2016 Forest River CEDAR CREEK: complaints, problems and recalls

FEBRUARY 2014, WE PURCHASED A NEW 2013 FOREST RIVER (NOT LISTED IN NHTSA MFG. SELECTION): COACHMEN FREEDOM EXPRESS LIBERTY EDITION, 297RLDSLE. TRAILER CAME EQUIPPED WITH 225/75R15 D TRAIL EXPRESS - POWER TOWING TIRES. NOT LISTED IN YOUR DATA. DEALER INSTALLED A HUSKY 801-1200# LOAD BALANCING AND ANTI-SWAY BAR SYSTEM ON OUR 2008 YUKON XL 1/2 TON SUV. WE TOWED OUR RIG BACK TO FORT MYERS 100 MILES. DURING OUR TRIP HOME WE HAD TO STOP SEVERAL TIMES TO ADJUST +++ THE SWAY BAR TENSION BECAUSE THE TRAILER WAS STILL SWAYING. I DISCUSSED THIS WITH HUSK…

Look up ODI 10596747 at NHTSA ↗

VEHICLE IS A 2017 5TH WHEEL TRLR.. ON 7/12/2019 I WAS TOWING THE TRLR AT 70 MPH AND PULLED INTO A STOP. TRLR IS 2 AXLES AND THE RT. FRONT TIRE WAS FLAT WITH ABOUT A 7 INCH STRIP OF TREAD HANGING LOOSE AT THE JUNCTION OF THE TREAD/SIDEWALL. I REPLACED THE TIRE AT A COST OF $140.00. TIRE PRESSURE WAS 75 PSI AND THE AIR TEMP WAS 90 DEG. ON 7/14/2019 I HAD ANOTHER BLOWOUT WITH THE LEFT REAR TIRE AT 70MPH. THE TIRE CAME APART AND DAMAGE THE TRAILER FLOOR AND SIDE SKIRTING. THE AIR TEMP WAS 77 DEG. BOTH TIRES WERE ORIGINAL EQUIPMENT GOODYEAR MARATHON…

Look up ODI 11231809 at NHTSA ↗

HEADING TO GO CAMPING DRIVING 55 MPH WITH MY SON AND WIFE FOLLOWING US IN THEIR CAR, THE RIGHT FRONT TRAILER TIRE BLEW ON MY CAMPER. THIS CAUSED THE FENDER TO BE TORN OFF AND SOME OF THE SKIRTING TO BE BEND AND SCUFFED UP FROM THE RV. SPARE WAS PUT ON AND WE CONTINUED TO THE CAMPGROUND. NOW INVESTIGATING WHAT TO DO TO PROCEED. I HAVE NOT NOTIFIED INSURANCE YET AND MAY ATTEMPT TO ORDER PARTS FOR RV AND REPAIR MYSELF. ALL OF THE TIRES WILL GET REPLACED BEFORE MY NEXT CAMPING TRIP. THE RV IS 1 YEAR AND A MONTH OLD.

Look up ODI 11208933 at NHTSA ↗

ALL FOUR OF OUR CASTLE ROCK ST TIRES ON OUR TRAVEL TRAILER ARE SHOWING PREMATURE CRACKS IN THE SIDEWALL AND WHERE THE TREAD MEETS THE SIDEWALL. THIS COULD LEAD TO A CATASTROPHIC FAILURE OF THE TIRE AT HIGH SPEED. THESE TIRES HAVE BEEN IN USE LESS THAN 18 MONTHS.

Look up ODI 11413047 at NHTSA ↗

Tire failure verified by CompassRV and P&J Towing. Belt broke causing the tire to separate and damage the outside of the RV. Safety risk: immediate swerve of a large camper. Multiple complaints on this tire through RVforum. Tire inspected by Compass RV and P&J tire and towing . No warning just a loud pop. ST235/80/R16.

Look up ODI 11582290 at NHTSA ↗

The contact owns a 2021 Forest River Cedar Creek. The contact stated that he noticed that the spare tire under the vehicle was missing. The contact stated that he replaced the spare tire however, the contact stated that while driving approximately 60 MPH, he noticed that the spare tire was shaking. Upon inspecting the vehicle, he noticed that the spare tire was loose and hanging, and the carrier winch was also loosened. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Look up ODI 11491781 at NHTSA ↗

THE OFF DOOR SLIDE (KITCHEN SLIDE) BRACKET IS CRACKED. IF THIS WOULD BREAK, THE SLIDE WILL NOT BE HELD CLOSED.

Look up ODI 10723854 at NHTSA ↗

UPON TURNING INTO A PARKING LOT WITH A VERY SMALL INCLINE AT APPROXIMATELY 2 MILES PER HOUR, THE REAR OF THE FIFTH WHEEL BOTTOMED OUT & SCRAPED THE PAVEMENT CAUSING IT TO RIP OFF THE BOTTOM OF THE BACK CAP. AS A RESULT OF THE BACK CAP BEING PULLED AWAY FROM THE FRAME, IT ALSO CAUSED US TO HAVE TO PULL THE FIFTH WHEEL HOME WITHOUT ANY BRAKE LIGHTS, HAZARD LIGHTS OR TURN SIGNALS, WHICH IS A HAZARD TO US & OTHER DRIVERS ON THE ROAD. THE REAR OF THE FIFTH WHEEL SITS ENTIRELY TOO LOW TO GROUND & THIS WILL HAPPEN EVERY TIME IT IS PULLED TO A NEW LOCA…

Look up ODI 11319904 at NHTSA ↗

WE PURCHASED OUR BRAND NEW FIFTH WHEEL FROM A DEALER AND PULLED IT ACROSS THE STREET TO A CAMPGROUND FOR A FEW DAYS. ON THE DRIVE HOME WE PULLED OFF INTO A GAS STATION WITH A VERY SLIGHT INCLINE. THE BACK END OF THE CEDAR CREEK 35LFT IS SO LOW THAT IT SCRAPPED THE PAVEMENT AS WE PULLED IN AND DAMAGED THE BACK WALL AS WELL AS ALL THE BRAKE WIRING. DO TO THIS DESIGN FLAW, WE'RE UNABLE TO TAKE OUR RV ANYWHERE IN FEAR OF DAMAGING IT AGAIN. *TR

Look up ODI 11328822 at NHTSA ↗

I NEED TO KNOW THE RULES ABOUT A RV5TH WHEEL TRAILER THE GVW RATING IS 13THOUSAND615PDS. THE AXEL RATING IS 12THOUSAND PDS. ARE THE AXLES TO SMALL OR IS OK I BEEN TOLD BY CA,HWY PORTAL THAT MY AXLES ARE TO SMALL I NEED TO KNOW CAN YOU PLEASE LET ME KNOW. *TR

Look up ODI 10575378 at NHTSA ↗

LEAF SPRING BRACKET OR AXLE MOUNT CAME LOOSE CAUSING THE AXLE TO COME LOOSE ON DRIVERS SIDE CAUSING THE WHOLE RV TO FISH TAIL - LUCKILY NO BODILY INJURY OCCURRED. THIS HAPPENED ON STATE RT 22 NEAR CONWAY SOUTH CAROLINIA. INCIDENT DATE WAS APRIL 7, 2020. THE DEALER HAS PROVIDED LIMITED INFORMATION ON REPAIR - WAITING FOR PARTS. CONTACTED FACTORY AND THEY ALSO STATED WAITING ON 3 PARTY VENDOR PARTS. NO EXPLANATION ON WHY THIS HAPPENED. AFTER SOME INTERNET SEARCHING FOUND THE ATTACHED PDF AND ALSO COPY OF LETTER SENT TO CEDAR CREEK.

Look up ODI 11323215 at NHTSA ↗

While towing our 5th wheel cross country on a trip in July 2020 our front hydraulic jack legs starting coming down several times while driving and contacted the road surface which could have possibly resulted in loss of control. Some how the hydraulic system was applying pressure by itself while towing .I first tried disconnecting electrical power to the hydraulic system and keeping the jack legs up with a 400 lb rated ratchet strap and the legs would still come down on its own with enough pressure to break the 400 lb rated strap. I was finall…

Look up ODI 11458311 at NHTSA ↗

The contact owns a 2023 Forest River XLR Toy Hauler RV. The contact stated while driving approximately 40 MPH and hauling the RV he heard an abnormal exploding sound and realized that the passenger side rear tire on the RV blew out. The contact stated no warning light was illuminated. The contact had weighed the RV and it was approximately 1,400 lbs. The contact pulled over to change the tire on the RV and noticed that the leaf-spring on the passenger was collapsing. The contact checked and observed that all the leaf-springs on the RV were coll…

Look up ODI 11549603 at NHTSA ↗

The contact owns a 2021 Forest River Cedar Creek. The contact stated that he noticed that the spare tire under the vehicle was missing. The contact stated that he replaced the spare tire however, the contact stated that while driving approximately 60 MPH, he noticed that the spare tire was shaking. Upon inspecting the vehicle, he noticed that the spare tire was loose and hanging, and the carrier winch was also loosened. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Look up ODI 11491781 at NHTSA ↗

The contact owns a 2022 Forest River Cedar Creek. The contact stated that while outside of his trailer, he smelled a fuel odor emitting from the trailer. The contact performed an inspection on the trailer and discovered that his LP tanks were consuming propane at an accelerated speed. The contact took the vehicle to a dealer where he informed them that he would not take possession of the trailer until the trailer was repaired. The contact stated that while the trailer was being repaired, the stove caught fire while a technician was inside the t…

Look up ODI 11464005 at NHTSA ↗

The contact owns a 2023 Forest River Cedar Creek Trailer. The contact stated that there were electrical failures with the heating and other electrical components in the trailer. The contact stated that a technician inspected the trailer and found exposed wires in the glued-shut control board. The wires were replaced; however, the failure persisted. The vehicle was taken to the dealer where it was diagnosed and determined that the furnace board and control board needed to be replaced twice. The trailer was repaired but the failure persisted. The…

Look up ODI 11607611 at NHTSA ↗

ON ONE OF THE FIRST TRIPS WITH THE FIFTH WHEEL WE WERE TRAVELING AND WHILE IN MOTION, SUDDENLY LOST ALL TRAILER BRAKES. WE WERE ON A TOWN STREET, IN THE BUSINESS DISTRICT DURING HEAVY TRAFFIC. WE WERE ABLE TO PULL OVER SAFELY AND INSPECT THE VEHICLE. THE BRAKE LIGHTS WERE FUNCTIONAL AND THE FIFTH WHEEL HAD POWER. WHEN MY HUSBAND CRAWLED UNDER THE VEHICLE TO SEE IF HE COULD DETERMINE THE ISSUE HE FOUND THAT THE ELECTRICAL LINE TO THE BRAKES WAS NOT SPLICED TOGETHER PROPERLY AND HAD COME APART. MY HUSBAND WAS ABLE TO TAPE THE APPROPRIATE WIRE…

Look up ODI 11093206 at NHTSA ↗

The automatic awning did not have proper backing plates installed, so the first time going out caused the awning to collapse completely against the full glass wall. The wire harness system was not the correct gauge wire, which posed a potential fire hazard. The fuse was pulled out because the motor to the faulty awning was overheating. The front entry (only) door for entering the RV and existing safely was not mounted correctly, so the owners (occupants) were locked inside during the daytime hours when the door expanded with sun/heat. The o…

Look up ODI 11484655 at NHTSA ↗

We purchased a new fifth wheel camper on [XXX]. After we picked it up, we joined some Facebook groups related to our model and learned there is a recall associated with the model we bought. We confirmed there is an open recall (24V395) on our VIN on forest river's website [XXX] ). Upon review of the recall instructions listed online - our RV was in fact wired incorrectly and not only needs inspected but fixed. Recall 24V395 was opened on June 5, 2024 and dealer notification occurred July 14, 2024. With this in mind, our dealer should have been…

Look up ODI 11611230 at NHTSA ↗

THE OFF DOOR SLIDE (KITCHEN SLIDE) BRACKET IS CRACKED. IF THIS WOULD BREAK, THE SLIDE WILL NOT BE HELD CLOSED.

Look up ODI 10723854 at NHTSA ↗

While driving down the road at highway speeds (65-68 M.P.H.) the "under belly" of the 2020 Cedar Creek 5th wheel trailer became dislodged and fell onto the freeway. Large sections of plastic (Estimating 36" X 48") as well as insulation was thrown onto the highway. After further inspection one could see the brackets holding the wooden cross member beams into place were only fastened with one sheet metal screw. The brackets were designed to have two sheet metal screws holding the bracket to the frame of the trailer. It was also noted wooden cros…

Look up ODI 11504940 at NHTSA ↗

We purchased a new fifth wheel camper on [XXX]. After we picked it up, we joined some Facebook groups related to our model and learned there is a recall associated with the model we bought. We confirmed there is an open recall (24V395) on our VIN on forest river's website [XXX] ). Upon review of the recall instructions listed online - our RV was in fact wired incorrectly and not only needs inspected but fixed. Recall 24V395 was opened on June 5, 2024 and dealer notification occurred July 14, 2024. With this in mind, our dealer should have been…

Look up ODI 11611230 at NHTSA ↗

The door in the second bedroom will not open if the sofa is opened to a bed. When the bed is open you cannot access the room from outside and you can not exit the room. The specification brochure shows that the door is supposed to open out to eliminate the problem, however the door was installed incorrectly in all of the 2025 models. When contacting Forest River they are denying saying that the door was designed that way with an emergency window in the room. The room cannot be entered or exited if the bed is out with the door being this wa…

Look up ODI 11762673 at NHTSA ↗

WHILE RETURNING HOME FROM A TRIP WE WERE NOTIFIED BY ANOTHER DRIVER WE HAD JUST LOST A TIRE. ONCE WE PULLED OVER WE FOUND THAT THE ENTIRE WHEEL HAD SHEARED OFF THE HUB. AFTER LIMPING THE TRAILER OFF THE HIGHWAY WE WENT BACK AND RETRIEVED THE TIRE. I FOUND TWO OF THE STUDS WITH THE WHEEL. OF THE SIX STUDS 2 SHEARED EVEN WITH THE HUB AND FOUR SHEARED INSIDE THE HUB. SINCE WE HAVE OWNED THE TRAILER THE ONLY TWO TIMES I CAN NOT VERIFY HOW WELL THE STUDS WERE TORQUED IS FROM THE MANUFACTURE AND LAST YEAR WHEN WE HAD ALL FOUR TIRES REPLACED AT A DEAL…

Look up ODI 10705166 at NHTSA ↗

WE HAVE A 2017 CEDAR CREEK 38FBD WITH DUAL 7000 POUND AXLES AND OEM ALLOY WHEELS. THE SECOND OF MY FOUR ALLOY WHEELS CRACKED SOMETIME DURING THE 3 DAYS WE WERE SETUP AT COE RIVERSIDE PARK @ LAKE KANOPOLIS, KS. I FOUND THIS OUT WHEN MY AFTERMARKET TPMS ALARMED THAT THE TIRE WAS AT 5 PSI RATHER THAN NEAR 110PSI WHEN I TURNED IT ON. IF THE CRACK AND RESULTING PRESSURE LOSS HAD OCCURED WHILE WE WERE PULLING OUR FIFTH WHEEL, WE MAY HAVE LOST CONTROL OF THE TRAILER AND INJURED NOT ONLY OURSELVES, BUT OTHERS ON THE ROAD. AS I STATED, THIS IS THE S…

Look up ODI 11268618 at NHTSA ↗

On the first trip out, We had a tire blowout. There was no warning on the TPMS, and the tire tread peeled like a retread. It caused major damage to the rv slide out, and threw tire tread across the highway putting other motorists at risk. Forest River refused to cover any of the damage. The tire manufacturer covered less than 30% of the cost of a new tire. After the repairs, we made another trip. This time we had two more blowouts. This damaged the other side of the rv and also took out all of the brake wiring, leaving us with no brakes on the …

Look up ODI 11498946 at NHTSA ↗