U.S. public vehicle records

Saturn RELAY recalls by model year

Explore the records behind recurring owner reports.

Key facts

122 owner complaints analyzed

3 distinct recall campaigns

42,000 mi median reported failure mileage

Scope: 2005 to 2007 model years. Data updated: 2026-09-30 (September 30, 2026). 109 complaints include usable failure mileage. View data status.

Compare model years

Recalls by model year

All campaigns in the snapshot affecting each model year, including recalls announced years later.

From yearThrough year

Recall campaigns

Shared campaigns appear once in each affected model year.

2005

2006

2007

2005: 2; 2006: 1; 2007: 0

First model yearSecond model year

Year-by-year records

Saturn RELAY model-year comparison
Model year	Complaints	Recalls	Change in recalls
2005	91	2	Not available
2006	19	1	-1
2007	12	0	-1

Recall history

3 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.

05V061000 · Seats:Mid/Rear Assembly

Reported: 2005-02-18 (February 18, 2005) · Model years: 2005

ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.

Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.

Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.

NHTSA campaign record ↗

05V287000 · Parking Brake

Reported: 2005-06-20 (June 20, 2005) · Model years: 2005

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.

Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.

NHTSA campaign record ↗

05V552000 · Equipment:Other:Labels

Reported: 2005-12-07 (December 7, 2005) · Model years: 2006

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.

Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.

NHTSA campaign record ↗

Explore the data

Vehicle analysis explorer

Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.

Data completeness

122 unique complaints in this selection. Analysis snapshot: 2026-09-30.

89.3%Usable mileage109 / 122 records

100.0%Valid incident date122 / 122 records

100.0%Valid filing date122 / 122 records

100.0%Ordered incident and filing dates122 / 122 records

Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.

Problems by model year

Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.

From model yearThrough model year

Component complaint heatmap
Component	2005	2006	2007
Electrical System	2022.0% ODI 10140423 · 2,500 mi WE PURCHASED A SATURN RELAY FROM SATURN OF CHARLESTON HUNTINGTON ,SEPT 05 , WE WERE TOLD IT HAD A PREVIOUS OWNER BUT THEY HAD BROUGHT IT BACK BECAUSE THEY DIDN'T LIKE THE COLOR , AT SATURN YOU HAVE 30 DAYS OR 1500 MILES TO DO THIS . IT HAD 665 MILES ON IT . ALMOST LIKE BRAND NEW RIGHT? WELL THE FIRST WEEK I HAD IT HAD TO GO BACK IN TO HAVE A PART SERVICED IN THE DVD PLAYER .NOW I HAVE HAD IT 4 WEEKS AND HAVE HAD NOTHING BUT ELECTRONIC TROUBLE AND SATURN SAYS THERE IS NOTHING WRONG WITH IT AND I KNOW THERE IS , THE SPEEDOMETER GOES UP AND DOWN W… Look up ODI 10140423 at NHTSA ↗	210.5% ODI 10568780 · 128,500 mi NOTED THAT DRIVING LIGHTS FLASHED WITH WIPERS ON DELAY SETTING. AT NEXT USE, LOW OIL PRESSURE LIGHT & WARNING SOUNDED BUT LIGHTS DID NOT FLASH WITH DELAY WIPERS. TURNING OFF ENGINE AND PULLING HOOD LATCH & CLOSING HOOD ENDED LOW PRESSURE WARNING (OIL PRESSURE/ LEVEL WERE CORRECT-FALSE ALARM). 2 DAYS LATER, LIGHTS AGAIN FLASHED WITH WIPERS ON DELAY BUT NO OIL PRESSURE WARNING. CONTINUED THIS BACK-AND-FORTH (EITHER OIL WARNING OR LIGHT FLASH WITH WIPER USE, BUT NOT CONCOMITANT) FOR 2 MONTHS, THEN LOW PRESSURE WARNINGS BECAME CONSTANT, AND THE LIG… Look up ODI 10568780 at NHTSA ↗	325.0% ODI 10229347 · 29,693 mi STARTER SOMETIMES ENGAGES, SOMETIMES DOESN'T ENGAGE, SOMETIMES STAYS ENGAGED. TOOK TO DEALERSHIP FEW TIMES AND WAS FINALLY TOLD THAT'S THE WAY IT IS. *TR Look up ODI 10229347 at NHTSA ↗
Service Brakes, Hydraulic	1415.4% ODI 10175424 · 1,000 mi 2005 SATURN RELAY HAS NUMEROUS DESIGN FLAWS, AND SATURN IS UNABLE TO FIX. ONSTAR DISABLES SPEEDOMETER WHEN USED, RADIO MUTES AND CAR MUST BE TURNED OFF AND BACK ON TO RESET, ABS SYSTEM MALFUNCTIONS REPEATEDLY EVEN AFTER REPLACING EBCM, ABS PUMP, BCM, LIGHTS FLICKER BOTH INTERIOR AND EXTERIOR, ALTERNATOR FOUND TO HAVE ERRATIC OUTPUT, NEW ALTERNATOR DID NOT SOLVE PROBLEM. BRAKE ROTORS WARPED WITHIN 25K MILES. SATURN WILL ONLY KEEPING TRYING TO REPAIR, BUT IS UNABLE TO SOLVE PROBLEMS. *NM Look up ODI 10175424 at NHTSA ↗	210.5% ODI 10240568 · 34,500 mi I HAVE A 2006 SATURN RELAY. IT WAS AN EXECUTIVE DRIVEN CAR AND WAS PURCHASED WITH 400 MILES ON IT AND THE WARRANTY TRANSFERRED OVER TO ME. THE TRACTION CONTROL ON THIS VEHICLE IS DEFECTIVE. WHEN THE TRACTION CONTROL ENGAGED IT WOULD KNOCK OUT THE STABILITY CONTROL, TRACTION CONTROL, AND ABS SYSTEM. ALTHOUGH I HAVE BREAKS, THEY ARE MANUAL BREAKS. AT FIRST SATURN SAID THE SYSTEM IS WORKING TO FACTORY SPECS UNTIL IT HAPPENED TO THEIR VEHICLE. THEN ALL OF A SUDDEN THERE WAS A PROBLEM WITH MINE. I DO NOT FEEL SAFE IN THE CAR BECAUSE, I SHOULD… Look up ODI 10240568 at NHTSA ↗	00.0% No examples available for this selection.
Service Brakes	99.9% ODI 10489110 · 80,000 mi ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. *TR Look up ODI 10489110 at NHTSA ↗	15.3% ODI 11030754 · 130,000 mi SERVICE ABS AND SERVICE TRACTION CONTROL LIGHTS CAME ON AND HAVE REMAINED ON FOR SEVERAL DAYS. FURTHER MESSAGES CONTINUE FLASHING ON THE DRIVER INFORMATION CENTER. THIS HAS BEEN A RECURRING PROBLEM OVER THE PAST YEAR AFTER ABS WHEEL SENSORS AND THE ASSOCIATED WIRING WERE REPLACED. WITH THE NUMEROUS COMPLAINTS ON THE INTERNET - I WAS THINKING THAT SURELY A TSB OR RECALL ON THESE ISSUES HAS BEEN OVERLOOKED OR SIMPLY IGNORED BY THE MECHANICS AND SERVICE WRITERS AT THE GM DEALERSHIPS NATIONWIDE. I KNOW THAT A TECH LL SCANNER IS REQUIRED TO CHECK FO… Look up ODI 11030754 at NHTSA ↗	18.3% ODI 11149773 · 150,000 mi TL* THE CONTACT OWNS A 2007 SATURN RELAY. WHILE DRIVING 50 MPH, THE VEHICLE ACCELERATED TO 80 MPH. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE DID NOT DECELERATE. THE CONTACT PLACED THE VEHICLE INTO NEUTRAL AND THE SPEED DECREASED TO 40 MPH. THE CONTACT THEN SHIFTED INTO PARK AND THE VEHICLE STOPPED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000. Look up ODI 11149773 at NHTSA ↗
Structure:Body:Door	66.6% ODI 10195669 · 5,000 mi TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING BETWEEN 5-45 MPH, THE CONTACT HEARD A BEEPING NOISE. THE NOISE INDICATED THAT THE PASSENGER SIDE DOOR WAS OPEN, HOWEVER, THE DOOR WAS CLOSED. SHE HAD TO OPEN AND CLOSE THE DOOR FOR THE BEEPING NOISE TO STOP. THE DEALER STATED THAT THEY CLEANED THE DOOR PINS. APPROXIMATELY A YEAR AND A HALF LATER, THE FAILURE RECURRED. THE DEALER STATED THAT THEY CHANGED THE HARD SIDE TRIM. APPROXIMATELY SIX MONTHS LATER, THE FAILURE RECURRED FOR THE THIRD TIME. THE DEALER HAS NOT INSPECTED THE VEHIC… Look up ODI 10195669 at NHTSA ↗	210.5% ODI 10196756 · 7,000 mi TL*THE CONTACT OWNS A 2006 SATURN RELAY. THE CONTACT STATED THAT THE REAR PASSENGER SIDE SLIDING DOOR FAILED TO CLOSE PROPERLY. THE DOOR HAS TO BE SLAMMED SHUT IN ORDER FOR IT TO CLOSE. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE VEHICLE HAS NOT BEEN INSPECTED BY A DEALER. THE CURRENT AND FAILURE MILEAGES WERE 7,000. Look up ODI 10196756 at NHTSA ↗	216.7% ODI 10239838 · 18,220 mi I WENT TO GET MY 2 YEAR OLD OUT OF THE VAN AND THE WHOLE DOOR FELL OFF JUST MISSING MY FEET. TR UPDATED 09/09/08. JB Look up ODI 10239838 at NHTSA ↗
Latches/Locks/Linkages	44.4% ODI 10237385 · 23,000 mi TL*THE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT THE PASSENGER SIDE ELECTRIC DOOR DOES NOT LATCH PROPERLY. AS A RESULT, THE DOOR OPENS WHILE THE VEHICLE IS MOVING. HE TOOK THE VEHICLE TO THE DEALER AND THEY RE-ADJUSTED THE DOOR STRIKER. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. SECONDLY, HE NOTICED EXCESSIVE VIBRATION WHEN DEPRESSING THE BRAKE PEDAL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY MACHINED HIS BRAKING SYSTEM. AFTER THE REPAIR, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO ANOTHER DE… Look up ODI 10237385 at NHTSA ↗	210.5% ODI 10242466 · 36,000 mi POWER SLIDING DOOR ON 2006 SATURN RELAY IS NOT CLOSING PROPERLY AND OPENS UNEXPECTEDLY. DOOR DOES NOT CLOSE COMPLETELY, DOES NOT LATCH AND OCCASSIONALLY DOOR REOPENS WHILE VEHICLE IS MOVING. TROUBLE STARTED ABOT TWO MONTHS AGO BUT THE REGULARITY OF THIS OCCURRANCE HAS INCREASED SIGNIFICANLTY OVER THE LAST FOUR DAYS. *TR Look up ODI 10242466 at NHTSA ↗	216.7% ODI 10242745 · 17,000 mi I OWN A 2007 SATURN RELAY 3 MINIVAN. THE VAN HAS DUAL POWER ASSISTED REAR SLIDING CARGO DOORS. DURING MY FAMILY'S EVACUATION FOR HURRICANE GUSTAV THE PASSENGER SIDE POWER ASSISTED SLIDING CARGO DOOR DID NOT CLOSE PROPERLY (DID NOT LATCH). I ELECTRICALLY RE-CLOSED THE DOOR AND LOCKED THE VEHICLE. DURING THE WEEK OF SEPTEMBER 1ST THROUGH SEPTEMBER 7TH THE SAME DOOR WOULD NOT CLOSE PROPERLY, UNLATCHED WHEN THE FORWARD DRIVER OR PASSENGER DOOR WAS CLOSED AFTER ENTERING, AND UNLATCHED WHILE I WAS DRIVING ON INTERSTATE I-10 PASSING THROUGH THE MOBILE… Look up ODI 10242745 at NHTSA ↗
Electronic Stability Control (Esc)	44.4% ODI 10248524 · 42,000 mi ON SUNDAY, NOVEMBER 9, 2008 I WAS BACKING UP IN MY DRIVEWAY WHEN THE TRACTION CONTROL ENGAGED BRIEFLY, STOPPED AND THE SERVICE LIGHT FOR BOTH THE TC AND THE ABS REMAINED ON. I HAVE NOT BEEN ABLE TO GET RID OF THE SERVICE LIGHTS. ON MONDAY I BROUGHT THE VAN INTO THE LOCAL GARAGE. IN JUNE 2008, I HAD THE SAME PROBLEM BUT THE SERVICE LIGHTS TURNED OFF. THE SAME GARAGE PUT IN NEW BALL BEARINGS INCLUDING THE ONE THAT HAS THE SENSOR IN IT FOR THE TC AND ABS. I HAVE READ THE EBCM MODULE OR THE SENSOR ON THE BALL BEARING COULD BE THE PROBLEM. *TR… Look up ODI 10248524 at NHTSA ↗	210.5% ODI 10432537 · 111,000 mi I STARTED GETTING "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT WITH "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT AND "SERVICE STABILITY SYSTEM". ALL ARE ALWAYS AT THE SAME TIME. SHUTTING OFF THE ENGINE AND RESTARTING (PER OWNERS MANUAL) TEMPORARILY CAUSES THE LIGHTS AND MESSAGES TO TURN OFF, BUT THEY ALWAYS RETURN LATER. THIS PROBLEM IS WELL DOCUMENTED IN SATURN FORUMS AND IS HAPPENING WITH MANY, MANY OWNERS. *TR Look up ODI 10432537 at NHTSA ↗	18.3% ODI 10283736 · 55,000 mi THE TRACTION CONTROL AND ABS GOES OUT EXCESSIVELY IN MY 2007 SATURN RELAY, AFFECTING THE BRAKING SYSTEM. THIS HAPPENS EVERY TIME IT IS DRIVEN. THERE IS A SERVICE MESSAGE THAT APPEARS. THE ONLY CORRECTION SO FAR IS TO SHUT THE ENGINE OFF AND TURN IT BACK ON. THIS ONLY WORKS FOR A FEW MINUTES UNTIL IT BEGINS AGAIN. *TR Look up ODI 10283736 at NHTSA ↗
Exterior Lighting	66.6% ODI 10116052 · 750 mi HEADLIGHTS, DASH LIGHTS AND INTERIOR LIGHTS GO DIM/BRIGHT/DIM/BRIGHT ETC. AT NIGHT WHEN ACCELERATION WITH FOOT OR WITH USE OF CRUSE CONTROL. NOTIFIED SATURN AND ALSO DEALER. THEY BOTH SAID THIS IS A CHARACTERISTIC OF THE RELAY. DEALER ALSO SAID THEY HAD THE SAME PROIBLEM WITH THE L SERIES. SATURN NOR DEALER HAVE ATTEMPTED TO TALK DIRECTLY TO ME OR FIX IT DESPITE E-MAILS, LETTERS, PHONE CALLS. I WORRY THAT AN 18 WHEELER MIGHT THINK I AM FLASHING HIM THAT IT IS OK TO PULL OVER TO THE RIGHT. THIS IS A DANGEROUS SITUATION AND THE NEW 05 SATURN RELA… Look up ODI 10116052 at NHTSA ↗	15.3% ODI 10568780 · 128,500 mi NOTED THAT DRIVING LIGHTS FLASHED WITH WIPERS ON DELAY SETTING. AT NEXT USE, LOW OIL PRESSURE LIGHT & WARNING SOUNDED BUT LIGHTS DID NOT FLASH WITH DELAY WIPERS. TURNING OFF ENGINE AND PULLING HOOD LATCH & CLOSING HOOD ENDED LOW PRESSURE WARNING (OIL PRESSURE/ LEVEL WERE CORRECT-FALSE ALARM). 2 DAYS LATER, LIGHTS AGAIN FLASHED WITH WIPERS ON DELAY BUT NO OIL PRESSURE WARNING. CONTINUED THIS BACK-AND-FORTH (EITHER OIL WARNING OR LIGHT FLASH WITH WIPER USE, BUT NOT CONCOMITANT) FOR 2 MONTHS, THEN LOW PRESSURE WARNINGS BECAME CONSTANT, AND THE LIG… Look up ODI 10568780 at NHTSA ↗	00.0% No examples available for this selection.
Power Train	11.1% ODI 10267433 · 45,000 mi MY WIFE PLACED OUR 2005 SATURN RELAY MINIVAN IN PARK, AND STEPPED OUT TO GET THE MAIL. THE VAN IMMEDIATELY STARTED BACKWARDS, WITH THE DOOR PUSHING HER DOWN. LUCKILY, AS IT PUSHED HER DOWN, SHE FELL TO THE INSIDE, AND WAS ABLE TO ACTIVATE THE PARKING BRAKE WITH HER HAND, STOPPING THE CAR. SHE DID RECEIVE A VERY MINOR KNEE INJURY, BUT IT COULD HAVE BEEN MUCH WORSE. OUR TWO DAUGHTERS WERE BOTH IN THE CAR, WHICH WOULD HAVE ROLLED DOWN A HILL AND INTO A NEIGHBORS HOUSE, HAD SHE NOT STOPPED IT. MY FIRST THOUGHT WAS THAT SHE'D MADE A MIS… Look up ODI 10267433 at NHTSA ↗	421.1% ODI 10295177 · 139,000 mi AWD DISABLED WHEN NEEDED IN SNOW. IT SEEMS TO BE CAUSED BY ICY SLUSH. I CONFIRMED WITH THE DEALER THAT THE HUB ASSEMBLY'S AWD SENSOR CAN GET COVERED UP WITH MUD OR SLUSH AND THE AWD SYSTEM WILL DISABLE. ANY AWD SYSTEM THAT GETS DISABLED BY SLUSH IS LUDICROUSLY DESIGNED, AND BORDERLINE NEGLIGENT WITH REGARDS TO SAFETY. *TR Look up ODI 10295177 at NHTSA ↗	18.3% ODI 11149773 · 150,000 mi TL* THE CONTACT OWNS A 2007 SATURN RELAY. WHILE DRIVING 50 MPH, THE VEHICLE ACCELERATED TO 80 MPH. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE DID NOT DECELERATE. THE CONTACT PLACED THE VEHICLE INTO NEUTRAL AND THE SPEED DECREASED TO 40 MPH. THE CONTACT THEN SHIFTED INTO PARK AND THE VEHICLE STOPPED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000. Look up ODI 11149773 at NHTSA ↗

Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.

Failure mileage by component

Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.

Component failure mileage distribution
Component	Mileage range (25th–75th percentile)	Median	Usable records	Examples
Electrical System	5,250–116,076 mi	83,000 mi	24	ODI 10140423 · 2,500 mi WE PURCHASED A SATURN RELAY FROM SATURN OF CHARLESTON HUNTINGTON ,SEPT 05 , WE WERE TOLD IT HAD A PREVIOUS OWNER BUT THEY HAD BROUGHT IT BACK BECAUSE THEY DIDN'T LIKE THE COLOR , AT SATURN YOU HAVE 30 DAYS OR 1500 MILES TO DO THIS . IT HAD 665 MILES ON IT . ALMOST LIKE BRAND NEW RIGHT? WELL THE FIRST WEEK I HAD IT HAD TO GO BACK IN TO HAVE A PART SERVICED IN THE DVD PLAYER .NOW I HAVE HAD IT 4 WEEKS AND HAVE HAD NOTHING BUT ELECTRONIC TROUBLE AND SATURN SAYS THERE IS NOTHING WRONG WITH IT AND I KNOW THERE IS , THE SPEEDOMETER GOES UP AND DOWN W… Look up ODI 10140423 at NHTSA ↗ ODI 10144004 · 2,878 mi DT: THE CONTACT STATES THERE WAS AN ONGOING PROBLEM WITH EXTERIOR AND INTERIOR LIGHTING. WHILE DRIVING, THE HEADLIGHTS AND THE DASHBOARD PANEL LIGHTS FLICKERED FROM BRIGHT TO DIM. ALSO, THE IDLE WAS VERY LOUD AND ROUGH. SHE TOOK THE VEHICLE TO THE DEALER. THE DEALER REPLACED THE ALTERNATOR. THIS DID NOT CORRECT THE PROBLEM. THE DEALER WAS UNABLE TO ACCURATELY DIAGNOSE THE PROBLEM, AND NO FURTHER REPAIRS WERE MADE. AK UPDATED 12/27/2005. THE HORN SPRINGS WERE DEFORM WHICH RESULTED IN THE HORN BEING INOPERATIVE. THE SLIDING DOOR WOULD … Look up ODI 10144004 at NHTSA ↗ ODI 10146606 · 2,427 mi HEADLIGHTS FLICKER EVEN AFTER 5 REPAIR ATTEMPTS. HEATER INTERMITTENTLY INOPERATIVE AFTER 5 REPAIR ATTEMPTS. POWER SLIDING DOORS DO NOT CLOSE PROPERLY AFTER 4 REPAIR ATTEMPTS. DIFFICULT STARTING AFTER 3 REPAIR ATTEMPTS. FUEL GAUGE ERRATIC BELOW QUARTER TANK. JB Look up ODI 10146606 at NHTSA ↗
Service Brakes, Hydraulic	31,125–83,000 mi	42,055 mi	14	ODI 10175424 · 1,000 mi 2005 SATURN RELAY HAS NUMEROUS DESIGN FLAWS, AND SATURN IS UNABLE TO FIX. ONSTAR DISABLES SPEEDOMETER WHEN USED, RADIO MUTES AND CAR MUST BE TURNED OFF AND BACK ON TO RESET, ABS SYSTEM MALFUNCTIONS REPEATEDLY EVEN AFTER REPLACING EBCM, ABS PUMP, BCM, LIGHTS FLICKER BOTH INTERIOR AND EXTERIOR, ALTERNATOR FOUND TO HAVE ERRATIC OUTPUT, NEW ALTERNATOR DID NOT SOLVE PROBLEM. BRAKE ROTORS WARPED WITHIN 25K MILES. SATURN WILL ONLY KEEPING TRYING TO REPAIR, BUT IS UNABLE TO SOLVE PROBLEMS. NM Look up ODI 10175424 at NHTSA ↗ ODI 10203540 · 39,500 mi THE TRACTION CONTROL SYSTEM ENGAGED WHILE DRIVING AT FREEWAY SPEED ON STATE HIGHWAY 153 IN CHATTANOOGA, TN, CAUSING THE VEHICLE TO VEER RIGHT OUT OF THE LANE. THE SYSTEM IMMEDIATELY SHUT OFF AND A "SERVICE TRACTION CONTROL SYSTEM/ABS SYSTEM/STABILITY SYSTEM" WARNING APPEARED IN THE DASH READOUT. AFTER TURNING OFF THE VEHICLE, THE WARNING WENT AWAY. THEN A WEEK LATER THE SAME THING HAPPENED ON A CITY STREET AT LOW SPEED, AND AGAIN THE WARNING APPEARED, AND AGAIN, IT DISAPPEARED. I'VE CONTACTED SATURN WHO STATED THE FAULT WAS IN THE ELECTRON… Look up ODI 10203540 at NHTSA ↗ ODI 10237385 · 23,000 mi TLTHE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT THE PASSENGER SIDE ELECTRIC DOOR DOES NOT LATCH PROPERLY. AS A RESULT, THE DOOR OPENS WHILE THE VEHICLE IS MOVING. HE TOOK THE VEHICLE TO THE DEALER AND THEY RE-ADJUSTED THE DOOR STRIKER. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. SECONDLY, HE NOTICED EXCESSIVE VIBRATION WHEN DEPRESSING THE BRAKE PEDAL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY MACHINED HIS BRAKING SYSTEM. AFTER THE REPAIR, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO ANOTHER DE… Look up ODI 10237385 at NHTSA ↗
Service Brakes	80,588–135,625 mi	91,500 mi	10	ODI 10489110 · 80,000 mi ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. TR Look up ODI 10489110 at NHTSA ↗ ODI 10520704 · 78,000 mi WHILE DRIVING ON FREEWAY, SATURN RELAY 2005 SLOWED DOWN AND LOST POWER INTERMITTENTLY. DASH WARNING LIGHTS FLASHED ON AND OFF (ABS/STABILITY/TRACTION) - WARNING LIGHTS. THE VEHICLE HAD NO POWER ON AND OFF. WHEN I APPLIED THE GAS, THE VEHICLE BOGGED DOWN AND CONTINUED TO SLOW. THEN ALL OF A SUDDEN, THE VEHICLE ACCELERATED WHEN I DEPRESSED THE GAS PEDAL. I COULD NOT MOVE OVER TO THE BERM DUE TO HEAVY TRAFFIC SO I ATTEMPTED TO EXIT AT AN UPCOMING EXIT RAMP. WHEN I APPLIED THE BRAKES NOTHING HAPPENED THE FIRST FEW TIMES. THEN THE BRAKES WORKED SO I… Look up ODI 10520704 at NHTSA ↗ ODI 10522302 · 60,000 mi TL THE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT WHILE REVERSING FROM A DRIVEWAY, THE BRAKES FAILED WITH THE ILLUMINATION OF THE ABS WARNING LIGHTS. AS A RESULT, THE CONTACT CRASHED INTO A MAILBOX FROM THE DRIVER'S SIDE. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED THAT THE DRIVER'S SIDE WHEEL HUB NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE BRAKE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILU… Look up ODI 10522302 at NHTSA ↗
Structure:Body:Door	10,438–31,500 mi	17,610 mi	8	ODI 10195669 · 5,000 mi TLTHE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING BETWEEN 5-45 MPH, THE CONTACT HEARD A BEEPING NOISE. THE NOISE INDICATED THAT THE PASSENGER SIDE DOOR WAS OPEN, HOWEVER, THE DOOR WAS CLOSED. SHE HAD TO OPEN AND CLOSE THE DOOR FOR THE BEEPING NOISE TO STOP. THE DEALER STATED THAT THEY CLEANED THE DOOR PINS. APPROXIMATELY A YEAR AND A HALF LATER, THE FAILURE RECURRED. THE DEALER STATED THAT THEY CHANGED THE HARD SIDE TRIM. APPROXIMATELY SIX MONTHS LATER, THE FAILURE RECURRED FOR THE THIRD TIME. THE DEALER HAS NOT INSPECTED THE VEHIC… Look up ODI 10195669 at NHTSA ↗ ODI 10251421 · 11,584 mi WE PURCHASE THE VAN MARCH 2006 AS THE FIRST OWNERS. THE ORIGINAL PROBLEM STARTED IN JUNE OF 2007 WHEN THE PASSENGER SIDE POWER SLIDING DOOR WOULD OPEN BACK UP WHEN CLOSING. WE TOOK THE VAN TO THE DEALER AND THEY REPLACED THE DOOR JAM SWITCH. THE MILEAGE AT THE TIME WAS 11,584. FROM THAT TIME TO NOW DEC 2008, WITH 31,000 MILES, THE PROBLEM HAS CONTINUED AND ADDING IN THE DRIVER SIDE POWER SLIDING DOOR. THE PROBLEMS RANGED FROM DOORS CLOSING AND GETTING AN ALARM INDICATING THAT THE DOOR(S) WERE OPEN TO HAVING TO PLACE THE DOORS IN MANUAL IN ORDER… Look up ODI 10251421 at NHTSA ↗ ODI 10297585 · 30,000 mi TL THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING THE REAR SLIDING DOOR OPENED WITHOUT WARNING. HE PULLED OVER AND IT TOOK 10 MINUTES TO CLOSE THE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE CENSORS AND MOTOR WERE REPLACED. AFTER THE REPAIR HE EXPERIENCED AN IDENTICAL FAILURE. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND REPAIRED AT HIS EXPENSE. NONE ON THE REPAIRS HAVE REMEDIED THE FAILURE. THE FAILURE MILEAGE WAS 30000. THE CURRENT MILEAGE WAS 112107. Look up ODI 10297585 at NHTSA ↗
Latches/Locks/Linkages	25,250–53,500 mi	37,800 mi	8	ODI 10237385 · 23,000 mi TLTHE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT THE PASSENGER SIDE ELECTRIC DOOR DOES NOT LATCH PROPERLY. AS A RESULT, THE DOOR OPENS WHILE THE VEHICLE IS MOVING. HE TOOK THE VEHICLE TO THE DEALER AND THEY RE-ADJUSTED THE DOOR STRIKER. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. SECONDLY, HE NOTICED EXCESSIVE VIBRATION WHEN DEPRESSING THE BRAKE PEDAL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY MACHINED HIS BRAKING SYSTEM. AFTER THE REPAIR, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO ANOTHER DE… Look up ODI 10237385 at NHTSA ↗ ODI 10244585 · 63,000 mi POWER DOOR ON 2005 SATURN RELAY IS NOT SHUTTING COMPLETELY AND IT HAS ALSO STARTED TO OPEN WHILE DRIVING. IT HAS NOT OPENED COMPLETELY WHILE DRIVING, BUT IT SEPARATES ENOUGH THAT THE LOCKING SYSTEM ON THE CAR STARTS TO LOCK AND UNLOCK ALL THE DOORS REPEATEDLY. THE INTERIOR MANUAL HANDLE TO CONTROL THE DOOR NO LONGER WORKS, BUT IT DOES WORK BY USING THE INTERIOR BUTTON. THE EXTERIOR HANDLE DOES NOT WORK 100% OF THE TIME AND SOMETIMES THE DOOR DOES NOT FULLY OPEN AND HAS TO BE MANUALLY PUSHED OPEN THE REST OF THE WAY, OR SHUT AND THEN REOPENED… Look up ODI 10244585 at NHTSA ↗ ODI 10281096 · 55,000 mi TLTHE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE PASSENGER SIDE DOORS OPENED WITHOUT WARNING. THE DRIVER HAD TO STOP THE VEHICLE TO CLOSE THE DOORS; HOWEVER, THEY WOULD NOT CLOSE COMPLETELY AND CONTINUED TO PEN WHILE DRIVING. THE DEALER INSPECTED THE VEHICLE AND WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT TO HAVE THE VEHICLE REINSPECTED BY A SATURN DEALER. THE MANUFACTURER ALSO STATED THAT SINCE THE MILEAGE WAS HIGH THEY WOULD NOT COMPENSATE THEM FOR ANY REPAIRS. THE IS AWARE O… Look up ODI 10281096 at NHTSA ↗
Electronic Stability Control (Esc)	66,500–110,500 mi	86,000 mi	7	ODI 10248524 · 42,000 mi ON SUNDAY, NOVEMBER 9, 2008 I WAS BACKING UP IN MY DRIVEWAY WHEN THE TRACTION CONTROL ENGAGED BRIEFLY, STOPPED AND THE SERVICE LIGHT FOR BOTH THE TC AND THE ABS REMAINED ON. I HAVE NOT BEEN ABLE TO GET RID OF THE SERVICE LIGHTS. ON MONDAY I BROUGHT THE VAN INTO THE LOCAL GARAGE. IN JUNE 2008, I HAD THE SAME PROBLEM BUT THE SERVICE LIGHTS TURNED OFF. THE SAME GARAGE PUT IN NEW BALL BEARINGS INCLUDING THE ONE THAT HAS THE SENSOR IN IT FOR THE TC AND ABS. I HAVE READ THE EBCM MODULE OR THE SENSOR ON THE BALL BEARING COULD BE THE PROBLEM. *TR… Look up ODI 10248524 at NHTSA ↗ ODI 10443718 · 86,000 mi 12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. … Look up ODI 10443718 at NHTSA ↗ ODI 10520704 · 78,000 mi WHILE DRIVING ON FREEWAY, SATURN RELAY 2005 SLOWED DOWN AND LOST POWER INTERMITTENTLY. DASH WARNING LIGHTS FLASHED ON AND OFF (ABS/STABILITY/TRACTION) - WARNING LIGHTS. THE VEHICLE HAD NO POWER ON AND OFF. WHEN I APPLIED THE GAS, THE VEHICLE BOGGED DOWN AND CONTINUED TO SLOW. THEN ALL OF A SUDDEN, THE VEHICLE ACCELERATED WHEN I DEPRESSED THE GAS PEDAL. I COULD NOT MOVE OVER TO THE BERM DUE TO HEAVY TRAFFIC SO I ATTEMPTED TO EXIT AT AN UPCOMING EXIT RAMP. WHEN I APPLIED THE BRAKES NOTHING HAPPENED THE FIRST FEW TIMES. THEN THE BRAKES WORKED SO I… Look up ODI 10520704 at NHTSA ↗
Exterior Lighting	7,359–95,000 mi	50,400 mi	6	ODI 10116052 · 750 mi HEADLIGHTS, DASH LIGHTS AND INTERIOR LIGHTS GO DIM/BRIGHT/DIM/BRIGHT ETC. AT NIGHT WHEN ACCELERATION WITH FOOT OR WITH USE OF CRUSE CONTROL. NOTIFIED SATURN AND ALSO DEALER. THEY BOTH SAID THIS IS A CHARACTERISTIC OF THE RELAY. DEALER ALSO SAID THEY HAD THE SAME PROIBLEM WITH THE L SERIES. SATURN NOR DEALER HAVE ATTEMPTED TO TALK DIRECTLY TO ME OR FIX IT DESPITE E-MAILS, LETTERS, PHONE CALLS. I WORRY THAT AN 18 WHEELER MIGHT THINK I AM FLASHING HIM THAT IT IS OK TO PULL OVER TO THE RIGHT. THIS IS A DANGEROUS SITUATION AND THE NEW 05 SATURN RELA… Look up ODI 10116052 at NHTSA ↗ ODI 10144004 · 2,878 mi DT: THE CONTACT STATES THERE WAS AN ONGOING PROBLEM WITH EXTERIOR AND INTERIOR LIGHTING. WHILE DRIVING, THE HEADLIGHTS AND THE DASHBOARD PANEL LIGHTS FLICKERED FROM BRIGHT TO DIM. ALSO, THE IDLE WAS VERY LOUD AND ROUGH. SHE TOOK THE VEHICLE TO THE DEALER. THE DEALER REPLACED THE ALTERNATOR. THIS DID NOT CORRECT THE PROBLEM. THE DEALER WAS UNABLE TO ACCURATELY DIAGNOSE THE PROBLEM, AND NO FURTHER REPAIRS WERE MADE. AK UPDATED 12/27/2005. THE HORN SPRINGS WERE DEFORM WHICH RESULTED IN THE HORN BEING INOPERATIVE. THE SLIDING DOOR WOULD … Look up ODI 10144004 at NHTSA ↗ ODI 10167074 · 20,800 mi DT: THE CONTACT STATED THE EXTERIOR AND INTERIOR LIGHTS BECAME DIM AND BRIGHTENED WHILE DRIVING. THE PROBLEM WORSENED WHILE THE CRUISE CONTROL WAS ON. THE DEALERSHIP WAS MADE AWARE OF THE PROBLEM, BUT THERE WERE NO REPAIRS PERFORMED. Look up ODI 10167074 at NHTSA ↗
Power Train	128,575–136,525 mi	128,950 mi	6	ODI 10267433 · 45,000 mi MY WIFE PLACED OUR 2005 SATURN RELAY MINIVAN IN PARK, AND STEPPED OUT TO GET THE MAIL. THE VAN IMMEDIATELY STARTED BACKWARDS, WITH THE DOOR PUSHING HER DOWN. LUCKILY, AS IT PUSHED HER DOWN, SHE FELL TO THE INSIDE, AND WAS ABLE TO ACTIVATE THE PARKING BRAKE WITH HER HAND, STOPPING THE CAR. SHE DID RECEIVE A VERY MINOR KNEE INJURY, BUT IT COULD HAVE BEEN MUCH WORSE. OUR TWO DAUGHTERS WERE BOTH IN THE CAR, WHICH WOULD HAVE ROLLED DOWN A HILL AND INTO A NEIGHBORS HOUSE, HAD SHE NOT STOPPED IT. MY FIRST THOUGHT WAS THAT SHE'D MADE A MIS… Look up ODI 10267433 at NHTSA ↗ ODI 10295177 · 139,000 mi AWD DISABLED WHEN NEEDED IN SNOW. IT SEEMS TO BE CAUSED BY ICY SLUSH. I CONFIRMED WITH THE DEALER THAT THE HUB ASSEMBLY'S AWD SENSOR CAN GET COVERED UP WITH MUD OR SLUSH AND THE AWD SYSTEM WILL DISABLE. ANY AWD SYSTEM THAT GETS DISABLED BY SLUSH IS LUDICROUSLY DESIGNED, AND BORDERLINE NEGLIGENT WITH REGARDS TO SAFETY. *TR Look up ODI 10295177 at NHTSA ↗ ODI 10568780 · 128,500 mi NOTED THAT DRIVING LIGHTS FLASHED WITH WIPERS ON DELAY SETTING. AT NEXT USE, LOW OIL PRESSURE LIGHT & WARNING SOUNDED BUT LIGHTS DID NOT FLASH WITH DELAY WIPERS. TURNING OFF ENGINE AND PULLING HOOD LATCH & CLOSING HOOD ENDED LOW PRESSURE WARNING (OIL PRESSURE/ LEVEL WERE CORRECT-FALSE ALARM). 2 DAYS LATER, LIGHTS AGAIN FLASHED WITH WIPERS ON DELAY BUT NO OIL PRESSURE WARNING. CONTINUED THIS BACK-AND-FORTH (EITHER OIL WARNING OR LIGHT FLASH WITH WIPER USE, BUT NOT CONCOMITANT) FOR 2 MONTHS, THEN LOW PRESSURE WARNINGS BECAME CONSTANT, AND THE LIG… Look up ODI 10568780 at NHTSA ↗

Complaint and recall timeline

Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.

ComponentPeriod

Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.

Monthly counts, recall campaigns and complaint examples

Monthly complaint and recall timeline
Month	Campaigns announced	Examples
2024-10	None	No examples available for this selection.
2024-11	None	No examples available for this selection.
2024-12	None	No examples available for this selection.
2025-01	None	No examples available for this selection.
2025-02	None	No examples available for this selection.
2025-03	None	No examples available for this selection.
2025-04	None	No examples available for this selection.
2025-05	None	No examples available for this selection.
2025-06	None	No examples available for this selection.
2025-07	None	No examples available for this selection.
2025-08	None	No examples available for this selection.
2025-09	None	No examples available for this selection.
2025-10	None	No examples available for this selection.
2025-11	None	No examples available for this selection.
2025-12	None	No examples available for this selection.
2026-01	None	No examples available for this selection.
2026-02	None	No examples available for this selection.
2026-03	None	No examples available for this selection.
2026-04	None	No examples available for this selection.
2026-05	None	No examples available for this selection.
2026-06	None	No examples available for this selection.
2026-07	None	No examples available for this selection.
2026-08	None	No examples available for this selection.
2026-09 (partial)	None	No examples available for this selection.

Emerging complaint spikes

Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.

This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.

No complete months meet the spike thresholds for this selection.

Equal-age model-year comparison

Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.

Observation windowFirst model yearSecond model year

2006: 9 complaints · 2007: 8 complaints

Equal observation windows
Model year	Through age 0	Through age 1	Through age 2
2006	5	7	9
2007	2	5	8

Date coverage across each selected cohort

Date basis for all complaints in selected model years
Year	Incident dates used	Filing date fallbacks	Excluded dates
2006	19	0	0
2007	12	0	0

Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.

Components reported together

Each cell counts unique complaints naming both components. Open a nonzero cell for examples.

Component co-occurrence matrix
Component	Electrical System	Service Brakes, Hydraulic	Service Brakes	Structure:Body:Door	Latches/Locks/Linkages	Electronic Stability Control (Esc)	Exterior Lighting	Power Train
Electrical System	—	3 ODI 10175424 · 1,000 mi 2005 SATURN RELAY HAS NUMEROUS DESIGN FLAWS, AND SATURN IS UNABLE TO FIX. ONSTAR DISABLES SPEEDOMETER WHEN USED, RADIO MUTES AND CAR MUST BE TURNED OFF AND BACK ON TO RESET, ABS SYSTEM MALFUNCTIONS REPEATEDLY EVEN AFTER REPLACING EBCM, ABS PUMP, BCM, LIGHTS FLICKER BOTH INTERIOR AND EXTERIOR, ALTERNATOR FOUND TO HAVE ERRATIC OUTPUT, NEW ALTERNATOR DID NOT SOLVE PROBLEM. BRAKE ROTORS WARPED WITHIN 25K MILES. SATURN WILL ONLY KEEPING TRYING TO REPAIR, BUT IS UNABLE TO SOLVE PROBLEMS. *NM Look up ODI 10175424 at NHTSA ↗ ODI 10366814 · 148,000 mi I BOUGHT A USED 2005 SATURN RELAY 3 IN JANUARY 2010. I HAVE 2 MAJOR ISSUES GOING ON: POWER SLIDING DOORS WILL NOT RECOGNIZE THAT THEY ARE CLOSED AND WILL CONTINUE TO DING AS IF I WAS DRIVING WITH THEM OPEN...ON A FEW OCCASIONS I HAVE HEARD THE POWER DOOR MOTOR START ON ITS OWN AS IF IT WAS TRYING TO OPEN THE DOORS WHILE I AM DRIVING! SECOND ISSUE IS ABS/TRACTION CONTROL LIGHTS HAVE BEEN COMING ON SPORADICALLY SINCE I PURCHASED IT. OF COURSE, NO ONE CAN FIND THE PROBLEM BECAUSE THEY CAN'T REPLICATE IT. IT DOESN'T MATTER THE DRIVING CONDITION… Look up ODI 10366814 at NHTSA ↗ ODI 10443718 · 86,000 mi 12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. … Look up ODI 10443718 at NHTSA ↗	4 ODI 10489110 · 80,000 mi ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. TR Look up ODI 10489110 at NHTSA ↗ ODI 10567927 AFTER HAVING MY BRAKES REPLACED, THE ABS LIGHT CONTINUES TO COME ON. THE LIGHT WILL GO OFF FOR AWHILE, BUT EVERY TIME I APPLY THE BRAKES IT WILL COME BACK ON FOR DAYS. I AM ALSO HAVING ISSUES WITH MY BRAKE LIGHTS, TURN SIGNALS, AND HEADLIGHTS. THEY KEEP GOING IN AND OUT. SOMETIMES THE PASSENGER SIDE DOOR WILL NOT OPEN OR CLOSE CORRECTLY, I CHECK TO MAKE SURE NOTHING IS IN THE WAY BUT STILL HAVE THE PROBLEM. TR Look up ODI 10567927 at NHTSA ↗ ODI 10885096 · 90,000 mi TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE OPERATING THE VEHICLE, THE SPEED SENSOR AND TRACTION CONTROL SENSOR LIGHTS ILLUMINATED AND THE BRAKING DISTANCE INCREASED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC BODY CONTROL MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. ALSO, THE SLIDING DOOR CHIME ACTIVATED EVEN THOUGH BOTH SLIDING DOORS WERE CLOSED. ALSO, THE STEERING WHEEL SUDDENLY BECAME VERY DIFFICULT TO TURN. THE CAUSE OF THE FAILURES WER… Look up ODI 10885096 at NHTSA ↗	0	0	3 ODI 10443718 · 86,000 mi 12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. … Look up ODI 10443718 at NHTSA ↗ ODI 10758509 · 110,000 mi THE FIRST TIME I WAS PARKED AND THE VAN WOULD NOT START. I WAS TOLD IT MIGHT BE THE FUEL PUMP. I HAD THE VAN TOW TO A SERVICE CENTER. THEY SAID IT WAS THE FUEL RELAY. I PAID TO HAVE THE FUEL RELAY REPLACED. A FEW DAYS LATER SAME THING HAPPENED AGAIN. THE VAN WOULD NOT START. THIS TIME WE THOUGHT IT WAS THE BATTERY OR SPARK PLUGS. I PAID TO HAVE A NEW BATTERY, NEW SPARK PLUGS, SPARK PLUG CABLES. A FEW DAYS LATER I WAS LEAVING FROM WORK AND THE VAN WOULD NOT START AGAIN. I HAD IT TOW AND THEY SAID IT MIGHT BE THE FUEL PUMP. THEY WERE GOING TO REP… Look up ODI 10758509 at NHTSA ↗ ODI 11030754 · 130,000 mi SERVICE ABS AND SERVICE TRACTION CONTROL LIGHTS CAME ON AND HAVE REMAINED ON FOR SEVERAL DAYS. FURTHER MESSAGES CONTINUE FLASHING ON THE DRIVER INFORMATION CENTER. THIS HAS BEEN A RECURRING PROBLEM OVER THE PAST YEAR AFTER ABS WHEEL SENSORS AND THE ASSOCIATED WIRING WERE REPLACED. WITH THE NUMEROUS COMPLAINTS ON THE INTERNET - I WAS THINKING THAT SURELY A TSB OR RECALL ON THESE ISSUES HAS BEEN OVERLOOKED OR SIMPLY IGNORED BY THE MECHANICS AND SERVICE WRITERS AT THE GM DEALERSHIPS NATIONWIDE. I KNOW THAT A TECH LL SCANNER IS REQUIRED TO CHECK FO… Look up ODI 11030754 at NHTSA ↗	5 ODI 10144004 · 2,878 mi DT: THE CONTACT STATES THERE WAS AN ONGOING PROBLEM WITH EXTERIOR AND INTERIOR LIGHTING. WHILE DRIVING, THE HEADLIGHTS AND THE DASHBOARD PANEL LIGHTS FLICKERED FROM BRIGHT TO DIM. ALSO, THE IDLE WAS VERY LOUD AND ROUGH. SHE TOOK THE VEHICLE TO THE DEALER. THE DEALER REPLACED THE ALTERNATOR. THIS DID NOT CORRECT THE PROBLEM. THE DEALER WAS UNABLE TO ACCURATELY DIAGNOSE THE PROBLEM, AND NO FURTHER REPAIRS WERE MADE. AK UPDATED 12/27/2005. THE HORN SPRINGS WERE DEFORM WHICH RESULTED IN THE HORN BEING INOPERATIVE. THE SLIDING DOOR WOULD … Look up ODI 10144004 at NHTSA ↗ ODI 10489110 · 80,000 mi ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. TR Look up ODI 10489110 at NHTSA ↗ ODI 10567927 AFTER HAVING MY BRAKES REPLACED, THE ABS LIGHT CONTINUES TO COME ON. THE LIGHT WILL GO OFF FOR AWHILE, BUT EVERY TIME I APPLY THE BRAKES IT WILL COME BACK ON FOR DAYS. I AM ALSO HAVING ISSUES WITH MY BRAKE LIGHTS, TURN SIGNALS, AND HEADLIGHTS. THEY KEEP GOING IN AND OUT. SOMETIMES THE PASSENGER SIDE DOOR WILL NOT OPEN OR CLOSE CORRECTLY, I CHECK TO MAKE SURE NOTHING IS IN THE WAY BUT STILL HAVE THE PROBLEM. *TR Look up ODI 10567927 at NHTSA ↗	1 ODI 10568780 · 128,500 mi NOTED THAT DRIVING LIGHTS FLASHED WITH WIPERS ON DELAY SETTING. AT NEXT USE, LOW OIL PRESSURE LIGHT & WARNING SOUNDED BUT LIGHTS DID NOT FLASH WITH DELAY WIPERS. TURNING OFF ENGINE AND PULLING HOOD LATCH & CLOSING HOOD ENDED LOW PRESSURE WARNING (OIL PRESSURE/ LEVEL WERE CORRECT-FALSE ALARM). 2 DAYS LATER, LIGHTS AGAIN FLASHED WITH WIPERS ON DELAY BUT NO OIL PRESSURE WARNING. CONTINUED THIS BACK-AND-FORTH (EITHER OIL WARNING OR LIGHT FLASH WITH WIPER USE, BUT NOT CONCOMITANT) FOR 2 MONTHS, THEN LOW PRESSURE WARNINGS BECAME CONSTANT, AND THE LIG… Look up ODI 10568780 at NHTSA ↗
Service Brakes, Hydraulic	3 ODI 10175424 · 1,000 mi 2005 SATURN RELAY HAS NUMEROUS DESIGN FLAWS, AND SATURN IS UNABLE TO FIX. ONSTAR DISABLES SPEEDOMETER WHEN USED, RADIO MUTES AND CAR MUST BE TURNED OFF AND BACK ON TO RESET, ABS SYSTEM MALFUNCTIONS REPEATEDLY EVEN AFTER REPLACING EBCM, ABS PUMP, BCM, LIGHTS FLICKER BOTH INTERIOR AND EXTERIOR, ALTERNATOR FOUND TO HAVE ERRATIC OUTPUT, NEW ALTERNATOR DID NOT SOLVE PROBLEM. BRAKE ROTORS WARPED WITHIN 25K MILES. SATURN WILL ONLY KEEPING TRYING TO REPAIR, BUT IS UNABLE TO SOLVE PROBLEMS. *NM Look up ODI 10175424 at NHTSA ↗ ODI 10366814 · 148,000 mi I BOUGHT A USED 2005 SATURN RELAY 3 IN JANUARY 2010. I HAVE 2 MAJOR ISSUES GOING ON: POWER SLIDING DOORS WILL NOT RECOGNIZE THAT THEY ARE CLOSED AND WILL CONTINUE TO DING AS IF I WAS DRIVING WITH THEM OPEN...ON A FEW OCCASIONS I HAVE HEARD THE POWER DOOR MOTOR START ON ITS OWN AS IF IT WAS TRYING TO OPEN THE DOORS WHILE I AM DRIVING! SECOND ISSUE IS ABS/TRACTION CONTROL LIGHTS HAVE BEEN COMING ON SPORADICALLY SINCE I PURCHASED IT. OF COURSE, NO ONE CAN FIND THE PROBLEM BECAUSE THEY CAN'T REPLICATE IT. IT DOESN'T MATTER THE DRIVING CONDITION… Look up ODI 10366814 at NHTSA ↗ ODI 10443718 · 86,000 mi 12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. … Look up ODI 10443718 at NHTSA ↗	—	0	1 ODI 10211770 FAILURE OF SLIDING SIDE DOOR TO LOCK FAILURE OF WINDSHIELD WIPERS FAILURE OF REAR BRAKES. *TR Look up ODI 10211770 at NHTSA ↗	1 ODI 10237385 · 23,000 mi TL*THE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT THE PASSENGER SIDE ELECTRIC DOOR DOES NOT LATCH PROPERLY. AS A RESULT, THE DOOR OPENS WHILE THE VEHICLE IS MOVING. HE TOOK THE VEHICLE TO THE DEALER AND THEY RE-ADJUSTED THE DOOR STRIKER. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. SECONDLY, HE NOTICED EXCESSIVE VIBRATION WHEN DEPRESSING THE BRAKE PEDAL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY MACHINED HIS BRAKING SYSTEM. AFTER THE REPAIR, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO ANOTHER DE… Look up ODI 10237385 at NHTSA ↗	3 ODI 10248524 · 42,000 mi ON SUNDAY, NOVEMBER 9, 2008 I WAS BACKING UP IN MY DRIVEWAY WHEN THE TRACTION CONTROL ENGAGED BRIEFLY, STOPPED AND THE SERVICE LIGHT FOR BOTH THE TC AND THE ABS REMAINED ON. I HAVE NOT BEEN ABLE TO GET RID OF THE SERVICE LIGHTS. ON MONDAY I BROUGHT THE VAN INTO THE LOCAL GARAGE. IN JUNE 2008, I HAD THE SAME PROBLEM BUT THE SERVICE LIGHTS TURNED OFF. THE SAME GARAGE PUT IN NEW BALL BEARINGS INCLUDING THE ONE THAT HAS THE SENSOR IN IT FOR THE TC AND ABS. I HAVE READ THE EBCM MODULE OR THE SENSOR ON THE BALL BEARING COULD BE THE PROBLEM. TR… Look up ODI 10248524 at NHTSA ↗ ODI 10443718 · 86,000 mi 12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. … Look up ODI 10443718 at NHTSA ↗ ODI 10432537 · 111,000 mi I STARTED GETTING "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT WITH "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT AND "SERVICE STABILITY SYSTEM". ALL ARE ALWAYS AT THE SAME TIME. SHUTTING OFF THE ENGINE AND RESTARTING (PER OWNERS MANUAL) TEMPORARILY CAUSES THE LIGHTS AND MESSAGES TO TURN OFF, BUT THEY ALWAYS RETURN LATER. THIS PROBLEM IS WELL DOCUMENTED IN SATURN FORUMS AND IS HAPPENING WITH MANY, MANY OWNERS. TR Look up ODI 10432537 at NHTSA ↗	0	0
Service Brakes	4 ODI 10489110 · 80,000 mi ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. TR Look up ODI 10489110 at NHTSA ↗ ODI 10567927 AFTER HAVING MY BRAKES REPLACED, THE ABS LIGHT CONTINUES TO COME ON. THE LIGHT WILL GO OFF FOR AWHILE, BUT EVERY TIME I APPLY THE BRAKES IT WILL COME BACK ON FOR DAYS. I AM ALSO HAVING ISSUES WITH MY BRAKE LIGHTS, TURN SIGNALS, AND HEADLIGHTS. THEY KEEP GOING IN AND OUT. SOMETIMES THE PASSENGER SIDE DOOR WILL NOT OPEN OR CLOSE CORRECTLY, I CHECK TO MAKE SURE NOTHING IS IN THE WAY BUT STILL HAVE THE PROBLEM. TR Look up ODI 10567927 at NHTSA ↗ ODI 10885096 · 90,000 mi TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE OPERATING THE VEHICLE, THE SPEED SENSOR AND TRACTION CONTROL SENSOR LIGHTS ILLUMINATED AND THE BRAKING DISTANCE INCREASED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC BODY CONTROL MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. ALSO, THE SLIDING DOOR CHIME ACTIVATED EVEN THOUGH BOTH SLIDING DOORS WERE CLOSED. ALSO, THE STEERING WHEEL SUDDENLY BECAME VERY DIFFICULT TO TURN. THE CAUSE OF THE FAILURES WER… Look up ODI 10885096 at NHTSA ↗	0	—	0	0	2 ODI 10520704 · 78,000 mi WHILE DRIVING ON FREEWAY, SATURN RELAY 2005 SLOWED DOWN AND LOST POWER INTERMITTENTLY. DASH WARNING LIGHTS FLASHED ON AND OFF (ABS/STABILITY/TRACTION) - WARNING LIGHTS. THE VEHICLE HAD NO POWER ON AND OFF. WHEN I APPLIED THE GAS, THE VEHICLE BOGGED DOWN AND CONTINUED TO SLOW. THEN ALL OF A SUDDEN, THE VEHICLE ACCELERATED WHEN I DEPRESSED THE GAS PEDAL. I COULD NOT MOVE OVER TO THE BERM DUE TO HEAVY TRAFFIC SO I ATTEMPTED TO EXIT AT AN UPCOMING EXIT RAMP. WHEN I APPLIED THE BRAKES NOTHING HAPPENED THE FIRST FEW TIMES. THEN THE BRAKES WORKED SO I… Look up ODI 10520704 at NHTSA ↗ ODI 11030754 · 130,000 mi SERVICE ABS AND SERVICE TRACTION CONTROL LIGHTS CAME ON AND HAVE REMAINED ON FOR SEVERAL DAYS. FURTHER MESSAGES CONTINUE FLASHING ON THE DRIVER INFORMATION CENTER. THIS HAS BEEN A RECURRING PROBLEM OVER THE PAST YEAR AFTER ABS WHEEL SENSORS AND THE ASSOCIATED WIRING WERE REPLACED. WITH THE NUMEROUS COMPLAINTS ON THE INTERNET - I WAS THINKING THAT SURELY A TSB OR RECALL ON THESE ISSUES HAS BEEN OVERLOOKED OR SIMPLY IGNORED BY THE MECHANICS AND SERVICE WRITERS AT THE GM DEALERSHIPS NATIONWIDE. I KNOW THAT A TECH LL SCANNER IS REQUIRED TO CHECK FO… Look up ODI 11030754 at NHTSA ↗	2 ODI 10489110 · 80,000 mi ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. TR Look up ODI 10489110 at NHTSA ↗ ODI 10567927 AFTER HAVING MY BRAKES REPLACED, THE ABS LIGHT CONTINUES TO COME ON. THE LIGHT WILL GO OFF FOR AWHILE, BUT EVERY TIME I APPLY THE BRAKES IT WILL COME BACK ON FOR DAYS. I AM ALSO HAVING ISSUES WITH MY BRAKE LIGHTS, TURN SIGNALS, AND HEADLIGHTS. THEY KEEP GOING IN AND OUT. SOMETIMES THE PASSENGER SIDE DOOR WILL NOT OPEN OR CLOSE CORRECTLY, I CHECK TO MAKE SURE NOTHING IS IN THE WAY BUT STILL HAVE THE PROBLEM. TR Look up ODI 10567927 at NHTSA ↗	1 ODI 11149773 · 150,000 mi TL* THE CONTACT OWNS A 2007 SATURN RELAY. WHILE DRIVING 50 MPH, THE VEHICLE ACCELERATED TO 80 MPH. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE DID NOT DECELERATE. THE CONTACT PLACED THE VEHICLE INTO NEUTRAL AND THE SPEED DECREASED TO 40 MPH. THE CONTACT THEN SHIFTED INTO PARK AND THE VEHICLE STOPPED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000. Look up ODI 11149773 at NHTSA ↗
Structure:Body:Door	0	1 ODI 10211770 FAILURE OF SLIDING SIDE DOOR TO LOCK FAILURE OF WINDSHIELD WIPERS FAILURE OF REAR BRAKES. *TR Look up ODI 10211770 at NHTSA ↗	0	—	2 ODI 10242466 · 36,000 mi POWER SLIDING DOOR ON 2006 SATURN RELAY IS NOT CLOSING PROPERLY AND OPENS UNEXPECTEDLY. DOOR DOES NOT CLOSE COMPLETELY, DOES NOT LATCH AND OCCASSIONALLY DOOR REOPENS WHILE VEHICLE IS MOVING. TROUBLE STARTED ABOT TWO MONTHS AGO BUT THE REGULARITY OF THIS OCCURRANCE HAS INCREASED SIGNIFICANLTY OVER THE LAST FOUR DAYS. *TR Look up ODI 10242466 at NHTSA ↗ ODI 10242745 · 17,000 mi I OWN A 2007 SATURN RELAY 3 MINIVAN. THE VAN HAS DUAL POWER ASSISTED REAR SLIDING CARGO DOORS. DURING MY FAMILY'S EVACUATION FOR HURRICANE GUSTAV THE PASSENGER SIDE POWER ASSISTED SLIDING CARGO DOOR DID NOT CLOSE PROPERLY (DID NOT LATCH). I ELECTRICALLY RE-CLOSED THE DOOR AND LOCKED THE VEHICLE. DURING THE WEEK OF SEPTEMBER 1ST THROUGH SEPTEMBER 7TH THE SAME DOOR WOULD NOT CLOSE PROPERLY, UNLATCHED WHEN THE FORWARD DRIVER OR PASSENGER DOOR WAS CLOSED AFTER ENTERING, AND UNLATCHED WHILE I WAS DRIVING ON INTERSTATE I-10 PASSING THROUGH THE MOBILE… Look up ODI 10242745 at NHTSA ↗	0	0	0
Latches/Locks/Linkages	0	1 ODI 10237385 · 23,000 mi TL*THE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT THE PASSENGER SIDE ELECTRIC DOOR DOES NOT LATCH PROPERLY. AS A RESULT, THE DOOR OPENS WHILE THE VEHICLE IS MOVING. HE TOOK THE VEHICLE TO THE DEALER AND THEY RE-ADJUSTED THE DOOR STRIKER. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. SECONDLY, HE NOTICED EXCESSIVE VIBRATION WHEN DEPRESSING THE BRAKE PEDAL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY MACHINED HIS BRAKING SYSTEM. AFTER THE REPAIR, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO ANOTHER DE… Look up ODI 10237385 at NHTSA ↗	0	2 ODI 10242466 · 36,000 mi POWER SLIDING DOOR ON 2006 SATURN RELAY IS NOT CLOSING PROPERLY AND OPENS UNEXPECTEDLY. DOOR DOES NOT CLOSE COMPLETELY, DOES NOT LATCH AND OCCASSIONALLY DOOR REOPENS WHILE VEHICLE IS MOVING. TROUBLE STARTED ABOT TWO MONTHS AGO BUT THE REGULARITY OF THIS OCCURRANCE HAS INCREASED SIGNIFICANLTY OVER THE LAST FOUR DAYS. *TR Look up ODI 10242466 at NHTSA ↗ ODI 10242745 · 17,000 mi I OWN A 2007 SATURN RELAY 3 MINIVAN. THE VAN HAS DUAL POWER ASSISTED REAR SLIDING CARGO DOORS. DURING MY FAMILY'S EVACUATION FOR HURRICANE GUSTAV THE PASSENGER SIDE POWER ASSISTED SLIDING CARGO DOOR DID NOT CLOSE PROPERLY (DID NOT LATCH). I ELECTRICALLY RE-CLOSED THE DOOR AND LOCKED THE VEHICLE. DURING THE WEEK OF SEPTEMBER 1ST THROUGH SEPTEMBER 7TH THE SAME DOOR WOULD NOT CLOSE PROPERLY, UNLATCHED WHEN THE FORWARD DRIVER OR PASSENGER DOOR WAS CLOSED AFTER ENTERING, AND UNLATCHED WHILE I WAS DRIVING ON INTERSTATE I-10 PASSING THROUGH THE MOBILE… Look up ODI 10242745 at NHTSA ↗	—	0	0	0
Electronic Stability Control (Esc)	3 ODI 10443718 · 86,000 mi 12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. … Look up ODI 10443718 at NHTSA ↗ ODI 10758509 · 110,000 mi THE FIRST TIME I WAS PARKED AND THE VAN WOULD NOT START. I WAS TOLD IT MIGHT BE THE FUEL PUMP. I HAD THE VAN TOW TO A SERVICE CENTER. THEY SAID IT WAS THE FUEL RELAY. I PAID TO HAVE THE FUEL RELAY REPLACED. A FEW DAYS LATER SAME THING HAPPENED AGAIN. THE VAN WOULD NOT START. THIS TIME WE THOUGHT IT WAS THE BATTERY OR SPARK PLUGS. I PAID TO HAVE A NEW BATTERY, NEW SPARK PLUGS, SPARK PLUG CABLES. A FEW DAYS LATER I WAS LEAVING FROM WORK AND THE VAN WOULD NOT START AGAIN. I HAD IT TOW AND THEY SAID IT MIGHT BE THE FUEL PUMP. THEY WERE GOING TO REP… Look up ODI 10758509 at NHTSA ↗ ODI 11030754 · 130,000 mi SERVICE ABS AND SERVICE TRACTION CONTROL LIGHTS CAME ON AND HAVE REMAINED ON FOR SEVERAL DAYS. FURTHER MESSAGES CONTINUE FLASHING ON THE DRIVER INFORMATION CENTER. THIS HAS BEEN A RECURRING PROBLEM OVER THE PAST YEAR AFTER ABS WHEEL SENSORS AND THE ASSOCIATED WIRING WERE REPLACED. WITH THE NUMEROUS COMPLAINTS ON THE INTERNET - I WAS THINKING THAT SURELY A TSB OR RECALL ON THESE ISSUES HAS BEEN OVERLOOKED OR SIMPLY IGNORED BY THE MECHANICS AND SERVICE WRITERS AT THE GM DEALERSHIPS NATIONWIDE. I KNOW THAT A TECH LL SCANNER IS REQUIRED TO CHECK FO… Look up ODI 11030754 at NHTSA ↗	3 ODI 10248524 · 42,000 mi ON SUNDAY, NOVEMBER 9, 2008 I WAS BACKING UP IN MY DRIVEWAY WHEN THE TRACTION CONTROL ENGAGED BRIEFLY, STOPPED AND THE SERVICE LIGHT FOR BOTH THE TC AND THE ABS REMAINED ON. I HAVE NOT BEEN ABLE TO GET RID OF THE SERVICE LIGHTS. ON MONDAY I BROUGHT THE VAN INTO THE LOCAL GARAGE. IN JUNE 2008, I HAD THE SAME PROBLEM BUT THE SERVICE LIGHTS TURNED OFF. THE SAME GARAGE PUT IN NEW BALL BEARINGS INCLUDING THE ONE THAT HAS THE SENSOR IN IT FOR THE TC AND ABS. I HAVE READ THE EBCM MODULE OR THE SENSOR ON THE BALL BEARING COULD BE THE PROBLEM. TR… Look up ODI 10248524 at NHTSA ↗ ODI 10443718 · 86,000 mi 12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. … Look up ODI 10443718 at NHTSA ↗ ODI 10432537 · 111,000 mi I STARTED GETTING "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT WITH "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT AND "SERVICE STABILITY SYSTEM". ALL ARE ALWAYS AT THE SAME TIME. SHUTTING OFF THE ENGINE AND RESTARTING (PER OWNERS MANUAL) TEMPORARILY CAUSES THE LIGHTS AND MESSAGES TO TURN OFF, BUT THEY ALWAYS RETURN LATER. THIS PROBLEM IS WELL DOCUMENTED IN SATURN FORUMS AND IS HAPPENING WITH MANY, MANY OWNERS. TR Look up ODI 10432537 at NHTSA ↗	2 ODI 10520704 · 78,000 mi WHILE DRIVING ON FREEWAY, SATURN RELAY 2005 SLOWED DOWN AND LOST POWER INTERMITTENTLY. DASH WARNING LIGHTS FLASHED ON AND OFF (ABS/STABILITY/TRACTION) - WARNING LIGHTS. THE VEHICLE HAD NO POWER ON AND OFF. WHEN I APPLIED THE GAS, THE VEHICLE BOGGED DOWN AND CONTINUED TO SLOW. THEN ALL OF A SUDDEN, THE VEHICLE ACCELERATED WHEN I DEPRESSED THE GAS PEDAL. I COULD NOT MOVE OVER TO THE BERM DUE TO HEAVY TRAFFIC SO I ATTEMPTED TO EXIT AT AN UPCOMING EXIT RAMP. WHEN I APPLIED THE BRAKES NOTHING HAPPENED THE FIRST FEW TIMES. THEN THE BRAKES WORKED SO I… Look up ODI 10520704 at NHTSA ↗ ODI 11030754 · 130,000 mi SERVICE ABS AND SERVICE TRACTION CONTROL LIGHTS CAME ON AND HAVE REMAINED ON FOR SEVERAL DAYS. FURTHER MESSAGES CONTINUE FLASHING ON THE DRIVER INFORMATION CENTER. THIS HAS BEEN A RECURRING PROBLEM OVER THE PAST YEAR AFTER ABS WHEEL SENSORS AND THE ASSOCIATED WIRING WERE REPLACED. WITH THE NUMEROUS COMPLAINTS ON THE INTERNET - I WAS THINKING THAT SURELY A TSB OR RECALL ON THESE ISSUES HAS BEEN OVERLOOKED OR SIMPLY IGNORED BY THE MECHANICS AND SERVICE WRITERS AT THE GM DEALERSHIPS NATIONWIDE. I KNOW THAT A TECH LL SCANNER IS REQUIRED TO CHECK FO… Look up ODI 11030754 at NHTSA ↗	0	0	—	0	0
Exterior Lighting	5 ODI 10144004 · 2,878 mi DT: THE CONTACT STATES THERE WAS AN ONGOING PROBLEM WITH EXTERIOR AND INTERIOR LIGHTING. WHILE DRIVING, THE HEADLIGHTS AND THE DASHBOARD PANEL LIGHTS FLICKERED FROM BRIGHT TO DIM. ALSO, THE IDLE WAS VERY LOUD AND ROUGH. SHE TOOK THE VEHICLE TO THE DEALER. THE DEALER REPLACED THE ALTERNATOR. THIS DID NOT CORRECT THE PROBLEM. THE DEALER WAS UNABLE TO ACCURATELY DIAGNOSE THE PROBLEM, AND NO FURTHER REPAIRS WERE MADE. AK UPDATED 12/27/2005. THE HORN SPRINGS WERE DEFORM WHICH RESULTED IN THE HORN BEING INOPERATIVE. THE SLIDING DOOR WOULD … Look up ODI 10144004 at NHTSA ↗ ODI 10489110 · 80,000 mi ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. TR Look up ODI 10489110 at NHTSA ↗ ODI 10567927 AFTER HAVING MY BRAKES REPLACED, THE ABS LIGHT CONTINUES TO COME ON. THE LIGHT WILL GO OFF FOR AWHILE, BUT EVERY TIME I APPLY THE BRAKES IT WILL COME BACK ON FOR DAYS. I AM ALSO HAVING ISSUES WITH MY BRAKE LIGHTS, TURN SIGNALS, AND HEADLIGHTS. THEY KEEP GOING IN AND OUT. SOMETIMES THE PASSENGER SIDE DOOR WILL NOT OPEN OR CLOSE CORRECTLY, I CHECK TO MAKE SURE NOTHING IS IN THE WAY BUT STILL HAVE THE PROBLEM. *TR Look up ODI 10567927 at NHTSA ↗	0	2 ODI 10489110 · 80,000 mi ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. TR Look up ODI 10489110 at NHTSA ↗ ODI 10567927 AFTER HAVING MY BRAKES REPLACED, THE ABS LIGHT CONTINUES TO COME ON. THE LIGHT WILL GO OFF FOR AWHILE, BUT EVERY TIME I APPLY THE BRAKES IT WILL COME BACK ON FOR DAYS. I AM ALSO HAVING ISSUES WITH MY BRAKE LIGHTS, TURN SIGNALS, AND HEADLIGHTS. THEY KEEP GOING IN AND OUT. SOMETIMES THE PASSENGER SIDE DOOR WILL NOT OPEN OR CLOSE CORRECTLY, I CHECK TO MAKE SURE NOTHING IS IN THE WAY BUT STILL HAVE THE PROBLEM. TR Look up ODI 10567927 at NHTSA ↗	0	0	0	—	1 ODI 10568780 · 128,500 mi NOTED THAT DRIVING LIGHTS FLASHED WITH WIPERS ON DELAY SETTING. AT NEXT USE, LOW OIL PRESSURE LIGHT & WARNING SOUNDED BUT LIGHTS DID NOT FLASH WITH DELAY WIPERS. TURNING OFF ENGINE AND PULLING HOOD LATCH & CLOSING HOOD ENDED LOW PRESSURE WARNING (OIL PRESSURE/ LEVEL WERE CORRECT-FALSE ALARM). 2 DAYS LATER, LIGHTS AGAIN FLASHED WITH WIPERS ON DELAY BUT NO OIL PRESSURE WARNING. CONTINUED THIS BACK-AND-FORTH (EITHER OIL WARNING OR LIGHT FLASH WITH WIPER USE, BUT NOT CONCOMITANT) FOR 2 MONTHS, THEN LOW PRESSURE WARNINGS BECAME CONSTANT, AND THE LIG… Look up ODI 10568780 at NHTSA ↗
Power Train	1 ODI 10568780 · 128,500 mi NOTED THAT DRIVING LIGHTS FLASHED WITH WIPERS ON DELAY SETTING. AT NEXT USE, LOW OIL PRESSURE LIGHT & WARNING SOUNDED BUT LIGHTS DID NOT FLASH WITH DELAY WIPERS. TURNING OFF ENGINE AND PULLING HOOD LATCH & CLOSING HOOD ENDED LOW PRESSURE WARNING (OIL PRESSURE/ LEVEL WERE CORRECT-FALSE ALARM). 2 DAYS LATER, LIGHTS AGAIN FLASHED WITH WIPERS ON DELAY BUT NO OIL PRESSURE WARNING. CONTINUED THIS BACK-AND-FORTH (EITHER OIL WARNING OR LIGHT FLASH WITH WIPER USE, BUT NOT CONCOMITANT) FOR 2 MONTHS, THEN LOW PRESSURE WARNINGS BECAME CONSTANT, AND THE LIG… Look up ODI 10568780 at NHTSA ↗	0	1 ODI 11149773 · 150,000 mi TL* THE CONTACT OWNS A 2007 SATURN RELAY. WHILE DRIVING 50 MPH, THE VEHICLE ACCELERATED TO 80 MPH. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE DID NOT DECELERATE. THE CONTACT PLACED THE VEHICLE INTO NEUTRAL AND THE SPEED DECREASED TO 40 MPH. THE CONTACT THEN SHIFTED INTO PARK AND THE VEHICLE STOPPED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000. Look up ODI 11149773 at NHTSA ↗	0	0	0	1 ODI 10568780 · 128,500 mi NOTED THAT DRIVING LIGHTS FLASHED WITH WIPERS ON DELAY SETTING. AT NEXT USE, LOW OIL PRESSURE LIGHT & WARNING SOUNDED BUT LIGHTS DID NOT FLASH WITH DELAY WIPERS. TURNING OFF ENGINE AND PULLING HOOD LATCH & CLOSING HOOD ENDED LOW PRESSURE WARNING (OIL PRESSURE/ LEVEL WERE CORRECT-FALSE ALARM). 2 DAYS LATER, LIGHTS AGAIN FLASHED WITH WIPERS ON DELAY BUT NO OIL PRESSURE WARNING. CONTINUED THIS BACK-AND-FORTH (EITHER OIL WARNING OR LIGHT FLASH WITH WIPER USE, BUT NOT CONCOMITANT) FOR 2 MONTHS, THEN LOW PRESSURE WARNINGS BECAME CONSTANT, AND THE LIG… Look up ODI 10568780 at NHTSA ↗	—

Co-reporting does not establish that one component caused another concern.

Recurring narrative patterns

Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.

Search patterns

6 patterns with matching reports.

Warning lights and dashboard alerts

14 mentions · 11.5% of complaints

Median mileage: 78,881 mi (14 usable records).

ODI 10202160 · 40,000 mi

I HAVE A 2005 SATURN RELAY. THREE WEEKS AGO, THE "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT AND THE "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT STARTED COMING ON INTERMITTENTLY (BUT BOTH ALWAYS AT THE SAME TIME). IF I CUT OFF THE IGNITION AND RESTARTED THE CAR, THE MESSAGES AND LIGHTS WOULD GO AWAY UNTIL I STARTED THE CAR THE NEXT DAY. IN A ONE-WEEK PERIOD, THESE WARNINGS AND LIGHTS CAME ON THREE TO FOUR TIMES. THE DEALERSHIP WARNED ME THAT WHEN THE WARNING LIGHTS WERE ON, MY CAR DID NOT HAVE ABS OR TRACTION CONTROL. SO …

Look up ODI 10202160 at NHTSA ↗

ODI 10244255 · 41,256 mi

2005 SATURN RELAY. WHEEL SPEED SENSOR JUMPER WIRING REQUIRED REPLACEMENT (INDICATED BY WARNING LIGHT). ISSUE IS THE ANTI-LOCK BRAKES WILL NOT FUNCTION BASED ON MALFUNCTIONING SENSOR. GM WAS AWARE OF THE ISSUE, AND HAD A PROCEDURE IN PLACE FOR DEALER TO IMPLEMENT. THIS SHOULD BE A RECALL ISSUE, AS THE REMEDY REQUIRES A DIFFERENT WIRING PROCESS THAN ORIGINALLY ENGINEERED. DRIVERS ARE AT RISK WITHOUT ANTI-LOCK BRAKES. *TR UPDATED 12/10/08

Look up ODI 10244255 at NHTSA ↗

ODI 10340533 · 79,761 mi

I HAVE A 2005 SATURN RELAY. I PURCHASED THE VEHICLE "USED" FROM SATURN OF TEMPE ON MARCH 1ST, 2009. THE MILEAGE ON THE VEHICLE WHEN I PURCHASED IT WAS 62,245. ONE YEAR LATER I STARTED GETTING "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT WITH "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT OCCASIONALLY, BUT BOTH WERE ALWAYS AT THE SAME TIME. SHUTTING OFF THE ENGINE AND RESTARTING (PER OWNER?S MANUAL) TEMPORARILY CAUSED THE LIGHTS AND MESSAGES TO TURN OFF, BUT RETURNED DAYS LATER. I TOOK THE VEHICLE TO FLETCHER'S TIRE AND AUTO SER…

Look up ODI 10340533 at NHTSA ↗

Matching rule

\b(warning light\w*|check engine|dashboard warning\w*|malfunction indicator)\b

Brake response concerns

9 mentions · 7.4% of complaints

Median mileage: 60,000 mi (9 usable records).

ODI 10154805 · 12,746 mi

DT*: THE CONTACT STATED THE VEHICLE ROLLED SLIGHTLY BACKWARD ON AN INCLINE WHILE MOVING FOOT FROM THE BRAKE PEDAL TO THE ACCELERATOR PEDAL. ONE DEALER DETERMINED THIS WAS NORMAL AND ANOTHER DETERMINED A RECENT DESIGN CHANGE WAS THE CAUSE. UPDATED 5/2/2006 - *NM

Look up ODI 10154805 at NHTSA ↗

ODI 10216644 · 17,700 mi

TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING 5-20 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD WHEN DEPRESSED. IN ADDITION, THE PEDAL SHUTTERED. AS A RESULT, THERE WAS A LOSS OF STEERING. THE DEALER STATED THAT DEBRIS IN THE PLUGS CAUSED THE FAILURE. THEY CLEANED THE PLUGS; HOWEVER, THE FAILURE CONTINUED TO OCCUR. AS OF JANUARY 30, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 17,700 AND CURRENT MILEAGE WAS 34,880.

Look up ODI 10216644 at NHTSA ↗

ODI 10237385 · 23,000 mi

TL*THE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT THE PASSENGER SIDE ELECTRIC DOOR DOES NOT LATCH PROPERLY. AS A RESULT, THE DOOR OPENS WHILE THE VEHICLE IS MOVING. HE TOOK THE VEHICLE TO THE DEALER AND THEY RE-ADJUSTED THE DOOR STRIKER. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. SECONDLY, HE NOTICED EXCESSIVE VIBRATION WHEN DEPRESSING THE BRAKE PEDAL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY MACHINED HIS BRAKING SYSTEM. AFTER THE REPAIR, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO ANOTHER DE…

Look up ODI 10237385 at NHTSA ↗

Matching rule

Stalling or loss of power

7 mentions · 5.7% of complaints

Median mileage: 84,826 mi (6 usable records).

ODI 10149277

WITH A 1/4 OF A TANK OF GAS MY SATURN RELAY 2005 SHUT OFF ON A DECLINE CAUSING THE LOSS OF POWER BRAKES AND STEERING. THE MANUFACTURE SAID THE VEHICLE IS OPERATING AS DESIGNED! *NM

Look up ODI 10149277 at NHTSA ↗

ODI 10175584 · 31,239 mi

DT*: THE CONTACT STATED WHEN THE VEHICLE WAS FACING DOWN HILL MOVING OR PARKED, WITH 1/4 OF A TANK OF GAS OR LESS, THE FUEL GAUGE INDICATOR NEEDLE WOULD MOVE TOWARD EMPTY AND FUEL WOULD NOT FLOW TO THE ENGINE CAUSING A PROBLEM STARTING THE VEHICLE. ALSO, THIS CAUSED THE VEHICLE TO STALL WHILE THE VEHICLE MOVED DOWN HILL. THE SALES/SERVICE DEALER AND MANUFACTURER WERE NOTIFIED, AND THE CONTACT WAS INFORMED BY BOTH THE SERVICE DEALER AND THE MANUFACTURER, THAT THE DESIGN OF THE VEHICLE REQUIRED AT LEAST A HALF FULL TANK OF FUEL TO PREVENT ENGIN…

Look up ODI 10175584 at NHTSA ↗

ODI 10520704 · 78,000 mi

WHILE DRIVING ON FREEWAY, SATURN RELAY 2005 SLOWED DOWN AND LOST POWER INTERMITTENTLY. DASH WARNING LIGHTS FLASHED ON AND OFF (ABS/STABILITY/TRACTION) - WARNING LIGHTS. THE VEHICLE HAD NO POWER ON AND OFF. WHEN I APPLIED THE GAS, THE VEHICLE BOGGED DOWN AND CONTINUED TO SLOW. THEN ALL OF A SUDDEN, THE VEHICLE ACCELERATED WHEN I DEPRESSED THE GAS PEDAL. I COULD NOT MOVE OVER TO THE BERM DUE TO HEAVY TRAFFIC SO I ATTEMPTED TO EXIT AT AN UPCOMING EXIT RAMP. WHEN I APPLIED THE BRAKES NOTHING HAPPENED THE FIRST FEW TIMES. THEN THE BRAKES WORKED SO I…

Look up ODI 10520704 at NHTSA ↗

Matching rule

\b(stall\w*|loss of power|lost power|engine shut\w* off)\b

Hard or delayed shifting

3 mentions · 2.5% of complaints

Median mileage: 128,800 mi (3 usable records).

ODI 10443718 · 86,000 mi

12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. …

Look up ODI 10443718 at NHTSA ↗

ODI 10568789 · 129,100 mi

ATTEMPTED LOW/MODERATE ACCELERATION FROM STOP; TRANSMISSION SEEMED TO SLIP WITH ENGINE RPM INCREASING BUT NO TRANSFER OF POWER BEYOND ABOUT INITIAL HALF-FOOT OF FORWARD MOTION, THEN HARD SHIFTED INTO GEAR (LURCHED THE VEHICLE) AND ACCELERATED RAPIDLY. THIS EVENT WAS INITIALLY INTERMITTENT AND NOT ABLE TO BE REPRODUCED BY MECHANIC. IT HAS NOW BECOME FREQUENT AND AFFECTS SHIFTING AT HIGHWAY SPEEDS AS WELL AS FROM STOP, MAKING CONTROL OF ACCELERATION UNPREDICTABLE IS HARD SHIFTING THROUGH MOST GEARS WHEN THIS IS OCCURRING, ALTHOUGH AT OTHER TIMES …

Look up ODI 10568789 at NHTSA ↗

ODI 10568801 · 128,800 mi

AFTER STARTING VEHICLE, WITH FOOT ON BRAKE, GEAR SELECTION LEVER WOULD NOT MOVE FROM PARK AND PARKING BRAKE WOULD NOT DISENGAGE AS RESULT. SHUT DOWN ENGINE, RESTARTED WITH SAME RESULT. AFTER SEVERAL MORE ATTEMPTS TO MOVE THE SHIFT LEVER, IT FINALLY RELEASED FROM PARK BUT HAD DIFFICULTY MOVING DIRECTLY INTO REVERSE GEAR - IT HAD TO BE "ROWED" THRU ALL GEARS TO SETTLE TO REVERSE, AND THE TRANSMISSION DID NOT SEEM TO ENGAGE IN REVERSE INITIALLY. WHEN IT DID ENGAGE REVERSE GEAR, THE TRANSMISSION "JUMPED," LURCHING THE CAR (THE PARKING BRAKE HAD DIS…

Look up ODI 10568801 at NHTSA ↗

Matching rule

Battery drain and no-start mentions

2 mentions · 1.6% of complaints

Median mileage: 105,000 mi (2 usable records).

ODI 10489482 · 100,000 mi

FUEL READ A LITTLE LESS THAN 1/4 OF A TANK. DRIVING 40 MPH DOWN THE STREET, ENGINE STOPPED. WOULD NOT START. TOWED HOME. PUT GAS IN IT AND IT STARTED. HAPPENED AGAIN ON DEC 20. DRIVING 70MPH ON THE INTERSTATE. FUEL GAUGE AT 1/4 TANK. ENGINE STOPPED. PUT 2 GALLONS OF GAS IN AND IT STARTED. FUEL SENSOR WAS REPLACED IN SPRING OF 2010 BY AN AUTHORIZED GM DEALER[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Look up ODI 10489482 at NHTSA ↗

ODI 10758509 · 110,000 mi

THE FIRST TIME I WAS PARKED AND THE VAN WOULD NOT START. I WAS TOLD IT MIGHT BE THE FUEL PUMP. I HAD THE VAN TOW TO A SERVICE CENTER. THEY SAID IT WAS THE FUEL RELAY. I PAID TO HAVE THE FUEL RELAY REPLACED. A FEW DAYS LATER SAME THING HAPPENED AGAIN. THE VAN WOULD NOT START. THIS TIME WE THOUGHT IT WAS THE BATTERY OR SPARK PLUGS. I PAID TO HAVE A NEW BATTERY, NEW SPARK PLUGS, SPARK PLUG CABLES. A FEW DAYS LATER I WAS LEAVING FROM WORK AND THE VAN WOULD NOT START AGAIN. I HAD IT TOW AND THEY SAID IT MIGHT BE THE FUEL PUMP. THEY WERE GOING TO REP…

Look up ODI 10758509 at NHTSA ↗

Matching rule

Steering assistance concerns

1 mentions · 0.8% of complaints

Median mileage: 82,000 mi (1 usable records).

ODI 10335274 · 82,000 mi

MY 2006 SATURN ION ALL OF A SUDDEN LOST ITS POWER STEERING WHILE I WAS DRIVING! I ALMOST CRASHED! AND NOW IT GOING TO COST OVER 500 OR MORE TO FIX. I COULD HAVE BEEN KILLED, I WAS GOING UP A HILL ON A CURVE. JUST ALL OF A SUDDEN THE BELL RANG AND IT POPPED UP PWR STR. I GOT THE CAR STOPPED AND TURNED IT OFF WHEN I TURNED IT BACK ON IT WAS FINE FOR ABOUT 5 FEET AND AGAIN IT DID IT. I GOT HOME AND CHECKED THE FUSE AND MADE SURE IT WAS OK. TODAY I DROVE ALL OVER AND IT WAS OK AND THEN ALL OF A SUDDEN AGAIN IT CAME ON AND THE STEERING WHEEL …

Look up ODI 10335274 at NHTSA ↗

Matching rule

\b(power steer\w*|steering assist\w*|steering lock\w*|steering wheel lock\w*)\b