2018 Thor PALAZZO: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
0 owner complaints analyzed
3 distinct recall campaigns
Not available median reported failure mileage
Scope: 2018 model year. Data updated: . 0 complaints include usable failure mileage. View data status.
Most common problems
No owner complaints are recorded for this selection. A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
No usable records for this chart.
| Category | Count |
|---|
No records.
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 0 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
No usable records for this chart.
| Category | Count |
|---|
No records.
Pattern summary
There is not enough complaint evidence to summarize patterns.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Recall history
3 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
17V634000 · Equipment:Other:Labels
Reported: 2017-10-09 (October 9, 2017)
Thor Motor Coach (TMC) is recalling certain 2017-2018 Challenger, Axis, Chateau, Four Winds, Hurricane, Miramar, Palazzo, Tuscany, Vegas, Venetian, and Windsport motorhomes. The cargo carrying capacity (CCC) label on these vehicles may indicate an incorrect water capacity for the water heater/fresh water tank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Tires and Rims for Motor vehicles over 10,000lbs."
Consequence: If the water capacity information is incorrect and it causes the vehicle to be over loaded, there would be an increased risk of a crash.
Remedy: TMC will notify owners and send them corrected labels, free of charge. The recall began on November 15, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000147.
NHTSA campaign record ↗17V758000 · Equipment
Reported: 2017-11-22 (November 22, 2017)
Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.
NHTSA campaign record ↗18V763000 · Exterior Lighting:Turn Signal | Exterior Lighting:Brake Lights | Electrical System
Reported: 2018-10-30 (October 30, 2018)
Thor Motor Coach (TMC) is recalling certain 2017 Tuscany XTE and 2017-2019 Venetian, Aria, Tuscany, and Palazzo motorhomes built on Freightliner Custom Chassis Corporation chassis. The Power Distribution Module (PDM) may have been damaged during manufacturing, possibly resulting in the rear marker lights, brake lights, or turn signals not functioning.
Consequence: Nonfunctioning lights can increase the risk of a crash.
Remedy: The remedy for this recall is still under development. Daimler Trucks North America, the manufacturer of the chassis began issuing owners an interim notification on October 24, 2018, and will send a second notification when parts become available. The recall began October 30, 2018. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000163.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
0 unique complaints in this selection. Analysis snapshot: 2026-09-30.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 2015 | 2016 | 2017 | 2018 | 2019 |
|---|---|---|---|---|---|
| Structure:Body | 00.0%No examples available for this selection. | 240.0%ODI 11149573 · 10,000 miTHE WOOD FLOORS IN THE CARGO BAYS OF MY CLASS 'A' MOTORHOME WERE NOT SEALED DURING MANUFACTURING, WHICH ALLOWED WATER TO ENTER THE BAYS AND ROTTING THE WOOD FLOORS. THIS RESULTED IN A HAZARDOUS CONDITION WHILE THE VEHICLE IS IN MOTION WHERE ITEMS, IN THE BAYS, COULD FALL UNDER THE TIRES OR JEOPARDIZE THE SAFETY OF OTHER VEHICLES. THIS CONDITION HAS OCCURRED TWICE ON MY VEHICLE AND WAS REPAIRED ONCE BY THOR UNDER WARRANTY, BUT REOCCURRED LESS THAN SIX MONTHS LATER. | 150.0%ODI 11110475 · 10,000 miLOCKING MECHANISM ON ENTRY DOOR STUCK IN LOCKED POSITION. I HAD TO GO TO DEALER AND HAVE SERVICE DEPARTMENT OPEN THE DOOR. PASSENGERS MAY NOT BE ABLE TO EXIT IN AN EMERGENCY. VEHICLE WAS STATIONARY. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Unknown Or Other | 00.0%No examples available for this selection. | 240.0%ODI 10874059 · 6,500 miON APRIL 5, 2016, AS WE WERE DRIVING IN SOUTH CAROLINA, ON A DIVIDED HIGHWAY AT ABOUT 65 MPH, WHEN WITH NO WARNING, WITH NO WARNING, THE OVERHEAD CABINET DIRECTLY OVER OUR HEADS CAME CRASHING DOWN ON US. IT HIT ME ON THE HEAD AND SHOULDER, AND HIT MY HUSBAND, JEFF, ON HIS ARM AND HAND. JEFF MANAGED TO LOOK OUT THE SIDE WINDOW AND USE THE CENTER LANE MARKING TO MAKE SURE WE STAYED ON THE ROAD. HE THEN PUT HIS HEAD DOWN SO THAT HE COULD SEE WELL ENOUGH UNDERNEATH THE FALLEN CABINET TO GET US OFF ON THE SHOULDER OF THE ROAD. IF HE HADN'T BEEN… | 150.0%ODI 11185668 · 8,000 miWE PURCHASED A 2017 THOR PALAZZO 36.1 MOTOR HOME IN JAN 2017. SAW THAT A TRIM RING WAS PUT ON THE FLOOR OF THE REAR BATH. WE ASSUMED THIS WAS FOR ACCESS TO THE REAR DIESEL ENGINE. WE DISCOVERED THAT ALTHOUGH THE TRIM RING WAS SCREWED DOWN NO ACCESS TO THE DIESEL ENGINE WAS CUT OUT. WHEN WE CALLED THOR CUSTOMER SERVICE WE WERE TOLD THE THOR PALAZZO MODEL DID NOT HAVE SPECS FOR AN ENGINE ACCESS PANEL. WE ASKED THEN WHY A TRIM RING INSTALLED? THEY DID NOT HAVE AN ANSWER TO THIS. FAST FORWARD TO FALL 2018 WE HAD A SMALL COMPRESSOR LEAK IN THE EN… | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Engine | 150.0%ODI 109806512015 THOR MOTOR COACH. CONSUMER WRITES IN REGARDS TO NUMEROUS DEFECTS ON VEHICLE. *LD THE CONSUMER STATED THE BATTERY HAS BEEN REPLACED MULTIPLE TIMES FOR NOT HOLDING A CHARGE AND THE HOT WATER HEATER WOULD NOT HEAT THE WATER AFTER USE. THE RADIO AND THE DASH CAMERA WERE INOPERABLE. THE 12 VOLT PLUGS ON THE DASH WERE NOT WORKING. THE 7 WAY PLUG IN THE BACK OF THE CAMPER DROPPED OFF AND WAS REPAIRED. THE LIGHT INDICATORS FOR THE LEVELING JACK APPEARED TO BE MALFUNCTIONING WHEN SETTING UP THE COACH. THERE WAS WATER FOUND IN THE BATTERY COMPA… | 00.0%No examples available for this selection. | 150.0%ODI 11185668 · 8,000 miWE PURCHASED A 2017 THOR PALAZZO 36.1 MOTOR HOME IN JAN 2017. SAW THAT A TRIM RING WAS PUT ON THE FLOOR OF THE REAR BATH. WE ASSUMED THIS WAS FOR ACCESS TO THE REAR DIESEL ENGINE. WE DISCOVERED THAT ALTHOUGH THE TRIM RING WAS SCREWED DOWN NO ACCESS TO THE DIESEL ENGINE WAS CUT OUT. WHEN WE CALLED THOR CUSTOMER SERVICE WE WERE TOLD THE THOR PALAZZO MODEL DID NOT HAVE SPECS FOR AN ENGINE ACCESS PANEL. WE ASKED THEN WHY A TRIM RING INSTALLED? THEY DID NOT HAVE AN ANSWER TO THIS. FAST FORWARD TO FALL 2018 WE HAD A SMALL COMPRESSOR LEAK IN THE EN… | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Equipment | 150.0%ODI 109806512015 THOR MOTOR COACH. CONSUMER WRITES IN REGARDS TO NUMEROUS DEFECTS ON VEHICLE. *LD THE CONSUMER STATED THE BATTERY HAS BEEN REPLACED MULTIPLE TIMES FOR NOT HOLDING A CHARGE AND THE HOT WATER HEATER WOULD NOT HEAT THE WATER AFTER USE. THE RADIO AND THE DASH CAMERA WERE INOPERABLE. THE 12 VOLT PLUGS ON THE DASH WERE NOT WORKING. THE 7 WAY PLUG IN THE BACK OF THE CAMPER DROPPED OFF AND WAS REPAIRED. THE LIGHT INDICATORS FOR THE LEVELING JACK APPEARED TO BE MALFUNCTIONING WHEN SETTING UP THE COACH. THERE WAS WATER FOUND IN THE BATTERY COMPA… | 120.0%ODI 11311742 · 8,000 miWE ARE VERY CONCERNED THE WINDOWS ON OUR 2016 PALAZZO WITH ONLY 12000 MILES ON IT HAS WINDOWS THAT ARE SEPARATING. THEY STARTED SEPARATING AT 8000. WE HAVE 5 WINDOWS THAT ARE SEPARATING AND ALL OF THE SUDDEN ARE HANGING OFF THE MOTOR HOME. IT WOULD BE DEVASTATING IF THEY FELL OFF AND HIT ANOTHER MOTOR VEHICLE OR MOTORCYCLE. *DT*JB | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Visibility:Glass, Side/Rear | 150.0%ODI 11435577 · 45,000 miThe contact owns a 2015 Thor Palazzo. The contact stated while driving 60 MPH, the rear driver’s side window detached from the motorhome and hit the road. The contact stated that he continued driving to his destination. The motorhome was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was approximately 45,000. | 120.0%ODI 11311742 · 8,000 miWE ARE VERY CONCERNED THE WINDOWS ON OUR 2016 PALAZZO WITH ONLY 12000 MILES ON IT HAS WINDOWS THAT ARE SEPARATING. THEY STARTED SEPARATING AT 8000. WE HAVE 5 WINDOWS THAT ARE SEPARATING AND ALL OF THE SUDDEN ARE HANGING OFF THE MOTOR HOME. IT WOULD BE DEVASTATING IF THEY FELL OFF AND HIT ANOTHER MOTOR VEHICLE OR MOTORCYCLE. *DT*JB | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Electrical System | 150.0%ODI 109806512015 THOR MOTOR COACH. CONSUMER WRITES IN REGARDS TO NUMEROUS DEFECTS ON VEHICLE. *LD THE CONSUMER STATED THE BATTERY HAS BEEN REPLACED MULTIPLE TIMES FOR NOT HOLDING A CHARGE AND THE HOT WATER HEATER WOULD NOT HEAT THE WATER AFTER USE. THE RADIO AND THE DASH CAMERA WERE INOPERABLE. THE 12 VOLT PLUGS ON THE DASH WERE NOT WORKING. THE 7 WAY PLUG IN THE BACK OF THE CAMPER DROPPED OFF AND WAS REPAIRED. THE LIGHT INDICATORS FOR THE LEVELING JACK APPEARED TO BE MALFUNCTIONING WHEN SETTING UP THE COACH. THERE WAS WATER FOUND IN THE BATTERY COMPA… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Electrical System:12v/24v/48v Battery | 150.0%ODI 109806512015 THOR MOTOR COACH. CONSUMER WRITES IN REGARDS TO NUMEROUS DEFECTS ON VEHICLE. *LD THE CONSUMER STATED THE BATTERY HAS BEEN REPLACED MULTIPLE TIMES FOR NOT HOLDING A CHARGE AND THE HOT WATER HEATER WOULD NOT HEAT THE WATER AFTER USE. THE RADIO AND THE DASH CAMERA WERE INOPERABLE. THE 12 VOLT PLUGS ON THE DASH WERE NOT WORKING. THE 7 WAY PLUG IN THE BACK OF THE CAMPER DROPPED OFF AND WAS REPAIRED. THE LIGHT INDICATORS FOR THE LEVELING JACK APPEARED TO BE MALFUNCTIONING WHEN SETTING UP THE COACH. THERE WAS WATER FOUND IN THE BATTERY COMPA… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Equipment:Recreational Vehicle/Trailer:Lpg Systems:Water Heater | 150.0%ODI 109806512015 THOR MOTOR COACH. CONSUMER WRITES IN REGARDS TO NUMEROUS DEFECTS ON VEHICLE. *LD THE CONSUMER STATED THE BATTERY HAS BEEN REPLACED MULTIPLE TIMES FOR NOT HOLDING A CHARGE AND THE HOT WATER HEATER WOULD NOT HEAT THE WATER AFTER USE. THE RADIO AND THE DASH CAMERA WERE INOPERABLE. THE 12 VOLT PLUGS ON THE DASH WERE NOT WORKING. THE 7 WAY PLUG IN THE BACK OF THE CAMPER DROPPED OFF AND WAS REPAIRED. THE LIGHT INDICATORS FOR THE LEVELING JACK APPEARED TO BE MALFUNCTIONING WHEN SETTING UP THE COACH. THERE WAS WATER FOUND IN THE BATTERY COMPA… | 00.0%No examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| No usable records for this analysis. | ||||
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-10 | 0 | None | No examples available for this selection. |
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | None | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | None | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | None | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | None | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2018: 0 complaints · 2019: 1 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2018 | 0 | 0 | 0 |
| 2019 | 1 | 1 | 1 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2018 | 0 | 0 | 0 |
| 2019 | 1 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component |
|---|
| No usable records for this analysis. |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.