE COACH AND CONTINUING ALONG THE ENTIRE LENGTH OF THE COCKPIT AND POSSIBLY BEYOND TO UNDER THE DINETTE SEATING AREA. THE SEPARATION IS VISIBLE FROM UNDERNEATH THE MOTOR HOME AS WELL AS FROM THE COCKPIT PASSENGER SEATING AREA WHERE THE ROAD IS VISIBLE WHILE DRIVING. 2) THE DASHBOARD HAS DETA…

Look up ODI 10559623 at NHTSA ↗

APPARENTLY, THE HOUSE PART OF THE RV SEPARATED FROM THE CHASSIS. THE BRACKETS ON BOTH SIDES OF THE RV CHASSIS BACKED OUT WHICH CAUSED THE BOLTS TO BREAK ALL THE WAY BACK TO THE ENTRY DOOR.

Look up ODI 11350432 at NHTSA ↗

FLEETWOOD MOTORHOME WITH SI-GI WINDOWS IN WHICH 4 WINDOWS INCLUDING THE CO-PILOTS WINDOW FOGGING FROM DUAL PANE WINDOW SEALS BROKEN CAUSING UNSAFE VISUAL VISION THROUGH WINDOW. *TR

Look up ODI 10260642 at NHTSA ↗

WINDSHIELD WIPER CLEANING AREA LEAVE A LARGE UNTOUCHED AREA 12-14 INCHES BETWEEN THE BLADES; DURING HEAVY RAIN OR SNOW SHOWERS. IT IS BAD ENOUGH THAT I CAN NOT SEE THE RIGHT SHOULDER OF HWY. AND HAVE DIFFICULTLY SEEING THE ROAD AS I DRIVE AROUND RIGHTHAND TURNS. THE CLEAN AREA HEIGHT IS ONLY BARELY EYE LEVEL(I'M 5' 4") WHICH MAKES SEEING SIGNAL LIGHTS DIFFICULT. I FEEL THIS A SAFETY ISSUE WHEN I CANNOT SEE THE WHOLE ROAD WHEN I DRIVE IN POOR WEATHER CONDITIONS. O'CONNOR'S RV (MY RV DEALER) IN CHILLIWACK,B.C.,CANADA, HAS CONTACTED THE MANUFAC…

Look up ODI 10400704 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 FLEETWOOD STORM. THE CONTACT WAS DRIVING 50 MPH WHEN THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT A CLEAR DIAGNOSIS WAS NOT NOTED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 350.

Look up ODI 10560231 at NHTSA ↗

THERE APPEARS TO BE A MANUFACTURING DEFECT IN MATERIAL OR WORKMANSHIP THAT HAS CAUSED THE FOLLOWING STRUCTURAL/SYSTEM FAILURES FROM NORMAL OPERATION: 1) PASSENGER SIDE COCKPIT FLOORING HAS SEPARATED FROM THE COACH FRAME STARTING FROM THE FRONT OF THE COACH AND CONTINUING ALONG THE ENTIRE LENGTH OF THE COCKPIT AND POSSIBLY BEYOND TO UNDER THE DINETTE SEATING AREA. THE SEPARATION IS VISIBLE FROM UNDERNEATH THE MOTOR HOME AS WELL AS FROM THE COCKPIT PASSENGER SEATING AREA WHERE THE ROAD IS VISIBLE WHILE DRIVING. 2) THE DASHBOARD HAS DETA…

Look up ODI 10559623 at NHTSA ↗

Rear stabilizer bracket bolts fell out brackets and screws are missing, on the other side 1 bolt is missing. Without these parts the sway bar does not function and the vehicle dangerously s w a y s.

Look up ODI 11419515 at NHTSA ↗