2021 Forest River SANDPIPER problems and owner complaints

2015 Forest River Sandpiper 365asqb 42’ 5th wheel RV Frame Failure - Our RV has been stationary 90% of the time since it was purchased brand new. Initially the cabinets began opening while in motion and the doors scrubbed as they closed. Within two weeks the center of the roof had a gap where the front cap meets the top of the roof. This was repaired immediately. Over the past four months the center of the RV has progressively gotten worse sagging in the center. While pulling the RV four days ago the RV became uncontrollable while in motion. …

Look up ODI 11634244 at NHTSA ↗

Traveling home from Arkansas towing our RV. No difficulties noted pulled RV.Traveled only DOT roads never boondocking in which case not been taken off road. When pulling out of a Bucees in Pigeon Forge our rear driver side wheels went over a scooped curb. Did not feel it but my husband the driver saw it in the rear view mirror. Stop in Branson MO noted the driver side rear slide did not go out all the way. This has happened with another slide which required an adjustment so we planned to address upon arrival home. Sikeston MO bathroom door woul…

Look up ODI 11657071 at NHTSA ↗

The contact owns a 2024 Forest River Sandpiper. The contact stated that while the RV was parked, the rear of the RV became detached and inoperable. There was no warning light illuminated. The dealer was contacted. The RV was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was not available.

Look up ODI 11724629 at NHTSA ↗

RV WAS PARKED AND WAS PLUGGED INTO SHORE POWER. AN ELECTRICAL CONNECTOR IN THE UNDERBELLY MELTED. THIS CONNECTOR IS USED BETWEEN ROMEX CABLE FROM THE SUPPLY SIDE AND THE OUTLET WHICH IS FEED WITH SO CORD. THERE WAS NO LOAD ON THE OUTLET WHICH WAS CONNECTED TO THE CONNECTOR AT THE TIME IT FAILED. THE FIRST 2 PICTURES ARE OF EACH SIDE OF THE CONNECTOR WHICH FAILED. THE THIRD PICTURE IS THE PLASTIC BARRIER UNDER THE FLOOR WHICH MELTED.

Look up ODI 11415831 at NHTSA ↗

The contact owns a 2020 Forest River Sandpiper. The contact stated that the interior lights would flicker on and off. The contact also stated that they detected a burning odor and was relating it to the converter box and the fuse box shorting out not allowing electrical components to function in the vehicle. The contact stated no warning light was illuminated. The vehicle was not taken to the local dealer nor independent mechanic to be diagnosed or repaired. The manufacturer had been informed of the failure and informed the contact that they co…

Look up ODI 11424581 at NHTSA ↗

We traveled from Clermont, FL to Green Cove Springs, FL. We went through some construction, and when driving, we noticed the passenger side back bunk slide was sitting out from the camper. Then, when we arrived at the campground, we saw our axles were completely shifted to the driver's side. The shift was so extreme that the tires were outside the camper's fender (on the driver's side), and the extreme opposite on the passenger side. This then caused issues with the main slide coming out, as it was hitting the tires. In addition, the slide we n…

Look up ODI 11664263 at NHTSA ↗

This RV is a Manufactured defect Nightmare through Estimates and Insurance Estimate and inspection have 15 defects from [XXX] with over 50 pictures showing Manufacturing defects and inspection from Progressive Insurance found over 53 itemize report with what was wrong with the trailer with over 100 pictures. We had to voluntary surrender this RV to Huntington National bank because no one would help us with the expense to fix this trailer and upon returning this trailer The heating unit of the climate control proceeded to go out and this was th…

Look up ODI 11729476 at NHTSA ↗

I WAS DRIVING DOWN THE ROADS IN COLORADO AND A CAR FLAGGED ME DOWN STATING MY HOLDING TANKS FELL OFF THE TRAILER I LOOKED AN THE FRONT HOLDING TANK HAD FALLEN OFF SOMEWHERE ON THE HIGHWAY DUE TO DEFECTIVE WELDS ON BRACKETS HOLDING TANK IN PLACE. THIS IS A 60 GALLON TANK THAT COULD HAVE CAUSED SEVERAL ACCIDENTS. VEHICLE WAS IN MOTION

Look up ODI 11118104 at NHTSA ↗

When traveling along I-40 in Oklahoma we experienced poor road conditions causing our camper to violently buck, bounce and move excessively while driving. Upon arrival in Texas we noticed cracking along the exterior fiberglass of the unit. We contacted insurance to start the claim process. While talking with industry professionals and progressive insurance it was recommended to have the camper inspected structurally prior to any fiberglass repair. Upon inspection by Certified RV in Elkhart, IN we were informed that our camper has several issues…

Look up ODI 11721638 at NHTSA ↗

THE SANDPIPER MAIN POWER CORD HOOK UP IS DIRECTLY ABOVE THE RV'S FURNACE EXHAUST VENT. THIS FURNACE EXHAUST GETS VERY HOT AND IT HEATS UP THE ELECTRICAL POWER CORD PUTTER RUBBER COVERING TO THE POINT IT STARTED TO SMELL LIKE AN ELECTRICAL FIRE. I KNOW THIS IS A HAZARD, BUT EVEN MORE SO MY WIFE IS HANDY CAPPED AND STAYS IN THE CAMPER. I FEAR FOR LIFE AS WELL AS MY OWN. I KNOW HOW FAST THESE RV CAN BURN. THIS PROBLEM NEEDS TO BE RESOLVED BEFORE IT BECOMES A DISASTER. I'M WRITING THIS TO INFORM YOU OF WHAT I SEE AS A VERY SERIOUS AND POSSIBLE…

Look up ODI 11326420 at NHTSA ↗

The ladder bracket attached to the rear of the RV was not installed into anything structural it was only attached to the RV fiberglass using 4 small screws. When I attempted to climb onto the roof the bracket broke off the RV causing me to fall appx 8-10 to the ground. I was injured as a result of the fall and I needed to go to an Emergency Room for tests and treatment. This ladder is extremely unsafe and will cause bodily harm possibly death to anyone that uses it.

Look up ODI 11623783 at NHTSA ↗

We have repeatedly reported to both the manufacturer and the dealership that there are multiple screws and staples protruding throughout the RV, creating an ongoing safety hazard. These issues were present from the time of purchase and have been documented during prior service visits. The RV has been returned to the dealership numerous rimes for repairs and has been out of service for a significant portion of our ownership since purchasing it in summer of 2025. On April 11, 2026, during only our second night using the RV, I was walking from the…

Look up ODI 11732097 at NHTSA ↗

WHEN DRIVING DOWN THE HIGHWAY THE LIVING ROOM SLIDE OUT COMES OUT APROX 4 INCHES DURING TRANSIT. HAVE TAKEN TO DEALER 4 TIMES AND PROBLEM STILL CONTINUES TO EXIST WHICH IS A SERIOUS SAFETY RISK AND HAZARD TO MYSELF AND OTHERS ON THE ROAD.

Look up ODI 10994062 at NHTSA ↗

When traveling along I-40 in Oklahoma we experienced poor road conditions causing our camper to violently buck, bounce and move excessively while driving. Upon arrival in Texas we noticed cracking along the exterior fiberglass of the unit. We contacted insurance to start the claim process. While talking with industry professionals and progressive insurance it was recommended to have the camper inspected structurally prior to any fiberglass repair. Upon inspection by Certified RV in Elkhart, IN we were informed that our camper has several issues…

Look up ODI 11721638 at NHTSA ↗

We have repeatedly reported to both the manufacturer and the dealership that there are multiple screws and staples protruding throughout the RV, creating an ongoing safety hazard. These issues were present from the time of purchase and have been documented during prior service visits. The RV has been returned to the dealership numerous rimes for repairs and has been out of service for a significant portion of our ownership since purchasing it in summer of 2025. On April 11, 2026, during only our second night using the RV, I was walking from the…

Look up ODI 11732097 at NHTSA ↗

I have driven on these tires 1800 miles since my purchase of the Forest River 5th wheel trailer in 2021. While driving on narrow country road at 35 mph, driver's side rear tire blew. It had little tread wear and blew the tread/belt off of 12" of the tire with a gash on the interior portion of the tire from sidewall to sidewall. The tire pressure was checked prior to driving the 15 miles until the incident and was at 80 psi per the tires limits. The tires are rated to be driven up to 75 mph so I was way under that limit. Replaced with the s…

Look up ODI 11664120 at NHTSA ↗

2015 Forest River Sandpiper 365asqb 42’ 5th wheel RV Frame Failure - Our RV has been stationary 90% of the time since it was purchased brand new. Initially the cabinets began opening while in motion and the doors scrubbed as they closed. Within two weeks the center of the roof had a gap where the front cap meets the top of the roof. This was repaired immediately. Over the past four months the center of the RV has progressively gotten worse sagging in the center. While pulling the RV four days ago the RV became uncontrollable while in motion. …

Look up ODI 11634244 at NHTSA ↗

THE LEAF SPRINGS ON ONE SIDE OF OUR FIFTH WHEEL FAILED DUE TO THE EXCESSIVE WEIGHT ON THAT SIDE (THERE ARE THREE SLIDE OUTS -SANDPIPER 372LOK) THE ORIGINAL LEAF SPRINGS SEEM TO BE INADEQUATE AS THEY HAVE FAILED ON THAT SIDE. WE NEEDED TO INCREASE THE WEIGHT CAPACITY FOR THE LEAF SPRINGS ON THAT SIDE. BECAUSE WE INCREASED IT ON THE ONE SIDE, WE HAD TO INCREASE IT ON THE OPPOSITE SIDE AS WELL. OUR CAMPER IS NOT EVEN A YEAR OLD, AND FOREST RIVER HAS REFUSED TO HONOR THEIR WARRANTY. THEY HAVE INSTEAD SAID THAT IT IS DEXTERS ISSUE. DEXTER HAS S…

Look up ODI 10990608 at NHTSA ↗

Traveling home from Arkansas towing our RV. No difficulties noted pulled RV.Traveled only DOT roads never boondocking in which case not been taken off road. When pulling out of a Bucees in Pigeon Forge our rear driver side wheels went over a scooped curb. Did not feel it but my husband the driver saw it in the rear view mirror. Stop in Branson MO noted the driver side rear slide did not go out all the way. This has happened with another slide which required an adjustment so we planned to address upon arrival home. Sikeston MO bathroom door woul…

Look up ODI 11657071 at NHTSA ↗