CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: NATIONAL RV WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST OWNERS IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR NATIONAL RV AT 1-800-999-7260, EXT. 4335. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), AN AGENCY OF THE UNITED STATES DEPARTMENT OF TRANSPORTATION, HAS BEEN NOTIFIED THAT NATIONAL RV, INC. AND ITS HOLDING COMPANY, NATIONAL RV HOLDINGS, INC., HAVE FILED FOR BANKRUPTCY. NHTSA HAS BEEN ADVISED THAT OWNERS WHO WISH TO PURSUE CLAIMS RELATED TO SAFETY RECALL REPAIR WORK ON THEIR NATIONAL RV VEHICLES MAY FILE A PROOF OF CLAIM WITH THE UNITED STATES BANKRUPTCY COURT FOR THE CENTRAL DISTRICT OF CALIFORNIA, RIVERSIDE DIVISION. THE CASE NUMBER ASSIGNED TO THIS MATTER IS 07-17941. THE PROOF OF CLAIM FORM AND INSTRUCTIONS ARE AVAILABLE ONLINE AT THE COURT'S WEBSITE WWW.CACB.USCOURTS.GOV. ADDITIONAL INFORMATION ABOUT THE BANKRUPTCY AND ITS PROCEEDINGS MAY ALSO BE FOUND AT WWW.OMNIMGT.COM/NATIONALRV. NATIONAL RV'S PHONE NUMBER IS (951) 943-6007. INFORMATION ABOUT SAFETY RECALLS ON NATIONAL RV'S PRODUCTS MAY BE FOUND AT WWW.SAFERCAR.GOV. THE NHTSA WISHES TO ADVISE OWNERS OF RECALLED PRODUCTS THAT, IN THE INTERESTS OF THEIR SAFETY AND THE SAFETY OF THE MOTORING PUBLIC, ALL SAFETY RECALL WORK SHOULD BE PERFORMED ON MOTOR VEHICLES AND ITEMS OF EQUIPMENT.
Reported: 2003-02-21 (February 21, 2003) · Model years: 2001
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPOSITION A LIGHT BULT FROM ONE SOCKET TO ANOTHER, AND REATTACH A WIRE FROM ONE CONNECTOR TO ANOTHER. OWNER NOTIFICATION BEGAN SEPTEMBER 2, 2003. OWNERS SHOULD CONTACT NATIONAL RV AT 1-800-439-3653. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), AN AGENCY OF THE UNITED STATES DEPARTMENT OF TRANSPORTATION, HAS BEEN NOTIFIED THAT NATIONAL RV, INC. AND ITS HOLDING COMPANY, NATIONAL RV HOLDINGS, INC., HAVE FILED FOR BANKRUPTCY. NHTSA HAS BEEN ADVISED THAT OWNERS WHO WISH TO PURSUE CLAIMS RELATED TO SAFETY RECALL REPAIR WORK ON THEIR NATIONAL RV VEHICLES MAY FILE A PROOF OF CLAIM WITH THE UNITED STATES BANKRUPTCY COURT FOR THE CENTRAL DISTRICT OF CALIFORNIA, RIVERSIDE DIVISION. THE CASE NUMBER ASSIGNED TO THIS MATTER IS 07-17941. THE PROOF OF CLAIM FORM AND INSTRUCTIONS ARE AVAILABLE ONLINE AT THE COURT'S WEBSITE <A HREF=HTTP://WWW.CACB.USCOURTS.GOV>HTTP://WWW.CACB.USCOURTS.GOV</A> . ADDITIONAL INFORMATION ABOUT THE BANKRUPTCY AND ITS PROCEEDINGS MAY ALSO BE FOUND AT <A HREF=HTTP://WWW.OMNIMGT.COM/NATIONALRV>HTTP://WWW.OMNIMGT.COM/NATIONALRV</A> . NATIONAL RV'S PHONE NUMBER IS (951) 943-6007. INFORMATION ABOUT SAFETY RECALLS ON NATIONAL RV'S PRODUCTS MAY BE FOUND AT WWW.SAFERCAR.GOV. THE NHTSA WISHES TO ADVISE OWNERS OF RECALLED PRODUCTS THAT, IN THE INTERESTS OF THEIR SAFETY AND THE SAFETY OF THE MOTORING PUBLIC, ALL SAFETY RECALL WORK SHOULD BE PERFORMED ON MOTOR VEHICLES AND ITEMS OF EQUIPMENT.
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
6 unique complaints in this selection. Analysis snapshot: 2026-10-01.
66.7%Usable mileage4 / 6 records
100.0%Valid incident date6 / 6 records
100.0%Valid filing date6 / 6 records
100.0%Ordered incident and filing dates6 / 6 records
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
CSPC: MANCHESTER RV PROPANE TANK S/N 1119471, CAT #6879, HAS A BROKEN WELD ON BRACKET FROM THE PROPANE TANK, CAUSING THE TANK TO DROP ONTO THE SPARE TIRE AND CREATE A POTENTIAL DANGER TO THE RV. *DT *JS *TT
ON 1/27/07 WHILE DRIVING WITH MY FAMILY ON MY 2000 NATIONAL RV SURFSIDE WE STARTED SMELLING PROPANE GAS, AT FIRST WE THOUGHT IT WAS COMING FROM THE STOVE. WE CHECKED IT AND FOUND NOTHING, WHEN WE MADE IT TO OUR DESTINATION AS I GOT OFF THE RV I SMELL PROPANE GAS IN THE EXTERIOR SO DECIDED TO CHECK THE TANK. WHEN I OPENED THE PROPANE DEPARTMENT I HEARD THE TANK HISSING, SO I THOUGHT MAYBE A FITTING HAD COME LOOSE, BUT AFTER CHECKING THE TANK WITH SOAP AND WATER I FOUND THAT IT WAS LEAKING FROM A BRACKET WELDED TO THE TANK FOR MOUNTING. ON 01/…
TL*THE CONTACT OWNS A 2000 NATIONAL RV SURFSIDE. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKES SUDDENLY ENGAGED AND THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL WHICH EXTENDED TO THE FLOORBOARD. THE CONTACT THEN NOTICED THAT THE BRAKES WERE VERY HOT AFTER THE VEHICLE COASTED TO A STOP. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE BRAKES WERE LOCKING UP AND OVERHEATING. HE WAS NOTIFIED BY THE MANUFACTURER THE VEHICLE WAS NOT INCLUDED IN RECALL 04V084…
Service Brakes, Hydraulic:Brake Fluid Low Warning: Lamp
00.0%
No examples available for this selection.
00.0%
No examples available for this selection.
150.0%ODI 10334558 · 40,500 mi
TL* THE CONTACT OWNS A 2001 NATIONAL SURFSIDE RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS FAILURE WITH THE REAR BRAKE LINE THAT RESULTED TO COMPLETE LOSS OF THE FRONT AND REAR BRAKES. THE FAILURE WAS CONTRIBUTED TO EXCESSIVE RUST. THE CONTACT DOWNSHIFTED INTO FIRST GEAR AND THE SPEED REDUCED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS DRIVEN WITH CAUTION TO A NEARBY INDEPENDENT MECHANIC WHERE THE REAR BRAKE LINE WAS REPLACED. THERE WAS NO WARNING LIGHT INDICA…
Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings
00.0%
No examples available for this selection.
00.0%
No examples available for this selection.
150.0%ODI 10334558 · 40,500 mi
TL* THE CONTACT OWNS A 2001 NATIONAL SURFSIDE RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS FAILURE WITH THE REAR BRAKE LINE THAT RESULTED TO COMPLETE LOSS OF THE FRONT AND REAR BRAKES. THE FAILURE WAS CONTRIBUTED TO EXCESSIVE RUST. THE CONTACT DOWNSHIFTED INTO FIRST GEAR AND THE SPEED REDUCED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS DRIVEN WITH CAUTION TO A NEARBY INDEPENDENT MECHANIC WHERE THE REAR BRAKE LINE WAS REPLACED. THERE WAS NO WARNING LIGHT INDICA…
THE CONSUMER NOTICED THAT THE BIN ABOVE THE TAIL PIPE WAS MELTED. THE CONSUMER FEELS THERE SHOULD BE A HEAT SHIELD BETWEEN THE TAIL PIPE AND THE PLASTIC BIN. THE GENERATOR TAIL PIPE IS ALSO LOCATED UNDER A PLASTIC BIN WITHOUT A HEAT SHIELD *SCC *NLM
AUTO PARK BRAKE SYSTEM HAS FAILED 3 TIMES. REAR WHEELS TRIED TO LOCK UP AND DID ONCE I SLOWED THE COACH . GREEN PRESSURE SWITCH FAILED WHILE GOING DOWN THE ROAD. LIGHT SWITCH FAILED LEAKED FLUID , DASH LIGHT "CAME ON" , REAR WHEELS DID NOT LOCK UP THIS TIME. GRAY LITE S/W FAILED AGAIN LEAKING FLUID "DASH LIGHT CAME ON AGAIN. THE SWITCHING SYSTEM SEEMS TO BE UNRELIABLE, CAUSES UNSAFE UNEXPECTED LOCK UP ON REAR WHEELS WITH NO NOTICE, IF IN TRAFFIC VERY DANGEROUS SITUATION.
ON 1/27/07 WHILE DRIVING WITH MY FAMILY ON MY 2000 NATIONAL RV SURFSIDE WE STARTED SMELLING PROPANE GAS, AT FIRST WE THOUGHT IT WAS COMING FROM THE STOVE. WE CHECKED IT AND FOUND NOTHING, WHEN WE MADE IT TO OUR DESTINATION AS I GOT OFF THE RV I SMELL PROPANE GAS IN THE EXTERIOR SO DECIDED TO CHECK THE TANK. WHEN I OPENED THE PROPANE DEPARTMENT I HEARD THE TANK HISSING, SO I THOUGHT MAYBE A FITTING HAD COME LOOSE, BUT AFTER CHECKING THE TANK WITH SOAP AND WATER I FOUND THAT IT WAS LEAKING FROM A BRACKET WELDED TO THE TANK FOR MOUNTING. ON 01/…
TL*THE CONTACT OWNS A 2000 NATIONAL RV SURFSIDE. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKES SUDDENLY ENGAGED AND THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL WHICH EXTENDED TO THE FLOORBOARD. THE CONTACT THEN NOTICED THAT THE BRAKES WERE VERY HOT AFTER THE VEHICLE COASTED TO A STOP. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE BRAKES WERE LOCKING UP AND OVERHEATING. HE WAS NOTIFIED BY THE MANUFACTURER THE VEHICLE WAS NOT INCLUDED IN RECALL 04V084…
Service Brakes, Hydraulic:Brake Fluid Low Warning: Lamp
Too few reports for a range
40,500 mi
1 (sparse)
ODI 10334558 · 40,500 mi
TL* THE CONTACT OWNS A 2001 NATIONAL SURFSIDE RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS FAILURE WITH THE REAR BRAKE LINE THAT RESULTED TO COMPLETE LOSS OF THE FRONT AND REAR BRAKES. THE FAILURE WAS CONTRIBUTED TO EXCESSIVE RUST. THE CONTACT DOWNSHIFTED INTO FIRST GEAR AND THE SPEED REDUCED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS DRIVEN WITH CAUTION TO A NEARBY INDEPENDENT MECHANIC WHERE THE REAR BRAKE LINE WAS REPLACED. THERE WAS NO WARNING LIGHT INDICA…
Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings
Too few reports for a range
40,500 mi
1 (sparse)
ODI 10334558 · 40,500 mi
TL* THE CONTACT OWNS A 2001 NATIONAL SURFSIDE RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS FAILURE WITH THE REAR BRAKE LINE THAT RESULTED TO COMPLETE LOSS OF THE FRONT AND REAR BRAKES. THE FAILURE WAS CONTRIBUTED TO EXCESSIVE RUST. THE CONTACT DOWNSHIFTED INTO FIRST GEAR AND THE SPEED REDUCED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS DRIVEN WITH CAUTION TO A NEARBY INDEPENDENT MECHANIC WHERE THE REAR BRAKE LINE WAS REPLACED. THERE WAS NO WARNING LIGHT INDICA…
AUTO PARK BRAKE SYSTEM HAS FAILED 3 TIMES. REAR WHEELS TRIED TO LOCK UP AND DID ONCE I SLOWED THE COACH . GREEN PRESSURE SWITCH FAILED WHILE GOING DOWN THE ROAD. LIGHT SWITCH FAILED LEAKED FLUID , DASH LIGHT "CAME ON" , REAR WHEELS DID NOT LOCK UP THIS TIME. GRAY LITE S/W FAILED AGAIN LEAKING FLUID "DASH LIGHT CAME ON AGAIN. THE SWITCHING SYSTEM SEEMS TO BE UNRELIABLE, CAUSES UNSAFE UNEXPECTED LOCK UP ON REAR WHEELS WITH NO NOTICE, IF IN TRAFFIC VERY DANGEROUS SITUATION.
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
Monthly complaint and recall timeline
Month
Complaints
Campaigns announced
Examples
2024-11
0
None
No examples available for this selection.
2024-12
0
None
No examples available for this selection.
2025-01
0
None
No examples available for this selection.
2025-02
0
None
No examples available for this selection.
2025-03
0
None
No examples available for this selection.
2025-04
0
None
No examples available for this selection.
2025-05
0
None
No examples available for this selection.
2025-06
0
None
No examples available for this selection.
2025-07
0
None
No examples available for this selection.
2025-08
0
None
No examples available for this selection.
2025-09
0
None
No examples available for this selection.
2025-10
0
None
No examples available for this selection.
2025-11
0
None
No examples available for this selection.
2025-12
0
None
No examples available for this selection.
2026-01
0
None
No examples available for this selection.
2026-02
0
None
No examples available for this selection.
2026-03
0
None
No examples available for this selection.
2026-04
0
None
No examples available for this selection.
2026-05
0
None
No examples available for this selection.
2026-06
0
None
No examples available for this selection.
2026-07
0
None
No examples available for this selection.
2026-08
0
None
No examples available for this selection.
2026-09
0
None
No examples available for this selection.
2026-10 (partial)
0
None
No examples available for this selection.
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2000: 1 complaints · 2001: 0 complaints
Equal observation windows
Model year
Through age 0
Through age 1
Through age 2
2000
0
0
1
2001
0
0
0
Date coverage across each selected cohort
Date basis for all complaints in selected model years
Year
Incident dates used
Filing date fallbacks
Excluded dates
2000
3
0
0
2001
2
0
0
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
Service Brakes, Hydraulic:Brake Fluid Low Warning: Lamp
0
0
—
1ODI 10334558 · 40,500 mi
TL* THE CONTACT OWNS A 2001 NATIONAL SURFSIDE RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS FAILURE WITH THE REAR BRAKE LINE THAT RESULTED TO COMPLETE LOSS OF THE FRONT AND REAR BRAKES. THE FAILURE WAS CONTRIBUTED TO EXCESSIVE RUST. THE CONTACT DOWNSHIFTED INTO FIRST GEAR AND THE SPEED REDUCED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS DRIVEN WITH CAUTION TO A NEARBY INDEPENDENT MECHANIC WHERE THE REAR BRAKE LINE WAS REPLACED. THERE WAS NO WARNING LIGHT INDICA…
Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings
0
0
1ODI 10334558 · 40,500 mi
TL* THE CONTACT OWNS A 2001 NATIONAL SURFSIDE RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS FAILURE WITH THE REAR BRAKE LINE THAT RESULTED TO COMPLETE LOSS OF THE FRONT AND REAR BRAKES. THE FAILURE WAS CONTRIBUTED TO EXCESSIVE RUST. THE CONTACT DOWNSHIFTED INTO FIRST GEAR AND THE SPEED REDUCED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS DRIVEN WITH CAUTION TO A NEARBY INDEPENDENT MECHANIC WHERE THE REAR BRAKE LINE WAS REPLACED. THERE WAS NO WARNING LIGHT INDICA…
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
2 patterns with matching reports.
Brake response concerns
1 mentions · 16.7% of complaints
Median mileage: 40,000 mi (1 usable records).
ODI 10369037 · 40,000 mi
TL*THE CONTACT OWNS A 2000 NATIONAL RV SURFSIDE. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKES SUDDENLY ENGAGED AND THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL WHICH EXTENDED TO THE FLOORBOARD. THE CONTACT THEN NOTICED THAT THE BRAKES WERE VERY HOT AFTER THE VEHICLE COASTED TO A STOP. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE BRAKES WERE LOCKING UP AND OVERHEATING. HE WAS NOTIFIED BY THE MANUFACTURER THE VEHICLE WAS NOT INCLUDED IN RECALL 04V084…
TL* THE CONTACT OWNS A 2001 NATIONAL SURFSIDE RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS FAILURE WITH THE REAR BRAKE LINE THAT RESULTED TO COMPLETE LOSS OF THE FRONT AND REAR BRAKES. THE FAILURE WAS CONTRIBUTED TO EXCESSIVE RUST. THE CONTACT DOWNSHIFTED INTO FIRST GEAR AND THE SPEED REDUCED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS DRIVEN WITH CAUTION TO A NEARBY INDEPENDENT MECHANIC WHERE THE REAR BRAKE LINE WAS REPLACED. THERE WAS NO WARNING LIGHT INDICA…