| Power Train | 545.5%ODI 11588225I was driving my car at about 25 mph and I was not able to switch gears (manual transmission). I sent the car to the dealer and they told me that the clutch was burnt and I also needed to change the flywheel for a total cost of over USD 6,300. The repair was not covered by the warranty and the car was only under 5,500 miles and under a year of bought. I have read similar cases in the web and I am pretty sure that this is a manufacturing problem. The car is a GR Corolla, which is advertised as a sports car, but the dealer is saying that the car… Look up ODI 11588225 at NHTSA ↗ | 360.0%ODI 11618942on [XXX] this vehicle lost power on the very busy interstate due to the clutch failing. this caused loss of power, and i had to exit the vehicle to push it to the side of the road while traffic was passing at 55+ mph. I could have very easily been hit either inside or outside of the vehicle and could do nothing to prevent this. other people could be injured due to the vehicle being stopped in the middle of the highway. this is due to a premature failing of the clutch liner. Toyota will not replace under warranty stating that it is a wear an… Look up ODI 11618942 at NHTSA ↗ | 333.3%ODI 11676673While driving home from dinner I pulled off from a stop light as normal and shifted from 1st into 2nd then 3rd with zero issues. As I went to shift into 4th it was as if the gear was locked out, thinking there was just something I was missing I tried 5th and was met with the same issue, tried 4th again and still nothing and I couldn’t get into 3rd. At this point I was rapidly losing speed and I was on a busy road. I pulled into a left turn lane brought the vehicle to a stop until it was safe to proceed with the turn tried to go into first gear … Look up ODI 11676673 at NHTSA ↗ |
|---|
| Engine | 19.1%ODI 11702094Drove car at reasonable low speeds (30-40mph) parked vehicle and noticed smell of something burning and light smoke. Opened hood and car was on fire. No mods, completely stock, low mileage. All services up to date. No reasonable explanation for sudden fire Look up ODI 11702094 at NHTSA ↗ | 240.0%ODI 11628055I started the car to warm it when ambient temperature was approximately 24F. The car revved up then nearly stalled about 3 times then threw a check engine light for a random cylinder misfire and disabled the forward collision warning system. The car has always had issues with nearly dying during cold starts below about 40F but this is the first time it has thrown a code. Look up ODI 11628055 at NHTSA ↗ | 222.2%ODI 11712533Hello, Today (01/21/2026), on my 2025 Toyota GR Corolla vehicle (odometer 5243 miles), after 3200 miles of driving with the updated engine control unit (ECU) as of 10/14/2025 according to the T-SB-0071-25, a P2C90 error appeared again with an Check Engine Light. This happened during acceleration while entering the highway, when the engine speed reached between 3000 and 4000 RPM. This situation disables many of the vehicle's active safety systems (all-wheel drive, vehicle stability control, traction control, adaptive cruise control, lane kee… Look up ODI 11712533 at NHTSA ↗ |
|---|
| Electrical System | 19.1%ODI 11598691My compilation of known issues are: 1. Bumper gap: front bumper gets dislocated from the main body of the car that can cause road debris/hazard 2. Flimsy / slipping clutch: causing grindy shifter (1-2-3) or lose control of the vehicle’s acceleration 3. Oil overheating and rear differential 2WD: might contribute to car’s sudden combustion Look up ODI 11598691 at NHTSA ↗ | 120.0%ODI 11628055I started the car to warm it when ambient temperature was approximately 24F. The car revved up then nearly stalled about 3 times then threw a check engine light for a random cylinder misfire and disabled the forward collision warning system. The car has always had issues with nearly dying during cold starts below about 40F but this is the first time it has thrown a code. Look up ODI 11628055 at NHTSA ↗ | 111.1%ODI 11718019Driving my car normally when, at around 3,800 miles, my car threw a CEL and went into limp mode, while in traffic. I had to pull over safely, immediately shut off vehicle and have it towed to the dealership for diagnostic & repair. The code was the infamous P2C90 Crankcase ventilation leak check engine light code. This has happened over the course of 14k miles, 4+ more times. Each time, the CEL turns on and disables: cruise control, lane assist, blind spot assist, AWD (limp mode) and directly affects driving. I have taken the vehicle back to th… Look up ODI 11718019 at NHTSA ↗ |
|---|
| Forward Collision Avoidance: Adaptive Cruise Control | 19.1%ODI 11634755I am writing to file a complaint regarding my 2023 Toyota GR Corolla Circuit Edition. The issue pertains to the ECU programming, which was not properly calibrated for the wheels that came with this model. Instead, the weight and dimensions from the Morizo Edition were utilized. This discrepancy causes the vehicle to inaccurately register speed, which is a significant safety concern. The malfunctioning component is the ECU, and it is available for inspection upon request. The inaccurate speedometer readings put my safety and the safety of other… Look up ODI 11634755 at NHTSA ↗ | 00.0%No examples available for this selection. | 222.2%ODI 11712533Hello, Today (01/21/2026), on my 2025 Toyota GR Corolla vehicle (odometer 5243 miles), after 3200 miles of driving with the updated engine control unit (ECU) as of 10/14/2025 according to the T-SB-0071-25, a P2C90 error appeared again with an Check Engine Light. This happened during acceleration while entering the highway, when the engine speed reached between 3000 and 4000 RPM. This situation disables many of the vehicle's active safety systems (all-wheel drive, vehicle stability control, traction control, adaptive cruise control, lane kee… Look up ODI 11712533 at NHTSA ↗ |
|---|
| Forward Collision Avoidance: Automatic Emergency Braking | 00.0%No examples available for this selection. | 120.0%ODI 11628055I started the car to warm it when ambient temperature was approximately 24F. The car revved up then nearly stalled about 3 times then threw a check engine light for a random cylinder misfire and disabled the forward collision warning system. The car has always had issues with nearly dying during cold starts below about 40F but this is the first time it has thrown a code. Look up ODI 11628055 at NHTSA ↗ | 222.2%ODI 11690162The car randomly reports an Engine Malfunction which results in many warning lights indicating that certain systems are non-functional. These include (but are not limited to): - Forward collision warning - Automatic emergency braking - Cruise control - Basically, any driver assistance feature that requires external sensors is turned off Also, the rear wheel drive is turned off so the car only drives using the front wheels. On each successive drive, with the engine turned off in between, some of these systems start functioning again. After 3… Look up ODI 11690162 at NHTSA ↗ |
|---|
| Forward Collision Avoidance: Warnings | 19.1%ODI 11557146The 2024 whom are being sold at the same time as the 2023 GR Corollas have had improvements to both the front brake cooling with aluminum and have had the ducting reopened after the safety correction. To ensure the safety of the drivers and passengers, quality of the vehicle and its longevity. Recommend recalling all 2023 circuit editions to also adjust the from driver and passenger side brakes and their coolant ducting to be on par with the 2024 versions. The 2023 versions over have paid higher markups and have heavier rims due to inequality c… Look up ODI 11557146 at NHTSA ↗ | 00.0%No examples available for this selection. | 222.2%ODI 11690162The car randomly reports an Engine Malfunction which results in many warning lights indicating that certain systems are non-functional. These include (but are not limited to): - Forward collision warning - Automatic emergency braking - Cruise control - Basically, any driver assistance feature that requires external sensors is turned off Also, the rear wheel drive is turned off so the car only drives using the front wheels. On each successive drive, with the engine turned off in between, some of these systems start functioning again. After 3… Look up ODI 11690162 at NHTSA ↗ |
|---|
| Vehicle Speed Control | 218.2%ODI 11557146The 2024 whom are being sold at the same time as the 2023 GR Corollas have had improvements to both the front brake cooling with aluminum and have had the ducting reopened after the safety correction. To ensure the safety of the drivers and passengers, quality of the vehicle and its longevity. Recommend recalling all 2023 circuit editions to also adjust the from driver and passenger side brakes and their coolant ducting to be on par with the 2024 versions. The 2023 versions over have paid higher markups and have heavier rims due to inequality c… Look up ODI 11557146 at NHTSA ↗ | 120.0%ODI 11674789Clutch slipping causing the inability to accelerate when needed Look up ODI 11674789 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Fuel/Propulsion System | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 222.2%ODI 11690162The car randomly reports an Engine Malfunction which results in many warning lights indicating that certain systems are non-functional. These include (but are not limited to): - Forward collision warning - Automatic emergency braking - Cruise control - Basically, any driver assistance feature that requires external sensors is turned off Also, the rear wheel drive is turned off so the car only drives using the front wheels. On each successive drive, with the engine turned off in between, some of these systems start functioning again. After 3… Look up ODI 11690162 at NHTSA ↗ |
|---|