| Steering | 80936.2%ODI 10482910 · 300 miPOWER STEERING FAILURE WHILE BACKING UP AND DRIVING. TURNING VEHICLE OFF AND ON CAUSES POWER STEERING TO WORK. VERY HARD TO STEER, NOT SAFE TO DRIVE... DEALER IS PUTTING A HOLE NEW POWER STEERING UNIT IN... *TR Look up ODI 10482910 at NHTSA ↗ | 48528.9%ODI 10573219 · 5,677 miTO AVOID HITTING ANOTHER VEHICLE THAT ILLEGALLY CAME INTO THE LANE I WAS ENTERING (THEY WERE DRIVING ON THE SHOULDER), I HAD TO TAKE EVASIVE ACTION, WHICH CAUSED ME TO TURN MY VEHICLE INTO A CURB. AT THE TIME, I WAS TRAVELING 15 TO MAYBE 20 MPH. AFTER HITTING THE CURB, MY VEHICLE CAME TO A STOP AND UPON INSPECTION I DISCOVERED THAT THE LOWER CONTROL ARM HAD COMPLETELY BROKEN IN HALF. MY VEHICLE WAS TOWED TO A LOCAL DEALERSHIP, WHERE THEY SUBSEQUENTLY SERVICED THE VEHICLE, WHICH I PICKED UP ON MARCH 15, 2014. HOWEVER, WITHIN 100 MILES OF DRI… Look up ODI 10573219 at NHTSA ↗ | 33718.8%ODI 10680739 · 25 miFORD MOTOR CO. AND WORTHINGTON FORD OF LONG BEACH, CA ARE SELLING VEHICLES WITH DAMAGED/DEFECTIVE STEERING AND REFUSING TO FIX THE DEFECT(S). 1/25/2015 PURCHASED FORD EXPLORER (8 MILES ON VEHICLE); DAY AFTER PURCHASE, 1/26/2015, NOTICED PROBLEM WITH STEERING, PARKED VEHICLE, WOULD NOT DRIVE OR LET WIFE DRIVE. RETURNED VEHICLE IMMEDIATELY TO DEALER VIA ARMSTRONG TOWING (FLATBED) FOR REPAIRS/EVALUATION. WORTHINGTON FORD OF LONG BEACH: [XXX] ALL ACCUSED ME OF CAUSING THE DAMAGE; SAID IT ISN'T UNDER WARRANTY SERVICE AND WANTED TO CHARGE ME $600.00… Look up ODI 10680739 at NHTSA ↗ | 50420.5%ODI 10838706 · 12,200 miWHILE MAKING A TURN ON A LOCAL STREET POWER STEERING WENT OUT. I WAS ABLE TO PULL TO THE SIDE SHUT OFF THE VEHICLE AND WAITED A MINUTE AND RESTARTED NO FURTHER ISSUES. I HAVE OWNED MANY EXPLORERS INCLUDING 11-13 AND NOW 16. THE 16 HAS 12K MILES ON IT. Look up ODI 10838706 at NHTSA ↗ | 754.4%ODI 109135132017 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO VEHICLE ALERT GAUGE MESSAGE CENTER DISPLAYS FAILURE OF COLLISION WARNING SYSTEM, TRACKING CONTROL SYSTEM AND STEERING SYSTEM. ATTEMPTS TO REPLACE/REPAIR SENSOR AND STEERING COLUMN FAILS. *SMD THE DEALER INFORMED THE CONSUMER A SENSOR WAS REPLACED. TWO DAYS LATER, THE DEALER CALLED THE CONSUMER AND INFORMED HIM THE VEHICLE NEEDED TO BE REPROGRAMMED AND STEERING COLUMN NEEDED TO BE REPLACED. *JB Look up ODI 10913513 at NHTSA ↗ | 182.5%ODI 11118467 · 8,400 miMY EXPLORE HAS FAILED TO START ON 4 DIFFERENT OCCASIONS. THE DEALER SERVICE DEPARTMENT SENT A TOW TO GET THE CAR, AND THE DRIVER GOT IT TO START AFTER SEVERAL ATTEMPTS, THEN HE SHUT IF OFF AND IT FAILED TO START AGAIN. THE SERVICE MANAGER TOLD ME HE COULDN'T GET THE ISSUE TO OCCUR SO THERE WASN'T ANYTHING FOR HIM TO DO EVEN THOUGH HE HAD A FAULT CODE. MY EXPLORE ONLY HAS LEST THAN 9000 MILES AND IS STILL UNDER WARRANTY BUT YET THEY ARE TELLING ME THERE ISN'T ANYTHING THEY CAN DONE AFTER KEEPING MY CAR FOR 3 WEEKS. THERE SHOULD BE THINGS THAT SH… Look up ODI 11118467 at NHTSA ↗ | 93.0%ODI 11208940 · 1,800 miON MARCH 2ND 2019 FORD EXPLORER SPORT WITH 1,800 MILES WAS TOWED TO THOMASSEN FORD IN CHARLES TOWN WV LEAVING OWNER STRANDED. COMPLAINED OF STRONG FUEL/GASOLINE ODOR INSIDE THE VEHICLE. FUEL/GASOLINE WAS LEAKING BADLY OUT OF THE VEHICLE ONTO THE EXHAUST PIPE. ON MARCH 4TH NOTIFICATION WAS PROVIDED FROM SERVICE WRITER THAT NONE OF THE FUEL LINES OR CLAMPS WERE ATTACHED PROPERLY FROM THE FACTORY. VEHICLE SAT AT THOMASSEN FORD UNTIL MARCH 27TH WHEN REPAIRS WERE COMPLETE. APRIL 9TH 2019 SOME FORM OF FLUID LEAKED OUT OF THE PARKED VEHICLE FOR 8… Look up ODI 11208940 at NHTSA ↗ | 252.0%ODI 11315531 · 900 miWHILE DRIVING ON THE HIGHWAYTHE 'STEERING FAULT SERVICE NOW LIGHT' CAME UP ON THE DASHBOARD WHILE TRAVELING 75 MPH MILES ON ODOMETER 900. AFTER STOPPING THE CAR AND RESTARTING IT THE 'STEERING LOSS STOP SAFELY' MESSAGE POPPED UP ON THE DASHBOARD I HAD TO DRIVE TO THE DEALERSHIP WITH NO POWER STEERING OR ANY TRANSMISSION OPTIONS LIKE SPORT, ECONOMY, REGULAR, DEEP SNOW, NO ASSIST FOR UPHILL OR DOWNHILL PARKING Look up ODI 11315531 at NHTSA ↗ | 51.2%ODI 11404027 · 20 miTHE WHEEL WELLS OF THE VEHICLE COLLECT LARGE AMOUNTS OF SNOW AND ICE. THIS BUILD UP CONSTRICTS THE WHEELS OF THE VEHICLE CONTACTING THE TIRES RESTRICTING ROTATION AND STEERING. THIS IS AN EXTREMELY DANGEROUS POTENTIALLY DEADLY SITUATION. WE HAVE CONTACTED FORD MOTOR COMPANY AND THE DEALERSHIP. NO REMEDY TO THIS SITUATION HAS BEEN OFFERED. PLEASE INVESTIGATE AND ANY ASSISTANCE IS APPRECIATED. I BELIEVE THIS IS A WIDE SPREAD PROBLEM FORD IS UNWILLING TO DEAL WITH. THIS CONDITION OCCURS IN COLD WEATHER AND SNOWY ICY CONDITIONS. THE BUILD UP HA… Look up ODI 11404027 at NHTSA ↗ | 93.4%ODI 11504904 · 207,000 miThe contact owns a 2022 Ford Explorer. The contact stated while starting the vehicle, the steering wheel started moving independently from side to side, without warning. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 207,000. Look up ODI 11504904 at NHTSA ↗ | 1210.9%ODI 11517340I rented a 2023 Ford Explorer. I had many issues with the added safety features while renting it, ultimately resulting in an accident. Firstly, the lane keeping assist did not function properly. In construction zones, back roads, and during rainy weather, the vehicle would jerk very hard to one side of the other. Even after trying to shut off the lane keeping assist feature, it it would automatically turn back on. Luckily, most of those incidents would happen in low traffic areas. Until the final time it happened, resulting in a head on collisi… Look up ODI 11517340 at NHTSA ↗ | 29.5%ODI 11633176 · 3,600 miThe contact owns a 2024 Ford Explorer. The contact stated while driving approximately 30-40 MPH in cold weather, the vehicle started making an abnormal clunking and rattling sound near the wheels. The contact was unable to determine the source of the noise. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 24V091000 (SUSPENSION, STEERING). The vehicle was taken to the local dealer, where it was diagnosed that the front struts were worn and needed to be replaced. The dealer recomm… Look up ODI 11633176 at NHTSA ↗ | 98.9%ODI 11683816On October 24, 2024, my 2025 Ford Explorer ST experienced a sudden steering column lock and complete loss of braking while I was driving, leading to a crash and injuries. The vehicle had approximately 800 miles and was a warranty replacement provided weeks earlier. Prior to delivery, the dealer referenced a Quality Assurance hold of about two months on this vehicle, which was not disclosed to me in any detail. The simultaneous loss of steering and brakes suggests a potential common cause safety defect that may affect other 2025 Explorer ST v… Look up ODI 11683816 at NHTSA ↗ | 12.6%ODI 11740470Purchased new 26 Ford Explorer on [XXX] from Franklin Ford in TN. During test drive noted the BlueCruise hands free was canceling but was advised by dealer that it might need to download an update or sync my profile. Next day I confirmed the BlueCruise and adaptive cruise was not working. The hands free BlueCruise and adaptive system will cancel randomly with no warning even while in turn. This almost caused me to slam into the vehicle next to me several times but was able to catch the wheel just in time. This is an extreme danger and hazard. T… Look up ODI 11740470 at NHTSA ↗ | 0UnavailableNo examples available for this selection. |
|---|
| Unknown Or Other | 34515.4%ODI 10497684 · 1,023 miI JUST BOUGHT A 2013 FORD EXPLORER LAST WEEK AND I AM HAVING AN ISSUE WITH BURNT OIL SMELL GETTING INSIDE THE CABIN EVEN WITH A/C IN RECIRCULATION MODE. IT IS SUCH A DISAPPOINTMENT TO PAY OVER 40K FOR A BRAND NEW SUV AND BEEN DEALING WITH SUCH AN ISSUE. I HAVE A NEWBORN AND I AM AFRAID TO TAKE IT WITH ME IN THE EXPLORER BECAUSE I GUESS IT IS HARMFUL FOR ANYBODY. FIRST TIME I BOUGHT A FORD AND I AM NOT HAPPY ABOUT MY DECISION TO SWITCH BRANDS. I TOOK TO THE DEALERSHIP AND NEED TO GO BACK ON MONDAY TO DO A SYSTEM UPDATE BUT I DON'T THINK UPDATING… Look up ODI 10497684 at NHTSA ↗ | 33620.0%ODI 10608596 · 100 miWHEN DRIVING MY 2014 FORD EXPLORER AT ANY SPEED AND ON ANY TERRAIN, THE EXHAUST FUMES ENTER INTO THE CABIN OF THE VEHICLE. THE ODOR IS EXTREME, CAUSES HEADACHES, NAUSEA, AND TENDS TO BURN MY EYES AS WELL AS MY GRANDDAUGHTER, WHO IS WITH ME MOST OF THE TIME. BECAUSE THERE HAVE NOT BEEN ENOUGH PEOPLE COMPLAIN OF THIS PROBLEM, AND BECAUSE FORD HAS NOT RECOGNIZED THAT THERE IS A PROBLEM, MY DEALER WAS NOT GOING TO ATTEMPT TO FIX THE PROBLEM. FINALLY THEY HAVE AGREED TO SPRAY THE UNDER PART OF THE EXHAUST WITH A RUBBERIZED SEALANT THAT WAS USED … Look up ODI 10608596 at NHTSA ↗ | 40222.4%ODI 10716742 · 4,000 miRETURNING HOME FROM CHURCH WHEN ALL OF A SUDDEN I COULD NOT STEER THE CAR. IT WAS VEERING TO THE LEFT AND I COULD NOT STRAIGHTEN IT UP. THERE WAS A THUD AND DIRT AND DUST AND THE CAR STOPPED. GOT OUT AND THE FRONT LEFT SUSPENSION WAS ON THE GROUND. NO TICKET, NO NOTHING BECAUSE I DID NOT HIT ANYTHING. FORD HAS MADE A DECISION THAT IS WAS NOT A CAR FAILURE. WE ASK FOR THE FINDINGS OF THERE INSPECTIONS AND WAS TOLD THY DID NOT RELEASE THOSE TO THE CUSTOMER. WE REALLY WOULD LIKE TO SEE THEIR REPORT AS I DID NOT HIT ANYTHING AND WANT TO KNOW WHY TH… Look up ODI 10716742 at NHTSA ↗ | 43017.5%ODI 10817212 · 4,567 miPURCHASED 2016 FORD EXPLORER NEW. HAS 4567 MILES ON IT. STARTING NOTICING A POPPING SOUND UNDER FOOT FLOOR BOARD DRIVER SIDE WHENEVER I FIRST START THE VEHICLE AND MOVE FORWARD TO ABOUT 7 MILES PER HOUR ABOUT TWO MONTHS AFTER PURCHASE. NOISE DOES NOT HAPPEN ANYTIME AFTER THE FIRST POP WHILE DRIVING, ONLY WHEN YOU FIRST START THE VEHICLE AND MOVE FORWARD AT ABOUT 7 MPH. TOOK TO FORD DEALER TO HAVE THE NOISE CHECKED OUT THEY ADJUSTED THE FRONT BRIDGE LINK BOLT AS PER TSB 15-0186 AND SAID THE NOISE WAS GONE. I WENT TO PICK UP THE VEHICLE AND AS S… Look up ODI 10817212 at NHTSA ↗ | 37021.9%ODI 10906040 · 200 miI HAVE A 2017 FORD EXPLORER THAT HAS A EXHAUST LEAK THAT I SMELL WHEN I ENTER THE HIGHWAY. I ALSO SMELL THIS ODOR WHEN I TOW MY WAVE RUNNER. THE ODOR IS SO STRONG THAT MY SON VOMITED WHILE IN THE VEHICLE. I TOOK MY 2017 FORD EXPLORER TO THE DEALER AND THEY TOLD ME THAT THEY WERE AWARE OF THE PROBLEM BUT CAN NOT FIX IT. THIS IS A BRAND NEW VEHICLE THAT I CANNOT DRIVE AND FORD DOES NOT CARE. WHAT CAN I DO? I GOOGLED THIS ISSUE TO SEE IF ANYONE ELSE IS HAVING THIS ISSUE AND I FOUND THAT THERE IS A LAWSUIT AGAINST FORD FOR THIS SAME ISSUE WITH 2011… Look up ODI 10906040 at NHTSA ↗ | 16722.8%ODI 11072324 · 5 miTHE CAR INTERMITTENTLY WREAKS OF GAS FUMES (NOT CARBON MONOXIDE) ON THE INSIDE OF THE CARE. THIS PRIMARILY HAPPENS BETWEEN 1/4 TO TO A FULL GAS TANK. THE SMELL ALWAYS OCCURS AFTER A GAS FILL UP. THE GAS TANK IS NEVER OVERFILLED. IT ALSO HAPPENS WHEN TAKING A SHARP TURN AFTER A STOP SIGN/LIGHT, AND WHEN BRAKING SWIFTLY. LIVING IN A NORTHERN CLIMATE, THE GAS SMELL GETS TO BE SO BAD, THAT WINDOWS NEED TO PERIODICALLY BE OPENED IN ORDER TO VENT THE VEHICLE OF GAS SMELL. THIS DOES NOT GO OVER WELL WHEN IT IS ZERO OUTSIDE. WITH OVER 3500 MI… Look up ODI 11072324 at NHTSA ↗ | 4715.8%ODI 11233031 · 3,000 miTHE 2019 FORD EXPLORER IS DELIVERED NEW WITH ONE INADEQUATE HORN. ALL OTHER MODEL YEARS HAVE TWO HORNS AND ARE WHAT YOU EXPECT FROM A HORN. THIS IS A DANGEROUS SITUATION, THE HORN IS SO LOW I COULD NOT SCARE A SQUIRREL. FORD MOTOR COMPANY SAID THEY CANNOT UPGRADE. THE FORD DEALER SAID THEY CANNOT UPGRADE WITHOUT EFFECTING THE WARRANTY. Look up ODI 11233031 at NHTSA ↗ | 20716.9%ODI 11282678 · 75 miHAVE EXTREMELY STRONG EXHAUST FUMES COMING IN THE FRESH AIR INTAKE-MAKING ME AND MY PASSENGERS EXTREMELY SICK-NAUSEUS, REALLY BAD HEADACHES, EXTREMELY SLEEPY, ACID REFLUX AND EVEN HAVE PEOPLE ASK HALF HOUR AFTER LEAVING THE VEHICLE IF WE'VE BEEN STANDING NEXT TO AN EXHAUST PIPE!!!! ONE OF THESE TIMES, IM NOT GOING TO REALISE JUST HOW TIRED ITS MAKING ME-THAT I CRASH AND KILL MYSELF OR WORSE KILL SOMEONE ELSE OR FAMILY!! SERIOUS ISSUE ANS FORD CLAIMS......NOTHING WRONG!! [XXX]!! THIS IS A DEADLY FLAW THAT NEEDS TO BE DEALT WITH RIGHT NOW!!! WAY … Look up ODI 11282678 at NHTSA ↗ | 8419.5%ODI 11429352Constant shuddering between 30-45mph. Local dealer fobs it off as typical, I've driven other 2020 and 2021 Explorers, none have exhibited similar symptoms. Dealer refuses to repair, Ford corporate will not investigate. Has already had one rear axle replaced under warranty, not waiting another 3 weeks for parts when this one breaks again. Look up ODI 11429352 at NHTSA ↗ | 5520.6%ODI 11470468Purchased car 5/31/22 from Apple Ford, 8800 Stanford Blvd, Columbia MD 21045. Started hearing sounds of rodent infestation 2 days later. Sporadic scurrying sounds that seemed to be coming from metal frame area above headliner in the car. Have recorded the sounds and attempted to share this verification of infestation with dealership, to no avail. As disabled vet w/anxiety/ptsd, scurrying sounds are unnerving, rodents are known to cause wiring damage which affects vehicle safety, sudden emergence of rodents when operating vehicle is addition… Look up ODI 11470468 at NHTSA ↗ | 2522.7%ODI 11532171I purchased a new 2023 Ford Explorer and during the finance process I found out it had a rear back up camera recall . I wasn’t able to take possession of my vehicle . It’s been sitting on the car dealership lot where I bought it . I bought it May 26th and the repair still hasn’t been resolved !! I want my vehicle !! I’m making a substantial payment on a vehicle I can’t have !!!! Please resolve this ASAP !!!! Look up ODI 11532171 at NHTSA ↗ | 419.0%ODI 11595059This vehicle has a 360 camera system that was not included, despite is being included in the component package that is standard for this vehicle. I contacted the dealer directly, informed them that there are cameras installed on the vehicle, but only the rear camera is operational. Further investigation into the matter revealed that Ford apparently "recalled" the camera systems on the Explorer for the 2023 models, but has not distributed any information to its dealers. Now I have a forward facing camera that is not operational, but the vehic… Look up ODI 11595059 at NHTSA ↗ | 1716.8%ODI 11631832Hands free connection from cell phone to vehicle speakers and mic won't work properly. I consider this a safety issue as it requires me to pickup phone and turn off Bluetooth and work phone manually, looking at it, rather than hands-free. Dealer says corporate has no resolution. Ford consumer line said they're aware but no idea when or if a resolution will be available. Look up ODI 11631832 at NHTSA ↗ | 1026.3%ODI 11730076I was driving home from work on the interstate. It was not overly crowded and not many vehicles around me. I was going the speed limit. All the sudden I heard a loud pop and a very loud sound. I wasn’t sure exactly what happened. I thought maybe I blew a tire so I pulled over to the side of the road. I then figured out that my sunroof had shattered/exploded in my brand new 2026 ford explorer. I just purchased it new on 1/30/26 and it has approx 3k mileage. Luckily I had the shade on my sunroof closed otherwise glass would have been everywhe… Look up ODI 11730076 at NHTSA ↗ | 0UnavailableNo examples available for this selection. |
|---|
| Power Train | 1185.3%ODI 10493132 · 224 miTHE SHIFTER CLICKS AS SOON AS I PUT THE GEAR IN PARK. TOOK IT TO DEALERSHIP AND WAS TOLD THAT IT IS NORMAL. I HAVE QUITE A FEW BAD EXPERIENCES WITH MY PREVIOUS CARS THAT I KNOW WHEN SOMETHING IS NOT NORMAL. TAKING THE CAR AGAIN TOMORROW SINCE IT KEEPS ON HAPPENING. IT'S ONLY BEEN 4 DAYS SO THE CAR SHOULD NOT HAVE ANY PROBLEMS. *TR Look up ODI 10493132 at NHTSA ↗ | 744.4%ODI 10533188 · 1,100 miI BOUGHT MY FORD EXPLORER 2014 ON JULY 1ST 2013. ON AUGUST 1ST, 2013, MY CAR DID NOT MOVE FORWARD WHILE I STARTED THE CAR AND PUT IT TO 'D' (DRIVE) IN A PARKING LOT. INSTEAD, THE CAR WENT BACKWARDS WHILE I STEPPED ON GAS. I WAS VERY CONFUSED, AND THOUGHT IT WAS MY ILLUSION. SO I STEPPED ON BRAKE AND CHECKED THE DRIVE PANEL, THE LIGHT FOR 'D' IS ON. THEN I SWITCH TO 'P' AND AFTER A FEW SECONDS PUT TO 'D' AGAIN. HOWEVER, MY CAR STILL WENT BACKWARD AND MY REAR BUMP HIT THE FRONT BUMPER OF ANOTHER CAR WHICH PARK BEHIND MINE. THEN I GOT CONFIRM… Look up ODI 10533188 at NHTSA ↗ | 844.7%ODI 10725238 · 2,100 miDURING AND AFTER ACCELERATION AT ANY SPEED THERE IS A VERY STRONG SULPHUR SMELL IN THE CABIN OF THE VEHICLE. IT APPEARS TO ENTER FROM THE REAR OF THE VEHICLE AND IT MUST BE EXHAUSTED BY OPENING THE WINDOWS EVERY SINGLE TIME. THE FUMES CONTAIN CO2 AND ARE VERY DANGEROUS TO ALL WITHIN THE VEHICLE. ALL PASSENGERS COMPLAIN OF A LIGHT HEADACHE AND NAUSEA. Look up ODI 10725238 at NHTSA ↗ | 2008.1%ODI 10864072 · 7,794 miVEHICLE LOST ACCELERATION SUDDENLY: FIRST TIME HAPPENED WHEN I STOPPED AT THE INTERSECTION WAITING THE TRAFFIC TO CLEAR AND WHEN I WANT THE VEHICLE TO ACCELERATE IT DID NOT SO I PULLED OVER AND TURNED ENGINE OFF AND RESTART IT FIVE MINUETS LATER AND THE VEHICLE ACCELERATE AND I MANAGE TO REACH MY DESTINATION, NEXT DAY I TOOK THE VEHICLE TO FORD DEALER BECAUSE THE SERVICE POWERTRAIN FAULT ILLUMINATES. FORD DEALER SAID THAT THE PROBLEM IS THE THROTTLE BODY MALFUNCTION AND NEED TO BE REPLACED BUT THE PART IS ON A BACK ORDER AND IS NOT AVAILABLE FO… Look up ODI 10864072 at NHTSA ↗ | 1146.7%ODI 11011958 · 20 miUPON PARKING OUR BRAND NEW EXPLORER IN OUR DRIVEWAY (IT HAS A 10 DEGREE SLANT), WE TURNED OFF THE KEYLESS/PUSH BUTTON IGNITION, BUT MY HUSBAND ACCIDENTALLY HAD IT IN DRIVE. OUR SMALL CHILDREN WERE UNCLIPPING THEIR SEATBELTS AND STARTING TO GET OUT OF THE VEHICLE WHEN MY HUSBAND TOOK HIS FOOT OFF THE BRAKE. WITH THE CAR IN DRIVE AND IGNITION OFF, IT ROLLED BACK VERY QUICKLY DOWN OUR DRIVEWAY. THIS COULD HAVE BEEN DEADLY TO OUR SMALL CHILDREN HAD THEY OPENED THEIR DOORS. I CALLED FORD.COM WHO TOLD ME TO CALL THE DEALER. I CALLED DEALER. THEY TOO… Look up ODI 11011958 at NHTSA ↗ | 486.6%ODI 11127949MY 2016 EXPLORER HAS 74,000 MILES AND THE RPM NEEDLE IS STICKING. HAD IT EVALUATED AND FOUND TRANSMISSION NEUTRAL OUT ON A 2/3 SHIFT AND A 4/5 SHIFT. FLUID LEVEL IS CORRECT, THIS IS DUE TO EXCESSIVE CLEARANCE IN THE DIRECT CLUTCH. THE FORD DEALERSHIP RECOMMEND OVERHAUL OR REPLACEMENT. REPLACEMENT IS ON BACK ORDER AND WOULD TAKE SEVERAL MONTHS TO GET. I CALLED THE FORD CUSTOMER SERVICE AND GOT A CASE #CAS15675568. HAVE REACHED OUT TO THE DEALER SHIP AND THEY ARE DISCUSSING AND IT HAS NOW BEEN 48 HRS. WHAT IS DIFFICULT ABOUT MAKING A DECISI… Look up ODI 11127949 at NHTSA ↗ | 3110.4%ODI 11487140Transmission torque converter and transmission clutches malfunctioning. Yes it's available for inspection if needed. Safety is an issue because car shudders when driving. Yes, problem has been observed by a dealer. And has been inspected with an estimated cost of $5,100+ No warning lights come on to know to assess the issue. Look up ODI 11487140 at NHTSA ↗ | 48039.2%ODI 11288974 · 1,896 miI PURCHASED A 2020 FORD EXPLORER AT SAMES FORD IN LAREDO, TX. THE VEHICLE WAS RECEIVED 11 SEPT 2019. THE VEHICLE BROKE DOWN ON 18 SEPT 2019 IN INDIANA (MILEAGE 1896) WHILE IN MOTION ON THE HIGHWAY. THE VEHICLE WAS TOWED TO AUTO PARK FORD IN STERGIS, MICHIGAN. THE PROBLEM WAS THE TRANSMISSION OIL COOLER, WHICH I NOW KNOW IS ENDEMIC TO THIS MODEL. I WAS TOLD THE FAILURE OF THE TRANSMISSION OIL COOLER HAD ALSO CAUSED THE TRANSMISSION TO FAIL. THE TRANSMISSION & OIL COOLER WERE REPLACED AND I HAD TO DRIVE FROM NEW YORK TO MICHIGAN AT MY OWN EXPENSE… Look up ODI 11288974 at NHTSA ↗ | 11727.2%ODI 11414737 · 111 miI PURCHASED A FORD EXPLORER ST 2021 IN NEW YORK FROM CITY WORLD FORD ON BOSTON RD IN THE BRONX ON APRIL 22, 2021 AT APPROXIMATELY 9:37PM. I TOOK MY CAR HOME THE SAME SAME DAY. THE FOLLOWING DAY (SECOND DAY) I STARTED EXPERIENCING A PRE-COLLISION ASSIST NOT AVAILABLE AND POWERTRAIN MALFUNCTION/REDUCED POWER LIGHT ON MY DASHBOARD AT 12:49 PM. THE CAR BEGAN TO JERK AND FELT LIKE IT WAS ON AWD MODE. THE GAS PEDAL WAS HEAVY AND DIFFICULT TO DRIVE WHILE I WAS ON THE HIGHWAY WITH MY CHILDREN. I STARTED TO SMELL FIRE COMING FROM THE INSIDE OF MY CAR. O… Look up ODI 11414737 at NHTSA ↗ | 5821.7%ODI 11461576Ford released a bulletin - 22S27- to all dealers to immediately stop demo/delivery for all new Explorers in stock as of 4/19/22. At issue is a possibility of a fractured bolt that causes the differential to separate and cause "severe vibration" rendering the vehicle disabled. No fix was mentioned other than a software update possibly by the end of June 22 (2d qtr). This is serious if dealers are told to stop delivery! I just got mine in the beginning of April. Ford needs to step up and address this to ALL owners and not just dealers. It appears… Look up ODI 11461576 at NHTSA ↗ | 1210.9%ODI 11513768The transmission was very difficult time trying to figure out how to start shifting gears, and when it did I felt very hard shifting. The engine revved up, struggled to rev up when accelerating, held gears, chugged, slipped, it felt extremely lazy, and hard shift. The RPMs were fluctuating like crazy. You slam on the accelerator the RPMs start going up then it starts fluctuating crazy. Look up ODI 11513768 at NHTSA ↗ | 14.8%ODI 11619992Hello, I bought 2024 ford explore in Aug 2024 with a few hundred miles on it!! Now two months down the road with 5500miles on it, it is jerking real hard when driving or passing vehicles and slowing down!! The drive mode is in normal at all times. I took it back to where I bought it in Booneville does place and they sent me to ford place in Paris ark where they are ordering a part to see if it fix it or if I need a new transmission. Is this a lemon or what Look up ODI 11619992 at NHTSA ↗ | 1514.9%ODI 11629443We have experience a wrench light on the dash in regards to a powertrain malfunction. I have done some research, it seams that there are a lot of other ford explorer owners that are experiencing this. I have found that there is also a possible TSB for this. Just wondering if this TSB could be recall eligible. Look up ODI 11629443 at NHTSA ↗ | 37.9%ODI 11737580At approximately 1,700 miles, my brand-new 2026 Ford Explorer ST (3.0L EcoBoost) suffered a sudden, catastrophic engine failure while driving, causing an immediate and dangerous loss of motive power. Prior to the failure, the engine experienced severe misfires. Following manufacturer Technical Service Bulletin (TSB) guidance regarding EcoBoost engine misfires, a step-colder spark plug heat range (NGK LTR7IX-11) was utilized to remedy pre-ignition. Ford Motor Company has denied warranty coverage for this catastrophic powertrain failure, falsely … Look up ODI 11737580 at NHTSA ↗ | 0UnavailableNo examples available for this selection. |
|---|
| Structure | 2008.9%ODI 10535838 · 1,800 miWATER COMING IN THE VEHICLE THROUGH THE THIRD ROW PASSENGER SEATBELT..IT THEN DRIPS ON THE SEAT ..HAD IT AT THE DEALER THREE TIMES ALREADY..THEY DO NOT HAVE A CLUE HOW TO FIX IT. *TR Look up ODI 10535838 at NHTSA ↗ | 17910.7%ODI 108914372014 FORD EXPLORER. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO RUST ALONG FRONT EDGE OF VEHICLE HOOD. DEALERSHIP REFUSES TO REPLACE HOOD OR INCLUDE REQUESTS UNDER EXTENDED WARRANTY PROTECTION. *SMD IT WAS FINALLY DETERMINED, IT WAS NOT RUST AS THE CONSUMER BELIEVED. THE CONSUMER RETURNED TO THE DEALER, WHERE THEY REPAIRED AND REPAINTED THE HOOD. THE CONSUMER REQUESTED A REPLACEMENT HOOD, BUT THE FORD REPRESENTATIVE STATED IT WOULD NOT HELP AS THE NEW HOOD WOULD HAVE THE SAME PROBLEM. IN OTHER WORDS, THE SAME REPAIR WOULD LIKELY OC… Look up ODI 10891437 at NHTSA ↗ | 26114.5%ODI 10809612 · 1,000 miTL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS AN ABNORMAL ODOR IN THE VEHICLE WHILE DRIVING APPROXIMATELY 45-65 MPH. THE FAILURE HAPPENED WITHOUT WARNING. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WERE APPROXIMATELY 20 HOLES THAT NEEDED TO BE RESEALED. PRIOR TO THE FAILURE, THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VENTILATION CABIN NEEDED TO BE RESEALED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MA… Look up ODI 10809612 at NHTSA ↗ | 37415.2%ODI 11425190The contact owns a 2016 Ford Explorer. The contact received a recall notification for NHTSA Campaign number: 21V316000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Vin tool confirms parts not available. Look up ODI 11425190 at NHTSA ↗ | 37522.2%ODI 11149985 · 40,000 miTL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 65 MPH, THE KEYLESS ENTRY PAD ON THE EXTERIOR OF THE DRIVER'S DOOR FRACTURED AND FELL OFF INTO TRAFFIC. SIMULTANEOUSLY, THE 'LIFTGATE AJAR' MESSAGE ILLUMINATED. THE CONTACT STOPPED AT A NEARBY FUEL STATION AND ATTEMPTED TO CORRECT THE FAILURE BY APPLYING MASKING TAPE TO RE-ATTACH THE KEYLESS ENTRY PAD TO THE DOOR. THE CONTACT STATED THAT SEVERAL WIRES WERE EXPOSED IN THE PROCESS. SUPREME FORD OF SLIDELL (400 EAST HOWZE BEACH ROAD, SLIDELL, LOUISIANA 70461, [phone removed]) W… Look up ODI 11149985 at NHTSA ↗ | 17724.2%ODI 11429419 · 35,872 miThe contact owns a 2018 Ford Explorer. The contact stated that while driving at an unknown speed, the passenger’s side window frame detached without warning. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA for assistance. The failure mileage was 35,872 Look up ODI 11429419 at NHTSA ↗ | 10434.9%ODI 11421113The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA campaign number 21V316000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. Vin tool showed no open recall. Look up ODI 11421113 at NHTSA ↗ | 30.2%ODI 11608742 · 66,000 miThe contact owns a 2020 Ford Explorer. The contact stated that while driving approximately 30 MPH, the interior panoramic sunshade cover detached from the interior roof headliner and fell inside the cabin of the vehicle. The vehicle was taken to the local dealer who determined that the sunshade cover needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 66,000. Look up ODI 11608742 at NHTSA ↗ | 40.9%ODI 11604001 · 52,000 miThe contact owns a 2021 Ford Explorer. The contact stated while driving approximately 60 MPH, the contact observed that the driver’s side A-pillar trim had detached. The vehicle was steered to the side of the road and trim taped down. The vehicle was taken to a dealer where it was diagnosed that the A-pillar trim needed to be replaced. The vehicle was not prepared. The contact believed that the failure was associated with NHTSA Campaign Number: 24V031000 (Structure); however, the VIN was not included. The manufacturer was notified of the failur… Look up ODI 11604001 at NHTSA ↗ | 10.4%ODI 11749368 · 50,000 miThe contact owns a 2022 Ford Explorer. The contact stated that the sunroof sunshade detached from the inner roof and sagged downward, creating a visibility hazard. The contact stated that the rearview mirror view was obstructed due to the failure. The contact stated that the failure was caused by faulty clips securing the sunshade. The vehicle was not yet repaired. The manufacturer and a local dealer were notified of the failure. The failure mileage was 50,000. Look up ODI 11749368 at NHTSA ↗ | 21.8%ODI 11594860 · 4,000 miThe contact owns a 2023 Ford Explorer. The contact stated that while driving at an undisclosed speed, the wheel well inner liner fell onto the tire. The wheel well liner was rubbing on the tire. The tires were rubbing with ice, mud, and snow in the wheel well. The vehicle was taken to the local dealer, where it was diagnosed that the bracket and bolts for the wheel well liner were missing. The vehicle was not repaired. The manufacturer was contacted and informed the contact that there was no repair coverage on the vehicle for the failure. The f… Look up ODI 11594860 at NHTSA ↗ | 00.0%No examples available for this selection. | 11.0%ODI 11677512 · 15,000 miThe contact owns a 2025 Ford Explorer. The contact stated while driving 65 MPH, there was an abnormal windy sound coming from the driver's side-view mirror. The vehicle was taken to two different dealers, where it was determined that the turbulence was caused by the mirror. The contact was informed that the molding was different from the passenger's side-view mirror molding. The dealer determined that driver's side-view mirror needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance wa… Look up ODI 11677512 at NHTSA ↗ | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Engine | 22510.1%ODI 10472937 · 350 miWHEN ACCELERATING THE VEHICLE QUICKLY WITH THE AIR CONDITIONER ON (DOES NOT MATTER IF IT'S ON FRESH AIR INTAKE OR RECIRCULATING), THERE IS A DEFINITE ODOR OF GASOLINE EXHAUST IN THE CABIN OF THE VEHICLE. THE PROBLEM CAN BE DUPLICATED AT ANY SPEED, FROM A DEAD STOP OR ACCELERATING DURING A PASSING MANEUVER. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP AND TWO TECHNICAL BULLETINS WERE ADDRESSED (ONE FOR A VIBRATION SOUND COMING FROM UNDER THE HOOD WHICH WAS REPAIRED AND THE OTHER FOR THE EXHAUST ODOR IN THE CABIN). UPON COMPLETION OF THE FACTORY… Look up ODI 10472937 at NHTSA ↗ | 19611.7%ODI 10533188 · 1,100 miI BOUGHT MY FORD EXPLORER 2014 ON JULY 1ST 2013. ON AUGUST 1ST, 2013, MY CAR DID NOT MOVE FORWARD WHILE I STARTED THE CAR AND PUT IT TO 'D' (DRIVE) IN A PARKING LOT. INSTEAD, THE CAR WENT BACKWARDS WHILE I STEPPED ON GAS. I WAS VERY CONFUSED, AND THOUGHT IT WAS MY ILLUSION. SO I STEPPED ON BRAKE AND CHECKED THE DRIVE PANEL, THE LIGHT FOR 'D' IS ON. THEN I SWITCH TO 'P' AND AFTER A FEW SECONDS PUT TO 'D' AGAIN. HOWEVER, MY CAR STILL WENT BACKWARD AND MY REAR BUMP HIT THE FRONT BUMPER OF ANOTHER CAR WHICH PARK BEHIND MINE. THEN I GOT CONFIRM… Look up ODI 10533188 at NHTSA ↗ | 22612.6%ODI 10671421 · 30 miPURCHASED A BRAND NEW 2015 FORD EXPLORER. ALMOST IMMEDIATELY BEGAN SMELLING EXHAUST FUMES. CONCERNED THAT THIS WASN'T "NEW CAR BREAK-IN", I PURCHASED A CARBON MONOXIDE DETECTOR WITH MEMORY. OVER A COUPLE OF WEEKS OF DRIVING THE DETECTOR REGISTERED 97 PPM AT PEAK. AFTER CHECKING ON THE INTERNET, I FOUND OTHERS THAT HAVE HAD A SIMILAR PROBLEM. *TR Look up ODI 10671421 at NHTSA ↗ | 38115.5%ODI 10838549 · 4,000 miRADIATOR COOLING FAN SQUEALS LOUDLY WHEN CAR IS IDLE OR DRIVING SLOWLY. CAR HAS ALREADY BEEN IN THE SHOP TO REPLACE THE FAN ONCE. NEW FAN BEGAN SQUEALING AGAIN WITHIN 30 MINUTES OF DRIVING AFTER REPAIR. CAR ONLY HAS 4000 MILES ON IT. HAVE READ OTHER COMPLAINTS OF FAULTY COOLING FAN BEARINGS. AFRAID FAN WILL STOP WORKING AND CAUSE FIRE OR OVERHEATING. Look up ODI 10838549 at NHTSA ↗ | 23714.0%ODI 10916675 · 604 miAFTER A STOP, THE CAR WAS AT STATIONARY, WAS NOT ABLE TO START THE CAR BY PUSHING THE START BUTTON, GAVE ME ERROR ON THE DASHBOARD "FULL ACCESSORY POWER ACTIVE". TRIED TO TURN IT OFF, AFTER MULTIPLE TIMES OF TRYING, WAS ABLE TO START THE CAR, IT HAS 606 MI ON IT. Look up ODI 10916675 at NHTSA ↗ | 9513.0%ODI 11088714 · 10 miWHEN ACCELERATING, THE SMELL OF EXHAUST FILLS THE CAR. WHEN YOU PRESS THE GAS ALL YOU CAN SMELL IS EXHAUST. IT'S BEEN THIS WAY FROM DAY ONE. FORD TRIED TO FIX IT UNDER RECALL BUT IT DID ABSOLUTELY NOTHING. YOU CAN STILL SMELL IT JUST THE SAME. NO DIFFERENCE AFTER THEIR ATTEMPT TO FIX IT. Look up ODI 11088714 at NHTSA ↗ | 196.4%ODI 11193405 · 4,500 miTL* THE CONTACT OWNS A 2019 FORD EXPLORER. WHILE DRIVING THE VEHICLE, THE CONTACT SMELLED EXHAUST FUMES AND FUEL INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO ADVANTAGE FORD (4000 SE FEDERAL HWY, STUART, FL 34997, [phone removed]) TO BE DIAGNOSED, BUT THE TEST WAS NOT YET COMPLETED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 4,500. Look up ODI 11193405 at NHTSA ↗ | 1159.4%ODI 11298598 · 2,100 miMY BRAND NEW 2020 FORD EXPLORER PLATINUM TOP OF LINE MODEL (VIN [XXX]) BROKE DOWN ON CHRISTMAS EVE 2019 AFTER A COMPLETE ENGINE SEIZURE WITH LESS THAN 2000 MILES AND LEFT US STRANDED WITH MY FAMILY FOR HOURS IN THE MIDDLE OF THE ROAD. THE VEHICLE LOST ALL POWER AND CONTROL AND HAD THIS HAPPENED ON AN INTERSTATE HIGHWAY DOING 80 MILES PER HOUR THE RESULT COULD HAVE BEEN CATASTROPHIC AND POTENTIALLY FATAL. IT HAS BEEN AT THE DEALERSHIP SINCE AND I AM BEING TOLD IT NEEDS A NEW ENGINE BUT FORD CANNOT PROVIDE A DATE WHEN THE ENGINE WILL BE AVAILA… Look up ODI 11298598 at NHTSA ↗ | 4811.2%ODI 11447286A police officer complained of a strong odor of exhaust coming through the hvac vents. Officer complained of a light dizziness feeling. Suv was grounded from service. Complaint was verified. Upon opening of the hood a odor of exhaust gas was smelled on the right side of the motor. No visible leaks could be heard or seen. Suv was driven to our local Ford dealer for repair. Look up ODI 11447286 at NHTSA ↗ | 3011.2%ODI 11471465On four occasions over the past 30 days the vehicle has simply lost power while driving. No acceleration and the vehicle coasts to a stop and will not restart. On a few occasions it restarted after some time. Just shutdown while driving down the road. The third time it happened we took to the dealer and they claimed to fix a fuel pump module. It happened again a few days later. Took it back to the dealer and they claimed it was just low on gas even though it’s happened four times and there was gas in the tank. Took it home from the de… Look up ODI 11471465 at NHTSA ↗ | 109.1%ODI 11513768The transmission was very difficult time trying to figure out how to start shifting gears, and when it did I felt very hard shifting. The engine revved up, struggled to rev up when accelerating, held gears, chugged, slipped, it felt extremely lazy, and hard shift. The RPMs were fluctuating like crazy. You slam on the accelerator the RPMs start going up then it starts fluctuating crazy. Look up ODI 11513768 at NHTSA ↗ | 14.8%ODI 11711981• Driver seat not setting its memory for the driver , and will move on its own and go all the way to dash while setting in it or all the way back . Has happened multiple times and also twice while driving. • Safety at risk could have made me wreck my vehicle if I hadn’t pulled over and the seat stopped what it was doing front and back. • yes , been checked by dealership (4) times in service department. •yes, every code on the dash has appeared and lasted a total 20 minutes and car went into limp mode. Couldn’t turn car on or off. First happ… Look up ODI 11711981 at NHTSA ↗ | 76.9%ODI 11645436While driving on an interstate with my children, my automatic braking system decided their was something in front of my car when there wasn't and slammed on the brakes. There was a semi truck behind us and it almost hit us. Took it to the dealer and all they did was shut the feature off for automatic braking. The interior screens have been reprogrammed twice to fix glitches. the rear hatch has been reprogrammed. The windows continue to randomly roll up and down on their own. My engine decided to not start for an hr before randomly turning on fo… Look up ODI 11645436 at NHTSA ↗ | 615.8%ODI 11733462While driving my new Ford explorer, with 638 miles on it, on the highway I heard a loud pop, and lost power steering. I was barely able to pull the vehicle over to the shoulder to get off the highway. If I would have been on an interstate or a busier highway it could have been very dangerous. I believe that this has put me in danger having to maneuver the vehicle to the side of the highway and sit there while waiting for a tow truck. The Vehicle was towed to the dealership where we bought it. the service manager told us that the engine had blow… Look up ODI 11733462 at NHTSA ↗ | 0UnavailableNo examples available for this selection. |
|---|
| Power Train:Automatic Transmission | 10.0%ODI 11620249 · 102,000 miThe contact owns a 2013 Ford Explorer. The contact stated that while shifting into the park position, the "change to parking mode" warning message was displayed. The vehicle failed to detect that the vehicle was in the park gear. The vehicle was taken to an independent mechanic where the contact was advised to call the manufacturer. A local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 102,000. Look up ODI 11620249 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 30.1%ODI 11460064 · 103,000 miThe contact owns a 2016 Ford Explorer. The contact stated while driving approximately 65 MPH, the vehicle began to shake and shudder when the accelerator pedal was depressed. The contact stated that to control the shudder she slowed the vehicle to the point that the motion stopped and then slowly accelerated back to highway speeds. The contact stated that the shuddering occurred any time the contact attempted to accelerate. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was dia… Look up ODI 11460064 at NHTSA ↗ | 30.2%ODI 11449707 · 61,000 miThe contact owns a 2017 Ford Explorer. The contact stated that while idle with the vehicle in drive or reverse, the vehicle would shudder. The contact stated that there was a lack of full motive power upon acceleration; occasionally, while moving from a stop, the vehicle would shudder while driving. The vehicle was taken to an independent mechanic for diagnostic testing. The mechanic informed him that the failure might be due to the torque converter overheating, causing damage to the torque converter. Additionally, there was possible internal d… Look up ODI 11449707 at NHTSA ↗ | 20.3%ODI 11654141The contact owns a 2018 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the vehicle began to vibrate excessively. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was unknown. Look up ODI 11654141 at NHTSA ↗ | 00.0%No examples available for this selection. | 100.8%ODI 114521452020 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO ISSUES WITH THE TRANSMISSION. THE CONSUMER STATED THE VEHICLE EXPERIENCED SEVERE VIBRATIONS AT CERTAIN SPEEDS AND AS THE TRANSMISSION SHIFTS. THE CONSUMER STATED THAT THE MANUFACTURER BREACHED IT'S CONTRACTUAL OBLIGATION BY FAILING TO PROPERLY AND TIMELY REPAIR THE VEHICLE. Look up ODI 11452145 at NHTSA ↗ | 20.5%ODI 11457587Approximately 1.5 months ago, my ford explorer started having issues with shifting frm drive to reverse or reverse to drive, stopped to reverse and stop to drive. I had my oil changed and there were 2 updates to the transmission that were done. The problem persists. When going through a car wash in which you put the car in neutral and ride through as it washes, I placed the car in neutral and almost hit the vehicle in front of me due to it taking 3-4 seconds to shift from drive to neutral. Look up ODI 11457587 at NHTSA ↗ | 10.4%ODI 11575750 · 10,000 miThe contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, the reverse mode did not function as needed. The contact stated that when the gear shifter was shifted to reverse mode, the vehicle rolled either forward or backwards and then hesitated. The vehicle was taken to the dealer, however the failure was not diagnosed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000. Look up ODI 11575750 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Tires:Tread/Belt | 10.0%ODI 11279916TL* THE CONTACT OWNS A 2013 FORD EXPLORER EQUIPPED WITH HANKOOK VENTUS S1 NOBLE 2 TIRES, SIZE: 255/50R20. WHILE THE CONTACT WAS WASHING THE VEHICLE, SHE NOTICED THAT BOTH FRONT TIRES WERE SHREDDING. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIRES WOULD WORSEN OVER TIME BEFORE NEEDING TO BE REPLACED. THE TIRES WERE NOT REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS NOT NOTIFIED. THE TIRE AND VEHICLE FAILURE MILEAGES WERE UNKNOWN. Look up ODI 11279916 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 20.1%ODI 11014656 · 16,000 miTL* THE CONTACT OWNS A 2016 FORD EXPLORER EQUIPPED WITH HANKOOK VENTUS S1 NOBLE 2 TIRES, SIZE: 255/50/R20 (NA). WHILE THE VEHICLE WAS PARKED, THE CONTACT BECAME AWARE OF CHUNKS OF TIRE MISSING FROM THE TIRE. THE VEHICLE WAS TAKEN TO A TIRE FACILITY TO BE INSPECTED. THE CONTACT WAS NOT GIVEN A CAUSE FOR THE TIRE FAILURE. THE MANUFACTURER WAS CONTACTED AND MADE AWARE OF THE FAILURE. THE APPROXIMATE TIRE AND VEHICLE FAILURE MILEAGE WAS 16,000. Look up ODI 11014656 at NHTSA ↗ | 50.3%ODI 11104082 · 24,000 miTL* THE CONTACT OWNS A 2017 FORD EXPLORER EQUIPPED WITH HANKOOK VENTUS S1 NOBLE 2 TIRES, SIZE: 255/50R20. THE CONTACT STATED THAT ALL FOUR TIRES EXPERIENCED PEELING AND TREAD CHIPPING. THE VEHICLE WAS TAKEN TO THE DEALER (AUTONATION FORD, 1400 INTERSTATE 20, ARLINGTON TX), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 24,000. THE VIN WAS NOT AVAILABLE. Look up ODI 11104082 at NHTSA ↗ | 30.4%ODI 11367079 · 24,000 miTL* THE CONTACT OWNS A 2018 FORD EXPLORER EQUIPPED WITH HANKOOK TIRES, TIRE LINE: VENTUS S1 NOBLE, TIRE SIZE: 255/50/R20, DOT NUMBER: 5MNC1AH3917. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL VIBRATION IN THE VEHICLE DUE TO CUPPING OF THE TIRES. THE CONTACT STATED THAT THE DRIVER'S SIDE FRONT TIRE HAD EXPERIENCED TREAD SEPARATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER HUNTLEY FORD LOCATED AT 13900 AUTO MALL DR, HUNTLY, IL 60142 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE BUT OFFERE… Look up ODI 11367079 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Structure:Body | 22410.0%ODI 10473133 · 250 miTL* THE CONTACT OWNS A 2013 FORD ESCAPE. THE CONTACT STATED BOTH THE FRONT DRIVER AND PASSENGER LOWER DOOR SEALS WERE NOT EQUIPPED WITH A SLIP RESISTANT SAFETY TREAD. THE PASSENGER SLIPPED AND FELL WHEN ENTERING THE DOOR AS HER FOOT WAS PLACED ON THE DOOR SEAL. THE PASSENGER SLIGHTLY BUMPED HER HEAD AND SUSTAINED AN ABRASION TO THE LEG. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE DOOR SEAL WAS A MANUFACTURERS DESIGN. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 250. Look up ODI 10473133 at NHTSA ↗ | 925.5%ODI 10563009 · 10 miTL* THE CONTACT RENTED A 2014 FORD EXPLORER. THE CONTACT STATED THAT HE ATTEMPTED TO OPEN THE REAR CUP HOLDER BUT FOUR OF HIS FINGERS BECAME STUCK INSIDE OF THE PLASTIC HOLDER. THE CONTACT STATED THAT HE HAD TO PRY THE HOLDER OPEN IN ORDER TO RELEASE HIS FINGERS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 10. THE VIN WAS UNAVAILABLE. Look up ODI 10563009 at NHTSA ↗ | 1327.4%ODI 10706528 · 900 miI AM GOING INTO THE 5TH MONTH OF LEASING MY 2015 FORD EXPLORER AND I AM NOT HAPPY WITH THIS VEHICLE. CURRENTLY THE ODOMETER READS 2,100 MILES AND THEY WERE NOT ENJOYABLE MILES. I HAVE TO SAY THAT THIS 2015 EXPLORER HAS THE WORST DESIGN ON THE INSIDE THAT I'VE EVER SEEN. THE OUTWARD VISIBILITY FROM THE DRIVER'S SEAT FOR THE FRONT AND REAR OF THIS VEHICLE IS SEVERELY COMPROMISED BY THE HUGE C PILLARS WHICH CREATE BLIND SPOTS WITHIN THE VEHICLE. ALTHOUGH THIS MODEL HAS BLIS, I'VE ALMOST BEEN IN 2 COLLISIONS BECAUSE I CANNOT SEE MY RIGHT SIDE… Look up ODI 10706528 at NHTSA ↗ | 2018.2%ODI 10861521 · 250 miTHE AUTOMATIC LIFTGATE FUNCTIONED ON ITS OWN WITHOUT ANY OPERATOR INPUT. THIS HAS HAPPENED 3 TIMES WITHIN APPROXIMATELY ONE MONTH OF OWNERSHIP. ALSO ONE INSTANCE OF LIFTGATE CLOSING ON HEAD. FORD CLAIMS THEY ARE AWARE OF SIMILAR COMPLAINTS AND IS WORKING ON A FIX.??? IF THE OPERATOR WERE NOT AWARE THIS OCCURRED AND A CHILD OR PET WERE IN THE 3RD ROW, THIS COULD HAVE SERIOUS CONSEQUENCES. PLEASE SEE ATTACHED REPAIR ORDER WITH FORD'S RESPONSE. ALL INSTANCES SO FAR WERE VEHICLE IN PARK WITH OPERATOR NEAR THE REAR END OR BEHIND OF THE VEHICLE. Look up ODI 10861521 at NHTSA ↗ | 26115.4%ODI 10924538 · 415 miVERY STRONG EXHAUST SMELL IN CABIN AFTER HARD ACCELERATION. THE AC WAS ON AND IN THE RECIRCULATION POSITION. THE SMELL IS STRONG AND THE CABIN MUST BE VENTED BY ROLLING THE WINDOWS DOWN TO EVACUATE THE SMELL. Look up ODI 10924538 at NHTSA ↗ | 10013.7%ODI 11078974CRACK ON WINDSHIELD BY BODY AT TOP, NO SCRATCH ABOVE ON PAINT, STRATCH STARTED SMALL AND IS GROWING Look up ODI 11078974 at NHTSA ↗ | 4314.4%ODI 11257685 · 15 miREAR HATCH ELECTRIC OPENING/CLOSING MECHANISM FAILED - HATCH CAME DOWN A STRUCK THE HEAD OF A PERSON CAUSING AN INJURY. ALSO BECAUSE THE HATCH WOULDN'T CLOSE PROPERLY EXHAUST ENTERED THE VEHICLE WHEN BEING DRIVEN. Look up ODI 11257685 at NHTSA ↗ | 322.6%ODI 11326423 · 1,400 miDRIVER DOOR AND WINDOW VIBRATING WHEN REAR WINDOWS ARE ROLLED DOWN IN EXCESS OF 40 MPH. *TR Look up ODI 11326423 at NHTSA ↗ | 174.0%ODI 11443304On October 25, 2021; my wife and I were driving across country when we experienced a blow-out at 75 MPH in New Mexico (about 80 miles west of Amarillo. The blow-out was caused by body cladding, which came off the right rear door of our 2021 Ford Explorer - apparently attributable to 19+ MPH desert cross winds at highway speeds of 75 MPH. The trim lodged in the right rear wheel well; slicing the tire and cutting a gash from the aluminum rim. We had to get to California for a scheduled closing on our new home and were therefore unable to stay in … Look up ODI 11443304 at NHTSA ↗ | 72.6%ODI 11473328While at a gas station I opened the hood to check the oil, and the hood folded backwards far enough to contact, and destroy the windshield. My wife was cleaning the windshield at the time, and narrowly avoided having her hand/forearm severely injured by the hood. This is not supposed to happen. Whatever mechanism that is meant to prevent an incident like this was either defective, or non existent. Look up ODI 11473328 at NHTSA ↗ | 76.4%ODI 11580499For a week before 3/19/24, the driver door made increasing crunching noises when opened and closed. On 3/20/24 the driver door would not open and was subsequently left at Dean Sellers Ford for diagnosis and repair. The dealer relayed that there was a repair advisory on this issue which related to closed investigation / action PE23-013. On 3/21/24, the repair was completed and paid even though Ford Motor has previously agreed to announce a recall by March 2024. As on 4/2/24, no recall notification has been announced or received. Look up ODI 11580499 at NHTSA ↗ | 00.0%No examples available for this selection. | 44.0%ODI 11673960My 2025 Ford Explorer has a wind noise that Ford has admitted to having an issue with. My case number is CXH04811376. In the upper corner of both the drivers and passenger side front window there is a loud wind noise that begins at speeds of 40 mph and more. A Customer Experience Specialist admitted there is a problem but they will not fix it until there is a recall. Look up ODI 11673960 at NHTSA ↗ | 25.3%ODI 11763243Sunroof spontaneously shattered while driving down the road. Look up ODI 11763243 at NHTSA ↗ | 0UnavailableNo examples available for this selection. |
|---|