2019 Newmar LONDON AIRE: complaints, problems and recalls

SIDEWALL SEPARATION FAILURE FOUND DURING A SAFETY CHECK

Owner-reported narrative. 11,621 miles reported. Look up ODI 11415690 at NHTSA ↗

For no reason started getting codes for low D.E.F and then buzzers and finally engine light for engine derate. Called Spartan, which is the chassis manufacture. Was told that the they were having a lot of problems with the DEF head and to leave it in a safe place because replacement parts were not available. Stated it could be 1 to 2 months before a part would be available. I was over 700 miles from home and not very happy about leaving a half million dollar motorhome in the middle of no where. So I drove it with lights and buzzers going of and…

Owner-reported narrative. Look up ODI 11425242 at NHTSA ↗

While staying at a campground in Creede, Colorado my motorhome displayed several fault codes relating to the emissions system. I immediately called Spartan (the chassis manufacturer) to report the faults and they explained my Def Head sensor had failed and that I should try to get to an authorized service center as ASAP. So the following morning I left Creede ( a remote location that is far away from any authorized service provider) in route to Fredrick, Colorado, the closest service provider. I made it to Littleton, Colorado, 25 miles south …

Owner-reported narrative. Look up ODI 11425360 at NHTSA ↗

The Back up camera and 360 camera fail frequently. The rear camera video will interminably go blank when backing. It will also sometimes change to the front view camera view which almost caused an accident in heavy freeway traffic because I thought I lost my trailer. I have had to replace 3 camera in 3 years and both Newmar and the camera manufacture Riverpark/Xicte have no solutions. Now the latest is to start replacing cables. The is a well known problem among RV owners.

Owner-reported narrative. Look up ODI 11541209 at NHTSA ↗

There was previously a recall on the power distribution modules on these Chassis the recall was insufficient, and these PMs continue to fail. This is a very much a safety hazard as the PDM controls lights as well as the electric fan clutch, which can cause the engine to overheat leaving you stranded on the road also it can cause lights to fail and the operator does not know they have failed. The issue tends to be intermittent in nature and very difficult to diagnose. I have contacted freightliner directly about this issue and they were of no he…

Owner-reported narrative. Look up ODI 11728067 at NHTSA ↗

Reported: 2018-06-08 (June 8, 2018)

Newmar Corporation (Newmar) is recalling certain 2018-2019 Newmar Mountain Aire, London Aire, Essex, and King Aire motorhomes. These vehicles are equipped with windshield wipers that may have an incorrect bend, possibly preventing the wiper arms from properly contacting the windshield. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 104, "Windshield Wiping and Washing Systems."

Consequence: If the windshield wipers do not properly contact the windshield, the driver's visibility may be reduced, increasing the risk of a crash.

Remedy: Newmar will notify owners, and dealers will replace the wiper arms, free of charge. The recall began on August 3, 2018. Owners may contact Newmar customer service at 1-800-731-8300.

Reported: 2018-08-06 (August 6, 2018)

Newmar Corporation (Newmar) is recalling certain 2018-2019 Newmar Ventana LE, Mountain Aire, Essex, Ventana, Dutch Star, New Aire, London Aire and King Aire motorhomes. The affected vehicles have entry doors that have latch rods that may be improperly adjusted, allowing the door to open during transit.

Consequence: If the door opens during transit, it can increase the risk of injury or a crash.

Remedy: Newmar will notify owners, and dealers will readjust the door latch rod, free of charge. The recall began September 5, 2018. Owners may contact Newmar customer service at 1-800-731-8300.

Reported: 2018-12-04 (December 4, 2018)

Newmar Corporation (Newmar) is recalling certain 2018-2019 Newmar Essex, Ventana LE, Ventana, London Aire, and Mountain Aire vehicles. The brake caliper mounting bolts may not have been sufficiently tightened.

Consequence: Loose brake caliper mounting bolts can reduce brake effectiveness, increasing the risk of a crash.

Remedy: Newmar has notified owners, and Daimler Trucks North America dealers will inspect and tighten the brake caliper mounting bolts, free of charge. The recall began January 10, 2019. Owners may contact Newmar customer service at 1-800-731-8300. Newmar's number for this recall is 18V-703.

Reported: 2019-05-20 (May 20, 2019)

Newmar Corporation (Newmar) is recalling certain 2019 Essex, King Aire, London Aire, Mountain Aire, and 2020 Dutch Star motorhomes. The brake relay valve may have an air flow restriction due to a partially blocked orifice, which may lead to extended stopping distance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Consequence: An increase in stopping distance without warning increases the risk of crash.

Remedy: Newmar will notify owners, and Spartan dealers will inspect and replace the brake relay valve, if necessary, free of charge. The recall began June 20, 2019. Owners may contact Newmar customer service at 1-800-731-8300 or Spartan customer service at 1-800-543-5008. Newmar's number for this recall is 19012.

Reported: 2019-06-07 (June 7, 2019)

Newmar Corporation (Newmar) is recalling certain 2016-2019 Ventana LE and 2017-2019 Dutch Star, Essex, London Aire, Mountain Aire and Ventana, and 2018-2019 New Aire motorhomes built on a Daimler trucks chassis. The rear mounted Power Distribution Module (PDM) may have been damaged during manufacturing, possibly resulting in the rear marker lights, brake lights, or turn signals not functioning.

Consequence: Nonfunctioning lights can increase the risk of a crash.

Remedy: Newmar will notify owners, and Daimler Trucks dealers will inspect and replace the rear PDM, as necessary, free of charge. The recall began July 18, 2019. Owners may contact Newmar customer service at 1-800-731-8300. Newmar's number for this recall is 18V-852.

Reported: 2020-03-20 (March 20, 2020)

Newmar Corporation (Newmar) is recalling certain 2019-2020 Essex and London Aire, 2019 Mountain Aire, Ventana LE and Ventana and 2020 Kountry Star motorhomes built on DTNA chassis. The brake caliper mounting bolts may have been insufficiently tightened.

Consequence: Loose brake caliper mounting bolts can reduce brake effectiveness, increasing the risk of a crash.

Remedy: Newmar will notify owners, and DTNA dealers will inspect and repair the vehicles, free of charge. The recall began May 6, 2020. Owners may contact DTNA customer service at 1-800-547-0712 or Newmar customer service at 1-800-731-8300. Newmar's number for this recall is 20V-127.

Reported: 2020-07-21 (July 21, 2020)

Newmar Corporaton (Newmar) is recalling certain 2016-2019 Ventana LE, 2017-2020 Ventana, London Aire, Essex and Dutch Star, 2017-2019 Mountain Aire, 2018-2020 New Aire, and 2020 Kountry Star motorhomes that received the 'inspection-only' remedy from recall 19V-426. The rear mounted Power Distribution Module (PDM) may have been damaged during manufacturing, possibly resulting in the rear marker lights, brake lights, or turn signals not functioning.

Consequence: Non-functioning exterior marker lights can increase the risk of a crash.

Remedy: Newmar will notify owners, and Daimler Trucks North America dealers will replace the PDM, free of charge. This recall began September 11, 2020. Owners may contact Newmar's customer service at 1-800-731-8300. Newmar's number for this recall is 20V-404.

Reported: 2020-08-27 (August 27, 2020)

Newmar Corporation (Newmar) is recalling certain 2018-2019 Essex and New Aire, 2019 Dutch Star, London Aire, Mountain Aire, and Ventana motorhomes. The instrument panel brightness cannot be adjusted, possibly causing glare when driving at night. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

Consequence: Glare can reduce the driver's visibility of the road, increasing the risk of a crash.

Remedy: Newmar will notify owner, and dealers will update the software and processor, as necessary, free of charge. The recall began October 21, 2020. Owners may contact Newmar customer service at 1-800-731-8300.

Reported: 2021-07-27 (July 27, 2021)

Newmar Corporation (Newmar) is recalling certain 2019-2021 Bay Star, Ventana, New Aire, 2019-2020 Canyon Star, Bay Star Sport, Essex, King Aire, London Aire, Mountain Aire, 2018-2021 Dutch Star, 2020 Kountry Star, and 2019 Ventana LE recreational vehicles. The adhesive that bonds the vented portion of the window may fail.

Consequence: Adhesive failure may cause the vent portion of the window to detach, increasing the risk of a crash or injury.

Remedy: Dealers will inspect the windows, and replace the vent if necessary, free of charge. Owner notification letters were mailed on September 10, 2021. Owners may contact Newmar customer service at 1-800-731-8300. Newmar's number for this recall is 21E 047.

Reported: 2021-09-09 (September 9, 2021)

Newmar Corporation (Newmar) is recalling certain 2019-2021 London Aire, Dutch Star, Essex, King Aire, Mountain Aire, 2020-2021 Ventana, and 2021 New Aire recreational vehicles. The instrument cluster may intermittently go blank while the vehicle is in motion.

Consequence: A blank instrument cluster display may be missing critical information such as the vehicle's speed and warning lights, which can increase the risk of a crash.

Remedy: Dealers will update the control module software, and reroute and secure the ductwork, free of charge. Owner notification letters were mailed on November 8, 2021. Owners may contact Newmar's customer service at 1-800-731-8300.

Reported: 2022-04-11 (April 11, 2022)

Newmar Corporation (Newmar) is recalling certain 2019-2022 Bay Star, Bay Star Sport, Ventana, Dutch Star, New Aire, Canyon Star, 2019 Ventana LE, 2020-2022 Kountry Star, 2019-2020 Mountain Aire, London Aire, Essex, and 2021 Super Star vehicles. The wiring under the seats may be incorrectly secured, which can lead to a pinched wire in the seat adjustment mechanism and cause an electrical short circuit.

Consequence: A short circuit increases the risk of a fire.

Remedy: Dealers will inspect and secure the wiring, adding circuit breaker and fuse protection as necessary, free of charge. Owner notification letters are expected to be mailed on June 10, 2022. Owners may contact Newmar's customer service at 1-800-731-8300.