2018 Keystone COUGAR: complaints, problems and recalls

2013 KEYSTONE COUGAR TRAILER. CONSUMER WRITES IN REGARDS TO TIRE FAILURE. *SMD THE CONSUMER NOTICED AS HE WAS DRIVING, HE NOTICED THAT ONE OF THE RIGHT SIDE TRAILER TIRES WERE SHREDDING. WHEN HE WAS FINALLY ABLE TO STOP, HE DISCOVERED THE TIRE WAS LOOSING AIR AND THE TREAD HAS COMPLETELY SEPARATED FROM THE CASING AND THE SIDEWALL WAS STILL INTACT. THERE WAS EXTENSIVE DAMAGE TO THE SHEET METAL AND DUAL AXLES. *JB

Look up ODI 10807027 at NHTSA ↗

I BOUGHT THIS KEYSTONE TRAILER NEW IN AUGUST OF 2020. THE TIRES ONLY HAD 400 MILES OF USE BEFORE THIS TRIP. I EQUIPPED MY TRAILER WITH TIRE MINDER SYSTEM TO MONITOR TIRE PRESSURE AND TEMPERATURE. THERE WAS NO WARNING OF TIRE FAILURE. THE TIRE JUST EXPLODED AND CAME APART. DAMAGING MY TRAILER.

Look up ODI 11386578 at NHTSA ↗

THERE ARE 2 FOLD OUT COACHES ON THE TRAILER WITH AIR MATTRESS' FOR THE PAD. WE HAVE NOT BEEN ABLE TO HAVE EITHER AIR MATTRESS STAY INFLATED OVER NIGHT SINCE WE BOUGHT IT. ONE OF THEM LEAKS THROUGH THE OUTLET TO DEFLATE IT AND WE HAVE TO PUT A CELLOPHANE BAGGIE UNDER THE CAP TO KEEP IT UP PART OF THE NIGHT. THE OTHER AIR MATTRESS HAS ONE CORNER THAT THE WAS FOLDED OVER WHEN IT WAS MADE (THE MATERIAL IS DOUBLED OVER) AND THERE IS A LEAK THERE. WE HAVE TRIED EVERY PATCH MADE AND CANNOT GET THE LEAK STOPPED BECAUSE IT IS ON THE EDGE. THE OTHER…

Look up ODI 10620648 at NHTSA ↗

The contact owns a 2017 Keystone Cougar Trailer. The contact stated that the slide island was leaning and the flooring in the middle of the RV was unstable. The RV was taken to the local service center, which discovered that three cross members had separated from the frame of the RV and caused severe damage to the frame. The cause of the failure was not yet determined. The contact was advised that the RV frame was unrepairable. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN wa…

Look up ODI 11688194 at NHTSA ↗

The contact owns a 2018 Keystone Cougar Trailer. The contact stated that the spring hangers fractured without warning. The contact received notification of NHTSA campaign number: 21V380000 (Suspension, Structure) however, the part to do the recall was unavailable. The vehicle was taken to the local dealer who stated that parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified and informed the contact to take the vehicle to a Keystone dealer …

Look up ODI 11431251 at NHTSA ↗

The contact owns a 2019 Keystone Cougar. The contact stated that upon exiting the vehicle, the contact noticed that the fiberglass outside of one of the rear slides was cracked. The vehicle was taken to a local dealer where it was diagnosed with the fiberglass needing to be replaced. The vehicle was repaired but the failure recurred a year later. The contact then received notification of NHTSA campaign number: 21V380000 (Suspension, Structure) and was relating the failure to the recall. The manufacturer had been informed of the failure and refe…

Look up ODI 11426127 at NHTSA ↗

The contact owns a 2020 Keystone Cougar RV. The contact stated that the side panels of the camper were detaching at the corners. The contact stated that her husband inspected the chassis of the camper and noticed that the chassis was severely corroded and fractured. The dealer was notified of the failure and referred the contact to the manufacturer. The RV was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 21V380000 (Structure, Suspension); however, the VIN was not included. The manufacturer was notified o…

Look up ODI 11553087 at NHTSA ↗

The contact owns a 2023 Keystone Cougar. The contact stated that the emergency exit window casing was too long and the inside window glass did not fit evenly. The contact stated that the window casing was unusually wider than the frame unit. The contact received recall NHTSA Campaign Number: 23V169000 (Structure). The recall repair was completed. However, excessive caulking and screws were applied, and the recall repair was not completed proficiently. The manufacturer was made aware of the failure but provided no assistance. The failure mileag…

Look up ODI 11579994 at NHTSA ↗

The domestic refrigerator on this 2016 KEYSTONE RV caught on fire while traveling.

Look up ODI 11578572 at NHTSA ↗

The contact owns a 2019 Keystone Cougar. The contact stated while driving 60 mph, the draining tank hose fractured and detached from the RV on the passenger side. The contact stated there was no warning light illuminated. The vehicle was not taken to the local dealer nor the independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was informed of the failure. The approximate failure mileage was 5,000.

Look up ODI 11421160 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 KEYSTONE COUGAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE REAR DRIVER'S SIDE CORNER PANEL DETACHED FROM THE VEHICLE. THE CONTACT NOTICED THAT THE REAR DRIVER SIDE AXLE WAS SEVERELY DAMAGED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 1,200.

Look up ODI 10607193 at NHTSA ↗

TL* THE CONTACT OWNS A 2013 KEYSTONE COUGAR. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE REAR BUMPER BEGAN TO SEPARATE FROM THE VEHICLE OVER THE COURSE OF A TWO HOUR DRIVE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE BUMPER WOULD HAVE TO BE RE-ATTACHED. THE VEHICLE WAS REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 120. UPDATED 06/10/13 *BF UPDATED 06/14/2013*JS

Look up ODI 10509288 at NHTSA ↗

WAS DRIVING ON 10 FREEWAY IN CALIFORNIA WAS MOTIONED BY A PASSING CAR THAT WE HAD A PROBLEM WITH SPARE TIRE ON THE BACK OF OUR RV FIFTHWHEEL. WHEN WE PULLED OVER THE SPARE TIRE WAS NEARLY ON THE GROUND. THE BUMPER WHICH HOLDS THE SPARE TIRE HAD BASICALLY RIPPED AND WAS PEELING AWAY( FROM THE WELDS )AND WAS JUST BARELY HOLDING ON. WHEN WE BOUGHT THE FIFTHWHEEL (BRAND NEW, NOT USED) WE DID NOT ADD OR CHANGE ANYTHING. WE FOUND RECALLS ON THIS EXACT THING,BUT WHEN NOTIFING KEYSTONE ALL THEY WOULD SAY WAS IT WAS OUT OF WARRANTY AND RECALL NOT GOOD…

Look up ODI 11115549 at NHTSA ↗

I JUST BOUGHT A NEW 5TH WHEEL COUGAR TRAVEL TRAILER LAST MAY. THE WHOLE BOTTOM FRAME IS BENDING AND DEGRADING BECAUSE I SUSPECT IT WAS MADE WITH CHEAP CHINESE STEEL. THE MANUFACTURER REFUSES TO TAKE RESPONSIBILITY FOR THE ISSUE AND IS BLAMING IT ON HITTING THE CURB WHICH IS PHYSICALLY IMPOSSIBLE. OTHER PEOPLE ON-LINE COMPLAIN OF SIMILAR FRAME FAILURE. THE RV INDUSTRY IS NOT PROPERLY REGULATED AND A CATASTROPHIC FAILURE OF THIS FRAME COULD POTENTIALLY CAUSE DEATH AND INJURY. I DO NOT FEEL SAFE IN THAT THING AND I JUST PURCHASED IT. PLEASE I…

Look up ODI 11072727 at NHTSA ↗

COMPANY DEFECT TANDEM AXLES ARE NOT PARALLEL WITH ONE ANOTHER BY 1.5" THIS MAKES A BIG SAFETY ISSUE FOR MY FAMILY AND EVERY ONE ON THE ROADS! COMPANY REFUSES TO FIX THE ISSUE THEY SAID ITS WITHIN SPECS. THE CAMPER PULLS LEFT ALL THE TIME WHEN TOWING. THE FRONT TANDEM AXLE IS TURNING LEFT BY 1.5"

Look up ODI 11376928 at NHTSA ↗

On XXX between 11 am to 2pm, I was driving [XXX] to [XXX], via [XXX], and at rest area [XXX], I stopped for fueling truck and getting something to eat with family. After stopping at the parking site for trailer, I noticed that the RV box on the front above the gooseneck, was touching the top of my truck trunk. I use a fifth wheel gooseneck and tow from the center of my truck/trunk bed, and we usually have about 2 inch gap between rv and truck, but at this time there was no gap, the weight of RV was on top the truck back side panels. The Lipper…

Look up ODI 11755033 at NHTSA ↗

There was a bulge showing near the front of the camper, dealer inspected and said there is frame flex, possibly broken welds on the frame, which is a common problem with the lippert manufactured frames. Model years directly before this year(2022) were recalled for the same problem. This seems to be a common issue for 2022 models as well but there still is no safety recall despite the inherent risk of them being on the road.

Look up ODI 11661037 at NHTSA ↗

Camping world Hamburg delivered to me fifth wheel they Ammit they did not have inspected causing Catastrophic structural frame failure and pin-box cross-member buckling (Frame Flex) engineered within the upper deck chassis frame. This structural failure has caused widespread, secondary body panel collapse, including deep spiderweb fractures tearing through the upper fiberglass radius wall paneling, vertical trim moldings violently warping and splitting open, and the upper passenger-side roof cap seam ripping completely open. The failed componen…

Look up ODI 11756974 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 KEYSTONE COUGAR FIFTH WHEEL. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE FRONT DRIVER'S SIDE LEAF SPRING FRACTURED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE ONE LEAF SPRING OUT THE FOUR WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300. UPDATED 7/31/13 *CN THE CONSUMER STATED WHILE TOWING THE RV AT HIGHWAY SPEED, THE LEFT FRONT LEAF SPRING BROKE AND CAUSED THE AXLE TO BREAK AS WELL. UPDATED 08/06/13

Look up ODI 10523629 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 KEYSTONE COUGAR FIFTH WHEEL. WHILE DRIVING 60 MPH, THE HANGER THAT HELD THE DRIVER SIDE SPRING DETACHED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

Look up ODI 10865643 at NHTSA ↗

TL* THE CONTACT OWNS A 2016 KEYSTONE COUGAR. WHILE DRIVING APPROXIMATELY 63 MPH, THE REAR DRIVER SIDE WHEEL FRACTURED WITHOUT WARNING. DUE TO THE FAILURE, THE FRONT PASSENGER SIDE TIRE FLATTENED. THE VEHICLE WAS TOWED AND HAD TO BE DRIVEN LESS THAN 20 MPH. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP FOR INSPECTION. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.

Look up ODI 10906328 at NHTSA ↗

The contact owns a 2018 Keystone Cougar Trailer. The contact stated that the spring hangers fractured without warning. The contact received notification of NHTSA campaign number: 21V380000 (Suspension, Structure) however, the part to do the recall was unavailable. The vehicle was taken to the local dealer who stated that parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified and informed the contact to take the vehicle to a Keystone dealer …

Look up ODI 11431251 at NHTSA ↗

TL* THE CONTACT OWNS A 2019 KEYSTONE COUGAR TRAVEL TRAILER. WHILE TRAVELING TO A CAMPGROUND, THE DEXTER AXLE FAILED AND THE REAR PASSENGER SIDE WHEEL DETACHED. THE TRAILER WAS LEFT AT THE CAMPGROUND AND WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. *DT*TP CONSUMER STATED THE RECALL IS SAFETY NOTICE 19-340. DEXTER AXLE INNER BEARING INSUFFICIENT GREASE AFFECTING MODELS WITH D44 AXLES - COUGAR 22. RBS…

Look up ODI 11240550 at NHTSA ↗

The contact owns a 2020 Keystone Cougar RV. The contact stated that the side panels of the camper were detaching at the corners. The contact stated that her husband inspected the chassis of the camper and noticed that the chassis was severely corroded and fractured. The dealer was notified of the failure and referred the contact to the manufacturer. The RV was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 21V380000 (Structure, Suspension); however, the VIN was not included. The manufacturer was notified o…

Look up ODI 11553087 at NHTSA ↗

Camping world Hamburg delivered to me fifth wheel they Ammit they did not have inspected causing Catastrophic structural frame failure and pin-box cross-member buckling (Frame Flex) engineered within the upper deck chassis frame. This structural failure has caused widespread, secondary body panel collapse, including deep spiderweb fractures tearing through the upper fiberglass radius wall paneling, vertical trim moldings violently warping and splitting open, and the upper passenger-side roof cap seam ripping completely open. The failed componen…

Look up ODI 11756974 at NHTSA ↗

WAS DRIVING ON 10 FREEWAY IN CALIFORNIA WAS MOTIONED BY A PASSING CAR THAT WE HAD A PROBLEM WITH SPARE TIRE ON THE BACK OF OUR RV FIFTHWHEEL. WHEN WE PULLED OVER THE SPARE TIRE WAS NEARLY ON THE GROUND. THE BUMPER WHICH HOLDS THE SPARE TIRE HAD BASICALLY RIPPED AND WAS PEELING AWAY( FROM THE WELDS )AND WAS JUST BARELY HOLDING ON. WHEN WE BOUGHT THE FIFTHWHEEL (BRAND NEW, NOT USED) WE DID NOT ADD OR CHANGE ANYTHING. WE FOUND RECALLS ON THIS EXACT THING,BUT WHEN NOTIFING KEYSTONE ALL THEY WOULD SAY WAS IT WAS OUT OF WARRANTY AND RECALL NOT GOOD…

Look up ODI 11115549 at NHTSA ↗

THE SPARE TIRE HOLDER MOUNTED ON THE REAR BUMPER BROKE WHILE TRAVELING ON THE INTERSTATE AT 70 MPH IN HEAVY TRAFFIC. WE WERE SHOCKED TO SEE HOW LIGHT IT WAS MADE AFTER IT BROKE. NO INJURIES HAPPEN BUT THIS COULD HAVE EASILY TURNED OUT DIFFERENTLY. WE DID NOT FIND OUR SPARE TIRE.

Look up ODI 10885387 at NHTSA ↗

The domestic refrigerator on this 2016 KEYSTONE RV caught on fire while traveling.

Look up ODI 11578572 at NHTSA ↗

WE HAVE TWO ISSUES WITH THE FIFTH WHEEL CAMPER IN QUESTION. WE ONLY FELT IT NECCESARY TO CONTACT THE NHTSA BECAUSE THE MANUFACTURER REFUSED TO REMEDY THE OBVIOUS PROBLEM WHEN WE WERE AT AN AUTHORIZED SERVICE CENTER AND ASKED THEM TO IN THE INTEREST OF OUR SAFETY AND THAT OF OTHER MOTORISTS. THE FIFTH WHEEL CAME WITH THE WRONG SIZE WHEEL AND TIRE WITH THREE BEING LARGER TIRES ON 16' RIMS AND ONE BEING A SMALLER TIRE ON A 15' RIM. IT CAUSED THE UNIT WHICH IS A 40' LONG FIFTH WHEEL. A NEW UNIT FROM THE DEALER. WHEN WE REALIZED WHAT WAS GOING ON WE…

Look up ODI 11033482 at NHTSA ↗

Spontaneous increase in propane supply levels causing heating equipment to overheat. No inspection has taken place because manufacturer cites lack of replacement parts for warranty replacement.

Look up ODI 11459460 at NHTSA ↗

Vehicle is a 2022 Keystone Cougar 29RLI recreational vehicle. Safety issue is with the Solara awnings manufactured by Lippert. Awning fabric appeared to only be glued to the poly cord that secures it to the trailer. While we were setup, the awning roller fell away from the trailer. If we had been in transit, it could have hit a car in an adjacent lane, causing an accident. The rear awning is also failing but is still mostly in tact.

Look up ODI 11472233 at NHTSA ↗

Camping world Hamburg delivered to me fifth wheel they Ammit they did not have inspected causing Catastrophic structural frame failure and pin-box cross-member buckling (Frame Flex) engineered within the upper deck chassis frame. This structural failure has caused widespread, secondary body panel collapse, including deep spiderweb fractures tearing through the upper fiberglass radius wall paneling, vertical trim moldings violently warping and splitting open, and the upper passenger-side roof cap seam ripping completely open. The failed componen…

Look up ODI 11756974 at NHTSA ↗

THE ELECTRIC BRAKE WIRING THAT CONNECTS THE COACH BODY TO THE FRONT AXLE WAS RUBBING ON THE INSIDE SIDEWALL OF THE LF TIRE OF THE TRAILER. IT HAS RUBBED A POLISHED GROOVE IN THE SIDEWALL OF THE TIRE. THE WIRING CONNECTING THE REAR AXLE TO THE COACH WAS RUBBING ON THE INTERIOR SURFACE OF THE LR WHEEL. I SECURED THE WIRING AWAY FROM THE TIRE AND WHEEL AND RETURNED THE FIFTH WHEEL TO THE DEALER WHERE I PURCHASED IT. KEYSTONE RV'S ATTITUDE SURPRISES ME, THEY CLAIM THAT THE WIRE COULDN'T HAVE BEEN RUBBING ON THE TIRE AND WHEEL, BECAUSE THE WIRE …

Look up ODI 10474175 at NHTSA ↗

WE OWN A 2013 KEYSTONE COUGAR 5TH WHEEL MODEL 331MKS. ON 4/4/14 WE WERE AT A CAMPGROUND AND STARTED TO SET UP. THE RIG WAS ONLY ON 12V BATTERY POWER. I HAD NOT YET CONNECTED TO SHORE POWER. WHEN I PUSHED THE BUTTON TO LOWER THE LANDING GEAR, NOTHING HAPPENED. I TRIED THE REMOTE CONTROL, AND NOTHING HAPPENED AGAIN. I WENT TO GET THE POWER CORD INTENDING TO PLUG IT IN. THE CORD WAS IN THE STORAGE AREA IN THE FRONT, UNDER THE HITCH, WHERE THE BATTERY IS. WHEN I OPENED THE DOOR, IMMEDIATELY SMOKE WAS BILLOWING OUT. THEN I SAW THE FLAME. IT WAS COMI…

Look up ODI 10577632 at NHTSA ↗

THE ELECTRIC BRAKES HAVE A VERY FLIMSY CONNECTION BEHIND EACH BRAKE PLATE. A VERY SMALL WIRE IS EXPOSED TO THE ELEMENTS. IN OUR CASE, SOMETHING BROKE THE WIRE AND THE BRAKES FAILED. KEYSTONE HAD THEIR DEALER REPAIR THE WIRE TO ITS ORIGINAL FLIMSY STATE. A FEW MONTHS AGO THE TRAILER BRAKES WERE IRRATIC (UNRELIABLE). I TOOK THE TRAILER TO REPAIR FACILITY. IN SEARCHING FOR THE PROBLEM, THEY DISCOVERED THAT THE RUBBER GASKET ON ALL FOUR INNER GREASE SEALS WERE SEVERELY DAMAGED BECAUSE THEY WERE UNDERSIZED. IF THE GREASE ISN'T CONTAINED IN…

Look up ODI 10885443 at NHTSA ↗

FROM THE TIME I LEFT THE DEALER LOT, I NEVER HAD BRAKES THAT WORKED PROPERLY. INCREASING THE OUTPUT FROM THE BRAKE CONTROLLER DIDN'T HELP. THE BRAKES WOULD OVER HEAT AND NEVER FELT THAT I HAD ENOUGH BRAKE TO STOP THE TRAILER/TRUCK. HAD THE BRAKES CHECKED BY SEVERAL RV DEALERS WHICH LED TO AN ADJUST ONLY. RECENT TRIP CAUSED "HOT" BRAKES/WHEELS AND BRAKE SMELL. WENT TO A FACILITY THAT SPECIALIZES IN RV REPAIR AND TOLD THEM TO TEAR THE SYSTEM APART AND FIX THE PROBLEM. THEY FOUND NOT ENOUGH VOLTAGE AT BRAKES. FURTHER INVESTIGATION FOUND EXCESS…

Look up ODI 11022172 at NHTSA ↗

I PURCHASED A NEW TRAVEL TRAILER MANUFACTURED BY KEYSTONE IN MAY OF 2015. I TOOK IT BACK TO THE DEALER AFTER MY FIRST TRIP WHEN I REALIZED THE BRAKES BARELY FUNCTIONED. AFTER 4 MONTHS OF TRYING TO GET THE MANUFACTURE TO ACKNOWLEDGE THE BRAKES DID NOT WORK FROM THE FACTORY KEYSTONE STATED THAT THEY FELT THE BRAKES FUNCTIONED PROPERLY. THE DEALER, RCD SALES AGREED WITH ME THAT THE BRAKES DID NOT WORK AND THEY HAD A SECOND 2016 TRAILER ON THEIR LOT WHICH THE BRAKES DID NOT FUNCTION EITHER AND THEY WERE SCARED TO SALE IT. I REVIEWED THE BRAKES MYSE…

Look up ODI 10747990 at NHTSA ↗

BATTERIES ARE NOT STORED PROPERLY NO BATTERY BOXES OR IMPROPER STRAP DOWNS

Look up ODI 11057118 at NHTSA ↗

MY 2018 KEYSTONE COUGAR HAS HAD A ELECTRICAL SHORT IN THE BEDROOM SLIDE. WHAT HAS BEEN OF REAL CONCERN IS THAT THE WIRES GOING THROUGH THE TRAILER INTO THE SLIDE WAS INCORRECTLY INSTALLED AT THE FACTORY. THE PLASTIC PROTECTIVE GROMMET BETWEEN THE WIRES GOING FROM THE TRAILER TO THE SLIDE WAS LEFT UNSECURED AND ALLOWED THE WIRES TO RUB INTO (AGAINST THE TRAILER FRAME)...UNTIL A SHORT OCCURRED. THE REALLY BAD THING WAS THAT THE FUSE IN THE PANEL DID NOT BLOW DEPENDING ON THE POSITION OF THE SLIDE GOING IN AND OUT. IT ALLOWED THE SPRING (HOLDI…

Look up ODI 11221294 at NHTSA ↗

The contact owns a 2020 Keystone Cougar. The contact stated while the RV was stationary, the rear motor turned on independently and fractured the gears. The contact took the RV to an independent mechanic, where it was diagnosed with needing the gearbox to be replaced. The RV was not repaired but was pending repairs. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 19V689000 (Electrical System) however, the VIN was not included. A dealer was not contacted. The contact attempted to reach the manufacturer by email…

Look up ODI 11430579 at NHTSA ↗

THE ELECTRIC BRAKE WIRING THAT CONNECTS THE COACH BODY TO THE FRONT AXLE WAS RUBBING ON THE INSIDE SIDEWALL OF THE LF TIRE OF THE TRAILER. IT HAS RUBBED A POLISHED GROOVE IN THE SIDEWALL OF THE TIRE. THE WIRING CONNECTING THE REAR AXLE TO THE COACH WAS RUBBING ON THE INTERIOR SURFACE OF THE LR WHEEL. I SECURED THE WIRING AWAY FROM THE TIRE AND WHEEL AND RETURNED THE FIFTH WHEEL TO THE DEALER WHERE I PURCHASED IT. KEYSTONE RV'S ATTITUDE SURPRISES ME, THEY CLAIM THAT THE WIRE COULDN'T HAVE BEEN RUBBING ON THE TIRE AND WHEEL, BECAUSE THE WIRE …

Look up ODI 10474175 at NHTSA ↗

WHILE TRAVELING ON OUR FAMILY VACATION, WITH OUR 2013 KEYSTONE COUGAR 5TH WHEEL. WE EXPERIENCED 2 TIRE BLOWOUTS. WHILE TRAVELING N ON I-59 (JUST INSIDE GA STATE LINE) AT APPROX. 60 MPH, THE RIGHT REAR TIRE EXPLODED CAUSING DAMAGE TO THE CAMPER. PUT SPARE ON AND CONTINUED ON OUR TRIP. ONCE WE ARRIVED AT CAMPGROUND THE EXPLODED TIRE WAS TAKEN TO A TIRE STORE AND REPLACED. NEW TIRE WAS PUT ON CAMPER AND THE SPARE RETURNED TO THE SPARE POSITION ON THE REAR OF THE CAMPER. UPON OUR RETURN TRIP HOME, TRAVELING ON I-75 S, WE HAD BLOWOUT #2. IT WAS THE …

Look up ODI 10872829 at NHTSA ↗

ONLY EVENT SO FAR, A PROPERLY INFLATED TIRE HAD THE TREAD COME OFF THE CASING AT ABOUT 7000 MILES AT 60 MPH. I REPLACED THE OEM LOAD RANGE 'D' TIRES WITH LOAD RANGE 'E' TIRES.THESE OEM TIRES AT 2540# GIVE A SCANT 160# SAFETY MARGIN. IN JULY WHILE DOING MAINTENANCE FOR A 1500 MILE TRIP I READ THE AXLE TAGS SO I COULD OBTAIN THE CORRECT SEALS FOR THE HUB BEARINGS. THE AXLES ARE RATED 4400# EACH TIMES 2 IS 8800#. THE GVW RATING FOR THE TRAILER IS 10,000#. SO IF THIS 5TH WHEEL IS TRAVELING FULLY LOADED IT IS 1200# OVER THE CAPACITY OF THE INST…

Look up ODI 11289033 at NHTSA ↗

TL* THE CONTACT OWNS A 2016 KEYSTONE COUGAR. WHILE DRIVING APPROXIMATELY 63 MPH, THE REAR DRIVER SIDE WHEEL FRACTURED WITHOUT WARNING. DUE TO THE FAILURE, THE FRONT PASSENGER SIDE TIRE FLATTENED. THE VEHICLE WAS TOWED AND HAD TO BE DRIVEN LESS THAN 20 MPH. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP FOR INSPECTION. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.

Look up ODI 10906328 at NHTSA ↗

WE HAVE TWO ISSUES WITH THE FIFTH WHEEL CAMPER IN QUESTION. WE ONLY FELT IT NECCESARY TO CONTACT THE NHTSA BECAUSE THE MANUFACTURER REFUSED TO REMEDY THE OBVIOUS PROBLEM WHEN WE WERE AT AN AUTHORIZED SERVICE CENTER AND ASKED THEM TO IN THE INTEREST OF OUR SAFETY AND THAT OF OTHER MOTORISTS. THE FIFTH WHEEL CAME WITH THE WRONG SIZE WHEEL AND TIRE WITH THREE BEING LARGER TIRES ON 16' RIMS AND ONE BEING A SMALLER TIRE ON A 15' RIM. IT CAUSED THE UNIT WHICH IS A 40' LONG FIFTH WHEEL. A NEW UNIT FROM THE DEALER. WHEN WE REALIZED WHAT WAS GOING ON WE…

Look up ODI 11033482 at NHTSA ↗

COMPANY DEFECT TANDEM AXLES ARE NOT PARALLEL WITH ONE ANOTHER BY 1.5" THIS MAKES A BIG SAFETY ISSUE FOR MY FAMILY AND EVERY ONE ON THE ROADS! COMPANY REFUSES TO FIX THE ISSUE THEY SAID ITS WITHIN SPECS. THE CAMPER PULLS LEFT ALL THE TIME WHEN TOWING. THE FRONT TANDEM AXLE IS TURNING LEFT BY 1.5"

Look up ODI 11376928 at NHTSA ↗

Driving my 2020 Keystone 1/2 Cougar to Camping World in NC when a noise made from camper, parts came from tire, and white smoke from camper to find driver side front axle tire had blown apart. Bought replacement tire while initial repairs completed. On return home, felt another jerk from camper, just thought normal tow jerk, and got home to find passenger side rear axle tire was completely gone and had rode home on the rim. Tire: Trailer King RST ST225/75R15

Look up ODI 11459442 at NHTSA ↗