Home And Park ROADTREK 190 recalls by model year

Reported: 2000-08-21 (August 21, 2000) · Model years: 1999, 2000

VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON DODGE 2500/3500 VAN CHASSIS AND ON CHEVROLET G-CUT AWAY VAN CHASSIS. THESE MOTOR HOMES WERE BUILT USING FRAMELESS WINDOWS. SOME OF THESE WINDOWS MAY HAVE NOT BONDED CORRECTLY.

Consequence: WHEN THE WINDOWS ARE OPENED/CLOSED, OR WHEN LITTLE PRESSURE IS APPLIED TO THE VENT GLASS, THE BONDING CAN GIVE UP PRODUCING A DELAMINATION BETWEEN VENT GLASS AND ALUMINUM.

Remedy: DEALERS WILL REPLACE THE AFFECTED WINDOWS WITH NEW ONES.

Reported: 2000-12-28 (December 28, 2000) · Model years: 2000

VEHICLE DESCRIPTION: CERTAIN CLASS B MOTOR HOMES BUILT ON DODGE VAN CHASSIS AND EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE BETWEEN JANUARY 28 AND AUGUST 15, 2000. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

Remedy: AM-SAFE NOTIFIED HOME & PARK CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE.

Reported: 2004-09-22 (September 22, 2004) · Model years: 2002, 2004

ON CERTAIN MOTOR HOMES, THE SPARE TIRE CARRIER BRACKET CAN FATIGUE AND LEAD TO FRACTURE.

Consequence: IF THE BRACKET BREAKS, CONTINUOUS VIBRATION MAY CAUSE THE CARRIER TO SLOWLY SLIDE OUT OF THE TRAILER HITCH CROSSTUBE AND FALL ON THE ROAD, WHICH COULD CAUSE A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE SPARE TIRE CARRIER BRACKET BY WELDING IT TO THE TRAILER HITCH CROSSTUBE, ELIMINATING ALL VIBRATION. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT HOME AND PARK AT 1-888-762-3873.

Reported: 2003-03-17 (March 17, 2003) · Model years: 2003

ON CERTAIN MOTOR HOMES BUILT ON CHEVROLET G-VAN CHASSIS, THE CHASSIS FUEL RETURN LINE, WHICH IS TAPPED TO SUPPLY FUEL TO THE GENERATOR, HAS BEEN FOUND TO HAVE PRESSURES THAT EXCEED THE MAXIMUM ALLOWED BY THE GENERATOR MANUFACTURER. AS A RESULT, IF THE GENERATOR IS OPERATED AT THE SAME TIME THE CHASSIS ENGINE IS RUNNING, EXCESS FUEL COULD BE DELIVERED TO THE GENERATOR, CREATING A POTENTIAL FOR A GENERATOR STALL AND POSSIBLE FUEL SPILL.

Consequence: IN THE EVENT OF A FUEL SPILL, A FIRE COULD OCCUR.

Remedy: DEALERS WILL INSTALL AN APPROVED KIT THAT DRAWS THE GENERATOR FUEL SUPPLY DIRECTLY FROM THE FUEL TANK. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HOME & PARK AT 1-888-762-3873.

Reported: 2004-11-12 (November 12, 2004) · Model years: 2003, 2004

ON CERTAIN MOTOR HOMES BUILT ON CHEVROLET 2500/3500 VAN CHASSIS, WHILE REPLACING THE STEEL RIMS WITH ALUMINUM RIMS, INCORRECT VALVE STEMS WITH INCORRECT PRESSURE RATING LOWER THAN THE MAXIMUM PRESSURE ALLOWED FOR THE TIRES WERE INSTALLED.

Consequence: SOME VALVES MAY LEAK AIR INCREASING THE RISK OF A TIRE FAILURE. THIS COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE VALVE STEMS. THE RECALL BEGAN IN NOVEMBER 2004. OWNERS SHOULD CONTACT HOME & PARK AT 1-888-762-3873.

Reported: 2006-05-11 (May 11, 2006) · Model years: 2003, 2004, 2005, 2006

ON CERTAIN MOTOR HOMES BUILT ON CHEVROLET CHASSIS AND EQUIPPED WITH A DECORATIVE DASH TRIM KIT, THE ADHESIVE BACKED SYNTHETIC TRIM IS ATTACHED TO THE DASH, ENGINE COVER, DOOR PANEL AND THE CHEVROLET "BOW TIE" DECAL IS ATTACHED TO THE STEERING WHEEL (DIRECTLY OVER THE EXISTING BOW TIE IMPRESSION). THIS DECAL COULD AFFECT THE DEPLOYMENT OF THE AIR BAG SAFETY RESTRAINT BUILT INTO THE STEERING WHEEL.

Consequence: IN THE EVENT OF A VEHICLE CRASH IN WHICH THE DRIVER SIDE AIR BAG IS DEPLOYED, THE RESULTING FUNCTIONALITY OF THE AIR BAG IS UNCERTAIN, WHICH CAN INCREASE THE RISK OF INJURY TO VEHICLE OCCUPANTS.

Remedy: OWNERS WILL BE INSTRUCTED TO REMOVE THE STEERING WHEEL DECAL. THE RECALL BEGAN ON MAY 30, 2006. OWNERS MAY CONTACT HOME AND PARK AT 1-800-663-0066.

Reported: 2005-11-09 (November 9, 2005) · Model years: 2005, 2006

ON CERTAIN CLASS B MOTOR HOMES BUILT ON CHEVROLET CHASSIS AND EQUIPPED WITH PROPANE BBQ CONNECTION. A RUBBER HOSE IS CONNECTED TO THE PROPANE REGULATOR AT ONE END AND HAS A BRASS SHUTOFF VALVE CONNECTOR ON THE OTHER "FREE END." THE CLAMP USED FOR HOLDING THE BRASS BBQ SHUTOFF VALVE IS NOT INSERTED PROPERLY INTO ITS HOLDING CLAMP.

Consequence: SINCE THE RESTRAINING CLAMP IS MISSING, THE HOSE CAN BOUNCE UP AND DOWN. AS THE VEHICLE IS DRIVEN, THE CONNECTOR CAN FALL TO THE GROUND DRAGGING ONTO THE PAVEMENT AND COULD WEAR A HOLE THROUGH THE HOSE. PROPANE CAN LEAK OUT CREATING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSPECT THE BBQ HOSE CONNECTOR ASSEMBLY, CHECK FOR ANY WEAR, AND REPLACE UNITS. THE UNITS WILL BE RESTRAINED AND CLAMPS WILL BE ADDED TO LIMIT THE LENGTH OF THE FREE END OF THE HOSE. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT HOME AND PARK AT 888-762-3873.