| Electrical System | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 323.1%ODI 10314924 · 1,500 miTHE MOTORCYCLE (SUZUKI C 90 BOULEVARD) WOBBLES UNCONTROLLABLY ON DECELERATION, THAT CAN CAUSE LOSS OF CONTROL, THIS STARTED WHEN IT HAD ONLY 1500 MILES ON IT. DEALER WOULD DO NOTHING. IT HAS ALSO HAD ELECTRICAL SYSTEM PROBLEMS THE RECTIFIER SHORTS OUT. SUZUKI REPLACED THE RECTIFIER AND STATOR. THESE PROBLEMS ARE INHERENT IN 2005 AND 2006 SUZUKI C90 BOULEVARD. IN 2007 SUZUKI REVAMPED THE STATOR AND RECTIFIER. *TR Look up ODI 10314924 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 666.7%ODI 10419925 · 12,000 miTHE SAME REGULATOR/RECTIFIER MODEL USED IN OUR C90S BIKES, IS SUBJECT TO RECALL WHEN INSTALLED IN OTHER SUZUKI MODELS, BUT NOT ON OUR C90S. WE ALL KNOW, THE C90 REGULATOR IS FAILURE PRONE, NOTABLY DUE TO ITS EXPOSURE TO EXTREME HEAT IN THE REAR GENERATOR COVER, BUT ALSO DUE TO ITS DESIGN. AS A RESULT IT CAN FAIL RESULTING IN SUBSEQUENT FAILURE OF THE STATOR, AND STALLING OF THE BIKE ON THE HIGHWAY. THESE ARE THE EXACT SAME REASONS THE SAME REGULATOR HAS BEEN RECALLED IN VIRTUALLY EVERY OTHER MODEL IT IS USED IN. IN OTHER BIKE MODELS, THE REG… Look up ODI 10419925 at NHTSA ↗ | 360.0%ODI 10420122 · 12,300 miNHTSA CAMPAIGN ID NUMBER: 11V108000 COMPONENT: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR THE REGULATOR / RECTIFIER ASSEMBLIES WITH THE FOLLOWING SUZUKI PART NUMBERS ARE BEING RECALLED ON THE MOTORCYCLES MENTIONED: 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. I RECENTLY HAD THIS PROBLEM WITH MY 2008 C90T SUZUKI MOTORCYCLE. MY BIKE HAS THE SAME COMPONANTS THAT RECENTLY FAILED. HOW COME THE C90 IS NOT ON THE LIST OF MOTORCYCLES. I WOULD… Look up ODI 10420122 at NHTSA ↗ |
|---|
| Fuel System, Gasoline:Storage:Tank Assembly | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 1100.0%ODI 10278195 · 1,900 miTL*THE CONTACT OWNS A 2000 SUZUKI VL1500 MOTORCYCLE. ON JANUARY 12, 2009, THE VEHICLE CAUGHT FIRE WHILE WARMING UP. THE FRONT END OF THE VEHICLE NEAR THE FUEL TANK WAS THE PART THAT CAUGHT FIRE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 06V025000 PRIOR TO THE FAILURE. SHE ATTEMPTED TO GET ASSISTANCE FROM THE MANUFACTURER IN REGARDS TO THE REPAIRS, BUT THEY HAD NOT RECEIVED ANY CORRESPONDENCE. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 1,900. Look up ODI 10278195 at NHTSA ↗ | 266.7%ODI 10155524DT*: THE CONTACT STATED THE FUEL TANK IS LEAKING. THERE IS A NHTSA RECALL, #06V025000 ON THE MOTORCYCLE REGARDING THE FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY. THE PARTS NEEDED TO REPAIR THE MOTORCYCLE ARE NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE CONTACT WAS INSTRUCTED NOT TO RIDE THE MOTORCYCLE UNTIL THE PARTS WERE AVAILABLE. THE MANUFACTURER CONFIRMED THE PARTS ARE NOT AVAILABLE. Look up ODI 10155524 at NHTSA ↗ | 1100.0%ODI 10159349 · 16,000 miDT*: THE CONTACT STATED WHILE DRIVING AN ODOR EMITTED FROM THE VEHICLE AND THE VEHICLE CONSUMED EXCESSIVE FUEL. THIS OCCURRED AT VARIOUS SPEEDS. WHEN THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR THE RECALL REMEDY REPAIR #06V025000 REGARDING THE FUEL TANK, THE DEALER DETERMINED THE FUEL TANK WAS CRACKED. THE PARTS NEEDED TO REPAIR THE VEHICLE WERE NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE MANUFACTURER CONFIRMED THE PARTS ARE NOT AVAILABLE. UPDATED 07/03/06. *JB Look up ODI 10159349 at NHTSA ↗ | 00.0%No examples available for this selection. | 116.7%ODI 10155641 · 13,000 miSUZUKI HAS A RECALL ON THE INTRUDER 1500 GAS TANKS. THEY HAVE MY BIKE NOW BECAUSE THE TANK LEAKS. THEY WON'T GIVE IT BACK AND THERE ISN'T A TIMELINE WHEN THEY WILL HAVE REPLACEMENT TANKS. *NM Look up ODI 10155641 at NHTSA ↗ | 323.1%ODI 10135234 · 7,456 mi2005 SUZUKI BOULEVARD C90 MOTORCYCLE: GAS TANK LEAK, SOME SPOT AS PREVIOUS YEARS. TOP RIGHT CORNER. BAD WELD VERIFIED BY DEALERSHIP SERVICE MANAGER. DEALER ORDERED NEW GAS TANK. DOWN TIME FOR CUSTOMER (ME) 1 WEEK.*JB Look up ODI 10135234 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Steering | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.7%ODI 10314924 · 1,500 miTHE MOTORCYCLE (SUZUKI C 90 BOULEVARD) WOBBLES UNCONTROLLABLY ON DECELERATION, THAT CAN CAUSE LOSS OF CONTROL, THIS STARTED WHEN IT HAD ONLY 1500 MILES ON IT. DEALER WOULD DO NOTHING. IT HAS ALSO HAD ELECTRICAL SYSTEM PROBLEMS THE RECTIFIER SHORTS OUT. SUZUKI REPLACED THE RECTIFIER AND STATOR. THESE PROBLEMS ARE INHERENT IN 2005 AND 2006 SUZUKI C90 BOULEVARD. IN 2007 SUZUKI REVAMPED THE STATOR AND RECTIFIER. *TR Look up ODI 10314924 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 222.2%ODI 10420836 · 3,000 miRE: INFERIOR STEERING HEAD BEARING ISSUE. FOR: MOTORCYCLE SUZUKI BOULEVARD C90T (VL1500T) WTF, AT 35 MPH HANDLE BAR CONSISTENTLY SHAKES VIOLENTLY FROM SIDE TO SIDE. FAILURE OF OEM BALL BEARINGS ARE JUNK AND CAUSES THIS DANGEROUS CONDITION. NEEDS NEW TIMKEN TAPERED ROLLER BEARINGS TO CURE THIS DANGEROUS CONDITION. THIS IS MAJOR COST TO ME TO REPAIR AND REMOVE FRONT END FOR INFERIOR CHEAP BEARINGS. THE OEM BEARINGS SUCK, AND TO REPLACE THE BEARINGS WITH SAME JUNK IS RIDICULOUS. WARRANTY IS VOIDED IF ANY OTHER BEARING IS USED, THIS IS BS. *TR… Look up ODI 10420836 at NHTSA ↗ | 360.0%ODI 10420122 · 12,300 miNHTSA CAMPAIGN ID NUMBER: 11V108000 COMPONENT: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR THE REGULATOR / RECTIFIER ASSEMBLIES WITH THE FOLLOWING SUZUKI PART NUMBERS ARE BEING RECALLED ON THE MOTORCYCLES MENTIONED: 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. I RECENTLY HAD THIS PROBLEM WITH MY 2008 C90T SUZUKI MOTORCYCLE. MY BIKE HAS THE SAME COMPONANTS THAT RECENTLY FAILED. HOW COME THE C90 IS NOT ON THE LIST OF MOTORCYCLES. I WOULD… Look up ODI 10420122 at NHTSA ↗ |
|---|
| Engine | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 116.7%ODI 10537435 · 3,500 miTL* THE CONTACT OWNS A 2004 SUZUKI INTRUDER VL 1500 K4 MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 55-60 MPH, THE VEHICLE EXHIBITED A POPPING NOISE AS IT STALLED. THE MOTORCYCLE WAS TOWED TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MOTORCYCLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 3,500 AND THE APPROXIMATE CURRENT MILEAGE WAS 4,000. Look up ODI 10537435 at NHTSA ↗ | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 111.1%ODI 11515235Motorcycle has brand new battery. Sudden loss of power, engine sputtering, gauges moving sporadically like they were loosing power. Engine backfiring. vehicle would die. be able to be restarted. Known issue with this vehicle. part reported is to be a faulty stator. manufacturer recalled earlier and later year vehicles that use this same part, but did not recall this specific model for recall warranty service. Known faulty part not being covered by manufacturer warranty. Due to this issue the bike lost all power/regained full power intermittentl… Look up ODI 11515235 at NHTSA ↗ | 120.0%ODI 10475248 · 4,000 miENGINE FAILURE IN TRAFFIC DUE TO FAULTY STATOR/REGULATOR/RECTIFIER - BASED ON INTERNET FORUMS, THIS APPEARS TO BE SYSTEMIC FOR THIS MODEL OF MOTORCYCLE. POSES DANGER AS ENGINE FAILURE IN TRAFFIC COULD LEAD TO AN ACCIDENT. PLEASE NOTE THAT THERE ARE RECALLS FOR SEVERAL SUZUKI MOTORCYCLES THAT USE THE SAME STATOR/REGULATOR/RECTIFIER. THIS MODEL SHOULD ALSO BE RECALLED TO PREVENT ANY FUTURE ACCIDENTS. *TR Look up ODI 10475248 at NHTSA ↗ |
|---|
| Suspension | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 1100.0%ODI 1012154712003 SUZUKI 1500 : CONSUMER IS EXPERIENCING A BAD SHAKING VIBRATION IN THE HANDLE BARS WHEN DECELERATING FROM 40 TO 25 MPH.***NO ANSWER REQUIRED***. *MR SLOWING DOWN AND USING THE TURN SIGNAL COULD RESULT IN AN ACCIDENT. THE CONSUMER COULD NOT TAKE HIS HANDS OFF OF THE HANDLE BARS TO SIGNAL A TURN OR STOP. THE CONSUMER WAS INFORMED BY THE MANUFACTURER AND DEALER THAT THE PROBLEM COULD NOT BE FIXED. *SC *JB Look up ODI 10121547 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 111.1%ODI 10443722FRONT WHEEL WOBBLES VIOLENTLY ABOVE 25 MPH. ONLY HAVE ABOUT 8,000 MILES. BIKE IS LESS THAN ONE YEAR OLD. RESEARCH INDICATES THAT IT IS THE FAULTY STEERING HEAD BEARINGS. *TR Look up ODI 10443722 at NHTSA ↗ | 120.0%ODI 10420122 · 12,300 miNHTSA CAMPAIGN ID NUMBER: 11V108000 COMPONENT: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR THE REGULATOR / RECTIFIER ASSEMBLIES WITH THE FOLLOWING SUZUKI PART NUMBERS ARE BEING RECALLED ON THE MOTORCYCLES MENTIONED: 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. I RECENTLY HAD THIS PROBLEM WITH MY 2008 C90T SUZUKI MOTORCYCLE. MY BIKE HAS THE SAME COMPONANTS THAT RECENTLY FAILED. HOW COME THE C90 IS NOT ON THE LIST OF MOTORCYCLES. I WOULD… Look up ODI 10420122 at NHTSA ↗ |
|---|
| Electrical System:Alternator/Generator/Regulator | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 111.1%ODI 10420818 · 38,560 miFAILURE OF STATOR AND RECTIFIER ON 2007 SUZUKI C90 MOTORCYCLE. R/R PART RECTIFIER ASSY 32800-41F11, ALSO CAUSES FAILURE IN STATOR. SAME PROBLEMS LISTED IN RECALL FOR OTHER SUZUKI BIKES (NHTSA CAMPAIGN ID NUMBER: 11V108000), BUT C90 WAS NOT COVERED BUT USES THE SAME COMPONENTS AND HAS THE SAME PROBLEM. BOTH RR AND STATOR REPLACED BEFORE 40KM ON BIKE. *TR Look up ODI 10420818 at NHTSA ↗ | 120.0%ODI 10420122 · 12,300 miNHTSA CAMPAIGN ID NUMBER: 11V108000 COMPONENT: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR THE REGULATOR / RECTIFIER ASSEMBLIES WITH THE FOLLOWING SUZUKI PART NUMBERS ARE BEING RECALLED ON THE MOTORCYCLES MENTIONED: 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. I RECENTLY HAD THIS PROBLEM WITH MY 2008 C90T SUZUKI MOTORCYCLE. MY BIKE HAS THE SAME COMPONANTS THAT RECENTLY FAILED. HOW COME THE C90 IS NOT ON THE LIST OF MOTORCYCLES. I WOULD… Look up ODI 10420122 at NHTSA ↗ |
|---|
| Service Brakes, Hydraulic | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 17.7%ODI 10138545 · 4,800 miFRONT BRAKE FAILS TO STOP VEHICLE. FRONT BRAKE LEVER TRAVEL IS EXCESSIVE AND OFTEN TOUCHES THE THROTTLE GRIP WITHOUT PROVIDING ANY SIGNIFICANT DECELERATION. DEALER RECENTLY BLED BRAKES AT THE 4000 MILE SERVICE. ALMOST HAD AN ACCIDENT ON OCT 1, 2005 WHEN THE MOTORCYCLE WAS UNABLE TO STOP IN AN EMERGENCY SITUATION. HAD TO CHANGE LANES TO AVIOD A REAR END COLLISION. THIS PROBLEM HAS OCCURRED WITH OTHER VS1400 SUZUKI INTRUDERS. *NM Look up ODI 10138545 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 111.1%ODI 10421049 · 65,000 miREAR ROTOR ON SUZUKI C90 07 MODEL, WAS REPLACED BY THE DEALER TWICE IN THE FIRST YEAR.WITH UNDER 16000 MILES AT THE TIME IT WORKED IT'S WAY LOOSE AGAIN AND THE DEALER REFUSED TO PASS IT FOR INSPECTION AND SUZUKI REFUSED TO PAY FOR THE REPLACEMENT. SINCE THAT TIME HAVE PUT A LOT MORE MILES ON THE BIKE AND CANNOT TAKE IT TO THE DEALER FOR AN INSPECTION. NOW AFTER ABOUT 65,000 MILES ON THE BIKE, THE RIVETS FINALLY GAVE OUT ON A TRIP IN THE MOUNTAINS SOUTH OF PAGOSA SPRINGS, CO. THEN BEFORE I COULD GET A REPLACEMENT HAD A MINOR WRECK MAKING A LEFT… Look up ODI 10421049 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Structure:Motorcycle:Kickstand/Center Stand | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 215.4%ODI 10128605 · 100 miDT: SUZUKI 2005 BLVD. C90T -TOURING MOTORCYCLE. THE PROBLEM IS WITH THE KICK STAND. WHEN THE CONSUMER PUT THE KICK STAND DOWN IT WILL NOT LOCK AND THE BIKE WILL FALL OVER. *JB Look up ODI 10128605 at NHTSA ↗ | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|