| Electrical System | — | 2ODI 11443354The 2021 RAV4 Prime has a known defect with the heat pump causing an alarming sound to be heard within about a 1 minute of startup. The grinding noise causes distraction as it is extremely loud and occurs generally while backing out/maneuvering in tight areas. Toyota released a Service Bulletin in their European Market in October (numbered BE-00612T-TME - "Train Horn noise" from A/C compressor when the vehicle is started), but has not made available the same fixes in the US even months later. Look up ODI 11443354 at NHTSA ↗ ODI 11564618RECALL HAS NOT BEEN TAKEN CARE OF IN A TIMELY MANNER. CAR MIGHT LIGHT ON FIRE! VERY UNSAFE! Look up ODI 11564618 at NHTSA ↗ | 5ODI 11457199The RAV4 Prime's fuel system holds 14.5 gallons, however only between 10 - 11 gallons of that is usable per the digital "miles to zero" gauge on the instrument panel. When the gauge reaches "zero" and notifies the driver to fill up, the tank only fills 10 -11 gallons and keeps 3 - 4.5 gallons in reserve. This is a big issue because the "miles to zero" gauge reads the full tank when you fill it up (approximately 550 miles), but begins to swing drastically on miles left as you drive the car to accommodate for the 10 - 11 gallons that it actuall… Look up ODI 11457199 at NHTSA ↗ ODI 11551856When driving over small bumps while slowing down will cause the rear brakes to lock Look up ODI 11551856 at NHTSA ↗ ODI 11559489Toyota issued a recall in July 2023 stating the the DC-DC conversion system may have been damaged in manufacture, potentially causing a short, and possibly leading to a fire if charged at less than 41 degrees. Toyota indicated that a fix would be available in the 4th quarter of 2023. We are nearing the end of the 4th quarter and fix is still not available. Living in upstate New York, nighttime temperatures frequently are less than 41 degrees. As a result I am reluctant to charge overnight. This defeats the purpose of a plug-in hybrid, resu… Look up ODI 11559489 at NHTSA ↗ | 1ODI 11551856When driving over small bumps while slowing down will cause the rear brakes to lock Look up ODI 11551856 at NHTSA ↗ | 1ODI 11476650May 29 2022 I parked my new RAV4 PRIME EV on an incline and left the vehicle running to keep the a/c cold & radio playing. The car was securely parked atop an incline facing up the incline while still running. While the vehicle sat idle I walked my dog waiting to clean up after him. He was taking a long time so I decided to turn off the vehicle. I walked over to the running vehicle in park, opened the driver door and pressed the off button to turn the vehicle off. This caused the vehicle to roll backwards down the incline while in the park pos… Look up ODI 11476650 at NHTSA ↗ | 0 | 4ODI 11559489Toyota issued a recall in July 2023 stating the the DC-DC conversion system may have been damaged in manufacture, potentially causing a short, and possibly leading to a fire if charged at less than 41 degrees. Toyota indicated that a fix would be available in the 4th quarter of 2023. We are nearing the end of the 4th quarter and fix is still not available. Living in upstate New York, nighttime temperatures frequently are less than 41 degrees. As a result I am reluctant to charge overnight. This defeats the purpose of a plug-in hybrid, resu… Look up ODI 11559489 at NHTSA ↗ ODI 11584962The manufacturer has not corrected the recall in 10 months Look up ODI 11584962 at NHTSA ↗ ODI 11734723The vehicle generated an error message "Plug In Charging System Malfunction" warning on the dash. The remedy is a Toyota T-SB-0021-21 which requires a software upgrade to fix the air fan sensor reading to the charging unit. This is only considered part of the 60 month/60,000 mile power train warranty despite it being part of the battery charging system which has a 150,000 mile warranty. It is also presumably caused by a software error Toyota has made. They should fix this at no cost to the customer, instead I was charged $215 plus tax. Look up ODI 11734723 at NHTSA ↗ | 0 |
|---|
| Unknown Or Other | 2ODI 11443354The 2021 RAV4 Prime has a known defect with the heat pump causing an alarming sound to be heard within about a 1 minute of startup. The grinding noise causes distraction as it is extremely loud and occurs generally while backing out/maneuvering in tight areas. Toyota released a Service Bulletin in their European Market in October (numbered BE-00612T-TME - "Train Horn noise" from A/C compressor when the vehicle is started), but has not made available the same fixes in the US even months later. Look up ODI 11443354 at NHTSA ↗ ODI 11564618RECALL HAS NOT BEEN TAKEN CARE OF IN A TIMELY MANNER. CAR MIGHT LIGHT ON FIRE! VERY UNSAFE! Look up ODI 11564618 at NHTSA ↗ | — | 0 | 0 | 1ODI 11458186On March 19, 2022 I was attempting to make a left turn onto a five lane (including the center left turn lane) road. When the traffic cleared my car (a plug-in hybrid in EV mode) did not accelerate as it usually does, but slowly rolled into the first lane of traffic. I pushed the accelerator to the floor but it stopped in the traffic lane. I had to quickly select reverse and back out of the first lane of oncoming traffic. Luckily the car behind me had not moved up and I had room to avoid an accident. This seemed like it may have been a failur… Look up ODI 11458186 at NHTSA ↗ | 0 | 0 | 0 |
|---|
| Fuel/Propulsion System | 5ODI 11457199The RAV4 Prime's fuel system holds 14.5 gallons, however only between 10 - 11 gallons of that is usable per the digital "miles to zero" gauge on the instrument panel. When the gauge reaches "zero" and notifies the driver to fill up, the tank only fills 10 -11 gallons and keeps 3 - 4.5 gallons in reserve. This is a big issue because the "miles to zero" gauge reads the full tank when you fill it up (approximately 550 miles), but begins to swing drastically on miles left as you drive the car to accommodate for the 10 - 11 gallons that it actuall… Look up ODI 11457199 at NHTSA ↗ ODI 11551856When driving over small bumps while slowing down will cause the rear brakes to lock Look up ODI 11551856 at NHTSA ↗ ODI 11559489Toyota issued a recall in July 2023 stating the the DC-DC conversion system may have been damaged in manufacture, potentially causing a short, and possibly leading to a fire if charged at less than 41 degrees. Toyota indicated that a fix would be available in the 4th quarter of 2023. We are nearing the end of the 4th quarter and fix is still not available. Living in upstate New York, nighttime temperatures frequently are less than 41 degrees. As a result I am reluctant to charge overnight. This defeats the purpose of a plug-in hybrid, resu… Look up ODI 11559489 at NHTSA ↗ | 0 | — | 2ODI 11551856When driving over small bumps while slowing down will cause the rear brakes to lock Look up ODI 11551856 at NHTSA ↗ ODI 11563605I was pulling into a parking space at a slow speed and breaking when my car accelerated violently and caused me to go across a median and strike another parked vehicle. Police came and did a report. I took my car right away to dealer and they had me take it to their collision shop to be repaired. They said they would try to find the unintended acceleration problem after it was repaired. No warning lights or airbags. Look up ODI 11563605 at NHTSA ↗ | 0 | 0 | 3ODI 11519151Car won't accelerate for about 1 to 2 seconds from stopped. Didn't have the issue before the 23TA01 recall performed at the Dealership. Look up ODI 11519151 at NHTSA ↗ ODI 11559489Toyota issued a recall in July 2023 stating the the DC-DC conversion system may have been damaged in manufacture, potentially causing a short, and possibly leading to a fire if charged at less than 41 degrees. Toyota indicated that a fix would be available in the 4th quarter of 2023. We are nearing the end of the 4th quarter and fix is still not available. Living in upstate New York, nighttime temperatures frequently are less than 41 degrees. As a result I am reluctant to charge overnight. This defeats the purpose of a plug-in hybrid, resu… Look up ODI 11559489 at NHTSA ↗ ODI 11742590Observed arcing noises and strong electrical fire smell upon plugging in L2 EVSE charging cable. MIL lit, Hybrid Vehicle Charging System codes active; vehicle refused to charge afterwards. Self-diagnosed and repaired defective 6.6 kW onboard charger. See pics of clear arcing damage withing charging unit - possible fire risk. Look up ODI 11742590 at NHTSA ↗ | 1ODI 11563605I was pulling into a parking space at a slow speed and breaking when my car accelerated violently and caused me to go across a median and strike another parked vehicle. Police came and did a report. I took my car right away to dealer and they had me take it to their collision shop to be repaired. They said they would try to find the unintended acceleration problem after it was repaired. No warning lights or airbags. Look up ODI 11563605 at NHTSA ↗ |
|---|
| Service Brakes | 1ODI 11551856When driving over small bumps while slowing down will cause the rear brakes to lock Look up ODI 11551856 at NHTSA ↗ | 0 | 2ODI 11551856When driving over small bumps while slowing down will cause the rear brakes to lock Look up ODI 11551856 at NHTSA ↗ ODI 11563605I was pulling into a parking space at a slow speed and breaking when my car accelerated violently and caused me to go across a median and strike another parked vehicle. Police came and did a report. I took my car right away to dealer and they had me take it to their collision shop to be repaired. They said they would try to find the unintended acceleration problem after it was repaired. No warning lights or airbags. Look up ODI 11563605 at NHTSA ↗ | — | 4ODI 11590033My 2021 Toyota RAV4 Prime had traction control, braking issues and failure to warn in the event of a possible forward collision. On a few occasions the brakes seem to just slide and the car would keep moving. Last week I was in an accident and the emergency braking system, the forward collision warning system and all the air bags failed. The California Highway Patrol was surprised that even though the estimation collision speed was 60 mph the air bags did not deploy. I would have not had a chance to test out the air bags, emergency braking syst… Look up ODI 11590033 at NHTSA ↗ ODI 11621836MY [XXX] ’S) SUDDEN ACCELERATION INCIDENT [XXX] - TOYOTA RAV4 2021: I was gliding into a parking space with my foot on the brake and as I went to straighten out the wheel to come to a full stop the car lurched forward full speed and smashed into the car parked in the row that was facing me. Good thing there was no one in that car, it had been backed in so I hit the rear end of it. The damage is so extensive it is beyond comprehension. My airbags did not deploy, which they should have. I saw that the ‘malfunction brake’ orange light was ill… Look up ODI 11621836 at NHTSA ↗ ODI 11634802Upon entering a light controlled intersection at a relatively slow speed (probably less than 20 mph} on wet pavement, an oncoming car suddenly made a left turn directly in front of me. I applied the applied the breaks hard and slid into the passenger side of the turning vehicle. The ABS system did not function. The air bag did not deploy. At the moment of the collision my speed was reduced and I do not know the threshold for airbags to deploy, but this was a direct front end collision. I was able to brace myself and was not injured. I am n… Look up ODI 11634802 at NHTSA ↗ | 5ODI 11464100My RAV4 PRIME was in stop and go traffic. Brakes did not switch from regen braking to physical brakes. Slammed on the brakes several times, they did not slow the car enough. Eventually the brakes locked up as the RAV4 rear ended the car in front. Pushing that car into the one in front of it, and that one in front of that, and that one in front of that. Causing damage to three other cars. Two other people are claiming medical, the driver went to the ER. Air bags did not deploy. Taking to the repair shop. They were shocked that the air bags did… Look up ODI 11464100 at NHTSA ↗ ODI 11590033My 2021 Toyota RAV4 Prime had traction control, braking issues and failure to warn in the event of a possible forward collision. On a few occasions the brakes seem to just slide and the car would keep moving. Last week I was in an accident and the emergency braking system, the forward collision warning system and all the air bags failed. The California Highway Patrol was surprised that even though the estimation collision speed was 60 mph the air bags did not deploy. I would have not had a chance to test out the air bags, emergency braking syst… Look up ODI 11590033 at NHTSA ↗ ODI 11621836MY [XXX] ’S) SUDDEN ACCELERATION INCIDENT [XXX] - TOYOTA RAV4 2021: I was gliding into a parking space with my foot on the brake and as I went to straighten out the wheel to come to a full stop the car lurched forward full speed and smashed into the car parked in the row that was facing me. Good thing there was no one in that car, it had been backed in so I hit the rear end of it. The damage is so extensive it is beyond comprehension. My airbags did not deploy, which they should have. I saw that the ‘malfunction brake’ orange light was ill… Look up ODI 11621836 at NHTSA ↗ | 0 | 2ODI 11467556We have COMPLETELY lost brakes on MULTIPLE occasions for a few seconds per occasion. Brake loss has occurred upon slow, even braking and on flat, dry, even pavement with no pot poles or loose gravel around. When this happens, an orange light appears on the dash, we lose brakes for a few seconds, the car regains brakes, and jolts forward with no change in foot position on the brake pedal. We have taken the car to the dealer multiple times and every single time this incident has occurred the rear right wheel speed shows about a 10% variation in s… Look up ODI 11467556 at NHTSA ↗ ODI 11563605I was pulling into a parking space at a slow speed and breaking when my car accelerated violently and caused me to go across a median and strike another parked vehicle. Police came and did a report. I took my car right away to dealer and they had me take it to their collision shop to be repaired. They said they would try to find the unintended acceleration problem after it was repaired. No warning lights or airbags. Look up ODI 11563605 at NHTSA ↗ |
|---|
| Forward Collision Avoidance: Automatic Emergency Braking | 1ODI 11476650May 29 2022 I parked my new RAV4 PRIME EV on an incline and left the vehicle running to keep the a/c cold & radio playing. The car was securely parked atop an incline facing up the incline while still running. While the vehicle sat idle I walked my dog waiting to clean up after him. He was taking a long time so I decided to turn off the vehicle. I walked over to the running vehicle in park, opened the driver door and pressed the off button to turn the vehicle off. This caused the vehicle to roll backwards down the incline while in the park pos… Look up ODI 11476650 at NHTSA ↗ | 1ODI 11458186On March 19, 2022 I was attempting to make a left turn onto a five lane (including the center left turn lane) road. When the traffic cleared my car (a plug-in hybrid in EV mode) did not accelerate as it usually does, but slowly rolled into the first lane of traffic. I pushed the accelerator to the floor but it stopped in the traffic lane. I had to quickly select reverse and back out of the first lane of oncoming traffic. Luckily the car behind me had not moved up and I had room to avoid an accident. This seemed like it may have been a failur… Look up ODI 11458186 at NHTSA ↗ | 0 | 4ODI 11590033My 2021 Toyota RAV4 Prime had traction control, braking issues and failure to warn in the event of a possible forward collision. On a few occasions the brakes seem to just slide and the car would keep moving. Last week I was in an accident and the emergency braking system, the forward collision warning system and all the air bags failed. The California Highway Patrol was surprised that even though the estimation collision speed was 60 mph the air bags did not deploy. I would have not had a chance to test out the air bags, emergency braking syst… Look up ODI 11590033 at NHTSA ↗ ODI 11621836MY [XXX] ’S) SUDDEN ACCELERATION INCIDENT [XXX] - TOYOTA RAV4 2021: I was gliding into a parking space with my foot on the brake and as I went to straighten out the wheel to come to a full stop the car lurched forward full speed and smashed into the car parked in the row that was facing me. Good thing there was no one in that car, it had been backed in so I hit the rear end of it. The damage is so extensive it is beyond comprehension. My airbags did not deploy, which they should have. I saw that the ‘malfunction brake’ orange light was ill… Look up ODI 11621836 at NHTSA ↗ ODI 11634802Upon entering a light controlled intersection at a relatively slow speed (probably less than 20 mph} on wet pavement, an oncoming car suddenly made a left turn directly in front of me. I applied the applied the breaks hard and slid into the passenger side of the turning vehicle. The ABS system did not function. The air bag did not deploy. At the moment of the collision my speed was reduced and I do not know the threshold for airbags to deploy, but this was a direct front end collision. I was able to brace myself and was not injured. I am n… Look up ODI 11634802 at NHTSA ↗ | — | 4ODI 11590033My 2021 Toyota RAV4 Prime had traction control, braking issues and failure to warn in the event of a possible forward collision. On a few occasions the brakes seem to just slide and the car would keep moving. Last week I was in an accident and the emergency braking system, the forward collision warning system and all the air bags failed. The California Highway Patrol was surprised that even though the estimation collision speed was 60 mph the air bags did not deploy. I would have not had a chance to test out the air bags, emergency braking syst… Look up ODI 11590033 at NHTSA ↗ ODI 11621836MY [XXX] ’S) SUDDEN ACCELERATION INCIDENT [XXX] - TOYOTA RAV4 2021: I was gliding into a parking space with my foot on the brake and as I went to straighten out the wheel to come to a full stop the car lurched forward full speed and smashed into the car parked in the row that was facing me. Good thing there was no one in that car, it had been backed in so I hit the rear end of it. The damage is so extensive it is beyond comprehension. My airbags did not deploy, which they should have. I saw that the ‘malfunction brake’ orange light was ill… Look up ODI 11621836 at NHTSA ↗ ODI 11634802Upon entering a light controlled intersection at a relatively slow speed (probably less than 20 mph} on wet pavement, an oncoming car suddenly made a left turn directly in front of me. I applied the applied the breaks hard and slid into the passenger side of the turning vehicle. The ABS system did not function. The air bag did not deploy. At the moment of the collision my speed was reduced and I do not know the threshold for airbags to deploy, but this was a direct front end collision. I was able to brace myself and was not injured. I am n… Look up ODI 11634802 at NHTSA ↗ | 0 | 1ODI 11588930I was driving very slowly in my driveway. I turned to enter my garage. As I put my foot on the break, the car accelerated crashing into my house. There was sudden unexplained and unintended acceleration on my RAV4 prime. Look up ODI 11588930 at NHTSA ↗ |
|---|
| Air Bags | 0 | 0 | 0 | 5ODI 11464100My RAV4 PRIME was in stop and go traffic. Brakes did not switch from regen braking to physical brakes. Slammed on the brakes several times, they did not slow the car enough. Eventually the brakes locked up as the RAV4 rear ended the car in front. Pushing that car into the one in front of it, and that one in front of that, and that one in front of that. Causing damage to three other cars. Two other people are claiming medical, the driver went to the ER. Air bags did not deploy. Taking to the repair shop. They were shocked that the air bags did… Look up ODI 11464100 at NHTSA ↗ ODI 11590033My 2021 Toyota RAV4 Prime had traction control, braking issues and failure to warn in the event of a possible forward collision. On a few occasions the brakes seem to just slide and the car would keep moving. Last week I was in an accident and the emergency braking system, the forward collision warning system and all the air bags failed. The California Highway Patrol was surprised that even though the estimation collision speed was 60 mph the air bags did not deploy. I would have not had a chance to test out the air bags, emergency braking syst… Look up ODI 11590033 at NHTSA ↗ ODI 11621836MY [XXX] ’S) SUDDEN ACCELERATION INCIDENT [XXX] - TOYOTA RAV4 2021: I was gliding into a parking space with my foot on the brake and as I went to straighten out the wheel to come to a full stop the car lurched forward full speed and smashed into the car parked in the row that was facing me. Good thing there was no one in that car, it had been backed in so I hit the rear end of it. The damage is so extensive it is beyond comprehension. My airbags did not deploy, which they should have. I saw that the ‘malfunction brake’ orange light was ill… Look up ODI 11621836 at NHTSA ↗ | 4ODI 11590033My 2021 Toyota RAV4 Prime had traction control, braking issues and failure to warn in the event of a possible forward collision. On a few occasions the brakes seem to just slide and the car would keep moving. Last week I was in an accident and the emergency braking system, the forward collision warning system and all the air bags failed. The California Highway Patrol was surprised that even though the estimation collision speed was 60 mph the air bags did not deploy. I would have not had a chance to test out the air bags, emergency braking syst… Look up ODI 11590033 at NHTSA ↗ ODI 11621836MY [XXX] ’S) SUDDEN ACCELERATION INCIDENT [XXX] - TOYOTA RAV4 2021: I was gliding into a parking space with my foot on the brake and as I went to straighten out the wheel to come to a full stop the car lurched forward full speed and smashed into the car parked in the row that was facing me. Good thing there was no one in that car, it had been backed in so I hit the rear end of it. The damage is so extensive it is beyond comprehension. My airbags did not deploy, which they should have. I saw that the ‘malfunction brake’ orange light was ill… Look up ODI 11621836 at NHTSA ↗ ODI 11634802Upon entering a light controlled intersection at a relatively slow speed (probably less than 20 mph} on wet pavement, an oncoming car suddenly made a left turn directly in front of me. I applied the applied the breaks hard and slid into the passenger side of the turning vehicle. The ABS system did not function. The air bag did not deploy. At the moment of the collision my speed was reduced and I do not know the threshold for airbags to deploy, but this was a direct front end collision. I was able to brace myself and was not injured. I am n… Look up ODI 11634802 at NHTSA ↗ | — | 0 | 0 |
|---|
| Power Train | 4ODI 11559489Toyota issued a recall in July 2023 stating the the DC-DC conversion system may have been damaged in manufacture, potentially causing a short, and possibly leading to a fire if charged at less than 41 degrees. Toyota indicated that a fix would be available in the 4th quarter of 2023. We are nearing the end of the 4th quarter and fix is still not available. Living in upstate New York, nighttime temperatures frequently are less than 41 degrees. As a result I am reluctant to charge overnight. This defeats the purpose of a plug-in hybrid, resu… Look up ODI 11559489 at NHTSA ↗ ODI 11584962The manufacturer has not corrected the recall in 10 months Look up ODI 11584962 at NHTSA ↗ ODI 11734723The vehicle generated an error message "Plug In Charging System Malfunction" warning on the dash. The remedy is a Toyota T-SB-0021-21 which requires a software upgrade to fix the air fan sensor reading to the charging unit. This is only considered part of the 60 month/60,000 mile power train warranty despite it being part of the battery charging system which has a 150,000 mile warranty. It is also presumably caused by a software error Toyota has made. They should fix this at no cost to the customer, instead I was charged $215 plus tax. Look up ODI 11734723 at NHTSA ↗ | 0 | 3ODI 11519151Car won't accelerate for about 1 to 2 seconds from stopped. Didn't have the issue before the 23TA01 recall performed at the Dealership. Look up ODI 11519151 at NHTSA ↗ ODI 11559489Toyota issued a recall in July 2023 stating the the DC-DC conversion system may have been damaged in manufacture, potentially causing a short, and possibly leading to a fire if charged at less than 41 degrees. Toyota indicated that a fix would be available in the 4th quarter of 2023. We are nearing the end of the 4th quarter and fix is still not available. Living in upstate New York, nighttime temperatures frequently are less than 41 degrees. As a result I am reluctant to charge overnight. This defeats the purpose of a plug-in hybrid, resu… Look up ODI 11559489 at NHTSA ↗ ODI 11742590Observed arcing noises and strong electrical fire smell upon plugging in L2 EVSE charging cable. MIL lit, Hybrid Vehicle Charging System codes active; vehicle refused to charge afterwards. Self-diagnosed and repaired defective 6.6 kW onboard charger. See pics of clear arcing damage withing charging unit - possible fire risk. Look up ODI 11742590 at NHTSA ↗ | 0 | 0 | 0 | — | 0 |
|---|
| Vehicle Speed Control | 0 | 0 | 1ODI 11563605I was pulling into a parking space at a slow speed and breaking when my car accelerated violently and caused me to go across a median and strike another parked vehicle. Police came and did a report. I took my car right away to dealer and they had me take it to their collision shop to be repaired. They said they would try to find the unintended acceleration problem after it was repaired. No warning lights or airbags. Look up ODI 11563605 at NHTSA ↗ | 2ODI 11467556We have COMPLETELY lost brakes on MULTIPLE occasions for a few seconds per occasion. Brake loss has occurred upon slow, even braking and on flat, dry, even pavement with no pot poles or loose gravel around. When this happens, an orange light appears on the dash, we lose brakes for a few seconds, the car regains brakes, and jolts forward with no change in foot position on the brake pedal. We have taken the car to the dealer multiple times and every single time this incident has occurred the rear right wheel speed shows about a 10% variation in s… Look up ODI 11467556 at NHTSA ↗ ODI 11563605I was pulling into a parking space at a slow speed and breaking when my car accelerated violently and caused me to go across a median and strike another parked vehicle. Police came and did a report. I took my car right away to dealer and they had me take it to their collision shop to be repaired. They said they would try to find the unintended acceleration problem after it was repaired. No warning lights or airbags. Look up ODI 11563605 at NHTSA ↗ | 1ODI 11588930I was driving very slowly in my driveway. I turned to enter my garage. As I put my foot on the break, the car accelerated crashing into my house. There was sudden unexplained and unintended acceleration on my RAV4 prime. Look up ODI 11588930 at NHTSA ↗ | 0 | 0 | — |
|---|