2016 Freightliner SPRINTER 2500: complaints, problems and recalls

TL* THE CONTACT OWNS A 2008 FREIGHTLINER SPRINTER 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V354000 (AIR BAGS); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATE 01/13/16 MA UPDATED 01/25/16.*JB

Look up ODI 10789615 at NHTSA ↗

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 FREIGHTLINER SPRINTER 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V354000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. THE VIN WAS NOT PROVIDED.

Look up ODI 10881831 at NHTSA ↗

I WAS NOTIFIED OF THE RECALL BY MERCEDES. I CALLED THE PHONE NUMBER PROVIDED. MERCEDES GAVE ME THE PHONE NUMBER FOR MERCEDES BENZ OF SOUTHAMPTON TO REPLACE THE FAULTY AIRBAGS. I PROVIDED THEM WITH VIN NUMBER, THEY CONFIRMED THE RECALL, ORDERED PARTS, AND SCHEDULED AN APPOINTMENT. WHEN WE ARRIVED FOR THE APPOINTMENT (MORE THAN AN HOUR'S DRIVE AWAY) MERCEDES BENZ OF SOUTHAMPTON REFUSED TO REPLACE THE DEFECTIVE AIRBAG BECAUSE THIS IS A FREIGHTLINER VAN. MERCEDES BUILT THE VAN, MERCEDES INITIATED THE RECALL, MERCEDES SENT ME TO THE DEALERSHIP. THE…

Look up ODI 11143869 at NHTSA ↗

TAKATA RECALL. WE TOOK SAID VEHICLE TO MERCEDES BENZ, BATON ROUGE, LA OVER 3 WEEKS AGO, MARJORIE REIFF [phone removed]) STATED THAT THE REPLACEMENT HAS TO BE ORDERED AND WOULD LIKE US TO CHECK BACK. WE WENT TO MERCEDES BENZ AGAIN TODAY (02/08/208) AND THE SAME PERSON STATED THAT OUR VEHICLE IS NOT LISTED BUT THE REPLACEMENT HAS TO BE ORDERED AND IT WOULD TAKE ABOUT 30 DAYS TO COME IN. I HAVE UNTIL 02-22-2018 TO GET THIS PROBLEM RESOLVED AND CANNOT GET ANY ASSISTANCE FROM THE DEALERSHIP IN BATON ROUGE, LA. CAN SOMEONE HELP WITH THIS MATTER?

Look up ODI 11071838 at NHTSA ↗

OUR FREIGHTLINER SPRINTER 2500 2010 WITH LESS THAN 31K MILES HAS EXPERIENCED A CONDITION THAT HAS CAUSED THE MIL TO ILLUMINATE. THE ISSUE FROM THE DEALER IS THAT BOTH OF THE NOX SENSORS APPEAR TO HAVE FAILED. FROM ON LINE THREADS REGARDING THIS VEHICLE IT SEEMS THAT MB IS AWARE OF THIS ISSUE. THE ISSUE APPEARS TO BE DEFECTIVE CIRCUITS WITHIN THE NOX MODULE. MB MADE A CHANGE TO THE NOX UNITS AND MODULES TO CORRECT THIS ISSUE, YET THERE APPEARS TO BE NO TSB OR RECALL IN PLACE. THIS REPAIR COSTS APPROXIMATELY $1700.00 FOR BOTH NOX SENSORS/MOD…

Look up ODI 11151572 at NHTSA ↗

Driving down the road in heavy traffic and the lights on the dash came on and the vehicle went into limp mode almost immediately. I lost the ability to accelerate. I pressed the gas pedal and the engine just revved like it was in neutral. It almost caused an accident. lights were engine, traction, abs. Called MB dealer and they advised the wheel sensors had a NTSB warranty extension on the wheel sensors but my vehicle is not covered because the 10 yr warranty extension is up. Is there any way to get them to cover this problem?

Look up ODI 11678762 at NHTSA ↗

The contact's boss owns a 2019 Freightliner Sprinter 2500. The contact stated that the wheel speed sensor wires were corroded. Additionally, the check engine warning light was illuminated. The contact called the local dealer however, the vehicle was not diagnosed nor repaired. The manufacturer was contacted and it was suggested that the vehicle be taken to another state, possibly New York or Pennsylvania for repair. The contact was concerned about driving the vehicle to another state for the repair and stated that it was too expensive to tow. T…

Look up ODI 11451114 at NHTSA ↗

I am experiencing cold start hesitation and unresponsive throttle at high elevation. The vehicle takes up to 20-30 seconds to accelerate, and puts me in a dangerous situation (in a highway intersection, for example). Once the engine temperature is warm, this issue goes away.

Look up ODI 11477168 at NHTSA ↗

LOCATION OF CRUISE CONTROL ARM IS TOO CLOSE TO THE STEERING WHEEL AND TURN SIGNAL ARM. ACCIDENTAL ACTIVATION IS LIKELY AND HAS OCCURRED DURING NORMAL OPERATION OF THE VEHICLE BY EITHER ACCIDENTAL CONTACT OF THE LEFT HAND WHILE STEERING OR WHILE ATTEMPTING TO OPERATE THE TURN SIGNAL. THIS CONDITION IS COMPOUNDED BY THE ORIENTATION OF THE CRUISE CONTROL ARM, WHERE AN UP OR DOWN MANIPULATION WILL 'SET' OR 'RESUME' THE CRUISE SPEED, BOTH OF WHICH CAN ACTIVATE THE CRUISE SYSTEM. SUCH MANIPULATION (UP OR DOWN) IS MOST LIKELY TO OCCUR DUE TO THE…

Look up ODI 10609711 at NHTSA ↗

Vehicle was driving fine, then warning lights that ABS system was no longer functioning, cruse control inoiperable, "go to shop immediatly" with no apparent cause. I took it to a shop and they attached the electronic scanner which indicated "Front Right Speed Sensor failed". This is the second speed sensor that I have had replaced this year (the first was one of the rear speed sensors). I replaced the front right speed sensor this morning, but the system has not reset. I hate to drive the vehicle with the warnings still indicated and cruise …

Look up ODI 11538211 at NHTSA ↗

The contact owns a 2016 Freightliner Sprinter 2500. The contact stated that while driving at various speeds, the rear wheels would brake independently; as the failure persisted, the ABS warning light would illuminate on the instrument panel. The contact called the dealer; however, they could not grant a soon enough appointment. The contact stated that as he was coming to a stop with his foot on the brake pedal, the vehicle independently accelerated as the contact slammed on the brake pedal. He was then forced to swerve out of the way of the veh…

Look up ODI 11442305 at NHTSA ↗

The contact owns a 2019 Freightliner Sprinter 2500. The contact received notification of NHTSA Campaign Number: 23V100000 (Visibility, Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Look up ODI 11521162 at NHTSA ↗

Transmission problem

Look up ODI 11452010 at NHTSA ↗

I NEED TO KNOW IF THE RECALL FOR THE DRIVER SIDE AIR BAG WAS IN EFFECT BECAUSE THIS IS SOMETHING VERY SERIOUS. MY HUSBAND DRIVES THIS VEHICLE EVERYDAY AND I WOULDN'T WANT A DEPOLYMENT OF THE BAG DUE TO A RUPTURE AND HE WOULD BE HURT. HOW DO I FIND OUT IF IT WAS DONE? I READ ABOUT THIS ON A TELEVISION INVESTIGATION AND IT MAKES ME NERVOUS.

Look up ODI 10971927 at NHTSA ↗

My vehicle is having massive DPF filter issues I paid for it to be fixed and Mercedes fixed the DEF system under warranty but right before the warranty expired some how the DPF filter "was broke" I feel like Mercedes should have fixed it while it was under warranty but they did not. I asked for a good will repair and they refused. They wanted to charge me $6k for repairs and I could only take it to them. No one else could repair it. Finally I was getting sick from driving it with the massive emissions issues so I took it to an independent diese…

Look up ODI 11763739 at NHTSA ↗

COLOR INSTRUMENT CLUSTER INCLUDING COLOR DISPLAY BETWEEN THE SPEEDOMETER AND TACHOMETER WILL NOT DIM AT NIGHT. THE RESULTING WASH OF LIGHT MAKES SEEING OUT THE SIDE MIRRORS OR ANYTHING AT NIGHT VERY DIFFICULT. VAN IS NOT SAFE TO DRIVE AT NIGHT. MANUFACTURE CONFIRMS THE PROBLEM BUT HAS NO FIX.

Look up ODI 11389057 at NHTSA ↗

Hello. I’m complaining about CWA ( cross wind assist) . Everyone knows and internet groups are full of information about this issue. The CWA is not safe , it’s dangerous on the road and can suddenly brake check another vehicle behind you or can throw you to oncoming traffic lane. The system also applies brakes when passing under bridges or road signs that are across the road. This system is dangerous and needs to be recalled for the safety reasons.

Look up ODI 11733238 at NHTSA ↗

LOCATION OF CRUISE CONTROL ARM IS TOO CLOSE TO THE STEERING WHEEL AND TURN SIGNAL ARM. ACCIDENTAL ACTIVATION IS LIKELY AND HAS OCCURRED DURING NORMAL OPERATION OF THE VEHICLE BY EITHER ACCIDENTAL CONTACT OF THE LEFT HAND WHILE STEERING OR WHILE ATTEMPTING TO OPERATE THE TURN SIGNAL. THIS CONDITION IS COMPOUNDED BY THE ORIENTATION OF THE CRUISE CONTROL ARM, WHERE AN UP OR DOWN MANIPULATION WILL 'SET' OR 'RESUME' THE CRUISE SPEED, BOTH OF WHICH CAN ACTIVATE THE CRUISE SYSTEM. SUCH MANIPULATION (UP OR DOWN) IS MOST LIKELY TO OCCUR DUE TO THE…

Look up ODI 10609711 at NHTSA ↗

Driving down the road in heavy traffic and the lights on the dash came on and the vehicle went into limp mode almost immediately. I lost the ability to accelerate. I pressed the gas pedal and the engine just revved like it was in neutral. It almost caused an accident. lights were engine, traction, abs. Called MB dealer and they advised the wheel sensors had a NTSB warranty extension on the wheel sensors but my vehicle is not covered because the 10 yr warranty extension is up. Is there any way to get them to cover this problem?

Look up ODI 11678762 at NHTSA ↗

Vehicle was driving fine, then warning lights that ABS system was no longer functioning, cruse control inoiperable, "go to shop immediatly" with no apparent cause. I took it to a shop and they attached the electronic scanner which indicated "Front Right Speed Sensor failed". This is the second speed sensor that I have had replaced this year (the first was one of the rear speed sensors). I replaced the front right speed sensor this morning, but the system has not reset. I hate to drive the vehicle with the warnings still indicated and cruise …

Look up ODI 11538211 at NHTSA ↗

The contact owns a 2016 Freightliner Sprinter 2500. The contact stated that while driving at various speeds, the rear wheels would brake independently; as the failure persisted, the ABS warning light would illuminate on the instrument panel. The contact called the dealer; however, they could not grant a soon enough appointment. The contact stated that as he was coming to a stop with his foot on the brake pedal, the vehicle independently accelerated as the contact slammed on the brake pedal. He was then forced to swerve out of the way of the veh…

Look up ODI 11442305 at NHTSA ↗

On May 22, 2023 around 19:00 after driving my vehicle for nearly 90 minutes the vehicle no longer responded to the gas pedal being depressed by increasing acceleration. The vehicle would not go over 2,500 RPMs even with the gas pedal fully depressed. No warning were shown on the driver display or in the messaging system. The manual gear shifting did not work to raise or lower the gears while the vehicle was in this state. The vehicle display showed the vehicle in "D" for Drive and I could not change it to any other value such as D1, D2, etc…

Look up ODI 11523457 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 FREIGHTLINER SPRINTER 2500. THE CONTACT STATED THAT OIL WAS SPILLING FROM THE ENGINE COMPARTMENT ONTO THE ROAD SURFACE. THE CONTACT INDICATED THAT UP FIVE QUARTS OF OIL WOULD SPILL OUT EVERY SEVEN DAYS. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V294000 (FUEL SYSTEM). THE CONTACT INDICATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 288,000.

Look up ODI 10761446 at NHTSA ↗

The contact owns a 2016 Freightliner Sprinter 2500. The contact stated that while driving at various speeds, the rear wheels would brake independently; as the failure persisted, the ABS warning light would illuminate on the instrument panel. The contact called the dealer; however, they could not grant a soon enough appointment. The contact stated that as he was coming to a stop with his foot on the brake pedal, the vehicle independently accelerated as the contact slammed on the brake pedal. He was then forced to swerve out of the way of the veh…

Look up ODI 11442305 at NHTSA ↗

DRIVER PARKED ON A HILL AND PUT THE VAN IN PARK. EXITED THE VEHICLE AND WAS OUT OF THE VEHICLE 15 SECS BEFORE HE HEARD A POP AND A GRIND AND SMELLED AN ODOR. HE TURNED AND WATCHED HIS VAN ROLL DOWN A HILL INTO TWO PARKED CARS. IT WAS PARK (STATIONARY) ON A CITY STREET AND UNOCCUPIED.

Look up ODI 11360505 at NHTSA ↗

I WAS DELIVERY FOR DHL FOR 5 HOURS PIER TO THE ACCIDENT. I WAS ON A CITY STREET IN UPPER CHI-CHESTER, PA. WHEN I TRIED TO YIELD AND PREPARE FOR A STOP SIGN. WHEN I WENT TO APPLY THE BREAKS AND ADDED MORE PRESSURE TO THE BREAKS THEY JUST THEN DROPPED THE FLOOR. I THEN TRIED TO PUMP THE BREAKS, STILL NOTHING, NO BREAKS. FROM NOT BEING ABLE TO STOP AT THE STOP SIGN, I WENT THROUGH THE INTERSECTION CAUSING AN ACCIDENT. AFTER RESEARCHING ONLINE, I HAVE FOUND THAT THESE VEHICLES HAVE ALOT OF BREAK PROBLEMS AND A NUMBER OF REPORTS THAT SHOWN BRE…

Look up ODI 10817731 at NHTSA ↗

Vehicle was driving fine, then warning lights that ABS system was no longer functioning, cruse control inoiperable, "go to shop immediatly" with no apparent cause. I took it to a shop and they attached the electronic scanner which indicated "Front Right Speed Sensor failed". This is the second speed sensor that I have had replaced this year (the first was one of the rear speed sensors). I replaced the front right speed sensor this morning, but the system has not reset. I hate to drive the vehicle with the warnings still indicated and cruise …

Look up ODI 11538211 at NHTSA ↗

Multiple Episodes of vigorous Sudden Application of Active Brake Assist, sometimes with a sudden dip, occasionally without a noticeable inciting issue. Often Occurs at Hiway speeds, on a narrow bridge with car slowing to 5 mph. At low speeds break assist may turn off and able to resume driving, sometimes requires restart of engine to clear brake assist. Drivers following behind are not happy when this unexpectedly happens, very unsafe. Atteeempts to deal with it through dealer have been unsuccessful or dis,issued.

Look up ODI 11543624 at NHTSA ↗