Home And Park ROADTREK 210 recalls by model year

Reported: 2004-09-22 (September 22, 2004) · Model years: 2002, 2003, 2004

ON CERTAIN MOTOR HOMES, THE SPARE TIRE CARRIER BRACKET CAN FATIGUE AND LEAD TO FRACTURE.

Consequence: IF THE BRACKET BREAKS, CONTINUOUS VIBRATION MAY CAUSE THE CARRIER TO SLOWLY SLIDE OUT OF THE TRAILER HITCH CROSSTUBE AND FALL ON THE ROAD, WHICH COULD CAUSE A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE SPARE TIRE CARRIER BRACKET BY WELDING IT TO THE TRAILER HITCH CROSSTUBE, ELIMINATING ALL VIBRATION. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT HOME AND PARK AT 1-888-762-3873.

Reported: 2004-11-12 (November 12, 2004) · Model years: 2003, 2004

ON CERTAIN MOTOR HOMES BUILT ON CHEVROLET 2500/3500 VAN CHASSIS, WHILE REPLACING THE STEEL RIMS WITH ALUMINUM RIMS, INCORRECT VALVE STEMS WITH INCORRECT PRESSURE RATING LOWER THAN THE MAXIMUM PRESSURE ALLOWED FOR THE TIRES WERE INSTALLED.

Consequence: SOME VALVES MAY LEAK AIR INCREASING THE RISK OF A TIRE FAILURE. THIS COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE VALVE STEMS. THE RECALL BEGAN IN NOVEMBER 2004. OWNERS SHOULD CONTACT HOME & PARK AT 1-888-762-3873.

Reported: 2006-05-11 (May 11, 2006) · Model years: 2003, 2004, 2005, 2006

ON CERTAIN MOTOR HOMES BUILT ON CHEVROLET CHASSIS AND EQUIPPED WITH A DECORATIVE DASH TRIM KIT, THE ADHESIVE BACKED SYNTHETIC TRIM IS ATTACHED TO THE DASH, ENGINE COVER, DOOR PANEL AND THE CHEVROLET "BOW TIE" DECAL IS ATTACHED TO THE STEERING WHEEL (DIRECTLY OVER THE EXISTING BOW TIE IMPRESSION). THIS DECAL COULD AFFECT THE DEPLOYMENT OF THE AIR BAG SAFETY RESTRAINT BUILT INTO THE STEERING WHEEL.

Consequence: IN THE EVENT OF A VEHICLE CRASH IN WHICH THE DRIVER SIDE AIR BAG IS DEPLOYED, THE RESULTING FUNCTIONALITY OF THE AIR BAG IS UNCERTAIN, WHICH CAN INCREASE THE RISK OF INJURY TO VEHICLE OCCUPANTS.

Remedy: OWNERS WILL BE INSTRUCTED TO REMOVE THE STEERING WHEEL DECAL. THE RECALL BEGAN ON MAY 30, 2006. OWNERS MAY CONTACT HOME AND PARK AT 1-800-663-0066.

Reported: 2005-11-09 (November 9, 2005) · Model years: 2005, 2006

ON CERTAIN CLASS B MOTOR HOMES BUILT ON CHEVROLET CHASSIS AND EQUIPPED WITH PROPANE BBQ CONNECTION. A RUBBER HOSE IS CONNECTED TO THE PROPANE REGULATOR AT ONE END AND HAS A BRASS SHUTOFF VALVE CONNECTOR ON THE OTHER "FREE END." THE CLAMP USED FOR HOLDING THE BRASS BBQ SHUTOFF VALVE IS NOT INSERTED PROPERLY INTO ITS HOLDING CLAMP.

Consequence: SINCE THE RESTRAINING CLAMP IS MISSING, THE HOSE CAN BOUNCE UP AND DOWN. AS THE VEHICLE IS DRIVEN, THE CONNECTOR CAN FALL TO THE GROUND DRAGGING ONTO THE PAVEMENT AND COULD WEAR A HOLE THROUGH THE HOSE. PROPANE CAN LEAK OUT CREATING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSPECT THE BBQ HOSE CONNECTOR ASSEMBLY, CHECK FOR ANY WEAR, AND REPLACE UNITS. THE UNITS WILL BE RESTRAINED AND CLAMPS WILL BE ADDED TO LIMIT THE LENGTH OF THE FREE END OF THE HOSE. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT HOME AND PARK AT 888-762-3873.

Reported: 2006-03-09 (March 9, 2006) · Model years: 2006

ON CERTAIN CLASS B MOTOR HOMES BUILT ON CHEVROLET CHASSIS, WHEN THE REAR AXLE LIFT KIT WAS INSTALLED, THE U-BOLT NUTS WERE NOT TIGHTENED PROPERLY.

Consequence: A LOOSE REAR AXLE CAN CREATE A SLUGGISH DRIVING FEELING, REAR BOUNCING AND LOUD BANGING NOISE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE U-BOLTS FREEE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2006. OWNERS MAY CONTACT ROADTREK AT 888-762-3873.

Reported: 2007-02-12 (February 12, 2007) · Model years: 2006, 2007

ON CERTAIN CLASS B MOTOR HOMES BUILT ON CHEVROLET CHASSIS, A BRASS CONNECTOR COUPLING FITTING USED TO CONNECT THE COPPER PIPING FROM THE MOTOR HOME PROPANE STORAGE CONTAINER TO THE BRASS FITTING ASSEMBLY BEHIND THE REFRIGERATOR.

Consequence: THE CONNECTION CAN LEAK WITH VEHICLE USAGE RESULTING IN A POSSIBLE FIRE HAZARD.

Remedy: DEALERS WILL INSPECT THE BRASS CONNECTOR FITTING AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON FEBRUARY 20, 2007. OWNERS MAY CONTACT HOME AND PARK AT 1-888-762-3873.