Mckenzie MEDALLION recalls by model year

Reported: 2003-05-08 (May 8, 2003) · Model years: 1998, 1999

ON CERTAIN MOTORHOMES, FIFTH WHEELS AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM, THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK.

Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUALLY OPERATED, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: NORCOLD WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPLACEMENT COOLING UNIT FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-667-3005 OR MONACO AT 574-862-7211.

Reported: 2004-10-05 (October 5, 2004) · Model years: 1999, 2000, 2001, 2002, 2003, 2004

ON CERTAIN FIFTH WHEEL TRAILERS, A DEFICIENCY IN THE STRUCTURAL INTEGRITY OF THE MAIN FRAME RAILS COULD CAUSE THE RAILS TO CRACK AND AXLES COULD SHIFT, CAUSING THE FIFTH WHEEL TO PULL ERRATICALLY.

Consequence: THIS COULD CAUSE THE DRIVER OF THE TOW VEHICLE TO LOSE CONTROL CREATING THE POTENTIAL FOR A CRASH RESULTING IN PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT AND ADD AN ADDITION OF GUSSET PLATES AND CROSS TUBES TO STRENGHEN THE AXLE SPRING HANGERS. THE RECALL BEGAN ON OCTOBER 29, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2001-04-05 (April 5, 2001) · Model years: 2000, 2001

VEHICLE DESCRIPTION: TRAVEL TRAILERS AND FIFTH WHEEL TRAILERS. A WIRE SUPPLYING 12VOLT DC TO THE HOLDING TANK MONITORING SYSTEM DISPLAY PANEL WAS INSTALLED WITHOUT PROPER CIRCUIT PROTECTION. THE CIRCUIT IS CONNECTED TO THE VOLTAGE SOURCE WITH A 12VOLT DC 50 AMP SELF-RESETTING CIRCUIT BREAKER AS PROTECTION AGAINST AN ELECTRICAL SHORT TO GROUND.

Consequence: AN ELECTRICAL SHORT COULD OCCUR.

Remedy: DEALERS WILL INSTALL A 6-AMP CIRCUIT BREAKER ON THE 12VOLT DC WIRE SUPPLYING VOLTAGE TO THE HOLDING TANK MONITOR PANEL DISPLAY. OWNER NOTIFICATION BEGAN JUNE 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2008-06-05 (June 5, 2008) · Model years: 2000, 2001, 2002

MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Remedy: MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.

Reported: 2004-11-19 (November 19, 2004) · Model years: 2002, 2003, 2004

ON CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH LIQUID PROPANE GAS (LPG), IT WAS DISCOVERED AN EXCESS OF LPG HOSE WAS COILED IN THE REAR REFRIGERATOR ACCESS COMPARTMENT A CAUSING IT TO BE ROUTED CLOSE IN PROXIMITY TO THE BURNER FLUE BOX COVER OF THE REFRIGERATOR.

Consequence: THIS COULD POTENTIALLY CAUSE THERMAL DAMAGE TO THE LPG LINE AND PRODUCE A LEAK OF LPG IN THE ACCESS COMPARTMENT THAT COULD RESULT IN AN EXPLOSION OR FIRE.

Remedy: OWNERS ARE BEING ASKED TO INSPECT THE LPG LINE FROM THE OUTSIDE OF THE VEHICLE TO ENSURE THAT IT IS NOT CLOSE TO THE BURNER. IF NO DAMAGE TO THE LINE IS PRESENT AND THE LPG LINE IS THE APPROPRIATE LENGTH AND ROUTED CORRECTLY, THE COVER WILL BE REINSTALLED AND NO FURTHER ACTION WILL BE TAKEN. IF AN EXCESS OF HOSE IS CAUSING CONTACT OR CLOSE PROXIMITY TO THE BURNER COVER, OWNERS SHOULD SHUT OFF THE SUPPLY OF GAS AT THE LPG TANKS AND CONTACT MONACO IMMEDIATELY. THE RECALL BEGAN DECEMBER 8, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2003-03-19 (March 19, 2003) · Model years: 2003

ON CERTAIN FIFTH WHEEL VEHICLES ,THE FEDERAL CERTIFICATION LABEL HAS AN INCORRECT AXLE WEIGHT RATING. THE INITIAL LABEL READ 12,100 WITH 5,200 LB. AXLES. CORRECTED LABEL SHOULD READ 14,400 WITH 6,000 LB. AXLES.

Consequence: THESE VEHICLES DO NOT COMPLY WITH THE REGULATIONS.

Remedy: DEALERS WILL INSTALL A CORRECTED LABEL ON THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE LABEL WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-877-466-8226.