Thor Motor Coach SEQUENCE recalls by model year
Explore the records behind recurring owner reports.
Key facts
6 owner complaints analyzed
6 distinct recall campaigns
13,250 mi median reported failure mileage
Scope: 2020 to 2024 model years. Data updated: . 2 complaints include usable failure mileage. View data status.
Recalls by model year
All campaigns in the snapshot affecting each model year, including recalls announced years later.
Recall campaigns
Shared campaigns appear once in each affected model year.
| Category | Count |
|---|---|
| 2020 | 1 |
| 2021 | 2 |
| 2022 | 3 |
| 2023 | 3 |
| 2024 | 2 |
2020: 1; 2021: 2; 2022: 3; 2023: 3; 2024: 2
Year-by-year records
Recall history
6 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
20V424000 · Seat Belts: Rear/Other:Buckle Assembly | Seat Belts
Reported: 2020-07-22 (July 22, 2020) · Model years: 2020, 2021
Thor Motor Coach (TMC) is recalling certain 2020-2021 Sequence and Tellaro motorhomes. The dinette booth seat belts may be too short preventing them from being usable by some occupants. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."
Consequence: Inability to use the seat belt may increase the risk of injury in the event of a crash.
Remedy: TMC will notify owners, and dealers will replace the 18-inch seat belt tether with a 24-inch tether on both sides of the dinette booth, free of charge. This recall began September 16, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000198.
NHTSA campaign record ↗23V285000 · Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings
Reported: 2023-04-21 (April 21, 2023) · Model years: 2021, 2023
Thor Motor Coach (TMC) is recalling certain 2021-2023 Sequence, 2021-2024 Rize, Scope, Tellaro, 2023-2024 Dazzle, and Twist motorhomes, equipped with certain Cummins Onan QG 2800i generator sets. The fuel hose between the inline fuel filter and the injection pump module (IPM) may have inadequate clamp force, possibly resulting in a gasoline leak.
Consequence: A gas leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will inspect and replace the fuel hose and clamps, as necessary, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000294.
NHTSA campaign record ↗21V396000 · Equipment:Recreational Vehicle/Trailer | Electrical System:Wiring
Reported: 2021-05-26 (May 26, 2021) · Model years: 2022
Thor Motor Coach (TMC) is recalling certain 2022 Rize, Scope, Sequence, and Tellaro vehicles. The Flex-190 Solar Panel junction box may short.
Consequence: An electrical short can cause the junction box to overheat, increasing the risk of a fire.
Remedy: Dealers will install a new solar panel and junction box, free of charge. Owner notification letters were mailed July 22, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000226.
NHTSA campaign record ↗22V300000 · Equipment:Recreational Vehicle/Trailer:Lpg Systems:Lines And Fittings
Reported: 2022-05-05 (May 5, 2022) · Model years: 2022
Thor Motor Coach (TMC) is recalling certain 2022 Scope, Tellaro, Sanctuary, Delano, Sequence, Tranquility, Rize, Synergy, Quantum, Magnitude, Geneva, Compass, Chateau, Four Winds, and 2022-2023 Tiburon, and Gemini vehicles. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.
Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Dealers will replace the quick disconnect fittings, free of charge. Owner notification letters were mailed June 27, 2022. Owners may contact TMC customer service at 1-877-855-2867.
NHTSA campaign record ↗25V791000 · Equipment:Electrical:Accessory Generator:Solar Panel | Structure:Critical Fasteners
Reported: 2025-11-17 (November 17, 2025) · Model years: 2022, 2023, 2024
Thor Motor Coach (TMC) is recalling certain 2023-2024 Twist, Dazzle, 2023 Tranquility, Sanctuary, 2022-2024 Tellaro, Sequence, and 2024 Freedom Elite Van recreational vehicles. The solar panel mounting brackets may become loose or break allowing the solar panel to detach.
Consequence: A detached solar can become a road hazard for other vehicles and increasing the risk of a crash.
Remedy: Dealers will inspect and install missing washers, as necessary, free of charge. Owner notification letters were mailed January 12, 2026. Another notice will be sent once the remedy becomes available. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000336.
NHTSA campaign record ↗25V792000 · Structure:Critical Fasteners | Equipment:Electrical:Accessory Generator:Solar Panel
Reported: 2025-11-17 (November 17, 2025) · Model years: 2023, 2024
Thor Motor Coach (TMC) is recalling certain 2024 Twist, 2023-2024 Dazzle, Scope, Rize, Sequence, and 2022-2024 Tellaro recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.
Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will remove and replace the sealant, free of charge. Owner notification letters were mailed February 23, 2026. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall RC000337.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
6 unique complaints in this selection. Analysis snapshot: 2026-09-30.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 2020 | 2021 | 2022 | 2023 | 2024 |
|---|---|---|---|---|---|
| Unknown Or Other | 1100.0%ODI 11712651I am the owner of a Thor Sequence 20K RV built on a 2022 Ram ProMaster 3500 chassis, purchased new in Florida. My vehicle Vin [XXX] is subject to safety recall # 25V-720 involving a potential engine fire- compartment fire risk. There is no repair or remedy currently available and no timeline has been provided by the manufacturer. Because of the fire risk, the vehicle is unsafe to operate. In addition the open safety recall has rendered the vehicle unsellable and untradeable, causing substantial loss of value and use through no fault of my ow… | 150.0%ODI 11363961 · 16,000 miWHEN DRIVING THE VEHICLE AT HIGHWAY SPEED (I-90 ACROSS MONTANA AND DAKOTAS), THROUGH WINDY WEATHER, THE ROOF MOUNTED WINDOW WOULD POP OPEN AND BEGIN FLAPPING IN THE WIND. THE LATCHING MECHANISM GETS PULLED APART DURING THE WIND GUSTS ALLOWING THE WINDOW TO OPEN BY ITSELF. THIS IS DUE TO THE BAR HANDLE ON THE LATCH FLEXING ENOUGH TO POP OUT OF ITS TRACK ALLOWING THE LATCH MECHANISM TO RELEASE. | 133.3%ODI 11534784Cabinets are falling off ceiling. Screws falling out. Could ask on passenger side bed. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Electrical System:Alternator/Generator/Regulator | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 11478573 · 10,500 miThe contact owns a 2022 Thor Motor Coach Sequence 20K RV. The contact stated that the skid plate to protect the alternator had the incorrect OEM bolt size and was also missing bolts to secure the alternator. The dealer was made aware of the failure; however, the contact realigned the skid plate and replaced the bolts with the correct size by himself. The RV was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 10,500. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Engine | 1100.0%ODI 11712651I am the owner of a Thor Sequence 20K RV built on a 2022 Ram ProMaster 3500 chassis, purchased new in Florida. My vehicle Vin [XXX] is subject to safety recall # 25V-720 involving a potential engine fire- compartment fire risk. There is no repair or remedy currently available and no timeline has been provided by the manufacturer. Because of the fire risk, the vehicle is unsafe to operate. In addition the open safety recall has rendered the vehicle unsellable and untradeable, causing substantial loss of value and use through no fault of my ow… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Equipment:Recreational Vehicle/Trailer | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 11623862Thor Sequences RV: The roof top solar that was installed by Thor Motorcoach flew off of the RV roof while I was driving on [XXX] in downtown Columbus, Ohio. I thought something fell out of a cabinet when I heard a thud. I exited [XXX] on [XXX], and a Central Ohio Transit Authority van driver told something flew off the roof of the RV. I parked and inspected the vehicle and discovered the solar panel was missing. I drove to Mark Wahlberg Air Stream where I purchased the camper van and reported the issue. The staff in maintenance showed me two s… | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Seats | 00.0%No examples available for this selection. | 150.0%ODI 11532368Since purchase in April 2022, driver seat has side to side and up/down movement which is not part of the design, and appears to be unstable and potential safety hazard for driving. This movement does not occur in the similar swivel style passenger seat. Dealership stated seat issues would be repaired under warranty from Thor. Multiple repair attempts were made by authorized service provider (dealership) addressing other seat issues (not adjusting or rotating properly as designed), but excessive play in the seat still exists. Continued requests … | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
| Structure | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 11534784Cabinets are falling off ceiling. Screws falling out. Could ask on passenger side bed. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| Unknown Or Other | Too few reports for a range | 16,000 mi | 1 (sparse) | ODI 11363961 · 16,000 miWHEN DRIVING THE VEHICLE AT HIGHWAY SPEED (I-90 ACROSS MONTANA AND DAKOTAS), THROUGH WINDY WEATHER, THE ROOF MOUNTED WINDOW WOULD POP OPEN AND BEGIN FLAPPING IN THE WIND. THE LATCHING MECHANISM GETS PULLED APART DURING THE WIND GUSTS ALLOWING THE WINDOW TO OPEN BY ITSELF. THIS IS DUE TO THE BAR HANDLE ON THE LATCH FLEXING ENOUGH TO POP OUT OF ITS TRACK ALLOWING THE LATCH MECHANISM TO RELEASE. |
| Electrical System:Alternator/Generator/Regulator | Too few reports for a range | 10,500 mi | 1 (sparse) | ODI 11478573 · 10,500 miThe contact owns a 2022 Thor Motor Coach Sequence 20K RV. The contact stated that the skid plate to protect the alternator had the incorrect OEM bolt size and was also missing bolts to secure the alternator. The dealer was made aware of the failure; however, the contact realigned the skid plate and replaced the bolts with the correct size by himself. The RV was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 10,500. |
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-10 | 0 | None | No examples available for this selection. |
| 2024-11 | 1 | None | ODI 11623862Thor Sequences RV: The roof top solar that was installed by Thor Motorcoach flew off of the RV roof while I was driving on [XXX] in downtown Columbus, Ohio. I thought something fell out of a cabinet when I heard a thud. I exited [XXX] on [XXX], and a Central Ohio Transit Authority van driver told something flew off the roof of the RV. I parked and inspected the vehicle and discovered the solar panel was missing. I drove to Mark Wahlberg Air Stream where I purchased the camper van and reported the issue. The staff in maintenance showed me two s… |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | 25V791000, 25V792000 | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 1 | None | ODI 11712651I am the owner of a Thor Sequence 20K RV built on a 2022 Ram ProMaster 3500 chassis, purchased new in Florida. My vehicle Vin [XXX] is subject to safety recall # 25V-720 involving a potential engine fire- compartment fire risk. There is no repair or remedy currently available and no timeline has been provided by the manufacturer. Because of the fire risk, the vehicle is unsafe to operate. In addition the open safety recall has rendered the vehicle unsellable and untradeable, causing substantial loss of value and use through no fault of my ow… |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2022: 3 complaints · 2023: 0 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2022 | 1 | 2 | 3 |
| 2023 | 0 | 0 | 0 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2022 | 3 | 0 | 0 |
| 2023 | 0 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component | Unknown Or Other | Electrical System:Alternator/Generator/Regulator | Engine | Equipment:Recreational Vehicle/Trailer | Seats | Structure |
|---|---|---|---|---|---|---|
| Unknown Or Other | — | 0 | 1ODI 11712651I am the owner of a Thor Sequence 20K RV built on a 2022 Ram ProMaster 3500 chassis, purchased new in Florida. My vehicle Vin [XXX] is subject to safety recall # 25V-720 involving a potential engine fire- compartment fire risk. There is no repair or remedy currently available and no timeline has been provided by the manufacturer. Because of the fire risk, the vehicle is unsafe to operate. In addition the open safety recall has rendered the vehicle unsellable and untradeable, causing substantial loss of value and use through no fault of my ow… | 0 | 0 | 1ODI 11534784Cabinets are falling off ceiling. Screws falling out. Could ask on passenger side bed. |
| Electrical System:Alternator/Generator/Regulator | 0 | — | 0 | 0 | 0 | 0 |
| Engine | 1ODI 11712651I am the owner of a Thor Sequence 20K RV built on a 2022 Ram ProMaster 3500 chassis, purchased new in Florida. My vehicle Vin [XXX] is subject to safety recall # 25V-720 involving a potential engine fire- compartment fire risk. There is no repair or remedy currently available and no timeline has been provided by the manufacturer. Because of the fire risk, the vehicle is unsafe to operate. In addition the open safety recall has rendered the vehicle unsellable and untradeable, causing substantial loss of value and use through no fault of my ow… | 0 | — | 0 | 0 | 0 |
| Equipment:Recreational Vehicle/Trailer | 0 | 0 | 0 | — | 0 | 0 |
| Seats | 0 | 0 | 0 | 0 | — | 0 |
| Structure | 1ODI 11534784Cabinets are falling off ceiling. Screws falling out. Could ask on passenger side bed. | 0 | 0 | 0 | 0 | — |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.