U.S. public vehicle records

Grand Design LINEAGE recalls by model year

Explore the records behind recurring owner reports.

Key facts

3 owner complaints analyzed

11 distinct recall campaigns

3,300 mi median reported failure mileage

Scope: 2025 to 2027 model years. Data updated: 2026-10-03 (October 3, 2026). 1 complaints include usable failure mileage. View data status.

Compare model years

Recalls by model year

All campaigns in the snapshot affecting each model year, including recalls announced years later.

From yearThrough year

Recall campaigns

Shared campaigns appear once in each affected model year.

2025

2026

2027

2025: 7; 2026: 10; 2027: 3

First model yearSecond model year

Year-by-year records

Grand Design LINEAGE model-year comparison
Model year	Complaints	Recalls	Change in recalls
2025	3	7	Not available
2026	0	10	+3
2027	0	3	-7

Recall history

11 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.

24V863000 · Equipment:Electrical:Engine Block Heater

Reported: 2024-11-15 (November 15, 2024) · Model years: 2025

Grand Design RV, LLC (Grand Design) is recalling certain 2025 Lineage 25FW motorhomes. The battery warming pad was installed incorrectly, which can damage internal wiring and cause an electrical short.

Consequence: An electrical short increases the risk of a fire.

Remedy: Dealers will replace the battery warming pad, free of charge. Owner notification letters were mailed December 6, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910046.

NHTSA campaign record ↗

25V473000 · Latches/Locks/Linkages | Equipment:Recreational Vehicle/Trailer

Reported: 2025-07-17 (July 17, 2025) · Model years: 2025, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational trailers, equipped with Lippert Modularia entrance doors. The door latch mechanism may fail.

Consequence: Door latch failure may prevent occupants from exiting the vehicle in an emergency, increasing the risk of injury.

Remedy: Dealers will install a new retainer clip and install a secondary retainer to the tension rod, free of charge. Owner notification letters were mailed September 12, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910051.

NHTSA campaign record ↗

26V042000 · Equipment:Electrical:Accessory Generator:Solar Panel | Structure:Critical Fasteners

Reported: 2026-01-23 (January 23, 2026) · Model years: 2025, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.

Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.

Remedy: Dealers will properly secure the solar panels, free of charge. Owner notification letters were mailed March 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910053. This recall has been superseded by Recall 26V276.

NHTSA campaign record ↗

26V058000 · Seats

Reported: 2026-01-30 (January 30, 2026) · Model years: 2025, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage motorhomes. The seat base on the driver and front passenger seat may have been improperly tightened, causing the base to become loose. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, “Seating Systems.”

Consequence: A loose seat base increases the risk of injury in the event of a crash.

Remedy: Dealers will inspect and tighten the seat base, as necessary, free of charge. Owner notification letters were mailed March 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910057.

NHTSA campaign record ↗

26V174000 · Electrical System | Structure:Body:Step/Ladder

Reported: 2026-03-20 (March 20, 2026) · Model years: 2025, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage motorhomes. The entry door position switch may not make adequate contact to read that the door is closed, which allows the steps to deploy unexpectedly.

Consequence: Steps extending while in transit increase the risk of a crash.

Remedy: Dealers will reposition the switch, free of charge. Owner notification letters were mailed May 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910058.

NHTSA campaign record ↗

26V276000 · Structure:Critical Fasteners | Equipment:Electrical:Accessory Generator:Solar Panel

Reported: 2026-04-30 (April 30, 2026) · Model years: 2025, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.

Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.

Remedy: Dealers will install mechanical fasteners, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910059. This recall supersedes NHTSA recall 26V042.

NHTSA campaign record ↗

26V277000 · Seats:Critical Fasteners

Reported: 2026-04-30 (April 30, 2026) · Model years: 2025, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The driver and passenger seat bases may have not been tightened properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, “Seating Systems.”

Consequence: A loose base may allow the seat to move during a crash, increasing the risk of injury.

Remedy: Dealers will inspect and properly tighten the seat bases as necessary, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall M910060.

NHTSA campaign record ↗

26V057000 · Equipment:Recreational Vehicle/Trailer:Plumbing:Freeze Prevention Heater

Reported: 2026-01-30 (January 30, 2026) · Model years: 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2026 Solitude recreational vehicles equipped with a ThermaHeat Tank Pad. The water tank heating pad may experience high resistance and fail.

Consequence: A heating pad failure can increase the risk of a fire.

Remedy: Dealers will inspect the heating pads and replace as necessary, free of charge. Owner notification letters were mailed on March 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910055/M910056.

NHTSA campaign record ↗

26V446000 · Electrical System | Equipment:Recreational Vehicle/Trailer

Reported: 2026-07-10 (July 10, 2026) · Model years: 2026, 2027

Grand Design RV, LLC (Grand Design) is recalling certain 2026-2027 Lineage recreational vehicles equipped with certain MaxxAir N-Series Maxxfan rooftop ventilation fans. The printed circuit board may fail during certain operations and overheat.

Consequence: An overheated printed circuit board increases the risk of a fire.

Remedy: Dealers will inspect and replace the printed circuit board as necessary, free of charge. Owner notification letters were mailed July 21, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910063.

NHTSA campaign record ↗

26V491000 · Equipment:Other:Labels

Reported: 2026-07-28 (July 28, 2026) · Model years: 2026, 2027

Grand Design RV, LLC (Grand Design) is recalling certain 2026-2027 Lineage motorhomes equipped with the 20-inch wheel and tire package. The tire information label may state the incorrect rear tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Wheels and Rims - Other than Passenger Cars."

Consequence: Incorrect tire pressure information can result in over inflated tires, increasing the risk of tire failure and a crash.

Remedy: Dealers will replace the labels, free of charge. Owner notification letters were mailed September 17, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910065.

NHTSA campaign record ↗

26V595000 · Tires

Reported: 2026-09-14 (September 14, 2026) · Model years: 2026, 2027

Grand Design RV, LLC (Grand Design) is recalling certain 2026-2027 Lineage recreational vehicles equipped with the optional Lineage 43 tire package. The vehicle's top speed may exceed the tire's speed rating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Wheels and Rims - Other than Passenger Cars."

Consequence: A tire may fail while traveling at higher speeds, increasing the risk of a crash.

Remedy: The remedy for this recall is under development. Owner notification letters are expected to be mailed November 2, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910067.

NHTSA campaign record ↗

Explore the data

Vehicle analysis explorer

Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.

Data completeness

3 unique complaints in this selection. Analysis snapshot: 2026-10-03.

33.3%Usable mileage1 / 3 records

100.0%Valid incident date3 / 3 records

100.0%Valid filing date3 / 3 records

100.0%Ordered incident and filing dates3 / 3 records

Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.

Problems by model year

Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.

From model yearThrough model year

Component complaint heatmap
Component	2025	2026	2027
Equipment	133.3% ODI 11727477 The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall. Look up ODI 11727477 at NHTSA ↗	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.
Fuel/Propulsion System	133.3% ODI 11681267 On 6/30/25 I originally reported the Safety Issue (Case #11670309). The engine dies while driving. The display indicates "Low Fuel Pressure" and the Check Engine light comes on. The vehicle has been to the Ford Service Center several times for repair. They have validated the issue and have documented the DTS codes. Some components have been replaced or overlaid. My and other's safety has been put at risk. When the engine dies the vehicle has no power steering or power brakes. Pulling over to a safe location is difficult or not available.… Look up ODI 11681267 at NHTSA ↗	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.
Latches/Locks/Linkages	133.3% ODI 11727477 The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall. Look up ODI 11727477 at NHTSA ↗	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.
Structure:Body	133.3% ODI 11754990 · 3,300 mi The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No war… Look up ODI 11754990 at NHTSA ↗	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.
Suspension:Rear:Springs	133.3% ODI 11754990 · 3,300 mi The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No war… Look up ODI 11754990 at NHTSA ↗	0Unavailable No examples available for this selection.	0Unavailable No examples available for this selection.

Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.

Failure mileage by component

Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.

Component failure mileage distribution
Component	Mileage range (25th–75th percentile)	Median	Usable records	Examples
Structure:Body	Too few reports for a range	3,300 mi	1 (sparse)	ODI 11754990 · 3,300 mi The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No war… Look up ODI 11754990 at NHTSA ↗
Suspension:Rear:Springs	Too few reports for a range	3,300 mi	1 (sparse)	ODI 11754990 · 3,300 mi The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No war… Look up ODI 11754990 at NHTSA ↗

Complaint and recall timeline

Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.

ComponentPeriod

Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.

Monthly counts, recall campaigns and complaint examples

Monthly complaint and recall timeline
Month	Complaints	Campaigns announced	Examples
2024-11	0	24V863000	No examples available for this selection.
2024-12	0	None	No examples available for this selection.
2025-01	0	None	No examples available for this selection.
2025-02	0	None	No examples available for this selection.
2025-03	0	None	No examples available for this selection.
2025-04	0	None	No examples available for this selection.
2025-05	0	None	No examples available for this selection.
2025-06	0	None	No examples available for this selection.
2025-07	0	25V473000	No examples available for this selection.
2025-08	1	None	ODI 11681267 On 6/30/25 I originally reported the Safety Issue (Case #11670309). The engine dies while driving. The display indicates "Low Fuel Pressure" and the Check Engine light comes on. The vehicle has been to the Ford Service Center several times for repair. They have validated the issue and have documented the DTS codes. Some components have been replaced or overlaid. My and other's safety has been put at risk. When the engine dies the vehicle has no power steering or power brakes. Pulling over to a safe location is difficult or not available.… Look up ODI 11681267 at NHTSA ↗
2025-09	0	None	No examples available for this selection.
2025-10	0	None	No examples available for this selection.
2025-11	0	None	No examples available for this selection.
2025-12	0	None	No examples available for this selection.
2026-01	0	26V042000, 26V058000, 26V057000	No examples available for this selection.
2026-02	0	None	No examples available for this selection.
2026-03	1	26V174000	ODI 11727477 The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall. Look up ODI 11727477 at NHTSA ↗
2026-04	0	26V276000, 26V277000	No examples available for this selection.
2026-05	0	None	No examples available for this selection.
2026-06	0	None	No examples available for this selection.
2026-07	0	26V446000, 26V491000	No examples available for this selection.
2026-08	1	None	ODI 11754990 · 3,300 mi The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No war… Look up ODI 11754990 at NHTSA ↗
2026-09	0	26V595000	No examples available for this selection.
2026-10 (partial)	0	None	No examples available for this selection.

Emerging complaint spikes

Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.

This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.

No complete months meet the spike thresholds for this selection.

Equal-age model-year comparison

Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.

Observation windowFirst model yearSecond model year

No selected model years have a complete observation window. Choose an eligible year or a shorter window.

Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.

Components reported together

Each cell counts unique complaints naming both components. Open a nonzero cell for examples.

Component co-occurrence matrix
Component	Equipment	Fuel/Propulsion System	Latches/Locks/Linkages	Structure:Body	Suspension:Rear:Springs
Equipment	—	0	1 ODI 11727477 The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall. Look up ODI 11727477 at NHTSA ↗	0	0
Fuel/Propulsion System	0	—	0	0	0
Latches/Locks/Linkages	1 ODI 11727477 The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall. Look up ODI 11727477 at NHTSA ↗	0	—	0	0
Structure:Body	0	0	0	—	1 ODI 11754990 · 3,300 mi The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No war… Look up ODI 11754990 at NHTSA ↗
Suspension:Rear:Springs	0	0	0	1 ODI 11754990 · 3,300 mi The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No war… Look up ODI 11754990 at NHTSA ↗	—

Co-reporting does not establish that one component caused another concern.

Recurring narrative patterns

Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.

Search patterns

2 patterns with matching reports.

Warning lights and dashboard alerts

2 mentions · 66.7% of complaints

Median mileage: 3,300 mi (1 usable records).

ODI 11681267

On 6/30/25 I originally reported the Safety Issue (Case #11670309). The engine dies while driving. The display indicates "Low Fuel Pressure" and the Check Engine light comes on. The vehicle has been to the Ford Service Center several times for repair. They have validated the issue and have documented the DTS codes. Some components have been replaced or overlaid. My and other's safety has been put at risk. When the engine dies the vehicle has no power steering or power brakes. Pulling over to a safe location is difficult or not available.…

Look up ODI 11681267 at NHTSA ↗

ODI 11754990 · 3,300 mi

The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No war…

Look up ODI 11754990 at NHTSA ↗

Matching rule

\b(warning light\w*|check engine|dashboard warning\w*|malfunction indicator)\b

Steering assistance concerns

1 mentions · 33.3% of complaints

Median mileage: Unavailable (0 usable records).

ODI 11681267

Look up ODI 11681267 at NHTSA ↗

Matching rule

\b(power steer\w*|steering assist\w*|steering lock\w*|steering wheel lock\w*)\b