2020 Kia OPTIMA PHEV problems and owner complaints

I HAVE 2017 KIA PLUG IN I HAD TO REPLACE BATTERIES SYSTEM TWICE WITHIN A YEAR. I ALSO HAVE A ENGINE KNOCKING AT 26000 MILES THAT THE DEALER CLAIMS IS A THAT WAS CAUSE BY SERVICE DONE TO OIL FILTER THAT DON'T MAKE NO SENSE. NO OIL LIGHT OR ENGINE LIGHT WENT OFF. FURTHER MORE AFTER THAT HAPPENED THE ELECTRICAL WENT OUT. THE KIA COMPANY'S REFUSE TO FIX IT. THE VEHICLE HAS 5 YEAR WARRANTY.

Look up ODI 11193782 at NHTSA ↗

ERROR MESSAGE "CHECK HYBRID SYSTEM. TURN OFF ENGINE" WITH YELLOW CAUTION TRIAGLE SHOWING EXCLAIMATION POINT AND HEV" CAME ON, AT HIGHWAY SPEED VEHICLE DROPPED TO FROM 65 MPH TO 40 MPH SUDDENLY, EXITED FREEWAY, TURNED CAR OFF AND RESTARTED...VEHICLE HAD LOSS OF PROPULSION, WOULD NOT GO OVER 20 MPH. STOP, AT STOP SIGN, AND WHEN I APPLIED GAS, THE VEHICLE WOULD NOT GO OVER 10 MPH...ONCE SAFELY OFF THE ROAD, I TURNED ENGINE OFF, TOWED TO DEALER. DEALER COULD NOT DUPLICATE. 1 DAY AFTER PICKING UP THE VEHICLE FROM DEALER, SAME PROBLEM OCCURRED. …

Look up ODI 11219554 at NHTSA ↗

For several years my 'check hybrid engine' followed by turn off engine. The dealership can not figure out the cause. Twice in the last month the engine has automatically shut off when the "check hybrid engine' warning light displays. I nearly had an accident because the brakes are much weaker when the engine shut off. Kia dealership is unable to find the source of the problem and says the car is functioning normally and to continue to drive it.

Look up ODI 11657677 at NHTSA ↗

WHILE DRIVING MY KIA HYBRID A NOTICE CAME UP ON THE DASH BOARD TO IMMEDIATELY PULL OVER AND SHUT OFF MY ENGINE AND I WAS ON A MAJOR HIGHWAY GOING ABOUT 75 WHEN I LOST TOTAL POWER AND MY VEHICLE BEGAN TO LOOSE POWER. I WAS ABLE TO GET IT OFF THE ROAD AND IMMEDIATELY CALLED MY DEALER. I HAD KNOW ABOUT THIS BECAUSE A RELATIVE AND I BROUGHT THE CARS THE SAME DAY AND SHE EXPERIENCE THIS 3 TIMES.THE DEALER SAID IT WAS A SWITCH THAT GOT STUCK WHEN THE CAR GOES FROM ELECTRIC TO GAS. I SPOKE WITH KIA AND THEY SAID THERE IS NO FORMAL RECALL. BUT THIS …

Look up ODI 11064175 at NHTSA ↗

WHEN I WAS DRIVING ON THE HIGHWAY ON 2/14/2011 A "CHECK HYBRID SYSTEM" WARNING CAME ON, CHECK ENGINE LIGHT, TRIANGLE HEV LIGHT, A RED BATTERY LIGHT CAME ON AND CAR LOST ENGINE POWER. AFTER MY VEHICLE SLOWED TRAFFIC DOWN DUE TO NOT HAVING POWER I WAS BARELY ABLE TO PULL OVER TO THE SIDE OF THE ROAD BY COASTING THE CAR TO THE SHOULDER. IT WOULD NOT ACCELERATE WHAT SO EVER NOT EVEN WITH JUST THE ENGINE POWER. WHEN I PULLED OVER THE BIG CHECK HYBRID SYSTEM WARNING DISSAPEARED AND ONLY THE CHECK ENGINE LIGHT AND TRIANGLE HEV LIGHT STAYED ON. I HAD M…

Look up ODI 11396321 at NHTSA ↗

BACKUP CAMERA DOES NOT ACTIVATE ON THE NAVIGATION SCREEN WHEN WE PUT THE CAR IN REVERSE. THIS HAPPENS OFTEN BUT NOT EVERY SINGLE TIME.

Look up ODI 11110703 at NHTSA ↗

I LEASED A NEW #KIA #OPTIMA #PHEV FROM YOU IN JULY OF 2018. IN JULY OF 2020, THE CHARGING CABLE LODGED IN THE CAR AND IT TOOK 4 HOURS FOR ROADSIDE ASSISTANCE TO REMOVE IT. ON DECEMBER 2, 2020, I GOT A CHECK ENGINE LIGHT AND MADE AN APPOINTMENT FOR SERVICE, BUT BEFORE I COULD BRING IT ON DEC 3, THE CHECK ENGINE LIGHT BECAME A TURN ENGINE OFF NOW LIGHT, AND THE CAR STOPPED DEAD IN THE MIDDLE OF A BUSY HIGHWAY WITH A WISP OF SMOKE FROM UNDER THE HOOD, A DANGEROUS SITUATION. I HAD IT TOWED TO KIA OF DELRAY. IT'S STILL THERE, THEY HAVEN'T TOLD …

Look up ODI 11384136 at NHTSA ↗

Vehicle dash warning light started flashing and told me to turn off vehicle. There were no shoulders on the road where I was. I smelled a burning smell (like a belt -not brakes). I stopped and turned the car off. Very dangerous!!! Not impressed that the dealership or manufacturer allowed this vehicle to be re-sold! I turned the vehicle into the service department. Do NOT want this vehicle back! Lemons should not be on the road!!!

Look up ODI 11459106 at NHTSA ↗

While driving the car on the highway, when I try accelerating, the car suddenly acts as if it's in neutral and the engine roars without engaging a higher or lower gear and the car start losing power/speed. It takes like three to five seconds to engage a gear again; I have to lift my foot from the pedal a little bit and wait for it to lock on a higher or a lower gear for me to accelerate again.

Look up ODI 11445028 at NHTSA ↗

I WAS TOLD BY THE DEALERSHIP THAT MY 2018 KIA OPTIMA PHEV WAS REPAIRED BUT AFTER I DROVE IT OFF THE LOT AND GOT ON THE FREEWAY THE WARNING LIGHT CAME ON AGAIN AND LOST ALL POWER. I ALMOST GOT INTO ANOTHER ACCIDENT BECAUSE OF THIS. THE DEALERSHIP SAID THEY WORKED WITH KIA TECHNICAL SUPPORT TO FIX MY CAR BUT APPARENTLY KIA DOESN'T KNOW WHAT'S WRONG WITH THEIR OWN CAR. THE VEHICLE HAS ONLY 19K MILES. I'M AFRAID FOR MY SAFETY AND MY FAMILIES THAT THIS WILL CONTINUE TO HAPPEN.

Look up ODI 11398068 at NHTSA ↗

The contact owns a 2017 Kia Optima. The contact stated while driving 65 MPH, the air bag and seat belt warning lights illuminated. The vehicle was taken to a local dealer for a scheduled repair of NHTSA campaign number: 18V161000 (Hybrid Propulsion System). After performing the recall repair the mechanic cleared the warning light however, the warning light returned soon after. The contact took the vehicle back to the same local dealer to be diagnosed. The contact was informed that the driver’s and passenger’s side frontal airbags needed to be r…

Look up ODI 11432935 at NHTSA ↗

KIA WON'T SERVICE THE ELECTRICAL LOSS RECALL

Look up ODI 11192587 at NHTSA ↗

TL* THE CONTACT OWNS A 2017 KIA OPTIMA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V161000 (HYBRID PROPULSION SYSTEM). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED A LOCAL DEALER (JIM BONE KIA, 1255 SANTA ROSA AVE, SANTA ROSA, CA 95404, [phone removed]) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Look up ODI 11118109 at NHTSA ↗

TL* THE CONTACT OWNS A 2017 KIA OPTIMA PHEV. WHILE DRIVING APPROXIMATELY 40 MPH, THE "CHECK BRAKES" WARNING MESSAGE ILLUMINATED. ALSO, WHEN THE CONTACT DEPRESSED THE BRAKE PEDAL, IT TRAVELED ALL THE WAY DOWN TO THE FLOORBOARD AND THE VEHICLE DID NOT STOP. WHEN THE CONTACT WAS TRAVELING ON AN INCLINE, THE VEHICLE ROLLED BACKWARDS TO A COMPLETE STOP. THE VEHICLE WAS ENGAGED IN PARK AND THEN TURNED OFF. THE VEHICLE WAS RESTARTED AND OPERATED NORMALLY. THE VEHICLE WAS DRIVEN TO GERALD KIA OF NORTH AURORA (201 HANSEN BLVD, NORTH AURORA, IL 60542) TO…

Look up ODI 11219845 at NHTSA ↗

For several years my 'check hybrid engine' followed by turn off engine. The dealership can not figure out the cause. Twice in the last month the engine has automatically shut off when the "check hybrid engine' warning light displays. I nearly had an accident because the brakes are much weaker when the engine shut off. Kia dealership is unable to find the source of the problem and says the car is functioning normally and to continue to drive it.

Look up ODI 11657677 at NHTSA ↗