2023 Volvo S60: complaints, problems and recalls

THE ADAPTIVE CRUISE CONTROL IN MY VEHICLE HAS BEEN OCCASIONALLY MALFUNCTIONING (ABOUT 10-15 TIMES SINCE PURCHASING MY VEHICLE IN MAY) CAUSING IT TO APPLY THE PARKING BRAKE AT SPEEDS OF ABOUT 5 MPH. THIS CAUSES MY VEHICLE TO ABRUPTLY STOP WITHOUT THE BRAKE LIGHTS BEING ACTIVATED. I THEN HAVE TO DEPRESS THE BRAKE PEDAL AND RELEASE THE PARKING BRAKE. THEN MY CRUISE CONTROL IS INOPERATIVE UNTIL I RESTART THE VEHICLE. I WAS NEARLY REAR ENDED AFTER THE MOST RECENT OCCURRENCE. I'VE TAKEN MY VEHICLE TO THE NEAREST VOLVO REPAIR CENTER FOUR TIMES TO BE R…

Look up ODI 10466894 at NHTSA ↗

WHILE DRIVING THE CAR ELECTRONICS, SUCH AS THE DASHBOARD LIGHTS, AND RADIO STARTED TO FLICKER OFF AND ON REPEATEDLY AND THE ENGINE CUT OFF. I WAS UNABLE TO CONTROL THE STEERING AND THE CAR CAME TO A COMPLETE STOP. I WAITED A FEW MIN AND WAS ABLE TO START BACK THE CAR AND DRIVE IT. THIS INCIDENT HAS HAPPENED 2 TIMES IN A 6 MONTH PERIOD. THE CAR WAS RECENTLY SERVICED AT AROUND 38,000 MILES AT THE VOLVO DEALERSHIP. THE ISSUE STARTED TO OCCUR ABOUT A MONTH AFTER THE CAR WAS SERVICED.

Look up ODI 11025107 at NHTSA ↗

I PURCHASED THE CAR ON FRIDAY, OCTOBER 18, ON SATURDAY, OCTOBER 19, THE CAR WENT HAYWIRE, WINDSHIELD WIPERS WOULD TURN OFF, NO TURN SIGNALS, NO HEADLIGHTS, AND NO INSTRUMENT PANEL. TOTALLY UNSAFE. CONTACTED DEALER, AND HE SAID, "WOW, YOU'RE THE 2ND PERSON TODAY TO CALL WITH THESE ISSUES. WE THINK THERE MAY BE A RECALL, BUT YOU'LL HAVE TO TAKE IT TO THE GERMAN DEALERSHIP ON MONDAY." NO HELP, NO CONCERN FOR SAFETY, NOTHING! HAD THE VEHICLE TOWED IN ON MONDAY, AND GERMAN DEALERSHIP HAS TO ORDER THE SOFTWARE. MY CAR SITS, THE DEALERSHIP THAT…

Look up ODI 10548824 at NHTSA ↗

BY DEFAULT, THE AUTO STOP/START FUNCTION IS ENGAGED EVERY TIME YOU START THE 2015.5 VOVO S60. THE CAR HAS ABOUT 1,800 MILES AND WAS PICKED UP AT THE END OF AUGUST, 2015, LEASED AS NEW. MY WIFE WAS STOPPED AT A TRAFFIC LIGHT, ON A RELATIVELY FLAT ROAD. THE CAR TURNED OFF THE ENGINE USING THE AUTO-STOP/START. WHEN SHE TOOK HER FOOT OFF THE BRAKE AND PUT IT ON THE ACCELERATOR, THE CAR TURNED OFF COMPLETELY. THE DASH TURNED OFF. SHE HAD TO PUT ON HER HAZARD WARNING LIGHTS, PUT THE CAR INTO PARK AND PRESS THE STOP/START BUTTON TO START THE CAR. S…

Look up ODI 10789878 at NHTSA ↗

PURCHASED A BRAND NEW 2016 VOLVO S60 - THE CAR AT INCIDENT DATE HAD 200 MILES ON IT. WHILE DRIVING IN TRAFFIC ON A CALIFORNIA FREEWAY - THE CAR LOST ALL POWER, STEERING, LIGHTS, ETC WHILE IN THE NUMBER 4 OF 7 LANE FREEWAY AT NIGHT. THE CAR WAS BLACKED OUT, NO LIGHTS, NO POWER, NO ENGINE, STALLED WITHOUT POWER IN THE MIDDLE OF THE FREEWAY. - WE WERE ALMOST KILLED AS A RESULT OF THIS INCIDENT. THERE WERE NUMEROUS COLLISIONS THAT OCCURRED BEHIND AND AROUND US AS A RESULT OF THIS CAR BEING DEAD IN THE WATER IN THE MIDDLE OF THE FREEWAY AT NIGHT.…

Look up ODI 10811942 at NHTSA ↗

The check engine light appeared on my 2018 Volvo s60. After taking the car to 2 Independent mechanics and the dealer, it was diagnosed as an Engine Control Module (ECM) failure. My 2018 Volvo s60 has ONLY 44,200 miles. The dealer stated that they "haven't seen this failure in cars with such low mileage. Usually, cars have 125,000+ miles if/when the ECM fails". The dealer and an Independent mechanic both stated that the brakes, steering, starter, thermostat, etc., could fail at any time. This could put my family, and other families on the road, …

Look up ODI 11671445 at NHTSA ↗

PARKING BREAK CAN BECOME TEMPORARILY UNAVAILABLE AND WHEN THIS HAPPENS THE INFORMATION CENTER DOES NOT RELAY ANY OTHER INFORMATION WHEN THE AUTO IS RUNNING! GPS, TIRE PRESSURE, ETC LOW GAS, ETC INFORMATION IS VOIDED. THREE TIMES CAR HAD TO BE REPAIR, APPARENTLY WATER, COFFEE ETC CAN GET INTO THE SWITCH AS THE SWITCH IS LOCATED NEXT TO THE CUP HOLDERS BETWEEN THE SEATS. BAD LOCATION OR POOR DESIGN OF THE SWITCH? SERIOUS "BECAUSE RUNNING INFORMATION" IS VOIDED ON DASH!. FIRST REPAIR WAS FREE, SECOND TIME THE REPAIR WAS TO COST $500. THIRD TIM…

Look up ODI 11350197 at NHTSA ↗

MY 2020 S60 T5 R-DESIGN HAD 3 BROKEN SENSORS, A SAFETY RECALL, MALFUNCTIONING BRAKES WHICH CAUSED THE CAR TO VEER, AND MOST RECENTLY A LEAKING A/C HOSE. ALL PROBLEMS FROM THE FACTORY (OUT OF THIN AIR) WITHIN THE FIRST 12 MONTHS OF MY LEASE. AFTER NUMEROUS COMPLAINTS TO VOLVO CAR USA, I WAS OFFERED A GENERIC AND DISMISSIVE ANSWER THAT VOLVO 'IS NOT IN THE POSITION' TO OFFER A TRADE ASSIST OR ANY HELP. NO EXPLANATION TO A LOYAL VOLVO CUSTOMER. THEY'RE SIMPLY 'SORRY' THAT I HAD TO TAKE OFF WORK TO SERVICE THEIR CAR AND WAS TOLD TO UBER HOME (NO C…

Look up ODI 11394308 at NHTSA ↗

While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thorough…

Look up ODI 11418969 at NHTSA ↗

New 2022 Volvo S60 began shutting off while driving on highways and Interstates and in once within feet of railroad crossing. Also occurrences of car being unable to turn off even after several attempts. Problem arose 2/2022. In all instances traffic, including 18 wheelers, was approaching behind at highway and interstate speeds up to 70mph. Sometimes a warning lamp would appear saying vehicle is shut off/ powering down, or place vehicle in park vehicle shutting off. Other warning lamps would come on like parking assist currently not available…

Look up ODI 11473106 at NHTSA ↗

While driving on the interstate 5 in Seattle, WA this Volvo rental car from National had the Multi-media screen went blank. No tell-tales nor instrument readings. The 360 camera and reverse camera systems worked as not part of the Android system. The infotainment system encountered a problem with an Android System with data corrupt. Had to reset factory data reset. Given this is a non-compliance to FMVSS Controls and Displays per Standard 101, I feel obligated to report this concern for driver safety around compatability of the Android sys…

Look up ODI 11544210 at NHTSA ↗

ON THE APRIL 23, 2014, MY HUSBAND WAS DRIVING AND THE CAR SHOT OUT AT HIGH SPEED HE DIDN'T REALIZE WHAT HAPPENED. ON APRIL 24, 2014, I WAS IN MY DRIVEWAY IN PARK AS I PUT THE CAR IN DRIVE TO SLOWLY ENTER MY GARAGE THE CAR TOOK OFF AT HIGH SPEED TIRES SPUN LEFT TIRE MARKS ON MY PAVEMENT AND I HIT THE BRAKES IN GARAGE NOT TO HIT THE WALL AND LEFT MARKS THERE AS WELL. MY NEIGHBORS WERE RIGHT THERE WITNESSING THIS SCARY EXPERIENCE. I CALLED CORPORATE IMMEDIATELY THEY TOLD ME TO GET IT TO THE DEALER. I CALLED A TOW TRUCK AND THE TOW TRUCK DRIVER T…

Look up ODI 10585460 at NHTSA ↗

WHILE DRIVING THE CAR ELECTRONICS, SUCH AS THE DASHBOARD LIGHTS, AND RADIO STARTED TO FLICKER OFF AND ON REPEATEDLY AND THE ENGINE CUT OFF. I WAS UNABLE TO CONTROL THE STEERING AND THE CAR CAME TO A COMPLETE STOP. I WAITED A FEW MIN AND WAS ABLE TO START BACK THE CAR AND DRIVE IT. THIS INCIDENT HAS HAPPENED 2 TIMES IN A 6 MONTH PERIOD. THE CAR WAS RECENTLY SERVICED AT AROUND 38,000 MILES AT THE VOLVO DEALERSHIP. THE ISSUE STARTED TO OCCUR ABOUT A MONTH AFTER THE CAR WAS SERVICED.

Look up ODI 11025107 at NHTSA ↗

FRONT LEFT WHEEL CAME OFF WHEN PULLING INTO GARAGE ONLY HELD ON BY 1 AND 1/2 BOLTS. 4/13/2014 ENGINE STOPPED RUNNING WHILE PULLING INTO TRAFFIC CAR STALLED IN MIDDLE OF THE ROAD. 5/5/2014 DYNAMIC TRACTION CONTROL SYSTEM FAILED AND CAR BECAME UNCONTROLLABLY WOBBLY WHILE DRIVING. 5/5/2014 OTHER NUMEROUS FAILURES INCLUDE: BREAKDOWN OF THE COLLISION AVOIDANCE SYSTEM. CRUISE CONTROL DOES NOT WORK. FRONT CAMERA MALFUNCTION-TOOK IT IN TO GET FIXED STILL NOT WORKING CORRECTLY. AC BREAKS DOWN ? TOOK IT IN TO GET FIXED STILL HAS PRO…

Look up ODI 10586898 at NHTSA ↗

BY DEFAULT, THE AUTO STOP/START FUNCTION IS ENGAGED EVERY TIME YOU START THE 2015.5 VOVO S60. THE CAR HAS ABOUT 1,800 MILES AND WAS PICKED UP AT THE END OF AUGUST, 2015, LEASED AS NEW. MY WIFE WAS STOPPED AT A TRAFFIC LIGHT, ON A RELATIVELY FLAT ROAD. THE CAR TURNED OFF THE ENGINE USING THE AUTO-STOP/START. WHEN SHE TOOK HER FOOT OFF THE BRAKE AND PUT IT ON THE ACCELERATOR, THE CAR TURNED OFF COMPLETELY. THE DASH TURNED OFF. SHE HAD TO PUT ON HER HAZARD WARNING LIGHTS, PUT THE CAR INTO PARK AND PRESS THE STOP/START BUTTON TO START THE CAR. S…

Look up ODI 10789878 at NHTSA ↗

PURCHASED A BRAND NEW 2016 VOLVO S60 - THE CAR AT INCIDENT DATE HAD 200 MILES ON IT. WHILE DRIVING IN TRAFFIC ON A CALIFORNIA FREEWAY - THE CAR LOST ALL POWER, STEERING, LIGHTS, ETC WHILE IN THE NUMBER 4 OF 7 LANE FREEWAY AT NIGHT. THE CAR WAS BLACKED OUT, NO LIGHTS, NO POWER, NO ENGINE, STALLED WITHOUT POWER IN THE MIDDLE OF THE FREEWAY. - WE WERE ALMOST KILLED AS A RESULT OF THIS INCIDENT. THERE WERE NUMEROUS COLLISIONS THAT OCCURRED BEHIND AND AROUND US AS A RESULT OF THIS CAR BEING DEAD IN THE WATER IN THE MIDDLE OF THE FREEWAY AT NIGHT.…

Look up ODI 10811942 at NHTSA ↗

CHECK ENGINE LIGHT KEEPS GOING ON. BRING IT TO A BODY SHOP AND NOTHING CHANGED. CAR JUST SHUTS DOWN WHILE TRYING TO DRIVE IT.

Look up ODI 11351974 at NHTSA ↗

The check engine light appeared on my 2018 Volvo s60. After taking the car to 2 Independent mechanics and the dealer, it was diagnosed as an Engine Control Module (ECM) failure. My 2018 Volvo s60 has ONLY 44,200 miles. The dealer stated that they "haven't seen this failure in cars with such low mileage. Usually, cars have 125,000+ miles if/when the ECM fails". The dealer and an Independent mechanic both stated that the brakes, steering, starter, thermostat, etc., could fail at any time. This could put my family, and other families on the road, …

Look up ODI 11671445 at NHTSA ↗

Engine Auto turn off never works. Advertised as feature of the car. Yet to see if active.

Look up ODI 11435892 at NHTSA ↗

On two separate occasions in the past two months June 6 and Aug. 15, this vehicle experienced a severe unintended engine surge / unintended acceleration event while at a complete stop with my foot firmly on the brake. On both occasions, the engine RPMs spiked above 1,000 RPM, forcing the vehicle to pull heavily against the brakes as if trying to race forward into the intersection. On the most recent event (Aug. 15) when stopping at a red light it appeared that the supercharger kicked in, pulling against the brakes. Six or eight pedestrians wer…

Look up ODI 11758721 at NHTSA ↗

While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thorough…

Look up ODI 11418969 at NHTSA ↗

While reversing, the car came to a sudden abrupt halt and the check engine lamp and other warning lamps illuminated. The ignition was still active (the car was in hybrid mode, operating on battery for motive power only), I cycled the transmission to "D" and no forward movement occurred, also tried "R" and back to "D" with the same result - no movement. I cycled the ignition off and on, the engine started and the car could be moved. CEL still on. I scanned the car and found permanent DTC's U0111 (Lost Communication with Battery Energy Control Mo…

Look up ODI 11485063 at NHTSA ↗

I am submitting a formal vehicle safety complaint regarding a sudden and complete system failure in my Volvo S60 2023, which occurred in March 2026 in [XXX] . While traveling on [XXX] at highway speed, the vehicle abruptly and without warning lost all electrical power. The dashboard went completely blank, and all electronic systems ceased functioning. Critically, the steering became unresponsive/locked at the same time, creating an immediate and severe safety hazard. I was fortunate to avoid a collision, but the incident had clear potential …

Look up ODI 11733466 at NHTSA ↗

THE ACTIVE CRUISE CONTROL STOPS FOR NO REASON. THIS PROBLEM IS INTERMITTENT. ON A NUMBER OF OCCASIONS (~20 TIMES SINCE I PICKED UP THE CAR), THE CAR SLOWS DOWN AS THE TRAFFICS SLOWS DOWN. THE CAR IS ALMOST AT A STOP (5-10 MPH) AND THE EMERGENCY BRAKES COMES ON, THE CARS BRAKES HARD & STOPS AND THE PARKING BRAKE TURNS ON. THE ALERT "CRUISE CONTROL UNAVAILABLE" SHOW IN THE DISPLAY. THEREAFTER THE CRUISE WILL NOT ENGAGE. AFTER I SHUT OFF THE CAR AND RESTART IT, THE CRUISE AGAIN WORKS AGAIN. IN ADDITION TO NOT PERFORMING AS ADVERTISED, THIS R…

Look up ODI 10454695 at NHTSA ↗

WHEN PRESSING THE ACCELERATOR TO ENTER TRAFFIC THERE WAS A VERY SIGNIFICANT HESITATION FOLLOWED BY A SUDDEN LURCH WHICH ALMOST LEAD TO A T-BONE ACCIDENT. THIS WAS THE THIRD TIME THIS HAS HAPPENED IN THE LAST TWO WEEKS. VOLVO FOUND A SERVICE BULLETIN FOR 6 CYLINDER ENGINE AND INSTALLED THE SOFTWARE UPGRADE. IT IS TOO EARLY TO TELL IF IT WORKED. *TR

Look up ODI 10512056 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 VOLVO S60 T6. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH WITH THE CRUISE CONTROL ACTIVATED, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING AS THE CONTACT RELEASED THE CRUISE CONTROL FUNCTION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT A NEW PROGRAM NEEDED TO BE DOWNLOADED INTO THE CENTRAL COMPUTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 500 AND THE CURRENT MILEAGE WAS 2,200.

Look up ODI 10574348 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 VOLVO S60. WHILE DRIVING 5 MPH PULLING INTO THE GARAGE, THE VEHICLE INDEPENDENTLY ACCELERATED TO 60 MPH. THE VEHICLE CRASHED INTO THE GARAGE AND THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

Look up ODI 10883087 at NHTSA ↗

AS FAR BACK AS 2011, THERE WERE COMPLAINTS THAT VOLVOS EQUIPPED WITH THE CITY SAFETY SYSTEM WOULD SUDDENLY STOP OR SLOW DOWN FOR NO REASON. THIS SAME SITUATION HAPPENED TO ME IN SEPTEMBER 2018. AS I WAS MAKING A LEFT TURN TO CROSS AN INTERSECTION, MY VOLVO S60 SUDDENLY CAME TO A HALT. THERE WAS NOTHING IN FRONT OF ME. I WAS NOT SURE WHAT HAD HAPPENED AS I HEARD A GRINDING NOISE. I PULLED THE CAR OVER AND AS I WAS ABOUT TO GET OUT OF THE CAR, I NOTICED A WARNING ON THE DASH THAT THE CITY SAFETY HAD GONE OFF. FOR SOME UNKNOWN REASON, MY VOLVO …

Look up ODI 11131716 at NHTSA ↗

I was pulling into a parking spot. When I went to accelerate, the car over-accelerated. The engine revved so high, I could not control it. I had nowhere to go and hit a cement wall, totalling my car. All the airbags went off. I did walk away, though. I researched this issue online and it seems there are many instances of this happening. No warnings whatsoever. No recalls at all.

Look up ODI 11768119 at NHTSA ↗

I was pulling into a parking spot in a strip mall parking lot. When I braked after turning into the parking spot, the brakes failed. The car moved forward and hit the Chevy Suburban parked in front of it and started to push it. The automatic collision avoidance system did not stop the car, either. The owner of the Suburban was in that vehicle and was able to put it in gear and move it out of the way. My car continued to move forward at the speed it had been going at when the brakes failed so apparently it was still accelerating. The car th…

Look up ODI 11759182 at NHTSA ↗

The contact owns a 2020 Volvo S60. The contact stated that while at a stop light, the vehicle erroneously drove forward and crashed into a second vehicle. The contact indicate that during the crash the collision avoidance feature did not activate. No injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer and local dealer were notified of the incident. The failure mileage was 16,000.

Look up ODI 11633726 at NHTSA ↗

See attached document for complaint.

Look up ODI 11688190 at NHTSA ↗

MY 2012 VOLVO S60 HAD SERIOUS ENGINE NOISE BROUGHT TO THE SHOP THEY THOUGHT IT MIGHT OF BEEN THE FACT THAT I HAD LOW OIL, BUT I HAD JUST GOTTEN MY OIL CHANGED 12/17/14 AND IT WAS 5/27/15 NOW AND I HAD NOT DRIVEN ANYWHERE CLOSE TO 6 THOUSAND MILES TO DEPLETE ALL THE OIL. THE SHOP TOLD ME TO REALLY FIGURE OUT WHAT WAS GOING ON THEY WOULD HAVE TO TAKE OUT THE ENGINE TO TAKE A LOOK AT WHAT WAS MAKING THE NOISE. THAT EVENING I GOT A CALL FROM THE SHOP AGAIN TELLING ME THAT THERE WAS A SERIOUS PROBLEM. THEY TOLD ME BECAUSE MY CAR WAS DANGEROUSLY LOW…

Look up ODI 10721909 at NHTSA ↗

1ST INCIDENT, DECEMBER 2012. ABOUT 760 MILES ON NEW CAR. QUARTER TANK OF FUEL. TRAVELING AT 65 MPH ON INTERSTATE, VEHICLE LOST POWER, AND HAD TO COAST TO A STOP AT SIDE OF ROAD. FORTUNATELY IN RURAL AREA WITH LOW TRAFFIC SO NO PROBLEMS. AFTER TOWING TO DEALER, NO PROBLEM IDENTIFIED... ECM-P008700 CODE REPORTED AS FUEL PRESSURE LOSS. SOFTWARE MENTIONED AS THE PROBLEM, ECM UPGRADE ACCOMPLISHED. 2ND INCIDENT, MARCH 2013. ABOUT 2350 MILES ON CAR, AGAIN QUARTER TANK OF FUEL. AGAIN ON INTERSTATE, VEHICLE ABRUPTLY LOST POWER AND HAD TO COAST T…

Look up ODI 10504529 at NHTSA ↗

THE LOW PRESSURE FUEL SENSOR ON THESE VEHICLES IS KNOWN BY MANUFACTURER TO FAIL. THIS FAILURE CAN CAUSE HARD START CONDITIONS, TAKING OVER 5 SECONDS AT TIMES TO START THE VEHICLE. THE MAIN DANGER OF THIS COMES FROM THE FACT THIS IS A VEHICLE EQUIPPED WITH AUTO STOP/START TECHNOLOGY. I HAVE EXPERIENCED NEAR MISSES DUE TO COMING TO A STOP AT A STOP SIGN AND THEN TAKING OVER 5 SECONDS ON OCCASION FOR THE VEHICLE TO RESTART THE ENGINE. ON VEHICLES WITH WORN FUEL PUMPS THIS ISSUE COULD MANIFEST AS LOSS OF POWER UNDER HEAVY ENGINE LOAD, SUCH AS C…

Look up ODI 11243196 at NHTSA ↗

PURCHASED A BRAND NEW 2016 VOLVO S60 - THE CAR AT INCIDENT DATE HAD 200 MILES ON IT. WHILE DRIVING IN TRAFFIC ON A CALIFORNIA FREEWAY - THE CAR LOST ALL POWER, STEERING, LIGHTS, ETC WHILE IN THE NUMBER 4 OF 7 LANE FREEWAY AT NIGHT. THE CAR WAS BLACKED OUT, NO LIGHTS, NO POWER, NO ENGINE, STALLED WITHOUT POWER IN THE MIDDLE OF THE FREEWAY. - WE WERE ALMOST KILLED AS A RESULT OF THIS INCIDENT. THERE WERE NUMEROUS COLLISIONS THAT OCCURRED BEHIND AND AROUND US AS A RESULT OF THIS CAR BEING DEAD IN THE WATER IN THE MIDDLE OF THE FREEWAY AT NIGHT.…

Look up ODI 10811942 at NHTSA ↗

This incident only occurs when placing the vehicle into drive after first having reversed. It happens intermittently. After reversing, the vehicle is stopped, place into B, which is drive with extra regenerative braking, and then the accelerator is press. The vehicle does not move. As the accelerator is pressed further, the transmission slams into gear and the vehicle launches with all the vigor of a vehicle that has the accelerator pressed to the floor. The vehicle was delivered to the dealer for diagnostics. There were not diagnostic code pre…

Look up ODI 11492820 at NHTSA ↗

I was at a stoplight with my foot on the brake. The car lurched forward, which prompted me to push harder on the brake. Then, with my foot firmly on the brake, the car accelerated into the car in front of me. There was body damage to the car. Volvo investigated and said that the computer indicated that the gas pedal was engaged at 90% while the brake was engaged at the same time. This would involve me putting my foot on the gas and brake at the same time, which simply is not what happened. There is clearly something wrong with their computer …

Look up ODI 11704987 at NHTSA ↗

I WAS DRIVING DOWN THE INTERSTATE, SUDDENLY I HEARD A LOUD BOOM. I COULD HEAR SOMETHING SLIDING DOWN MY ROOF AND OFF THE BACK OF THE CAR. I DIDN'T KNOW WHAT WAS GOING ON, THEN I HEARD A WIND NOISE ABOVE. I REALIZED THAT MY SUNROOF WAS BROKEN AND GLASS WAS CASCADING DOWN AND FLYING OFF OF MY CAR. IT JUST SPONTANEOUSLY EXPLODED. I PULLED OVER TO LOOK AT THE SUNROOF AND TO SEE IF THERE WAS A ROCK THAT HIT IT OR SOMETHING ELSE. THERE WAS NOTHING THERE EXCEPT FOR A SHATTERED SUNROOF WITH A HUGE HOLE. THE GLASS WAS POINTING UPWARD AS IF IT HAD EXPLOD…

Look up ODI 10809037 at NHTSA ↗

RIGHT FRONT TIRE 235/40/R18/95H DEFLATED WHEN IT HIT A POT HOLE ON LOW SPEED STREET ROAD. INNER SIDEWALL WAS DAMAGED AND TIRE NEED TO BE REPLACED. THIS IS THE FIRST INCIDENT.

Look up ODI 10920373 at NHTSA ↗

ECO FRIENDLY SOY BASED MATERIALS USED FOR WIRING ATTRACTS RODENTS AND RESULTS IN MODERATE TO SEVERE DAMAGE. HAD MY CAR "EATEN" BY SQUIRRELS TWICE IN 3 MONTHS, THE FIRST TIME THE DAMAGE WAS AROUND $300, THE SECOND $2500! I HAVE NO GUARANTEE THAT THIS WONT HAPPEN AGAIN, IN FACT IT LIKELY WILL BECAUSE THE WIRE CASING IS STILL SOY BASED!!!!

Look up ODI 11089768 at NHTSA ↗

I WAS IN STOP-AND-GO TRAFFIC ON A LEVEL SURFACE STREET. AFTER I CAME TO A STOP, THE STOP-START SYSTEM SHUT OFF THE ENGINE. WHEN I LET UP ON THE BRAKE SLIGHTLY, THE CAR STARTED TO ROLL FORWARD, BUT THE ENGINE DIDN'T START (IT NORMALLY DOES THIS). WHEN I LET UP LIGHTLY MORE AND QUICKLY USED THE ACCELERATOR, THE ENGINE FELT LIKE IT STALLED. ONCE STALLED, THE DASHBOARD SCREEN READ "PRESS START." PRESSING START DIDN'T DO ANYTHING OR PROVIDE ANY FEEDBACK, AND SUCCESSIVE ATTEMPTS DIDN'T HELP. AFTER NOT HITTING ANYTHING FOR A ~MINUTE, I FINALLY GOT FEE…

Look up ODI 10721712 at NHTSA ↗

DRIVING STRAIGHT DOWN A ROAD AND AT A SPEED OF AROUND 40 MPH, ALL WARNING LIGHTS FLASHED AND THE ENGINE SHUT DOWN. AFTER A DISTANCE, THE CAR CAME TO A STOP AND I ATTEMPTED TO RESTART IT. I SHIFTED THE CAR INTO PARK AND WAS FINALLY ABLE TO GET THE ENGINE TO RESTART.

Look up ODI 10820872 at NHTSA ↗

SPONTANEOUS EXPLOSION OF OVERHEAD SUNROOF WHILE DRIVING. CAR WAS PURCHASED NEW IN SEPTEMBER 2017 AND ONLY HAS 10,000 MILES OF IT. THE SUNROOF HAD NO SCRATCH, DENTS, OR CHIPS - DEFINITELY NO REASON TO SUGGEST THAT IT MAY LITERALLY EXPLODE OUTWARD OVER MY HEAD WHILE DRIVING DOWN THE INTERSTATE. AT THE TIME OF THE INCIDENT I WAS ACTUALLY ON THE PHONE WITH MY MOM AND THE EXPLOSION WAS SO LOUD THAT SHE THOUGHT I HAD WRECKED MY VEHICLE DOWN AN EMBANKMENT.

Look up ODI 11073999 at NHTSA ↗

My sunroof glass spontaneously shattered while I was driving on the highway on 10/9/2025. There was no apparent cause. It sounded like an explosion, and glass came down all over me and the seats. Very disturbing!

Look up ODI 11692719 at NHTSA ↗

WHILE DRIVING ON A SUNNY DAY I KEPT BEING BLINDED BY CHROME / MIRROR FINISH ELEMENTS SURROUNDING THE STEERING WHEEL. IT WASN'T HAPPENING ONLY FOR A MOMENT, MY EYES HURT AFTER DRIVING HOME FROM WORK. THAT IS VERY DISTRACTING AND AFFECTS DRIVER'S VISION! TO HIDE MY EYES FROM THE BLINDING LIGHT, I HAD TO MOVE THE STEERING WHEEL TO VERY UNCOMFORTABLE POSITION (WHAT STILL DIDN'T SOLVE THE PROBLEM) OR PRETTY MUCH COVER FLASHING SPOTS WITH MY HANDS. THAT CREATES A HAZARDOUS CONDITIONS EVERYTIME WHEN THE SUN IS OUT. I AM ATTACHING A PICTURE, BUT IT DO…

Look up ODI 11328659 at NHTSA ↗

I turned the car on and got an error message that said the turn indicator system failed. After trying to clear the message from the dash using the button on the steering wheel, I discovered that nothing on the steering wheel was working, including the windshield wipers or any buttons on the steering wheel. I called the manufacturer and they told me not to drive it and they towed it to the dealer. The dealer said they had see this before as either a software issue or electrical issue and would need to replace the stalks and buttons.

Look up ODI 11421793 at NHTSA ↗

Tire has a defect

Look up ODI 11676297 at NHTSA ↗

The indirect measurement TPMS system of this car has misdetected low tire pressure on three occasions. Most recently, on October 3 while driving on the freeway at about 70 MPH the TPMS alert illuminated. I checked the information screen and the display showed low pressure in all four tires. Because I have had misdetection of the right front tire twice before, and that it seemed very unlikely that all four tires would deflate at the same time, I disregarded the alert as a false detection. Later I checked the air pressure in all four tires and fo…

Look up ODI 11618880 at NHTSA ↗

While driving on a highway the car went from drive into neutral all by itself and I could not put it into drive. Managed to get to a break down lane and turned car off and on. It started normally in drive, but that only lasted for 30 seconds when it went back into neutral. I was close to my exit and this happened multiple times - was in drive and it went into neutral on its own! Very dangerous. Car was picked up by Volvo assist and towed away last night. Car is 7 months old car with 3800 miles on it. It was towed to the dealer where it w…

Look up ODI 11533862 at NHTSA ↗

The 360 view camera works wonderfully with sufficient light. In dark or dimly lit areas, the camera is totally dark and unusable. Parking in a dark parking lot or area is not possible using the camera. When I was trying to park between the parking lines in the rain in early morning I had to get out of the car to see if I was in the lines. I have taken the car back to the dealer and they state that there are no issues with the camera system. Many owners on Volvo forums state similar issues. I can provide pictures upon request.

Look up ODI 11552391 at NHTSA ↗

TL*THE CONTACT OWNS A 2012 VOLVO S60(NA). THE CONTACT STATED WHILE DRIVING 68 MPH THE VEHICLE SUDDENLY STALLED. SHE WAS ABLE TO COAST THE VEHICLE TO THE SHOULDER OF THE INTERSTATE. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE CONTACT PLANNED TO HAVE THE VEHICLE TOWED TO AN AUTHORIZED DEALER. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 906.

Look up ODI 10399515 at NHTSA ↗

The contact owns a 2012 Volvo S60. The contact stated that while driving at an undisclosed speed, she smelled a burning odor in the interior of the vehicle, after which the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. After a visual inspection of the engine compartment, the contact became aware that the engine was without oil; however, the low oil warning light was not illuminated. The check engine warning light was illuminated. The vehicle was not ta…

Look up ODI 11570537 at NHTSA ↗

The contact owns a 2013 Volvo S60. The contact stated that the vehicle failed to warn of low oil pressure. The contact stated he would become aware that the engine oil pressure was low when the vehicle stalled or while servicing the vehicle. The contact was concerned for his safety and for the potential engine damage that could occur. The contact related the failure NHTSA Campaign Number: 13V592000 (Engine and Engine Cooling). Additionally, the contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that h…

Look up ODI 11503852 at NHTSA ↗

The contact owns a 2015 Volvo S60. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and had flashed off and on while driving at highway speeds. The contact stated that the vehicle also stalled on several occasions. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the engine cylinders were faulty, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was of…

Look up ODI 11663339 at NHTSA ↗

The contact owns a 2022 Volvo S60. The contact stated while driving 40 MPH, the vehicle lost motive power. The contact stated that “Critical Safety Fault Battery - Stop and Service immediately” message was displayed. The contact was able to make it to work and had the vehicle towed to the dealer. The dealer diagnosed the vehicle and stated that the vehicle had experienced the failure listed in NHTSA Campaign Number: 22V793000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was repaired. The manufacturer…

Look up ODI 11501021 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND OPERATED AS DESIGNED. THE VEHICLE WAS TAKEN TO THE VOLVO STORE LOCATED AT 1051 WEST WEBSTER AVE, WINTER PARK, FL 32789, BUT WAS NOT DIAGNOSED NOR REPAIRED. THE NHTSA CAMPAIGN NUMBER: 11V303000 (FUEL SYSTEM, GASOLINE) WAS REFERENCED HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 79,000.

Look up ODI 11340317 at NHTSA ↗

The contact owns a 2024 Volvo S60. The contact stated while driving approximately 45 MPH, a message stating that the propulsion system was reduced was displayed, and the vehicle came to a complete stop in the middle of the road, nearly causing a crash. Additionally, the steering wheel seized, the gear shift indicator light turned off, and the four wheels seized while the engine continued to run. A Police Officer arrived at the scene and directed traffic to prevent a crash. The vehicle was towed to the nearest dealer, where it was diagnosed wit…

Look up ODI 11631582 at NHTSA ↗

ON AUGUST 24, 2013, I WAS INVOLVED IN A CAR ACCIDENT. A CAR STOPPED SHORT ON THE HIGHWAY. THE CAR IN FRONT OF ME HIT THAT CAR. I THEN HIT THE CAR IN FRONT OF ME. I HAD ONLY A FEW SECONDS TO REACT. ANOTHER CAR THEN RE-ENDED ME. MY AIRBAG NOR SEATBELT PRETENTIONERS DEPLOYED. I HAD DIFFICULTY TURNING THE CAR OFF. THE CAR WAS TOTALED. WITHIN A FEW WEEKS OF THE INCIDENT, I REPORTED THE MATTER TO VOLVO. THEY SENT AN INVESTIGATOR OUT. VOLVO CLAIMS THAT SENSORS WERE NOT ACTIVATED SINCE THE DAMAGE WAS ABOVE THEM, AND THERE WAS NOT ANY PROBLEM. HOWEVER, …

Look up ODI 10560896 at NHTSA ↗

VEHICLE INVOLVED DAMAGE FRONT AND LEFT FRONTAL AREA. SPEED 40-45 MPH. NO FRONTAL OR SIDE CURTAIN AIR BAG AND CURTAIN DEPLOYMENT. FAILURE OF COLLISION WARNING SYSTEM AND ELECTRONICAL INDICATORS, ABS DID NOT DEPLOY. *TR

Look up ODI 10503753 at NHTSA ↗

While I was making a left turn in ice my car bumped into a curb and the side airbags deployed randomly. There is zero damage to the side of the car. Immediately the car turned off and the hazards tripped as well. Currently the car runs perfectly smooth and has no problems turning on or off.

Look up ODI 11445725 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 VOLVO S60. WHILE DRIVING 5 MPH PULLING INTO THE GARAGE, THE VEHICLE INDEPENDENTLY ACCELERATED TO 60 MPH. THE VEHICLE CRASHED INTO THE GARAGE AND THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

Look up ODI 10883087 at NHTSA ↗

After taking vehicle in for a service SRS airbag light and getting it fixed under warranty the same light has come back on.

Look up ODI 11514981 at NHTSA ↗

I purchased a vehicle from a dealership that was aware of faulty airbags that was returned to dealership from another consumer. I discovered the issue a few months later when airbag warning light appeared and had it repaired which included steering wheel airbag, lower knee airbag and the seat belt in September. I did know it was involved in a accident prior to purchase since carfax states airbags did not deploy. A reporter approached me in September to inform me that my vehicle was involved in a story of said dealership selling cars with faulty…

Look up ODI 11623092 at NHTSA ↗

When my son got a car last December, we bought him a 2024 Volvo s60, primarily for the safety features. Since we have had the vehicle, Volvo has had a lot of issues with their infotainment system. He has contacted them many times and I had started to keep a record of how often it would glitch. If it was just music not working, no big deal. But sometimes it was the backup camera too and once the heat. He recently had a car accident. He is okay (of course shaken up) but it was a bad situation. A van had dropped a lot of items. Plumbing and metal …

Look up ODI 11701707 at NHTSA ↗