2004 4-Star Trailers HORSE TRAILER: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
3 owner complaints analyzed
2 distinct recall campaigns
Not available median reported failure mileage
Scope: 2004 model year. Data updated: . 0 complaints include usable failure mileage. View data status.
Most common problems
Tires is the most frequently named component, appearing in 2 of 3 complaints (66.7%). A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
| Category | Count |
|---|---|
| Tires | 2 |
| Suspension:Rear:Axle:Spindle | 1 |
Tires: 2; Suspension:Rear:Axle:Spindle: 1
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 3 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
| Category | Count |
|---|---|
| 2007 | 1 |
| 2008 | 1 |
| 2009 | 1 |
2007: 1; 2008: 1; 2009: 1
Pattern summary
Tires leads the component reports. Use these patterns to inspect individual reports and prepare questions for a mechanic.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Owner report 10183491 · 2007-02-26 (February 26, 2007)
TL*- THE CONTACT TOOK HIS 2004 KIEFER BUILT HORSE TRAILER TO DEALER TO GET A TIRE REPLACEMENT AND WAS INFORMED THAT THERE WAS SOMETHING WRONG WITH THE AXLE. AFTER THE TIRE WAS REPLACED HE TOOK THE VEHICLE TO GRAND CHAMPION AND THEY INFORMED HIM THAT THE TIRE NEEDED BALANCING. GRAND CHAMPION TOLD THE CONTACT THAT THE TIRE WAS BALANCED WHEN THE TIRE COMPANY REPLACED THE TIRE. THE CONTACT TOOK THE VEHICLE IN ABOUT 4-6 MONTHS LATER AND WAS INFORMED THAT THE SAME TIRE WAS WEARING AGAIN. HE THEN TOOK THE VEHICLE BACK TO GRAND CHAMPION , AND W…
Owner-reported narrative. Look up ODI 10183491 at NHTSA ↗
Owner report 10237354 · 2008-08-07 (August 7, 2008)
NEW TIRES PURCHASED ON OCTOBER 5, 2007 COMPLETELY FAILED LESS THAN 7 MONTHS LATER IN MAY 2008. YOUR SYSTEM DOES NOT HAVE THE OPTION OF SELECTING THE CORRECT TIRE MANUFACTURER SO I ENTERED THE INFORMATION AS CLOSE TO THE CORRECT DATA AS POSSIBLE. PARKHOUSE TIRE, INC. PURCHASED THE TIRES AND I DO NOT KNOW THE MFG. *TR
Owner-reported narrative. Look up ODI 10237354 at NHTSA ↗
Owner report 10283652 · 2009-09-11 (September 11, 2009)
BLOW OUT OF UNIROYAL LT235 85R16 TIRES ON HORSE TRAILER WITH NO SIGNS OF WEAR. SECOND BLOW OUT WAS THIS YEAR. I FEEL THERE IS A PROBLEM WITH THIS TIRE AS THIS IS A COMMON PROBLEM. TIRES WERE INFLATED PROPERLY. REPLACED ALL 4 TIRES WITH A DIFFERENT BRAND. *TR
Owner-reported narrative. Look up ODI 10283652 at NHTSA ↗
Recall history
2 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
06V302000 · Equipment
Reported: 2006-08-09 (August 9, 2006)
ON CERTAIN HORSE TRAILERS, THE FASTENERS SECURING THE HAYPOD TO THE ROOF MOUNTING BRACKET MAY FAIL.
Consequence: THIS ALLOWS THE HAYPOD TO SEPARATE FROM THE TRAILER. THIS COULD POSE A SERIOUS HAZARD TO OTHERS.
Remedy: DEALERS WILL INSTALL NEW FASTENERS SECURING THE HAYPOD TO THE MOUNTING BRACKET ON THE ROOF OF THE TRAILER FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 16, 2006. OWNERS MAY CONTACT 4-STAR AT 1-800-848-3095.
NHTSA campaign record ↗07V396000 · Equipment
Reported: 2007-08-31 (August 31, 2007)
ON CERTAIN TRAILERS EQUIPPED WITH COVERED HAYRACKS, THE FASTENERS SECURING THE HAYRACK TO THE ROOF MOUNTING BRACKET MAY FAIL, ALLOWING THE HAYRACK TO SEPARATE FROM THE TRAILER.
Consequence: THIS COULD POSE A SERIOUS HAZARD TO FOLLOWING VEHICLES INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL NEW FASTENERS SECURING THE HAYRACK TO THE MOUNTING BRACKET ON THE ROOF OF THE TRAILER. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT 4-STAR AT 1-800-848-3095.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
3 unique complaints in this selection. Analysis snapshot: 2026-10-01.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 2003 | 2004 | 2005 | 2006 | 2007 |
|---|---|---|---|---|---|
| Tires | 00.0%No examples available for this selection. | 266.7%ODI 10237354NEW TIRES PURCHASED ON OCTOBER 5, 2007 COMPLETELY FAILED LESS THAN 7 MONTHS LATER IN MAY 2008. YOUR SYSTEM DOES NOT HAVE THE OPTION OF SELECTING THE CORRECT TIRE MANUFACTURER SO I ENTERED THE INFORMATION AS CLOSE TO THE CORRECT DATA AS POSSIBLE. PARKHOUSE TIRE, INC. PURCHASED THE TIRES AND I DO NOT KNOW THE MFG. *TR | 00.0%No examples available for this selection. | 125.0%ODI 1019786620 JUNE 2007 WAS TRAVELING ON I-75 NORTH @ MILE 72 AT 65 MPH LEFT CAMPER TIRE FAILED, TOOK ALL PLUMBING OFF CAMPER, RIM DESTROYED. THERE'S WAS NOTHING LEFT TO SAVE. HIT NOTHING IN ROAD, TIRE WAS AT 52 PSI 1 HOUR BEFORE. TIRE WAS A GOODYEAR MARATHON. REPLACED BOTH TIRES. GOODYEAR DEALER DIDN'T CARRY MARATHONS REPLACED WITH CARLYSES. *TR | 00.0%No examples available for this selection. |
| Tires:Sidewall | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10167223 · 2,000 miDT*: THE CONTACT STATED WHILE DRIVING 55 MPH, THE FRONT RIGHT TIRE ON THE APPALACHIAN 22 FOOT DECKOVER TRAILER DEFLATED WITHOUT WARNING. UPON INSPECTION, THE RUBBER OF THE TIRE WAS PEELED AWAY FROM THE NYLON CORDS. THE TIRE WAS CHANGED HOWEVER THE TRAILER WAS NOT TAKEN IN FOR SERVICE. THE TIRE WAS A KENDA USA LODESTAR. | 125.0%ODI 10173301 · 2,000 miWHILE DRIVING APPROXIMATELY 55 MPH IN HEAVY HIGHWAY TRAFFIC, THE FRONT RIGHT TIRE (KENDA USA LOADSTAR) ON OUR APPALACHIAN 22 FOOT DECKOVER TRAILER BLEWOUT. THE TIRE RUBBER PEELED AWAY FROM THE NYLON CORDS AND LEFT A VERY LARGE HOLE IN THE SIDEWALL. WHILE CHANGING THIS TIRE, IT WAS NOTICED THAT ONE OF THE OTHER TIRES HAD AN EGG SHAPED BUBBLE. DUE TO THE CONDITION OF THE OTHER TIRE, WE DIDN'T FEEL THAT IT WOULD BE SAFE FOR US TO CONTINUE OUR TRIP. (WE DIDN'T HAVE AND COULDN'T GET ANOTHER SPARE.) ONCE HOME, WE LOOKED MORE CLOSELY AT ALL OF TH… | 00.0%No examples available for this selection. |
| Trailer Hitches | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10180974 · 500 miTL* - THE CONTACT HAD A 2005 BIG TEX TRAILER HITCHED TO A 1999 SUBURBAN 1500 WHEN HE HAD TO STOP SUDDENLY. THE BRAKES FAILED, AND THE TRAILER WOULD NOT STOP. HOWEVER, THE TRAILER EVENTUALLY STOPPED, THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS APPROXIMATELY 500 MILES. THE CONTACT LOOKED UNDER THE VEHICLE AND DISCOVERED THE RUBBER BRAKE LINE SHEARED OFF. THE DEALER REPLACED THE BRAKE LINE. APPROXIMATELY 6- 8 MONTHS LATER, THE BRAKE LINE HAD TO BE REPLACED BECAUSE OF THE SAME PROBLEM WITH THE BRAKES. THE CONTACT STATED THE SAFETY LATC… | 125.0%ODI 10187332TL*- THE CONTACT OWNS A 2006 STEHL TOW DOLLY BY TRAILER CORPORATION OF AMERICA. THE HITCH DISCONNECTED WHILE DRIVING ON AN INCLINE. THE SAFETY CHAINS YANKED THE TRAILER INTO THE BACK OF A BUS, CAUSING $5,000 IN DAMAGE. THE CONTACT CONTINUED UP THE INCLINE WHEN THE PASSENGER NOTICED THAT THE TRAILER SEPARATED FROM THE BUS. THE TRAILER AND THE VEHICLE ATTACHED TO IT WERE 6 FEET FROM BACKING INTO WHEN THE CONTACT WAS ABLE TO JUMP IN AND STOP THE VEHICLE.*AK | 00.0%No examples available for this selection. |
| Equipment | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10180974 · 500 miTL* - THE CONTACT HAD A 2005 BIG TEX TRAILER HITCHED TO A 1999 SUBURBAN 1500 WHEN HE HAD TO STOP SUDDENLY. THE BRAKES FAILED, AND THE TRAILER WOULD NOT STOP. HOWEVER, THE TRAILER EVENTUALLY STOPPED, THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS APPROXIMATELY 500 MILES. THE CONTACT LOOKED UNDER THE VEHICLE AND DISCOVERED THE RUBBER BRAKE LINE SHEARED OFF. THE DEALER REPLACED THE BRAKE LINE. APPROXIMATELY 6- 8 MONTHS LATER, THE BRAKE LINE HAD TO BE REPLACED BECAUSE OF THE SAME PROBLEM WITH THE BRAKES. THE CONTACT STATED THE SAFETY LATC… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 10180974 · 500 miTL* - THE CONTACT HAD A 2005 BIG TEX TRAILER HITCHED TO A 1999 SUBURBAN 1500 WHEN HE HAD TO STOP SUDDENLY. THE BRAKES FAILED, AND THE TRAILER WOULD NOT STOP. HOWEVER, THE TRAILER EVENTUALLY STOPPED, THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS APPROXIMATELY 500 MILES. THE CONTACT LOOKED UNDER THE VEHICLE AND DISCOVERED THE RUBBER BRAKE LINE SHEARED OFF. THE DEALER REPLACED THE BRAKE LINE. APPROXIMATELY 6- 8 MONTHS LATER, THE BRAKE LINE HAD TO BE REPLACED BECAUSE OF THE SAME PROBLEM WITH THE BRAKES. THE CONTACT STATED THE SAFETY LATC… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Structure | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 1100.0%ODI 10232471TL*THE CONTACT OWNS A 2007 COVENANT CARGO TRAILER (NA). THE CONTACT NOTICED THAT THE CHASSIS WAS ROTTED, INSTEAD OF WELDED AND CUT TOO SHORT IN SEVERAL AREAS. THE INTEGRITY OF THE TRAILER WAS FLEXING AND SEPARATING. THE VIN WAS UNKNOWN. HE CALLED AND EMAILED THE MANUFACTURER, BUT NEVER RECEIVED ASSISTANCE. THE MILEAGES WERE UNKNOWN. |
| Structure:Frame And Members:Underbody Shields | 1100.0%ODI 10134094VEHICLE IN QUESTION IS A HANNIGAN MOTORCYCLE TRAILER, SIERRA MODEL, MADE BY HANNIGAN MOTORSPORTS, 4044 HWY 641 SOUTH, MURRAY, KY 42071, [phone removed]. I HAD TO LIST ANOTHER MANUFACTURER BECAUSE HANNIGAN IS NOT LISTED AND YOU CANNOT CONTINUE WITHOUT A MANUFACTURER. TRAILER HAS UNUSUAL UNDERSIDE AERODYNAMICS THAT CAUSE ROAD DUST AND FINE SAND TO BE SUCKED FROM THE ROADWAY AND ON TO THE UNDERSIDE OF THE TRAILER JUST BEHIND THE WHEELS. DO NOT KNOW WHEN IT STARTED, AS THE AREA IS NOT READILY VISIBLE, BUT JUDJING FROM AFTER THE BODY WAS PENET… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
| Suspension:Multiple Axle | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 125.0%ODI 10202960TL*THE CONTACT OWNS A 2006 COVENANT ENCLOSED CARGO TRAILER (NA). THE CONTACT STATED THAT THE AXLES WERE STRIKING THE BODY OF THE VEHICLE AND SEVERED THE BRAKE WIRES. THE AXLE WAS REPLACED, BUT THE FAILURE REMAINS. NO OTHER VEHICLE INFORMATION WAS AVAILABLE. | 00.0%No examples available for this selection. |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| No usable records for this analysis. | ||||
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 | 0 | None | No examples available for this selection. |
| 2026-10 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2006: 4 complaints · 2007: 1 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2006 | 3 | 4 | 4 |
| 2007 | 0 | 1 | 1 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2006 | 4 | 0 | 0 |
| 2007 | 1 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component | Tires | Suspension:Rear:Axle:Spindle |
|---|---|---|
| Tires | — | 0 |
| Suspension:Rear:Axle:Spindle | 0 | — |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.