Harley-Davidson FXSTB recalls by model year
Explore the records behind recurring owner reports.
Key facts
11 owner complaints analyzed
2 distinct recall campaigns
4,500 mi median reported failure mileage
Scope: 1999 to 2009 model years. Data updated: . 9 complaints include usable failure mileage. View data status.
Recalls by model year
All campaigns in the snapshot affecting each model year, including recalls announced years later.
Recall campaigns
Shared campaigns appear once in each affected model year.
| Category | Count |
|---|---|
| 1999 | 1 |
| 2000 | 0 |
| 2001 | 0 |
| 2002 | 0 |
| 2007 | 1 |
| 2008 | 0 |
| 2009 | 0 |
1999: 1; 2000: 0; 2001: 0; 2002: 0; 2007: 1; 2008: 0; 2009: 0
Year-by-year records
Recall history
2 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
99V200000 · Fuel System, Gasoline:Storage:Tank Assembly
Reported: 1999-07-23 (July 23, 1999) · Model years: 1999
VEHICLE DESCRIPTION: MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH A FUEL TANK VENT FITTING THAT COULD BE PLUGGED ALLOWING THE CARBURETOR TO OVERFLOW FUEL.
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK VENT FITTING AND, IF PLUGGED, WILL CORRECT THIS CONDITION.
NHTSA campaign record ↗07V173000 · Electrical System:12v/24v/48v Battery:Cables
Reported: 2007-04-26 (April 26, 2007) · Model years: 2007
CERTAIN MOTORCYCLES WERE BUILT WITH A CONDITION THAT PERMITS THE POSITIVE BATTERY CABLE TO CONTACT A WELD BEAD ON THE OIL TANK. THIS MAY CAUSE THE WELD BEAD TO ABRADE THROUGH THE INSULATION ON THE CABLE AND CAUSE AN ELECTRICAL SHORT FROM THE BATTERY THROUGH THE OIL TANK AND OIL LINES.
Consequence: THIS COULD LEAD TO AN OIL LEAK AND/OR POSSIBLE FIRE, WHICH COULD RESULT IN INJURY OR DEATH TO THE RIDER.
Remedy: DEALERS WILL INSTALL A BATTERY CADDY THAT WILL PROTECT THE CABLE AND ENSURE PROPER CABLE ROUTING. THIS RECALL BEGAN ON MAY 4, 2007. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-342-4080.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
11 unique complaints in this selection. Analysis snapshot: 2026-10-01.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 1999 | 2000 | 2001 | 2002 | 2007 | 2008 | 2009 |
|---|---|---|---|---|---|---|---|
| Power Train | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10201683 · 1 miNEW 2007 HARLEY DAVIDSON FXSTB WITH EXCESSIVE HEAT. UNBEARABLE ON WARM DAYS. ALSO A LOUD RATTLE COMING FROM THE DRIVE TRAIN. THE HIGH HEAT IS NOT ONLY DAMAGING THE MOTOR IT MORE IMPORTANTLY DAMAGES THE RIDER AND PASSENGER. THE FIX OFFERED BY HARLEY IS TO BUY $1500 OF UPGRADES. THIS IS A PROBLEM THAT ONLY A RECALL CAN FIX, IT IS NOT UP TO THE CONSUMER TO FOOT THE BILL TO FIX A DEFECTIVE PRODUCT. *JB | 2100.0%ODI 10543546 · 2,100 miI PURCHASED THE VEHICLE WITH 1835 MILES ON THE ODOMETER AND ABOUT A WEEK LATER I NOTICED AN AUDIBLE "CLUNK" WHEN STARTING THE ENGINE. I INVESTIGATED THE PROBLEM ONLINE AND FOUND THAT THIS IS A VERY COMMON PROBLEM AMONGST HARLEY DAVIDSONS WITH THE 96 CID ENGINE. THE SOUND IS THE MECHANICS WITHIN THE ENGINE INTERLOCKING VIOLENTLY WHICH CAN RESULT IN CATASTROPHIC FAILURE. THE SOLUTION TO THE PROBLEM IS THE PURCHASE OF AN UPGRADED COMPENSATOR WHICH TOTAL SEVERAL HUNDREDS OF DOLLARS. PRESENTLY THERE IS NO RECALL IN PLACE. *TR | 00.0%No examples available for this selection. |
| Electrical System | 0UnavailableNo examples available for this selection. | 1100.0%ODI 10712808 · 25,000 miIGNITION LOCK CYLINDER CAME OUT AND STUCK TO KEY. ALWAYS TREATED GENTLY AND CAREFULLY. THIS IS A VERY COMMON PROBLEM BECAUSE OF POOR OUTSOURCING, DEALERS DON'T CARE. HARLEY STILL WON'T ACCEPT EMAIL ON THEIR OWN WEBSITE. THIS FACT MAKES IT QUITE CLEAR THEY WANT NO EVIDENCE OF CORRESPONDENCE REGARDING CUSTOMER COMPLAINTS. IT'S 2015...YOU'D THINK THEY WOULD ACTUALLY RECEIVE EMAIL FROM PEOPLE BY NOW? *TR | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Electrical System:Wiring:Fuses And Circuit Breakers | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 1100.0%ODI 8014156WHENEVER WATER COMES IN CONTACT WITH VEHICLE HEADLIGHTS BLOW UT. DEALER REPLACED TURN SIGNAL ASSEMBLY. THAT DIDN'T CORRECT THE PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Engine And Engine Cooling | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10203716 · 229 miAFTER RECENTLY PURCHASING A NEW MOTOR VEHICLE WITH ONLY (8) MILES THE (CYLINDER HEAD FAILED AFTER 229 MILES DRIVEN)......NO PARTS ARE AVAILABLE STILL UP TO THIS PRESENT TIME. *TR | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Engine And Engine Cooling:Exhaust System:Manifold/Header/Muffler/Tail Pipe | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10201683 · 1 miNEW 2007 HARLEY DAVIDSON FXSTB WITH EXCESSIVE HEAT. UNBEARABLE ON WARM DAYS. ALSO A LOUD RATTLE COMING FROM THE DRIVE TRAIN. THE HIGH HEAT IS NOT ONLY DAMAGING THE MOTOR IT MORE IMPORTANTLY DAMAGES THE RIDER AND PASSENGER. THE FIX OFFERED BY HARLEY IS TO BUY $1500 OF UPGRADES. THIS IS A PROBLEM THAT ONLY A RECALL CAN FIX, IT IS NOT UP TO THE CONSUMER TO FOOT THE BILL TO FIX A DEFECTIVE PRODUCT. *JB | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Exterior Lighting:Brake Lights | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10324681 · 6,000 miTL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FXSTB MOTORCYCLE. THE CONTACT STATED WHILE DRIVING AT APPROXIMATE SPEEDS OF 30 MPH, THE RUNNING AND BRAKE LIGHTS FAILED. THE CONTACT MADE REPAIRS TO THE VEHICLE AND FOUND THE ENTIRE BRAKE LIGHT ASSEMBLY NEEDED REPLACEMENT. THE MANUFACTURER WAS CONTACTED BUT WOULD NOT PROVIDE ANY ASSISTANCE. THE CONTACT STATED THE INCIDENT WAS THE THIRD OCCURRENCE OF THE FAILURE. THE FAILURE MILEAGE WAS 6,000 AND THE CURRENT MILEAGE WAS 22,000. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Structure:Body:Bumpers | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10193357 · 390 miTL*THE CONTACT OWNS A 2007 HARLEY DAVIDSON FXSTB. WHILE TRAVELING 65 MPH, THE CONTACT STRUCK A BUMP IN THE ROAD AND THE SUSPENSION BOTTOMED OUT. THE BUMP CAUSED THE REAR LICENSE PLATE AND BRACKET TO MAKE CONTACT WITH THE REAR TIRE. HE WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. THE DEALER PUT A LARGER BUMPER ON THE VEHICLE. THE # OF CYLINDERS WAS UNKNOWN. THE CURRENT MILEAGE IS 400 AND FAILURE MILEAGE WAS 390. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Suspension:Rear | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10451422 · 10,000 miTL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FXSTB. WHILE PARKED, THE CONTACT REMOVED A REAR WHEEL TO REPLACE THE TIRE AND NOTICED THAT THE SHOULDER OF THE HUB WAS WORN DOWN AROUND ITS CENTER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO DEFECT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 10,000. UPDATED 04/19/12*LJ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| Power Train | Too few reports for a range | 2,100 mi | 3 (sparse) | ODI 10201683 · 1 miNEW 2007 HARLEY DAVIDSON FXSTB WITH EXCESSIVE HEAT. UNBEARABLE ON WARM DAYS. ALSO A LOUD RATTLE COMING FROM THE DRIVE TRAIN. THE HIGH HEAT IS NOT ONLY DAMAGING THE MOTOR IT MORE IMPORTANTLY DAMAGES THE RIDER AND PASSENGER. THE FIX OFFERED BY HARLEY IS TO BUY $1500 OF UPGRADES. THIS IS A PROBLEM THAT ONLY A RECALL CAN FIX, IT IS NOT UP TO THE CONSUMER TO FOOT THE BILL TO FIX A DEFECTIVE PRODUCT. *JB ODI 10543546 · 2,100 miI PURCHASED THE VEHICLE WITH 1835 MILES ON THE ODOMETER AND ABOUT A WEEK LATER I NOTICED AN AUDIBLE "CLUNK" WHEN STARTING THE ENGINE. I INVESTIGATED THE PROBLEM ONLINE AND FOUND THAT THIS IS A VERY COMMON PROBLEM AMONGST HARLEY DAVIDSONS WITH THE 96 CID ENGINE. THE SOUND IS THE MECHANICS WITHIN THE ENGINE INTERLOCKING VIOLENTLY WHICH CAN RESULT IN CATASTROPHIC FAILURE. THE SOLUTION TO THE PROBLEM IS THE PURCHASE OF AN UPGRADED COMPENSATOR WHICH TOTAL SEVERAL HUNDREDS OF DOLLARS. PRESENTLY THERE IS NO RECALL IN PLACE. *TR ODI 11081111 · 40,000 miCLUTCH HUB SPLINE FAILURE DUE TO FAULTY AUTOMATIC CHAIN TENSIONER AND COMPENSATOR SPROCKET. THIS IS APPARENTLY A VERY COMMON ISSUE CAUSING A LOUD CLUNKING WHEN STARTING AND DAMAGING PARTS SUCH AS HAPPENED WITH MY CLUTCH HUB. THE ONLY WAY TO PREVENT IT IS TO CHANGE TO UPGRADED AFTERMARKET COMPENSATOR SPROCKET AND MANUAL CHAIN TENSIONER. QUALITY PARTS FOR THE REPAIR COST OVER $1K |
| Electrical System | Too few reports for a range | 25,000 mi | 1 (sparse) | ODI 10712808 · 25,000 miIGNITION LOCK CYLINDER CAME OUT AND STUCK TO KEY. ALWAYS TREATED GENTLY AND CAREFULLY. THIS IS A VERY COMMON PROBLEM BECAUSE OF POOR OUTSOURCING, DEALERS DON'T CARE. HARLEY STILL WON'T ACCEPT EMAIL ON THEIR OWN WEBSITE. THIS FACT MAKES IT QUITE CLEAR THEY WANT NO EVIDENCE OF CORRESPONDENCE REGARDING CUSTOMER COMPLAINTS. IT'S 2015...YOU'D THINK THEY WOULD ACTUALLY RECEIVE EMAIL FROM PEOPLE BY NOW? *TR |
| Engine And Engine Cooling | Too few reports for a range | 229 mi | 1 (sparse) | ODI 10203716 · 229 miAFTER RECENTLY PURCHASING A NEW MOTOR VEHICLE WITH ONLY (8) MILES THE (CYLINDER HEAD FAILED AFTER 229 MILES DRIVEN)......NO PARTS ARE AVAILABLE STILL UP TO THIS PRESENT TIME. *TR |
| Engine And Engine Cooling:Exhaust System:Manifold/Header/Muffler/Tail Pipe | Too few reports for a range | 1 mi | 1 (sparse) | ODI 10201683 · 1 miNEW 2007 HARLEY DAVIDSON FXSTB WITH EXCESSIVE HEAT. UNBEARABLE ON WARM DAYS. ALSO A LOUD RATTLE COMING FROM THE DRIVE TRAIN. THE HIGH HEAT IS NOT ONLY DAMAGING THE MOTOR IT MORE IMPORTANTLY DAMAGES THE RIDER AND PASSENGER. THE FIX OFFERED BY HARLEY IS TO BUY $1500 OF UPGRADES. THIS IS A PROBLEM THAT ONLY A RECALL CAN FIX, IT IS NOT UP TO THE CONSUMER TO FOOT THE BILL TO FIX A DEFECTIVE PRODUCT. *JB |
| Exterior Lighting:Brake Lights | Too few reports for a range | 6,000 mi | 1 (sparse) | ODI 10324681 · 6,000 miTL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FXSTB MOTORCYCLE. THE CONTACT STATED WHILE DRIVING AT APPROXIMATE SPEEDS OF 30 MPH, THE RUNNING AND BRAKE LIGHTS FAILED. THE CONTACT MADE REPAIRS TO THE VEHICLE AND FOUND THE ENTIRE BRAKE LIGHT ASSEMBLY NEEDED REPLACEMENT. THE MANUFACTURER WAS CONTACTED BUT WOULD NOT PROVIDE ANY ASSISTANCE. THE CONTACT STATED THE INCIDENT WAS THE THIRD OCCURRENCE OF THE FAILURE. THE FAILURE MILEAGE WAS 6,000 AND THE CURRENT MILEAGE WAS 22,000. |
| Structure:Body:Bumpers | Too few reports for a range | 390 mi | 1 (sparse) | ODI 10193357 · 390 miTL*THE CONTACT OWNS A 2007 HARLEY DAVIDSON FXSTB. WHILE TRAVELING 65 MPH, THE CONTACT STRUCK A BUMP IN THE ROAD AND THE SUSPENSION BOTTOMED OUT. THE BUMP CAUSED THE REAR LICENSE PLATE AND BRACKET TO MAKE CONTACT WITH THE REAR TIRE. HE WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. THE DEALER PUT A LARGER BUMPER ON THE VEHICLE. THE # OF CYLINDERS WAS UNKNOWN. THE CURRENT MILEAGE IS 400 AND FAILURE MILEAGE WAS 390. |
| Suspension:Rear | Too few reports for a range | 10,000 mi | 1 (sparse) | ODI 10451422 · 10,000 miTL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FXSTB. WHILE PARKED, THE CONTACT REMOVED A REAR WHEEL TO REPLACE THE TIRE AND NOTICED THAT THE SHOULDER OF THE HUB WAS WORN DOWN AROUND ITS CENTER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO DEFECT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 10,000. UPDATED 04/19/12*LJ |
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 | 0 | None | No examples available for this selection. |
| 2026-10 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2008: 0 complaints · 2009: 1 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2008 | 0 | 0 | 0 |
| 2009 | 0 | 0 | 1 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2008 | 2 | 0 | 0 |
| 2009 | 1 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component | Power Train | Electrical System | Electrical System:Wiring:Fuses And Circuit Breakers | Engine And Engine Cooling | Engine And Engine Cooling:Exhaust System:Manifold/Header/Muffler/Tail Pipe | Exterior Lighting:Brake Lights | Structure:Body:Bumpers | Suspension:Rear |
|---|---|---|---|---|---|---|---|---|
| Power Train | — | 0 | 0 | 0 | 1ODI 10201683 · 1 miNEW 2007 HARLEY DAVIDSON FXSTB WITH EXCESSIVE HEAT. UNBEARABLE ON WARM DAYS. ALSO A LOUD RATTLE COMING FROM THE DRIVE TRAIN. THE HIGH HEAT IS NOT ONLY DAMAGING THE MOTOR IT MORE IMPORTANTLY DAMAGES THE RIDER AND PASSENGER. THE FIX OFFERED BY HARLEY IS TO BUY $1500 OF UPGRADES. THIS IS A PROBLEM THAT ONLY A RECALL CAN FIX, IT IS NOT UP TO THE CONSUMER TO FOOT THE BILL TO FIX A DEFECTIVE PRODUCT. *JB | 0 | 0 | 0 |
| Electrical System | 0 | — | 0 | 0 | 0 | 0 | 0 | 0 |
| Electrical System:Wiring:Fuses And Circuit Breakers | 0 | 0 | — | 0 | 0 | 0 | 0 | 0 |
| Engine And Engine Cooling | 0 | 0 | 0 | — | 0 | 0 | 0 | 0 |
| Engine And Engine Cooling:Exhaust System:Manifold/Header/Muffler/Tail Pipe | 1ODI 10201683 · 1 miNEW 2007 HARLEY DAVIDSON FXSTB WITH EXCESSIVE HEAT. UNBEARABLE ON WARM DAYS. ALSO A LOUD RATTLE COMING FROM THE DRIVE TRAIN. THE HIGH HEAT IS NOT ONLY DAMAGING THE MOTOR IT MORE IMPORTANTLY DAMAGES THE RIDER AND PASSENGER. THE FIX OFFERED BY HARLEY IS TO BUY $1500 OF UPGRADES. THIS IS A PROBLEM THAT ONLY A RECALL CAN FIX, IT IS NOT UP TO THE CONSUMER TO FOOT THE BILL TO FIX A DEFECTIVE PRODUCT. *JB | 0 | 0 | 0 | — | 0 | 0 | 0 |
| Exterior Lighting:Brake Lights | 0 | 0 | 0 | 0 | 0 | — | 0 | 0 |
| Structure:Body:Bumpers | 0 | 0 | 0 | 0 | 0 | 0 | — | 0 |
| Suspension:Rear | 0 | 0 | 0 | 0 | 0 | 0 | 0 | — |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.