| Electrical System | 1164.7%ODI 10515647 · 263,175 miTL* THE CONTACT OWNS A 2012 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT ALL FOUR BATTERIES FAILED. THE CONTACT ALSO MENTIONED THE STARTER PREVIOUSLY FAILED AND THE FAILURE MAY BE RELATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 263,175. Look up ODI 10515647 at NHTSA ↗ | 228.6%ODI 11104712 · 197,000 miTHE CAB READING LIGHTS NOT FUNCTIONING, DASHBOARD LIGHTS MALFUNCTION OR NOT WORKING. THEY STOP FUNCTIONING WHILE VEHICLE WAS STATIONARY. Look up ODI 11104712 at NHTSA ↗ | 541.7%ODI 10704799 · 276,000 miWE WERE ASLEEP IN THE TRUCK WITH THE CURTAINS CLOSED. THE ENGINE WAS RUNNING SMOOTHLY AND THE AIR CONDITIONING WAS BLOWING COLD AIR. WE WERE AWAKENED BY SOMEONE POUNDING ON OUR DOOR. WHEN I OPENED THE CURTAIN, THE LEFT SIDE OF THE WINDSHIELD WAS A SHEET OF FLAMES COMING OUT FROM UNDER THE HOOD. FLAMES WERE ALSO COMING OUT OF THE LEFT SIDE HOOD LATCH ACCESS HOLE AND COVERING THE LEFT SIDE WING WINDOW. WE EXITED THE TRUCK BY THE RIGHT SIDE DOOR AND TOOK A PICTURE OF THE FIRE WITHIN TWO MINUTES OF GETTING OUT. THIS PICTURE IS AVAILABLE. ANOTHER P… Look up ODI 10704799 at NHTSA ↗ | 425.0%ODI 10780250 · 123,525 miA/C - DEFROSTER BLOWER MOTOR BEGAN TO INTERMITTENTLY STOP. THROWING DASH CODE SPN 523318 FMI 7 REGARDLESS OF VEHICLE BEING IN MOTION OR PARKED. THEN MOTOR QUIT WORKING SUDDENLY. UPON TAKING IT TO A DEALERSHIP THEY FOUND THE MOTOR WAS SEIZED AND THE WIRING HARNESS HAD BEGAN TO MELT. WHEN REPLACING THE MOTOR THE TECHNICIAN SAID THEY HAD CHANGED THE DESIGN OF THE MOTORS. HE REPLACED THE MOTOR, AND HAD TO ADD A NEW ADAPTOR FOR THE MOTOR. HE ALSO HAD TO REPLACE THE WIRING HARNESS THAT HAD MELTED WHICH ATTACHES TO THE ADAPTOR. Look up ODI 10780250 at NHTSA ↗ | 325.0%ODI 11390543 · 313,882 miI AM A FIRE INVESTIGATOR WITH ONONDAGA COUNTY FIRE INVESTIGATION UNIT. RECENTLY I HAD TWO FIRES WITH SIMILAR VEHICLES BOTH WERE 2016 FREIGHTLINERS CASCADIA 125 BOTH WERE PARKED AND NOT RUNNING AT THE TIME OF THE FIRE EVENTS. BOTH ORIGIN AND CAUSE INVESTIGATIONS APPEARED TO REVEAL A FAILURE/MALFUNCTION AT THE WHAT HAS BEEN DESCRIBED TO ME AS BEING THE POWER DISTRIBUTION MODULAR (PDM). BOTH RESULTED IN THE VEHICLES BEING DESTROYED BY FIRE.*DT*JB*JB*JB*JB*JB Look up ODI 11390543 at NHTSA ↗ | 00.0%No examples available for this selection. | 218.2%ODI 11140059SEMI WAS TRAVELING WESTBOUND ON INTERSTATE 80 WHEN IT ENTERED NORTH DITCH OF THE ROADWAY. SEMI ROLLED AT LEAST ONCE AFTER ENTERING DITCH. DRIVER WAS EJECTED FROM THE VEHICLE WHILE IT WAS ROLLING. IT CAME TO REST ON PASSENGER SIDE FACING WESTBOUND. DRIVER WAS PRONOUNCED DEAD AT HOSPITAL. AT THE SCENE OF THE ACCIDENT THE MECHANIC OF THE COMPANY MENTIONED THERE WAS A PROBLEM WITH THE BRAKES. THE AIR BAG DID NOT DEPLOY AND THE SEAT BELT ALARM CONTINUED TO SOUND EVEN WHEN THE BELT WAS CONNECTED. THIS HAPPENED ONLY SHORTLY AFTER DRIVER STARTED SHI… Look up ODI 11140059 at NHTSA ↗ | 13.4%ODI 11504208This Truck that I'm buying from USCryo Carriers that is a Freightliner has been in the shop numerous times for electrical issues and lighting issues and body and tires problems and they have yet to fix them and get them properly repaired and the Truck is shocking me while driving and whenever laying in the bunkso much it hurts and causes headaches I pay insurance and for the truck, but my company is steady making me pay all repairs even though I have insurance Look up ODI 11504208 at NHTSA ↗ | 311.5%ODI 11329834 · 20 miWHEN MY TRUCK DRIVING ON THE HIGH WAY WITH 70 MILES PER HOUR. THE CLUTCH FAN KICK IN - CRUISE CONTROL AUTOMATICALLY CANCEL - GEAR IN AND OUT. RPM ROSE UP AND DOWN FAST FROM IDLE TO THE CURRENT SPEED. IT BROUGHT TO DEALER TWICE BUT THEY SAID MY TRUCK IS RUNNING FINE. THERE IS NO LIGHT COME ON. 1ST TIME TOOK TO DEALER AT 54000 MILE, 2ND AT 63000. NOW IT IS 70,000 MILES. *TR Look up ODI 11329834 at NHTSA ↗ | 16.3%ODI 11561665When driving, there is a constant and very strong vibration throughout the entirety of the truck. This makes it difficult to steer and drive in a safe manner. I've replaced any parts that might be associated with this malfunction with brand new parts at the advice of professional mechanics (cost over $30,000) and it was to no avail. The truck is still malfunctioning and I have been left unable to work or barely working for 14 months. The vibration has caused many health concerns, like headaches, nausea, and stomach ulcers. I went to over 10 dea… Look up ODI 11561665 at NHTSA ↗ | 17.7%ODI 11631506ABS system is shutting causing all safety systems to shut down including cruise control. Freightliner is overlaying the harness for abs sensors at the owners expense. There should be a recall for them to fix this issue. They are very aware of what's going on and are doing nothing to fix the issue. Look up ODI 11631506 at NHTSA ↗ | 216.7%ODI 11535215Dash light warning lights come on and causes the cruise control to stop working. A total of 6 fault lights comes on and also causes the Adaptive Cruise Control to not work. This is the 3rd Freightliner Cascadia that I have driven in the past 3 and a half years and every single truck has had the same problem. Freightliner has refused to acknowledge that there is a problem. Nobody seems to know what to do to correct the problem. We are owner operators and long haul drivers and needcruise control. Freightliner dealers are almost impossible to get … Look up ODI 11535215 at NHTSA ↗ | 17.1%ODI 11633144It is hard to impossible to drive the truck in a straight line (compared to models without the smartvalves), and often drifts side to side randomly without any warning or feedback. The steering requires constant input, and the "feel" of the truck is not correct to allow intuitive steering. When driving in tight areas, I find that I need to stay at least a foot away from barriers or other objects to not be in danger of hitting them. When in width-limited areas, like construction zones, I often need to straddle the center line and block other … Look up ODI 11633144 at NHTSA ↗ | 00.0%No examples available for this selection. | 266.7%ODI 11679210On August 1st, I was travelling on I-44 (a toll road with an 80 mph speed) near Claremont Oklahoma. I was doing 68 mph when a red warning message came up on my dash. It read...KINGPIN RELEASE ACTIVATED. STOP IMMEDIATELY! KINGPIN RELEASED WITHOUT REQUEST. I did not touch my brakes. I gently moved to the the shoulder and coasted to a stop...so as not to put any pressure on the kingpin or fifth-wheel and hoping the weight of the trailer would hold it in place til I could stop. I checked under my truck and the lock was perfectly across the ja… Look up ODI 11679210 at NHTSA ↗ |
|---|
| Service Brakes | 15.9%ODI 11193880 · 650,000 miTL* THE CONTACT OWNS A 2012 FREIGHTLINER CASCADIA. WHILE OPERATING THE VEHICLE, FLAMES SUDDENLY APPEARED FROM THE PASSENGER SIDE HEADLIGHT ASSEMBLY. THE DRIVER IMMEDIATELY STOPPED THE VEHICLE AND APPLIED WATER TO EXTINGUISH THE FLAMES. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. ALSO, WHILE DRIVING, THE SPEEDOMETER DISPLAYED 12 MPH LESS THAN THE ACTUAL SPEED TRAVELED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THERE WAS A COMPUTER FAILURE. ALSO, THERE WAS AN ENGINE WATER PUMP LEAK THAT PRODUCED WHITE SMOKE. THE INDEPENDENT MECHANIC REPLACED THE G… Look up ODI 11193880 at NHTSA ↗ | 228.6%ODI 10561849 · 265,000 miTL* THE CONTACT OWNS A 2013 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT THE J-BRAKE AND TRAILER BRAKE ERRONEOUSLY ENGAGED. THE CONTACT ALSO MENTIONED THAT THE BRAKES INTERMITTENTLY FAILED TO RESPOND TO DECELERATION ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE ON GUARD SYSTEM HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 265,000. UPDATED 7/31/14*CN *TR Look up ODI 10561849 at NHTSA ↗ | 325.0%ODI 10578648 · 1,000 miWITH MERITOR WABCO ONGUARD CRUISE CONTROL EQUIPPED FROM THE FACTORY. THE CRUISE CONTROL UNIT OFTEN TIMES SLAMS ON THE BRAKES AFTER ERRONEOUSLY DETECTING AN IMMINENT COLLISION. IT FREQUENTLY HARD BRAKES AFTER DETECTING ITEMS THAT ARE WELL OUT OF THE TRAVEL PATH OF THE VEHICLE. THIS BEHAVIOR IS NOT PREDICTABLE TO EITHER THE DRIVER OR NEARBY VEHICLES, AND WILL EVENTUALLY LEAD TO A CRASH OR A DANGEROUS SHIFTED LOAD. I HAVE EXPERIENCED THIS IN 4 DIFFERENT FREIGHTLINER CASCADIAS OF RECENT VINTAGE (2012 OR NEWER), ALL EQUIPPED WITH THE ONGUARD CRUISE … Look up ODI 10578648 at NHTSA ↗ | 318.8%ODI 10721639 · 25,000 miTL* THE CONTACT OWNS A 2015 FREIGHTLINER CASCADIA. WHILE APPROACHING A STOP AT A LOW SPEED, THERE WAS A LOAD ABNORMAL NOISE COMING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE POWER STEERING LINE AND THE HOSE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 15V185000 (SERVICE BRAKES, AIR) BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 25,000. THE VIN WAS UNAVAILABLE… Look up ODI 10721639 at NHTSA ↗ | 00.0%No examples available for this selection. | 111.1%ODI 11415300 · 271,455 miTL* THE CONTACT OWNS A 2017 FREIGHTLINER CASCADIA. THE CONTACT STATED WHILE DRIVING AT 40 MPH, THE VEHICLE BRAKED WITHOUT WARNING. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT SUSTAINED A PINCHED NERVE IN NECK. THE CONTACT DOES NOT KNOW IF THE VEHICLE WAS TAKEN TO LOCAL DEALER OR IF IT HAD BEEN REPAIRED. THE CONTACT DOES NOT KNOW IF MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 271,455. THE VIN WAS NOT AVAILABLE. Look up ODI 11415300 at NHTSA ↗ | 218.2%ODI 11140059SEMI WAS TRAVELING WESTBOUND ON INTERSTATE 80 WHEN IT ENTERED NORTH DITCH OF THE ROADWAY. SEMI ROLLED AT LEAST ONCE AFTER ENTERING DITCH. DRIVER WAS EJECTED FROM THE VEHICLE WHILE IT WAS ROLLING. IT CAME TO REST ON PASSENGER SIDE FACING WESTBOUND. DRIVER WAS PRONOUNCED DEAD AT HOSPITAL. AT THE SCENE OF THE ACCIDENT THE MECHANIC OF THE COMPANY MENTIONED THERE WAS A PROBLEM WITH THE BRAKES. THE AIR BAG DID NOT DEPLOY AND THE SEAT BELT ALARM CONTINUED TO SOUND EVEN WHEN THE BELT WAS CONNECTED. THIS HAPPENED ONLY SHORTLY AFTER DRIVER STARTED SHI… Look up ODI 11140059 at NHTSA ↗ | 931.0%ODI 11091048 · 250 miOUR COMPANY SAYS THE 2019 WILL NOT IDLE WHEN IT IS BETWEEN 30 AND 60 DEGREES , WELL PROBLEM IT CAN BE 58 OUTSIDE AND ITS OVER 70 INSIDE, WELL ROLL DOWN THE WINDOWS , YEAH NOW NO SAFETY FOR THE DRIVER, AND WE HAVE WOMAN OUT THERE TO. SO I DONT THING THEY WANT TO BE RAPED, SO IDLING THE TRUCK SHOULD BE UP TO THE DRIVER NOT THE COMPANY. WITH OUT PROPER SLEEP YOU NOW HAVE SLEEP DRIVERS DRIVING 80,000 POUND WEAPONS ON THE FREEWAYS, FIRST PERSON KILLED WILL BE ON YOUR HEADS IF THIS ISNT TAKEN CARE OF. CRASH PERVENTION SYSTEM ALL OK BUT WHEN DRIVIN… Look up ODI 11091048 at NHTSA ↗ | 726.9%ODI 11444204SHOW ABS NOT WORKING SERVICE REQUIRED ABS DETECTED INTERNAL PROBLEM,AND MAY NEED REPROGRAMMING OR REPLASEMENT STABILLY CONTROLS NOT WORKING SERVICE REQUIRED Error CODE 520247 31 ERROR CODE 1810 Look up ODI 11444204 at NHTSA ↗ | 318.8%ODI 11530297My Emplyoer has not fixed anything on the truck, the truck shouldn’t be operating, doesn’t meet DOT Regulations, I was told not to go into any scales or weigh stations, loses air and the air doesn’t build back up properly, I lost all air in my breaks while driving on the road Look up ODI 11530297 at NHTSA ↗ | 215.4%ODI 11503055Front end collision with camery hybrid at 35 to 40 mph. Vehicle was rented from Miller Leasing in Hartford CT. Miller ordered truck without Detroit assurance 5.0 or front desk brakes. On collision the screw in air fryer broke off causing loss of brakes. Air dryer was mounted on the frame passenger side exposed to possible damage. After traveling a couple hundred feet the truck smashed the camery in the guardrail and there was a fatality. Look up ODI 11503055 at NHTSA ↗ | 18.3%ODI 11722434while driving a UPS Freightliner truck (Cascadia Vin number [XXX] ) on [XXX] on [XXX] in Charlotte, North Carolina, the tractor brakes locked down causing [XXX] 's arm to jam into shoulder from having all momentum come to abrupt stop causing seatbelt to yank across shoulder ultimately necessitating surgery and putting me out of work for 6 months+ and ongoing INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Look up ODI 11722434 at NHTSA ↗ | 214.3%ODI 11578262All 6 Rotors have circumferential Groves. Dealer refuses to fix the issue. It was dropped for repairs due to lack of proper braking. Dealer road tested unit and stated that everything operates properly. When confronted that groves will get deeper in short period of time and it's a safety issue they still refused to repair. Unit has bumper to bumper warranty for 100k miles. Look up ODI 11578262 at NHTSA ↗ | 00.0%No examples available for this selection. | 133.3%ODI 11757569On May 24, 2026, while driving home from the Ocotillo Wells OHV Recreation Area toward San Diego, California, a drive of roughly 90 miles, a dashboard warning reading "Stability Controls Not Working" illuminated on [XXX] near Warner Springs in San Diego County. The vehicle is a 2026 Freightliner Cascadia chassis carrying a Renegade Classic 43CMD Super C motorhome body. The vehicle was approximately six weeks old with about 3,100 miles. I stopped the vehicle and attempted to clear the fault by cycling the chassis power; the warning did not clear… Look up ODI 11757569 at NHTSA ↗ |
|---|
| Steering | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 318.8%ODI 10721639 · 25,000 miTL* THE CONTACT OWNS A 2015 FREIGHTLINER CASCADIA. WHILE APPROACHING A STOP AT A LOW SPEED, THERE WAS A LOAD ABNORMAL NOISE COMING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE POWER STEERING LINE AND THE HOSE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 15V185000 (SERVICE BRAKES, AIR) BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 25,000. THE VIN WAS UNAVAILABLE… Look up ODI 10721639 at NHTSA ↗ | 325.0%ODI 10983250MULTIPLE VEHICLE RECALLS THAT HAVE COSTED ME THOUSANDS FROM EXCESSIVE OPERATING COST , AND HAVE BEEN ENDANGERING MY LIFE SINCE THE DAY I BOUGHT MY TRACTOR:-( Look up ODI 10983250 at NHTSA ↗ | 111.1%ODI 10926527TL* THE CONTACT OWNED A 2017 FREIGHTLINER CASCADIA. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SWERVE BACK AND FORTH VIOLENTLY. THE WHEELS SEPARATED FROM THE AXLE CAUSING THE VEHICLE TO VEER TO THE RIGHT AND THE FRONT PASSENGER SIDE WHEEL FRACTURED, BUT DID NOT DETACH FROM THE VEHICLE. THE CONTACT MENTIONED THAT THE STEERING ROD SNAPPED AND BECAME LOOSE FROM THE HUB. DURING THE INCIDENT, THE PASSENGER SIDE OF THE VEHICLE ENCOUNTERED THE ROAD AND THE REAR OF THE TRACTOR TRAILER SWERVED AND DID A U-TURN, WHICH CAUSED THE CAB TO CRAS… Look up ODI 10926527 at NHTSA ↗ | 00.0%No examples available for this selection. | 620.7%ODI 11132252 · 10,000 miTRUCK FLOATS/SWAYS SIDE TO SIDE DOWN THE ROAD MAKING IT HARD TO CONTROL AND REQUIRING CONSTANT CORRECTION LEADING TO OVERCORRECTION AND ADDITIONAL SWAYING. TRUCK HANDLES CURVES POORLY. YOU CANNOT GOOD THE STEERING WHEEL IN ONE PLACE AROUND A CURVE, YOU MUST CONSTANTLY REPOSITION/CORRECT THE WHEEL THROUGHOUT THE CURVE. SUSPENSION IS POORLY DESIGNED, CAUSING TOO MUCH MOTION FOR THE DRIVER TO CONSINRESPOND TOO, LEADING TO FATIGUE AND MUSCLE ACHES. THIS IS SPECIFICALLY REGARDING ALL OLD DOMINION FREIGHT LINE 2 AXKE DAYCAB 2019 FREIGHTLINER CASC… Look up ODI 11132252 at NHTSA ↗ | 13.8%ODI 11505866Multiple safety issues with truck #1 When driving & using cruise control (CC) at 60 mph & truck is at that speed (60 mph) truck is moving from top speed to E coast mode. Immediately RPM is down (from 1250 to 600) & steering wheel is much harder b/c reduced power from engine . Response time for driver to avoid potential hazardous situations on the road (i.e. animals, rocks, trees, etc.) is longer & not safe #2 This problem is related to when truck is in regen. In driving, and when truck is doing regen (visible on the dash: high temp light/ ic… Look up ODI 11505866 at NHTSA ↗ | 212.5%ODI 11471285I purchased a new P4 through my employers Lease Purchase program, and when I ordered my new truck, I ordered it with the Hendrickson Air-Ride Suspension Package for the front axle, disc brakes front and rear, and a few other options. My truck required 14 all axle alignment’s before it was driving correctly, after destroying both left & right steer tires. One Freightliner dealer set the right front at 7/16” toe-in, after I threatened to bring legal action against the dealership, only to learn three weeks later, the toe-in was set at 7/16”, which… Look up ODI 11471285 at NHTSA ↗ | 00.0%No examples available for this selection. | 18.3%ODI 11626573The contact owns a 2023 Freightliner Cascadia. The contact stated that while driving at 55 MPH, the steering wheel locked up, the vehicle became uncontrollable, and the vehicle flipped over. The vehicle was uncontrollable. All the warning lights illuminated. A police report was filed. The contact received injuries to her back and was taken by ambulance to a hospital, where medical attention was provided. The airbags deployed. There was an unknown substance leaking from the vehicle. There was no reported fire. The vehicle was towed to an unknown… Look up ODI 11626573 at NHTSA ↗ | 214.3%ODI 11624756 · 92,500 miThe contact owned a 2024 Freight Liner PT. The contact stated while the driver was driving at 64 MPH, the driver heard a pop sound, and the vehicle veered off to the left and crashed into a cement guard rail. The contact stated that the driver was steering in the right direction, however, the vehicle independently veered to the left. The vehicle was towed to the tow yard. The vehicle was deemed totaled by the insurance company. In addition, the contact stated that the same vehicle experienced a similar failure in January 2024. The contact … Look up ODI 11624756 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Forward Collision Avoidance: Automatic Emergency Braking | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 19.1%ODI 11526068The Automatic Emergency Braking System has activated at least 3 different times while I was driving. At each occurrence there was nothing in the roadway or travel lane. The vehicle came to an abrupt stop twice and slammed the brakes on but then released them a moment later once. In each event a very near collision with other vehicles was almost caused. There are other drivers that use this truck that have reported similar events (5 or 6), but I cannot say for certain what the exact circumstances were in those events. This vehicle is available f… Look up ODI 11526068 at NHTSA ↗ | 724.1%ODI 11453359ABS AND TRACTION control failed. Because of this, the $ 7,000 automatic collision avoidance system is not working. 300.000 miles on 2019 truck is just ridiculous. Look up ODI 11453359 at NHTSA ↗ | 934.6%ODI 11326113 · 51,600 miAUTOMATIC EMERGENCY BRAKING SYSTEM ACTIVATING WHEN IT SHOULD NOT BE. COMPANY SAYS TRUCK IS NOT SHOWING A BRAKING EVENT ON THEIR END EITHER THIS HAS HAPPENED ATOTAL OF 3 TIMES. THE TRUCKS LANE GUIDANCE SENSOR IS GOING OFF EVEN WHEN THERE'S NO LINE TO GUIDE IT AND THE TRACTION SENSOR COMES ON EVEN WHEN IT DOESN'T BREAK TRACTION. *TR Look up ODI 11326113 at NHTSA ↗ | 425.0%ODI 11485349This complaint is being filed in addition to my previous complaint which is complaint #1147128511471285. Both left and right vehicle airbag suspension height regulators were just replace a month ago, and once again, the right side airbag ride height regulator has blown apart, causing my semi truck to lean heavily to the right side, and wear out my right front steer tire exceedingly fast. And, the radar braking system erratically slams the brakes on at random times, which could cause a catastrophic accident. Imagine hauling an 80,000 lb. load, … Look up ODI 11485349 at NHTSA ↗ | 430.8%ODI 11445705FYI, this is the second 2022 Cascadia I’ve driven with this issue. The forward radar sensor detects a target 3 feet in front of me and slams on the brakes if the cruise control is set. I can over ride it by turning off the CC, but then I get constant alarms for following too closely and collision alerts. The issue has generated 4 critical events to my company. This happens randomly, with no warning whether I am in traffic or not. I believe this to be a significant safety issue at worst, and a very unpleasant driving environment at best. Accordi… Look up ODI 11445705 at NHTSA ↗ | 325.0%ODI 11516552The CMV was on a straight road on a sunny day approaching a standard railroad crossing, and for no apparent reason the emergency braking system engaged. We have video of this incident from the truck. I tried to download it but your system would not allow the format. Look up ODI 11516552 at NHTSA ↗ | 321.4%ODI 11633128When approaching stopped traffic, sometimes the truck will respond and begin to slow down. At other times, the truck will continue at set speed toward a detected stopped vehicle, and in situations where the time and distance are way too short to justify no reaction by the system. The truck at sometimes acts like it is auto-driving; at others it acts as if it is only in crash-mitigation mode, and will wait for the driver until the last possible second and then slam on brakes. There have been some times where the truck actually gave a collisio… Look up ODI 11633128 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Engine | 423.5%ODI 10924605 · 398,000 miTL* THE CONTACT OWNS A 2012 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT AFTER STOPPING THE VEHICLE, IT WAS DISCOVERED THAT COOLANT LEAKED FROM THE VEHICLE. UPON INSPECTION, IT WAS DETERMINED THAT THE COOLANT RESERVOIR HAD CRACKED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SURGE TANK HAD FAILED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 398,000. THE VIN WAS NOT AVAILABLE. Look up ODI 10924605 at NHTSA ↗ | 00.0%No examples available for this selection. | 216.7%ODI 10704799 · 276,000 miWE WERE ASLEEP IN THE TRUCK WITH THE CURTAINS CLOSED. THE ENGINE WAS RUNNING SMOOTHLY AND THE AIR CONDITIONING WAS BLOWING COLD AIR. WE WERE AWAKENED BY SOMEONE POUNDING ON OUR DOOR. WHEN I OPENED THE CURTAIN, THE LEFT SIDE OF THE WINDSHIELD WAS A SHEET OF FLAMES COMING OUT FROM UNDER THE HOOD. FLAMES WERE ALSO COMING OUT OF THE LEFT SIDE HOOD LATCH ACCESS HOLE AND COVERING THE LEFT SIDE WING WINDOW. WE EXITED THE TRUCK BY THE RIGHT SIDE DOOR AND TOOK A PICTURE OF THE FIRE WITHIN TWO MINUTES OF GETTING OUT. THIS PICTURE IS AVAILABLE. ANOTHER P… Look up ODI 10704799 at NHTSA ↗ | 16.3%ODI 11318785WHEN THE TRUCK WAS PURCHASED THE ODOMETER SAID IT HAD ABOUT 28K MILES ON IT FOR $45K. WELL FOR THE LAST 45 DAYS I HAVE BEEN HAVING ISSUE AFTER ISSUE TO THE POINT WHERE IT WAS SMOKING SO BAD I COULD NOT DRIVE IT ANY LONGER. SO I CALL THE DEALER TO ADVISE THEM THAT TOO MANY ISSUES WERE HAPPENING AND THEY SAID IT WAS NOTHING THEY COULD DO FOR ME. TOOK IT TO FREIGHT LINER DEALERSHIP AND THEY TOLD ME THAT THE ODOMETER ON THE MOTOR WAS 293,662 NOT THE 28K IT WAS SOLD UNDER. NOW THE TRUCKS MOTOR HAS TO BE OVERHAULED WHICH IS $41K ACCORDING TO FREIGHT … Look up ODI 11318785 at NHTSA ↗ | 433.3%ODI 11390543 · 313,882 miI AM A FIRE INVESTIGATOR WITH ONONDAGA COUNTY FIRE INVESTIGATION UNIT. RECENTLY I HAD TWO FIRES WITH SIMILAR VEHICLES BOTH WERE 2016 FREIGHTLINERS CASCADIA 125 BOTH WERE PARKED AND NOT RUNNING AT THE TIME OF THE FIRE EVENTS. BOTH ORIGIN AND CAUSE INVESTIGATIONS APPEARED TO REVEAL A FAILURE/MALFUNCTION AT THE WHAT HAS BEEN DESCRIBED TO ME AS BEING THE POWER DISTRIBUTION MODULAR (PDM). BOTH RESULTED IN THE VEHICLES BEING DESTROYED BY FIRE.*DT*JB*JB*JB*JB*JB Look up ODI 11390543 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 310.3%ODI 11166483VALVE COVER GASKET LEAKING OIL AT 20.000 MILES. VERY HARD STEERING WHEN LOW RPM ( PARKING AND ECO - TRANSMISSION SHIFT TO NEUTRAL AT HIGH SPEED , RESULTING IN LOW RPM. SAFETY PROBLEM IF A TURN IS REQUIRED) BLUETHOOTH IS USELESS. VERY BAD RECEPTION ON THE OTHER END BRAKES : SHIFT SOMETIME TO LEFT OR TO RIGHT, WHEN APLLIED. FUEL GAUGE OFF BY 1/8 OF CAPACITY AND GETTING WORSE Look up ODI 11166483 at NHTSA ↗ | 13.8%ODI 11632316Subject: Complaint Regarding Illegal Practices by Lemberg Group My name is [XXX] , and I am currently employed as a driver for Lemberg Group. I operate a white Freightliner Cascadia truck, unit number [XXX]. I am writing to formally report illegal practices being conducted by Lemberg Group that violate environmental regulations and federal transportation safety laws. These practices not only jeopardize public safety but also put drivers like myself in unsafe and unlawful situations. Company Information: •Company Name: Lemberg Group •USDOT Nu… Look up ODI 11632316 at NHTSA ↗ | 16.3%ODI 11530297My Emplyoer has not fixed anything on the truck, the truck shouldn’t be operating, doesn’t meet DOT Regulations, I was told not to go into any scales or weigh stations, loses air and the air doesn’t build back up properly, I lost all air in my breaks while driving on the road Look up ODI 11530297 at NHTSA ↗ | 17.7%ODI 11622158The flex flang behind the turbocharger has broken off. This lets the hot exhaust gases blow directly onto the underside of the cab and onto electrical wires. And other parts of the truck Look up ODI 11622158 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Unknown Or Other | 423.5%ODI 110038185TH WHEEL LOCKING MECHANICAL DOES NOT LOCK WHEN BACKING UP AND COUPLING TO TRAILER Look up ODI 11003818 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 16.3%ODI 11318785WHEN THE TRUCK WAS PURCHASED THE ODOMETER SAID IT HAD ABOUT 28K MILES ON IT FOR $45K. WELL FOR THE LAST 45 DAYS I HAVE BEEN HAVING ISSUE AFTER ISSUE TO THE POINT WHERE IT WAS SMOKING SO BAD I COULD NOT DRIVE IT ANY LONGER. SO I CALL THE DEALER TO ADVISE THEM THAT TOO MANY ISSUES WERE HAPPENING AND THEY SAID IT WAS NOTHING THEY COULD DO FOR ME. TOOK IT TO FREIGHT LINER DEALERSHIP AND THEY TOLD ME THAT THE ODOMETER ON THE MOTOR WAS 293,662 NOT THE 28K IT WAS SOLD UNDER. NOW THE TRUCKS MOTOR HAS TO BE OVERHAULED WHICH IS $41K ACCORDING TO FREIGHT … Look up ODI 11318785 at NHTSA ↗ | 325.0%ODI 10883788 · 19,000 miJAKE BRAKE HANDLE FALLS FROM OFF POSITION TO ON POSITION OVER BUMPS. ON RT 81 NORTH CRUISE SET AT 60 HIT BUMP MAKE WENT FULL ON THREW ME AGAINST SEATBELT. THANKFULLY DRY ROAD Look up ODI 10883788 at NHTSA ↗ | 111.1%ODI 11643045KNOWN - TAKE OVER OF SLOW LANE FROM PASSING LANE ON FREEWAY RESULTING IN UN LAWFUL TAKE OVER OF SLOW LANE PLEASE ADVISE OF ALL SYSTEMS WORKING PROPERLY ON VIN DESIGNATED THANK YOU Look up ODI 11643045 at NHTSA ↗ | 218.2%ODI 11472396After experiencing numerous issues with Jost 5th wheels, specifically JSK36N model. The Wear ring bolts (NT0000005) are constantly getting loose making the Wear ring (SK 2105-19) move in the 5th wheel plate, what we consider unsafe. While working on hundreds of trucks we have noticed that this is this issue is very popular. The drivers have been complaining about the trailer king pin being loose in the 5th wheel, causing a hit/push on start/stop when driven in combination (truck + trailer). Because of not having the solid connection, the ‘’hi… Look up ODI 11472396 at NHTSA ↗ | 13.4%ODI 11610330My 2019 Freightliner Cascadia forward collision brakes activates automatically while on the road without any other vehicle nearby, airbrake malfunction (not released appropriately and fully released) and extremely fuel consumption. Look up ODI 11610330 at NHTSA ↗ | 415.4%ODI 11326113 · 51,600 miAUTOMATIC EMERGENCY BRAKING SYSTEM ACTIVATING WHEN IT SHOULD NOT BE. COMPANY SAYS TRUCK IS NOT SHOWING A BRAKING EVENT ON THEIR END EITHER THIS HAS HAPPENED ATOTAL OF 3 TIMES. THE TRUCKS LANE GUIDANCE SENSOR IS GOING OFF EVEN WHEN THERE'S NO LINE TO GUIDE IT AND THE TRACTION SENSOR COMES ON EVEN WHEN IT DOESN'T BREAK TRACTION. *TR Look up ODI 11326113 at NHTSA ↗ | 16.3%ODI 11530297My Emplyoer has not fixed anything on the truck, the truck shouldn’t be operating, doesn’t meet DOT Regulations, I was told not to go into any scales or weigh stations, loses air and the air doesn’t build back up properly, I lost all air in my breaks while driving on the road Look up ODI 11530297 at NHTSA ↗ | 323.1%ODI 11445705FYI, this is the second 2022 Cascadia I’ve driven with this issue. The forward radar sensor detects a target 3 feet in front of me and slams on the brakes if the cruise control is set. I can over ride it by turning off the CC, but then I get constant alarms for following too closely and collision alerts. The issue has generated 4 critical events to my company. This happens randomly, with no warning whether I am in traffic or not. I believe this to be a significant safety issue at worst, and a very unpleasant driving environment at best. Accordi… Look up ODI 11445705 at NHTSA ↗ | 18.3%ODI 11640831See attached document for complaint Look up ODI 11640831 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 133.3%ODI 11679210On August 1st, I was travelling on I-44 (a toll road with an 80 mph speed) near Claremont Oklahoma. I was doing 68 mph when a red warning message came up on my dash. It read...KINGPIN RELEASE ACTIVATED. STOP IMMEDIATELY! KINGPIN RELEASED WITHOUT REQUEST. I did not touch my brakes. I gently moved to the the shoulder and coasted to a stop...so as not to put any pressure on the kingpin or fifth-wheel and hoping the weight of the trailer would hold it in place til I could stop. I checked under my truck and the lock was perfectly across the ja… Look up ODI 11679210 at NHTSA ↗ |
|---|
| Forward Collision Avoidance: Warnings | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 18.3%ODI 11476588______________________________________________________________________________ Last October 2021 I bought truck Freightliner Cascadia 2016. Vin # [XXX]. Mileage: 477400. Last my trip I made in May 2022 from Nogales, AZ to Boise, ID When I approaching Ely, NV about 5-8 miles I drive down from the mountain hill . I used speed 25-30 MPH, suddenly my steering wheel was locked and did not made right turn. I used hardly brake because my truck was out of control and pulled forward shoulder out of highway. Only because I hardly used brake I save my li… Look up ODI 11476588 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 413.8%ODI 11453359ABS AND TRACTION control failed. Because of this, the $ 7,000 automatic collision avoidance system is not working. 300.000 miles on 2019 truck is just ridiculous. Look up ODI 11453359 at NHTSA ↗ | 623.1%ODI 11474018Wednesday 13 July, 2022 6:45pm PDT. Location US395 Lakeview, OR. Collision Avoidance System(CAS) applied maximum AEB braking for a false detection of obstruction in my travel lane. I was following a pickup and horse trailer at about 45mph. The pickup signaled a left turn and slowed. I applied minimum braking. The pickup and trailer turned clearing my travel lane(the tail end of the trailer was in the opposing lane). At this moment the CAS detected a collision warning(I was still applying some braking) and the AEB slammed on the brakes for about… Look up ODI 11474018 at NHTSA ↗ | 212.5%ODI 11485349This complaint is being filed in addition to my previous complaint which is complaint #1147128511471285. Both left and right vehicle airbag suspension height regulators were just replace a month ago, and once again, the right side airbag ride height regulator has blown apart, causing my semi truck to lean heavily to the right side, and wear out my right front steer tire exceedingly fast. And, the radar braking system erratically slams the brakes on at random times, which could cause a catastrophic accident. Imagine hauling an 80,000 lb. load, … Look up ODI 11485349 at NHTSA ↗ | 215.4%ODI 11445705FYI, this is the second 2022 Cascadia I’ve driven with this issue. The forward radar sensor detects a target 3 feet in front of me and slams on the brakes if the cruise control is set. I can over ride it by turning off the CC, but then I get constant alarms for following too closely and collision alerts. The issue has generated 4 critical events to my company. This happens randomly, with no warning whether I am in traffic or not. I believe this to be a significant safety issue at worst, and a very unpleasant driving environment at best. Accordi… Look up ODI 11445705 at NHTSA ↗ | 216.7%ODI 11516552The CMV was on a straight road on a sunny day approaching a standard railroad crossing, and for no apparent reason the emergency braking system engaged. We have video of this incident from the truck. I tried to download it but your system would not allow the format. Look up ODI 11516552 at NHTSA ↗ | 428.6%ODI 11633126The cruise control (level 2 autonomous) will turn itself off without any warning sometimes. This happens any time the truck is set for above the speed limit by more than 2 mph. The truck uses a speed limit map, independent of actual posted speed limits. When the truck detects a speed limit drop to below the cruise setting, either real or imagined, the cruise control disengages without any warning or notification. This is a problem when I expect the truck to continue its autonomous function in traffic situations, but it does not, and without… Look up ODI 11633126 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|
| Vehicle Speed Control | 00.0%No examples available for this selection. | 114.3%ODI 10584579 · 1,800 miTL* THE CONTACT OWNS A 2013 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS WITH THE CRUISE CONTROL ON, THE ON GUARD COLLISION SAFETY SYSTEM ENGAGED AND CAUSED THE VEHICLE TO SUDDENLY STOP. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 1,800 AND THE CURRENT MILEAGE WAS 225,546. Look up ODI 10584579 at NHTSA ↗ | 18.3%ODI 10578648 · 1,000 miWITH MERITOR WABCO ONGUARD CRUISE CONTROL EQUIPPED FROM THE FACTORY. THE CRUISE CONTROL UNIT OFTEN TIMES SLAMS ON THE BRAKES AFTER ERRONEOUSLY DETECTING AN IMMINENT COLLISION. IT FREQUENTLY HARD BRAKES AFTER DETECTING ITEMS THAT ARE WELL OUT OF THE TRAVEL PATH OF THE VEHICLE. THIS BEHAVIOR IS NOT PREDICTABLE TO EITHER THE DRIVER OR NEARBY VEHICLES, AND WILL EVENTUALLY LEAD TO A CRASH OR A DANGEROUS SHIFTED LOAD. I HAVE EXPERIENCED THIS IN 4 DIFFERENT FREIGHTLINER CASCADIAS OF RECENT VINTAGE (2012 OR NEWER), ALL EQUIPPED WITH THE ONGUARD CRUISE … Look up ODI 10578648 at NHTSA ↗ | 16.3%ODI 10732665 · 3,000 miTL* THE CONTACT OWNS A 2015 FREIGHTLINER CASCADIA. WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ENGAGED, THE BRAKE PEDAL WAS DEPRESSED AND THE SPEED REDUCED TO 45 MPH AND THEN SUDDENLY ACCELERATED INDEPENDENTLY. THE CONTACT STATED THAT THE CRUISE CONTROL FAILED TO DISENGAGE. AS A RESULT, THE CONTACT LOST CONTROL OF THE VEHICLE. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 3,000. Look up ODI 10732665 at NHTSA ↗ | 00.0%No examples available for this selection. | 111.1%ODI 10926597 · 500 miTHIS COMPLAINT PERTAINS TO ADAPTIVE CRUISE CONTROL (ACC), FORWARD CRASH AVOIDANCE (FCA) AND LANE DEPARTURE WARNING SYSTEMS (LDWS). I HAVE BEEN DRIVING THIS SPECIFIC VEHICLE BUT IT WILL PERTAIN TO ALL VEHICLES WITH THESE SYSTEMS. THE ACC AND FCAS BECAUSE OF ITS STRAIGHT LINE OF SIGHT IS MISINTERPRETING THE DATA ON APPROACH TO BRIDGES, OVERPASSES AND OVERHEAD SIGNS AND WILL INITIATE A HARD BRAKING EVENT ON THE INTERSTATE WHEN NO BRAKING IS REQUIRED CAUSING THE POTENTIAL TO LOSE CONTROL AND FOR A FOLLOWING VEHICLE TO CRASH. THIS PROBLEM WOULD BE … Look up ODI 10926597 at NHTSA ↗ | 327.3%ODI 11366557 · 310,500 miHAD SAME ISSUES ON 2018-2020 FREIGHTLINER CASCADIAS (7 DIFFERENT UNITS), CHASSIS HARNESS RUBBING AGAINST TRANSMISSION AND THE METAL BRACKET BY THE AIR COMPRESSOR. ACTIVE FAULT CODES FOR COOLANT LEVEL , TCS, TRANSMISSION ECU - DRIVERS NOT ABLE TO DRIVE ON AUTOMATIC MODE/ ONLY MANUAL MODE AVAILABLE. ONE TIME THE DRIVER WAS NOT EVEN ABLE TO START THE TRUCK IN THE MORNING, HAD TO GET THE UNIT TOWED TO THE DEALER AND HAVE THE HARNESS REPAIRED. ALL OF THE FAULTS PREVIOUSLY DESCRIBED COULD HAPPEN IN MOTION AND/OR WHEN VEHICLE WAS STATIONARY. Look up ODI 11366557 at NHTSA ↗ | 310.3%ODI 11091048 · 250 miOUR COMPANY SAYS THE 2019 WILL NOT IDLE WHEN IT IS BETWEEN 30 AND 60 DEGREES , WELL PROBLEM IT CAN BE 58 OUTSIDE AND ITS OVER 70 INSIDE, WELL ROLL DOWN THE WINDOWS , YEAH NOW NO SAFETY FOR THE DRIVER, AND WE HAVE WOMAN OUT THERE TO. SO I DONT THING THEY WANT TO BE RAPED, SO IDLING THE TRUCK SHOULD BE UP TO THE DRIVER NOT THE COMPANY. WITH OUT PROPER SLEEP YOU NOW HAVE SLEEP DRIVERS DRIVING 80,000 POUND WEAPONS ON THE FREEWAYS, FIRST PERSON KILLED WILL BE ON YOUR HEADS IF THIS ISNT TAKEN CARE OF. CRASH PERVENTION SYSTEM ALL OK BUT WHEN DRIVIN… Look up ODI 11091048 at NHTSA ↗ | 27.7%ODI 11193866 · 4,766 miTL* THE CONTACT OWNS A 2020 FREIGHTLINER CASCADIA. WHILE DRIVING WITH THE CRUISE CONTROL ENGAGED, THE VEHICLE UNINTENTIONALLY ACCELERATED. ALSO, THE CRASH WARNING ICON ILLUMINATED ALTHOUGH THERE WAS NO OBJECT IN FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO PENSKE TRUCK RENTAL (1405 GLENDALE AVE, SPARKS, NV 89431, [phone removed]) TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURES COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 4,766. CONTACT ALSO ALLEGED LOSS OF P… Look up ODI 11193866 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 18.3%ODI 11535215Dash light warning lights come on and causes the cruise control to stop working. A total of 6 fault lights comes on and also causes the Adaptive Cruise Control to not work. This is the 3rd Freightliner Cascadia that I have driven in the past 3 and a half years and every single truck has had the same problem. Freightliner has refused to acknowledge that there is a problem. Nobody seems to know what to do to correct the problem. We are owner operators and long haul drivers and needcruise control. Freightliner dealers are almost impossible to get … Look up ODI 11535215 at NHTSA ↗ | 642.9%ODI 11633126The cruise control (level 2 autonomous) will turn itself off without any warning sometimes. This happens any time the truck is set for above the speed limit by more than 2 mph. The truck uses a speed limit map, independent of actual posted speed limits. When the truck detects a speed limit drop to below the cruise setting, either real or imagined, the cruise control disengages without any warning or notification. This is a problem when I expect the truck to continue its autonomous function in traffic situations, but it does not, and without… Look up ODI 11633126 at NHTSA ↗ | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. |
|---|