| Engine And Engine Cooling:Engine | 111.1%ODI 514107OIL SEAT/RING FAILURE, CAUSING OIL TO RUN OUT ONTO RIMS/TIRES, POSING RISK OF ACCIDENT. Look up ODI 514107 at NHTSA ↗ | 342.9%ODI 723412OIL PUMP GEAR FAILED - HAD TRAFFIC BEEN HEAVY ENGINE COULD HAVE SIEZED UP BEFORE I COULD SAFELY STOP Look up ODI 723412 at NHTSA ↗ | 00.0%No examples available for this selection. | 112.5%ODI 860591THE PLASTIC GEAR THAT EXTENDS TO THE OIL PUMP COULD STRIP OR MALFUNCTION, WHICH COULD EVENTUALLY CAUSE THE ENGINE TO SEIZE. PLEASE GIVE ANY FURTHER DETAILS. *AK Look up ODI 860591 at NHTSA ↗ | 00.0%No examples available for this selection. | 133.3%ODI 9004942NOTICE A SMALL PUDDLE OF OIL ON THE GARAGE FLOOR, ALSO NOTICE BIKE HEATED UP VERY QUICKLY AND INTENSELY WHEN RIDING EVEN FOR SHORT DISTANCES, DEALER SAID OIL LEAK RESULTED FOR THE BIKE BEING NEW. BIKE STARTED STALLING, OVER HEAT LAMP STARTING COMING ON, R/R SEAL OIL, ORING, COLLAR GASKET AND FAN FUSE. Look up ODI 9004942 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Engine And Engine Cooling:Engine:Gasoline | 00.0%No examples available for this selection. | 114.3%ODI 519430ENGINE STALLS. Look up ODI 519430 at NHTSA ↗ | 150.0%ODI 717994THE OIL DRIVE GEAR IN THIS MODEL HAS THE POTENTIAL TO FAIL CAUSING ENGINE TO SEIZE. I PERSONALLY HAVE NOT HAD A FAILURE. Look up ODI 717994 at NHTSA ↗ | 337.5%ODI 723417THE PLASTIC OIL PUMP GEAR HAS A HISTORY OF FAILURES IN THE 1999 MODEL KAWASAKI VULCAN MOTORCYCLES. THE RESULT AT HIWAY SPEEDS COULD BE FATAL. MANY REPORTS FROM HTTP://WWW.VROC.ORG MEMBERS WHO HAVE EXPERIENCED FAILURES SAY THEY ARE LUCKY THEY WERE NOT IN THE FAST LANE WHEN THE ENGINE LOCKED UP. KAWASAKI REFUSES TO ISSUE A RECALL EVEN THOUGH THAT HAVE STOPPED USING THE PLASTIC GEAR IN NEWER MODELS. *AK Look up ODI 723417 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Fuel/Propulsion System | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 233.3%ODI 11481490My 2005 Vulcan 1600 has recent started seeping fuel from the bottom tabs that are welded onto the gas tank and is slowly progressively getting worse Look up ODI 11481490 at NHTSA ↗ | 3100.0%ODI 11128473FUEL IS LEAKING FROM THE REAR OF THE GAS TANK IN THE AREA THAT THE MOUNTING TABS ARE BRAZED TO THE TANK. GASOLINE IS RUNNING DOWN OVER THE REAR ENGINE CYLINDER AND TRANSMISSION CASE. THE SAME AS RECALL ISSUED ON THE 2003 IN 2007 #07V216000. Look up ODI 11128473 at NHTSA ↗ | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Unknown Or Other | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 225.0%ODI 735798KICK STAND FAILED TO KEEP MOTORCYCLE UPRIGHT WHILE IDLING. *AK Look up ODI 735798 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 11489884My 2005 Kawasaki vulcan 1600 nomad have gas tank is leaking, and I looked on the internet and I saw that many people have this problem, is there a recall? The gas tank leaks in the left corner of the tank under the seat? Please let me know, and thank you for all you support. Look up ODI 11489884 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Engine | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 112.5%ODI 11278406 · 30,000 miTL* THE CONTACT OWNS A 1999 KAWASAKI VULCAN 1500 NOMAD. WHILE TRAVELING 60 MPH, THE MOTORCYCLE STALLED AND COULD NOT BE RESTARTED. THE MOTORCYCLE WAS TOWED TO BIG ST. CHARLES MOTORSPORTS (LOCATED AT 3830 WEST CLAY STREET, ST. CHARLES, MO 63301) WHERE IT WAS DIAGNOSED THAT THERE WAS A PLASTIC GEAR IN THE OIL PUMP THAT CAUSED AN ELECTRICAL OVERRIDE IN THE MOTORCYCLE. THE MOTORCYCLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. THE VIN WAS NOT AVAILABLE. Look up ODI 11278406 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 112.5%ODI 10524681 · 500 miTHIS MOTORCYCLE AS OTHERS FROM CALIFORNIA, APPEARS TO RUN OUT OF FUEL WHEN THE TANK IS 1/2 FULL OR LESS. IT IS WELL DOCUMENTED ON THE VN FORUMS. IT HAS BEEN GIVEN A NAME OF POOGS WHICH STANDS FOR PHANTOM OUT OF GAS SYNDROME. THE DEALER ESCONDIDO CYCLE CENTER HAS NOT BEEN ABLE TO FIX IT. I CONTACTED KAWASAKI BUT THEY WILL NOT CONNECT ME WITH A TECHNICAL ADVISER. MOST OWNERS REMOVE THE EMISSION CONTROLS. I DO NOT WANT TO. I HAVE HAD ALMOST 20 INCIDENTS ON THE FREEWAY WHEREBY I HAD TO MOVE TO THE SHOULDER WITH NO POWER. THEN THE CRANKING R… Look up ODI 10524681 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10532418 · 1,000 miTL* THE CONTACT OWNS A 2009 KAWASAKI VULCAN 1700 VOYAGER MOTORCYCLE. THE CONTACT STATED THAT WHILE RIDING THE BIKE, THERE WAS A LOUD WHISTLING NOISE EMITTED CONTINUOUSLY. THE BIKE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE ENGINE UNDER DRIVE PULLEY AND BELT WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 1,000. UPDATED 09/05/13*LJ THE CONSUMER WAS INFORMED THE DRIVE BELT, ENGINE PULLEY AND REAR TIRE PULLEY WERE BAD, WHICH WAS CAUSED … Look up ODI 10532418 at NHTSA ↗ | 0UnavailableNo examples available for this selection. |
|---|
| Fuel System, Gasoline:Carburetor System | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10032293 · 2,000 miCONSUMER STATED THAT WHILE RIDING AT 35 MPH MOTORCYCLE HESITATED SEVERAL TIMES, ALMOST STALLING, CAUSING THE CARBURETOR TO BACKFIRE, AND RESULTING IN AN ACCIDENT. WHILE THE ABOVE MENTIONED EVENTS WAS TAKING PLACE CONSUMER WAS TRYING TO AVOID A PEDESTRIAN, AND INADVERTENTLY CRASHED INTO A UTILITY POLE. A POLICE REPORT IS ON FILE, CONSUMER WAS RUSHED TO A HOSPITAL WITH INJURIES TO SHOULDERS AND A SEVERELY BRUISED CHEST. VEHICLE WAS TOTALED. *AK Look up ODI 10032293 at NHTSA ↗ | 133.3%ODI 10090894 · 1,200 miON 2 OCCASIONS MY 2001 KAWASAKI VULCAN 800 WAS LEAKING FUEL IN MY GARAGE. HIS MOTORCYCLE USES A KEIHN CVK-36 CARBURATOR. REPLACED GASKET BETWEEN FUEL BOWL AND CARBURATOR BODY AS WELL AS NEW FLOAT, AND NEEDLE. *AK PROBLEM CONTINUED, WHEN MOTORCYCLE SEEPED FUEL ON A NEAR CONTINUOUS BASIS. IDENTIFIED THAT THE ACCELERATOR PUMP DIAGPHRAGM IN THE CARBURATOR HAS FAILED WITH CRACKS AND RUBBER TO MATERIAL SEPARATION. THE PART # KA43028-0002 ITEM 43028A IN KAWASAKI'S PART MANUAL IS $50.99. PARTIAL ROOT CAUSE BEING THAT DESIGN OF THE FUEL TAP. … Look up ODI 10090894 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|
| Power Train | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 11096561 · 79,000 miTL* THE CONTACT OWNS A 2002 KAWASAKI VULCAN NOMAD 1500. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT ATTEMPTED TO SHIFT INTO SECOND GEAR; HOWEVER, THE TRANSMISSION SWITCHED BACK INTO NEUTRAL AND THE MOTORCYCLE LOST ACCELERATION. THE CONTACT ATTEMPTED TO SWITCH INTO FIRST GEAR, BUT THE MOTORCYCLE SWITCHED INTO NEUTRAL AGAIN. THE CONTACT MANAGED TO DRIVE THE MOTORCYCLE HOME. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE MOTORCYCLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 79,000. Look up ODI 11096561 at NHTSA ↗ | 112.5%ODI 10059501 · 15,737 miWHILE RIDING THE MOTORCYCLE, CONSUMER EXPERIENCED A SUDDEN LOST OF DRIVING FORCE TO THE REAR WHEEL AND IMMEDIATELY STARTED SLOWING DOWN. *LA UPON INSPECTION OF THE MOTORCYCLE, IT WAS FOUND THAT THE MANUFACTURER FAILED TO LUBRICATE THE SPLINED COUPLING THAT WENT BETWEEN THE DRIVESHAFT OUTPUT AND THE FINAL DRIVE GEARBOX PINION ASSEMBLY. (2003 KAWASAKI, VULCAN 750A19). *JB Look up ODI 10059501 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 120.0%ODI 10425782TL* THE CONTACT OWNS A 2009 KAWASAKI VULCAN. THE CONTACT STATED THAT THE VEHICLE WOULD BECOME STUCK IN THIRD AND FIFTH GEARS, CAUSING DIFFICULTY WHEN ATTEMPTING TO BRAKE. THE CONTACT WOULD HAVE TO POP THE VEHICLE OUT OF GEAR AND RE-ENGAGE. THE DEALER ADJUSTED THE CLUTCH IN AN ATTEMPT TO CORRECT THE FAILURE BUT TO NO AVAIL. THE DEALER WAS MADE UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS 1 AND THE CURRENT MILEAGE WAS 400. Look up ODI 10425782 at NHTSA ↗ | 0UnavailableNo examples available for this selection. |
|---|
| Power Train:Driveline:Driveshaft | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 8017712WHILE DRIVING HEARD A KNOCKING NOISE.*AK Look up ODI 8017712 at NHTSA ↗ | 225.0%ODI 10053787 · 15,737 miTHE MOTORCYCLE'S SPLINES ON THE DRIVESHAFT WERE NOT PROPERLY LUBRICATED AT THE FACTORY. THIS CAUSED THE SPLINES TO OVER RUN, AND RESULTED IN LOSS OF POWER TO THE REAR WHEELS. THIS MADE STOPPING THE MOTORCYCLE DIFFICULT. MODEL VN750 A-19. *AK *MR Look up ODI 10053787 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. |
|---|