1999 Holiday Rambler ENDEAVOR: complaints, problems and recalls

MICHELIN TIRES 235/80R-XRV TIRES...THREE BLOWOUTS, BLOW AWAY A SIDE PANEL OF MOTORHOME. NO RESPONSE FROM ANY MANUFACTURER MONACO AND/OR MICHELIN. ONLY CHECK YOUR PRESSURES. WELL STOPPING AT EACH AND EVERY REST AREA TO CHECK PRESSURES AND STILL EXPERIENCING BLOWOUTS. IN ONE TRIP. WANT TO SELL MOTORHOME AFRAID TO DRIVE DOWN TO GAS STATION TO FUEL UP TO TAKE TO DEALER TO SELL. NEED TO REPLACE ALL TIRES AND COST $2,000.00. HAVE OWNED MOTORHOMES FOR OVER 30 YEARS AND FIRST TIME HAVE EVER HAD ANY PROBLEMS. I CAN SEE HOW THE INDUSTRY REACTS WHEN, JUST…

Owner-reported narrative. 48,000 miles reported. Look up ODI 10081081 at NHTSA ↗

1999 HOLIDAY RAMBLER EXPERIENCED A BLOW OUT. *MR *SC

Owner-reported narrative. Look up ODI 10134479 at NHTSA ↗

DT*: THE CONTACT STATED THAT ON THE FRONT AXLE THERE IS NO CENTER BOLT, ALLOWING THE FRONT AXLE AND SPRING TO SLIP FORWARD AND BACKWARD. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER WAS UNABLE TO REPAIR THE PROBLEM. THE MANUFACTURER WAS CONTACTED, BUT WAS UNWILLING TO ASSIST WITH THE PROBLEM. SECONDLY, THERE IS A SHIFTING OF THE DOOR BETWEEN THE BATHROOM AND THE KITCHEN, PREVENTING CLOSURE OF THE DOOR. THIS IS ACCOMPANIED BY A THUMPING NOISE IN THE FLOOR. THERE IS A NHTSA RECALL# 02V237000. THE VEHICLE HAS NOT BEEN INCLUDE…

Owner-reported narrative. 36,000 miles reported. Look up ODI 10160426 at NHTSA ↗

TL*THE CONTACT OWNS A 1999 HOLIDAY RAMBLER ENDEAVOR. WHILE DRIVING AT 60 MPH, THE CONTACT APPLIED HIS FOOT TO THE BRAKE PEDAL AND THE VEHICLE BEGAN TO JERK FROM THE RIGHT TO THE LEFT. THE FAILURE MADE IT DIFFICULT TO CONTROL THE STEERING. THE CONTACT NOTICED THE FAILURE EVERY TIME HE APPLIED HIS FOOT TO THE BRAKE FIRMLY. THE VEHICLE WAS TAKEN TO THE DEALERSHIP THREE TIMES. THE FIRST TIME, THE DEALER CHECKED THE WHEEL BEARINGS, THE SECOND TIME, THE DEALER GREASED AND INSPECTED THE BRAKE CAM AND THERE WERE NO REPAIRS PERFORMED THE THIRD TIME AS T…

Owner-reported narrative. 36,000 miles reported. Look up ODI 10328242 at NHTSA ↗

THE VEHICLE SHUTS DOWN WITHOUT WARNING WHILE DRIVING IN HEAVY RAIN, CONSUMER FEELS THAT THE CAUSE IS WATER SOAKING THE ENGINE AIR INTAKE WHICH IS LOCATED AT THE BOTTOM OF THE FILTER ASSEMBLY NEAR THE ROADWAY. * MJS

Owner-reported narrative. Look up ODI 557714 at NHTSA ↗

THE DEALER NEVER DISCLOSED THAT THE VEHICLE THEY PURCHASED WAS A BUY BACK THROUGH THE LEMON LAW, THE VEHICLE WAS NEVER REPAIRED PRIOR TO THE CONSUMERS PURCHASING IT, THE VEHICLE WOULD STALL WIHOUT WARNING, THE CONSUMER REQUESTED THAT THE DEALER EXTEND THE WARRANTY BUT THEY REFUSED. NLM

Owner-reported narrative. Look up ODI 560066 at NHTSA ↗

CONSUMER STATES THAT THE AIR BAGS ON THE SIDE BLEW WHILE DRIVING. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. NLM

Owner-reported narrative. Look up ODI 8019311 at NHTSA ↗

ODOMETER & TRIP ODOMETER ARE HARD TO READ IN DAYLIGHT. AN ACCIDENT COULD OCCUR AS YOU HAVE TO TAKE EYES OF THE ROAD TOO LONG TO TRY AND READ MILEAGE.

Owner-reported narrative. Look up ODI 9003037 at NHTSA ↗

Reported: 2000-10-19 (October 19, 2000)

VEHICLE DESCRIPTION: MOTOR COACHES PRODUCED ON ROADMASTER CHASSIS AND DIESEL CLASS A MOTOR COACHES PRODUCED ON FREIGHTLINER CHASSIS. THE FEDERAL CERTIFICATION LABEL CONTAINS THE INCORRECT TIRE PRESSURE INFLATION INFORMATION. THIS DOES NOT COMPLY WITH REQUIREMENTS OF PART 567, "CERTIFICATION" AND FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence: UNDER OR OVER-INFLATED TIRES CAN CAUSE OR CONTRIBUTE TO PREMATURE TIRE FAILURE, POSSIBLY RESULTING IN A SUDDEN BLOWOUT OR OTHER FAILURE WHICH COULD RESULT IN A LOSS OF CONTROL OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE CERTIFICATION LABEL WITH A NEW LABEL, WHICH CONTAINS THE CORRECT RECOMMENDED TIRE INFLATION DATA.

Reported: 2002-09-09 (September 9, 2002)

ON CERTAIN CLASS A MOTOR HOMES, THE FLOOR TRUSS NETWORK SUPPORT SYSTEM HAS A POTENTIAL TO WEAKEN CAUSING INTERNAL AND EXTERNAL FEATURES TO BECOME MISALIGNED. THE AFFECTED VEHICLES ARE 1999 - 2003 CLASS A MOTOR HOMES MANUFACTURED ON F53 20,500 POUND GROSS VEHICLE WEIGHT RATING (GVWR), FORD CHASSIS, AND 2000-2003 CLASS A MOTOR HOMES MANUFACTURED ON W-22 22,000 POUND GVWR, WORKHORSE CHASSIS.

Consequence: CONDITIONS CAN RESULT IN THE BOTTOMING OUT THE SUSPENSION AND AMPLIFICATION OF THE STRESS PLACED ON THE FLOOR TRUSS NETWORK. THE ADDITIONAL STRESS CAN RESULT IN THE FRACTURE OF WELDS SECURING THE FLOOR TRUSS NETWORK SYSTEM TO THE CHASSIS FRAME RAIL AND/OR FRACTURE OF THE FLOOR TRUSS NETWORK SUPPORT SYSTEM. THE POSSIBILITY EXISTS THAT THERE COULD BE DAMAGE TO ELECTRICAL WIRING AND/OR FUEL LINES WHICH COULD POTENTIALLY LEAD TO A FIRE.

Remedy: DEALERS WILL INSPECT THE FLOOR TRUSS NETWORK SUPPORT SYSTEM, REINFORCE THE EXISTING STRUCTURE, AND REPAIR, AS NEEDED, THE FLOOR TRUSS NETWORK SUPPORT. OWNER NOTIFICATION BEGAN NOVEMBER 5, 2002. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2003-05-08 (May 8, 2003)

ON CERTAIN MOTORHOMES, FIFTH WHEELS AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM, THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK.

Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUALLY OPERATED, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: NORCOLD WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPLACEMENT COOLING UNIT FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-667-3005 OR MONACO AT 574-862-7211.